natural biochemicals
description
Transcript of natural biochemicals
-
Odette Varela MillaWu-Jang Huang PhD.
National Pingtung University of Science and TechnologyPingtung, Taiwan.
-
Contents: Objectives Introduction Characteristics of carbonized rice residues Biochar preparation and characterization Scanning electron microscopy analysis Water spinach Worm avoidance test Soil Application of rice husk biochar and wood
biochar to soil Results
2
-
Objectives:
Realize an investigation of the short-term effects
related to slow pyrolysis biochar effects in plant
growth.
Furthermore it is planned to determine biochar
characteristics such as biodegradability, porosity and
cation exchange capacity, produced from agricultural
waste.
3
-
Organic waste as feedstock for biochar production
Many different materials have been proposed as biomassfeedstocks for biochar, including wood, grain husks, nutshells, manure and crop residues, (Lua et al., 2004, Martinez etal., 2006, Gonzalz et al., 2009).
4
-
The use of rice straw and rice husk has been practiced for a longtime (Ponamperuma, 1982; Eagle et al., 2000; Singh et al., 2008;Kaewpradit et al., 2009).
Karmakar et al., (2009) studied the effect of application of fly ashand rice husk ash, the study showed that the application of thesetype of waste improved soil properties by decreasing soil bulk densityand increasing soil pH, organic carbon, available nutrients, and cropsyield.
5
-
The total amount of crop residues produced each year in rice-basedsystems of Asia can be roughly estimated at about 112 million tons ofrice husks (based on 2005 production and a husk/paddy ratio of 0.2).(Pandey 1998)
Asia and China Rice Production 2008
Residue burning is widely practiced and causes air pollution, humanhealth problems, and considerable nutrient losses.
6
Source: http://www.fao.org/corp/statistics/en/
-
Taiwans cultivated land area
0
50000
100000
150000
200000
250000
Rice Vegetable
s
Fruits Tea Others
cropsOrganic (ha) 949.44 518.43 295.52 139.84 453.1
No organic (ha) 147081.56 151573.57 215067.48 25647.16 13107.9
He
cta
res
99.36% 99.66% 99.86%
99.46%96.66%
0.64%
0.14%
0.54%3.34%
0.34%
Source: Organization of certification Agriculture and Food Agency ,Council of Agriculture. 2009
-
Characteristics of Carbonized Rice Residues
Carbonized rice husks are a very light material with amicroporous structure and a bulk density of about 0.150 g cm3(Nakajima 1986).
The structure of rice husks is preserved in the carbonizationprocess but carbonized husks break easily, especially ifcarbonized at high temperatures.
8
-
Biochar was found to be alkaline in nature (pH 8.2). Rice husk biocharproduced under temperatures between 500 and 600 , showed anoticeable increment in silicon, calcium, potassium and magnesiumcontent.
9
Biochar preparation and characterization
-
Scanning electron microscope analysis
The EDS point analysis of rice husk indicated that the biocharparticles consisted of high silicon mineral agglomerates on lowercarbon content fibers with structures typical of its biomassorigin
10
-
11
-
Wood biochar EDS point analysis, indicated that the biocharparticles consisted of high potassium, chlorine, and calcium.
Mineral agglomerates also showed high carbon content
12
-
13
-
To investigate and quantify effects of rice husk-basedbiochar and wood-based biochar on the growth of waterspinach, a field experiment was carried out under differenttreatments, consisting of:
(1) control soil and fertilizer,
(2) soil with rice husk biochar and fertilizer in fivedifferent quantities,
(3) and soil with wood biochar and fertilizer in fivedifferent quantities.
14
-
From the literature, the recommends amount of rice husk biocharthat should be applied is: 10 ton per hectare (Biochar and CarbonSequestration, a regional perspective, 2009).
1.94 m
1.10 m
-
Water spinach
Water convolvulus has been widely grown throughout the world. It isfound in South and Southeast Asia, Tropical Africa, SouthAmerica, and Oceania (Wenfang, 1997). However, it is only in southand Southeast Asia that it is an important leafy vegetable.
16http://waynesword.palomar.edu/ww0804.htm
-
Worm avoidance test
A toxicity test was conducted before starting the biocharexperiment. Following the guidelines from A guide toconducting biochar trials (Major. J., 2009) we realized aworm avoidance test
17
-
We made our trial with 50 worms that were purchased in a fish shop
The container was prepared with rice husk biochar and soil fromthe experimental field. We had as a result that most of theworms shown an acceptance for rice husk biochar
18
-
Soil
The experiment was conducted on an uncultivated clayey Ultisol soil, which are strongly leached, acid forest soils with relatively low native fertility.
19
http
://eu
soils.jrc
.ec
.eu
rop
a.e
u/e
sdb
_a
rch
ive
/eu
da
sm/a
sia/m
ap
s/TW3000_1SO
.htm
-
Germination comparison between Soil field with Biochar andsoil field without biochar
Soil with biochar shows the best germination
20
-
Application of rice husk biochar and wood biochar to soil
Soil preparation21
-
Biochars were weighted and later added to each one of the plots
22
-
Top soil mixing technique (Major, 2009)
Before transplanting was necessary to irrigate for 10 minutes
Following the literature recommendations, plants were transplanted in a distance of 15cm between them.
Each plot had 22 plants
23
-
Morphology
Leaf number
Leaf length and wide
Stem size
Stem number
Root size
Weight
24
-
Results:
Water spinach plants for all of the considered treatments were harvested after 8 weeks.
25
-
26
-
Effect of rice husk biochar and wood biochar on plant root growth
All water spinach plants were measured before harvesting; carefully plants and roots were removed from soil.
27
-
28
-
Statistical analysis
Both biochar treatments where compared using leastsignificant difference (LSD), for their main effectson plant growth properties (SAS 9.1, 2004).
29
-
30
-
31
0 1 2 3 4 50
20
40
60
80
100
120
140
160
Leaf le
ngth
(m
m)
Treatments
Rice husk
Wood
0 1 2 3 4 50
10
20
30
40
Le
af
nu
mb
er
Treatments
Rice husk
Wood
0 1 2 3 4 50
5
10
15
20
Leaf w
ide (
mm
)
Treatments
Rice husk
Wood
0 1 2 3 4 50
20
40
60
80
100
120
140
160
Leaf le
ngth
(m
m)
Treatments
Rice husk
Wood
-
32
0 1 2 3 4 50.0
0.5
1.0
1.5
2.0
2.5
3.0
3.5
Ste
m n
um
ber
Treatments
Rice husk
Wood
0 1 2 3 4 50
50
100
150
200
Ste
m s
ize
(m
m)
Treatments
Rice husk
Wood
-
33
Randomly we choose water spinach plants from eachtreatment, T1, T2, T3, T4, T5, treated with each one of the biochars.
-
34
0 1 2 3 4 50
50
100
150
Ro
ot
siz
e (
mm
)
Treatments
Rice Husk
Wood
-
Effect of rice husk biochar and wood biochar on plant fresh weight
From each treatment, plants were collected
All plants were classified by treatment
Plants were weighted35
-
36
0 1 2 3 4 50.0
0.1
0.2
0.3
0.4
0.5
0.6
We
igh
t (k
g)
Treatments
Rice Husk
Wood
-
37
-
38
Figure 4.1 Figure 4.2
-
Conclusions
Rice husk biochar showed better holding capacity than woodbased biochar, due to the differences in their particle size, ricehusk biochar was able to integrate better into soil making thedistribution more uniform.
Water spinach requires plenty of water because of its highsucculence, regardless of this information, we irrigated theplants every 2 days for only 10 minutes.
The plants were able to absorb the water that biochar wasretaining, being not affected by the lack of water.
39