Manual: AX4050R SM SHERWOOD EN
Transcript of Manual: AX4050R SM SHERWOOD EN
3 ENIONE
AX-4050K STEREO INTEGRATED AMPLIFIER
=e CONTENTS s Safety Precautions Nee NE eds 48G4 Geneve ees eeeeasssenene dees
Specifications SaaS beNSS WH KV ge Saws Cbd ON Oe DAC a kick eu etie en eus
Circuit Description is bibSh Bibs eade Seine dope seVeneaaeehee evens
Block Diagram Sek RE RUUN Le Seis Ose ee nes ceas ode Me OaRN ee eaees
Wiring Diagram Sele GN adm sew'b b's 640 be dde bw 2 40'S eeenas <n ee
Troubleshooting WERT RT TTT Te Teer rT eT eee
Mechanical Parts List -+-:--cccccccccnccvccveccccscceceses
GS Sherwood
Exploded View(Cabinet & Chassis) ---+-+++++++-- 9 Printed Circuit Boards -:+--+---ceecee cence accacecoen: -11
Electrical Parts List ----cccccccccecsccsccccccenecrsces: -15
IC's Lead & Identifications «---+--+++++seeeeeeee eens -18 Schematic Diagrams So dse'e sine db esed seis cndeese eens 19
Transistors Lead & Identifications -+----++++++++- 23
is temas wae
_ SAFETY PRECAUTIONS
- WARNING | Before servicing this unit, familiarize yourself with the following precautions:
1. Many electrical and mechanical parts in this exposed metal parts of the cabinet, such as chassis have special safety characteristics that often pass unnoticed and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltge, wattage, etc. Replacement parts that have these special safety characteristics are identified in this manual and its supplements: electrical components having such features are identified by /A\ in the schematic diagram and the parts list.
Before replacing any of these components, read the parts list in this manual carefully. The use of substitute replacement parts that do not have the same safety characteristics as specified in the parts list may create shock, fire, or other hazards.
. Before returning the set to the customer, always do an AC leakage current check on the
terminals, screw heads, and metal overlays, to be sure the set is safe to operate danger of electrical shock. Plug the AC line cord directly into a 120 V AC outlet (120 V AC version only). (Do not use a line isolation transformer during this check.) Be sure your AC voltmeter has a sensitivity of 5000 © per volt or greater. Then connect a 1500 2 10 watt resistor, paralleled by a 0.15 uF 150 V AC capacitor, between a known good earth ground (such as a water pipe, or conduit) and the exposed metalic is parts, one at a time. Measure the AC voltage across the combination of a 1500 Q resistor and a 0.15 uF capacitor. Reverse the AC plug at the AC outlet and repeat AC voltage measurements for each exposed metalic part. Voltage measured must not exceed 0.75V RMS. This corresponds to 0.2 mA AC. Any value exceeding this limit constitutes a potential shock hazard and must be corrected immediately.
At 5000 Q per volt or greater sensitivity,
the reading should not exceed 0.75 V.
AC Outlet
AC Voltmeter
Good earth ground, such as
a water pipe or conduit.
0.15 «F 150 V AC,
Place the probe on each exposed metalic part.
SPECIFICATIONS
"Nominal [Limit >53 => 50
>55 |; =2>650
2.5403 | 150 + 30
RMS output power; :
both channels driven at 40 7-20 ki: feq., 0.08% THD, 8 Qo load.
both channels driven at 1 iz freq., 0.08% THD, 8 Q load
Inter Modulation distortion (60 Hz:7 my=4:1 SMPTE)
at 8 Q load, 50 W output.
Input sensitivity
at 1 i freq., 8 QO load, 50 W output.
ss
%
~PHONO input — TAPE2 MON. output
PHONO equalization RIAA RIAA
i RIAA 40 #; - 20 mz, TAPE2 MON. output
CE co tare
I
>73 >70
>95 > 90
+10+1 +1042
+10+1 +1042
>55 >50 > 53 > 50
>67
i PHONO overload at 1 id freq., 0.1% THD
Channel Separation
at input shorted CD, TAPE 1 kz
10 |Crosstolk
at 1 kd freq. input shorted
11 | Total harmonic distortion
at 40 Hz - 20 um freq.,8 Q load, 50 W output 40 fz
ae >65
General SPeEaker lOAd IMPCHANCE — ee ee reeves rev eeecesceecesccerseeeeessrenssenereesessensseeseessereeessseeenee ease seeneeseceneee nesses 80
Power consumptions seaseeroessquees uses etsieaas biti anianlelaeiowGuk ape vas ove eee wer sues ea.cv eee uses sean nen ba pacae seta weeneueee 340 W
Dimensions (WxHxD) icv aces seaweed ete ba dwseeeReu SGC ene Sc unease lede'ss wenees wave Oasis coe ase ewe bege uctabse 440x110 x 245 mm
(17-5/16 x 4-11/16 x 9-1 1/16) Weight (Net) reusabesecuidnienceunseses WAaieeis sue ule's Saleh Weg ae Va ww eaee Caebw eee debe e due de ola oon teawo twee Week@es tnes cate Suteuss se eewes 6.3 kg
| 7 a (13.9 Ibs) Power requirements:
A: 120 V 60 Hz for American/Canadian version
B: 120/220 V 60/50 Hz multi voltage version (switchable) D: 230 V 50 Hz German/Gemeral European version
E: 240 V 50 Hz for UK/Australian version
G: 220 V 50 Hz for Other Area
Notes:
1. Nominal specs represent the design specs. All units should be able to approximate these some will exceed
and some may drop slightly below these specs. Limit specs represent the absolute worst condition that still
might be considered acceptable: in no case should a unit fail to meet limit specs. :
2. This manual is based on the European (D) standard, and provides information on regional circuit modification
throught the use of alternate schematic diagram or wiring diagram, and information on regional component
variations through the use of parts lists. Design and specifications subject to change without notice.
3
CIRCUIT DESCRIPTION
Pin assignment
| RESET (IRO)BACK-UP
(NC)OPEN CLOCK
LC 7821 | DATA SAT ORBE DIGHLINK «<->
DECK PAUSE ~ VOL DOWN
FUNCTION CD LED
Biock Diagram
PAO
PAt
PA2 rot aaa A
170 PAA Lines PAS
PA6
PA?
Port PBS B PBS
t/O PB7
Liner
1
2
3 4 45
6
7
8
9
> ~
NWOMERWHoaBoenwane
BY me)
NOONE WNa=BSosanweaad
A
GND OR VDD(TCAP) OPEN OPEN(ICMP) OPEN |
PER KEY IN(LOW ACTIVE) GND - |
KEY SCAN IN1 KEY SCAN IN2 KEY SCAN IN3 KEY SCAN OUT1 KEY SCAN OUT2 PROTECTION RMC IN ‘AC CORD
OPEN MUTE PORT RELAY
KEY SCAN
BLOCK DIAGRAM
AX-4050R Model No.
~9 +8
Nive
-G-+6
QaLviqnesy
KI
Fz
+x}
cS
HOLDSTAS
BayNVAadS
dwiv AWOL
SNVol
HAMOd
qO1L95L08d
a0avul itkite? de Ligety
ssvqd
JINV1V¢a
pes AW
13t
Y~
MS ano
eS,
S “OU LNOO BrINAOs.
O ‘
AXL- LNdNi sv
A@ GNVLS
AG+
XToHivW
ABN
TII-a
SWY
802SS04Z DHAS OW
dOSN3S
NMOO /dh
H3A1HO O) 4NO
3dvL bOLOW
O)
NI advi
128297 O)
OLY
ONTHOLIMS
—©
« (O) BSHINIL
H3s4n¢
())}
onda
©)
O
1-4
WIRING DIAGRAM
Model No. : AX-4050R
00-001
POOP
0.4
NIVW
TOSNS
ee
Toeita
OCOD} 1OO0|
CO2@d3
1OSd3
O0<00T
GOOr
0 .€@
LNOwS
4dOLSTSOd
ype
ome
Ay ar
0.6 M/S HAMOd
OFecOoOoTs00r 20.8 TS YmdS
Taukt i Tred
OT cOOTrOOr
gq .€ Aal1s—
e-bTOcda
POZdo
tNOISH3A
@
AINO)
OECO0T GOOY
0.8 HOLOATAS
SFOVL DA
oie
IV
TROUBLESHOOTING
Symptom Cause and Remedy
Amplifier inoperative. e Faulty AC power cord.
Replace. |
e Defect in the power switch.
Replace. | e Broken wire in the power transformer.
Replace the power transformer.
e Blown fuse.
Replace the fuse.
e@ Defective power transformer.
Replace.
@ Short in the primary or secondary of the transformer circuitry.
Replace.
e Damaged rectifying diodes D601~D604.
Replace the defective diode(s).
e@ Short in the rectifying circuit.
Repair the short.
No sound from both channels or one channel] e Speaker switch A or B defective.
Replace the defective switch(es). |
e Defective in transistor Q311L/R, Q312L/R on the main board.
Replace the defective transistor(s). |
Headphones inoperative. e Defective resistor R401U/R.
peeeprenesimeree Pepa All the inputs inoperative. e Defective IC 1C102, 1C103, 1C201, 1IC202.
All the inputs work normally except phono. |e Defective IC101.
pienesewersnomanrercenerene Prepac, Loudness has no effect. e Defective loudness switch.
, Replace.
e Defective R201L/R, R202LU/R, C201U/R, C202U/R.
Replace
Bass control has no effect. e Variable resistor VR204 defective.
Replace.
Fuse blows when power Is turned on.
e Defective R212L/R, R213L/R, C212LU/R, C213U/R.
Replace.
Treble control has no effect. e Variable resistor VR203 defective.
Replace.
e Defective R214L/R, R215LU/R, C214U/R.
Replace.
Ref, No.
13 4 '
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40 41
Description
Packaging Materials
Cushion Poly
Film Soft PE
Poly Bag
Box Carton
Accessories
Battery 1.5 V AA(R6M)
Manua Instruction
Manual! Instruction
Manual Instruction
_ Ass'y Commander
Ass'y Commander
Cabinet & Chassis
Knob Main, ABS, Black Knob Rotary, ABS, Black
Panel Front, ABS, Black
Panel Front, ABS, Black
Badge, Inkei
Badge, Sherwood
Guide LED
Button Power, ABS, Black
Window Sensor
Jack Phone, Gold Ring
Switch Speaker Selector, Push
Button Speaker Sel., Push, ABS, Black
Bracket Speaker, Shield
Knob Function, ABS, Black
Knob Function, ABS, Black
Shield Fence, Volume
Shield Fence, Function
Button Direct Switch, ABS, Black
Switch Tact, SW2, SW3, SW4, SW5, SW6
Holder, Sensor
Switch Direct, Push
Volume BASS/TREBLE, with Nut
Volume Main, with Nut
Frame Left, SECC
Heatsink Power, Aluminum
Bracket PCB, SECC
Speaker Terminal, 8P
Speaker Terminal, 8P
Jack RCA Degi-Link, 2P
Jack RCA EXT IN/OUT, 4P
Jack RCA TAPE IN/OUT, CD, 6P
Jack RCA AUX, TUNER, PHONO, 6P
Sponge Rubber
Cover Bottom, SECC
Frame Right, SECC .
Foot, Gold Ring
Foot, Gold Ring
Foot, Black
Outlet
Outlet
Chassis Back, SECC
Chassis Back, SECC
Chassis Back, SECC
Stopper Cord, ABS, Black
Stopper Cord, ABS, Black
Cord Power, ABS, Black
Cord Power, ABS, Black
Plug Jumper
Terminal Ground
Terminal Ground
Cover Top, SECC
Volume Balance with Nut
MECHANICAL PARTS LIST |
Part No. Q'ty Vertion
9722030710 9715000120 9705001550
049605172132
5518001610
9007018100
9007018101
9007018102
058581000166
058581000165
04854306401 1 048545126611 048501034611 048501034612 048535038511 048535342011
8555043110 8543062910 8555046110
4438005010 4628056410 8545126210 6165149210
048543064111 048543064112
6165150610 6163114910 8545126710 4658003710 6515014110 4628043810 3208069010 3208065110 6122631220 7502007420 6505130010 4408105510 4408105810 4438112010 4438103110 4438103210 4438108010 6715024810 6122419510 6122620340
046033102611 046033102511
6033102510 4448105510 4448103610
046102042411 046102042451 046102042491 ©
6513000310
65180001 11
4308007410
4308000430
4328204210
4408104970
4408103720
046122021331
_ 3208067810
a ee ee
+ —- = — = A)
eee” ee oe eco ee ©? ee © Se Se >) ar Sa es Se Se ZN ae 9
KS
D | PT INDO
KS
KS
KS
KS
KS, PT INDO
D
KS
KS
D,PT INDO
KS
D
PT INDO
KS
KS
Ref. No. Description PartNo. Q'ty Vertion
42 Adapter 4428300410 1 PT INDO(Only)
43 Switch, Voltage Sel., Slide 6P 4618006510 1 PT INDO(Only)
44 Switch, Voltage Sel., Slide 3P 4618006610 1 PT INDO(Only)
Screws
$1-S§ #2BTC 3x8B, Black 8109230083 5
$6-S11 #2WPTC 3x8Y, Yellow 8159230081 6
$12-S22 #2BTC 3x8B, Black 8109230083 11
$23. #2WPTC 3x8Y, Yellow 8159230081 1
$24 #2BTC 3x8B, Black 8109230083 1
$25-S28 BSAM 4x88, Black 8109440083 4
$29 #2BTC 3x8B, Black 8109230083 1
$30 #2BTC 3x6B, Black 8109230063 1
$31 #2BTC 3x6B, Black 8109230063 1
$32-S34 #2BTC 3x8B, Black 8109230083 3
$35-S40 HEX MPSW 3x12Y, Yellow 8099130121 6
$41-S46 #Z2WPTC 3x8Y, Yellow 8159230081 6
$47-S55 #2BTC 3x6B, Black 8109230063 9
$56-S59 #2BTC 3x8B, Black 8109230083 4
$60-S63 #1PT. 3x10B, Black 8119130103 4
$64-S68 #2BTC 3x8B, Black 8709230083 8
$69-S76 #1PT 3x10B, Black 8119130103 8
$77 Ground 8155000710 1 $78-S79 #2BTC 3x8B, Black 8109230083 2
$80 #2PTC 4x6Y, Yellow 8119240061 1
$81-S82 #2BTC 3x8B, Black 8109230083 2
$83-S86 BSAM 4x8B, Black 8109440083 4
$87 #Z2WPTC 3x8Y, Yellow 8159230081 1
Miscellaneous
Lead Ass'y, 5P, 450mm, From CN301 to CP301 436105453021 1
Lead Ass'y, 5F, 400mm, From CN401 to CP401 436105403061 4
Power Transformer, 220 V, 60 Hz 2828100283 1 KS
Power Transformer, 230 V, 50 Hz 2828100381 1 OD
Power Transformer, 110/220 V, 50/60 Hz 2828100391 1 PTINDO
P1 P.C.Board Main 4004100200 1
P1-1 P.C.Board Stand-by 4004100210 1
P2 P.C.Board Front 4009100200 1
P2-1 P.C.Board Speaker Selector 4009100210 1
P2-2 P.C.Board Power Switch 4009100220 14
P2-3 P.C.Board Votage Selector 4009100230 14 PT INDO(Only)
PRODUCT SAFETY NOTICE
Each precaution in this manual should be follower during servicing. Components identified with the IEC symbol 4 in the parts list and the safety can be of special significance. When replacing a component identified with A , use only the replacement parts
designated, or parts with the same ratings of resistance, wattage or voltage that are designated in the parts list in this manual. Leakage- current or resistance measurements must be made to determine that exposed parts are acceptably insulated from the supply circuit before returing the product to the customer.
- EXPLODED VIEW Model No. : AX-4050R
Cabinet & Chassis PCB VOLTAGE SELECTOR (PT, INDO ONLY)
S PCB POWER S/W
€-
< < = eal O =
10
PRINTED CIRCUIT BOARDS Model No. : AX-4050R
PC.Board Main(4004100200)
OUTLET
OUTLET2
F702(ONLY EUROPE) TL2.5A/250V
EUROPE TLhi60mA/250V
11 : 12
PC.Board Front (4009100200)
P.C.Board Voltage Selector(4009100230)
VOLTAGE SELECTOR B'D 40091002300. gti
PT INDO Version Only
13
PC.Board SPKR SEL (4009100210)
TO MAIN B°D CP201
14
Model No. : AX-4050R
P.C.Board Power S/W (4009100220)
rad cit noi cen aR
ELECTRICAL PARTS LIST
PartNo. Q'ty Vertion Ref. No. Description
Resistor/Capacitor Tolerance, D:(+ 0.5%), J:(+ 5%), K:(+ 10%), M:(4 20%), Z:(+80, -20%).
Ref. No. Description
PRODUCT SAFETY NOTICE:
Ass'y P.C.Board Main
Capacitors
C101LF/RF Ceramic Tubutar 100 pF SOV
C1O2LF/RF Ceramic Tubular 100 pF SOV
C1i03U/R Electrolytic SG 10 uF SOV
C104L/R Ceramic Tubular 100 pF SOV
C105U/R Ceramic Tubular 2200 pF 16V C106L/R Electrolytic SG 100 uF 10V
C107U/R Mytar 0.0018 uF 100V
C108U/R Mylar 0.0056 uF 100V
C109L/R Electrolytic SG 4.7 uF SOV
C110U/R Mylar 0.0056 uF 100V
C111/C112 = Electrolytic SG 47 uF 25V
C113LF/RF Ceramic Tubular 100 pF SOV
C114LF/RF Ceramic Tubular 100 pF SOV
C115LF/RF Ceramic Tubular 100 pF SOV
CI16LF/RF Ceramic Tubular 700 pF 5OV
Ci17LF/RF Ceramic Tubular 100 pF 50V
C118LF/RF Ceramic Tubular 100 pF SOV
C119LF/RF Ceramic Tubular 100 pF SOV
C120LF/RF Ceramic Tubular 100 pF SOV
C121LF/RF Ceramic Tubular 100 pF 50V
C122LF/RF Ceramic Tubular 100 pF SOV
C123L/R Ceramic Tubular 47 pF SOV
~ C124U/R Electrolytic SG 47 uF 50V
C125-C128 Electrolytic SG 47 uF 25V
C129 Electrolytic SG 1 uF 50V
Ct30F/C131 Ceramic Tubular 0.1 uF SOV
C301L/R Electrolytic SG 3.3 uF SOV
C302L/R Ceramic Tubular 470 pF 50V
C303L/R Ceramic Tubular 820 pF 50V
C304L/R Ceramic Tubular 20 pF SOV
C305U/R Electrolytic SG 10 uF SOV
C306L/R Ceramic Tubular 27 pF 5OV
C307U/R Ceramic Tubular 3 pF 50V
C308L/R Ceramic Tubular 1000 pF 5O0V
C309L/R Ceramic Tubular 220 pF SOV
C310U/R Ceramic Tubular 220 pF SOV
C311L/R Mylar 0.047 uF 100V
C312L/R Ceramic Tubular 3 pF S0V
C313U/R Electrolytic SG 4.7 uF 50V
C314U/R Mylar 0.047 uF 100V
C315 Electrolytic SG 470 uF 10V
C316 Electrolytic SG 33 uF 25V
CS501LF Ceramic Disc 0.0047 uF 50V
C501RF Ceramic Disc 0.0047 uF SOV
C502LF Ceramic Disc 0.0047 uF SOV
C502RF Ceramic Disc 0.0047 uF SOV
CS503LF Ceramic Disc 0.0047 uF 50V
C503RF Ceramic Disc 0.0047 uF S5O0V
C601-C603 Mylar 0.1 uF 100V
cé6o4/cé60S Mylar 0.047 uF 100V
C606/C607 - Electrolytic HS 4700 uF SOV
C608-C612 Mylar 0.047 uF i100V
C613/C614 = Electrolytic SG 470 uF 25V
C615/C616 Electrolytic SG 41 uF SOV
Resistors
R101L/R Carbon Film 1 kohm 1/5 W
R102UR Carbon Film 91 kohm 1/5 W R103UR Carbon Film 914 kohm 1/5 W R104U/R Carbon Film 910 ohm 1/45 W
R105U/R Carbon Film 43 kohm 1/5 W qeeaoew oa
SFEcZeceNnNNNNNEBOFOeeeeen Feeu se FEET CeCe eceeee ee EOE CRE OO BO
054021010095
3519101935
3519101935
3479310071
3519101935
3519222915
3479310121
3679182120
3679562120
3479247971
3679562120
3479347031
3519101935
3519101935
3519101935
3519101935
3519101935
3519101935
3519101935
3519101935
3519101935
3519101935
3519470935
3479247971
3479347031
3479310971
3519104935
3479333971
3519471935
3519821935 3519200935
3479310071
3519270935
3519033935
3519102935
3519221935
3519221935
3679473120
3519033935
3479247971
3679473120
3479347121
3479333041
3579472530
3579472530
3579472530
3579472530 3579472530
3579472530
3679104120
3679473120 3419547225 3679473120
3409347149 3479310971
3069102970
3069913970
3069913970
3069911970
3069433970
2
2
2
NNN NNYN NHN NON NYO NYDNN NN ND NY =
NON AYN WA ee eee we ewe NYONNNNNNNNNNNNNN +A ANN N
NNN NY N
D(Only)
D(Only)
D(Only}
D(Only)
D(Only)
D(Only)
D(Only)
D(Only)
D(Only)
D(Only)
D(Only)
D(Only)}
D(Only)
D(Only)
D(Only)
D(Only)
D{Only)
D(Only)
D(Oniy)
15
R106U/R
R107U/R
R108L/R
R109
R110 R111L/R R112UR R113UR R114U/R R115UR R116UR R117UR R118L/R R119L/R R120L/R R121-R124 R125 R301UR R302L/R R303L/R R304U/R R305UR R306L/R R307L/R R308L/R R309L/R R310UR R311L/R R312UR R313U/R
R314U/R
R315UR
R316U/R
R317UR
R318L/R
R319L/R
R320U/R
R321U/R
R322UR
R323UR
R324U/R
R325UR
R326U/R
R327U/R R328L/R R329 R330 R331 R332 R333 R334 R335 R336L/R R337 R601 R602 R603/R604 R605 R606
L1O1LF/RF
L301U/R
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Metal Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Fiim
Carbon Film
Carbon Film
Carbon Film
Cernent
Cement
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Metal Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Metal Film
Meta! Film
Carbon Film
Carbon Film
Carbon Film
Collis
Inductor, 47 uH
Inductor, 0.5 uH
560 kohm 1/5 W
470 ohm 1/5 W
100 kohm 1/5 W
470 ohm 1/45W
470 ohm 1/5 W
kohm 1/5 W
kohm 1/5 W
kohm 1/5 W
kohm 1/5 W
kohm 1/5 W
1 kohm 1/5 W
47 kohm 1/5 W
ee ee ee
' 6.8 kohm 1/5 W.
. 3 kohm 1/5 W
470 ohm 1/5 W
400 .ohm 1/5 W
100. kohm 1/5 W
{1 kohm 1/45 W
39 kohm 1/5 W 680 ohm 1/5 W
10 kohm 1/5 W
10 kohm 1/5 W
100 kohm 1/5 W
2.2 kohm 1W
1.2 kohm 1/5 W
1.2 kohm 1/5 W
12 kohm 1/5 W
2 kohm 1/5 W
120 ohm 1/5W
22 kohm 1/5 W
120 ohm 1/5 W
2.7 kohm 1/5 W
1 kohm 1/5 W
330 ohm 1/5 W
0.27 ohm SW
0.27 ohm SW
- 39 kohm 1/5 W
330 ohm 1/5 W
45 kohm 1/5 W 4.7 kohm 1/5 W
22 ohm 1/55 W
22 ohm 1/5 W
10 ohm 1W
12 kohm 1/5 W
+ kohm 1/5 W
10 kohm 1/5 W
1.5 kohm 1/5 W
- 1 kohm 1/5 W
7.5 kohm 1/45 W
4 kohm 1/5 W
10 kohm 1/5 W
47 kohm 1/5 W
1 kohm 1/455 W
1 kohm 1/5 W
33 ohm 1W
270 ohm 1W
470 ohm 1/55 W
1 kohm 1/5 W
56 ohm 1/45 W
Products marked with A have special characteristics important to safety. If you replace of these components, read carefully
the product safety notice in the manual.
Part No. Q'ty Vertion
3069564970
3069471970
3069104970
- 3069471970
-3069471970
3069102970
3069102970
3069102970
3069102970
3069102970
3069102970
3069473970
3069682970
3069302970 —
3069471970
3069101970
3069104970
3069102970
3069393970
3069681970
3069103970
3069103970
3069104970
3029222470
3069122970
3069122970
3069123970
3069202970
3069121970
3069223970
3069121970
3069272970
3069102970
3069331970
3059278782
3059278782
3069393970
3069331970
3069153970
3069472970
3069220970
3069220970
3029100470
3069123970
3069102970
3069103970
3069152970
3069102970
3069752970
3069102970
3069103970
3069473970
3069102970
3069102970
3029330470
3029271470
3069471970
3069102970
3069560970
2648647082
2648001010
~enereroendeeoanwran ne a NNnNNnNBNnNNNNNNNNNNNNNNNNNNNNNNNNN A BSNNNNNNNNNN + ANN N
N) D(Only}
Ref. No.
D101
D301L/R
D302L/R
D303L/R
D304U/R
D30SL/R
D306L/R
D307
D308
D309/D3710
D601-D604
D605-D608
D609.
Q301UR Q302U/R Q303UR Q304U/R Q305UR Q306UR Q307UR Q308L/R Q309L/R Q310U/R Q311U/R Q312UR Q313U/R Q314 Q315/Q316 Q317 Q601
1C101
IC102
IC103
CP101
CP201
CN301
CN401
CP501
CP502
CP601
GND1
24
25
26
27
28
C801-C805
C806
C807
C808
R801
R802
Description
Diodes"
1N4148, Switching
Zener, UZ 27.0BSC
~1N4148, Switching
1N4148, Switching
1N4148, Switching
1N4148, Switching
1N4148, Switching
Zener, UZ 4.3BSB
Zener, UZ 7.5BSC
Zener, UZ 18.0BSC
—1N5402, Rectifier
1N4002, Rectifier
Zener, UZ 16.0BSD
Transistors
KTD1302, NPN, Silicon
KTC2240B/BKTC3200, NPN, Silicon
KTC2240B/BKTC3200, NPN, Silicon
KTC2240B8/BKTC3200, NPN, Silicon
KTC2240B/BKTC3200, NPN, Silicon
BKTAS49/KTA1024, PNP, Silicon
KTC2229/KTC3206, NPN, Silicon
25C4137, Bias
KSC2690, NPN, Silicon
KSA1220, PNP, Silicon
2SD718/KTD718, FET, N-CH.
2SB688/KTB688, FET, P-CH.
MPSAO6, NPN, Silicon
KTA1015Y/BKTA1266, PNP, Silicon
KTC1815Y/BKTC3198, NPN, Siticon
DTA114YS/KRA107M
KTA1015Y/BKTA1266, PNP, Silicon
ICs
KIA6259P, OP AMP.
LC7821
KIA4559P/KIA75559P, OP AMP.
Connectors
Wafer, 6P
Wafer, 4P
Wafer, 5P
Wafer, 5P
Wafer, LV, 3P
Wafer, 3P
Wafer, 8P
Miscellaneous
Plate, Ground
Speaker Terminal, 8P
Speaker Terminal, 8P
Jack RCA Degi-Link, 2P
Jack RCA EXT IN/OUT, 4P
Jack RCA TAPE IN/OUT, CD, 6P
Jack RCA AUX, TUNER, PHONO, 6P
End of P.C.B Main
Ass’y P.C.Board Stand-By
Capacitors
Mylar 0.047 uF 100V
Electrolytic SG 470 uF 25V
Electrolytic SG 1 uF SOV
Mylar 0.0047 uF 100V
Resistors
Metal Film 33 ohm 1W
Metal Film 10 chm 1W
qj £2 Fe ca
q
PartNo. Q'ty Vertion
2058322101
2258599115
2058322101
2058322101
2058322101
2058322101
2058322101
2258599102
2258599130
. 2258599127
2058100136
2258100135
2258599117
2208610102
2208606108
2208606108
2208606108
2208606108
2208206102
2208606107
2008622110
2008602102
2008202101
2028407109
2028107106
2208606114
2208206105
2208606104
2238006103
2208206105
2168206107
2168017132
2168206104
4428505810
4428505610
4428506910
4428506910
4428525790
4428505710
4428505510
4235007310
4408105510
4408105810
4438112010
4438103110
4438103210
4438108010
054021010096
3679473120
3409347149
3479310971
3679472120
3029330470 3029100470
~A & BN |- |? HO NHN NNN =
Ge ee ee ee ee
4
“=~ - NO -?NONNNNNNN NN DN ND HN
Ref. No.
D801-D805
Q801
CP602 CP701-1 CP702 (CP702) CP703-1
F701 (F701) F702 F703 (F703)
RLY801
GND2
P1/P2
34
C201UR C202UR C203UR C204UR C205UR C206/C207 C208U/R C209U/R C210UR C211UR C212UR C213UR C214UR C215UR C217/C218 C219UR C220U/R c701
1KS, PT iNDO.C702
1
<b hh ch
—> —- —-
D
16
C703
C704/C705
C706
C707/C708
R201L/R
R202L/R
R203U/R
R204L/R
R205L/R
R206U/R
R207/R208
R209U/R
R210L/R
Description
Diodes
1N4002, Rectifier
Transistor
MPSAOE6, NPN, Silicon
Connectors
Wafer, 4P
Lead Ass’y, LV 3P, AC, 160mm
Wafer, LV, 2P
Lead Ass'y, LV 2P, AC, 160mm
Lead Ass'y, LV 1P, AC, 140mm
Fuses
NB 150 mA, 250 V
T 160 mA, 250 V
T2.5A, 250 V
NB 2.5 A, 250 V
T2.5A, 250 V
Miscellaneous
HR-CR7, DC 12V
Plate, Ground
Pin solder
Outlet
Outlet
End of P.C.B Stand-By
Ass’'y P.C.Board Front
Capacitors
Ceramic Tubular
Mylar
Electrolytic SG
Ceramic Tubular
Ceramic Tubular
Electrotytic SG
Electrolytic SG
Electrolytic SG
Ceramic Tubular
Electrolytic SG
Mylar
Mylar
Mylar
Mylar
Electrolytic SG
Electrolytic SG
Ceramic Tubular
Electrolytic SG
Ceramic Tubular
Electrolytic
Electrolytic SG
Mylar
Electrolytic SG
Resistors
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
560
0.22
4.7
100
33 |
47
47
47
82
10
0.018
0.082
0.0039
0.018
47
47
820
10
1000
0.047
0.01
47
pF
uF
uF
pF
pF
uF
uF
uF
pF
uF
uF
uF
uF
uF
uF
uF
pF
uF
pF
uF
uF
uF
uF
50 V 63 V 50 V 50 V 50 V 25 V 50 V 50V 50 V 50 V 400 V 400 V 100 V 100 V 25V 50 V 50 V 50 V 50 V 5.5V 50 V 100 V 25 V
39 kohm 1/5 W
3.3 kohm 1/5 W
1 kohm 1/5 W
100 kohm 1/5 W
7.5 kohm 1/5 W
33 kohm 1/5 W
100 ohm 1/5 W
1 kohm 1/5 W
100 kohm 1/5 W we we & GQ Qa Qa G&S G&G Ga
a ea a a ee i ee ee
Part No. Q'ty Vertion
2258100135
22086061 14
4428505610
4358850314
4428525780
4358850214
4359852214
5508200930
5508301035
5508302535
5508202530
- §508302535
5528042001
4235007310
4228001410
4448105510
4448103610
054021010097
3519561935 3679224122 3479247971 3519101935 3519330935 3479347031 3479247971 3479247971 3519820935 3479310071 3679183120 3679823120 3679392120 3679183120 3479347031 3479247971 3519821935 3479310071 3519102935 3439247315 3479310971 3679103120 3479347041
3069393970
3069332970
3069102970
3069104970
3069752970
3069333970
3069101970
3069102970
3069104970
ee a ee —_ _— vA ab oh
NNN =
NNN NNN NN DN
Se —s—- NH @ @A ANN NON YN NYY NY DY NNN HN KY BD
PT INDO
KS,A,D,E,G
PT INDO
PT INDO
KS(Onlty)
D,PT INDO
D(Only)
KS(Only)
D(Onty)
-KS,A,D,E,G KS
D,PT INDO
atte. c= aT tread eglathea
Ref. No.
R211U/R
R212U/R
R213L/R
R214U/R
R215U/R
R216UR
R217/R218
R219U/R
R220U/R
R701
R702
R703
R704
R705
R706
R707
R708
R709
R710
R714
R712-R715
R716-R718
R719-R722
R723/R724
R725-R728
R729
R730
0701
0702
D703/D704
D705/D706
LED2
“LED3-LED6
Q701
Q702
Q703-Q707
Q708/Q709
Q710/Q711
IC201AC202
IC701
CN101 CN201 CN601 CN602 CN603(1/2)
SENSOR
16
17
19
20
44
Description
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Fiim
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Carbon Film
Diodes
Zener, UZ 5.18S8
Zener, UZ 4.3BSB
1N41438, Switching
Zener, UZ 5.1BSB
LEDs
SLR-34RCN49, Red
SLR-34YCN49, Yellow
Transistors
OTC114Y
100 kohm 1/5 W
18 kohm 1/5 W
3.9 kohm 1/5 W
1 kohm 1/5 W.
560 ohm 1/5W
1Mohm 1/5 W
100 ohm 1/5 W
100 ohm 1/45 W
1 kohm 1/5 W
4 kohm 1/5 W
10 kohm 1/5 W
100 kohm 1/5 W
330 ohm 1/5 W
1 kohm 1/5 W
22 kohm 1/5 W
220 kohm 1/5 W
100 kohm 1/5 W
10 kohm 1/5 W
100 kohm 1/5 W
1 kohm 1/5 W
10 kohmt/5W .
330 kohm 1/5 W
1 kohm 1/5 W
4.7 kohm 1/5 W
1 kohm 1/5 W
10 kohm 1/5 W
4 Mohm1/5 W
KTC1815Y/BKTC3198, NPN, Silicon
DTC114Y
MPSAO6Y, NPN, Silicon
MPSAS6Y, PNP, Silicon
ics
KIA4559P/KIA75559P, OP AMP.
LSC412329P, DWP115,
Connectors
Lead Ass'y, 6P, 100mm
Lead Ass'y, 4P, 200mm
‘Lead Ass'y, 8P, 100mm
Lead Ass'y, 4P, 280mm
CPU
ceoewewuouonnuncriuweuowockretnweeoewenwee Ge & & & &
Lead Ass'y, 4P, 180mm, A pair of CN603(2/2)
Miscelianeous
Remote Sensor TFMS-53808
Switch Tact, SW2, SW3, SW4, SWS, SW6
Holder, Sensor
Volume BASS/TREBLE
Volume Main, with Nut
, with Nut
Volume Balance with Nut
End of P.C.B Front
PartNo. Q'ty Vertion
3069104970 3069183970 3069392970 3069102970 3069561970 3069105970 3069101970 3069101970 3069102970 3069102970 3069103970 3069104970 3069331970 3069102970 3069223970 3069224970 3069104970 3069103970 3069104970 3069102970 3069103970 3069334970 3069102970 3069472970 3069102970 3069103970 3069105970
2258599103
2258599102
2058322101
2258599103
2381215704
2384521501
2208622106
2208606104
2208622106
2208606114
2208206113
2168206104
2138309172
436106103321
436104203321
436108103321
436104283321
436404183221
2408005003 4658003710 6515014110 3208069010 3208065110 3208067810
sa RNP W Ee BABB eee ne tae sNNNNNNN DN NY
NN OF | oN =
ee ee ee
—~ -= HM ~*~ Th —
Ref. No. Description PartNo. Q'ty Vertlon
Ass'y P.C.Board Power Switch
LED
LED1 SLR-34RCN49Q, Red 2381215704 1
Connector
CN603(2/2} A pair of CN603(1/2) 1
Miscellaneous
16 Switch Tact, SW1 4658003710 1
End of P.C.B Power Switch
Ass'y P.C.Board Speaker Selector
Capacitors
C401LF/RF Ceramic Tubular 560 pF SOV J 3519561935 2 D({Only)
Resistors
R401L/R Metai Film
R402LF/RF Carbon Film
470 ohm 1W J
15 kohm [SW J
3029471470 2 3069153970 2 D(Only)
Connectors
CP301 Wafer, 5P, Angle - 4428513450 1
CP401 Wafer, 5P, Angle 4428513450 1
Miscellaneous
8 Jack Phone, Gold Ring 4438005010 1
9 Switch Speaker Selector, Push 4628056410 2
End of P.C.B Speaker Selector
Ass'y P.C.Board Voltage Selector PT INDO(Only)
Fuses
F901 T 2.5 A, 250 V 5508302535 1
F902 T4A, 250 V 5508302935 1
. Connectors
CP701-2 Wafer, LV, 3P 4428525790 1
CP703-2 Wafer, LV, 1P 4428525770 1
CP704 Wafer, LV, 2P 4428525780 1
CP705 Wafer, LV, 4P 4428525800 1
Miscellaneous
P3 Pin Solder 4428001410 1
P4 Pin Solder 4428001410 1
42 Adapter 4428300410 4
43 Switch, Voltage Sel., Slide 6P 4618006510 1
44 Switch, Voltage Sel., Slide 3P 4618006610 1
End of P.C.B Voltage Selector
PRODUCT SAFETY NOTICE
Each precaution in this manual should be follower during servicing. Components identified with the IEC symbol A\ in the parts list and the safety can be of specia! significance. When replacing a component identified with A , use only the replacement parts designated, or parts with the same ratings of resistance, wattage or voltage that are designated in the parts list in this manual. Leakage- current or resistance measurements must be made to determine that exposed parts are acceptably insulated from the supply circuit before returing the product to the customer.
17
3 tay seeedttbetlabe gd
IC'S LEAD IDENTIFICATIONS & INTERNAL DIAGRAM
GD78XX : 1C601, IC801
CURRENT THERMAL SHUT LIMITER
START-UP CIRCUIT
GNO
LC7821 : 1C102
a. ey 30 Li © [2 8 =~ 29 | oO Rl. 2 gg es > L3. © > | tT 2 > Fa is rs eet 2 O Ra
LCOM?1 ©
- i
L — | ORS
e La ‘ Cr sal 2 R COMI L6 0 ar =n ee she
LCOM2 © e a >
L? o—— Th Bs}, >< 22 ee
: oe a L8 | i vee PITT) fs I > RB
LCOM3 o— : THT ma
VDD pe |
eon ns
NE o————_——___——_ VEE | ~8 5 3 <1 : <0 DATA
RES © f> 2 ao
: i 5 | 15 S o CE
| @
KIA7559P/KIA4559P KIA6259P : 1C101, 1C103 1C201, IC201
18
i ee eer
SCHEMATIC DIAGRAM I Model No. : AX-4050R
MAIN/ST-BY | A
G G
a L creo1
L1O{LF R1LO1L 1K C103L 10.50 pate FROM FRONT BD CN201 a '@. Ph i) i, ‘
47UH x a a ’
C101LF—-cioar—ol) miox|)2— & LOOP 100P | gikYa fi
ne gi § : r i = C130F ns G R10GL SS0K l j
O. 4U — ‘ q Aioa. _ciom. 1OSL 43% oC 485—m : : L = = 4 910 = | 100/10] cion | Gi9m. MAIN B CN301
101AF R1O1A 1K C103R 10/50 0.0018-M IC104 4004100200 SSP eee : R dd. KIAG259P RA0tL CaOiL 401 4W)
7 a : al <4 8 nio7R 41992 7 1K 3. 3/50 S C101RF+C 10earF+ oO RI03A1 16 if a h a 6
1oop| = 100P | & au 470 @301L A ° '" R1i08R 100K KT01302 gk c30aL A : —}- ‘ : ig o 1) are,
oO TO SPKR SEL B’D CP401 C1i3iF qo. 41U bern 0. 06448
910
A AALAL 1K . 0. 0018-M LG I
[ c1amr +C1i1ar 100P pee -15V
DTA1L114YS +3. 54v
TUNER
le: Ay RitiA ik +15. 2V [== ; :
R3S07R 2. 2k(1W)
- Ries
dee 1001 Ri24
|| 100 RBO4R 10K oso1n Tfiok maosA : 27Vv~-B8B
AIZaR | AK
KTD1302 ry
R30 1iR SS/e3018 4K 3. 2.’S0 Ld !
6.8K C123. 47P C3028 470P l Pa0eR
IC103 30K (FN KIA4559P © exp
47K RL20R OO 470 1REQS2 1REQ52
| PEQB2 sREBS2 Ri1eR L__ +46. SV —
C506 |, 6. BK C1iasA 47P 4700/
| GNO1 4
CP501
FROM MAIN TRANS. FROM MAIN TRANS.
—46. 6V
C607
4700/50 KTC1B15Y
a i ee > = ; :
MEE: 7.5K rosof ka7e5 Bee 0. SIE E92, ms +15, 2V 1 33(1w) 1N4002 1
ee oll P07 gee Hi —trsey 470/10 +26. BV
:
Dy @ -F- -|- AS c613 4 :
na 7S C) 1 oT REo3 470725 f
cdl as : Bork
O} J] Ww B18 is 5/9] le |o CT) HirFidqs4 0/0)”
KTC1B8157Y
> 6 6 “a
|
— F
KAA AAA ASA KOA AASA ]COCOOCOO &80866¢
CP6O1 CP101 FROM FRONT B’' OD CP101
FROM FRONT B'D CN6O1 1RBSde sREBEe Axpitster iN4d 2
NOTES ; i1.Resistor velives are indicated in
onme unilese otherwise enecified
(K=1- 000 M=1i-000:- 000 i
@2-Ceapscitor valves are indiceted in microfareces unilesa otherwise
specified.
CALITION Safety precaution to be followed
Ouring servicing
11Sance tnmnose naertsa marked with ZN
ere critical parts for sefety-.-
vee only the one described in the perts list
CPvO1i-141 GseBE RL16R ik
Ld
ONLY MULTI-VOLTAGE AREA
| B-GROLP } CP703B-1
J802
DIGI-LItK © _Cp2-micro-micrefarades |
TLe. SA’250V
TL2. SA’250V UNSWITCHED 4
QUTLET ' !
CcPE02
FROM FRONT 8° 0 CN6&O2
CP701-1
2/1Before returning the set to the
Customer make appropriate leakage current or resistance messurements
to determine the exposeo parts are ocroperly ansulated from the supply circuit. “FROM MAIN TAANS.
19° | | | 20
RELA’ POWER FRONT/SPKR SEL/VOLTAGE SELECTOR ee
FRONT B'D 4009100200 0704 5SVi-B A703 100K
Q7O1
SCHEMATIC DIAGRAM II
CN20 t TO MAIN B’O CP2G1
LGGA Bte- FROM MAIN B’ OD CP101
0708
5V1-B 5v1-8 0705
esa Model No. : AX-4050R
DTC114Y A217 100
= ieee Reis 100 Bass TREBLE
100K (C) 400K (C) ois aie vazo4*, 7 vR203
j = j 1 \ /50
be ee CAL1L 10/50 co 4 REOSL capa. vreo1 | ; Retou| ! —}—4 fh SOK(B) | 1 400K ' ye od ! a. 4.7780
eo = ci =a
100K(mN) BESS
'
1 BABY
$2 8% Q705
DTC114Y
i ee
41K C2Z06R ae 0. 8384;
Q703 DTC114Y
Q704 DTC114Y
Q70e OTC114Y
Q707 DTC114v
¥ Oo
| .
ha Snes ote aoe oe 6 By) Y*) C211R 10/50 a Ly NS t+ 8000008006
Fur : {
{ | : oe) = |
oO =] +5. 3V
1N4148 1/50
= so i Ne 7. R739] | 0. 8b, 6? é38-.
: e i +15. av
ee | TUNER yy PHONE
C1i815Y
i) ,
f) “ 4708 ‘
1N4148 Cn)
A7OB 22k
R3R> aa | 330K | aa0K| | — 716 R717 A71iB
AAAAAA/ OOOO)
Ww 6 % % tw om CN&O 1 Cate ae 1 TO MAIN BD CP601 erFiugag &
Of Oo FE H Wo o oO EO H
4 a)
fs = O i
| CP301 ;
VOLTAGE SELECTOAR1 VOLTAGE SELECTOR2
cP404 FROM MAIN B’ 0 CN401 CP703-2
FROM ST-BY BO
CP703-1
LIVE F901
TL2. 5SA“250V
SPKR SEL B'D 4009100210
NEUTRAL
| NOTES »-Resistor velves ere indicated in
onme unlese otherwise specified
(K=1.000 M=i-. 006-000 |!
-Capecitor velues ere indiceted microfaradses unless otnerwiase specified.
| CALITION ape EBRBeEe ea Ee Sees eB eeneweanwnaeaeeseens es ees Beene ee eRe Se ee ee eee ee
oupine Geeuvene ot | VOLTAGE SELECTOR B'D 4009100230
CP'705 cP704 CP70 i-a
FROM MAIN TRANS. FROM ST-BY FROM ST-BY 8B’ D
B’' D CP702e CP70 1-4 [pemicro-m icrofaredes])
q@eunaewwewewewe esses eee ewe eee eee meee em we eee ee eee ee eT ee ee ee ee Ss SS
11Since those parts merkes with ZN | ‘ere criticel parte for sefety: USe only the one described in the . 4 perts list ! —— Signal Line
2)18efore returning the eet to the - customer make appropriate leakage
to determine the exposed pertes
ere oroperly insulated from tne Supply circuit.
22
TRANSISTORS LEAD IDENTIFICATION
KTB688/2SB688 KTD7 18/2SD718
KSC2690 KSA1220_
25C4137
KTA1015/KTA1266 KTC1815/KTC3198 KTC2240/KTC3200 KTD1302
KTC114YS KTA114YS_
KTA949/KTA1024 KTC2229/KTC3206
MPSA06 MPSA56
EBC
B-—BASE
C—COLLECTOR
F—-EMITTER
23