How to change engine oil and filteron Toyota Auris E15 – replacementguide

VIDEO TUTORIAL

This replacement procedure can be used for:TOYOTA Auris Hatchback (E15) 1.5 (NZE151_), TOYOTA Auris Hatchback (E15)1.5 4WD (NZE154_), TOYOTA Prius Plus (XW40) 1.8 Hybrid (ZVW4_), TOYOTACorolla X Saloon (E150) 1.8 VVTi (ZRE142), TOYOTA Corolla X Saloon (E150) 2.0VVTi, TOYOTA Sienna III (XL30) 3.5 (GSL30_), TOYOTA Yaris II Hatchback (XP9)1.8 VVTi (ZSP90_), DAIHATSU Charade IV Saloon (G203) 1.6 GS, TOYOTAMatrix I MPV (E130) 1.8 4WD (ZZE13_), TOYOTA Avensis III Saloon (T27) 1.6(ZRT270_), TOYOTA Avensis III Saloon (T27) 1.8 (ZRT271_), TOYOTA Avensis IIISaloon (T27) 2.0 (ZRT272_), TOYOTA Avensis III Estate (T27) 1.6 (ZRT270_),TOYOTA Avensis III Estate (T27) 1.8 (ZRT271_), TOYOTA Avensis III Estate (T27)2.0 (ZRT272_), (+ 40)

\

The steps may slightly vary depending on the car design.

\

WWW.AUTODOC.CO.UK 1–27

Important!

REPLACEMENT: ENGINE OIL AND FILTER – TOYOTAAURIS E15. TOOLS YOU'LL NEED:

WWW.AUTODOC.CO.UK 2–27

Wire brush

All-purpose cleaning spray

Combination spanner #14

Drive socket # 14

Oil filter cup socket 67-14F

Ratchet wrench

Torque wrench

Flat Screwdriver

Clip removal tool

Oil drain pan

Funnel

Fender cover

Replacement: engine oil and filter – Toyota Auris E15.AUTODOC experts recommend:

REPLACEMENT: ENGINE OIL AND FILTER – TOYOTAAURIS E15. USE THE FOLLOWING PROCEDURE:

1

Open the hood.

WWW.AUTODOC.CO.UK 3–27

Replace the oil filter every time when changing motor oil.

All work should be done with the engine stopped.

Wear gloves to prevent contact with hot liquid.

2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

3

Unscrew the oil filler plug.

WWW.AUTODOC.CO.UK 4–27

4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – Toyota Auris E15.AUTODOC experts recommend:

5

Undo the fasteners of the oil pan lower cover. Use a clip removal tool.

WWW.AUTODOC.CO.UK 5–27

The vehicle must be on even keel, and if it is at an angle, the drainplug must be at the lowest point.

6

Remove the oil pan cover.

7

Put a waste oil container with at least 5 l capacity under the drainage hole.

WWW.AUTODOC.CO.UK 6–27

8

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.

9

Unscrew the drain plug. Use a combination spanner #14. Use a drive socket #14. Use a

ratchet wrench.

WWW.AUTODOC.CO.UK 7–27

10

Drain the used oil.

Replacement: engine oil and filter – Toyota Auris E15. Tipfrom AUTODOC:

11

Prepare a container for the old oil filter.

WWW.AUTODOC.CO.UK 8–27

Caution! The oil may be hot.

Wait until the oil has completely drained from the drainage hole.

12

Unscrew the filter housing cap together with the old filter element. Use the 67-14F socket.

Use a ratchet wrench.

13

Put the old oil filter in the container.

Replacement: engine oil and filter – Toyota Auris E15. Tipfrom AUTODOC experts:

WWW.AUTODOC.CO.UK 9–27

Move up the container. The oil starts to drain out of the drainagehole immediately after you have removed the oil filter.

14

Detach the oil filter from the filter cover.

15

Remove the oil filter cover O-ring. Use a flat screwdriver.

WWW.AUTODOC.CO.UK 10–27

16

Clean the oil filter housing cap. Use all-purpose cleaning spray.

17

Install a new O-ring to its mounting seat on the filter cover.

WWW.AUTODOC.CO.UK 11–27

18

Install the new oil filter to the mounting seat on the filter cover.

Please note!

19

Clean the oil filter seat. Use all-purpose cleaning spray.

WWW.AUTODOC.CO.UK 12–27

Make sure to install the filter correctly. Don't mix up the sides of thepart.

20

Lubricate the rubber seal of the new filter with a little amount of fresh oil.

21

Screw the new filter into its place.

WWW.AUTODOC.CO.UK 13–27

22

Screw the cap. Use the 67-14F socket. Use a torque wrench. Tighten it to 23 Nm torque.

23

Clean the area of the oil pan drainage hole.

WWW.AUTODOC.CO.UK 14–27

24

Screw in the new drainage plug and tighten it. Use a drive socket #14. Use a torque wrench.

Tighten it to 27 Nm torque.

25

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.

WWW.AUTODOC.CO.UK 15–27

26

Reinstall the oil pan lower cover.

27

Tighten the fasteners of the oil pan lower cover.

WWW.AUTODOC.CO.UK 16–27

28

Lower the car.

29

Remove the oil filler cap.

WWW.AUTODOC.CO.UK 17–27

30

Insert the funnel.

31

Pour oil into the engine through the filler. Required amount of oil: 4 l.

Replacement: engine oil and filter – Toyota Auris E15. Tip:

WWW.AUTODOC.CO.UK 18–27

Use the oil recommended by the manufacturer.

32

Check the oil level using the dipstick. Top up oil if necessary.

Please note!

33

Install the oil filler cap. Tighten the oil filler cap.

WWW.AUTODOC.CO.UK 19–27

The oil level should be between the Min and Max marks.

34

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the

engine.

35

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add

oil if necessary.

WWW.AUTODOC.CO.UK 20–27

Please note!

36

Remove the fender protection cover.

WWW.AUTODOC.CO.UK 21–27

The oil level should be between the Min and Max marks.

Make sure that the oil filler cap is properly tightened.

Check the threaded plug of the drainage hole and the oil filter sealfor tightness. If necessary, carefully tighten them up.

37

Close the hood.

Replacement: engine oil and filter – Toyota Auris E15.AUTODOC experts recommend:

WWW.AUTODOC.CO.UK 22–27

Note that oil pressure warning light, which indicates insufficientpressure in the lubrication system, may be on for a longer time thanusual. After a few seconds, the oil will fill all the channels, and thelight will go out.

To protect the environment from pollution, be sure to dispose of theused filters at special collection points.

DID YOU FIND THESE INSTRUCTIONSHELPFUL?

YES NO

BECOME A MEMBER OF AUTODOC CLUB!

WWW.AUTODOC.CO.UK 23–27

AUTODOC — TOP QUALITY AND AFFORDABLE CARPARTS ONLINE

AUTODOC MOBILE APP: GREAT DEALS AND CONVENIENTSHOPPING

A GREAT SELECTION OF SPARE PARTS FOR YOUR CAR

WWW.AUTODOC.CO.UK 24–27

BUY SPARE PARTS FOR TOYOTA

OIL FILTER: A WIDE SELECTION

WWW.AUTODOC.CO.UK 25–27

CHOOSE CAR PARTS FOR TOYOTA AURIS E15

OIL FILTER FOR TOYOTA: BUY NOW

WWW.AUTODOC.CO.UK 26–27

OIL FILTER FOR TOYOTA AURIS E15: THE BEST DEALS & OFFERS

The document contains only general recommendations that may be useful for you when you perform repair or replacement work. AUTODOCshall not be liable for any loss, injury, damage of property occurring in the repair or replacement process due to incorrect use ormisinterpretation of the provided information.

AUTODOC shall not be liable for any possible mistakes and uncertainties in this guide. The information provided is for information purposesonly and cannot replace advice from specialists.

AUTODOC shall not be liable for incorrect or hazardous usage of equipment, tools and car parts. AUTODOC strongly recommends to be carefuland observe the safety rules when performing repair or replacement works. Remember: usage of low quality auto parts does not guaranteeyou the appropriate level of road safety.

© Copyright 2021 – All the contents of this website, in particular texts, photographs and graphics, are protected by copyright. All rights,including reproduction, publication, editing and translation rights, are reserved by AUTODOC GmbH.

WWW.AUTODOC.CO.UK 27–27

Disclaimer: