ILC Cryomodule Vibration Measurements September 6, 2006 Mike McGee AD/Accelerator Physics Department...
-
Upload
angelica-mathews -
Category
Documents
-
view
217 -
download
0
Transcript of ILC Cryomodule Vibration Measurements September 6, 2006 Mike McGee AD/Accelerator Physics Department...
ILC Cryomodule Vibration Measurements
September 6, 2006
Mike McGee
AD/Accelerator Physics Department (APD) Meeting
Vibration Measurement Example
Vertical & Horizontal piezoelectric accelerometers mounted on Capture Cavity 2 cold mass For Cryogenic service Radiation shields
External measurements made using Geophones
Mike McGee, 6 Sep 2006APD Meeting
Environment Measurement Process
Mike McGee, 6 Sep 2006APD Meeting
Floor Seisometer
Cryostat Geophone
Amplifier & A/D
Laptop Data logger
Cold Mass Measurement Process
Mike McGee, 6 Sep 2006APD Meeting
Cold Mass Accelerometer
Amplifier & A/D
Laptop Data logger
Signal Conditioner & Low Pass Filter
Environment & Cold Measurement Analysis
Mike McGee, 6 Sep 2006APD Meeting
Demonstration
Mike McGee, 6 Sep 2006APD Meeting
Demonstration
Mike McGee, 6 Sep 2006APD Meeting
Courtesy of DESY
High Sensitivity Instrumentation
Mike McGee, 6 Sep 2006APD Meeting
Courtesy of DESY
Cryogenic Instrumentation
Mike McGee, 6 Sep 2006APD Meeting
Courtesy of DESY
Baseline (Floor) Instrumentation
Mike McGee, 6 Sep 2006APD Meeting
Courtesy of DESY
General Purpose Instrumentation
Mike McGee, 6 Sep 2006APD Meeting
HS-1Geophone
HS-1 Specifications
SPECIFICATION at 25°C, Geophone in designated operating position (Vertical or Horizontal)
Natural Frequency (Fn) 4.5 ± .75 Hz 7.5 ± .75 Hz 10 ± 1.0 Hz
DC Coil Resistance (DCR), ohms 225 ± 13 510 ± 27 1250 ± 62 225 ± 13 510 ± 27 1250 ± 62 225 ± 13 510 ± 27 1250 ± 62
Sensitivity (G), ± 10% V/in/s .510 .718 1.15 .510 .718 1.15 .510 .718 1.15
Sensitivity (G), ± 10% V/cm/s .201 .283 .453 .201 .283 .453 .201 .283 .453
Open Circuit Damping (Bo), ± 20%
.27 .28 .28 .62 .67 .67 .46 .50 .50
Damping Constant (CD) 246 505 1295 334 718 1843 251 539 1382
Coil Mass (M), grams ± 5% 29 28 28 12.8 11.8 11.8 12.8 11.8 11.8
Maximum Tilt Angle Vertical ModelsHorizontal Models
15° ± 2°
Vertical ModelsHorizontal Models
20° ± 3.5°
Vertical ModelsHorizontal Models
30° ± 7.5°
Courtesy of DESY
Instrumentation Electronics
Mike McGee, 6 Sep 2006APD Meeting
Courtesy of DESY
Capture Cavity 2 (Meson-Fermilab)
Mike McGee, 6 Sep 2006
Measurements by C. Boffo et al.
APD Meeting
DESY Vibration Measurements
Mike McGee, 13 Jul 2006T4CM Design Meeting #2