Installation Procedure: EVC-E Volvo Penta IPS*...
Transcript of Installation Procedure: EVC-E Volvo Penta IPS*...
7
7 7
7
7
Engine connections
IPS 350/400/450/500/600
IPS 800/900 IPS 1050/1200
AU
X BU
SA
UX B
US
AU
X BU
S
AUX BUS
AUX BUS AU
X BU
S
SEN
DER
S
DATA
LINK
DATALINK
DATA
LINK
SENDERS SEN
DER
S
A
B C
ENGINE CONN.
DIAGNOS
Multilink minimum requirements: NOTE! Minimum two 2.5” displays or one 4” or 7” display.Maximum two 4” or 7” displays on one helm station.
To next station To next station
10
Installation Procedure: EVC-E Volvo Penta IPS* TwinInstallation Procedure: EVC-E Volvo Penta IPS Twin
Document number: 47702213
Release date: 06-2012
Multilink hub
Buzzer
Connection for safety lanyard
Rudder angle sender (not used)
Fresh water and fuel level senders
SUS
Diagnose connection (VODIA)
Connection locations
Propulsion unit connections
SteeringControls
ACP – Active Corrosion Protection
Docking station
IMPORTANT! Never cut or modify the Volvo Penta EVC harnesses. For extra power supply, use the Volvo Penta relay for external accessories.
IPS 350/400/ 450/500/600
Steering unit
Joystick
IPS 800/900/ 1050/1200
Oil temperature and pressure
Oil temperature and pressure
Datalink to SUS
Datalink to SUS
Reverse (SECONDARY)
Reverse (SECONDARY)
Forward (PRIMARY)
Forward (PRIMARY)
Rev. pickup
Rev. pickup
Use template when making holes in dashboard
Use cable ties to fix cables
Transom unit
To transmission cableTo AUX-bus connection
To transom unit
Tilt adjuster bracket
Steering wheel hub
Max. 15 mm (0.59”) dashboard thickness
Connecting multiple Multilink hubs
Joystick Stand-alone HCU
Multifunction panel(Docking station panel)
Stand-alone HCU connections
Buzzer
11 11
10
Flybridge
JoystickSteering wheel
Multilink hub
Buzzer
Multifunction panel(Start/Stop panel)
Dynamic Positioning System interface
Dynamic Positioning System antenna
7” display
Levers
Lever connections
10
11 11
18
Typical installation / Main station
IPS 350/400/450/500/600, IPS 800/900, IPS 1050/1200
OK!
For information on cable lengths etc. please refer to Installation manual.
NOT OK!
OK!
1
2
3
4
5
Multisensor
SUS
CPM ACP
Battery Control Unit (BCU)
2.5“ Battery Management display
Battery sensor
IMPORTANT! This end of Y-connector must be connected directly, without extension, to levers/HCU.
Y-connector
Multiple helm stations
Helm station
Helm station
8
8
7
8
8
Engine Engine
8
2.5” display
7” display
4” display
Autopilot 4” display
To NMEA2000 backbone
BA C
Compass (CCU)
Joystick Steering wheelLevers
Lever connections
11
11 11
5
7
910 19 10
12
11
9
2.5” display
Multilink hub
10 10 1616
Termination plug
2121
Autopilot 4” display
To NMEA2000 backbone
10
10
12
10
Termination plug
1
20
NMEA interface
ADU
7
7
7
Battery Management Negative terminal
Starter motor
Remote frequency reciever with WLAN (RFW)
Continuous output 20 A
B: fused output
A: unfused output
House loads2.5” Battery Management display
Battery sensor
To engine connector (AUX)To external switches (optional)
Termination plug
25
7
AUX-bus termination
Correct!Termination in the beginning and at the end of the AUX-bus
Incorrect!No end termination of the AUX-bus
Termination plug
Termination plug
D11 D11
10
55
Battery Control Unit (BCU)
20
20
5
NMEA2000 backbone
Female terminator
Male terminator
ChartplotterEVC AutopilotCompass (CCU)EVC Autopilot
Battery 12 VDC
T-connectorBackbone ex-tension cable
Fuse
Power cable
23 20
202020Use AUX relay
24 20 22 24
e-Key panel
Battery sensor
10
Remote frequency reciever
with WLAN (RFW)
Battery Control Unit Battery sensore-KeyCompass (CCU)
Steering wheel non tilt adjuster
Steering
JoystickIncl. cables 1.5 m (5 ft.)
Steering wheel tilt adjuster Steering wheel hubIncl. cables 2.5 m (8 ft.)
e-Key Remote
47
70
22
13 0
6-2
012
Components and CablesControls
Components
Stand-alone HCU
LeversBuilt-in HCUs
Levers“Palm Beach”In combination with A-CAN
e-Key panelIgnition, start/stop and locking/unlocking the boat system
Multilink hub6 cable sockets
Autopilot interface NMEA 0183 interface NMEA 2000 interface
Fresh water level **Diameter 52 mm (2.05”)
EVC system tachometerDiameter 85 mm (3.35”) 110 mm (4.33”) 0–4000 rpm
Coolant temp **Diameter 52 mm (2.05”) C°, F°
Speedometer Unitless **Diameter 85 mm (3.35”) 110 mm (4.33”)0–40 1/Hour 0–60 1/Hour
Alarm instrument **Diameter 52 mm (2.05”)
Voltmeter **Diameter 52 mm (2.05”) 12 V, 24 V
Rudder indicator **Diameter 52 mm (2.05”)
Front ring kit (nut) Diameter 52 mm (2.05”) Black/ChromeDiameter 85 mm (3.25”) Black/ChromeDiameter 110 mm (4.33”) Black/Chrome
Front ring kit (clamp) Diameter 52 mm (2.05”) Black/ChromeDiameter 85 mm (3.25”) Black/Chrome
Fuel level **Diameter 52 mm (2.05”)
Engine oil pressure **Diameter 52 mm (2.05”) bar, psi
Turbo pressure **Diameter 52 mm (2.05”) bar, psi
4-in-1 Gauge **Diameter 110 mm (4.33”) Coolant temperature Voltage Oil pressure Fuel level
Aux. Dimmer Unit (ADU) **
Dynamic Positioning System interface
7” display power supply for 12 V systems
MultisensorTransom mounted
A-CANAnalog lever interface
MultisensorHull mounted
SenderFuel level sender 3–180 ohmFuel level sender 240–30 ohm
SenderWater level sender 3–180 ohm
Clear Wake Exhaust System Only for IPS800-1200
Dynamic Positioning System antenna
ACP KitTransom unit
ACP KitCPM unit, one transom unit
Instruments**) Only in combination with EVC system tachometer
19. Display cable, 5/6-pinFeet Meter Part no.5 1.5 21640400 Incl. in display kit
20. NMEA 2000 Extension cableFeet Meter Part no.1 0.3 21812185 6.6 2 21812194** 13 4 21867150 19 6 21867151 33 10 21867152
21. Battery sensor cable Feet Meter Part no.9.8 3 21840060
24. NMEA2000 Termination plugs Type Part no.Male 21812196** Female 21812203**
23. NMEA2000 Powercable Feet Meter Part no.6.6 2 21812205**
22. NMEA2000 T-connectorPart no.21812195**
**) Incl. in Autopilot kit
Cables
7. Standard EVC bus cable, 6-pin* Feet Meter Part no.5 1.5 21865234 16 5.0 874789 23 7.0 889550 30 9.0 889551 36 11.0 889552 42 13.0 888013*) One cable per engine has to be ordered.
8. Y-connector, 6-pinFeet Meter Part no.1.6 0.5 3588972
10. Multilink cable, 6-pinFeet Meter Part no.5 1.5 3886666
11. Extension cable, 6-pinFeet Meter Part no.5 1.5 3889410 10 3.0 3842733 16 5.0 3842734 23 7.0 3842735 30 9.0 3842736 36 11.0 3842737 66 20.0 21172469 131 40.0 21172470
16. Extension cable, 3-pinFeet Meter Part no.3 1.0 874759 10 3.0 3807043
12. Sender cable, 6-pinFeet Meter Part no.16 5.3 3807229
17. Steering adapter, 12/6-pinFeet Meter Part no.0.6 0.2 21421945
15. Extension cable, 6-pinFeet Meter Part no.5 1.5 21480272
13. Aux. relay cable, 6-pinFeet Meter Part no. 3.3 1.0 21427463Kit with cable & relay 12V: 21475508 24V: 21475509
6. Y-split steering, 6-pinFeet Meter Part no.1.3 0.4 21421941
9. 7” display cable, 6-pinFeet Meter Part no.5.5 1.7 21514712**) Incl. in display kit
14. Extension cable, 6-pinFeet Meter Part no.23 7.0 21166002 30 9.0 21166003 43 13 .0 21166004
18. Y-split multilink, 6-pinFeet Meter Part no.1.6 0.5 3588206
1 b. Wiring harness
IPS 800-900Feet Meter Part no.4.3 1.3 21851490 5.6 1.7 21851491 7.2 2.2 21851492 8.5 2.6 21851493 10.2 3.1 21851494 11.5 3.5 21851495 18 5.5 21851496
1c. Wiring harness
IPS 1050-1200Feet Meter Part no.4.3 1.3 21759842 5.6 1.7 21759840 7.2 2.2 21758217 8.5 2.6 21758219 10.2 3.1 21758220 11.5 3.5 21758221 18 5.5 21858754
2. Multisensor Y-split*Feet Meter Part no.1.9 0.6 21825662 *) Wiring harness AUX-bus.
3. BM-display Y-split*Feet Meter Part no. 1.9 0.6 21825656 *) Wiring harness AUX-bus.
4. CPM Y-split*Feet Meter Part no.1.9 0.6 21825665 *) Wiring harness AUX-bus.
5. Termination plugPart no.21825714
NMEA interface
ADU16 161010
2.5” displayNot in combination with 4” or 7” display
7” displayColor display
Autopilot 4” displayColor display
4” displayColor display Not in combination with 2.5” or 7” display
Not in combination with 2.5” or 4” display
1 a. Wiring harness
IPS 350-600Feet Meter Part no.1.9 0.6 21865860 6.2 1.9 21865861e-Key Remote (optional)
Locking/unlocking the boat system. Controls main circuit breaker and two aux relays
e-Key (standard)
Locking/unlocking the boat system
e-Key System
25. e-Key harness with Safety lanyard Feet Meter Type Part no.5 1.5 Single panel 21693202 5 1.5 Twin panel 21693206
26. e-Key harness without Safety lanyardFeet Meter Type Part no.5 1.5 Single panel 21693204 5 1.5 Twin panel 21693208
Multifunction panelFunction configured at startup
10