GROUP GC2 - Inverters R US
Transcript of GROUP GC2 - Inverters R US
DEEP
CYCL
E AGM
PREM
IUM
DEEP
CYC
LE SE
RIES
|ful
lriverb
attery
.com
DC250-6GROUP GC2
BATTERY & TERMINAL DIMENSIONS (All units shown in mm)
250 Amp Hours20 Hour Rate
CYCLING CAPACITY RESERVE CAPACITY
- All listed ratings are @ 100% SoC, T=77°F (25°C), 1.75VPC unless otherwise specified.- Specifications listed are for estimation purposes only. Battery performance can vary depending on application. Battery design subject to change.
(unit: mm)
6 Volt
1.6m Ω
ELECTRICAL SPECIFICATIONSNominal Voltage
275AHC100
250AHC20
229AHC10
204AHC5
960CCA
1160CA or MCA
2000 AmpsHPCA
Internal Resistance
GC2
ABS Plastic - Flame Res. Rating UL94-HB
MECHANICAL SPECIFICATIONSGroup Size
Terminal Type
11.14”Height (w/ terminal)
10.47”Height (case only)
7.13”Width
10.31”Length
76.1 lbs.Weight
See reverse sideM8 w/ TP08 Brass AP
283mm266mm181mm262mm34.5 kg
Terminal Torque
Case Type
DISCHARGE TABLE (Constant Current)Time20hr
10hr
8hr
5hr
3hr
2hr
1hr
Amps12.5
22.9
27.2
40.8
56.6
78.5
136
Rate0.05CA
0.10CA
0.13CA
0.25CA
0.33CA
0.50CA
1.00CA
DISCHARGE PROFILE (Constant Current)
Battery bank spacing required,12.5mm (1/2” inch) minimum
Reserve @25 AMPS Reserve @75 AMPS531 Minutes 135 Minutes
6-Volt Battery Temperature: 77°F (25°C)
Term
inal
Vol
tage
Discharge Time
6.5
6.0
5.5
5.0
4.5
4.0
1 2 25 510 10HoursMinutes
20 2060
250A 145A40.8A 22.9A 12.5A
500A
Terminal: M8 with TP08 Brass AP191.5262
266
18180
262 28
3
20 20
21
17.2
19.1
16
17.9
21
25 25
M8 M8
45
40
Storage
Operation
Charge with TC
TEMPERATURE RANGE SPECIFICATIONS
Charge w/o TC*TC= Temperature Compensation
5°F to 122°F
RecommendedCondition
5°F to 104°F
5°F to 122°F
32°F to 104°F
-40°F to 160°F
Maximum
-40°F to 160°F
-40°F to 160°F
5°F to 122°F
-15°C to 50°C
Recommended
-15°C to 40°C
-15°C to 50°C
0°C to 40°C
-40°C to 71°C
Maximum
-40°C to 71°C
-40°C to 71°C
-15°C to 50°C
Bulk
Absorption
Float
CHARGE VOLTAGES
7.35V
6V
TC Factor: (-2mV/°F/cell) or (-4mV/°C/cell)
Charge Stage
Battery Voltages
7.35V
6.8V
14.7V
12V
14.7V
13.6V
29.4V
24V
29.4V
27.2V
58.8V
48V
58.8V
54.6V
TERMINAL TORQUE SPECS (applicable values are highlighted)
TEMPERATURE vs CAPACITY110%
100%
90%
80%
70%
60%
50%
40%
30%
20%
10%
0%-20 0
TEMPERATURE °F (°C)
CAPA
CITY
%
20 40 60 80 100 120(-29.9) (-17.8) (-6.7) (4.4) (15.6) (26.7) (37.8) (48.9)
STATE of CHARGE (SOC) vs OPEN CIRCUIT VOLTAGE (OCV)6.50
6.38
6.25
6.13
6.00
5.88
5.75
13.00
12.75
12.50
12.25
12.00
11.75
11.5010 20
State of Charge (SOC)
OCV
(6V
Batt
ery)
OCV (12V Battery)
30 40 50 60 70 90 10080
SELF DISCHARGE vs TIME/TEMPERATURE100%
90%
80%
70%
60%
50%
40%
30%
20%
10%
0%0 2 4 6 8 10 12 14 16 18 20 22 24STORAGE PERIOD (MONTHS) Note: “Boost Charge” required @ 75% SoC, Max 50% Soc
Stat
e of
Cha
rge
(SoC
)
104°F (40°C) 86°F (30°C) 77°F (25°C)
CYCLE LIFE vs DEPTH of DISCHARGE (DOD)100%
90%
80%
70%
60%
50%
40%
30%
20%
10%
0%
DO
D
0 500LIFE CYCLES (per BCI)
1000 1500 2000 2500 3000 40003500 4500 5000
*(Based on BCI Testing @ 2-hr Rate)
9001:2008 Quality Management System14001:2004 Environmental Management System18001:2007 Occupational Health & Safety Management System
DELIVERY APPROVED!
LAND, SEA& AIR
Fullriver batteries are sealed lead acid batteries made with Absorbed Glass Mat (AGM) technology. The electrolyte is absorbed into the fiberglass separator material rather than in a free-flowing liquid form. Fullriver batteries are non-spillable electric storage batteries. They are excepted from the requirements of DOT’s hazardous materials regulations, since they adhere to the requirements of code 49 CFR Section 173.159(D) - (CLASSIFIED APPROVED: DOT, CFR, HMR49, IATA, ICAO67, IMDG27)
CERTIFIED
M6, AP
50-70lbs-in
4.1-5.8ft-lbs
5.6-7.9Nm
M8
85-95lbs-in
7.1-7.9ft-lbs
9.6-10.7Nm
M10
115-141lbs-in
9.6-12ft-lbs
13-16Nm
M6M (Stud)
40-56lbs-in
3.3-4.6ft-lbs
4.5-6.3Nm
M8M (Stud)
58-75lbs-in
4.9-6.3ft-lbs
6.6-8.5Nm
M10M (Stud)
92-115lbs-in
7.7-9.6ft-lbs
10.4-13Nm
3/8” Stud
106-150lbs-in
8.9-12ft-lbs
12-16.9Nm
FR45
70-90lbs-in
5.8-7.4ft-lbs
7.9-10.1Nm
TP06 (AP)
40-56lbs-in
3.3-4.6ft-lbs
4.5-6.3Nm
TP08/TP68 (AP)
63-83lbs-in
50-70ft-lbs
7.1-9.4Nm