Modular Sony HCD-GB3

SERVICE MANUAL

Sony CorporationHome Audio DivisionPublished by Sony Techno Create Corporation

E Model

COMPACT DISC DECK RECEIVER

9-887-236-012006E1678-1© 2006.05

Ver. 1.0 2006.05

SPECIFICATIONS

HCD-GB3

HCD-GB3 is the Amplifier, CD player, TapeDeck and Tuner section in CMT-GB3.

Model Name Using Similar Mechanism HCD-EC50CD

Base Unit Name BU-K6BD83S2-WODSection

Optical Pick-up Name KSM-213DCP

TAPE Model Name Using Similar Mechanism HCD-EC50

Section Tape Transport Mechanism Type —

Amplifier sectionThe following measured at AC 127 V, 60 Hz (Mexican model), AC 220 V, 60 Hz (Argentine model), AC 120, 220 or 240 V, 60 Hz (Other models)

DIN power output (rated): 40 + 40 W (6 ohms at 1 kHz, DIN)Continuous RMS power output (reference): 50 + 50 W (6 ohms at 1 kHz, 10% THD)

InputsAUDIO IN (stereo mini jack): Sensitivity 700 mV, impedance 47 kilohms

OutputsPHONES (stereo mini jack): Accepts headphones with an impedance of 8 ohms or moreSPEAKER: Accepts impedance of 6 ohms

CD player sectionSystem: Compact disc and digital audio systemLaser Diode Properties

Emission duration: continuousLaser Output*: Less than 44.6µW* This output is the value measurement at a distance of 200mm from the

objective lens surface on the Optical Pick-up Block with 7mm aperture.Frequency response: 20 Hz – 20 kHzSignal-to-noise ratio: More than 90 dBDynamic range: More than 90 dB

Tape deck sectionRecording system: 4-track 2-channel, stereo

Tuner sectionFM stereo, FM/AM superheterodyne tunerAntenna:

FM lead antennaAM loop antenna

FM tuner section:Tuning range: 87.5 – 108.0 MHz (50 kHz step)Intermediate frequency: 10.7 MHz

AM tuner section:Tuning range: 530 – 1,710 kHz (with 10 kHz tuning interval) 531 – 1,710 kHz (with 9 kHz tuning interval)Intermediate frequency: 450 kHz

GeneralPower requirements

Mexican model: AC 127 V, 60 HzArgentine model: AC 220 V, 50/60 HzOther models: AC 120, 220 or 230 – 240 V, 50/60 HzAdjustable with voltage selector

Power consumption: 80 WDimensions (w/h/d) (excl. speakers): Approx. 200 × 281.5 × 390.5 mmMass (excl. speakers): Approx. 5.1 kg

Design and specifications are subject to change without notice.

2

HCD-GB3

TABLE OF CONTENTS

1. SERVICING NOTES ................................................ 3

2. GENERAL ................................................................... 4

3. DISASSEMBLY3-1. Disassembly Flow ........................................................... 63-2. Side Panel (R), Side Panel (L) ......................................... 73-3. Top Panel Section ............................................................ 73-4. Mechanical Deck ............................................................. 83-5. Belt (MAIN), Belt (R/F) .................................................. 83-6. Front Panel Section ......................................................... 93-7. PANEL Board .................................................................. 93-8. JACK Board ..................................................................... 103-9. MAIN Board, REG Board ............................................... 103-10. CD Mechanism Deck Section (BU-K6BD83S2) ............ 113-11. Optical Pick-up (KSM-213DCP), BD83S Board ............ 123-12. Belt (DLM3A) ................................................................. 133-13. DC Fan, Chassis (MAIN MOLD) ................................... 133-14. POWER Board, AMP Board ........................................... 14

4. TEST MODE ............................................................... 15

5. MECHANICAL ADJUSTMENTS ......................... 16

6. ELECTRICAL ADJUSTMENTS .......................... 16

7. DIAGRAMS7-1. Block Diagram — BD/DRIVER Section — .................. 227-2. Block Diagram — TUNER Section — .......................... 237-3. Block Diagram — MAIN Section — ............................. 24

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

7-4. Printed Wiring Board — BD83S Board — .................... 257-5. Schematic Diagram — BD83S Board — ....................... 267-6. Printed Wiring Boards

— MAIN Board, REG Board — ..................................... 277-7. Schematic Diagram

— MAIN Board (1/3), REG Board — ............................ 287-8. Schematic Diagram — MAIN Board (2/3) — ............... 297-9. Schematic Diagram — MAIN Board (3/3) — ............... 307-10. Printed Wiring Board — AMP Board — ....................... 317-11. Schematic Diagram — AMP Board — .......................... 327-12. Printed Wiring Board — PANEL Board — ................... 337-13. Schematic Diagram — PANEL Board — ...................... 347-14. Printed Wiring Boards

— POWER Board, JACK Board — ................................ 357-15. Schematic Diagram

— POWER Board, JACK Board — ................................ 36

8. EXPLODED VIEWS8-1. Overall Section ................................................................ 458-2. Front Panel Section ......................................................... 468-3. Chassis Section ................................................................ 478-4. Top Panel Section ............................................................ 488-5. CD Mechanism Deck Section (BU-K6BD83S2-WOD) . 49

9. ELECTRICAL PARTS LIST .................................. 50

3

HCD-GB3

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing• Keep the temperature of the soldering iron around 270 °C

during repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous radiationexposure.

UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the lead-free mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARKUnleaded solder has the following characteristics.

• Unleaded solder melts at a temperature about 40 °C higherthan ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350 °C.Caution: The printed pattern (copper foil) may peel away if

the heated tip is applied for too long, so be careful!• Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.

LASER DIODE AND FOCUS SEARCH OPERATIONCHECKCarry out the “S curve check” in “CD section adjustment” and checkthat the S curve waveforms is output three times.

SECTION 1SERVICING NOTES

This appliance is classified as a CLASS 1 LASER product.The CLASS 1 LASER PRODUCT MARKING is located onthe rear exterior.

Laser component in this product is capable of emitting radiationexceeding the limit for Class 1.

When carrying this system1 Remove all discs to protect the CD mechanism.

2 Hold down CD u (play/pause) on the unit, and press ?/1 until “STANDBY” appears.

3 After “LOCK” appears, unplug the power cord.

NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT

CAUTION

4

HCD-GB3SECTION 2GENERAL

This section is extractedfrom instruction manual.

5

HCD-GB3

6

HCD-GB3SECTION 3

DISASSEMBLY

• This set can be disassembled in the order shown below.

3-1. DISASSEMBLY FLOW

3-3. TOP PANEL SECTION(Page 7)

3-6. FRONT PANEL SECTION(Page 9)

3-4. MECHANICAL DECK (Page 8)

3-5. BELT (MAIN), BELT (R/F)(Page 8)

3-7. PANEL BOARD(Page 9)

3-11. OPTICAL PICK-UP (KSM-213DCP), BD83S BOARD

(Page 12)

3-12. BELT (DLM3A)(Page 13)

3-10. CD MECHANISM DECK SECTION(BU-K6BD83S2)

(Page 11)

3-9. MAIN BOARD, REG BOARD

(Page 10)

3-8. JACK BOARD(Page 10)

3-2. SIDE PANEL (R),SIDE PANEL (L)

(Page 7)

SET

3-13. DC FAN, CHASSIS (MAIN MOLD)(Page 13)

3-14. POWER BOARD, AMP BOARD(Page 14)

7

HCD-GB3

4 two screws(+BV3 × 10)

9 Remove the top panel section in the direction of the arrow.

7 connector (CNP502)


6 two claws

5 two dowels

1 screw(+KTP3 × 10)


3 three screws(+BV3 × 10)

3-2. SIDE PANEL (R), SIDE PANEL (L)

3-3. TOP PANEL SECTION

3 side panel (R)

6 side panel (L)



1 four screws(case 3 TP2)

4 four screws(case 3 TP2)

Note: Follow the disassembly procedure in the numerical order given.

8

HCD-GB3

1 four screws(+BVTP 2.6 × 8)3 mechanical deck2 Slide the lever in the

direction of the arrow.

White Red

When re-assembling, solder each lead according to the color (Red, White, Black) as shown in the figure.

Red

Black

White

White

2 belt (R/F)1 belt (main)

3-4. MECHANICAL DECK

3-5. BELT (MAIN), BELT (R/F)

9

HCD-GB3




8 front panel section

2 wire (flat type) 29core (CNS111)



4 screw(+BV3 × 10)

3-6. FRONT PANEL SECTION

3-7. PANEL BOARD

3 fifteen screws(+BVTP2.6 × 8)4

6 PANEL board

two claws

1 knob (volume)

2 knob (jog)


10

HCD-GB3

qa two screws(+BV3 ×10)

q; screw(+BV3 ×10)

8 screw(+BV3 ×10)

qs MAIN board

9 REG board








3-9. MAIN BOARD, REG BOARD

3-8. JACK BOARD

2 two screws(+BVTP2.6 × 8)

6 JACK board

5 JACK HLDR 2 board

4 JACK HLDR 1 board

1 clamp

3 clip coathing

11

HCD-GB3

3-10. CD MECHANISM DECK SECTION (BU-K6BD83S2)

2 four screws(+BV3 × 10)

qa CD mechanism deck section (BU-K6BD83S2)

4 door (CD) assy

q; wire (flat type) 23core

6 wire (flat type) 13core

3 Remove the CD section and base unit (BU-K6BD83S2) section in the direction of the arrow.


7 two screws (+BV2.6)

8 two screws(+BVWH)

9 cover (CD mecha)

5 tape

12

HCD-GB3

8 Remove soldering from the four points.

7 wire (flat type) (16 core)(CN301)

q; BD83S board

9 optical pick-up (KSM-213DCP)

4 two screws (+PTPWHM 2.6)

1 two screws (+PTPWHM 2.6)

2 two coil springs (insulator)

3 two insulators

5 two coil springs (insulator)

6 two insulators

3-11. OPTICAL PICK-UP (KSM-213DCP), BD83S BOARD

13

HCD-GB3

3 cover

4 belt (DLM3A)

5 belt (DLM3A)



2 six screws(+BV3 × 10)


3 back panel

1 connecter (CNP902)

5 DC fan7 four screws

(+BVTP4 × 12)

6 Remove soldering from the two points.

qa chassis (main mold)

9 AC HOLD board

0 power cord

8 screw(+BV3 × 10)

3-12. BELT (DLM3A)

3-13. DC FAN, CHASSIS (MAIN MOLD)

14

HCD-GB3

4 four screws

7 two transister screws

1 screw(+BV3 × 10)

8 screw(+BV3 × 10)

2 three screws(+BV3 × 10)

6 POWER board

3 plate (pt shield)9 AMP board

5

3-14. POWER BOARD, AMP BOARD

15

HCD-GB3

[MC COLD RESET]The cold reset clears all data including preset data stored in thememory to initial conditions. Execute this mode when returningthe set to the customer.Procedure:

1. In the standby status, press the @/1 button to turn the poweron.

2. Press three buttons of [DSGX], s , and at last @/1 simulta-neously.

3. When “RESET” appears, the machine enters standby status.

[PANEL TEST MODE]Enter The Panel Test ModeProcedure:

1. In the standby status, press the @/1 button to turn the poweron.

2. Press three buttons of [DISPLAY], s , and [DSGX] simulta-neously.

3. When the panel test mode is activated, LEDs and segments ofLCD are all turned on.

Version CheckProcedure:

1. In the panel test mode (all LEDs and segments of LCD areturned on), press the [AUDIO IN] button.

2. On the LCD, date and version are displayed “xxxxxxxx”.For example, “1227V002”.

3. From this status, press the [TUNER/BAND] button, and thedestination is displayed. For example, “GB3LATIN”

4. To release from this mode, press three buttons of [DISPLAY],s , and [DSGX] simultaneously.

[CD REPEAT 5 LIMIT CANCEL MODE]Number of repeats for CD playback is 5 times when the repeat modeis “REPEAT”. This mode enables CD to repeat playback for limitlesstimes.Procedure:

1. Press the @/1 button to turn the power on.2. Press the CD 7 button to select CD function.3. Press three buttons of CD 7 , [EQ], and [DISC SKIP] simul-

taneously.4. It enters the CD repeat 5 limit cancel mode and displays “NO

LIMIT”5. To release this mode, press the @/1 button to turn the power

off.

[CD SHIP MODE]This mode can run the CD sled motor optionally. Use this mode, forinstance, when cleaning the optical pick-up.Procedure:

1. Press the @/1 button to turn the power on.2. Press the CD 7 button to select CD function.3. Press two buttons of CD 7 and @/1 simultaneously. *14. Set to the CD ship mode. (chucking on)5. After blink “STANDBY”, “LOCK” is displayed, disconnect

the AC plug.*1) If press three buttons of [DISC 3], s and @/1 simulta-

neously, activate the CD ship mode and MC cold reset.

[CD SLOT LOCK]This mode is for the antitheft of CD disc in shop. (not for transport)Procedure:

1. Press the @/1 button to turn the power on.2. Press the CD 7 button to select CD function.3. Insert a disc.4. While pressing the s button, press the Z button for more 5

seconds.5. The message “LOCKED” is displayed and the disc slot is

locked. (Even if exiting from this mode, the disc slot is stilllocked)

6. If press the Z button to eject the disc, the message“LOCKED” is displayed and can not eject the disc.

7. To release this lock, while pressing the s button, press the Z button for 5 seconds again.

8. The message “UNLOCKED” is displayed and the disc slot isunlocked.

[CD POWER MANAGE]This mode is for switch the CD power supply on/off. Even if thisstate pulls out AC plug, it is held.Procedure:

1. Press the @/1 button to turn the power on.2. Press the CD 7 button to select CD function.3. Press the @/1 button again to turn the power off (standby).4. While pressing the s button, press the @/1 button.5. It turns power on and display “CD POWER”, then display

“ON” or “OFF”.

[CHANGE-OVER THE AM TUNING INTERVAL]The AM tuning interval can be changed over 9 kHz or 10 kHz.Procedure:

1. Press the @/1 button to turn the power on.2. Press the [TUNER/BAND] button to select TUNER (AM)

function.3. Press the @/1 button again to turn the power off (standby).4. While pressing the TUNING+ JL button, press the

@/1 button.5. It turns power on and display “9k STEP” or “10k STEP”, and

thus the tuning interval is changed over.

SECTION 4TEST MODE

16

HCD-GB3

RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENTProcedure:

1. Mode: Playback

2. Turn the adjustment screw and check output peaks. If the peaksdo not match for L-CH and R-CH, turn the adjustment screwso that outputs match within 1dB of peak.

3. Mode: Playback

4. After the adjustments, apply suitable locking compound tothe pats adjusted.

Screwposition

L-CHpeak

within1dB

Outputlevel

L-CHpeak

R-CHpeak

within1dB

Screwposition

R-CHpeak

0 dB=0.775 VDECK SECTION

set

JACK boardPHONES jack(J102)

+–

level meter

test tapeP-4-A063(6.3 kHz, −10 dB)

1. Demagnetize the record/playback head with a headdemagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.

• Test Tape

Tape Signal Used for

P-4-A063 6.3 kHz, –10 dB Azimuth Adjustment

set

test tapeP-4-A063(6.3 kHz, −10 dB) oscilloscope

V H

waveform of oscilloscope

in phase 45° 90° 135° 180°

good wrong

JACK boardPHONES jack(J102)

• Precaution1. Clean the following parts with a denatured-alcohol-moistened

swab :record/playback head pinch rollererase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a headdemagnetizer. (Do not bring the head magnetizer close to theerase head.)

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, appiy suitable locking compound to

the parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

• Torque Measurement

• Tape Tension Measurement

Mode Tension Meter Meter Reading

FWD CQ-403Amore than 80 g

(more than 2.82 oz)

2.0 – 8.0 mN • m(20 to 80 g • cm)

(0.28 – 1.12 oz • inch)0.15 – 0.6 mN • m(1.5 to 6 g • cm)

(0.021 – 0.083 oz • inch)5 – 17.7 mN • m

(50 to 177 g • cm)(0.7 – 2.48 oz • inch)

5 – 17.7 mN • m(50 to 177 g • cm)

(0.7 – 2.48 oz • inch)

CQ-102AS

CQ-102C

CQ-201AS

CQ-201B

Mode

FWD

FWD

back tension

FF

REW

Torque meter Meter reading

SECTION 6ELECTRICAL ADJUSTMENTS

SECTION 5MECHANICAL ADJUSTMENTS

17

HCD-GB3

Checking Location:

+–

BD83S board

TP (RFACI)TP (VC)

oscilloscope (DC range)

Procedure :1. Connect oscilloscope to TP (RFACI) and TP (VC) on the

BD83S board.2. Press the I/1 button to turn the power ON, and press

the Z (CD) button to open the CD disc tray.3. Set disc (YEDS-18) on the tray and press the CD 7 button

to playback.4. Confirm that oscilloscope waveform is as shown in the figure

below. (eye pattern)A good eye pattern means that the diamond shape (◊) in thecenter of the waveform can be clearly distinguished.

VOLT/DIV: 200 mV TIME/DIV: 500 ns

level:0.9 ± 0.4 Vp-p

TP(VC)

TP(RFACI)

IC201

– BD83S Board (SIDE B) –

CD SECTION

Note:1. CD Block is basically constructed to operate without adjustment.2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.3. Use an oscilloscope with more than 10 MΩ impedance.4. Clean the object lens by an applicator with neutral detergent when the

signal level is low than specified value with the following checks.5. Check the focus bias check when optical pick-up block is replaced.

FOCUS BIAS CHECK

Adjustment Location: Record/Playback/Erase Head

18

HCD-GB3

TUNER SECTION 0 dB=1 µV

[AM]Setting:FUNCTION: TUNERTUNER/BAND button: AM

[FM]Setting:FUNCTION: TUNERTUNER/BAND button: FM

• Repeat the procedures in each adjustment several times.

AM RF signal generator

30% amplitude modulation by 400 Hz signalOutput level: 54 dBuV

60 cm

set

loop antenna A loop antenna B

+–

level meter

32 Ω

JACK boardPHONES jack (J102)

FM RF signalgenerator

75kHz frequencydeviation by 1K HzsignalOutput level: as low as possible (8dBuV)

+–

level meter

set

32 Ω0.01 µF

JACK boardPHONES jack (J102)

MAIN boardANTENNACNP802 pin 1


digital voltmeter

100 kΩMAIN boardTP (TUNER VT)

AM FREQUENCY COVERAGE ADJUSTMENT

Adjustment Part Frequency Display Reading on Digital Voltmeter

L852 530 kHz 1.5 ± 0.1 V

Confirmation 1,710 kHz 8 ± 0.5 V

AM TRACKING ADJUSTMENT

Adjust for a maximum reading on level meter

L851 530 kHz

FM FREQUENCY COVERAGE ADJUSTMENT

Adjustment Part Frequency Display Reading on Digital Voltmeter

L805 87.5 MHz 1.75 ± 0.1 V

Confirmation 108 MHz 6.2 ± 0.5 V

FM TRACKING ADJUSTMENT

Adjust for a maximum reading on level meter

L804 98 MHz

Adjustment Location: MAIN board (See page 19).

[FM DETECTOR ADJUSTMENT]Setting:FUNCTION: TUNERTUNER/BAND button: FM

1. Tune the set to 98 MHz.2. Adjust L806 so that modulation distortion may become the

best in the vicinity of the maximum value where the tuner outlevel becomes –15dBuV or more.

FM RF signalgenerator

Carrier frequency: 98MHzModulation:deviation by FM 75 kHzOutput level: 60 dBuV

+–

level meter

MAIN boardTP (TUNER GND)

MAIN boardIC801 pin qs(TUNER OUT L-ch)

set



19

HCD-GB3

Adjustment Location and Connecting Points

L851 CNP802

L852L804L805

AM TRACKING ADJUSTMENT

FM TRACKINGADJUSTMENT

(TUNER GND)

(TUNER VT)

FM FREQUENCYCOVERRANGEADUJUSTMENT

AM FREQUENCYCOVERRANGEADUJUSTMENT

FM DETECTORADUJUSTMENT

– MAIN BOARD (Component side) –

– MAIN BOARD (Condutor side) –

L806

TP (TUNER VT)

TP (TUNER GND)

IC801 pin qs(TUNER OUT L-ch)

31

20

HCD-GB3

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolytics andtantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• 2 : nonflammable resistor.• 5 : fusible resistor.• C : panel designation.

• H : adjustment for repair.• A : B+ Line.• B : B– Line.• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal productiontolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal productiontolerances.– BD83S BOARD –No mark: CD PLAY– Other Section –No mark: FM

• Circled numbers refer to waveforms.• Signal path.

F : TUNER (FM)f : TUNER (AM)J : CDd : AUXE : PB (TAPE)a : REC (TAPE)

• AbbreviationAR : Argentine modelE2 : 120V AC area in E modelMX : Mexican model

Note on Printed Wiring Boards:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• f : internal component.• : Pattern from the side which enables seeing.

• Indication of transistor.

THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printed in each block.)

SECTION 7DIAGRAMS

Note: The components identified by mark 0 or dottedline with mark 0 are critical for safety.Replace only with part number specified.

B

These are omitted.

C E

Q

C

B

These are omitted.

E

Q

2121

HCD-GB3

HCD-GB3

• Circuit Boards Location

REG board

AMP boardMAIN board

JACK board

PANEL board

POWER board

BD83S board

• Waveforms– MAIN Board – – BD83S Board –– PANEL Board ––

1 IC801 w; (XOUT)

13.3 µs1.5 Vp-p

500m V/DIV, 4 µs/DIV

2 IC701 qd (X0A/P90)

30.5 µs2.2 Vp-p

0.5 V/DIV, 10 µs/DIV

3 IC701 od (X0)

239 ns3.3 Vp-p

1 V/DIV, 100 ns/DIV

4 IC201 u; (RFACO) (CD PLAY mode)

200 mV/DIV, 500 ns/DIV

5 IC201 <z/, (XTAO) (CD PLAY mode)

1 V/DIV, 20 ns/DIV

6 IC201 1 (LRCK) (CD PLAY mode)

1 V/DIV, 10 µs/DIV

7 IC201 5 (BCK) (CD PLAY mode)

1 V/DIV, 200 ns/DIV

0.5 to 1.3 Vp-p

59.1 ns

3.3 Vp-p

22.7 µs

3.3 Vp-p

472 ns3.4 Vp-p

2222

HCD-GB3

HCD-GB3

7-1. BLOCK DIAGRAM — BD/DRIVER SECTION —

A

B

MAINSECTION(Page 24)


: CD

• Signal Path

Q670,671

Q669,672

Q665,668

Q666,667

M1

+

-

+

-

M1+

M1-

M2+

M2-

M

P67/AN7/INT2

P35/IC1

P74/SDA/SC2

P30/SO3P31/SC3

P75/SCL/SO2

P37/OCU1

P41/LED1

P43/LED3

P51/TIN1

P52/TIN2/PPGO

P53/PPG1

P42/LED2

P50/TINO

P54/SI0

P55/SC0

P33/TMCK

P56/SO0

P26

P76

SW3

SW1

SW7(CHACK)

SW8(OPEN)

SW2

SW6(CLOSE)

SW5(STOCK)

OPTICAL PICK-UPBLOCK

(KSM-213DCP/C2NP)

AUTOMATICPOWER

CONTROL

Q321

+1.7V+3.3V

LD

GND

FOCUSCOIL

F+

F

T+

T

SP+

SP

SL+

SL

TRACKINGCOIL

IC402

S201(LIMIT)

X20116.9344MHz

+3.3VSL/SP MOTORDRIVER

MOTORDRIVE

IC201RF AMP,DSP,MP3

12

6

11

13

14

VR

PD

16

15

18

17

4

23

2

20MUTE

CH2OUTF

CH1FIN

CH1RIN

CH2FIN

CH3FIN

OPIN+

CH2OUTR

CH1OUTR

CH1OUTF

CH4OUTF

CH4OUTR

CH3OUTR

CH3OUTF

M

M

M401(SPINDLE)

M402(SLED)

VCC

VC

A

B

C

D

E

F

DETECTOR

A

B

E50

F51

LD66

PD67

TFDR43

SSTP39

FFDR45

SFDR41

MPD

M-MUTE

38

XTACN

XRST

DATA

XLAT

CLOCK

117AOUT2

112AOUT1

108 XTAO

109 XTAI

57

58

C59

D60

SENS

XTACN

XRST

DATA

XLAT

CLOCK

SENS

13XLAT-MP3

REQ-MP3 REQ-MP3

CD-L

CD-R

XLAT-MP3

TRDR44

22CH3RIN SRDR42

CH2RIN FRDR46

5

3.3V+1.8V

IC203

CD MECHANISM DECKBLOCK

SYSTEM CONTROLLERIC701(1/2)

7

3 1

ACK-MP3ACK-MP3

12

15

7

89

16

11

20

26

8

DATA2 DATA-MP3

90CLK2 CLK-MP3

10IREQ-MP3IREQ-MP3

SCOR SCOR

+1.8REG

43

10

49

5

6

50

12

28

27

26

20

25

19

18

29

30

8

31

3

34

14

FOCUS/TRUCKINGCOIL DRIVER

MOTORDRIVE

M2M

MOTORDRIVE

MOTORDRIVE

Q661-664

VM9VCD

MOTORCONTROL

P36/OCU011

2323

HCD-GB3

HCD-GB3

7-2. BLOCK DIAGRAM — TUNER SECTION —


C

: TUNER(FM)

: TUNER(AM)

• Signal Path

5

11

25

7

1

31

83

26

27

28

18161715

19 20

AM RF-IN

REG

AM-OSC

36 FM RF-IN

34 FM RF-OUT

FM-OSC32

FM/AM

ANTENNA

L851

D851

L852AM OSC

L804FM RF

D802

D803

VT

L805FM OSC

CF80210.7MHz 10.7MHzCF801

L803

PD

LP-IN

LP-OUT

DODICLCE

X80175kHz

XIN

XOUT

AM-MIX

FM-MIX

FM-DET

AGC

AM IF-IN

FM IF-IN

12

13

L-OUT

R-OUT

IC801AM/FM IF AMP,

MIX, MPX, DET, OSCFM/AM PLL

TU-DOTU-DI

TU-CETU-CLK

TU-ANSD

TUNERR-CH R-CH

TUNERL-CH L-CH

CNP802

3

1

FM FREQUENCYCOVERAGE

AM FREQUENCYCOVERAGE

AM TRACKING

FM DETECTOR

FM TRACKING

CF803450kHz

TU-DI

TU-CE

TU-DO

TU-ANSD

VM+9VVM9V

VM9V+3V

+5V

TU-CLK

L806

Q801

Q802

+3VREG

+5VREG

Q803

FM MIXAMP

2

2424

HCD-GB3

HCD-GB3

7-3. BLOCK DIAGRAM — MAIN SECTION —

ABD/DRIVER SECTION(Page 22)

TUNERSECTION(Page 23)

C

BBD/DRIVER SECTION(Page 22)

: TUNER(FM)

: TUNER(AM)

: CD

• Signal Path

: AUX

: PB (TAPE)

: REC (TAPE)

• R-CH is omitted due to same as L-CH.

BIASOSC

Q507,508

Q501,502

REC/PBHEAD

BLOCKTAPE MECHANISM DECK

V2/P82

V1/P81

V0/P80

SYSTEM CONTROLLERIC701(2/2)

P57/SI1

ENCODER

AUDIO IN

J105

FUCTIONKEY

SW

REMOTECONTROLRECEIVER

IC703

SW703,704,706,709,710,719,721

SW711-716,SW708,720

SW701,702,705,722-724

L-CH

R-CH R-CH

TU-DO

TU-DITU-CLK

TU-ANSD

TU-CE

R-CH

P63/AN3

P71/AN9/SC1

39

46

55

56

57

33

L501

SW501(1/2)(REC/PB)

(REC/PB)

+4V

SW501(2/2)

BIAS OSC

AMP-ON

VM9V

P64/AN440

X1A14

X0A13

X70132.768kHz

X093

X192

X7024.19MHz

9 P34/IC0

FUCTIONKEY

FUCTIONKEY

38

41

1

DECODERIC702

21P44/LED4 322P45/LED5/TOT0 4

15

1623P46/LED6/TOT1

DATA

CLK

LCK5

11M1+

12M1-

13M2-

14M2+

M1+

M1-

M2-

M2+

RESETSWITCH

Q704

54 RSTXRESET

Q705,706

42

D051,052

RELAYDRIVE

ACIN

Q102

S001

E2

37 P61/AN1

P62/AN2

P65/AN5/INT0

P47/LED7/TOT2

P66/AN6/INT1

VM+9V

PB/REC EQ AMP,FUNCTION CONTROLLER

IC401

IC402LEVEL DET

D510

R-CH

A119 18OUT 1

SEL

OUT

1

B121

PB1P2

6

C12313SD

28REC 10

R-CHR-CH

L-CH

P27

45

POWERAMP

SEG0

SEG31

59

62COM0

COM3

DIM0

DIM1

6

10LED1

LED5

LIQUID CRYSTALDISPLAY

LCD702

Q244Q135

Q201

Q243

Q242

Q241

Q131-134,Q138

µCON VCC

µCON AVCC

36P60/ANO

P70/AN8/INT3

LINEFILTER

VOLTAGESELECTOR

L001

VM+9V

61

IC202

2P25

5

D702

+9VREG

IC101

+VP

-VP

13

D107-110

D191,192

Q151-154

D111,113+3.3VREG

Q191

Q192

AVDD

( +3.3V)DVDD

( +3.3V)

+3.3VREG

D156

D154

Q193

DETECTION

VM+9V

POWERMONITOR

Q121,122

+3.6VREG

Q701-703

1P24

67

6364

8994

100

.

.

.

17P40/LED0

24

SW699

LED702

LEDDRIVE

Q707,709,710

LED701,709(BACK LIGHT)

(STANDBY)

LED703-707(VOLUME)

J102PHONES

R-CH

R-CH

R-CH

L

R

R-CH

J101SPEAKER

R-CHCD-R

CD-L

P-SW

M-SW

+7V

PT001POWER

(MAIN)TRANSFORMER

PT002POWER

(SUB)TRANSFORMER

4

VOLUME

ENCODER

VOLUME 48 P73/AN11/SI2

SW700

AMPCONTROL

VOLTAGESHIFT

HPMUTE

RELAYCONTROL

OVERLOAD

AMPPROTECT

THERMALDET

PROTECT DET

DET

M

RY002

VM+9V FANCONTROL

Q901-Q903M901

FAN MOTORM

RY131

TH241

ERASE

D901

AMP-ON

2525

HCD-GB3

HCD-GB3

7-4. PRINTED WIRING BOARD — BD83S BOARD — • See page 21 for Circuit Boards Location. :Uses unleaded solder.

IC203

IC201

IC402

BD83S BOARD (SIDE A) BD83S BOARD (SIDE B)

1

1-868-067- (12)

3

5

E

4

M(SPINDLE MOTOR)

S201(LIMIT)

M

(SLED MOTOR)

GMAIN BOARD

CNS104(Page 27)

OPTICAL PICK-UPBLOCK

KSM-213DCP

12

1-868-067- (12)

12

TP(RFACI)

TP(VC)

1

A

B

C

D

E

F

G

2 3 4 5 6 7 8 9 10 11 12

• SemiconductorLocation

Ref. No. Location

IC201 E-8IC203 G-3IC402 C-10

Q321 F-5

2626

HCD-GB3

HCD-GB3

7-5. SCHEMATIC DIAGRAM — BD83S BOARD — • See page 21 for Waveforms. • See page 37 for IC Block Diagrams. • See page 40 for IC Pin Function Description.

C208

C205

R324

R101

R292

C110

R451

R102

R103

R104

R105

R107

R108

R109

R110

R111

R255

R253

C406

C301

R254

R252

R25

0

R26

8

R322

R321

C2

64

CN301

C222

C213

R291C201

C219

R112

R113

C203

C108

C102

C101

C103

C105

C111

C104

C109

C107

C113

C112

R275

R277

R276 C271

C221

C27

3

C2

61

C2

60

R26

5

R266

R267

R258

C25

8

R26

0

C256

C207

C254

C253

C252

C251

C232C206

C224

R278

C272

C204

C218

C291

C292

C217

C202

R401

C303

C322

C321

R323

R452

R421

C404

R207 C226

C26

5

C210

R256

C257

C323

Q321

C424

R423

C405

IC402

S201

TP

C230

TP

C220

C45

1

TP2

TP1

TP4

TP3

C274

R257

C304

IC201

R280

C401

C227

R202

C268 C215

C276

C277

IC203IC203

R201

CN102

C266C267

R203

C275

C214

X201

R270

R271

C223

0.1

0.1

100k

100

100

220p

22k

100

100

100

100

100

100

100

100

100

1k

1k

0.1

0.1

10k

10k

1M

10

k

2.2

2.2

0.0

01p

16P

0.1

0.1

10010010V

0.1

100

100

10010V

22

0p

22p

22

p

100p

100p

22

0p

220p

220p

220p

100p

100p

100

100

47k 0.1

0.1

47

0p

0.0

1

0.4

7

4.7

k

1k

4.7k

22

0k

22

0p

0

0.1

100 10V

0.0047p

470p

0.0047p

470p

0.1

0.1

0.1

10

0

0.1

0.1

0.1

470p

470p

0.1

0.1

0

10

1

0.001p

0

10

k

0

0.1

0 1

0.1

0.1

22k

0.1

10010V

2SA2119K

0.1

10k

0.1

BA5947FM-E2

100p

0.1

0.0

47

0.1

100k

1

CXD3014A-201R

0

22010V

1

0

10p 0.1

1

1

BH18LB1WG-TR

0

23P

10p5p

5p

0.1

16.9344MHz

1k

1M

0.1

FR

DR

FFD

R

TR

DR

TFD

R

FRDR

FFDR

TRDR

TFDR

SP

-

SP

+

SL+

SL-

SP+

SP-

SL+

SL-

OP

IN-

OP

IN+

CH

1FIN

CH

1R

IN

CH

2FIN

CH

2R

IN

GN

D

CN

F4

PO

WV

CC

CH

2O

UTR

CH

2O

UTF

CH

1O

UTR

CH

1P

UTF

CH

4O

UTR

CH

4O

UTF

CH

3O

UTF

CH

3O

UTR

PO

WV

CC

MU

TE

GN

D

CH

3R

IN

CH

3FIN

CH

4IN

CH

4C

AP

A

OP

OU

T

PR

EV

CC

VR

EF

GA

IN-S

W

MIRR

DFCT

FOK

VSS

LOCK

MDP

SSTP

IOVSS1

SFDR

SRDR

TFDR

TRDR

FFDR

FRDR

IOVDD1

AVDD0

AVSS0

E

F

TEI

TEO

FEI

FEO

VC

A

B

C

D

AV

DD

4

RFD

CO

PD

SEN

S

AC

_S

UM

EG

_INLD

PD

RFC

AV

SS

4

RFA

CO

RFA

CI

AV

DD

3

BIA

S

AS

YI

AS

YO

VP

CO

VC

TL

AV

SS

3

CLTV

FIL

O

FIL

I

PC

O

BC

KI

LR

CK

I

LR

CK

VSS

PC

MD

BC

K

VDD

IOVDD2

DOUT

TEST

IOVSS2

XVSS

XTAO

XTAI

XVDD

AVDD1

AOUT1

VREFL

AVSS1

AVSS2

VREFR

AOUT2

AVDD2

IOVDD0

IOV

SS

0

XTA

CN

XR

ST

VS

S

VD

D

SEN

S

WFC

K

XU

GF

XP

CK

GFS

C2P

O

SC

OR

VD

D

CO

UT

PC

MD

I

CLO

K

SV

SS

SV

DD

SV

SS

SVDD

VSSS

VD

D

VD

D

VS

S

TES

T1

SV

SS

SVSS

SVDD

JTAGTCK

JTAGTDI

JTAGTDO

JTAGTMS

TRST

VDD

TES1

PLLVDD

PLLVSS

AC

K-M

P3

REQ

-MP

3

IREQ

-MP

3

SS

TB

-MP

3

3 51

XLA

T-M

P3

XLA

T

CLK2

DA

TA

DA

TA

2

T+

VC

GND

LD

PD

F+

T-

F-

VCC

SCOR

SENS

CLK

XRST

D-OUT

DVDD(3.3V)

AVDD(3.3V)

E

D

A

B

C

F

VR

IREQ-MP3

REQ-MP3

ACK-MP3

XLAT-MP3

XLAT

DATA

DATA-MP3

CLK-MP3

2 4

(LIMIT)

AUTOMATIC

POWER

CONTROL

RF AMP,DSP,MP3

FOCUS/TRACKING

COIL DRIVER,

SLED/SPINDLE

MOTOR DRIVER

OPTICAL

PICK-UP

BLOCK

KSM-213DCP

(SPINDLE)

(SLED)

(VC)

(RFACI)

+1.8V REGULATOR

M-MUTE

D-GND

L-CH

A-GND

R-CH

M-GND

M+7V

XTACN

(APC)

(SPI)

No mark:CD PLAY

(2/3)CNS104

G

BD83S BOARD

(Page 29)

4

5

6 7

2727

HCD-GB3

HCD-GB3

7-6. PRINTED WIRING BOARDS — MAIN BOARD, REG BOARD — • See page 21 for Circuit Boards Location. :Uses unleaded solder.


Ref. No. Location

D107 E-7D108 E-7D109 E-7D110 E-7D111 E-7D113 E-7D131 D-8D132 D-8D154 F-6D156 F-5D191 F-5D192 F-5D193 F-3D501 C-10D502 C-9D503 C-9D504 C-9D505 D-9D506 C-9D508 D-9D510 D-9D511 D-8D802 B-3D803 B-4D812 B-2D813 B-2D814 B-4D851 B-4D901 G-3

IC101 G-11IC401 B-8IC402 C-10IC801 C-4

Q102 E-8Q121 E-8Q122 D-8Q131 E-3Q132 E-3Q133 E-4Q134 E-4Q135 E-3Q137 E-4Q138 E-4Q151 F-6Q152 F-6Q153 F-6Q154 F-6Q191 F-3Q192 F-3Q193 F-5Q501 C-8Q502 D-8Q507 B-10Q508 B-10Q801 B-5Q802 B-5Q803 D-3

A AMPBOARDCNP202

(Page 31)

FJACK

BOARDWH171

(Page 35)

BAMP

BOARDCNP201

(Page 31)

GBD83SBOARDCN102

(Page 25)

CPOWERBOARDWH151

(Page 35)

EPANELBOARDCNS701

(Page 33)

DAMP

BOARDCNP901

(Page 31)

IC401

IC402IC

801

IC101

ANTENNAFM/AM

4 6

3 1

1 3

6 4

K

K

K

K

A

A

AA

AA

1 3

6 4

TAPE MECHANISMDECK

6 1

1 3

64

1

7

E

E

E

E

E

E

E

8

351

1

1

1

1 4

2 2223

5

8

EE

E

E

E

E

E

EE

E

A

18

AA

K

K

K

E

E

E

E

A A

K

1 3

3 1

4 6

+

-

L

R

+

-

SPEAKERIMPEDANCE:

USE 6

1 2

A

B

C

D

E

F

G

H

3 4 5 6 7 8 9 10 11

3

31

1

(CHASSIS)

2828

HCD-GB3

HCD-GB3

7-7. SCHEMATIC DIAGRAM — MAIN BOARD (1/3), REG BOARD —

29

32

32

30

32

36

∗ : Impossible to measure No mark : FM

RELAYCONTROL

CLP101

CLP201

D113

D131

D108

D109

D110

WH103

WH203

IC101D132

D156

C101

C102

C113

C116

C118

C119

C121

C131

C133

C151

C181

C182

C183

C184

C187

C191

C192

C193

C402

C403

R101

R103

R104

R105

R106

R107 R108

R109R110

R111

R112

R113

R114

R121

R123

R124R125

R131

R153R154

R155

R156

R157

R158

R159

R160

R162R163

R164

R165

R166

R167

R168

R169

R170

R171

R172

R174

R177 R178R179 R180

R181

R182

R184

R188 R189

R191

R192R195

R196

R402

R902

C112

C153C152

WH101

WH102

WH901

C130

J101

L101

L102

C132

R129 R128 R127

Q135

RY131

R197

R194

R198

Q193

Q102Q122

Q121

C155

C156

C105

C106

D154

Q151

Q152

Q154

C134

Q131

R185 R199 R115 R117

R186 R200

R116

Q132

Q137

Q138

Q133

Q134

R406

R411

R193

Q192

Q191

C188

D901

R412

R183

R901

R133

R132

R130

R142

C412C413

C417

R410

R403

R404

C115

Q153

CNP151

C111

C114

R161

D192D191

D193

C515

D107

C418

D111

R118

EP102

LEAD PIN

LEAD PIN

1N4002B

1N4002B

1N5402-F46

1N5402-F46

1N5402-F46

3P

3P

KIA7809APIMC2836

MC2836

220050V

220050V

100025V

0.022

0.1

0.1

0.47

0.022

0.01

10016V

0.1

0.1

0.1

0.1

0.01

220 10V

0.1

0.1

100 16V

0.1

2.2k

47k

47k

47k

22k

22k 2.2k

2.22.2

100

100

100

100

220k

470k

10022k

47k

220k220k

47k

10k

2.2k

10k

10k

2.2k

10010k

22k

10k

22k

10k

10k

10k

10k

10k

10k

100

4.7k 4.7k0 0

10

10

10

22k 22k

1k

100k100

100

100

4.7k

220025V

0.470.47

5P

5P

4P

22010V

0.1

47 47 47

2SC3052F-TLF

RELAY

47

47

47

2SA1235TP-1EF

2SC3052F-T1-LF2SC3052F-T1-LF

2SC3052F-T1-LF

0.1

0.1

0.1

0.1

MC2838-T112-1

2SC3052F-T1-LF

2SA1235TP-1EF

2SA1235TP-1EF

470p

2SC5938-T112-1B

100 100 100 100

100 100

100

2SC5938-T112-1B

2SC5938-T112-1B

2SC5938-T112-1B

RT1P441C-TP-1

RT1N441C-TP-1

1k

1k

100k

KTC3203Y-AT

KTC3203Y-AT

0.01

MC2838-T112-1

220

10

4.7k

4.7k

4.7k

4.7k 100k

470 10V100 16V

0.1 50V

100k

1k

220

0.1

2SC3052F-T1-LF

8P

10016V

0.1

2.2k

1N4002B1N4002B

UDZW-TE17-3.9B

47p

1N5402-F46

0.1 50V

1N4002B

100

EARTH,PLATE

2929

HCD-GB3

HCD-GB3

7-8. SCHEMATIC DIAGRAM — MAIN BOARD (2/3) —

34

36

28

26

30

PB/REC EQ AMP,FUNCTION CONTROLLER

IC401

C194

C196

C198

C406

C40

7

C40

8C

415

C41

6

C431

C432

C43

3

C43

4

C43

7

C43

8

C501

C503C504

C505C506

C507C508

C510

C511

C512

C513

C514

C530

C532

C543C544

C568

C570

R134

R135

R136

R137

R138

R139

R140

R144

R145

R146

R147

R148

R149

R150

R405

R42

7

R42

8

R42

9

R43

0

R43

3

R43

4

R43

9

R44

0

R44

1

R44

2

R501

R502

R503R504

R505R506

R507R508

R509R510

R511R512

R513

R514

R515

R516

R517

R518

R519

R520

R521R522

R52

6

R527R528

R529

R530

R531

R532

R533

R534

R568

R570

R575R576R577

R579

R581

R582

R583

C564

C565 R543

R542

R545

R544

W501

W502

C562

C561

C566

R535

R536

R564

R565

CNA502

R560

R424 R425 R42

3

R42

6

CNS104

D502

D501

D504 D506 D503

D505

D510

CNP501

CNP502

Q501

D511

Q502

SW501

C158

C159

C567

L501

Q508

Q507

C410

CNP171

D508R578

R420

R419

C40

1

C409

C40

5

R561

C523

R525R523

R524C526

C525

C522 C529C527

C528

C197

C195 C573

C574 R574

R566

C577 R567

C571

R573

R584

R572

C421 C404

C531

C502

R54

1

C551

C509

CNS111

R571

IC402

TPR1

BD3881FV

0.1

0.1

0.1

1

0.00

47

0.00

47

0.1

0.1

0.22

0.22

470p

470p

470p

470p

47p

470p470p

0.0470.047

0.010.01

100 16V

470p

470p

0.001

0.001

0.1

0.001

0.0010.001

1

1

470

470

470

470

470

470

470

470

470

470

470

470

470

470

220

100k

100k

4.7k

4.7k

22k

22k

4.7k

4.7k

47k

47k

100

100

4.7k4.7k

10k10k

2.2k2.2k

470k470k

2.2M2.2M

100

100

47

47

100k

100k

100k

100k

22k22k

10k 4.7k4.7k

2.2k

2.2k

4.7k

4.7k

10k

10k

22k

1k

22k10k100k

10k

47k

4.7k

47k

0.01

1 4.7k

10k

4.7k

4.7k0.0022

0.0022

0.0022

47

47

10k

10k

6P-(PH)TAPE_HEAD

3P-PHTAPE_MECHA

0

8.2k 8.2k

10k

10k

23P

MC2840-T112-1

MC2840-T112-1

MC2840-T112-1 MC2840-T112-1 MC2840-T112-1

MC2840-T112-1

1SS355WTE-17

6P

3P

KTA1273-Y-AT

1SS355WTE-17

2SC3052F-T-1-LF

0.1

0.1

0.0047100V

2SC1740S-RT

2SC1740S-RT

0.1

8P

1SS355WTE-1710k

22k

22k

0.1

50V

0.1

0.1

50V

4.7

0.01

C5240.01 10k4.7k

4.7k 0.01

0.01

100p 100p0.001

0.001

47010V

0.1 1

1 100

100

1 220k

0.1

10k

220k

100k

0.11

0.001

47p

22k

2250V

100 16V

29P

220k

BA4558F-E2

• See page 39 for IC Block Diagram.

3030

HCD-GB3

HCD-GB3

7-9. SCHEMATIC DIAGRAM — MAIN BOARD (3/3) — • See page 21 for Waveform. • See page 38 for IC Block Diagram.

29

28 No mark : FM

L804

L805

C826

C827

C85

2

C82

1

C83

3

C83

1

C810

Q801

C838

C835

C836

C816

C834

JW804

JW802

JW803

JR801

JW806

R844

R846

R807

R85

3

R82

2

R837

R838

R810

R808

R830

R842

R839

R811

R81

8

R845

R829

R812

R84

8

C80

7

R821

R824

R825

R831 R828

C873

R836

R840

R83

3

R843

R814

R841

R859

R860

D813

D812

R852

R855

D851 C855

C85

4

C851

C83

0

C82

9

C825

C811

Q802

C83

2

CF801

CF802

C85

6

C84

7

C84

8

C853

Q803

C814

CF803

C80

1

IC801

R823

R83

5

C83

9

C828

C80

2

D802

R802

R81

5

C81

5

R84

9

C824

C817

R81

3

C820

R826

D814

R809

R834

R805

R85

1

C81

3

C819

R81

7

C82

2

L803C812

R806

C806

C804

C818

C809

R804

D803

X80

1

C823

C840C84

1

R801

R816

R863

R827

R819

R820

JW805

R850

JW851

L851L852

R803

C803

L806

CNP802

100p

100p

10p

0.04

7

0.47

0.47

0.22

2SC3052F-T1-LF

0.1

0.22

0.22

0.22

22010V

0

0

0

0

0

10

2.2k

100k

100k

2.2k

10k

10k

1M

10k

47k

47k

100

4.7k

47k

22

100k

470

1k

0.00

22

220

2.2k

470

220 47

2p

10k

22k

10k

470k

100

100

10k

10k

1PS226-115

1PS226-115

22

470k

SVC347A-TL 470p

10p0.047

0.01

0.01

16.3V

0.1

2SC3052F-T1-LF

0.47

5p

0.00

22

0.00

22

0.022

2SC5477

0.1

100

16V

LV23003VA

100

4.7k

0.1

100p

0.1

SV230-TB-E

10

4.7k

100p

22k

18p

0.1

10k

0.001

100

1PS226-115

1k

22k

100k

22k

220

10V

0.001

10k

470p

0.1

0

0.001

0.1

0.001

0.1

0

SV230-TB-E

75K

Hz 18p

0.47

2250

V

2.2k

10k

22k

100

10k

1k

0

2.2k

0

10

0.01

Fm-DET23003

3P

3131

HCD-GB3

HCD-GB3

7-10. PRINTED WIRING BOARD — AMP BOARD — • See page 21 for Circuit Boards Location. :Uses unleaded solder.


Ref. No. Location

D241 B-4

IC202 C-3

Q201 B-3Q202 B-4Q241 B-2Q242 B-2Q243 B-3Q244 B-3Q901 B-1Q902 B-2Q903 B-1

AMAIN

BOARDWH102

(Page 27)

DMAIN

BOARDWH901

(Page 27)

BMAIN

BOARDWH101

(Page 27)

IC202

1

3 1

15

4E

E

EE

E

E

E

E

E

-VP

R-OU

T

AMP BOARD

FAN

1 2

A

B

C

3 4 5

3232

HCD-GB3

HCD-GB3

7-11. SCHEMATIC DIAGRAM — AMP BOARD — • See page 39 for IC Block Diagram.

28

28

28

FAN

Q202

C201

C202

C203

C204

C209

C210

C21

1

C21

2

C244

C251

C253

C254

C901

C921

R201

R202

R207

R208

R213

R214

R215

R216

R217

R218

R219

R220

R221

R222

R223

R224R226

R227

R228R231

R232

R23

4

R235

R236

R237

R241

R242

R243

R244

R245

R247R248

R251

R253

R905

R907

R908

R909 R910

R924

C903

R249

C206

C205

R211

R212

Q243

Q244Q241

Q903

Q902

TH241

R238

Q901

Q242

D241

Q201R203

R911

R205

R246

R204

R206

R233

R225

CNP902

R906C902 R904

R923

R921R922

CNP901

CNP202

CNP201

IC202

R252C252

2SA2026

220p

220p

4.750V

4.750V

10p

10p

0.00

22

0.00

22

0.01

0.1

0.0022

0.0022

4.750V4.7

50V

0

0

100

100

10k

10k

1k

1k

1k

1k

1k

1k

22k

22k

10k

10k22k

2.2k

2.2k220

220

10k

0.222W

0.222W

0.222W

10k

10k

1k

100k

2.2k

470k10k

100

10k

47k

4.7k

4.7k

10k 47

2.2k

4750V

4.7k

220p

220p

33k

33k

2SC3052F-T1-LF

2SA1235TP-1EF2SC3052F-T1-LF

2SC3052F-T1-LF

2SA1235TP-1EF

0.222W

2SC3052F-T1-LF

2SA1235TP-1EF

MC2838-T112-1

2SA202647k

47

10k

10k

47k

10k

10k

22k

3P

47047

50V 10k

220k

1047

4P

5P

5P

STK432-070

1000.1

3333

HCD-GB3

HCD-GB3

7-12. PRINTED WIRING BOARD — PANEL BOARD — • See page 21 for Circuit Boards Location. :Uses unleaded solder.


Ref. No. Location

D509 C-6D701 C-4D702 C-4

IC701 C-5IC702 E-4IC703 C-3

LED701 B-3LED702 D-8LED703 G-6LED704 F-6LED705 E-5LED706 F-4LED707 G-4LED709 B-7

Q661 H-4Q662 H-6Q663 H-5Q664 H-5Q665 H-3Q666 H-3Q667 H-4Q668 H-4Q669 G-4Q670 G-4Q671 G-3Q672 G-3Q701 C-4Q702 C-4Q703 C-4Q704 C-3Q705 C-4Q706 C-4Q707 E-2Q709 F-2Q710 F-2

IC703

IC702

IC701

36 1(LIQUID CRYSTAL DISPLAY)

E

EE

E

E

E

3 1

>MTUNING+

CDu

>MTUNING-

(STANDBY)

?/1

TUNER/BAND

AUDIO IN

TAPE

DISPLAY

EMAIN

BOARDCNS111

(Page 27)

DSGX

DISC SKIP/EX-CHANGER

1DISC

2DISC

3DISC

Z

CD MECHANISMDECK

(VOLUME) (VOLUME)

(VOLUME)(VOLUME)

VOLUME

E E

E

E E

E E

E E

EE

+

ENTER

EQ

+

DIMMERILLUM

PLAY MODE/TUNING MODE

1 2

A

B

C

D

E

F

G

H

I

3 4 5 6 7 8 9

3434

HCD-GB3

HCD-GB3

7-13. SCHEMATIC DIAGRAM — PANEL BOARD — • See page 21 for Waveforms. • See page 39 for IC Block Diagram. • See page 43 for IC Pin Function Description.

29

JW700

JR704

L701

D702

C672

C702

C705

C706

C707

C70

8

C70

9

C710

C711

C71

2

C713

C71

4C

715

C716

C717 C718

C719

C721

C722

C723

C724

C725

C726

C72

7

C728

C729

C730

C73

4

C737

C738

C739

C74

1

C74

2

C74

3

C746

C74

7

C750

R651

R652

R653

R656

R657

R658

R659

R660

R661

R662

R663

R664

R66

6

R668

R669

R67

0

R671

R67

2

R67

3

R67

4

R67

5

R67

6

R67

7

R678

R67

9

R68

0

R681

R683

R684

R685

R686

R688

R69

0

R691

R69

2

R693

R69

4

R695

R69

6

R69

7

R698

R69

9

R700

R701

R702

R703

R704

R705

R706

R707

R708

R709

R710

R711

R712

R713

R714

R715

R716

R717

R718

R719

R721

R722

R724

R725

R726

R730

R732

R733

R734

R735

R738R

739

R74

0

R742

R743

R744

R745

R746

R747

R748

R749

R750

R751

R753

R754

R755

R756

R758

R759

R760

R761

R762

R763R764

R765 R766

R767

R769

R770

R771

R772

R773 R774

R775

R776

R777

R778

R779

R780

R784

R785

R786

R787

R79

2

R79

3

R79

4

R79

5

R797

R798

R799

R854

R857 R861

R862 R864 R865

R866

JR717

C733

C732 X701

C704

Q704

Q701

D701

LED

703

LED

704

LED

705

LED

706

LED

707

Q662

Q664

Q661

Q669Q671

Q668 Q670 Q672

SW699

SW701 SW702 SW705 SW722 SW723 SW724 SW703 SW704 SW706 SW709 SW710 SW719 SW721 SW711 SW712 SW713 SW714 SW715 SW716 SW708 SW720

R78

3

D509

LED701

LED709R757

R731

R66

5

Q665Q667

R856R796

R682

R667

R655

R728

C736

R687

C671

IC703

CNS701

CNS671

R689

C701

Q702

Q703

705

Q706

C703

R788

X702

R72

3

C73

1

R78

2R800

C735

Q663

IC702

IC701

R789

R790

R791

Q707

LCD702

SW700

R768

Q709

Q710

LED702

Q666

0

0

0

MC2836

0.1

0.01

0.01

0.1

0.001

47p

0.00

1

0.22

0.1

0.1

47p

0.00

10.

001

0.1

0.001 0.001

0.047

47010V

0.0047

0.001

47p

0.1

0.1

0.1

0.001

0.001

0.001

0.00

1

0.001

0.001

0.001

220p

220p

220p

0.0047

0.00

1

4.7 50V

47k

47k

47k

47k

470k

47k

47k

100

47k

47k

47k

47k

470

100

47k

470

470

22k

22k

22k

22k

22k

22k

100

22k

1k

22k

47k

2.2

22k

4.7k

2.2

1k

47k470

47k

470

470

1k 1k

470

1k

1k

1k

1k

4.7k

1k

1k

1k

1k

1k

1k

4.7k

22k

4.7k

10k

4.7k

1k

1k

1k

1k

1k

470

220k

1k

1k

100k

10k

22k

47k

470

1k

10k10

k

1k

1k

1k

2.2k

2.2k

2.2k

2.2k

47k

1k

1k

100k

100

10k

0

1k

1k

100

100k

47k

10k

22k22k

4.7k 22k

220k

4.7k

47k

1k

470

10k 22k

47k

1k

470

1k

100

10k

100k

10k

100

47

1k 1k 1k 1k

47k

100k

22k

1k

220 220

2.2k 2.2k 4.7k

1k

0

22p

22p32768Hz

4706.3V

RT1N441C-TP-1

2SA1235TP-1EF

UDZW-TE17-3.6B

1L43

45V

22D

OTD

T02

1L43

45V

22D

OTD

T02

1L43

45V

22D

OTD

T02

1L43

45V

22D

OTD

T02

1L43

45V

22D

OTD

T02

KTA1273-Y-AT

2SA1235TP-1EF

RT1N441C-TP-1

2SA1365-T112-1EF

2SA1365-T112-1EF

2SC3440-T112-1EF

2SC3440-T112-1EF 2SC3440-T112

-1EF

22k 1SS355WTE-17

1L0341Y23E0CA602

1L0341Y23E0CA602100k

10k

47k

2SA1365-T112-1EF 2SA1365-T112

-EF

10k10k

220k

470

47k

10k

0.1

4.7k

22 50V

RPM7240-H18

29P

13P

10k

0.1

2SC3052F-T1-LF

2SC3052F-T1-LF

2SC3052F-T1-LF

2SC3052F-T1-LF

10010V

0

4.19MHz

2.2k

0.1

22k

220k

0.001

2SC3052F-T-LF

BU2099FV

MB90802PF-G -113E1

1k

1k

1k

2SC3052F-T1-LF

10k

2SC3052F-T1-LF

2SC3052F-T1-LF

SLR-342VRT32

2SC3440-T112-1EF

3535

HCD-GB3

HCD-GB3

7-14. PRINTED WIRING BOARDS — POWER BOARD, JACK BOARD —

CMAIN

BOARDCNP151

(Page 27)

FMAIN

BOARDCNP171

(Page 27)

16

15

14

13

12

11

10

9

8

1

2

3

4

5

6

7

MX

MX

AR

POWER BOARD

JACK BOARD

J105AUDIO IN

J102PHONES

ACIN

VOLTAGESELECTOR

S001

E2

230-240V

220V

120V

*

PT002

*

PT001

NOT REPLACEABLEBUILT IN TRANSFORMER

1 4

9 5

1 8

1 2

A

B

C

D

E

3 4 5 6 7 8

1

8

• See page 21 for Circuit Boards Location. :Uses unleaded solder.

3636

HCD-GB3

HCD-GB3

7-15. SCHEMATIC DIAGRAM — POWER BOARD, JACK BOARD —

28

29

W052

RY002

L001

R051 R052

D052

D051

C053

C054

C51

R119 R120

R151

R152

J105

R175

R176

C142L103

J102

WH171

L106

L105

C140

W172

L104

C139

C141

WH151FH002 FH001

F051

PT002

PT001

JW001

JW005

JW002

JW003

S001

C055

WARE

G5PA-2

LINE FILTOR

4.7k 4.7k

MC2838-T112-1

MC2836-T112-1

0.47

0.47

0.1

47 47

4.7k

4.7k

JR1110

47k

47k

0.01

8P

0

0

0.1

WIRE-EARTHHP

0.1

0.01

8P

T3.15A/250V

0.47*

*: Not Replaceable Built in TransformerT001

T0021P TERMINAL

1P TERMINAL

37

HCD-GB3

• IC Block Diagrams

IC402 BA5947FM-E2

– BD83S Board –

1

LEVEL SHIFT

MUTING D

1516

+ –

+–

DD

1718

D

1920

VREF

2122232425262728

PREV

CC

OPOU

T

OUTV

REF

CH4C

APA

CH4I

N

CH3F

IN

CH3R

IN

GND

MUT

E

POW

VCC

CH3O

UTF

CH3O

UTR

CH4O

UTF

CH4O

UTR

OPIN

–

2

OPIN

+

INTERFACE

1413

D

1211

D

109876

CH2F

IN

CH2R

IN

GND

54

CH1F

IN

CH1R

IN

VREF

IN

POW

VCC

CH2O

UTR

CH2O

UTF

CH1O

UTR

CH1O

UTF

INTERFACE

D D

3

SW

INTERFACE

IC203 BH18LB1WG-TR

1VIN

2GND

3STBY

4 NC

5 VOUT

VOLTAGEREFERENCE

THERMALPROTECTION

OVER CURRENTPROTECTION

CONTROLBLOCK

38

HCD-GB3

IC801 LV23003VA

– MAIN Board –

1AM RF-IN

3FM-MIX

2REG

6VCC1

4GND1

AMRF

AMMIX

AMDET

AMIF

FMDET

FMIF

SD

FF

VCO

FF

FF

ST

TRIG

STSW

FMMIX FM

OSC

AMOSC

OSCBUFFER

FMS-METER

DECODER

PHASECOMPARATOR

MUTE

PROGRAMMABLEDIVIDER

REFERENCEDIVIDER

UNLOCKDETECTOR

SWALLOWCOUNTER

POWER ONRESET

DATA SHIFTREGISTER

LATCH

PHASEDETECTOECHARGEPUMP

UNIVERSALCOUNTER

5AM-MIX

7AMIF-IN

8FMIF-IN

9P-DET

10P-COMP11FM-DET

12L-OUT13R-OUT

14VSS

FMRF

36 FM RF-IN

35 GND2

34 FMRF-OUT

33 VCC2

30 BO229 BO1

32 FM-OSC

31 AM-OSC

28 A-OUT27 A-IN

23 FM DET-OUT

15CE16DI17CL18DO

22 MPX-IN

19 XIN20 XOUT

21 VDD

26 PD25 AGC

24 AM DET-OUT

LOW-PASSFILTER

AGC

IFBUFFER

PIROTDET

CCBI/F

39

HCD-GB3

– AMP Board –

IC202 STK432-070

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

+ch.1

+ch.2

LI+ LI-

NC

+VCC IC

C

LO+

LO-

+VP

-VP

RO+

RO-

-VCC SU

B

RI-

RI+

IC401 BD3881FV

28

REC1

O

27

REC1

N

26

REC2

N

25

REC2

O

24

INC2

23

INC1

22

INB2

21

INB1

20

INA2

19

INA1

18

OUT1

17

BAS1

16

OUT2

15

BAS2

BASS BASS

13

CONT

14

VEE

12

VDD

11

TRE2

10

TRE1

TREBLE

TREBLE

7

VOLI

N1

8VO

LIN2

9

GND

VOLUME

VOLUME

6

PB1O

LOGICCONTROL

5

PB2O

4

PB2N

1

PB1N

2

PB1P

3

PB2P

– MAIN Board –

12345678910

20191817161514131211

LPF

ControllerLatch

WriteBuffer

ShiftRegister

VSS

NCDATA

CLK

LCK

LED1

LED2

LED3

LED4

LED5

VDDOESONC

DIM

1

DIM

0

M2+M2-

M1-

M1+

IC702 BU2099FV

– PANEL Board –

40

HCD-GB3

• IC Pin Function DescriptionBD83S BOARD IC201 CXD3014A-201R (RF AMP, DSP, MP3)

Pin No. Pin Name I/O Description

1 LRCK O L/R sampling clock signal output terminal

2 LRCKI I L/R sampling clock signal input terminal

3 PCMD O Serial data output terminal

4 PCMDI I Serial data input terminal

5 BCK O Bit clock signal output terminal

6 BCKI I Bit clock signal input terminal

7 XTACN IOscillation circuit on/off switch control signal input from the system controller

“L”: oscillation stop, “H”: self-oscillation

8 XRST I System reset signal input from the system controller “L”: reset

9 VSS — Ground terminal

10 IREQ-MP3 O MP3 data request signal output to the system controller

11 CLOK I CD serial data transfer clock signal input from the system controller

12 DATA2 I MP3 serial data input from the system controller

13 XLAT-MP3 I MP3 serial data latch pulse signal input from the system controller

14 REQ-MP3 I MP3 data request signal input from the system controller

15 ACK-MP3 O MP3 acknowledge signal output to the system controller

16 XLAT I CD serial data latch pulse signal input from the system controller

17 VDD — Power supply terminal (+1.8V)

18 SVSS — Ground terminal

19 SVDD — Power supply terminal (+1.8V)

20 SENS O Internal status (SENSE) signal output to the system controller

21 WFCK O WFCK output (Not used)

22 XUGF O XUGF output (Not used)

23 XPCK O XPCK output (Not used)

24 GFS O GFP output (Not used)

25 C2PO O C2PO output (Not used)

26 SCOR O Subcode sync (S0+S1) detection signal output to the system controller


28 COUT I/O Track number count signal input/output (Not used)



31 MIRR I/O Mirror signal input/output (Not used)

32 DFCT I/O Defect signal input/output (Not used)

33 FOK I/O Focus OK signal input/output (Not used)




37 LOCK I/O Not used

38 MDP O Spindle motor servo control signal output terminal

39 SSTP I Disc inner position detection signal input terminal

40 IOVSS1 — Ground terminal

41 SFDR O Sled servo drive signal (+) output to the coil/motor driver

42 SRDR O Sled servo drive signal (–) output to the coil/motor driver

43 TFDR O Tracking servo drive signal (+) output to the coil/motor driver

44 TRDR O Tracking servo drive signal (–) output to the coil/motor driver

45 FFDR O Focus servo drive signal (+) output to the coil/motor driver

46 FRDR O Focus servo drive signal (–) output to the coil/motor driver

41

HCD-GB3


47 IOVDD1 — Power supply terminal (+3.3V)

48 AVDD0 — Power supply terminal (+3.3V)

49 AVSS0 — Ground terminal

50 E I E signal input from the optical pick-up block

51 F I F signal input from the optical pick-up block

52 TEI I Tracking error signal input terminal

53 TEO O Tracking error signal output terminal

54 FEI I Focus error signal input terminal

55 FEO O Focus error signal output terminal

56 VC O Middle point voltage output terminal

57 A I A signal input from the optical pick-up block

58 B I B signal input from the optical pick-up block

59 C I C signal input from the optical pick-up block

60 D I D signal input from the optical pick-up block


62 RFDCO O RFDC signal output (Not used)

63 PDSENS I Reference voltage pin (Connected to ground)

64 AC_SUM O RFAC summing amplifier signal output terminal

65 EQ_IN I RF equalizer circuit input terminal

66 LD OLaser diode on/off control signal output to the automatic power control circuit

“L”: laser off, “H”: laser on

67 PD I Light amount monitor input from the optical pick-up block laser diode

68 RFC I Equalizer cut off frequency adjustment terminal


70 RFACO O EFM signal output terminal

71 RFACI I EFM signal input terminal


73 BIAS I Asymmetry circuit constant current input terminal

74 ASYI I Playback EFM asymmetry comparator voltage input terminal

75 ASYO O Playback EFM full-swing output terminal

76 VPCO O Charge pump output terminal for broad-band EFM PLL (Not used)

77 VCTL I VCO2 control voltage input terminal for broad-band EFM PLL


79 CLTV I VCO1 control voltage input terminal for multiplier

80 FILO O Filter output terminal for master PLL

81 FILI I Filter input terminal for master PLL

82 PCO O Charge pump output terminal for master PLL



85 SSTB-MP3 I MP3 standby control signal input terminal “L”: standby (Connected to ground)



88 TEST1 I Test terminal (Connected to ground)

89 DATA I CD serial data input from the system controller

90 CLK2 I MP3 serial data transfer clock signal input from the system controller



93 JTAGTCK — Connected to ground

94 JTAGTDI — Connected to ground

42

HCD-GB3


95 JTAGTDO — Not used

96 JTAGTMS — Connected to ground

97 TRST — Connected to ground




101 DOUT O Digital audio signal output terminal (Not used)

102 TEST I Test terminal (Connected to ground)

103 TES1 I Test terminal (Connected to ground)


105 PLLVDD — Power supply terminal (+1.8V)

106 PLLVSS — Ground terminal

107 XVSS — Ground terminal

108 XTAO O System clock output terminal (16.9344 MHz)

109 XTAI I System clock input terminal (16.9344 MHz)

110 XVDD — Power supply terminal (+1.8V)


112 AOUT1 O L-ch analog audio signal output terminal

113 VREFL O L-ch reference voltage output terminal



116 VREFR O R-ch reference voltage output terminal

117 AOUT2 O R-ch analog audio signal output terminal




43

HCD-GB3

PANEL BOARD IC701 MB90802-108 (SYSTEM CONTROLLER)


1 P24 O Power relay control signal output

2 P25 O Amp control signal output

3 P26 O System reset signal output to the RF AMP

4 P27 O Control signal output to the PB/REC EQ AMP/FUNCTION CONTROLLER

5 P30/SO3 O Serial data output to the MP3 decoder

6 P31/SC3 O Serial data transfer clock signal output to the MP3 decoder

7 P32/SI3 I Serial data input

8 P33/TMCK O Latch pulse signal output to the RF AMP

9 P34/IC0 I Remote sensor signal input

10 P35/IC1 O Serial data latch pulse output to the MP3 decoder

11 P36/OCU0 O M-MUTE signal output to the MP3 decoder

12 P37/OCU1 O Data transfer request signal output to the MP3 decoder

13 X0A/P90 O Resonator output terminal (32.768kHz)

14 X1A/P91 I Resonator input terminal (32.768kHz)

15 VCC — Power supply terminal (+3.3V)


17 P40/LED0 O STANDBY LED control signal output

18 P41/LED1 I CD switch (SW3) input terminal



21 P44/LED4 O Serial data output to the decoder

22 P45/LED5/TOT0 O Serial data transfer clock signal output to the decoder

23 P46/LED6/TOT1 O Latch pulse signal output to the decoder

24 P47/LED7/TOT2 O Back light LED control signal output

25 P50/TIN0 I CD chuck switch (SW7) input terminal

26 P51/TIN1 I CD close switch (SW6) input terminal

27 P52/TIN2/PPG0 I CD stock switch (SW5) input terminal

28 P53/PPG1 I CD open switch (SW8) input terminal

29 P54/SI0 I Internal status (SENSE) input from the CD DSP

30 P55/SC0 O Serial data transfer clock signal output to the CD DSP

31 P56/SO0 O Serial data output to the CD DSP

32 AVCC — Power supply terminal (+3.3V)

33 P57/SI1 I Data input from the the tuner

34 P76 O Oscillator control signal output to the CD DSP

35 AVSS — Ground terminal

36 P60/AN0 I Power detection signal input

37 P61/AN1 I Key AD input1

38 P62/AN2 I Key AD input2

39 P63/AN3 I Tuner tuned status signal input

40 P64/AN4 I Tape mecha status signal input

41 P65/AN5/INT0 I Key AD input3

42 P66/AN6/INT1 I Power down detection signal input

43 P67/AN7/INT2 I Subcode data request signal input terminal


45 P70/AN8/INT3 I Signal input from the encoder

46 P71/AN9/SC1 I Audio level signal input

47 P72/AN10/SO1 I SUFFIX signal input (Connected to +3.3V)

48 P73/AN11/SI2 I Signal input from the volume encoder

44

HCD-GB3


49 P74/SDA/SC2 I Data transfer request signal input from the MP3 decoder

50 P75/SCL/SO2 I Acknowledge signal input from the MP3 decoder

51 MD2 I Input pin for selecting operation mode (Connected to ground)

52 MD1 I Input pin for selecting operation mode (Connected to +3.3V)

53 MD0 I Input pin for selecting operation mode (Connected to +3.3V)

54 RSTX I System reset signal input terminal

55 V0/P80 O Tuner chip enable signal output to the tuner

56 V1/P81 O Clock signal output to the tuner

57 V2/P82 O Data output to the tuner

58 V3 I Reference power terminal of LCD controller/driver

59, 60 COM0, COM1 O Common signal output to the LCD

61, 62 P83/COM2, P84/COM3 O Common signal output to the LCD

63, 64 SEG0, SEG1 O Segment signal output to the LCD



67 to 84 SEG2 to SEG19 O Segment signal output to the LCD

85 to 89 SEG20/P10 to SEG24/P14 O Segment signal output to the LCD



92 X1 I Resonator input terminal (4.19MHz)

93 X0 O Resonator output terminal (4.19MHz)



45

HCD-GB3

5 3-363-099-32 SCREW (CASE 3 TP2)6 1-787-319-12 FAN, DC#1 7-685-247-14 SCREW +KTP 3X10 TYPE2 NON-SLIT

SECTION 8EXPLODED VIEWS

NOTE:• -XX and -X mean standardized parts, so they

may have some difference from the originalone.

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.

• The mechanical parts with no referencenumber in the exploded views are not supplied.


Ref. No. Part No. Description Remark

1 2-669-681-02 PANEL (L), SIDE2 2-669-683-01 PANEL, BACK (E2)2 2-669-683-11 PANEL, BACK (AR, MX)3 2-669-682-02 PANEL (R), SIDE4 3-254-143-11 SCREW (B3), (+) BV TAPPING

8-1. OVERALL SECTION


A

A

B

B

C

C

3

2

4

4

4

4

54

4

6

44

4

4

5

front panel section

chassis section

top panel section

#1

#1

1

4

The components identified by mark 0 ordotted line with mark 0 are critical for safety.Replace only with part number specified.

46

HCD-GB3

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

51 2-669-695-01 KNOB (VOLUME)52 2-669-699-01 RING (VOLUME)53 2-669-698-01 LENS (VOLUME)54 2-679-198-01 SHEET (VOLUME)55 2-669-696-01 KNOB (JOG)

56 2-669-702-01 WINDOW (DISPLAY)57 2-672-558-01 RING (DSGX)58 X-2109-154-1 BUTTON (PLAY) ASSY59 2-669-689-01 KEY (DISPLAY)60 2-669-692-01 KEY (POWER)

61 2-669-691-01 KEY (DSGX)62 2-669-690-01 KEY (EQ)

8-2. FRONT PANEL SECTION

63 2-669-693-01 KEY (ENTER)64 2-672-557-01 KEY (EJECT)65 4-225-252-01 CUSHION (FOOT)

66 2-669-680-01 PANEL, FRONT67 A-1177-458-A PANEL BOARD, COMPLETE (E2)67 A-1177-460-A PANEL BOARD, COMPLETE (MX)67 A-1177-461-A PANEL BOARD, COMPLETE (AR)68 4-951-620-01 SCREW (2.6X8), +BVTP

69 1-832-657-21 CABLE, FLEXIBLE FLAT (29 CORE)70 2-669-697-01 LENS (STANDBY)71 3-701-748-00 CLAMP

58

51

53

55

52

56

62

54

63

57

64

70

59

61

65

65

66

67

68

71

68

69

60

notsupplied

notsupplied

notsupplied

47

HCD-GB3


8-3. CHASSIS SECTION

101 2-649-153-41 CHASSIS (MAIN MOLD)102 4-225-252-01 CUSHION (FOOT)103 3-254-143-11 SCREW (B3), (+) BV TAPPING104 3-229-336-11 SCREW, +BVWH TAPPING105 2-633-134-01 SCREW (B2.6), (+) BV TAPPING

106 2-681-036-01 COVER (CD MECHA)107 1-832-837-21 CABLE, FLEXIBLE FLAT (13 CORE)108 X-2109-155-1 DOOR (CD) ASSY109 1-831-612-21 CABLE, FLEXIBLE FLAT (23 CORE)110 A-1177-468-A MAIN BOARD, COMPLETE

111 3-701-748-00 CLAMP112 A-1177-469-A AMP BOARD, COMPLETE

113 3-905-609-31 SCREW (TRANSISTOR)0114 1-831-370-11 CORD, POWER (E2)0114 1-832-228-11 CORD, POWER (AR)

0114 1-832-377-11 CORD, POWER (MX)115 A-1177-464-A POWER BOARD, COMPLETE (E2)115 A-1177-466-A POWER BOARD, COMPLETE (MX)115 A-1177-467-A POWER BOARD, COMPLETE (AR)116 4-900-386-01 SCREW

0F051 1-532-237-00 FUSE (T3.15AL/250V)0PT001 1-443-911-11 TRANSFORMER, POWER (E2, AR)0PT001 1-443-995-21 TRANSFORMER, POWER (MX)

#2 7-685-661-14 SCREW +BVTP 4X12 TYPE2 IT-3

101

103

103

103

103

103

103

103

103

103

103103

103

104

105

105

102

107

108

109

111

114116

115

110 112

106

PT001F051

notsupplied

notsupplied

notsupplied

notsupplied

notsupplied

notsupplied

notsupplied

notsupplied

notsupplied

#2#2

113

CD mechanism deck section(BU-K6BD83S2-WOD)

48

HCD-GB3


8-4. TOP PANEL SECTION

151 4-951-620-01 SCREW (2.6X8), +BVTP152 2-649-154-01 LEVER (REC)153 2-649-132-11 BUTTON (CASS)154 3-921-725-01 SCREW (2.6X10), +PWH155 3-047-468-01 DAMPER

156 2-649-131-11 BOX, CASSETTE157 2-649-152-02 SPRING (CASS)

158 2-649-128-61 PANEL, TOP159 1-797-575-11 DECK, MECHANICAL160 2-688-622-01 BELT (MAIN)

161 2-688-621-01 BELT (R/F)162 3-701-748-00 CLAMP#3 7-685-850-04 SCREW +BVTT 2X3 (S)

160

162

161

151

151

152

155

159

158

157

154

156

153

#3

notsupplied

notsupplied

49

HCD-GB3


8-5. CD MECHANISM DECK SECTION (BU-K6BD83S2-WOD)

201 A-1179-506-A BD83S BOARD, COMPLETE202 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING203 2-632-062-01 BELT (DLM3A)204 4-227-045-11 SPRING (INSULATOR), COIL205 4-227-549-11 INSULATOR

208

201

205

204

203

S201

209

205

204

202

202

205

204

202

202

205

204

207

206206

notsupplied

notsupplied

206 4-951-620-01 SCREW (2.6X8), +BVTP207 1-797-193-12 MECHANICAL, CD (DLM3A23-11)208 1-832-404-21 CABLE, FLEXIBLE FLAT (16 CORE)

0209 A-4735-357-A OP BASE ASSY (KSM-213DHAP/ZRP1)S201 1-771-853-11 SWITCH, DETECTION (LIMIT)

50

HCD-GB3SECTION 9

ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• -XX and -X mean standardized parts, so theymay have some difference from the originalone.

• RESISTORSAll resistors are in ohms.METAL: Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F: nonflammable

• CAPACITORSuF: µF

• COILSuH: µH

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.

• SEMICONDUCTORSIn each case, u: µ, for example:uA. . : µA. . uPA. . : µPA. .uPB. . : µPB. . uPC. . : µPC. .uPD. . : µPD. .

When indicating parts by reference number,please include the board name.


A-1177-469-A AMP BOARD, COMPLETE********************

< CAPACITOR >

C201 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC202 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC203 1-126-963-11 ELECT 4.7uF 20% 50VC204 1-126-963-11 ELECT 4.7uF 20% 50VC205 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C206 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC209 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC210 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC211 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC212 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C244 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC251 1-165-621-91 CERAMIC CHIP 0.1uF 50VC252 1-165-621-91 CERAMIC CHIP 0.1uF 50VC253 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC254 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C901 1-126-963-11 ELECT 4.7uF 20% 50VC902 1-126-967-11 ELECT 47uF 20% 50VC903 1-126-967-11 ELECT 47uF 20% 50VC921 1-126-963-11 ELECT 4.7uF 20% 50V

< CONNECTOR >

CNP201 1-819-133-11 PIN, CONNECTORCNP202 1-815-446-11 PIN, CONNECTOR (PWB) 5PCNP901 1-815-445-11 PIN, CONNECTOR (PWB) 4PCNP902 1-819-131-11 PIN, CONNECTOR 3P

< DIODE >

D241 6-500-335-01 DIODE MC2838-T112-1

< IC >

IC202 6-709-529-01 IC STK432-070

< TRANSISTOR >

Q201 6-551-270-01 TRANSISTOR 2SA2026Q202 6-551-270-01 TRANSISTOR 2SA2026Q241 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ242 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ243 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF

Q244 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ901 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ902 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ903 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF

< RESISTOR >

R201 1-216-864-11 SHORT CHIP 0R202 1-216-864-11 SHORT CHIP 0R203 1-216-841-11 METAL CHIP 47K 5% 1/10WR204 1-216-841-11 METAL CHIP 47K 5% 1/10WR205 1-216-833-11 METAL CHIP 10K 5% 1/10W

R206 1-216-833-11 METAL CHIP 10K 5% 1/10WR207 1-216-809-11 METAL CHIP 100 5% 1/10WR208 1-216-809-11 METAL CHIP 100 5% 1/10WR211 1-216-839-11 METAL CHIP 33K 5% 1/10WR212 1-216-839-11 METAL CHIP 33K 5% 1/10W

R213 1-216-833-11 METAL CHIP 10K 5% 1/10WR214 1-216-833-11 METAL CHIP 10K 5% 1/10WR215 1-216-821-11 METAL CHIP 1K 5% 1/10WR216 1-216-821-11 METAL CHIP 1K 5% 1/10WR217 1-216-821-11 METAL CHIP 1K 5% 1/10W


R223 1-216-833-11 METAL CHIP 10K 5% 1/10WR224 1-216-833-11 METAL CHIP 10K 5% 1/10WR225 1-216-837-11 METAL CHIP 22K 5% 1/10WR226 1-216-837-11 METAL CHIP 22K 5% 1/10WR227 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R228 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR231 1-216-813-11 METAL CHIP 220 5% 1/10WR232 1-216-813-11 METAL CHIP 220 5% 1/10WR233 1-216-833-11 METAL CHIP 10K 5% 1/10WR234 1-216-833-11 METAL CHIP 10K 5% 1/10W

0R235 1-216-361-31 METAL OXIDE 0.22 5% 2W0R236 1-216-361-31 METAL OXIDE 0.22 5% 2W0R237 1-216-361-31 METAL OXIDE 0.22 5% 2W0R238 1-216-361-31 METAL OXIDE 0.22 5% 2W

R241 1-216-833-11 METAL CHIP 10K 5% 1/10W

R242 1-216-833-11 METAL CHIP 10K 5% 1/10WR243 1-216-821-11 METAL CHIP 1K 5% 1/10WR244 1-216-845-11 METAL CHIP 100K 5% 1/10WR245 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR246 1-216-833-11 METAL CHIP 10K 5% 1/10W

R247 1-216-853-11 METAL CHIP 470K 5% 1/10WR248 1-216-833-11 METAL CHIP 10K 5% 1/10WR249 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR251 1-216-809-11 METAL CHIP 100 5% 1/10WR252 1-216-809-11 METAL CHIP 100 5% 1/10W

The components identified by mark 0 ordotted line with mark 0 are critical for safety.Replace only with part number specified.


AMP

51

HCD-GB3


R253 1-216-833-11 METAL CHIP 10K 5% 1/10WR904 1-216-833-11 METAL CHIP 10K 5% 1/10WR905 1-216-841-11 METAL CHIP 47K 5% 1/10WR906 1-216-817-11 METAL CHIP 470 5% 1/10WR907 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R908 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR909 1-216-833-11 METAL CHIP 10K 5% 1/10WR910 1-216-805-11 METAL CHIP 47 5% 1/10WR911 1-216-805-11 METAL CHIP 47 5% 1/10WR921 1-216-797-11 METAL CHIP 10 5% 1/10W

R922 1-216-805-11 METAL CHIP 47 5% 1/10WR923 1-216-849-11 METAL CHIP 220K 5% 1/10WR924 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

< THERMISTOR >

TH241 1-805-217-21 THERMISTOR (1012)*************************************************************

A-1179-506-A BD83S BOARD, COMPLETE**********************

< CAPACITOR >

C101 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC102 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC103 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC104 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC105 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C107 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC108 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC109 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC110 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC111 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

C112 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC113 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC201 1-128-995-21 ELECT CHIP 100uF 20% 10VC202 1-164-360-11 CERAMIC CHIP 0.1uF 16VC203 1-128-995-21 ELECT CHIP 100uF 20% 10V

C204 1-164-360-11 CERAMIC CHIP 0.1uF 16VC205 1-164-360-11 CERAMIC CHIP 0.1uF 16VC206 1-164-360-11 CERAMIC CHIP 0.1uF 16VC207 1-128-995-21 ELECT CHIP 100uF 20% 10VC208 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C210 1-164-360-11 CERAMIC CHIP 0.1uF 16VC213 1-164-360-11 CERAMIC CHIP 0.1uF 16VC214 1-164-360-11 CERAMIC CHIP 0.1uF 16VC215 1-164-360-11 CERAMIC CHIP 0.1uF 16VC217 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C218 1-164-360-11 CERAMIC CHIP 0.1uF 16VC219 1-164-360-11 CERAMIC CHIP 0.1uF 16VC220 1-164-360-11 CERAMIC CHIP 0.1uF 16VC221 1-164-360-11 CERAMIC CHIP 0.1uF 16VC222 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C223 1-164-360-11 CERAMIC CHIP 0.1uF 16VC224 1-164-360-11 CERAMIC CHIP 0.1uF 16VC226 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC227 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC230 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C232 1-164-360-11 CERAMIC CHIP 0.1uF 16VC251 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC252 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC253 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC254 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V

C256 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC257 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC258 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC260 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3VC261 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C264 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC265 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC266 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC267 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50VC268 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V

C271 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC272 1-164-360-11 CERAMIC CHIP 0.1uF 16VC273 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC274 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC275 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V

C276 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC277 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC291 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC292 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC301 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C303 1-137-710-11 CERAMIC CHIP 10uF 20% 6.3VC304 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC321 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC322 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC323 1-128-995-21 ELECT CHIP 100uF 20% 10V

C401 1-128-394-11 ELECT CHIP 220uF 20% 10VC404 1-164-360-11 CERAMIC CHIP 0.1uF 16VC405 1-164-360-11 CERAMIC CHIP 0.1uF 16VC406 1-164-360-11 CERAMIC CHIP 0.1uF 16VC424 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C451 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

< CONNECTOR >

CN102 1-770-706-21 CONNECTOR, FFC/FPC 23PCN301 1-770-425-51 CONNECTOR, FFC/FPC 16P

< IC >

IC201 8-753-246-30 IC CXD3014A-201RIC203 6-709-050-01 IC BH18LB1WG-TRIC402 6-705-808-01 IC BA5947FM-E2

< TRANSISTOR >

Q321 6-551-120-01 TRANSISTOR 2SA2119K

< RESISTOR >

R101 1-216-809-11 METAL CHIP 100 5% 1/10WR102 1-216-809-11 METAL CHIP 100 5% 1/10WR103 1-216-809-11 METAL CHIP 100 5% 1/10WR104 1-216-809-11 METAL CHIP 100 5% 1/10WR105 1-216-809-11 METAL CHIP 100 5% 1/10W

R107 1-216-809-11 METAL CHIP 100 5% 1/10WR108 1-216-809-11 METAL CHIP 100 5% 1/10W

BD83SAMP

52

HCD-GB3


R109 1-216-809-11 METAL CHIP 100 5% 1/10WR110 1-216-809-11 METAL CHIP 100 5% 1/10WR111 1-216-809-11 METAL CHIP 100 5% 1/10W

R112 1-216-809-11 METAL CHIP 100 5% 1/10WR113 1-216-809-11 METAL CHIP 100 5% 1/10WR201 1-216-295-91 SHORT CHIP 0R202 1-216-295-91 SHORT CHIP 0R203 1-500-445-21 FERRITE, EMI (SMD) (2012)

R207 1-216-295-91 SHORT CHIP 0R250 1-216-857-11 METAL CHIP 1M 5% 1/10WR252 1-216-833-11 METAL CHIP 10K 5% 1/10WR253 1-216-821-11 METAL CHIP 1K 5% 1/10WR254 1-216-833-11 METAL CHIP 10K 5% 1/10W

R255 1-216-821-11 METAL CHIP 1K 5% 1/10WR256 1-216-837-11 METAL CHIP 22K 5% 1/10WR257 1-216-845-11 METAL CHIP 100K 5% 1/10WR258 1-216-849-11 METAL CHIP 220K 5% 1/10WR260 1-216-864-11 SHORT CHIP 0

R265 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR266 1-216-821-11 METAL CHIP 1K 5% 1/10WR267 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR268 1-216-833-11 METAL CHIP 10K 5% 1/10WR270 1-216-821-11 METAL CHIP 1K 5% 1/10W

R271 1-216-857-11 METAL CHIP 1M 5% 1/10WR275 1-216-809-11 METAL CHIP 100 5% 1/10WR276 1-216-841-11 METAL CHIP 47K 5% 1/10WR277 1-216-809-11 METAL CHIP 100 5% 1/10WR278 1-216-809-11 METAL CHIP 100 5% 1/10W

R280 1-216-864-11 SHORT CHIP 0R291 1-216-809-11 METAL CHIP 100 5% 1/10WR292 1-216-809-11 METAL CHIP 100 5% 1/10WR321 1-216-789-11 METAL CHIP 2.2 5% 1/10WR322 1-216-789-11 METAL CHIP 2.2 5% 1/10W

R323 1-216-864-11 SHORT CHIP 0R324 1-216-845-11 METAL CHIP 100K 5% 1/10WR401 1-216-295-91 SHORT CHIP 0R421 1-216-864-11 SHORT CHIP 0R423 1-216-833-11 METAL CHIP 10K 5% 1/10W

R451 1-216-837-11 METAL CHIP 22K 5% 1/10WR452 1-216-833-11 METAL CHIP 10K 5% 1/10W

< VIBRATOR >

X201 1-795-101-21 VIBRATOR, CERAMIC (16.9344MHz)*************************************************************

A-1177-470-A JACK BOARD***********

< CAPACITOR >

C139 1-164-156-11 CERAMIC CHIP 0.1uF 25VC140 1-164-156-11 CERAMIC CHIP 0.1uF 25VC141 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC142 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

< JACK >

J102 1-815-629-11 JACK (PHONES)J105 1-566-822-51 JACK (AUDIO IN)

< JUMPER RESISTOR >

JR111 1-216-864-11 SHORT CHIP 0

< COIL >

L103 1-469-152-11 FERRITE, EMI (SMD) (2012)L104 1-469-152-11 FERRITE, EMI (SMD) (2012)L105 1-216-295-91 SHORT CHIP 0L106 1-216-295-91 SHORT CHIP 0

< RESISTOR >

R119 1-216-805-11 METAL CHIP 47 5% 1/10WR120 1-216-805-11 METAL CHIP 47 5% 1/10WR151 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR152 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR175 1-216-841-11 METAL CHIP 47K 5% 1/10W

R176 1-216-841-11 METAL CHIP 47K 5% 1/10W

< CABLE HOLDER >

WH171 1-819-972-11 HOLDER, CABLE 8P*************************************************************

A-1177-468-A MAIN BOARD, COMPLETE*********************

< CAPACITOR >

C101 1-128-550-11 ELECT 2200uF 20% 50VC102 1-128-550-11 ELECT 2200uF 20% 50VC105 1-165-621-91 CERAMIC CHIP 0.1uF 50VC106 1-165-621-91 CERAMIC CHIP 0.1uF 50VC111 1-126-933-11 ELECT 100uF 20% 16V

C112 1-126-943-11 ELECT 2200uF 20% 25VC113 1-126-942-61 ELECT 1000uF 20% 25VC114 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC115 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC116 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V

C121 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3VC130 1-126-923-91 ELECT 220uF 20% 10VC131 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC132 1-165-621-91 CERAMIC CHIP 0.1uF 50VC133 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C134 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC151 1-126-933-11 ELECT 100uF 20% 16VC152 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC153 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC155 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C156 1-164-156-11 CERAMIC CHIP 0.1uF 25VC158 1-165-621-91 CERAMIC CHIP 0.1uF 50VC159 1-165-621-91 CERAMIC CHIP 0.1uF 50VC181 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC182 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C183 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC184 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC187 1-162-974-11 CERAMIC CHIP 0.01uF 50VC188 1-162-974-11 CERAMIC CHIP 0.01uF 50VC191 1-126-923-91 ELECT 220uF 20% 10V

C192 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC193 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

JACK MAINBD83S

53

HCD-GB3


C194 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC195 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC196 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C197 1-126-925-91 ELECT 470uF 20% 10VC198 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC401 1-126-956-91 ELECT 0.1uF 20% 50VC402 1-126-933-11 ELECT 100uF 20% 16VC403 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C404 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC405 1-126-956-91 ELECT 0.1uF 20% 50VC406 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC407 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC408 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V

C409 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC410 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC412 1-126-925-91 ELECT 470uF 20% 10VC413 1-126-933-11 ELECT 100uF 20% 16VC415 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C416 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC417 1-126-956-91 ELECT 0.1uF 20% 50VC418 1-126-956-91 ELECT 0.1uF 20% 50VC421 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC431 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V

C432 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10VC433 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC434 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC437 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC438 1-162-962-11 CERAMIC CHIP 470PF 10% 50V

C501 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC502 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC503 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC504 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC505 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

C506 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC507 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC508 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC509 1-126-933-11 ELECT 100uF 20% 16VC510 1-126-933-11 ELECT 100uF 20% 16V

C511 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC512 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC513 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC514 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC515 1-162-923-11 CERAMIC CHIP 47PF 5% 50V

C522 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC523 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC524 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC525 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC526 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C527 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC528 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC529 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC530 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC531 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C532 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC543 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC544 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC551 1-126-965-91 ELECT 22uF 20% 50VC561 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C562 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC564 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC565 1-115-156-11 CERAMIC CHIP 1uF 10VC566 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC567 1-137-391-11 MYLAR 0.0047uF 5% 100V

C568 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC570 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC571 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC573 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC574 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V

C577 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC801 1-126-933-11 ELECT 100uF 20% 16VC802 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC803 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC804 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C806 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC807 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC809 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC810 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10VC811 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C812 1-164-156-11 CERAMIC CHIP 0.1uF 25VC813 1-126-923-91 ELECT 220uF 20% 10VC814 1-164-156-11 CERAMIC CHIP 0.1uF 25VC815 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC816 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V

C817 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC818 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC819 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC820 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC821 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

C822 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC823 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC824 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC825 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC826 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C827 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC828 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC829 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC830 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC831 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V

C832 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3VC833 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3VC834 1-126-923-91 ELECT 220uF 20% 10VC835 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10VC836 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V

C838 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC839 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC840 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3VC841 1-126-965-91 ELECT 22uF 20% 50VC847 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C848 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC851 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC852 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC853 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC854 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V

C855 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC856 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V

MAIN

54

HCD-GB3


C873 1-162-907-11 CERAMIC CHIP 2PF 0.25PF 50V

< FILTER >

CF801 1-795-426-11 FILTER, CERAMIC (107MHz)CF802 1-579-554-21 FILTER, CERAMIC (107MHz)CF803 1-781-962-21 FILTER, CERAMIC (450kHz)

< CONNECTOR >

CNP151 1-819-136-11 PIN, CONNECTOR 8PCNP171 1-815-449-11 PIN, CONNECTOR (PWB) 8PCNP501 1-815-447-11 PIN, CONNECTOR (PWB) 6PCNP502 1-815-444-11 PIN, CONNECTOR (PWB) 3P

* CNP802 1-506-680-11 PLUG, CONNECTOR (2.5MM) 3P(ANTENNA FM/AM)

CNS104 1-779-291-11 CONNECTOR, FFC (LIF (NON-ZIF)) 23PCNS111 1-779-297-11 CONNECTOR, FFC (LIF (NON-ZIF)) 29P

< DIODE >

D107 6-501-046-01 DIODE 1N5402-F46D108 6-501-046-01 DIODE 1N5402-F46D109 6-501-046-01 DIODE 1N5402-F46D110 6-501-046-01 DIODE 1N5402-F46D111 8-719-063-79 DIODE 1N4002B

D113 8-719-063-79 DIODE 1N4002BD131 8-719-063-79 DIODE 1N4002BD132 8-719-000-07 DIODE MC2836D154 6-500-335-01 DIODE MC2838-T112-1D156 8-719-000-07 DIODE MC2836

D191 8-719-063-79 DIODE 1N4002BD192 8-719-063-79 DIODE 1N4002BD193 6-501-164-01 DIODE UDZW-TE17-3.9BD501 6-500-848-01 DIODE MC2840-T112-1D502 6-500-848-01 DIODE MC2840-T112-1

D503 6-500-848-01 DIODE MC2840-T112-1D504 6-500-848-01 DIODE MC2840-T112-1D505 6-500-848-01 DIODE MC2840-T112-1D506 6-500-848-01 DIODE MC2840-T112-1D508 6-501-193-01 DIODE 1SS355WTE-17

D510 6-501-193-01 DIODE 1SS355WTE-17D511 6-501-193-01 DIODE 1SS355WTE-17D802 6-501-369-01 DIODE SV230-TB-ED803 6-501-369-01 DIODE SV230-TB-ED812 8-719-062-51 DIODE 1PS226-115

D813 8-719-062-51 DIODE 1PS226-115D814 8-719-062-51 DIODE 1PS226-115D851 6-501-142-01 DIODE SVC347A-TL-ED901 6-500-335-01 DIODE MC2838-T112-1

< IC >

IC401 6-702-895-01 IC BD3881FVIC402 8-759-909-71 IC BA4558F-E2IC801 6-708-840-01 IC LV23003VA

< JACK >

J101 1-536-708-81 TERMINAL BOARD, PUSH (4P)(SPEAKER IMPEDANCE 6Ω)

< JUMPER RESISTOR >

JR101 1-216-864-11 SHORT CHIP 0JR102 1-216-864-11 SHORT CHIP 0JR103 1-216-864-11 SHORT CHIP 0JR104 1-216-864-11 SHORT CHIP 0JR105 1-216-864-11 SHORT CHIP 0


JR801 1-216-864-11 SHORT CHIP 0JR802 1-216-864-11 SHORT CHIP 0JR803 1-216-864-11 SHORT CHIP 0

< COIL >

L101 1-456-107-11 COIL, AIR-COREL102 1-456-107-11 COIL, AIR-COREL501 1-456-094-11 TRANSFORMER, BIAS OSCILLATIONL803 1-433-741-11 TRANSFORMER, IFL804 1-457-163-11 COIL, AIR-CORE

L805 1-457-162-11 COIL, AIR-COREL806 1-457-168-11 COIL, DETL851 1-457-161-11 COIL, AM ANTENNAL852 1-456-596-11 COIL, MW OSC

< TRANSISTOR >

Q102 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ121 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ122 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ131 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ132 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

Q133 8-729-027-38 TRANSISTOR RT1P441C-TP-1Q134 1-801-806-11 TRANSISTOR RT1N441C-TP-1Q135 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ137 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ138 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

Q151 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ152 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ153 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ154 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ191 8-729-036-86 TRANSISTOR KTC3203Y-AT

Q192 8-729-036-86 TRANSISTOR KTC3203Y-ATQ193 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ501 8-729-040-76 TRANSISTOR KTA1273-Y-ATQ502 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ507 8-729-119-78 TRANSISTOR 2SC1740S-RT

Q508 8-729-119-78 TRANSISTOR 2SC1740S-RTQ801 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ802 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ803 6-550-304-01 TRANSISTOR 2SC5477-T122-1

< RESISTOR >

R101 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR103 1-216-841-11 METAL CHIP 47K 5% 1/10WR104 1-216-841-11 METAL CHIP 47K 5% 1/10WR105 1-216-841-11 METAL CHIP 47K 5% 1/10WR106 1-216-837-11 METAL CHIP 22K 5% 1/10W

MAIN

55

HCD-GB3


R107 1-216-837-11 METAL CHIP 22K 5% 1/10WR108 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR109 1-216-789-11 METAL CHIP 2.2 5% 1/10WR110 1-216-789-11 METAL CHIP 2.2 5% 1/10WR111 1-216-809-11 METAL CHIP 100 5% 1/10W

R112 1-216-809-11 METAL CHIP 100 5% 1/10WR113 1-216-809-11 METAL CHIP 100 5% 1/10WR114 1-216-809-11 METAL CHIP 100 5% 1/10WR115 1-247-807-31 CARBON 100 5% 1/4WR116 1-247-807-31 CARBON 100 5% 1/4W

R117 1-247-807-31 CARBON 100 5% 1/4WR118 1-247-807-31 CARBON 100 5% 1/4WR121 1-216-849-11 METAL CHIP 220K 5% 1/10WR123 1-216-853-11 METAL CHIP 470K 5% 1/10WR124 1-216-809-11 METAL CHIP 100 5% 1/10W

R125 1-216-837-11 METAL CHIP 22K 5% 1/10WR127 1-249-401-11 CARBON 47 5% 1/4WR128 1-249-401-11 CARBON 47 5% 1/4WR129 1-249-401-11 CARBON 47 5% 1/4WR130 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R131 1-216-841-11 METAL CHIP 47K 5% 1/10WR132 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR133 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR134 1-216-817-11 METAL CHIP 470 5% 1/10WR135 1-216-817-11 METAL CHIP 470 5% 1/10W

R136 1-216-817-11 METAL CHIP 470 5% 1/10WR137 1-216-817-11 METAL CHIP 470 5% 1/10WR138 1-216-817-11 METAL CHIP 470 5% 1/10WR139 1-216-817-11 METAL CHIP 470 5% 1/10WR140 1-216-817-11 METAL CHIP 470 5% 1/10W

R142 1-216-845-11 METAL CHIP 100K 5% 1/10WR144 1-216-817-11 METAL CHIP 470 5% 1/10WR145 1-216-817-11 METAL CHIP 470 5% 1/10WR146 1-216-817-11 METAL CHIP 470 5% 1/10WR147 1-216-817-11 METAL CHIP 470 5% 1/10W

R148 1-216-817-11 METAL CHIP 470 5% 1/10WR149 1-216-817-11 METAL CHIP 470 5% 1/10WR150 1-216-817-11 METAL CHIP 470 5% 1/10WR153 1-216-849-11 METAL CHIP 220K 5% 1/10WR154 1-216-849-11 METAL CHIP 220K 5% 1/10W

R155 1-216-841-11 METAL CHIP 47K 5% 1/10WR156 1-216-833-11 METAL CHIP 10K 5% 1/10WR157 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR158 1-216-833-11 METAL CHIP 10K 5% 1/10WR159 1-216-833-11 METAL CHIP 10K 5% 1/10W

R160 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR161 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR162 1-216-809-11 METAL CHIP 100 5% 1/10WR163 1-216-833-11 METAL CHIP 10K 5% 1/10WR164 1-216-837-11 METAL CHIP 22K 5% 1/10W



R172 1-216-833-11 METAL CHIP 10K 5% 1/10WR174 1-216-809-11 METAL CHIP 100 5% 1/10WR177 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R178 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR179 1-216-864-11 SHORT CHIP 0R180 1-216-864-11 SHORT CHIP 0R181 1-216-797-11 METAL CHIP 10 5% 1/10WR182 1-216-797-11 METAL CHIP 10 5% 1/10W

R183 1-216-797-11 METAL CHIP 10 5% 1/10WR184 1-216-797-11 METAL CHIP 10 5% 1/10WR185 1-247-807-31 CARBON 100 5% 1/4WR186 1-247-807-31 CARBON 100 5% 1/4WR188 1-216-837-11 METAL CHIP 22K 5% 1/10W

R189 1-216-837-11 METAL CHIP 22K 5% 1/10WR191 1-216-821-11 METAL CHIP 1K 5% 1/10WR192 1-216-845-11 METAL CHIP 100K 5% 1/10WR193 1-216-845-11 METAL CHIP 100K 5% 1/10WR194 1-249-401-11 CARBON 47 5% 1/4W

R195 1-216-809-11 METAL CHIP 100 5% 1/10WR196 1-216-809-11 METAL CHIP 100 5% 1/10WR197 1-249-401-11 CARBON 47 5% 1/4WR198 1-249-401-11 CARBON 47 5% 1/4WR199 1-247-807-31 CARBON 100 5% 1/4W

R200 1-247-807-31 CARBON 100 5% 1/4WR402 1-216-809-11 METAL CHIP 100 5% 1/10WR403 1-216-821-11 METAL CHIP 1K 5% 1/10WR404 1-216-813-11 METAL CHIP 220 5% 1/10WR405 1-216-813-11 METAL CHIP 220 5% 1/10W

R406 1-216-821-11 METAL CHIP 1K 5% 1/10WR410 1-216-845-11 METAL CHIP 100K 5% 1/10WR411 1-216-821-11 METAL CHIP 1K 5% 1/10WR412 1-216-813-11 METAL CHIP 220 5% 1/10WR419 1-216-837-11 METAL CHIP 22K 5% 1/10W

R420 1-216-837-11 METAL CHIP 22K 5% 1/10WR423 1-216-833-11 METAL CHIP 10K 5% 1/10WR424 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR425 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR426 1-216-833-11 METAL CHIP 10K 5% 1/10W


R434 1-216-837-11 METAL CHIP 22K 5% 1/10WR439 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR440 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR441 1-216-841-11 METAL CHIP 47K 5% 1/10WR442 1-216-841-11 METAL CHIP 47K 5% 1/10W

R501 1-216-809-11 METAL CHIP 100 5% 1/10WR502 1-216-809-11 METAL CHIP 100 5% 1/10WR503 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR504 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR505 1-216-833-11 METAL CHIP 10K 5% 1/10W

R506 1-216-833-11 METAL CHIP 10K 5% 1/10WR507 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR508 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR509 1-216-853-11 METAL CHIP 470K 5% 1/10WR510 1-216-853-11 METAL CHIP 470K 5% 1/10W

MAIN

56

HCD-GB3


R511 1-216-861-11 METAL CHIP 2.2M 5% 1/10WR512 1-216-861-11 METAL CHIP 2.2M 5% 1/10WR513 1-216-809-11 METAL CHIP 100 5% 1/10WR514 1-216-809-11 METAL CHIP 100 5% 1/10WR515 1-216-805-11 METAL CHIP 47 5% 1/10W

R516 1-216-805-11 METAL CHIP 47 5% 1/10WR517 1-216-845-11 METAL CHIP 100K 5% 1/10WR518 1-216-845-11 METAL CHIP 100K 5% 1/10WR519 1-216-845-11 METAL CHIP 100K 5% 1/10WR520 1-216-845-11 METAL CHIP 100K 5% 1/10W


R526 1-216-833-11 METAL CHIP 10K 5% 1/10WR527 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR528 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR529 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR530 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R531 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR532 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR533 1-216-833-11 METAL CHIP 10K 5% 1/10WR534 1-216-833-11 METAL CHIP 10K 5% 1/10WR535 1-216-805-11 METAL CHIP 47 5% 1/10W

R536 1-216-805-11 METAL CHIP 47 5% 1/10WR541 1-216-837-11 METAL CHIP 22K 5% 1/10WR542 1-216-833-11 METAL CHIP 10K 5% 1/10WR543 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR544 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R545 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR560 1-216-864-11 SHORT CHIP 0R561 1-216-793-11 METAL CHIP 4.7 5% 1/10WR564 1-216-833-11 METAL CHIP 10K 5% 1/10WR565 1-216-833-11 METAL CHIP 10K 5% 1/10W


R572 1-216-845-11 METAL CHIP 100K 5% 1/10WR573 1-216-833-11 METAL CHIP 10K 5% 1/10WR574 1-216-809-11 METAL CHIP 100 5% 1/10WR575 1-216-837-11 METAL CHIP 22K 5% 1/10WR576 1-216-833-11 METAL CHIP 10K 5% 1/10W

R577 1-216-845-11 METAL CHIP 100K 5% 1/10WR578 1-216-833-11 METAL CHIP 10K 5% 1/10WR579 1-216-833-11 METAL CHIP 10K 5% 1/10WR581 1-216-841-11 METAL CHIP 47K 5% 1/10WR582 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R583 1-216-841-11 METAL CHIP 47K 5% 1/10WR584 1-216-849-11 METAL CHIP 220K 5% 1/10WR801 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR802 1-216-797-11 METAL CHIP 10 5% 1/10WR803 1-216-797-11 METAL CHIP 10 5% 1/10W

R804 1-216-864-11 SHORT CHIP 0R805 1-216-845-11 METAL CHIP 100K 5% 1/10W

R806 1-216-864-11 SHORT CHIP 0R807 1-216-845-11 METAL CHIP 100K 5% 1/10WR808 1-216-833-11 METAL CHIP 10K 5% 1/10W

R809 1-216-821-11 METAL CHIP 1K 5% 1/10WR810 1-216-857-11 METAL CHIP 1M 5% 1/10WR811 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR812 1-216-817-11 METAL CHIP 470 5% 1/10WR813 1-216-833-11 METAL CHIP 10K 5% 1/10W

R814 1-216-809-11 METAL CHIP 100 5% 1/10WR815 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR816 1-216-833-11 METAL CHIP 10K 5% 1/10WR817 1-216-833-11 METAL CHIP 10K 5% 1/10WR818 1-216-841-11 METAL CHIP 47K 5% 1/10W

R819 1-216-833-11 METAL CHIP 10K 5% 1/10WR820 1-216-821-11 METAL CHIP 1K 5% 1/10WR821 1-216-813-11 METAL CHIP 220 5% 1/10WR822 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR823 1-216-809-11 METAL CHIP 100 5% 1/10W

R824 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR825 1-216-817-11 METAL CHIP 470 5% 1/10WR826 1-216-809-11 METAL CHIP 100 5% 1/10WR827 1-216-809-11 METAL CHIP 100 5% 1/10WR828 1-216-805-11 METAL CHIP 47 5% 1/10W

R829 1-216-845-11 METAL CHIP 100K 5% 1/10WR830 1-216-841-11 METAL CHIP 47K 5% 1/10WR831 1-216-813-11 METAL CHIP 220 5% 1/10WR833 1-216-833-11 METAL CHIP 10K 5% 1/10WR834 1-216-837-11 METAL CHIP 22K 5% 1/10W

R835 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR836 1-216-833-11 METAL CHIP 10K 5% 1/10WR837 1-216-833-11 METAL CHIP 10K 5% 1/10WR838 1-216-833-11 METAL CHIP 10K 5% 1/10WR839 1-216-809-11 METAL CHIP 100 5% 1/10W

R840 1-216-837-11 METAL CHIP 22K 5% 1/10WR841 1-216-809-11 METAL CHIP 100 5% 1/10WR842 1-216-841-11 METAL CHIP 47K 5% 1/10WR843 1-216-853-11 METAL CHIP 470K 5% 1/10WR844 1-216-797-11 METAL CHIP 10 5% 1/10W

R845 1-216-801-11 METAL CHIP 22 5% 1/10WR846 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR848 1-216-821-11 METAL CHIP 1K 5% 1/10WR849 1-216-837-11 METAL CHIP 22K 5% 1/10WR850 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R851 1-216-837-11 METAL CHIP 22K 5% 1/10WR852 1-216-801-11 METAL CHIP 22 5% 1/10WR853 1-216-845-11 METAL CHIP 100K 5% 1/10WR855 1-216-853-11 METAL CHIP 470K 5% 1/10WR859 1-216-833-11 METAL CHIP 10K 5% 1/10W

R860 1-216-833-11 METAL CHIP 10K 5% 1/10WR863 1-216-837-11 METAL CHIP 22K 5% 1/10WR901 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR902 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

< RELAY >

RY131 1-755-307-11 RELAY

MAIN

57

HCD-GB3


< SWITCH >

SW501 1-762-369-11 SWITCH, SLIDE (a/H)

< CABLE HOLDER >

WH101 1-824-030-21 HOLDER, CABLE 5PWH102 1-824-030-21 HOLDER, CABLE 5PWH203 1-824-027-21 HOLDER, CABLE 3PWH901 1-824-029-21 HOLDER, CABLE 4P

< VIBRATOR >

X801 1-767-388-21 VIBRATOR, CRYSTAL (75kHz)*************************************************************

A-1177-458-A PANEL BOARD, COMPLETE (E2)A-1177-460-A PANEL BOARD, COMPLETE (MX)A-1177-461-A PANEL BOARD, COMPLETE (AR)

**********************

2-669-704-01 GUIDE, LCD

< CAPACITOR >

C671 1-126-965-91 ELECT 22uF 20% 50VC672 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC701 1-164-156-11 CERAMIC CHIP 0.1uF 25VC702 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC703 1-124-584-00 ELECT 100uF 20% 10V

C704 1-119-941-91 ELECT 470uF 20% 6.3VC705 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC706 1-164-156-11 CERAMIC CHIP 0.1uF 25VC707 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC708 1-162-923-11 CERAMIC CHIP 47PF 5% 50V

C709 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC710 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10VC711 1-164-156-11 CERAMIC CHIP 0.1uF 25VC712 1-164-156-11 CERAMIC CHIP 0.1uF 25VC713 1-162-923-11 CERAMIC CHIP 47PF 5% 50V

C714 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC715 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC716 1-164-156-11 CERAMIC CHIP 0.1uF 25VC717 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC718 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C719 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC721 1-126-925-91 ELECT 470uF 20% 10VC722 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC723 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC724 1-162-923-11 CERAMIC CHIP 47PF 5% 50V

C725 1-164-156-11 CERAMIC CHIP 0.1uF 25VC726 1-164-156-11 CERAMIC CHIP 0.1uF 25VC727 1-164-156-11 CERAMIC CHIP 0.1uF 25VC728 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC729 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C730 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC731 1-164-156-11 CERAMIC CHIP 0.1uF 25VC732 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC733 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC734 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C735 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC736 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C737 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC738 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC739 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C741 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC742 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC743 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC746 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC747 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C750 1-126-963-11 ELECT 4.7uF 20% 50V

< CONNECTOR >

CNS671 1-784-735-11 CONNECTOR, FFC 13PCNS701 1-779-297-11 CONNECTOR, FFC (LIF (NON-ZIF)) 29P

< DIODE >

D509 6-501-193-01 DIODE 1SS355WTE-17D701 6-501-163-01 DIODE UDZW-TE17-3.6BD702 8-719-000-07 DIODE MC2836

< IC >

IC701 6-806-467-01 IC MB90802PF-G-113E1IC702 6-704-046-01 IC BU2099FVIC703 6-600-446-01 IC RPM7240-H18

< JUMPER RESISTOR >





< COIL >

L701 1-216-864-11 SHORT CHIP 0

< LIQUID CRYSTAL DISPLAY >

LCD702 1-805-973-21 DISPLAY PANEL, LIQUID CRYSTAL

< LED >

LED701 6-501-479-01 DIODE 1L0341Y23E0CA602 (BACKLIGHT)LED702 8-719-060-44 DIODE SLR-342VRT32 (STANDBY)LED703 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)LED704 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)

PANELMAIN

58

HCD-GB3


LED705 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)

LED706 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)LED707 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)LED709 6-501-479-01 DIODE 1L0341Y23E0CA602 (BACKLIGHT)

< TRANSISTOR >

Q661 1-801-806-11 TRANSISTOR RT1N441C-TP-1Q662 8-729-040-76 TRANSISTOR KTA1273-Y-ATQ663 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ664 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ665 8-729-024-43 TRANSISTOR 2SA1365-T112-1EF

Q666 8-729-047-62 TRANSISTOR 2SC3440-T12-1FQ667 8-729-024-43 TRANSISTOR 2SA1365-T112-1EFQ668 8-729-047-62 TRANSISTOR 2SC3440-T12-1FQ669 8-729-024-43 TRANSISTOR 2SA1365-T112-1EFQ670 8-729-047-62 TRANSISTOR 2SC3440-T12-1F

Q671 8-729-024-43 TRANSISTOR 2SA1365-T112-1EFQ672 8-729-047-62 TRANSISTOR 2SC3440-T12-1FQ701 8-729-600-22 TRANSISTOR 2SA1235TP-1EFQ702 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ703 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF

Q704 1-801-806-11 TRANSISTOR RT1N441C-TP-1Q705 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ706 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ707 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ709 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF

Q710 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF

< RESISTOR >



R662 1-216-841-11 METAL CHIP 47K 5% 1/10WR663 1-216-841-11 METAL CHIP 47K 5% 1/10WR664 1-216-841-11 METAL CHIP 47K 5% 1/10WR665 1-216-841-11 METAL CHIP 47K 5% 1/10WR666 1-216-817-11 METAL CHIP 470 5% 1/10W

R667 1-216-817-11 METAL CHIP 470 5% 1/10WR668 1-216-809-11 METAL CHIP 100 5% 1/10WR669 1-216-841-11 METAL CHIP 47K 5% 1/10WR670 1-216-817-11 METAL CHIP 470 5% 1/10WR671 1-216-817-11 METAL CHIP 470 5% 1/10W


R677 1-216-837-11 METAL CHIP 22K 5% 1/10WR678 1-216-809-11 METAL CHIP 100 5% 1/10WR679 1-216-837-11 METAL CHIP 22K 5% 1/10W


R682 1-216-849-11 METAL CHIP 220K 5% 1/10WR683 1-216-841-11 METAL CHIP 47K 5% 1/10WR684 1-216-789-11 METAL CHIP 2.2 5% 1/10WR685 1-216-837-11 METAL CHIP 22K 5% 1/10WR686 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R687 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR688 1-216-789-11 METAL CHIP 2.2 5% 1/10WR689 1-216-833-11 METAL CHIP 10K 5% 1/10WR690 1-216-821-11 METAL CHIP 1K 5% 1/10WR691 1-216-841-11 METAL CHIP 47K 5% 1/10W

R692 1-216-817-11 METAL CHIP 470 5% 1/10WR693 1-216-841-11 METAL CHIP 47K 5% 1/10WR694 1-216-817-11 METAL CHIP 470 5% 1/10WR695 1-216-817-11 METAL CHIP 470 5% 1/10WR696 1-216-821-11 METAL CHIP 1K 5% 1/10W

R697 1-216-821-11 METAL CHIP 1K 5% 1/10WR698 1-216-817-11 METAL CHIP 470 5% 1/10WR699 1-216-821-11 METAL CHIP 1K 54% 1/10WR700 1-216-821-11 METAL CHIP 1K 5% 1/10WR701 1-216-821-11 METAL CHIP 1K 5% 1/10W

R702 1-216-821-11 METAL CHIP 1K 5% 1/10WR703 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR704 1-216-821-11 METAL CHIP 1K 5% 1/10WR705 1-216-821-11 METAL CHIP 1K 5% 1/10WR706 1-216-821-11 METAL CHIP 1K 5% 1/10W

R707 1-216-821-11 METAL CHIP 1K 5% 1/10WR708 1-216-821-11 METAL CHIP 1K 5% 1/10WR709 1-216-821-11 METAL CHIP 1K 5% 1/10WR710 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR711 1-216-837-11 METAL CHIP 22K 5% 1/10W

R712 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR713 1-216-833-11 METAL CHIP 10K 5% 1/10WR714 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR715 1-216-821-11 METAL CHIP 1K 5% 1/10WR716 1-216-821-11 METAL CHIP 1K 5% 1/10W


R723 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR724 1-216-821-11 METAL CHIP 1K 5% 1/10WR725 1-216-821-11 METAL CHIP 1K 5% 1/10WR726 1-216-845-11 METAL CHIP 100K 5% 1/10WR728 1-216-833-11 METAL CHIP 10K 5% 1/10W



PANEL

59

HCD-GB3


R743 1-216-821-11 METAL CHIP 1K 5% 1/10WR744 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR745 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR746 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR747 1-216-825-11 METAL CHIP 2.2K 5% 1/10W


R754 1-216-833-11 METAL CHIP 10K 5% 1/10WR755 1-216-864-11 SHORT CHIP 0R756 1-216-821-11 METAL CHIP 1K 5% 1/10WR757 1-216-845-11 METAL CHIP 100K 5% 1/10WR758 1-216-821-11 METAL CHIP 1K 5% 1/10W


R764 1-216-837-11 METAL CHIP 22K 5% 1/10WR765 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR766 1-216-837-11 METAL CHIP 22K 5% 1/10WR767 1-216-849-11 METAL CHIP 220K 5% 1/10WR768 1-216-833-11 METAL CHIP 10K 5% 1/10W

R769 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR770 1-216-841-11 METAL CHIP 47K 5% 1/10WR771 1-216-821-11 METAL CHIP 1K 5% 1/10WR772 1-216-817-11 METAL CHIP 470 5% 1/10WR773 1-216-833-11 METAL CHIP 10K 5% 1/10W


R779 1-216-809-11 METAL CHIP 100 5% 1/10WR780 1-216-833-11 METAL CHIP 10K 5% 1/10WR781 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR782 1-216-837-11 METAL CHIP 22K 5% 1/10WR783 1-216-837-11 METAL CHIP 22K 5% 1/10W

R784 1-216-845-11 METAL CHIP 100K 5% 1/10WR785 1-216-833-11 METAL CHIP 10K 5% 1/10WR786 1-216-809-11 METAL CHIP 100 5% 1/10WR787 1-216-805-11 METAL CHIP 47 5% 1/10WR788 1-216-864-11 SHORT CHIP 0



R799 1-216-837-11 METAL CHIP 22K 5% 1/10WR800 1-216-849-11 METAL CHIP 220K 5% 1/10WR854 1-216-821-11 METAL CHIP 1K 5% 1/10W

R856 1-216-833-11 METAL CHIP 10K 5% 1/10WR857 1-216-813-11 METAL CHIP 220 5% 1/10W

R861 1-216-813-11 METAL CHIP 220 5% 1/10WR862 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR864 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR865 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR866 1-216-821-11 METAL CHIP 1K 5% 1/10W

< SWITCH >

SW699 1-418-859-21 ENCODER, ROTARY (– +)SW700 1-786-417-11 ENCODER, ROTARY ( VOLUME )SW701 1-762-875-21 SWITCH, KEYBOARD (?/1)SW702 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)SW703 1-762-875-21 SWITCH, KEYBOARD (TUNING –/lj)

SW704 1-762-875-21 SWITCH, KEYBOARD (CD7)SW705 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)SW706 1-762-875-21 SWITCH, KEYBOARD (DSGX)SW708 1-762-875-21 SWITCH, KEYBOARD (–/ )SW709 1-762-875-21 SWITCH, KEYBOARD (1 DISC)

SW710 1-762-875-21 SWITCH, KEYBOARD (2 DISC)SW711 1-762-875-21 SWITCH, KEYBOARD (s)SW712 1-762-875-21 SWITCH, KEYBOARD (TUNING+/JL)SW713 1-762-875-21 SWITCH, KEYBOARD (EQ)SW714 1-762-875-21 SWITCH, KEYBOARD

(PLAY MODE/TUNING MODE)

SW715 1-762-875-21 SWITCH, KEYBOARD (DIMMER/ILLUM)SW716 1-762-875-21 SWITCH, KEYBOARD (+/ )SW719 1-762-875-21 SWITCH, KEYBOARD (3 DISC)SW720 1-762-875-21 SWITCH, KEYBOARD (ENTER)SW721 1-762-875-21 SWITCH, KEYBOARD(Z)

SW722 1-762-875-21 SWITCH, KEYBOARD (AUDIO IN)SW723 1-762-875-21 SWITCH, KEYBOARD (TAPE)SW724 1-762-875-21 SWITCH, KEYBOARD (DISC SKIP/EX-CHANGE)

< VIBRATOR >

X701 1-760-252-12 VIBRATOR, CRYSTAL (32768Hz)X702 1-795-054-51 VIBRATOR, CERAMIC (4.19MHz)

*************************************************************

A-1177-464-A POWER BOARD, COMPLETE (E2)A-1177-466-A POWER BOARD, COMPLETE (MX)A-1177-467-A POWER BOARD, COMPLETE (AR)

**********************

< CAPACITOR >

0C051 1-165-621-91 CERAMIC CHIP 0.1uF 50VC053 1-100-385-91 CERAMIC CHIP 0.47uF 25VC054 1-100-385-91 CERAMIC CHIP 0.47uF 25VC055 1-100-385-91 CERAMIC CHIP 0.47uF 25V

< DIODE >

D051 6-500-334-01 DIODE MC2836-T112-1D052 6-500-335-01 DIODE MC2838-T112-1

< FUSE HOLDER>

FH001 1-533-233-31 FUSE HOLDERFH002 1-533-233-31 FUSE HOLDER

PANEL POWER


60

HCD-GB3

< COIL >

0L001 1-402-663-11 TRANSFORMER, LINE FILTER (LFT)

< TRANSFORMER >

0PT002 1-443-913-11 TRANSFORMER, POWER

< RESISTOR >

R051 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR052 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

< RELAY >

0RY002 1-755-496-11 RELAY

< SWITCH >

0S001 1-786-408-11 SELECTOR, VOLTAGE (SWS-2301)(VOLTAGE SELECTOR)(E2)

< CABLE HOLDER >

WH151 1-819-972-11 HOLDER, CABLE 8P*************************************************************

A-1177-471-A REG BOARD**********

< CAPACITOR >

C118 1-164-156-11 CERAMIC CHIP 0.1uF 25VC119 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

< IC >

IC101 6-700-830-01 IC KIA7809API

< CABLE HOLDER >

WH103 1-824-027-21 HOLDER, CABLE 3P*************************************************************

MISCELLANEOUS**************

6 1-787-319-12 FAN, DC69 1-832-657-21 CABLE, FLEXIBLE FLAT (29 CORE)107 1-832-837-21 CABLE, FLEXIBLE FLAT (13 CORE)109 1-831-612-21 CABLE, FLEXIBLE FLAT (23 CORE)

0114 1-831-370-11 CORD, POWER (E2)

0114 1-832-228-11 CORD, POWER (AR)0114 1-832-377-11 CORD, POWER (MX)

159 1-797-575-11 DECK, MECHANICAL207 1-797-193-12 MECHANICAL, CD (DLM3A23-11)208 1-832-404-21 CABLE, FLEXIBLE FLAT (16 CORE)

0209 A-4735-357-A OP BASE ASSY (KSM-213DHAP/ZRP1)0F051 1-532-237-00 FUSE (T3.15AL/250V)0PT001 1-443-911-11 TRANSFORMER, POWER (E2, AR)0PT001 1-443-995-21 TRANSFORMER, POWER (MX)

S201 1-771-853-11 SWITCH, DETECTION (LIMIT)

REGPOWER

61

HCD-GB3

MEMO

HCD-GB3

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision

1.0 2006.05 New

Modular Sony HCD-GB3

Documents

Transcript of Modular Sony HCD-GB3