garden and gardening
Transcript of garden and gardening
garden and gardening
Assembly Instructions
Sun Room 8' - Clear Glazing
x2
4-
After Sale Service Email: customer.service @palram.com
USA 877 -627 -8476 I England 01302 -380775 1
France 0169 791 094 Canada 1 800 -866 -5749 Germany 0180- 522 -8778 International +972 4- 848 -6942
garden and gardening
IMPORTANT Please read these instructions carefully before you start to assemble this SunRoom 8'.
Keep these instructions in a safe place for future reference.
GENERAL RION is not responsible for the misuse of tools or parts All opaque panels with the stamped words THIS SIDE OUT indicates the outside to create a full UV protection. Remove plastic sticker as panels are locked in place. All clear panels are protected by plastic film on both sides and don't have specific direction to install. Remove the plastic film before installation. The quantity of parts that are required for the extension, depends on the number packages purchased. Door can be assembled on the left or right hand side; in addition you can determine door direction opening. Specific screws and bolts must be purchased based on the surface (wall and ground) that the SunRoom 8' will be connected to.
Front 4' Middle 2' Back 4'
Greenhouse Sizes
Pack Qty (Front 4')
Pack Qty (Middle 2')
Pack Qty (Back 4')
8' x 8' 1 x 1
8' x 10' 1 1 1
8' x 12' 1 2 1
8' x 14' 1 3 1
8' x 16' 1 4 1
8' x 18' 1 5 1
8' x 20' 1 6 1
garden and gardening
SAFETY ADVICE RION is not responsible for the misuse of tools or parts.
It is of utmost importance to assemble all of the parts according to the directions. Please follow them closely and do not skip any of the steps.
We strongly recommend using working gloves during assembly.
If using a step ladder or power tools ensure that you follow the manufacturer's safety advice. If local building codes require permits or licenses make sure that they are acquired before beginning. Your SunRoom 8' should be secured to the prepared foundation using the recommended hardware. Do not attempt to assemble the SunRoom 8' in windy or wet conditions. Dispose of all plastic bags. Please keep them out of reach of small children. Keep children away from the assembly area.
Do not lean against or push the SunRoom 8' during construction. Do not attempt to assemble this SunRoom 8' if you are tired, have taken drugs or alcohol or if you are prone to dizzy spells.
When your SunRoom 8' is fully assembled examine it for sharp edges and trim with a razor knife if necessary.
If you live in a hot climate area, where outside temperatures exceed 46° C (115° F) under the sun or 36° C (99° F) in the shade, this may cause the temperature inside the SunRoom 8' to exceed 55° C (131° F). Such conditions may harm your plants and will damage the SunRoom 8' by warping the structural profiles. In order to prevent damage: - Ensure good ventilation during hot days.
- Make sure that the temperature inside the SunRoom 8' never exceeds 55° C (131° F) by providing a shading screen, such as the Shade Net (available as an accessories option).
Note: RION is not responsible for any damage due to high temperatures. * Always close roof vent in high winds.
REQUIRED TOOLS GT1 - Special tool to connect pins through lined up holes. Pin Tool fix and lock profiles in place.
To assemble this product you will need the following tools (these items are not supplied).
A, 411
BEFORE ASSEMBLY RION is not responsible for the misuse of tools or parts.
Selecting a site - the SunRoom 8' must be, positioned and fixed on a flat level surface.
Sort the parts and check according to the contents parts list. Do not begin assembly if any other parts are missing.
If you prepare a concrete foundation do not excavate and pour concrete in frozen ground. We recommend that you place your SunRoom 8' in a spot where it will receive direct sunlight and will be protected from the wind as much as possible. The door should not face prevailing winds.
DURING ASSEMBLY Step 1: Determine which side to place the door. The decision will affect the upcoming steps.
Steps 1, 3: Arrange all 2D connectors with the stamped word "OUT" facing out of the SunRoom 8'.
Step 4:
Make sure that the frame is perfectly straightened by measuring and verifying that they leveled. Make sure that the frame is leveled and anchor it to the ground with screw / screw + dibble / spike (not supplied) in accordance with the selected surface.
The wall to which you are securing your SunRoom 8' must be 90° to the foundation. Step 17:
Make sure that the frame is perfectly straightened by measuring and verifying that they leveled. Make sure that the frame is leveled and anchor it to the wall with screw / screw + dibble / spike (not supplied excluding part # BC1)
in accordance with the selected surface.
The wall to which you are securing your SunRoom onto must be 90° to the foundation. Reinforcement Arch Profiles Steps 18 -23:
Ensure that all the metal profiles are inserted inside the plastic profiles. Repeat each step based on your SunRoom 8' size and the number of arch profiles needed to be assembled as illustrated. (These assembly instructions refer only to SunRoom 8'x8' and 8'x10').
Step 27: Make sure that the profiles are perfectly straightened by measuring and verifying that they are leveled. Anchor the Part 7937 to the ground with screw / screw + dibble / spike (not supplied) according to the selected surface. Step 28: Repeat Steps 24 -27 according to the amount of modules purchased. Step 30: Repeat and refer to Step 4. Steps 39 -40: Repeat and refer to Step 17.
Step 41: Seal the SunRoom 8' edges with Silicon Sealant. Step 57: Insert the rubber strip (Part GF) from the outside of the SunRoom 8'. Cut the remaining edges.
Step 64: Insert the rubber strip (Part 7945) from the outside of the SunRoom 8'. During this step, turn the door in order to insert the rubber strip correctly. Step 66: Determines door direction. The door can be installed and open either as a left or right hand door.
Step 69: Adjust the hinges height in accordance with the upper post and lower ramp of the door aperture, as specified in level C.
ATTENTION: 1 When encountering the
information icon, please refer to therelevant assembly step for additional comments and assistance.
iiThis icon indicates that the installer should be inside the product.
Item Front Back Middle
PN55 2 2 1
PN53 2
PN1 2 6 1
PN127 3
PN51 1
PN134 1
7953 3
7942 1
7803 2 1 1
7802
1
Contents Item Front Back Middle
586
<a 71.4tlelot
1
7801 1
7809 1
7612
7805
7614
7804
1 1
1
1
1
2 1
1 2 1
7951
7552
992
991
989
2
4 4
2
1
1
2
7950 1
7952 2
Item Front Back Middle
7949
01'
1
7884
0-.
2
7936 li
Y
1 1 1
7937 1 1
7536 1
7534 1
7535 1
7533 1
7934 1 2 1
7933 1 2 1
7935 1 2 1
7932 1 2 1
7957 1
Contents Item Front Back Middle DSN 1
........./ ? GF* 2 2 1
*only for clear Sun Room / Sun Lounge
7954 1
8017 1 7 S F 1 SIS!_
7608 2 3 1
7800 2 3 1
PIN1 liP 160 160 30
72 !ln 2 1st-
73 ' 2
74 pü! 2 4 2
01 If jlh 1 1
2 D Ìll,l
6 7 1
53 efi j 1
75
ÌIuII
1
51 0 4 2
Item Front Back Middle
76
71
10
11
12
13
14
1
1
1
1
1
2
1
1
2 1
09
III
5 3
S R2 1
B1
B2
B3
B4
B5
B12
1 1
4 8 2
1
3
1 1
1 1
Contents Item Front Back Middle
R1
\1 1 1
R4 1 1
R10 1 1
E1 4 5 1
E2 4 10 2
E13 2 3
E15 1 2 1
E100 4
E105 1
E106 1
E107 1 2 1
7938 ® 1
7939 1
7940
oin
1
7941 0
roo
1
7898 4
Item Front Back Middle
7948 Ce
2
BC1
7220
10 2
1
2
7912
J
1
7913 1
8039 3
7994 1
7995 1
7996 2
466
411
26
26
10
10
4
4
4008
7441
7442 4
4
1
7445 )))))))))))))))))0%
4
7224 6
Contents Item Front Back Middle
7958
CI
1
465 111
. 4
422
O, 4
4043 OVlllllll1111
8 9 3
22 : IWO 1D
1
99 -;; \
, /// / \ \ \ l i 1`.
1
GT1 1 1
7993 1
7918
iliNi 2
7919 2
7920 2 /0
7921 2 /o oO
7923 4
7922 2 0
7924 V 4
item Qty.
B3 -, i. 1
B4 1
11 Iii 1,,. Óil
2D /11111`
1
P i n 1 NO' 6
2
item Qty.
SR2 1
® Door
Tür
Porte
® Puerta
DE
FR
B3
. , .a ,;' %
Item Qty.
B2
B4
01
2D
1
2
1
2
pini 779 12
® Door
Tür
Porte
CO Puerta
DE
FR
2D a . .._ \;,. Ill B4
Póil) 2D . , ,
B2
b
,
BE Door
ur
Por
® Puerta
FR
b
b
b QI. ; ` ` `. __` ..., -.i,i,.i wM.Y
Item Qty.
B1
E1
1
1
a
131
Item Qty.
R1 4. 1
pini 759 6
E1
DE
or
Tür
Porte
® Puerta
FR
b
coe
R1
c
:"."4"M11111 .
El
pini pin"!
Item Qty.
El
7938
7939
2
1
1
Item Qty.
7224 O1 2
466 e 2
El
El
` _ 7939
7938
10 mm
a 466
Tür
Porte
® Puerta
DE
FR
aZ
q e
8 dS: Luid
L
ii
60 'AO wall
LZINd
L ' Uli`' aZ
L
Or OO L3
L LZLNd 11.0 ua;l
60
V Luid
Z
I Ii
IV 60 110 wail
i LZ/
q
e
L
It 4 . 4 SL
Z
0 OO L3
Z LZLNd 110 wall
9
Item Qty.
PN134 1
R10 a 1
7608 i 1
pini 72 2
Item Qty.
B12
E13
1
2
n a
B12
Item Qty.
7942 1
pini 6
B12 7942
E13
E13
11
Item Qty.
7884 2
Op.
411
ell 1
466 e 8
r a
12
Item Qty.
R4 - 1
B5 1
7800 i 1
Item Qty.
12
am
1
pini 72 4
Item Qty.
E106 1
E105 1
E100 1
2D 1 /il 09 ¡ j 2
Ìjß
,'. . :) IDi llll` E100
Item Qty.
pini 6
7941 0 1
7940
oin
1
7224 0 2
466 e 2
--_ 2 '
a 7940
'---. E106
7941
E105
'---. C
Item Qty.
71 \ ° '\ \
1
7801
Is
1
pini 72 6
pini
b
Item Qty.
pini 4
7224 Di 2
466 e 2
a
pini
c
pint
i
i Item Qty.
BC1
A 2
V
q e
Z E) 9917
Z
it? LL17
L ££6L
L Z£6L
L í"' Ì LS
'kÒ wall
Mr-
3 a
L i 809L
L
f\ ̀ S L3
Z Luid
'AÒ wail
Ir
e
Z E) 9917
Z
it? LL17
L 17£6L
L S£6L
L , Ì -* LS
'kÒ wall
'AO uid
Luid
L
L
L3
CIZ
'kb
Ir a 'l ' , rII
11
111'
I 1 I1 I! V\
00: ÿ - `:
3
e
bl
17 6L Luid
L f 008L
L f LOL3
L
:, % '.. V L
110 wall
Item Qty.
pin1 6
E2 2
B2 1
-
8'x8'
8'x10'
Item Qty.
PN1 3
B2 6
E2 6
7936 2
pini 40
Item Qty.
PN1 4
B2 8
E2 8
7936 3
pini 56
Item Qty.
B2
11
01
4
1
1
Item Qty.
2D t4Illll
3
pini 7,2 16
-
T ! 11 3 11 ., 1 11 11 11 I UI_ 11 I
Item Qty.
10
09
2
1
2D
E2
7957
1
4
1
10
10
2D
E2
` 1
09 E2 ` 7957
11
a E2
Item Qty.
53 4l 1
7957 1
pini n2 16
''' . / +% -
a
a
b c
C
10
d
-- . Ó .
d
2D
09
Item Qty.
PN51 1
R10 4 .-., 1
7608 i 1
pini 2
Item Qty.
P53 2
E13
.40 2
B12 1
pini 79 6
J PN51
E13 r E13
B12
PN53 PN53
Item Qty.
R4
E2
E13
7800
B5
13
76
1
2
1
1
1
1
1
Item Qty.
09 ij jil
2
2D tV111`
10
1
7809
s
1
pini 20
13
B5
2D
E2
E2 09
E13 09
2D
Item
Qty.
pini
14
i
Item Qty.
BC1
A 2
40
Item Qty.
7937 1
a
N 1,-1 \ _.....,-4....._ \ a\l*............._
- I. , . l
41
CAULK / SILICON
43
Item Qty.
992 - _ _
,--1 4,0 2
586 1
Item Qty.
SF 1
45
1
a
. q 411
411
46
Item Qty.
7536 1
7533 1
7534 1
465
.` 111
M4x8mm
2
422
M4
2
7536
y 7 mm
7533
47
Item Qty.
7535 1
465
1111 M4x8mm
2
422
M4
2
a
et
yn 7 mm
L Z08L 110 Wall
ki
® Windows Location
DE
FR
Fenster Standort
Fenêtre Emplacement
® Ventana Ubicación
50
Item Qty.
7803 3
Item Qty.
Window 1
!II
a b
b 4043
x 7672
X3
C
4043
74
7674
O
54
Item Qty.
4043 llllll
5
Pl.
Item Qty.
PN55 3
7552 3
4043 1,0))llllll»)
4
Item Qty.
72
74
1
3
7552
r--i . . . 1 i
íL -,rg 9i
1,14411 ¡Ì1 II ii 0 i L !
58
Item Qty.
7949
Ì 1
1
7950
,_
1
a
Item Qty.
7952 2
7445 2
7950 7949
7952 , 1-,
7949
a
Item Qty.
7953 1
7951 1
411
40 6
466 = t id 2
a
r,o
d
d
i
a I
b "'1`'C . , I
i I i i
I ,
, , i ..
i a
7951 411
__o 411
----------®
Item Qty.
7898
466
411
2
8
4
a
411 +466
61
Item Qty.
7953 1
7951
Iv
1
7898 2
411 Ò
6
466 = 6
a
c
7898 466
' c+f
Item Qty.
7953 1
7952
L
1
7445 ao 00,
ra
b t 7445 X445
T
b
1 i
F.1 Item Qty.
7918 0 2
7920 2 /0
7924 rp
4
a
b
7924
7918
7920
x2
30cm 11.8"
30cm 11.8"
c
0
Item Qty.
7954
Item Qty.
8017 1
8017
Item Qty.
7923 4
7919 -:-_-=_.:,,
2
7921 2 0:4
7922 2 0
7924 4
a
o
o
o 1
b
OD- 7924
7921
OD
Item Qty.
DSN 1
a
70
Item Qty.
7912 1
0 (3=l
8039 41)
2
7913 0 1
7958 1
4043 Ql»»»
2
a
i
i
4043
"v.
Nog
4043
0
8039
7958
71
Item Qty.
7948 2 C®
,0 ® t 7994
I 1
7995 1
7996 ll
2
7442 4:10-0 4
a
7948
7996 l'- 7995
m
V
. '
7993
7948 7994
7993
7442
V - 7442
e
7442
-1 7442
(3)
master RION SunRoom8' V1 -7