MATERIAL SAFETY DATA SHEETsds.chemtel.net/webclients/callico/CH-Z-0073.pdf · 02/08/02 MATERIAL...

PCI Nonwovens2351 U.S. Route 130Dayton, NJ 08810-1004Telephone: 1-800-835-2442

Product Code:Issue Date:Supersedes:Supersedes Date:

007302/08/02

MATERIAL SAFETY DATA SHEET

SECTION 1- PRODUCT IDE TIFICATION

Product Code:Product Name/Synonyms:Chemical Description:

0073Smart-Band™ Heavy Duty Foodservice TowelPolyesterlRayon Based Nonwoven Fabric

SECTION 11- COMPOSITION, INFORMATION ON INGREDIENTS

ComponentsPercent

by Weight CAS No.

"'Exposure Limits'"TWA Short Term(8 Hour) ( 15 Min.)

The composition of this material is proprietary.This material as sold is not hazardous per 29 CFR 1910.1200 criteria.

SECTION 111- HAZARDS IDENTIFICATION

Health Effects:Eyes:Skin:Inhalation:Ingestion:

one known.None known.N.A.N.A.

N.A. ~ Not Applicable

Page lof8

PCI Nonwovens2351 U.S. Route 130Dayton, NJ 08810-1004Telephone: 1-800-835-2442


007302/08/02


SECTION IV - FIRST AID MEASURES

First Aid Procedures:Eyes:

Skin:

Inhalation:Ingestion:

If irritation occurs, flush eyes immediately with large amounts of water for at least15 minutes and continue flushing until irritation subsides. If redness or irritationpersists. contact a physician.Use good personal hygiene and wash thoroughly after handling. If redness orirritation persists, contact a physician.N.A.N.A.

SECTION V - FIRE FIGHTING MEASURES

Flash Point( Specify Method):Flammability Class:Fire Extinguishing Media:Special Fire Fighting Procedures:Unusual Fire & Explosion Hazards:

Flammable (Explosive) Limits(Percent by Volume)

N.A. Lower Explosive Limit: N.A.N.A. Upper Explosive Limit: N.A.Water, Carbon Dioxide, Dry ChemicalNoneNone known; expected to be similar to ordinary combustible

SECTION VI - ACCIDE TAL RELEASE

Steps to be taken in case material is released or spilled: N.A.

N.A. = Not Applicable

of 8

PGI Nonwovens2351 U.S. Route 130Dayton, NJ 08810-1004Telephone: 1-800-835-2442


007302/08/02


SECTION VII - HANDLING AND STORAGE

Handling:

Storage:

None

Avoid storing near strong oxidizers.Avoid sources of ignition.Use caution when stacking to avoid unstable conditions.Store at temperatures below 140°FStore in a sprinkJered warehouse.

SECTION VIII - EXPOSURE CONTROLS, PERSONAL PROTECTION

Eye Protection:Gloves:Respiratory:Ventilation:Other:

None required when used as intended.None required when used as intended.None required.None required.N.A.

SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES

Appearance and Odor:Odor Threshold:Specific Gravity (Water=I):Vapor Density (Air=l):Vapor Pressure(mm of mercury):Evaporation Rate:


White FabricNANANANANA

of8

Boiling Point:Freezing Point:pH:Solubility in Water:

NANAN.A.N.A


Product Code:[ssue Date:Supersedes:Supersedes Date:

007302/08/02


SECTION X - STABILITY AND REACTIVITY

General Reactivity:Incompatibility (Materials to Avoid):Hazardous Decomposition Products:Hazardous Polymerization:Conditions to Avoid:

StableN.A.Not tested; expected to be similar to ordinary combustion...X.. Will Not Occur ..... Will OccurN.A.

SECTION XI - TOXICOLOGICAL INFORMATION

Reported Human Effects:

No primary dermal irritation human patch tests were conducted on this fabric.

Reported Animal Effects:

No animal toxicity studies have been carried out with this product.

Carcinogenicity Information:

Not classifiable as a Human Carcinogen by ACGIH, IARC, EPA or NTP.

SECTION XII - ECOLOGICAL INFORMATION

Ecotoxicity:

No ecological studies have been carried out on this product.

N.A. = Not Applicable

of8

PGI Nonwovens2351 U.S. Route 130Dayton, j J 08810-1004Telephonc: 1-800-835-2442


007302/08/02


SECTION XIII - DISPOSAL CO SIDERATION

Waste Disposal Methods:

Dispose in accordance with Federal, State and local regulations. Be aware that state andlocal requirements may differ widely depending on location and may in many cases bedifferent from federal rules.

When a decision is made to discard this material as supplied, it does not meet RCRA's(Resource Conservation and Recovery Act) characteristic definition of ignitability,corrosivity, or reactivity, and is not listed in 40 CFR 261.33. The toxicity characteristic(TC), however, has not been evaluated by the Toxicity Characteristic Leaching Procedure(TCLP)

SECTION XIV - TRANSPORTATION INFORMATION

Shipping Information:

Shipments of Smart-Band™ Foodservice Towel fabrics are not regulated by the U.S.Department of Transportation (DOT). There is no identification number. 0 speciallabels are required.

SECTION XV - REGULATORY INFORMATIO

U.S. Federal Regulations

OSHA:This MSDS is provided to comply with provisions of the Hazard CommunicationStandard (29 CFR 1910.1200).


of8

PGI Nonwovens2351 U.S. Route 130Dayton, J 08810-1004Telephone: 1-800-835-2442


007302/08/02


EPA:

TSCA:All components of this product are in compliance with the inventory listingrequirements of the U.S. Toxic Substances Control Act (TSCA) ChemicalSubstance Inventory, 8(b).

CERCLA Information (40CFR 302.4):Releases of this material to land or water are not reportable to the NationalResponse Center under the Comprehensive Environmental Response,Compensation, and Liability Act (CERCLA) or to state and local emergencyplanning committees under the Superfund Amendments and Reauthorization Act(SARA) Title III Section 304.

SARA TITLE Ill, Section 313 Information (40CFR 372):This product does not contain a chemical which is listed in Section 313 at orabove de minimis concentrations.

CLEA AIR ACT AME DMENTS OF 1990:This product and its packaging do not contain, nor are they manufactured with.any of the ozone-depleting substances listed in either Class I chlorofluorocarbons.halons. carbon tetracWoride, and methyl chloroform) or Class II(hydrochlorofluorocarbons) of the Clean Air Act Amendments of 1990.

FDA:

This product is not registered with the FDA. Therefore, it is not approved for use asarticles or components of articles intended for repeated contact with food.

USDA:

This product has not been evaluated by USDA for use in packaging material in directcontact with meat or poultry food products prepared under federal inspection.

N.A. Not Applicable

of8



007302/08/02


State Regulations

California's Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65):This product contains trace levels of Acetaldehyde CAS# 75-07-00 and FormaldehydeCAS # 50-00-0 known to the State of California to cause cancer, birth defects or otherreproductive harm contributed by the binder and additive.

Massachusetts Right-to-Know, Hazardous Substance List (MSL):This product contains trace levels of Acetaldehyde CAS# 75-07-00 and FormaldehydeCAS # 50-00-0 contributed by binder and the additives.

New Jersey Right-to-Know Hazardous Substance List:This product contains trace levels of Acetaldehyde CAS# 75-07-00 and FormaldehydeCAS # 50-00-0 contributed by binder and the additives.

SECTION XVI - OTHER INFORMATION

POI NonwovensHazard Rating Scale

4 = ExtremeHealth I 3 = HighFire I 2 = ModerateReactivity 0 I = SlightSpecial --- o= Insignificant

RatIngs are based on PGI gUidelInes, and are Intended for Internal use.


of8


Product Code:Issue Date:Supersedes:Supersedes Datc:

007302/08/02


References Documentation: Component MSDS(s)2001 ACGIH Guidc To Occupational Exposure Values

The Book of Chemical Lists on CD ROM, February 2002

Important otice:

All statements, technical information and recommendations set forth herein are based oninformation or tests which PGI Nonwovens believes to be reliable as of the date of thismaterial safety data sheet. However, nothing contained in this information is to be takenas a representation. guarantee, or warranty, for which PGI Nonwovens bears legalresponsibility. PGI Nonwovens urges persons receiving this information to make theirown determination as to the information's suitability and completeness for their particularapplication(s).

The data in this Material Safety Data Sheet relates only to the specific material designatedherein and does not relate to use in combination with any other material or in any process.

Abbreviations:

ACGIH = American Conference of Governmental Industrial HygienistsOSHA = Occupational Safety and Health AdministrationTLV = Threshold Limit ValuePEL = Permissible Exposure LimitTWA = Time Weighted AverageSTEL = Short-Term Exposure LimitEPA = Environmental Protection AgencyIARC = International Agency for Research on Cancer

TP = 'ational Toxicology ProgramFDA = Food & Drug AdministrationUSDA = United States Department of Agriculture

Responsibility For This MSDS:Elizabeth Howard, Assistant Director, Regulatory Affairs130 I E. 8th StreetNorth Little Rock, AR 72114Phone Number: (501) 399-2537Fax Number: (501) 399-2518Internet Address: [email protected]

N.A. - Not Applicable

0f8

MATERIAL SAFETY DATA SHEETsds.chemtel.net/webclients/callico/CH-Z-0073.pdf · 02/08/02 MATERIAL...

Documents

Transcript of MATERIAL SAFETY DATA SHEETsds.chemtel.net/webclients/callico/CH-Z-0073.pdf · 02/08/02 MATERIAL...