ICF-SW35SERVICE MANUALVer 1.1 2001. 05

US Model Canadian Model AEP Model E Model Tourist Model

SPECIFICATIONSCircuit system FM: Super heterodyne LW/MW/SW: Dual conversion super heterodyne Frequency range FM: 76.00 - 108.00 MHz 87.50 - 108.00 MHz*1 SW: 2250 - 26100 kHz*2 3850 - 26100 kHz*3 MW: 530 - 1710 kHz 530 - 1620 kHz LW: 150 - 285 kHz Speaker Approx. 66 mm (2 1/8 in.) diameter, 8 Ohms Maximum output 240 mW (at 10 % harmonic distortion) Output i (headphones) jack (3.5 mm stereo mini jack) 16 Ohms Power requirements DC 4.5 V, three R6 (size AA) batteries External power source DC IN 4.5 V Battery Life (approximate hours) Sony R6 (size AA) FM reception SW reception LW/MW reception 17 12 12 Sony LR6 alkaline (size AA) 46 33 33 Dimensions Approx. 168 106 35 mm (W H D) (6 5/8 4 1/4 1 7/16 in.) incl. projecting parts Mass Approx. 405 g (14.3 oz) incl. batteries Supplied Accessories Carrying case (1) Short wave guide (1) Design and specifications are subject to change without notice. The AC power adaptors operating voltage varies depending upon the country in which it is sold. Buy the AC power adaptor in the country you intend to use it. Your Sony dealer may not handle all of the above listed optional accessories. Please ask your dealer for detailed information on the optional accessories available in your country. *1 Italy, Saudi Arabia and Malaysia *2 Countries except for Italy *3 Italy only

FM STEREO/SW/MW/LW PLL SYNTHESIZED RECEIVER9-927-687-122001E0400-1 2001. 5

Sony CorporationPersonal Audio Company Shinagawa Tec Service Manual Production Group

1

Notes on Chip Component Replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be damaged by heat.

TABLE OF CONTENTS 1. GENERALOperating the Radio ................................................................. 3 Setting the Standby Time ........................................................ 5 Setting the Sleep Timer ........................................................... 5 Using Other Functions ............................................................. 5

2. DISASSEMBLY2-1. Cabinet (Rear) ..................................................................... 6 2-2. Main Board ......................................................................... 6 2-3. Micon Board ....................................................................... 7

3. ELECTRICAL ADJUSTMENTSFM Section .............................................................................. 8 SW/MW/LW Section ............................................................... 8 FM VCO Adjustment ............................................................... 9

4. DIAGRAMS4-1. 4-2. 4-3. 4-4. 4-5. 4-6. IC Pin Description ............................................................. 10 Block Diagram .................................................................. 11 Printed Wiring Board Main Section ............................ 13 Schematic Diagram Main Section ............................... 15 Printed Wiring Board Micon Section .......................... 17 Schematic Diagram Micon Section ............................. 19

5. EXPLODED VIEW5-1. Cabinet Section ................................................................. 22

6. ELECTRICAL PARTS LIST ......................................... 23

2

SECTION 1 GENERAL

This section is extracted from instruction manual.

3

4

5

SECTION 2 DISASSEMBLYNote : Follow the disassembly procedure in the numerical order given.

2-1. CABINET (REAR)1 P 3x14 4 claw 5 cabinet (rear)

2 P 3x14

3 claws

2-2. MAIN BOARD2 P 3x14

6 MAIN board

1 Removal the solder.

5 CN1

3 claw

4 claw

6

2-3. MICON BOARD

1 BTP 2x8 2 BTP 2x8 3 MICON board

7

SECTION 3 ELECTRICAL ADJUSTMENTSFM SECTIONSetting: BAND switch: FM VOLUME: MAX ATT: OFF TONE: MUSICFM RF signal generator telescopic antenna terminal 0.01F set

0 dB = 1 V

Connecting Digital Voltmeter (FM, SW, MW and LW)digital voltmeter TP (VT)

Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. AM IF ADJUSTMENT Adjust for a maximum reading on level meter. Frequency Display 11,800 kHz Adjustment Part T1, T4

400Hz, 30% FM modulation frequency deviation 22.5kHz Output level: as low as possible

SW/MW/LW SECTIONSetting: BAND switch: SW or MW or LW VOLUME: MAX ATT: OFF TONE: MUSIC (SW)AM RF signal generator 10F set telescopic antenna terminal

LW FREQUENCY COVERAGE CHECK Frequency Display Reading on Digital voltmeter Adjustment Part 150 kHz 1.0 - 1.3 V

SW FREQUENCY COVERAGE CHECK Frequency Display Reading on Digital voltmeter Adjustment Part 26,100 kHz 8.0 - 9.0 V

400Hz, 30% AM modulation Output level: as low as possible

FM FREQUENCY COVERAGE CHECK Frequency Display Reading on Digital voltmeter Adjustment Part 76 MHz 108 MHz 2.8 - 4.0 V 9.5 - 11.0 V

(MW/LW)AM RF signal generator Put the lead-wire antenna close to the set.

FM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. Frequency Display 76 MHz 108 MHz Adjustment Part L11 CT1 Adjustment Location: See page 9.

400Hz, 30% AM modulation Output level: as low as possible

Connecting Level Meter (FM, SW, MW and LW)level meter (range: 0.55 V ac) 16 set

i jack (J1)

8

FM VCO ADJUSTMENTFM RF signal generator telescopic antenna terminal

Connecting Frequency counterfrequency counter 1F/50V

IC1 0.01F set IC1

7 4

pin pin

33 k

98MHz, non-modulation Output level: 0.1v(100dB)

FM VCO ADJUSTMENT Reading on Frequency counter 76 kHz 200 Hz Adjustment Part RV2

Adjustment Location:FM TRACKING ADJUSTMENT AM IF ADJUSTMENT

main board (component side) ANT2 MW/LW FERRITE-ROD ANTENNA ANT1 FM/SW TELESCOPIC ANTENNA G S1 N(CONDUCTOR SIDE)

T1 16

T4 15 IC1 L11 CT1 8 1 IC2 16 S2 9

B R 1 2 TP (VT)

4 30 RV2 1 8

J1

IC3 8 5 1 4 17 18 CN1

FM VCO ADJUSTMENT

R1 R1

L8

C2

L17

R9

B C22 C20 D10 L11 L12 C43 R44 L9 C38

Q3

Q5

G C15 D5 D7 C17 L6 C12 D6 C19 C18 L5 C10 E B

15 C59 IC1 C60 CF2 C64 C62 10 TP (GND)

16

R7

2 3 C54

C55

D

R4 C26 B R22 E C25 B E S Q11

S

L4

1 main board (conductor side)

R17 TP (GND) CT1 C45

S D R14

D4

C13

R5

BPF1

C

C14

L7 D3

Q6

R8 C11

JC3 G

L3 C5 C7

C8 R6

C21 C39

Q8 D G Q7

JW4

C40 L10

R15

C

D11

C16

L15

R45 C44

C56 R53

Q19

R85

R49 R47 R50 R48

R46

C47

C46

C35 R37

C48 B E

Q23

C C36

C32

C65

Q17

C49 C53 C52 R52

L16

R43

R55

Q24

JC6

Q20

R56

B

C68

C73

R38

1 R64

30

R63

JC11

L14 C41 D9 CF4 C58 C57

JW3

Q13

C74

C89 Q35 JW8 JW10 JW11 JC18 C E B JW12 Q36 R83 C E B 15 16 17 18 CN1 JW13

E

C C

Q29

JC7

B

R75

TP (BEEP)

TP (B/R)

Q12

9 10

B E

C

JC16

C

Q28

R51 C50

X1

R54

C42

6

C

Q14

R41 C R40

Q15

C66 R60 5 C67 R61

Q18

C70

TP (LCH) 25

R34

T3 R33

R32

R35

C51 C E

R59

R25

B E B

C

JC5

TP (VCOH)

2 5

TP (AGC) TP R39 (VT) TP TP(10.25) (D-D OUT)

JC4 TP (VCOL)

R23

TP(RF GND) R42

JC8

S G

E

C

R30

D8

D C37 S R36

G

R29 B

R28 C33

R10

R26

20

L13

C

R11

Q4

B C9 C30 C31 R

C29 T2 C

C34

Q10

Q9 8 5

D R31 1

E B B C28 E R24 C E B

C C27 TP MW/L (H/L)

B EE B

R74 D12 C90 1

E B

TP (POWER) C91 JC17 JC19 C92

R62

IC3 4 C93

JW7

RV2 JW5

R65

JW16

TP (VT)

JW15

C100

9

SECTION 4 DIAGRAMS4-1. IC PIN DESCRIPTION IC201 uPD17072GB-017-1A7 (SYSTEM CONTROL, LCD DRIVER) Pin No. 1 2 3 4 5 69 10 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28, 29 30 31 34 35 49 50, 51 52 53 54 55 56 Pin Name CS POWER BAR/ROD MUTE AM/FM KS0 3 KR0 3 INITIAL NORMAL/FINE H/L 10.25 GND EO VCOL (LW/MW/SW) VCOH (FM) REG0 VDD XOUT XIN REG1 REGLCD0 CAPLCD0, 1 REGLCD1 COM0 3 LCD0 14 VDET1, 2 BEEP TUNE HOLD SCK DI/DO I/O O O O O O O I O I O O O I I O I O O I O I I O I/O Pin Description EEPROM CS control output Power supply (for signal ) start output H: Radio ON L: Radio OFF Antenna switch output H: BAR ANTENNA L: ROD ANTENNA MUTE output H: MUTE OFF L: MUTE ON Band switch signal output H: SW, MW, LW L: FM Key source output Key return input 9K/10K read output Frequency step switch input H: FINE L: NORMAL SW filter switch signal output H: SW L: FM, MW. LW Attenator output GND Tuner PLL error output VCO (SW/MW/LW band) input VCO (FM band) input Capacitor terminal (regulator circuit) Power supply terminal (+2.7 V) Oscillation output (75 kHz) Oscillation input (75 kHz) Capacitor terminal (regulator circuit) LCD driving power supply terminal LCD driving power supply terminal LCD driving power supply terminal LCD drive common output LCD drive segment output Reducing voltage information input Beep output Receive information input Hold input Serial clock output Serial data input/output

10

ICF-SW35

4-2. BLOCK DIAGRAM

11

12

ICF-SW354-3. PRINTED WIRING BOARD MAIN SECTION

1 A

2

3

4

5

6(US) MICON BOARD C238

7(Page 18)

8

9

10

11

12ANT1 FM/SW TELESCOPIC ANTENNA

13

14

MAIN BOARD

A

B

RV3 w VOL R66 T4 TP (FM ANT)

R57

C24

R13 R12

Q6

L8

L17

R9

B E

Q22

C23

CF3

JC14

D10

C61

C45

C21 C39

D7 C17

C

15 C59 C101 TP (TUNE) IC1 CF2 C63 JC9 JC10 C64

16

JW4

R21

Q26

C60

C54

C16

R45 C44

C71

C62

L9

R85

10

Q19

R46

C47

C72

R58

Q2

C32

C80

C65

C36

Q17

C49 C53 C52 R52

L16

R71

C69

JC8

Q25

R35

R59

R55

JC5

Q24

R69

JC6

Q20

C87

JC20

R56

R68

C81

C86

B

C68

R54

C82

R38

JC15

JW6

R63

JW3

Q13

D9

C74 D13 R76 C

CF4 C58

C57

C89

E

C C

Q29

JC7

E B

D12 C90

JW14

GRY

L20

B 15

R75

E

C41

TP (BEEP) E B

10

R74

JC22

JC11

L14

Q12

9

8

1 R64

30

TP (B/R)

9

B E

C

JC16

C

Q28

C83

C73

10

R51 C50

Q14

X1

C42

6

Q27

R41 C R40

Q15

C

E

R25

5

C51

R23

C79

E B C

C B E

JC2

NEWS

TP (GND)

R70

C66 R60 5 C67 R61

Q18

C70

R33

Q10

Q9

D

S2 TONE NEWS..MUSIC

C85

R43

C75 C76

TP (LCH) 25

R34

T3

R32

TP(RF GND) R42 B E B

S G

E

C

R30

MUSIC

D8

C34

B

R T2 C E B B C28 E R24 C E B

S

Q1

R67

C29

Q11

-2

-1

C35 R37

15

IC2

R49 R47 R50 R48

C46

TP (GND)

C48 B E

R26

Q23

C

D C37 S R36

G

R29

R28 C33

R10

C30 C31

D G

G GRN BLK N RED

R3

JW1

C1 EB BE S1 C -2

C R1 JC1

-1 ON OFF S1 ATT ON..OFF

D R31 1 2 5 JC4 TP (VCOL) C

C4

C C27

C

TP (VCOH)

TP (AGC) TP R39 (VT) TP TP(10.25) (D-D OUT)

B EE B

ANT2 TP MW/LW FERRITE-ROD ANTENNA (H/L) B E C

D1

C2

16

1

E

R20

B C77

L15

C56 R53

20

R44

C38

C9

C

R19

Q7

L13

C43

Q4

C102

R11

C

D11

D6 C19

C18

E

R15

R6

C78

L12

Q8

JC12

3

R14 C40 L10

C15 D5

R7

R2

JC13

2

C55

L11

L6 C12

L5 C10 E B

D

Q16

TP (AM/FM)

Q5

G

R4

C20

Q3

S

L4

B E

Q21

C

BPF1 1

R5

C3

C

E R16 B C22

T1

C14 D4 C13

R17 TP (GND) CT1

L7 D3

R8 C11

JC3 G

L3 C5 C7 E B C C

L2 C B E R27

D2

C

CF1

RV1 D18 L21 RV1 JW2 C6 MIN MAX

S D

C8

C

B

C26 B R22 E C25 B

L1

R18 JC21

J1 C88 R73 C84 R72

i

Q35

JW8 JW10

WHT

R62

C91

C95

C97 D14

C94

JW12

JC17

JW11

JC18

JW7

Q30

T5

E B

L18

RV2

B

JC19

C

Q36

C92

R83

E

16 17 18 CN1

IC3 4 C93 5

RED

C

TP (POWER)

+8

1

GRY D16

C99

JW13

JW16

JW15

Q31

L19

Q34

R77

F+04

R78

JW5

R65

C96

R79

C

C98

C100

R82

R80

E B

B E

C

D15

R84

J2 DC IN 4.5V

!

Q32

R81

Q33

B E

CC

E B

D17 11 1-677-230(11)

G

DRY BATTERY SIZE " AA " (IEC DESIGNATION R6) 3PCS, 4.5V

1MICON BOARD CN201

SP1 SPEAKER

(Page 18)

H Semiconductor Location Ref. No. D1 D2 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 Location D-13 B-12 C-9 C-9 C-9 C-9 C-9 D-8 E-7 C-8 C-7 E-10 Ref. No. D13 D14 D15 D16 D17 D18 IC1 IC2 IC3 Q1 Location F-3 F-3 F-12 F-12 F-12 C-12 C-5 D-3 F-10 D-13 Ref. No. Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 Q12 Q13 Location D-12 C-10 C-9 C-9 C-7 D-11 C-11 D-11 D-10 D-11 E-9 E-9 Ref. No. Q14 Q15 Q16 Q17 Q18 Q19 Q20 Q21 Q22 Q23 Q24 Q25 Location E-10 E-10 C-11 D-9 D-8 D-8 D-7 C-4 B-4 D-7 D-6 D-4 Ref. No. Q26 Q27 Q28 Q29 Q30 Q31 Q32 Q33 Q34 Q35 Q36 Location C-2 E-12 E-10 E-10 F-3 F-3 F-12 F-12 F-11 E-8 F-9 Note on Printed Wiring Boards: X : parts extracted from the component side. Y : parts extracted from the conductor side. f : internal component. b : Pattern from the side which enables seeing. f : internal component. C : panel designation. U : B+ Line. H : adjustment for repair. Power voltage is dc 4.5 V and fed with regulated dc power supply from battery terminal. Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW/LW < > : SW Signal path. F : FM f : MW/LW h : SW

Note on Schematic Diagram: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified.

13

14

ICF-SW354-4. SCHEMATIC DIAGRAM MAIN SECTION Refer to page 21 for IC Block Diagrams.

(Page 19)

(Page 20)

Waveform

1

0.1V/div

0.2sec/div

4.4Vp-p

1.78MHz

Q30 C

15

16

ICF-SW35

4-5. PRINTED WIRING BOARD MICON SECTION

1 A

2MICON BOARD

3

4

5

6

7

8

9(US)

10MAIN BOARD IC1 21

11

ALCD201 LIQUID CRYSTAL DISPLAY PANEL

(Page 13)

Semiconductor Location Ref. No. D201 D202 D203 D204 D205 D206 D207 D208 Location D-4 D-5 D-5 D-2 C-10 C-9 C-8 C-8 C-5 C-4 C-9 C-8 C-8 D-7 D-7 D-6 D-7 C-8 B-9 B-9

1

5

10

15 R246 R247 R248 R249 R250 R251 R252

20 C238 R271 R268 R269C235

JC221

R232 R233 C217 C218

R236 R237 R238 R239 R240 R241 R242 R243 R244 R245

BR234 R235 JC222 R231 R211 S204 ON/OFF R230 R229 C216 R210 8 5 R228 IC202 R212 1 4 R227 R213

R263 R262

C232

45 43

R272

L201

C230 C229 C228 C227

56

C

POWER S203 SLEEP D204

C214

R222 R223 R224 R225 R226 C220 15 R254

C221 R255 C222 R256 R257

S219 LIGHT

Q201

TP (KS0)

C208 TP (KS3)

G

R221 S214

Q203

D201

C239 C204

D

C211 R218 C210 R219 C209 R220

C205 R208

C2

25

Q204

C206

C213 R216 TP (MUTE) C212 R217

R261

25

R215

28

X201 C TP (VCOH)

R260 C226 C224 R259 C223 JC224 D

JC220

JC204 TP (KR0) JC211 JC207 S216 HOLD ON TP (KR1) JC216

D202 D203

JC212 JC213 JC208 JC214 JC215 JC210

JC206

JC205

TP TP (EA) R253 (CE9)

TP (10.25)

R207 B E C207 B E R205 C203 TP E B R201 (RF GND) R204 Q202 S D R206 C202 C C201 G S S215 S213 R203 R202 SW BAND

R209

20

C236

C215 R214

IC2015

E R270 BE B JC217 Q206 Q207 C IC205 R264 C C233 3 2 R265 R266 1 1 2 3 3 2 IC204 D207 IC203 1 TP D206 (VCOL) C D208 Q205 R267 JC218 TP (BATT) C237 JC223

40 42

L202

50

C231

D205 (BACK LIGHT)

IC201 IC202 IC203 IC204 IC205 Q201 Q202 Q203 Q204 Q205 Q206 Q207

35

55

29 30

1 10 14

JC219

TP (VT) 2 1

E

TP (H/L)

TP (D-DOUT)

S218 NORMAL..FINE FINE NORMAL

OFF JC203 TP (TUNE)

JC202

S212 ENTER/CLOCK S209 b TP (KR3)

5 TP 6 S211 (TUNER VDD) BAND 9 S210 TP 10 a (KS2) TP (POWER)

1

MAIN BOARD CN1

FTP (BEEP)

JC209

TIMER STANDBY /STANDBY TIME SET STANDBY MEMORY TP (KR2) S201 2 S202 1 TP (KS1)

(Page 14)15 16 17 18 CN201

TP (AM/FM)

C234

GS205 MEMORY SCAN S206 5 TP (BAR/ROD)

JC201

S208 3

S207 4

S217 (9K/10K)

H

04 9K S213,214 TUNE/SCAN/TIME SET S201,202,205-208 MEMORY PRESET PAGE 1-677-23110K 11 (11)

INote on Printed Wiring Boards: X : parts extracted from the component side. Y : parts extracted from the conductor side. f : internal component. b : Pattern from the side which enables seeing.

17

18

ICF-SW35

4-6. SCHEMATIC DIAGRAM MICON SECTION Refer to page 21 for IC Block Diagrams.

(Page 15)

(Page 15)

Note on Schematic Diagram: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. f : internal component. C : panel designation. U : B+ Line. H : adjustment for repair. Power voltage is dc 4.5 V and fed with regulated dc power supply from battery terminal. Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW/LW < > : SW

19

20

SECTION 5 EXPLODED VIEW IC Block DiagramsIC1 CXA1238SAM RF IN NPX REG FM RF IN AM OSC PLL LPF FM OSC FE GND FM/AM FE OUT VCO FM DISCRI MUTE FM RF GND REG AFC

NOTE: The mechanical parts with no reference number in the exploded views are not supplied. Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.

Accessories and packing materials are given in Color Indication of Appearance Parts the last of this parts list. Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinets Color

30

29

28 27 26 25 24 23 22 21

20

19

18

17

16

5-1. CABINET SECTION 9 13

14

12 15ANT1

FM FRONT-END

FM FRONT-END REG

10FM IF/ DISCRI

16

VCO

MPX REG. 1/2 COUNTER 1/2 COUNTER PO1 PO2 AUTOBLEND MONO/ST SELECT MUTING DECORD AMP RIPPLE FILTER 7 VCC 8 RIPPLE FILTER 9 AGC/AFC1 10 AGC/AFC2

20 19 16SP1

21

AM IF/ DET TUNING INDICATOR

8

BAND PASS MUTE

ANT2

1613 14 15 FMIF IN AMIF IN BAND SELECT

1

2

3

4

5 RCH OUT

6 LCH OUT

11 12 TUNE IND GND

18 17 7 22

PLL LPF PILOT DET LPF1 PILOT DET LPF2 ST IND/ VCO CHECK

24IC2 CXA1522PNF1 GND1 P-GND1 OUT1 VCC REG VOL IN1

IC3 LA5002MTP1

2 1 29 34TRIGGER CIRCUIT REGULATOR REFERENCE ERROR AMP NC NC 8 7 6 NC IN 5

31 35

33

25 23 25 32

16 15

14

13 12 11 10 9

30

PRE+POWER1 REG VOL PRE+POWER2

61 IN2 2 NC 3 4 NC NF2 5 6 7 8 GND2 P-GND2 OUT2 RIPPLE

5Description BUTTON (+/) CUSHION (B) BUTTON (POWER) BUTTON (PAGE) CABINET (FRONT) ASSY KNOB (N/F) STRAP, HAND SPRING (SPEAKER), WIRE MAIN BOARD, COMPLETE HOLDER (ANTENNA) SPACER (T) CASE (2ND B) CASE (1ST A) CASE (1ST B) TERMINAL (), BATTERY

4Remark

3

11LCD201

28Ref. No. 21 22 23 24 25 * 26 27 28 * 29 30 31 * 32 33 34 35 ANT1 ANT2 LCD201 SP1 Part No. 3-893-839-21 3-042-903-01 3-312-059-11 3-042-916-01 3-371-765-21 A-3663-471-A 3-042-908-01 3-042-913-01 3-042-894-01 3-042-906-01 1-792-459-11 3-042-895-01 3-045-127-01 3-044-853-01 3-045-971-01 1-501-222-81 1-501-793-21 1-803-943-11 1-529-645-11

27Description STAND LID, BATTERY CASE CUSHION, BATTERY FOOT, RUBBER SCREW (2X8), +BTP

26Remark

Ref. No.1 GND 2 OUT 3 NC 4 C

Part No. 3-042-909-01 3-044-852-01 3-042-907-01 3-042-910-01 X-3378-376-1 3-042-911-01 3-385-660-11 3-389-575-01 A-3683-159-A 3-042-904-01 3-047-311-01 3-042-898-01 3-042-896-01 3-042-897-01 3-042-900-01 7-685-649-79 3-042-899-01 3-383-877-01 3-042-902-01 7-682-546-09

1 2 3 4 5 6 7 8 * 9 10

IC203 RN5RL27AA-TR

IC204 R3111Q271A-TR IC205 R3111Q331A-TR

MICON BOARD, COMPLETE KNOB (HOLD) SHEET (LCD) CASE (LCD) HOLDER (LCD) CABLE, FLAT (FFC) 18P CASE (MICROCOMPUTER) LEAF (MICRO COMPUTER), COPPER SHEET (4 X 15) LEAF (LCD), COPPER ANTENNA, TELESCOPIC (FM/SW) ANTENNA, FERRITE-ROD (MW/LW) DISPLAY PANEL, LIQUID CRYSTAL SPEAKER (6.6cm)

GND 3 VREF

VREF

2 VDD

11 * 12 * 13 * 14 153 GND 1 OUT

1 VOUT

2 VIN

16 17 18 19 20

SCREW +P 3X14 TYPE2 NON-SLIT TERMINAL (+), BATTERY PLATE (ANT), CONTACT CABINET (REAR) SCREW +P 3X5

21

22

SECTION 6 ELECTRICAL PARTS LISTNOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u : , for example: uA.. : A.. uPA.. : PA.. uPB.. : PB.. uPC.. : PC.. uPD.. : PD.. CAPACITORS uF : F COILS uH : H

MAINWhen indicating parts by reference number, please include the board. Abbreviation CND : Canadian model EE : East European model EA : Saudi Arabia model 5E : Country of origin is show in E model IT : Italian model JE : Tourist model

Ref. No. *

Part No.

Description

Remark

Ref. No. C31 C32 C33 C34 C35 C36 C37 C38 C39 C40 C41 C42 C43 C44 C45

Part No. 1-162-970-11 1-162-905-11 1-162-970-11 1-162-970-11 1-162-905-11 1-162-847-11 1-162-970-11 1-162-970-11 1-162-917-11 1-162-919-11 1-126-157-11 1-162-970-11 1-164-357-11 1-162-964-11 1-162-911-11 1-164-357-11 1-162-913-11 1-162-907-11 1-164-471-11 1-162-921-11 1-162-927-11 1-162-927-11 1-162-970-11 1-162-957-11 1-126-157-11 1-162-970-11 1-124-259-11 1-126-157-11 1-162-970-11 1-162-970-11 1-124-259-11 1-115-156-11 1-126-157-11 1-124-584-00 1-115-156-11 1-164-227-11 1-164-227-11 1-115-156-11 1-165-176-11 1-165-176-11 1-115-156-11 1-115-156-11 1-115-156-11 1-124-259-11 1-110-563-11

Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.01uF 1PF 0.01uF 0.01uF 1PF 0.047uF 0.01uF 0.01uF 15PF 22PF 10uF 0.01uF 1000PF 0.001uF 6PF 1000PF 8PF 2PF 680PF 33PF 100PF 100PF 0.01uF 220PF 10uF 0.01uF 4.7uF 10uF 0.01uF 0.01uF 4.7uF 1uF 10uF 100uF 1uF 0.022uF 0.022uF 1uF 0.047uF 0.047uF 1uF 1uF 1uF 4.7uF 0.068uF 10% 0.25PF 10% 10% 0.25PF 10% 10% 10% 5% 5% 20% 10% 5% 10% 0.5PF

Remark 25V 50V 25V 25V 50V 16V 25V 25V 50V 50V 16V 25V 50V 50V 50V

A-3683-159-A MAIN BOARD, COMPLETE ********************* 3-042-896-01 3-042-897-01 3-042-898-01 3-042-904-01 CASE (1ST A) CASE (1ST B) CASE (2ND B) HOLDER (ANTENNA) < ANTENNA > ANT2 1-501-793-21 ANTENNA, FERRITE-ROD (MW/LW) < FILTER > BPF1 1-234-024-11 FILTER, BAND PASS < CAPACITOR > C1 C2 C3 C4 C5 C6 C7 C8 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 1-162-927-11 1-162-964-11 1-162-970-11 1-162-968-11 1-162-905-11 1-162-970-11 1-162-965-11 1-162-970-11 1-126-157-11 1-162-908-11 1-164-185-11 1-162-905-11 1-162-911-11 1-162-975-11 1-162-970-11 1-115-156-11 1-162-970-11 1-115-156-11 1-115-156-11 1-162-970-11 1-126-157-11 1-162-970-11 1-162-970-11 1-162-924-11 1-162-970-11 1-162-970-11 1-164-361-11 1-164-156-11 1-162-966-11 1-126-157-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 100PF 0.001uF 0.01uF 0.0047uF 1PF 0.01uF 0.0015uF 0.01uF 10uF 3PF 13PF 1PF 6PF 24PF 0.01uF 1uF 0.01uF 1uF 1uF 0.01uF 10uF 0.01uF 0.01uF 56PF 0.01uF 5% 10% 10% 10% 0.25PF 10% 10% 10% 20% 0.25PF 5% 0.25PF 0.5PF 5% 10% 50V 50V 25V 50V 50V 25V 50V 25V 16V 50V 50V 50V 50V 50V 25V 10V 25V 10V 10V 25V 16V 25V 25V 50V 25V 25V 16V 25V 50V 16V

* * *

C46 C47 C48 C49 C50 C51 C52 C53 C54 C55 C56 C57 C58 C59 C60 C61 C62 C63 C64 C65 C66 C67 C68 C69 C70 C71 C72 C73 C74 C75

5% 50V 0.5PF 50V 0.25PF 50V 5% 50V 5% 50V 5% 5% 10% 5% 20% 10% 20% 20% 10% 10% 20% 20% 20% 50V 50V 25V 50V 16V 25V 16V 16V 25V 25V 16V 10V 16V 10V 10V 25V 25V 10V 16V 16V 10V 10V 10V 16V 16V

10%

10% 20% 10% 10% 5% 10%

10% 10% 10% 10%

0.01uF 10% 0.047uF 0.1uF 0.0022uF 10% 10uF 20%

20% 10%

23

MAINRef. No. C76 C77 C78 C79 C80 C81 C82 C83 C84 C85 C86 C87 C88 C89 C90 C91 C92 C93 C94 C95 C96 C97 C98 C99 C100 C101 C102 Part No. 1-110-563-11 1-115-156-11 1-126-157-11 1-115-156-11 1-115-156-11 1-164-505-11 1-115-156-11 1-128-057-11 1-126-935-11 1-115-156-11 1-164-505-11 1-126-153-11 1-104-664-11 1-164-156-11 1-124-259-11 1-126-157-11 1-164-156-11 1-162-970-11 1-164-346-11 1-164-346-11 1-162-915-11 1-164-156-11 1-115-156-11 1-124-589-11 1-126-157-11 Description CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT 0.068uF 1uF 10uF 1uF 1uF 2.2uF 1uF 330uF 470uF 1uF 2.2uF 22uF 47uF 0.1uF 4.7uF 10uF 0.1uF 0.01uF 1uF 1uF 10PF 0.1uF 1uF 47uF 10uF 0.01uF 0.01uF 10% 20% Remark 16V 10V 16V 10V 10V 16V 10V 6.3V 6.3V 10V 16V 6.3V 10V 25V 16V 16V 25V 25V 16V 16V 50V 25V 10V 16V 16V 25V 25V Ref. No. D12 D13 D14 D15 D16 D17 D18 Part No. 8-719-988-61 8-719-988-61 8-719-977-40 8-719-988-61 8-719-988-61 Description DIODE DIODE DIODE DIODE DIODE 1SS355TE-17 1SS355TE-17 UDZ-TE-17-13B 1SS355TE-17 1SS355TE-17 Remark

8-719-975-40 DIODE RB411D 8-719-988-61 DIODE 1SS355TE-17 < IC >

20% 20%

20% 20% 20% 20% 10%

IC1 IC2 IC3

8-752-050-20 IC CXA1238S 8-752-059-51 IC CXA1522P 8-759-804-76 IC LA5002M < JACK >

J1 J2

1-566-891-11 JACK (i) 1-580-681-21 JACK, DC (POLARITY UNIFIED TYPE) (DC IN 4.5V) < JUMPER RESISTOR >

0.5PF

20% 20% 10% 10%

JC1 JC2 JC3 JC4 JC5 JC6 JC7 JC8 JC9 JC10 JC11 JC12 JC13 JC14 JC15 JC16 JC17 JC18 JC19 JC20 JC21 JC22

1-216-295-00 1-216-296-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 1-216-296-00 1-216-295-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 5% 5% 1/16W 1/16W

1-162-970-11 CERAMIC CHIP 1-162-970-11 CERAMIC CHIP < FILTER >

CF1 CF2 CF3 CF4

1-577-687-11 1-577-601-11 1-760-238-11 1-760-238-11

FILTER, CERAMIC (10.7MHz) FILTER, CERAMIC FILTER, CERAMIC FILTER, CERAMIC < CONNECTOR >

CN1

1-691-050-21 HOUSING, CONNECTOR 18P < TRIMMER >

CT1

1-141-304-21 CAP, TRIMMER < DIODE >

10PF 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP < COIL > L1 L2 L3 L4 L5 L6 L7 L8 L9 L10 1-412-939-11 1-412-947-11 1-412-938-11 1-412-963-11 1-412-945-11 1-412-947-11 1-412-939-11 1-412-947-11 1-412-939-11 1-412-939-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 1uH 4.7uH 0.82uH 100uH 3.3uH 4.7uH 1uH 4.7uH 1uH 1uH

D1 D2 D3 D4 D5 D6 D7 D8 D9 D10 D11

8-719-800-76 8-719-421-40 8-719-421-40 8-719-421-40 8-719-421-40 8-719-421-40 8-719-421-40 8-719-945-31 8-719-988-61 8-719-002-81

DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE

1SS226 MA77 MA77 MA77 MA77 MA77 MA77 SVC341-L 1SS355TE-17 1T363

8-719-002-81 DIODE 1T363

24

MAINRef. No. L11 L12 L13 L14 L15 L16 L17 L18 L19 L20 L21 Part No. 1-402-815-11 1-412-925-11 1-406-786-11 1-412-963-11 1-412-939-11 1-412-951-11 1-412-955-11 1-412-963-11 1-412-963-11 1-410-294-11 Description COIL (WITH CORE) (FM RF) INDUCTOR 68nH COIL, FM (OSC) INDUCTOR 100uH INDUCTOR 1uH INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 10uH 22uH 100uH 100uH 38uH 1uH Remark Ref. No. R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 Part No. 1-216-837-11 1-216-857-11 1-216-827-11 1-216-845-11 1-216-797-11 1-216-817-11 1-216-837-11 1-216-837-11 1-216-841-11 1-216-839-11 1-216-845-11 1-216-829-11 1-216-837-11 1-216-809-11 1-216-819-11 1-216-841-11 1-216-832-11 1-216-845-11 1-216-817-11 1-216-845-11 1-216-849-11 1-216-839-11 1-216-845-11 1-216-805-11 1-216-817-11 1-216-833-11 1-216-813-11 1-216-837-11 1-216-797-11 1-216-805-11 1-216-797-11 1-216-801-11 1-216-833-11 1-216-837-11 1-216-857-11 1-216-809-11 1-216-841-11 1-216-797-11 1-216-835-11 1-216-825-11 1-216-817-11 1-216-841-11 1-216-845-11 1-216-845-11 1-216-827-11 1-216-837-11 1-216-813-11 1-216-813-11 1-216-809-11 1-216-841-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 1M 3.3K 100K 10 470 22K 22K 47K 33K 100K 4.7K 22K 100 680 47K 8.2K 100K 470 100K 220K 33K 100K 47 470 10K 220 22K 10 47 10 22 10K 22K 1M 100 47K 10 15K 2.2K 470 47K 100K 100K 3.3K 22K 220 220 100 47K 2.2K 680 220 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W

1-412-939-11 INDUCTOR < TRANSISTOR >

Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 Q12 Q13 Q14 Q15 Q16 Q17 Q18 Q19 Q20 Q21 Q22 Q23 Q24 Q25 Q26 Q27 Q28 Q29 Q30 Q31 Q32 Q33 Q34 Q35 Q36

8-729-423-52 8-729-402-32 8-729-123-86 8-729-402-32 8-729-116-64 8-729-423-52 8-729-423-52 8-729-402-32 8-729-423-52 8-729-034-58 8-729-123-86 8-729-029-15 8-729-029-15 8-729-028-74 8-729-028-74 8-729-403-24 8-729-423-52 8-729-208-47 8-729-220-93 8-729-051-84 8-729-029-15 8-729-423-52 8-729-423-52 8-729-423-52 8-729-403-24 8-729-028-74 8-729-028-92 8-729-800-71 8-729-800-71 8-729-402-32 8-729-402-32 8-729-800-71 8-729-402-32 8-729-029-15 8-729-800-71

TRANSISTOR 2SC3931-C TRANSISTOR 2SD1819A-R FET 2SK238-K16 TRANSISTOR 2SD1819A-R FET 2SK508-K51 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3931-C 2SC3931-C 2SD1819A-R 2SC3931-C 2SC4555-6.7-TL

FET 2SK238-K16 TRANSISTOR DTC144TUA-T106 TRANSISTOR DTC144TUA-T106 TRANSISTOR DTA114TUA-T106 TRANSISTOR DTA114TUA-T106 TRANSISTOR XN4210 TRANSISTOR 2SC3931-C FET 2SK210-GR FET 2SK209-G TRANSISTOR XN015010R1SO TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC144TUA-T106 2SC3931-C 2SC3931-C 2SC3931-C XN4210 DTA114TUA-T106 DTA144TUA-T106 2SB815B7-TB 2SB815B7-TB 2SD1819A-R 2SD1819A-R 2SB815B7-TB 2SD1819A-R DTC144TUA-T106 2SB815B7-TB

8-729-029-15 TRANSISTOR DTC144TUA-T106 < RESISTOR >

R1

1-216-821-11 METAL CHIP

1K

5%

1/16W

1-216-825-11 METAL CHIP 1-216-819-11 METAL CHIP 1-216-813-11 METAL CHIP

25

MAINRef. No. R55 R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 R85

MICONPart No. 1-216-833-11 1-216-849-11 1-216-829-11 1-216-057-00 1-216-797-11 1-216-829-11 1-216-829-11 1-216-841-11 1-216-825-11 1-216-849-11 1-216-837-11 1-216-825-11 1-216-821-11 1-216-829-11 1-216-805-11 1-216-829-11 1-216-805-11 1-216-809-11 1-216-809-11 1-216-829-11 1-216-833-11 1-216-821-11 1-216-841-11 1-216-845-11 1-216-845-11 1-216-825-11 1-216-829-11 1-216-841-11 1-216-825-11 1-216-809-11 Description RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 220K 4.7K 2.2K 10 4.7K 4.7K 47K 2.2K 220K 22K 2.2K 1K 4.7K 47 4.7K 47 100 100 4.7K 10K 1K 47K 100K 100K 2.2K 4.7K 47K 2.2K 100 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/10W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C216 C217 C218 C220 C221 C222 C223 C224 C225 C226 C227 C228 C229 C230 C231 C232 C233 C234 C235 C236 C237 C238 C239 Ref. No. * Part No. Description Remark A-3663-471-A MICON BOARD, COMPLETE *********************** 1-792-459-11 3-042-894-01 3-042-895-01 3-042-906-01 3-042-908-01 3-042-913-01 3-044-853-01 3-045-127-01 3-045-971-01 3-047-311-01 CABLE, FLAT (FFC) 18P CASE (LCD) CASE (MICROCOMPUTER) HOLDER (LCD) KNOB (HOLD) SHEET (LCD) SHEET (4 X 15) LEAF (MICRO COMPUTER), COPPER LEAF (LCD), COPPER SPACER (T) < CAPACITOR > 1-164-362-11 1-136-177-00 1-162-970-11 1-162-964-11 1-162-970-11 1-162-970-11 1-162-970-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-115-156-11 1-115-156-11 1-164-156-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-970-11 1-162-964-11 1-162-638-11 1-164-156-11 1-162-925-11 1-162-917-11 1-164-156-11 1-164-156-11 1-163-021-11 1-164-156-11 1-162-970-11 1-126-166-11 1-124-589-11 1-115-156-11 CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP 470PF 1uF 0.01uF 0.001uF 0.01uF 0.01uF 0.01uF 100PF 100PF 100PF 100PF 100PF 100PF 100PF 100PF 1uF 1uF 0.1uF 100PF 100PF 100PF 0.01uF 0.001uF 1uF 0.1uF 68PF 15PF 0.1uF 0.1uF 0.01uF 0.1uF 0.01uF 2200uF 47uF 1uF 0.001uF 100PF 0.001uF 5% 5% 10% 10% 10% 10% 10% 5% 5% 5% 5% 5% 5% 5% 5% 50V 50V 25V 50V 25V 25V 25V 50V 50V 50V 50V 50V 50V 50V 50V 10V 10V 25V 50V 50V 50V 25V 50V 16V 25V 50V 50V 25V 25V 50V 25V 25V 5.5V 16V 10V 50V 50V 50V

* *

1-216-821-11 METAL CHIP

< VARIABLE RESISTOR > RV1 RV2 RV3 1-227-175-11 RES, VAR, CARBON 20K (MINyMAX (ATT ON)) 1-241-765-11 RES, ADJ, CARBON 22K 1-227-174-11 RES, VAR, CARBON 50K (w VOL) < SWITCH > S1 S2 1-572-552-11 SWITCH, SLIDE (ATT ON...OFF) 1-572-552-11 SWITCH, SLIDE (TONE NEWS...MUSIC) < TRANSFORMER > T1 T2 T3 T4 T5 1-404-764-11 1-411-760-11 1-419-539-11 1-404-444-31 1-435-410-11 TRANSFORMER, IF COIL (MW/LW RF) COIL, OSCILLATION TRANSFORMER, IF TRANSFORMER, DC-DC CONVERTER < VIBRATOR > X1 1-760-018-21 VIBRATOR, CRYSTAL (10.25MHz) *************************************************************

5% 5% 5% 10% 10%

5% 5%

10%

10% 20%

1-163-009-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP

10% 5% 10%

26

MICONRef. No. Part No. Description < CONNECTOR > * CN201 1-691-077-21 HOUSING, CONNECTOR 18P < DIODE > D201 D202 D203 D204 D205 D206 D207 D208 8-719-941-86 8-719-941-86 8-719-941-86 8-719-941-04 8-719-980-90 DIODE DAN202U DIODE DAN202U DIODE DAN202U DIODE SB007-03CP LED SLP381F-51-AB (BACK LIGHT) Q201 Q202 Q203 Q204 Q205 Q206 Q207 8-729-220-93 8-729-402-32 8-729-220-93 8-729-423-52 8-729-028-92 Remark Ref. No. Part No. Description < TRANSISTOR > FET 2SK209-G TRANSISTOR 2SD1819A-R FET 2SK209-G TRANSISTOR 2SC3931-C TRANSISTOR DTA144TUA-T106 Remark

8-729-402-32 TRANSISTOR 2SD1819A-R 8-729-402-32 TRANSISTOR 2SD1819A-R < RESISTOR >

8-719-941-04 DIODE SB007-03CP 8-719-988-61 DIODE 1SS355TE-17 8-719-941-04 DIODE SB007-03CP < IC >

R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R213 R214 R215 R216 R217 R218 R219 R220 R221 R222 R223 R224 R225 R226 R227 R228 R229 R230 R231 R232 R233 R234 R235 R236 R237 R238 R239 R240 R241 R242

1-216-821-11 1-216-829-11 1-216-831-11 1-216-833-11 1-216-831-11 1-216-809-11 1-216-813-11 1-216-837-11 1-216-805-11 1-216-857-11 1-216-857-11 1-216-845-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-833-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11

METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

1K 4.7K 6.8K 10K 6.8K 100 220 22K 47 1M 1M 100K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 10K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K

5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W

IC201 IC202 IC203 IC204 IC205

8-759-665-46 8-759-457-68 8-759-662-77 8-759-662-79 8-759-662-78

IC IC IC IC IC

uPD17072GB-017-1A7 AK93C45AV-L RN5RL27AA-TR R3111Q271A-TR R3111Q331A-TR

< JUMPER RESISTOR > JC201 JC202 JC203 JC204 JC205 JC206 JC207 JC208 JC209 JC210 JC211 JC212 JC213 JC214 JC215 JC216 JC217 JC218 JC219 JC220 JC221 JC222 JC223 JC224 1-216-296-00 1-216-296-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-864-11 SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT METAL CHIP < COIL > L201 L202 1-412-963-11 INDUCTOR 1-412-963-11 INDUCTOR 100uH 100uH 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

5%

1/16W

< LIQUID CRYSTAL DISPLAY > LCD201 1-803-943-11 DISPLAY PANEL, LIQUID CRYSTAL 1-216-845-11 METAL CHIP 1-216-845-11 METAL CHIP

27

MICONRef. No. R243 R244 R245 R246 R247 R248 R249 R250 R251 R252 R253 R254 R255 R256 R257 R259 R260 R261 R262 R263 R264 R265 R266 R267 R268 R269 R270 R271 R272 Part No. 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-857-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-833-11 1-216-809-11 1-216-797-11 1-216-831-11 1-216-850-11 1-216-837-11 1-216-857-11 1-216-857-11 1-216-845-11 1-216-833-11 1-216-821-11 1-216-857-11 1-216-857-11 1-216-857-11 1-216-809-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP < SWITCH > S201 S202 S203 S204 S205 1-692-444-11 SWITCH, KEY BOARD (2 (MEMORY PRESET PAGE)) 1-692-444-11 SWITCH, KEY BOARD (1 (MEMORY PRESET PAGE)) 1-692-444-11 SWITCH, KEY BOARD (SLEEP (POWER)) 1-692-444-11 SWITCH, KEY BOARD (ON/OFF (POWER)) 1-692-444-11 SWITCH, KEY BOARD (MEMORY SCAN (MEMORY PRESET PAGE)) 1-692-444-11 SWITCH, KEY BOARD (5 (MEMORY PRESET PAGE)) 1-692-444-11 SWITCH, KEY BOARD (4 (MEMORY PRESET PAGE)) 1-692-444-11 SWITCH, KEY BOARD (3 (MEMORY PRESET PAGE)) 1-692-444-11 SWITCH, KEY BOARD (b (TIMER STANDBY /STANDBY TIME SET STANDBY MEMORY)) 1-692-444-11 SWITCH, KEY BOARD (a (TIMER STANDBY /STANDBY TIME SET STANDBY MEMORY)) 1-692-444-11 SWITCH, KEY BOARD (BAND) 1-692-444-11 SWITCH, KEY BOARD (ENTER/CLOCK) 1-692-444-11 SWITCH, KEY BOARD ( < (TUNE/SCAN/TIME SET)) 1-692-444-11 SWITCH, KEY BOARD (, + (TUNE/SCAN/TIME SET)) 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 1M 1K 1K 1K 10K 100 10 6.8K 270K 22K 1M 1M 100K 10K 1K 1M 1M 1M 100 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No. S215 S216 S217 S218 S219 Part No. 1-692-444-11 1-553-977-00 1-553-510-11 1-553-977-00 1-692-444-11 Description SWITCH, KEY BOARD (SW BAND) SWITCH, SLIDE (HOLD .) SWITCH, SLIDE (9K/10K) SWITCH, SLIDE (NORMAL..FINE) SWITCH, KEY BOARD (LIGHT) < VIBRATOR > X201 1-767-517-11 VIBRATOR, CRYSTAL (75kHz) ************************************************************* MISCELLANEOUS *************** 31 1-792-459-11 CABLE, FLAT (FFC) 18P ANT1 1-501-222-81 ANTENNA, TELESCOPIC (FM/SW) SP1 1-529-645-11 SPEAKER (6.6cm) ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 3-042-774-01 MANUAL, INSTRUCTION (JAPANESE,ITALIAN, ARABIC) (IT,EA) 3-042-774-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH, GERMAN) (AEP) 3-042-774-21 MANUAL, INSTRUCTION (SPANISH, PORTUGUESE,DUTCH) (AEP,E,5E) 3-042-774-31 MANUAL, INSTRUCTION (SWEDISH,DANISH, FINNISH) (AEP) 3-042-774-41 MANUAL, INSTRUCTION (ENGLISH,FRENCH, SIMPLIFIED CHINESE) (US,CND,E,5E,EA) 3-042-774-51 MANUAL, INSTRUCTION (ENGLISH,RUSSIAN, HUNGARIAN) (EE) 3-042-774-61 MANUAL, INSTRUCTION (JAPANESE,KOREAN) (JE) 3-042-774-71 MANUAL, INSTRUCTION (ENGLISH, SIMPLIFIED CHINESE) (JE) 3-043-151-01 CASE, CARRYING 3-893-802-17 BOOK, GUIDE, WAVE (JE) 3-912-863-08 GUIDE, SHORT WAVE (EXCEPT JE) Remark

S206 S207 S208 S209 S210

S211 S212 S213 S214

28

ICF-SW35

MEMO

29

ICF-SW35

REVISION HISTORYClicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.1 1.0 Date 2001. 05 2000. 03 Description of Revision Tourist model has been added. New

30