MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use...
Transcript of MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use...
![Page 1: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/1.jpg)
MINIMUM VENTILATION
3rd ROSS BREEDERS ANADOLU
INFORMATION SHARING MEETINGINFORMATION SHARING MEETING
October 2010
Bernard Green
![Page 2: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/2.jpg)
Discussion Topics
• Why we ventilate• When do we use minimum ventilation?• Bird requirements• Effects of temperature on oxygen demand• House sealing• Problems with poorly sealed houses• Problems with poorly sealed houses• Potential solutions to managing “older” houses• What is negative pressure• Why it is important• Minimum ventilation system• Minimum ventilation rate• Evaluating minimum ventilation
![Page 3: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/3.jpg)
Why We Ventilate
We ventilate to:• Create an air exchange• Control moisture levels• Control the heat load• Control the effective temperature
– (Temp + RH + air speed + bird age)– (Temp + RH + air speed + bird age)
• Supply oxygen• Remove harmful gases
![Page 4: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/4.jpg)
When Do We Use Min Vent?
• It can be used summer and winter• It is used anytime the actual house temperature is below
the required set point temperature for the birds• It is used when trying to maintain temperature, but still
putting the least amount of fresh air possible to maintain good air qualitygood air quality
• When the house temperature goes above the required set point temperature, then it is no longer in minimum ventilation mode
Set Point Temperature
Minimum Ventilation
Transition and Tunnel Ventilation
![Page 5: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/5.jpg)
Bird Requirements
• Warm floor during brooding• Good air quality (oxygen)• No temperature fluctuations• No drafts• No environmental stresses
• It doesn’t matter what type of housing you have!• These are the bird requirements
![Page 6: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/6.jpg)
Effects of Temperature onOxygen Demand
• Oxygen demand is lowest when the environment allows the chick to be in its thermoneutral zone
• As environmental temperature decreases, oxygen demand increases– You cannot compromise ventilation for temperature– You cannot compromise ventilation for temperature
• When environmental temperature increases and the bird begins to pant, oxygen demand increases
![Page 7: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/7.jpg)
House Sealing
• Regardless of the type of ventilation system, it is important to seal the house
• Reduces cold air leakage onto the birds• Gives better control over what is happening in house• Gives you more control over the incoming air• Reduces the effect of outside conditions• Reduces the effect of outside conditions• Increases the operating pressure of the whole house
![Page 8: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/8.jpg)
Problems With Poorly Sealed Houses
• Cold floors due to drafts• Cold drafts onto the chicks• Can’t maintain temperature in winter• Can’t ventilate effectively in winterStress, stocking density, uniformity, health, poor start
• Cold drafts onto the heater probe• Heat loss through the cracks and openings• No mixing of cold incoming air with warm inside air• Unable to access the heat in the peak of the roofHigh heating costs, can’t maintain temperature
![Page 9: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/9.jpg)
Poorly Sealed Catching Door(University of Georgia)
��
![Page 10: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/10.jpg)
Cold Air Leakage at Catching Door(University of Georgia)
��
![Page 11: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/11.jpg)
Sealed vs. Unsealed Side Wall(University of Georgia)
� �� �
![Page 12: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/12.jpg)
Chick Spread – Uninsulated, Poor Seal(University of Georgia)
��
![Page 13: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/13.jpg)
Chick Spread – Insulated, Sealed(University of Georgia)
��
![Page 14: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/14.jpg)
Always Seal Fans From The Outside
��
![Page 15: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/15.jpg)
Curtain Leakage, Cold Floors(University of Georgia)
![Page 16: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/16.jpg)
Curtain Leakage on a Windy Day(University of Georgia)
![Page 17: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/17.jpg)
Air Leakage Through a Poorly Sealed Curtain(University of Georgia)
![Page 18: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/18.jpg)
Potential Solutions toManaging “Older” Houses
• SEAL THE HOUSE!! (minimal cost, huge impact)– Make sure tunnel inlet/cooling pad seals well– Seal around doors, fans, windows– Seal eave of the roof– Seal all joints in the roof
• Roof insulation (summer and winter benefit)• Roof insulation (summer and winter benefit)• Review your heating system (type and capacity)
– Radiant heaters put the heat where the chicks need it
• Review your heat distribution• Preheat the house for at least 2-3 days• Make sure floors are warm before chicks arrive
![Page 19: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/19.jpg)
Potential Solutions toManaging “Older” Houses
Some ideas:• Use secondary inner curtain to protect the birds from
drafts• Fan Jet system – explained below• Install minimum ventilation – examples below
– Air cannons– Air cannons– Inlets (pressure balanced, winch operated)
• Circulation fans can help to distribute heat (but they are NOT a substitute for minimum ventilation)
![Page 20: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/20.jpg)
Radiant Heating(University of Georgia)
Puts heat where needed, on the floor
![Page 21: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/21.jpg)
Internal Curtain
Internal CurtainInternal Curtain
Draft on chicksNo draft on chicks
![Page 22: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/22.jpg)
Fan Jet
Inlet Damper
![Page 23: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/23.jpg)
Fan Jet
![Page 24: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/24.jpg)
Fan Jet System
Fan Jet Plastic Tube
Exhaust Fan
![Page 25: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/25.jpg)
Fan Jet System
Advantages:• “Positive pressure” system• House does not have to be extremely well sealed• Fan jet runs continuously → good mixing of air and heat• Incoming air directed up away from birds• Heating system can be located at FJ for distribution• Heating system can be located at FJ for distribution• Relatively cheap systemDisadvantages:• May not be able to provide enough min vent for whole
cycle• Depends on stocking density, weight
![Page 26: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/26.jpg)
Air Cannons
![Page 27: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/27.jpg)
Pressure Balanced Inlet
![Page 28: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/28.jpg)
Air Cannons, Pressure Inlets
Advantages:• Quite an effective minimum ventilation system• Fairly cost effective – cheap “inlets” (Ø90mm pipe)• Curtains stay closed• Mixes incoming air with warm house airDisadvantages:Disadvantages:• System works on negative pressure, so…• House must be well sealed, or else……• House may get colder than before, chicks more stressed• Do not take this approach unless house can be well
sealed• Requires ventilation controller or cycle timer
![Page 29: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/29.jpg)
How Many Air Cannons?
• First, remember that air cannons are only for bare minimum ventilation
• They are not there for transitional ventilation• Don’t try to calculate the number of air cannons
– The number will usually be very big
• Suggestion:• Suggestion:– Install one in each bay on both sides of the house– Install two in each corner of the house– Check the operating pressure– Decide if more air cannons are required
![Page 30: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/30.jpg)
Hot Air
Poor Air Cannon Installation Examples
![Page 31: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/31.jpg)
Bringing in Cold Air
Valuable Heat Wasted
Chicks chilled, wet litter
Negative Pressure VentilationClosed Environment Houses
![Page 32: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/32.jpg)
What is Negative Pressure?
• When a fan tries to extract more air from a house than is allowed to enter the house
• When this happens air rushes in through inlets to replace the exhausted air
• Just because a fan is running, doesn’t mean there i s a negative pressurea negative pressure
![Page 33: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/33.jpg)
Side curtain full open, air short-cuts to fans.
Ventilated
Not Ventilated
No Negative Pressure
![Page 34: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/34.jpg)
Side curtain slightly closed.Air still short-cuts to fans.
Ventilated
Not Ventilated
No Negative Pressure
![Page 35: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/35.jpg)
Side curtain more closed.Air drawn from further down house.
Ventilated
Not Ventilated
No Negative Pressure
![Page 36: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/36.jpg)
Side curtain almost closed.Air drawn from entire length of house.
Ventilated
Negative Pressure in Negative Pressure in Whole House
Ventilated
![Page 37: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/37.jpg)
Why Is It Important?
• With negative pressure, air enters evenly through every inlet (including areas of leakage)
• By spreading inlets evenly can get even fresh air• By restricting inlet size, can regulate incoming air speed• Control over how far the air goes into the house• Air should go to the middle (peak) of the roof• Air should go to the middle (peak) of the roof• Higher incoming speed allows better mixing• Pressure determines the incoming air speed• High P → high air speed, Low P → low air speed• The wider the house → higher the pressure• By using pressure, we can put the air where we want
it
![Page 38: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/38.jpg)
Air Movement Based on Pressure
Just right
�
Low PressureBit higher
Higher� �
�
![Page 39: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/39.jpg)
Minimum Ventilation System
• Cross ventilation is most successful• Fans and inlets located in the side walls• Hot air gathers in the peak of the roof• Fans operate on a cycle timer (ON/OFF)• Pressure controlled side wall inlets direct cold air to peak• Cold, moist air mixes and pushes hot, dry air down• Cold, moist air mixes and pushes hot, dry air down• Distributes fresh, warm air• Low air movement at bird level (<0,25ms-1)
![Page 40: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/40.jpg)
Cross Ventilation
![Page 41: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/41.jpg)
Proper Inlet Air Flow(University of Georgia)
4˚C
10˚C15˚C50%
27˚C
10˚C75%
50%
![Page 42: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/42.jpg)
Inlet Air Flow(University of Georgia)
![Page 43: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/43.jpg)
“Seeing” Air Movement
Pressure lowPressure better, but still lowPressure right�
� � � �
Pressure rightPressure too high
�
![Page 44: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/44.jpg)
Air Inlet Management
• Inlets should open at least 4-5cm during minimum ventilation
• Having fewer inlets opening correct amount is better than too many opening only a little
• Inlets must open equally• Inlets used must be evenly distributed• Inlets used must be evenly distributed• Must operate on static pressure• Air direction plate required if there are ceiling
obstructions• Good inlet management is important!• Take care when choosing new inlets
![Page 45: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/45.jpg)
System To Automatically Control Which Inlets Will O pen
![Page 46: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/46.jpg)
This Inlet Type Must Be Manually “Locked” Closed
![Page 47: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/47.jpg)
Air Flow Through Modern Inlet(University of Georgia)
![Page 48: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/48.jpg)
Air Flow Through “Older” Type Inlet(University of Georgia)
![Page 49: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/49.jpg)
Controller
• There are simple, and complicated controllers available• Choose one that you can use with confidence!• A complicated controller is worth nothing if you can’t use
it!
![Page 50: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/50.jpg)
Management/Stockmanship
• The above is not worth much without good management• Manager is link between birds and ventilation system• Must be able to “read” bird behaviour and other signs• Must be able to adjust vent to satisfy bird requirement• There is no ventilation system that does not require
managementmanagement
![Page 51: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/51.jpg)
Minimum Ventilation Rate
• Theoretical/calculated rates (??m3/hr/kg) are only a guide !
• The right minimum rate is critical for bird performance and to minimise heat consumption
• Extremely fine line between under and over ventilating• Evaluate your minimum ventilation setting every day• Evaluate your minimum ventilation setting every day• Minimum ventilation fans should operate on a cycle timer
![Page 52: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/52.jpg)
Example Calculation
Assume:• Bird weight = 200g ; 30 000 birds• Ventilation “factor” = 1,1m³/hr/kgCalculation:• Ventilation = 30 000 x 0,2kg x 1,1m³/hr/kg = 6 600m³/hrCycle Timer Setting:Cycle Timer Setting:• 5 minute cycle ; fan = 20 000m³/hr (at pressure)Time ON = (6600 x 5) ÷ (1 x 20000) = 1,65 minutesTime ON = 1 min 39 secTime OFF = 3 min 21 sec
![Page 53: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/53.jpg)
Evaluating Minimum Ventilation
• The only way is by visiting the house• Done preferably first thing each morning• Evaluate in the first 30 seconds:
– stuffiness– ammonia– condensation (walls, drinker pipes, steelwork)– condensation (walls, drinker pipes, steelwork)– bird comfort– “AIR QUALITY”– What you feel in first 30 seconds is what the chicken
lived with all night• “Purging” the house is unacceptable
![Page 54: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/54.jpg)
Remember!
• Minimum ventilation determines how much fresh air you bring into the house (air quality)
• Pressure is used to make the air go where you want it to when it enters the house
![Page 55: MINIMUM VENTILATION§لتهوية...Discussion Topics • Why we ventilate • When do we use minimum ventilation? • Bird requirements • Effects of temperature on oxygen demand](https://reader034.fdocuments.in/reader034/viewer/2022052520/607c93801201524918726305/html5/thumbnails/55.jpg)
THANK YOU