Food chemical safety. Chemical contaminants in foods Characteristics: They are not added...
-
Upload
toby-marsh -
Category
Documents
-
view
217 -
download
1
Transcript of Food chemical safety. Chemical contaminants in foods Characteristics: They are not added...
Food chemical safety
Chemical contaminants in foods
Characteristics:They are not added intentionally added to food.Contamination can happen at one or more stages in food production.Illness is likely to result if consumers ingest enough of them.The above differentiate from other chemicals in food such as vitamins and additives.
Examples of chemical contaminants
Pesticides
Herbicides
Fungicides
Veterinary drugs
Pesticides
“eat your fruits and vegetables” is one of the recommendations for a healthy diet.Use of pesticides and chemicals to protect fruits and vegetables against insects and pests, and moulds.Correct and responsible use of pesticides can enhanced yield and safety of these produce.
Use of pesticide
Must follow the limits sets by the Ministry for use on food commodity, and the safe amount of pesticide residue that may be present at the point of sale.
The safe residue level conform with the international standards set by Codex Alimentarius Commision.
Potential hazard?
Pesticide residue.
Contamination of surface and ground water.
Persistent pesticide not degradable are removed from the registration list.
Acceptable Daily Intake (ADI)ADI is a measure of toxicity.
Calculated from a known toxicological effect of a chemical (e.g. pesticide), example: increased serum glutamate pyruvate aminotransferase (SGPT) in dicator of liver damage.
The dose of the pesticide below the point at which the defined toxicological effect occurs in animal studies is determeined (NO Observable Adverse Effect Level – NOAEL).
This is the maximum dose that can be consumed without any adverse effect resulting.
ADI exceeds the level is rare, but cases of lindane in milk (UK in1996) and chlormequat in pears in 1999.
Maximum Residue Level (MRL)MRL is not a toxicological parameters but a trading standard set by national and international authorities (e.g. Codex Alimentarius) to ensure that residues are controlled in world food trade.
MRL is the pesticide residue level in particular food following its production according to Good Agricultural Practices (GAP) i.e. apply pesticide at the right time and according to label directions, appropriate withdrawal period (time necessary between application of pesticide and harvest); the crop is harvested and residue determined.
If the level of pesticide exceed the MRL, the crop has not been grown according to GAP and the product not permitted to be sold, imported or exported.
Exceeded the MRL has no health implication, but the farmer has breached the national or international regulations and is liable for prosecution.
Exceeding the MRL is more common.
Pesticides must be in harmony with non target pests and environment.Those broad-spectrum pesticides and have long residual effect were either removed from the market or restricted usage.The regulatory body is Pesticide Board of Malaysia under the preview of the Ministry.
Pesticides withdrawn or partially banned by the Pesticide Board of Malaysia
Aldrin withdrawn by the parent companyDiledrin ------do-----Benomyl -------do-----Chlordane total banDDT total banHeptochlor total banPenthachlorophenate partial ban – not allowed for paddyEndosulphan partial ban – not allowed for cocoa
and pepperLindane (gamma-BHC) partial ban – allowed for palm oil
and coconut only
(total 17 pesticides)
Pesticides not allowed for use on vegetables
Some organophosphate pesticides, e.g. methamidophos and monocrotophos, were registered for use in vegetables but after review by the Pesticide Board, they have been banned based on their residue or toxicology problems.All pesticides use in Malaysia must be registered.Comply the Pesticide Act 1974 and Food Act 1985, for the registration, production, management and application of pesticides.
DDT : organochlorine(1,1’-(2,2,2-trichloroethylidene)bis(4-chlorobenzene)
Dr. Paul Muller, a Swiss chemist won an Nobel Prize in Medicine in 1948 for DDT, replacing extremely dangerous chemicals for pest control (arsenic, lead and mercury).Effective against mosquitoes causing malaria, kill lice, improve health in Sri Lanka.1964 use of DDT was discontinued in Sri Lanka, and coincide with publication of Carson’s Silent Spring.Attack on DDT:
(i) cause thin egg shells. (ii) DDT is so stable and could never be eliminated from the environment. Safe for human? Cancer? (lipid solubles)
Repeated administration of DDT to animals results in tremor, incoordination, muscular twitching and weakness.
DDT is excreted in urine.
Organophosphate (OPs)
Oldest synthetic pesticides. Common names: organic phosphates, phosphate
insecticides, phosphorus esters or phosphoric acid esters. Genarally speaking they are most toxic to vertebrate
animals. Mode of action is similar to nerve gas (potent
cholinesterase). Attack nerve, death as a result of respiratory failure.
e.g. malathion, parathion. easily metabolized by esterase,low mammalian toxicity. Residues in food products do not normally result in
exposure sufficient to lead to health problems in humans. Pyrethroids “green” pesticide from chrysanthemum
(pyrethrum).
Other insecticides
Carbamates similar to Ops, water solubles, contaminated water.
mode of action; similar to Ops cholinesterase inhibitors.
Cyclodiene: e.g. aldrin and dieldrin, stable in soil and relative stable to uv of sunlight. Use to control soil insects. Mode of action is neurotoxicity.
Herbicides
Weed killers.Trace residues present in final food products.
Chlorophenoxy acid esters: 2,4-D and 2,4,5-TNo apparent adverse effects on human and animals.The 2,4,5-T used in Agent Orange contains excessive amounts of tetrachrodioxin, suspected toxic impurity.
Bipyridyliums: paraquat and diquat.On contact plant tissues are quickly damaged.Cases of accidental or suicidal fatalities from paraquat poisoning.
Fungicides
Chemicals used to kill or stop the development of fungi.
To treat plants, roots,seeds
Industrial and environmental contaminants
Most do not pose threats to human, but some certain incidences have indicated that they can be a potential hazard.
Halogenated hydrocarbons: polychlorinated Biphenyls (PCBs) or trade name Aroclor ® first synthesise in1881.Uses: insulating fluids in electrical industries, food packaging made from recycled paper, paints, lubricants, insulating tapes, fireproofing materials, and ink.Considerable resistant to acids, bases, high temperature, electrical current and is nonflammable.Safety: no significant health threats to human.
DioxinTCDD (tetrachlorodibenzo-p-dioxin) are among most potent toxicants known, chemically very stable and binds strongly to to solids or particulate matter in soil, is lipophilic but sparingly soluble in water or organic liquids.
LD50 for TCDD in guinea pig is under 1 mg/kg; hamster is more than 10g/kg.
Toxicity affect the kidney and skin, promoter of carcinogenesis and is a carcinogen. Liver tumors, tumors of the mouth, nose and lung have been found.
Three times more potent than aflatoxin B1.
In rhesus monkeys, TCDD is fetotoxic, resulting in higher levels of abortion and death in pregnant females.
Human exposure: no fatalities, toxic effects include fatigue, affect peripheral nervous system and liver toxicity.
Heavy metals
Mercury: exists in many forms.metallic mercury, inorganic mercury compounds or salts, organic mercury compounds.Nervous system is very sensitive to all forms of mercury. Exposure to high levels of metallic, inorganic or organic mercury can permanently damage the brain, kidneys and developing fetus.Mercury chloride and methyl mercury are possible human carcinogens.Children are more sensitive toChildren are more sensitive to mercury than are adults, can be passed through breast milk.
Mercury level in water
FDA maximum permissible level of 1ppm methyl mercury in seafoods.
EPA mercury in drinking water 2 ppm.
Lead
Previously, this heavy metal was found in a variety of consumer products (lead-based paints, antiknock petrol, lead-glazed glasses, lead water pipes, lead glazes, lead solders).Lead poisoning is normally due to occupational situations.Children are most affected, lead absorption in children is about 40%, adult 10%, highest in the bone.Anemia, neurological disorders in developing children brains, can pass from placenta to fetus.Elimination or minimize exposures.
Cadmium
Cadmium in food is as inorganic cadmiun salts. Organic cadmium is unstable.
In Japan, chronic cadmium intoxication over 12-yr period occurred in some population that consumed rice contaminated with cadmium because of pollution. Painful disease called itai itai meaning “ouch ouch” bone disease, with symptoms of skeletal deformation and multiple fractures.
Cadmium stays in the liver and kidneys.
Breathing air with very high levels of cadmium can severely damage the lungs and cause death.
Arsenic
Found as inorganic and organic compounds. In foods, drinking water, wine and other sources.Used widely in manufacture of glass to remove green colour cause by impurities.Previously arsenic is used to treat syphilis until penicillin and other sulfa drugs were developed.Arsenic is abundant in seafoods, but in an organic form, not toxic, rapidly absorbed and excreted in the urine and bile.Classical syndromes of chronic arsenic exposure include hyperkeratosis, corns and warts on the feet and hands.May be indirect carcinogen.10 to 50 ppb may be necessary to maintain homeostasis of the body, used successfully to treat acute promyelocytic leukemia (APL).Standard in drinking water is 10ppb.
Contaminants of Industrial and Environmental Origin
CHEMICAL
Polychlorinated biphenyls
Dioxin
Mercury
Lead
Cadmium
Radionuclides
SOURCE
Electrical appliances
Impurity
Chlor-alkali
Vehicle emission, smelting, paint, glazes, solder
Sludge, smelting
Accidental release
ASSOCIATED FOOD
Fish, animal fat
Fish, milk, beef fat
Fish
Vegetables, canned food, canned dish, acidic food
Grains, vegetables, meat, molluscs
Fish, mushrooms
Contaminants of Biological Origin(Inherent Plant Food Toxicants)
CHEMICAL
Oxalates
Glycoalkaloids
Cynide
Phytohaemagglutinin
Various carcinogens
ASSOCIATED FOOD
Tea
White potato (solanine)
Cassava, Lima beans
Red kidney beans and other beans
Herbs, spices
Contaminants of Biological OriginMycotoxins
CHEMICAL
Aflatoxin
Trichothecenes
Ochratoxin A
Ergot alkaloids
Patulin
Zearalenone
SOURCE
Aspergillus flavus and A. parasiticus
Mainly Fusarium spp
A. ochraceous
Claviceps purpurea
Penicillium claviforms
Fusarium spp
ASSOCIATED FOOD
Corn, peanuts, copra, milk
Cereals and other foods
Wheat, corn, barley
Barley, wheat
Apples and other fruits
Cereals, oils, starch
Minimum Water Activity for Growth of Toxigenic Moulds
Mould
Aspergillus flavus
Aspergillus ochraceus
Penicillium griseofulvum
Minimum Aw
0.81
0.78
0.83
Target Organs of Some Mycotoxins
Mycotoxin
Aflatoxin
Ochratoxin
Trichothecenes
Ergot alkaloids
Zearalenone
Target
Liver
Kidney
Mucosa
Peripheral vascular system
Uro-genital tract
Regulatory Limits for Mycotoxins in Foods
Mycotoxin
Aflatoxins B and G
Aflatoxin M1
Ochratoxin A
Deoxynivalenol
Patulin
Zearalenone
Limit (ppb)
0 - 50
10 – 1000
0 – 0.5
1 – 300
1000 – 4000
20 – 50
30 - 1000
Commodities
All foods
Animal feeds
Milk, dairy
Rice, corn, barley, beans, pork kidney
Wheat
Apple juice
All foods
Regulatory Limits for Aflatoxins in Some Asian Countries
Country
China
Hong Kong
India
Japan
Malaysia
Philippines
Singapore
Sri Lanka
Thailand
Limit (ppb)
50
20
15
30
10
10
20
Absence
30
20
Commodity
Peanuts
Peanuts
Other foods
All
All
All
All
All
Peanuts
All
Other Toxicants of Biological Origin
ChemicalCiguatera
Shellfish toxins:
Paralytic, neurotoxic, diarrheic and amnesic
Pyrrolizidine alkaloids
Histamine
SourceDinoflagellates
Dinoflagellates
Various toxic plants
Spoilage bacteria
Associated FoodTropical fish
Shellfish
Cereals, honey
Fish, cheese
Contaminants Produced During Processing
Polynuclear aromatic hydrocarbons
Heterocyclic amines, nitropyrenes
Nitrosamines
Oxidized fats
Ethyl carbamate (urethane)
Improperly Used Agrochemicals
Pesticides: Organochlorine insecticides Organophosphorus insecticide Carbamate insecticides Other pesticides
Animal Drugs: Antimicrobials Growth promotants Anthelminthics Therapeutics
Fumingants Fungicides Plant growth regulatorsFertilizers Herbicides RodenticidesNematocides Molluscicides Biotechnology
Direct Food Additives(Improperly Used Additives)
Anti-caking agents
Antimicrobial agents
Antioxidants
Colours
Curing and pickling agents
Emulsifiers
Enzymes
Firming agents
Flavour enhancers
Flavourong agents
Humectants
Leavening agents
Release agents
Non-nutritive sweeteners
Nutrient supplements
Nutritive sweeteners
Oxidizing and reducing agents
pH control agents
Propellants and gases
Sequestrants
Solvents and vehicles
Stabilizers and thickners
Surface-active agents
texturizers
Indirect Food Additives(improperly used)
Processing AidsIon-exchange resins, filter aidsEnzyme preparationMicroorganismsSolvents, lubricants, release agentsSpecific function additives
Food Contact materialsUtensilsWorking surfacesEquipment
Packing materialsMetals, plastics, paper, wood, etc.
Cleaning AgentsDetergentsSanitizers
Adultrants
Borax
Boric acid
Formaldehyde
Unapproved colouring agents.
Monitoring Points for Chemical Hazards
Point sourceEnvironmental compartmentsPrimary productionImport/exportProduction and processingConsumer levelBiomonitoring
Criteria for Establishing Priorities
Severity of potential effects on health
Levels in individual foods and the diet
Size and susceptibility of the exposed population
Significance in domestic and international trade
Nature and cost of management options
Chemical Hazards in the Home
Contaminated food and water
Metal cookware contaminated with heavy metals
Ceramic serving dishes with toxic glazes
Leaded crystal used with acid foods
Miscellaneous home-use chemicals
Chemical Hazards in Food
Toxicity
Exp
osur
e Areas
of
Concern
Potential Physical Hazards
Glass Slime or scum Metal Bone Plastic Stones and rocks Capsules or crystals Pits or shell Wood Paper
Distribution of Complaints of Foreign Objects in Foods
Soft drinks 19%
Infant foods 16%
Bakery 14%
Chocolate and cocoa products 7%
Fruits 7%
Cereals 5%
Vegetables 4%
Fish 3%
Others 25%
Possible Control Measures
Visual inspectionFilters or sievesMagnetsSeparation by densityPersonnel precautions
Assignment: search for literature for reports on interaction of selenium and heavy metals.