Light Sport Aviation
description
Transcript of Light Sport Aviation
Presented to: US/Europe International Aviation Safety Conference
By: Kim K. Smith, Manager, Small Airplane Directorate and Larry L. Buchanan, Manager, Light Sport Aviation Branch
Date: June 5, 2008
Federal AviationAdministration
Aircraft and Pilot Overview
Light Sport Aviation
2 2Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Goals of Light Sport Effort• Develop aircraft design & airworthiness
standards for the unregulated segment of the aircraft market.
• Develop pilot standards for sport pilots – they previously did not exist.
• Target continuous improvement of GA safety by leveraging Light Sport Aviation industry experience and maturity.
• Provide standardization and minimum requirements for existing and new designs.
3 3Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Expected Level of Safety for LSA
The expected level of safety of an LSA is not the same as Part 23 certificated products, nor is the level of FAA oversight the same
• LSA Rule raises the level of safety (via Consensus Standards) on a previously unregulated segment of aviation
• Bridges gap between Ultralights and Part 23.
• Raise the level of safety, but still not expected to meet Part 23.
4 4Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Expected Level of Safety for LSA
Part 103
Part 23
103 Training Exemption
-Consensus Standard-Statement of Compliance
-Type Certificate-Production Certificate
-No Design Standards-No Manufacturing Standards
Amateur Built
SpecialLight-sport
Kit-BuiltLight-Sport
“Existing”Light-sport
Level of Certitude
5 5Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
LSA Program Accomplishments
• The first SLSASLSA airworthiness certificates were issued in April, 2005
• Since then – over 75 different manufacturers have produced “ready-to-fly” airplanes, powered parachutes (PPC), and Weight-Shift Control (WSC - i.e., “trikes”) that have been registered as SLSASLSA.
Over 1100 such aircraft have now received SLSASLSA airworthiness certificates
6 6Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
LSA Operational Safety
• Indications from Office of Accident Investigation:LSA safety is continually improvingAccident rate extremely low
• Assessment of the accident data would indicate, at this time, the LSA consensus standards and program boundaries are working well
• The safety record is being monitored very closely to be looking for trends that might indicate areas needing improvement
7 7Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
The Light Sport Rule - Purpose
Provide for the manufacture of Light-Sport Aircraft (LSA) that are safe for their intended use through:
Consensus Standards
Continued Airworthiness
Safety Directives
8 8Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Supporting FAA Regulations
14 CFR Part 21, §21.190(c)
Requirement for manufacturers to list the applicable consensus standards, provide a statement of compliance with the standards, and provide a statement of conformity of the aircraft to the design data, using the manufacturer’s quality assurance system that meets the standards
9 9Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Definition of a Light-Sport Aircraft (LSA)LSA means an aircraft, other than a helicopter or powered lift that, since its original certification, has continued to meet the following:
• Max takeoff weight (MTOW) of not more than:
• 1320 pounds (600 kilograms) for all land aircraft
• 1430 pounds (650 kilograms) for aircraft intended for operation on water
• Max speed (Vh) –120 knots (138 mph); Glider Vne –120 knots
– Max stall speed – not more than 45 knots (52 mph)
• 2 seats max; non-pressurized; single reciprocating engine
• Fixed or ground adjustable propeller; auto-feather for glider
• Fixed landing gear, except for an aircraft intended for operation on water or a glider (retractable gear allowed)
10 10Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
How are LSA certificated?• The FAA does not issue Type Certificates (TC) or
Production Certificates (PC) for LSA• Each aircraft is certificated individually• There are two classes of LSA airworthiness certificates,
Special (SLSASLSA) and Experimental (ELSAELSA)
SLSA: aircraft manufactured to consensus standards and delivered in a “ready-to-fly” condition
ELSA: aircraft assembled from a manufacturer’s “kit” that meets a consensus standard; or an SLSA aircraft converted to ELSA
• These aircraft are not eligible for compensation or hire• No longer need to meet manufacturer’s/standard’s
requirements
11 11Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Consensus Standards Process
• ASTM International was selected as the standards development organization, and the FAA has been working within their process for the development, approval, and revision of the standards
• The FAA accepts, not approves the standards (Ref. OMB Circular A-119, Rev. Feb. 10, 1998)
• The FAA does not require a specific number of standards
• The FAA does not have veto authority of the standards content or requirements
12 12Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Consensus Standards Topics
• The LSA Rule called for consensus standards in nine different subject areas Design and performance Required equipment Quality assurance Production acceptance tests Aircraft operating instructions Maintenance and inspection procedures Identification and recording of major repairs and
alterations Continued airworthiness Kit assembly instructions
13 13Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Flight Standards Overview
The “Sport Pilot and Light-Sport Aircraft” rules address the certification of –
• Sport pilot and flight instructor with a sport rating
• Repairmen
• Inspection and maintenance of the new experimental and special light-sport aircraft
14 14Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What are the Public Benefits?Impacts a large population – Airmen and Aircraft
• Operate an FAA registered and certificated aircraft Aircraft inspected and maintained by certificated airman Purchase “Ready to Fly Aircraft”
• Comp or hire: Flight Training/Rental
• Hold an FAA Pilot Certificate Carry a passenger Flight instruct
Provides for better access to: Insurance, financing,airports, and increased acceptance by generalaviation community
15 15Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What are the Classes of Light-Sport Aircraft (LSA)?
The definition limits LSA to small, simple‑to‑operate, & low‑performance aircraft.
May include several aircraft types –• Fixed-wing
• Gliders
• Powered parachutes
• Lighter-than-air
• Weight-shift-control (trikes)
• Gyroplanes
16 16Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What is Not a Light-Sport Aircraft?
• Part 103 Ultralights
(powered/unpowered)– Hanglider
– Paraglider
• Multiengine aircraft
• Powered lift
• Helicopters
• Complex aircraft Retractable gear Controllable pitch
propeller
17 17Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What are the Previously Certificated Aircraft?
• Standard CategoryPiper, Aeronca, Luscombe, Taylorcraft, Ercoupe, etc.
• Experimental Amateur-BuiltKit Fox, Rans, Air Creation
• Other (Primary Category)
• FAA will post list on AFS-610 website
18 18Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Aircraft Operated by Sport Pilots
Newly Manufactured“Ready-to-Fly”
Newly Manufactured
“Kit-Built”
Standard Category
Amateur Built
Transitioned “Ultralight Like”
Aircraft
19 19Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What Are the Part 91 Requirements?
• Recreational and Sport PilotsOperations in Class B Airspace
• Student Pilots (seeking sport pilot)Operations in Class B, C, and D
• PPCTraffic Pattern Right of Way
• PPC, GyroVFR – Night
20 20Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What are the Medical Certificate Requirements for Sport Pilot?
Operations Requiring A Medical Or U.S. Driver’s License - Other Than Balloon or Glider
• Student Pilot Seeking Sport Pilot Privileges
• A Pilot Exercising the Privileges of a Sport Pilot Certificate
• A Flight Instructor Acting As PIC of a Light-sport Aircraft
FAR 61.23
21 21Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
A Person Using a Current and Valid U.S. Driver’s License Must….
• Comply With Each Restriction and Limitation Imposed on Your Drivers License
• Comply With Any Judicial or Administrative Order Applying To The Operation of a Motor Vehicle
FAR 61.23
22 22Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Certification of Repairmen
23 23Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
Light - Sport Repairmen
• There is only one Repairman (Light-sport aircraft) Certificate.
• Eligible for two ratings: Inspection
Maintenance
24 24Federal AviationAdministration
Light Sport Aviation OverviewJune 5, 2008
What’s next for the LSA Certification Program?
• Manufacturer “LSA audits” by the FAA
• Monitor operational safety of the growing fleet
• Determine appropriate compliance/enforcement policy
• Review training programs: FAA/Designees/Industry - worldwide