G OTTA G O G REEN HOME of MAGNUM BOARD ® “The New Generation Building Material” “Install It...

GOTTA GO GREEN

HOME of MAGNUM BOARD®

“The New Generation Building Material”“Install It For Health-Install It For Life”

Helping The World Bounce Back

Magnum Board®

GOTTA GO GREEN



©2011, Magnum Board® All rights reserved.

©2011, Magnum Building Products. All rights reserved.

GOTTA GO GREEN



CURRENT INDUSTRY PROBLEM

Wood based products: Swells, rots, susceptible to insects such as termites and carpenter ants, flammable, can feed mold and mildew and when chemically treated may be toxic.

Portland cement based products: Respirable dust can be carcinogenic , difficult to work with (heavy), excessive expansion and contraction challenges.

Gypsum Based products: Susceptible to water and fire damage, known to feed mold and mildew, and is currently experiencing high rates of litigation due to chemical compounds that contribute to respiratory diseases and is corrosive to metals

Fiber resin based products: Susceptible to fire and its resultant off-gassing.


GOTTA GO GREEN



COST TO UNITED STATES RESULTING FROM KNOWN INDUSTRY PROBLEMS

Fire: According to a 2010 National Fire Protection Agency report, $18.6 billion in property damage was caused by fire.

Water: According to AMI, water intrusion is the primary reason for mold and mildew. In addition to this cost, as noted below, billions more are spent annually on water damage repair.

Insects: Western Pest Services reports that over $2 billion are spent annually on pest control and another $5 billion on pest damage and this covers TERMITES ONLY.


GOTTA GO GREEN



COST TO UNITED STATES RESULTING FROM KNOWN INDUSTRY PROBLEMS

Mold and Mildew: According to AMI, as far back as 2002, building material damage exceeded $25 billion and another $15 billion was attributed to illnesses associated with Mold and Mildew.

Toxins: According to Bob Connor and the Seattle PI Health and Fitness News, billions are spent annually as a result of toxin exposure.


GOTTA GO GREEN



Gypsum: Drying process utilizes over 1% of the power generatedin the US today and contributes greatly to global warming.

Portland Cement:Manufacturing process emits a great deal of CO2 into theatmosphere and releases particulate carcinogens into the air.

Wood Based Products: Every old growth forest cut down takes hundreds of years to fully regenerate the ECO system. Some of the adhesives used to make OSB contribute to respiratory issues due to out-gassing.


NEGATIVE ENVIRONMENTAL IMPACT FOR USING THESE COMPETITIVE PRODUCTS

GOTTA GO GREEN



SOLUTION (continued)

Magnum Board® (Trademark) is a GREEN product and is superior to its competitors for the following reasons:

Virtually impervious to fire• Non combustible• Zero flame spread• Zero smoke developed• UL approved

Virtually impervious to water• Can be submerged for long periods of time with no dimensional affects

Virtually impervious to all insects• Termites• Carpenter Ants


GOTTA GO GREEN



SOLUTION (continued)

Magnum Board® Products

• Do not feed mold or mildew• Are non-toxic – asbestos and formaldehyde free• Have no toxic VOCs• Absorbs CO2 from the air

Magnum Board® Products are gaining World recognition• Highest quality• Most tested MgO product on the market today

— Fully tested to AC386 published by the ICC-ES— Tested to US - ASTM standards— Underwriters Laboratory (UL) approved in US and Canada

• Strong R & D program to bring on newer, more competitive products• Most trusted MgO sheathing, siding and trim product supplier


GOTTA GO GREEN



MAGNUM® BOARD PRODUCT LINE


GOTTA GO GREEN



Magnum Sheathing


GOTTA GO GREEN




GOTTA GO GREEN



OTHER MAGNUM® PRODUCT APPLICATIONS


GOTTA GO GREEN



Exterior Insulation and Finish Systems

Skins for Structural Insulated Panels (SIPS) and Light Gauge Structural Steel Systems.

Fencing for Subdivisions, individual homes, farms ranches, by interstates and many other Fencing applications. Strong, long lasting,aesthetically pleasing and unaffected by any known insects.


GOTTA GO GREEN



MAGNUM® PRODUCT STORAGE, HANDLING & INSTALLATION GUIDELINES


GOTTA GO GREEN



Storing & Handling Magnum® Products Refer to MBP Storage and handling Guidelines No.: 083007-1338


GOTTA GO GREEN



Storing & Handling Magnum® Products Refer to MBP Storage and handling Guidelines No.: 083007-1338, Issue 3


GOTTA GO GREEN



Step 4Installing Magnum® Ceiling Board Refer to MBP Installation Guideline No.: 090509-1405, Issue 4

Step 1

Step 2

Step 3

Step 4


GOTTA GO GREEN



Installing Magnum® Sheathing - Standard Tape and Joint Compound Finish Refer to MBP Installation Guideline No.: 090509-1405, Issue 4

Using Tapered Product

Step 1

Step 2

Step 3


GOTTA GO GREEN




Step 4

Step 5

Step 6

Step 7


GOTTA GO GREEN




Step 8

Step 9

Step 10

Step 11


GOTTA GO GREEN



Step 13

Installing Magnum® Sheathing – Standard Tape and Joint Compound Finish Refer to MBP Interior Painting Guidelines No.: 071509-1235, Issue 1 (Sherwin Williams)

Step 12 - Optional

Step 14


http://www.picturesof.net/pages/081006-125242-420050.html

GOTTA GO GREEN



Installing Magnum® Sheathing Refer to MBP Interior Butt Joint Installation Guideline No: 051411-1412, Issue 1 or Exterior Butt Joint Installation Guideline No.: 111309-1108, Issue 3

Using Magnum Beveled Edge Product

Step 1

Step 2

Step 3


GOTTA GO GREEN



Shower Installation

Installing Magnum® Backer Board and Underlayment Refer to MBP Installation Guideline No: 090508-1545, Issue 2, prepared and endorsed by Mapei.

Standard installation

Tiling the Tub


GOTTA GO GREEN



Coming Soon

Installing Magnum® Wood Veneer Paneling Refer to MBP Installation Guideline No: 10010900, Issue 4


GOTTA GO GREEN



Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4

Wall Frame A

Wall Sheathing B

Weather Resistant

Barrier

C

“Z” Flashing D

Starter Strip E

Ledger Board F


GOTTA GO GREEN




Wall Frame A

Wall Sheathing B

Weather Resistant

Barrier

C

Step Flashing with 2”

Clearance

D

Starter Strip E

Roof Underlayment F

Roof Framing G

Roof Sheathing H


GOTTA GO GREEN




Wall Frame A

Wall Sheathing B

Weather Resistive

Barrier

C

Treated Bottom Plate D

Moisture Barrier E

Starter Strip F


GOTTA GO GREEN




Blind NailWe highly recommend installation of Magnum® Lap Siding by the blind nailing technique, such that fasteners are hidden by the course above (pic.1). Fasteners shall be installed between 1in and 1-1/8 in. from the top edge and no closer than 3/8 in. from the ends of the plank (pic.2).

Fasteners must be corrosion resistant, galvanized or stainless steel.

Overlap gauges help ensure straight and level Magnum® Siding installation


http://malcoproducts.com/product/roofing-siding-gutter/siding-fiber-cement/siding-tools-fiber-cement/gauges-speed-set

GOTTA GO GREEN




Pin BacksPinning the Magnum® Siding down at the bottom edge is a common practice called “pin back.” It is used to correct “high nailing”, loose planks, gaps or rattling. Pinning of the butt joints is not intended to increase wind load values; and shall be installed 3/8” from end and between 3/4” and 1” from bottom edge (pic.3). The fastener shall be installed flush to the surface (not countersunk), must be corrosion resistant (e.g. galvanized or stainless) and does not provide structural support. For best aesthetics nail heads should be touched up to color match.


GOTTA GO GREEN




Face NailingFace nailing is applicable where dictated by building code, in high wind areas, and when fastening is to OSB or equivalent sheathing without penetrating into studs.Face nailing exposes the fastener head to the elements and allows for the fastener to penetrate through two sheets of overlapped plank (pic.4

Fasteners shall be installed between 3/4” and 1” from the bottom edge of the board (pic.5) and the head must be snug, not counter-sunk or overdriven.


GOTTA GO GREEN



Magnum® Soffit is available ventilated and non-ventilated; and, in both wood grain and smooth profiles.

Installing Magnum® Ventilated and Non-Ventilated Soffit Refer to MBP Installation Guideline No: 112809-1202, Issue 2


GOTTA GO GREEN



Installing Magnum® Ventilated and Non-Ventilated Soffit Refer to MBP Installation Guideline No: 112809-1202, Issue 2

Fascia A

Wood Sub-fascia B

Siding C

Brick or CMU D

Starter Strip E


GOTTA GO GREEN



Installing Magnum® Board in Exterior Insulated Finish System (EIFS) Applications - Refer to Manufacturers Installation Guidelines


GOTTA GO GREEN



#8 Magnum® Products to Steel: Quik Drive or equal(Recommended steel thickness 16, 18 and 20 gauge)

Features:• #2 Undersized square drive – BIT2SU• Nibs under the head for easier countersinking• #2 drill point with wings• Ribbed flat head• Quik Guard® coating• Curved collation

Pro 200

Pro 250

Pro 300S

Model Shank Length TPI Point

Size

Carton Qty

CBSDQ158S

8 1 5/8” 18 2 1500 X X X

CBSDQ214S

10 2 ¼” 18 2 1000 X


GOTTA GO GREEN



#7 Magnum® Products to Wood – Quik Drive or equal

Features:• #2 Square drive – BIT2S• Nibs under the head for easier counter-sinking• Sharp point • Trim head• Available with yellow zinc

dichromate and gray phosphate

coatings• Curved collation

Pro 200

Pro 250

Pro 300S

Model Shank Length TPI

Point Size

Carton Qty

CBSDQ158S 8 1 5/8” 18 2 1500 X X X

CBSDQ214S 10 2 ¼” 18 2 1000 X


GOTTA GO GREEN



MAGNUM® PRODUCT INSTALLATIONS


GOTTA GO GREEN



Magnum® ModulesBeing factory assembled for field installation.


GOTTA GO GREEN



Magnum® ModulesFabricated in the factory for jobsite installation.


GOTTA GO GREEN



Magnum Board® Modules

Magnum Board is impervious to fire, water and all insects; is non combustible and non flammable; does not feed mold or mildew; and is completely non toxic and has no toxic VOCs


GOTTA GO GREEN



Magnum® Wall Section

Being shop assembled and readied for field installation.


GOTTA GO GREEN



Magnum® Wall Panels

Are rugged. These wall panels are enroute to a jobsite


GOTTA GO GREEN



Magnum® Wall Section

Being lifted into place at the jobsite.


GOTTA GO GREEN



field erected.

Magnum® GableFactory assembled field erected.


GOTTA GO GREEN



Magnum Board®

Is always safely packaged to ensure you receive top quality material at your point of delivery, every time.


GOTTA GO GREEN



Bahama Cottage

Magnum Board® products are approved for both interior and exterior sheathing applications.


GOTTA GO GREEN



Tarpon Springs, Florida Hotel Luxuriate

Notice the level 5 factory prepared finish achieved when using Magnum® interior sheathing


GOTTA GO GREEN


“The New Generation Building Material”“Install It For Health-Install It For Life”©2011, Magnum Building Products. All rights reserved.

Magnum® Interior Sheathing

Magnum® Sheathing is durable and flexible. Notice the curvatures in the bathroom.


GOTTA GO GREEN



Magnum® Interior Sheathing

Notice the curved bar in the kitchen of the Tarpon Luxuriate. Magnum® sheathing finishes easily and quickly saving installation time and money.


GOTTA GO GREEN



Magnum® Sheathing

Being installed in the interior and exterior of a retirement cottage high in the mountains of Georgia.


GOTTA GO GREEN



Magnum Board® Interior Sheathing

Installed at the office of Invision Architects, Tampa, Florida. Notice the level 5 finish and how smooth the cut outs are for their samples and product literature. ©2011, Magnum Building Products. All rights reserved.

GOTTA GO GREEN



Magnum Board® Receptionist Center

This beautiful receptionist center was built exclusively with Magnum Board® sheathing showing not only its beauty, but how easy it is to work with. The walls behind are also Magnum® Wall Board.


GOTTA GO GREEN



Magnum Structural Insulated Panel (SIP) Home

Magnum Board® is extremely versatile and can be substituted for most sheathing in the market place today providing a structure that is aesthetically pleasing and guaranteed to last for generations

See our website at www.magnumbp.com for more pictures of this beautiful structure.


http://www.magnumbp.com/

GOTTA GO GREEN



Composite Building Structures Ltd

ALT Technologies has selected Magnum Board® products for all sheathing and trim for their home structures. This is a display home being erected in their headquarters in FL. NASA tested to > 200mph wind resistance.


GOTTA GO GREEN



Eleuthera Bahamas Luxury Home

Magnum Board® products are being installed as both interior and exterior sheathing in this luxurious Bahamas home. Unaffected by the elements, no worries about weather damage during construction.


GOTTA GO GREEN



Mobile Bay Hurricane Proof Home

Magnum Board® was selected as the interior sheathing for this Hurricane Proof Home. See installations on next three-(3) slides.


GOTTA GO GREEN




Magnum Board® installed in the hallway.


GOTTA GO GREEN




Magnum Board installed in the foyer.


GOTTA GO GREEN




Magnum® Ceiling Board being installed.


GOTTA GO GREEN



Magnum Board Products are unique.

Tested to ICC AC386 and UL Approved

Cannot be compared to any other product on the market today.

Install it once – install it for health – install it For life

LETS HELP THEWORLD BOUNCE BACK

“TOGETHER”


GOTTA GO GREEN



See our website at: WWW.Magnumbp.com

Contact us at: [email protected], or [email protected]

Or call our home office at: 813-314-2202Facsimile No.: 813-314-2203

Often copied – never duplicated. Always demand the original

Magnum Board®

On Behalf of Mother Nature – Thank You


http://www.magnumbp.com/

mailto:[email protected]

G OTTA G O G REEN HOME of MAGNUM BOARD ® “The New Generation Building Material” “Install It...

Documents

Transcript of G OTTA G O G REEN HOME of MAGNUM BOARD ® “The New Generation Building Material” “Install It...