ME23486D
Transcript of ME23486D
-
8/8/2019 ME23486D
1/1
MERCEDES-BENZ C230 Kompressor
1995 to 1997
Notes and Illustrations
Engine and cooling systemType
Capacity (cm3
) / number of cylindersCompression ratio / pressure bar
Oil pressure bar
Oil temperature C
Valve clearance - inlet mm
Valve clearance - exhaust mm
Firing order
No 1 cylinder position
Thermostat opening temperature C
Radiator cap pressure bar
Fuel systemIdle speed - manual [auto] rpm
Fast idle speed - manual [auto] rpm
CO @ idle speed [3000 rpm] - see page VI %
HC @ idle speed [3000 rpm] - see page VI ppm
CO2 @ idle speed [3000 rpm] - see page VI %
O2 @ idle speed [3000 rpm] - see page VI %
Carburettor / fuel injection
Type / refMain jet / needle
Injection pressure bar
Pump pressure bar
Octane rating RON
Ignition systemType
Ignition coil
Primary resistance ohmsBallast resistor ohms
Voltage - Tmnl 15(+) to earth V
Distributor
Points gap (air gap) mm
Dwell angle (%)
Condenser capacity F
Rotation
Ignit ion t iming - basic [static Crankshaft @ rpm
V = Vacuum NV = No VacuumTotal ignition advance Crankshaft @ rpm
Crankshaft @ rpm
Crankshaft @ rpm
Centrifugal check. Crankshaft @ rpm
Crankshaft @ rpm
Crankshaft @ rpm
Vacuum range check mbar
Maximum vacuum advance Crankshaft
Spark plugs
Type
Electrode gap mm
Electrical systemBattery V / CC / RC
Alternator voltage / full load current / engine rpm
Starter motor current / voltage - cranking A / V
Starter motor current / voltage - locked A / V
Running gearBrakes -
Front (min. friction material thickness) mm
Rear (min. friction material thickness) mm
Tyres
Saloon Size
Estate / Van Size
Pressure - front / rear - Saloon bar
Pressure - front / rear - Estate / Van bar
Front suspension / wheel alignmentToe-in (+) / Toe-out () mm []
Camber
Castor
King pin inclination
Rear suspension / wheel alignment
Toe-in (+) / Toe-out () mm []
Camber
Torque wrench settingsCylinder head - stage 1 Nm
Cylinder head - stage 2 Nm
Cylinder head - stage 3 Nm
Cylinder head - stage 4 Nm
Big-end bearings Nm
Main bearings Nm
Clutch cover Nm
Flywheel [driveplate] Nm
Front hubs Nm
Rear hubs Nm
Wheel nuts / bolts Nm
Spark plugs Nm
CapacitiesEngine oil & filter litres
Gearbox - 4-speed [5-speed] litres
Automatic transmission - refill litres
Final drive litres
Cooling system litresFuel tank litres
DOHC 16V 142kW
2295 / 48.8 / _
0.3 [3.0 @ 3000rpm]
80
0: Hyd.
0: Hyd.
1-3-4-2
F
872
1.400.10
700 to 800 N/A
_
0.3
200
_
_
_Bosch
HFM_
3.2 to 36
_
95[U]
Computerized
_
0.3 to 0.6_
Battery
_
_
_
_
_
Computer control N/A
_Computer control
_
_
Computer control
_
_
Computer control
_
Bosch/Champion
F8DCO / C10YCC
0.80
12V 62Ah
14.0 / 90 / _
75 / 11.5
_
2.0
2.0
195/65x15: 205/60x15
_
2.1 / 2.3
_
[+20 10]
- 35 20. Sport: -5520
44030. Sport: 51030
_
+033 7
_
55. Bolt length 105mm
+ 90
+ 90
_
30, + 90 to 100
55, + 90 to 100
25
30, + 90 to 100
WSM
200 to 240110
25 to 30
5.8
1.5
_
1.1
8.362
Click on one of thebuttons above to view
data for this car. Toreturn to this screen and
make another choice,click anywhere on the
data screen.
AutomotiveTechnical
DATA
BOOKC230 Kompressor 1995 to 1997
C230 Kompressor 1995 to 1997
C230 Kompressor 1995 to 1997
C230 Kompressor 1995 to 1997
C230 Kompressor 1995 to 1997
C230 Kompressor 1995 to 1997
C230 Kompressor 1995 to 1997
MERP2312301
Engine &Cooling
Fuel Ignition ElectricalRunning
gearTorquesettings
CapacitiesNotes &
Illustrations
MENU HELP
http://../haymenu.pdfhttp://../hayhelp.pdfhttp://../hayhelp.pdfhttp://../haymenu.pdf