European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

41
5 July 2007 EASA Cologne Slide 1 European Aviation Safety Agency

Transcript of European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

Page 1: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 1

European Aviation Safety Agency

Page 2: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne

NPA 2007/07: Type trainingPart 66 Annex III Rulemaking task 66-011

EASA workshop05 July 2007

[email protected]

Page 3: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 3

European Aviation Safety Agency

66-011 Type training and examination standard

A few pieces of information affecting rulemaking task 66-011Amendment n°167 ICAO Annex 1Rulemaking task 21-039

Page 4: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 4

European Aviation Safety Agency

ICAO Annex 1 Licensing

New amendment n°167 (Tenth Edition) effective on July 2006, applicable on 23 November 2006Training should be “competency” based.It is flight operation orientated. No change for chapter 4 of Annex 1 (licences and rating for personnel other than flight crew members – especially for aircraft maintenance) and for Doc 7192 Part D-1 (training manual for aircraft maintenance)3 phases of learning process:

1) Knowledge 2) Skills 3) Experience

Page 5: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 5

European Aviation Safety Agency

ICAO Annex 1 Licensing

Creation of Doc 9868 about training (first edition February 2006) and associated to the ICAO annex 1

A methodology about ‘training” is given. Objectives / justification of a training need Task analysis and their formulation in an observable and measurable

fashion Continuous evaluation process to ensure the effectiveness of training Indicators for evaluation / Assessment, assessors, performance

oriented tests Performance or Criteria to be considered by the examiner when

assessing each competency / Definition of competency: a combination of skills, knowledge and attitude to perform a task to the prescribed standard /The tolerances applicable to all competency based tests

Page 6: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 6

European Aviation Safety Agency

21.039 Additional airworthiness specifications

for a given type of aircraft and type of operation

Rulemaking task 21-039Currently the following (for a given type of aircraft) are

approved by the NAA following a recommendation of the Joint Operational Evaluation Board (JOEB / JAA times), such as:

the minimum syllabus of pilot type rating training the MMEL …

Objective of task 21.039:To create in Part 21 the appropriate provisions describing how the Agency will approve the following additional airworthiness specifications for a given aircraft type, making them the minimum standard for all aircraft registered in the EU or operator by a European operator (lease in) to be used by the operators in order to develop their own training programmes, minimum equipment lists etc…

Page 7: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 7

European Aviation Safety Agency

21.039 additional airworthiness specifications for a given type of aircraft and type of operation

The most likely option is the TC holder to provide stakeholders with a minimum standard (approved by the Agency) to be used by the operator / Training organisation... This package could include:

- the need for a type rating- minimum syllabus of maintenance certifying staff type rating,

21.039 is now under progress and the chairman of 66-011 has been selected as member of the group to ensure coordination.An advanced-NPA / NPA could be ready by end 2007 (to be confirmed) in order to determine the best option (what we expect to regulate) and the content of the selected option will be drafted in 2008.A workshop will be organised after summer 2007: operators, training organisations, NAAs… will be invited; monitor http://www.easa.eu.int/home/events_en.html

Page 8: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 8

European Aviation Safety Agency

66-011 rulemaking task

66-011 Type training and examination standard (Part66 – Appendix III)

Page 9: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 9

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Unfortunately, elements from 21-039 are not available so far and are likely to be required only for new brand aircraft.From a standardization point of view, it is observed thatThere is significant variation in duration (for

example, duration of a type course for the same type and model can vary between 100 and 200h )

Too much room for interpretation is left for the content of the practical elements (no sufficient guidance).

Therefore, unequal treatment is reported in level, length and content

Page 10: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 10

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Some elements although quite extensive do not seem to be detailed enough to avoid too much significant variation in content and in duration.

The duration for the practical elements as specified in the current AMC (between two weeks and four months, based on the experience of the applicant) is not uniformly implemented: tendency was to limit the duration to two weeks, whatever the experience of the applicant was.

Page 11: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 11

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Current AMC 66.A.45(d) The practical training must comprise a period

of 4 months for applicants with no recent recorded previous practical experience of aircraft of comparable construction and systems, including the engines, but this can be reduced to a minimum of two weeks for applicant with such previous experience.

A programme of structured OJT may be prepared to satisfy the practical training requirement

The practical training should be supported by a detailed syllabus showing its content and duration (no existing guidance so far)

Page 12: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 12

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

The OJT program was mis-implemented. No cross reference to the practical training elements and its objectives

Standardization aspect: throughout the Member states.

The group was committed to fully review paragraph 66.A.45 (c) &(d) as well as Appendix III

Page 13: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 13

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

The term of reference was limited to large aircraft plus all aircraft where type training is required.

The group started to work in 2005 and 12 meeting were necessary:

Difficulties in solving the problems No perfect solution Areas of non-consensus or dissents The NPA was produced late behind the schedule.

66-011 group was composed of engineer association representative, industry and NAAs members. EAMTC was consulted.

Page 14: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 14

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

These facts encourage the following options:

Setting up a minimum duration for the theoretical elements and updating the current syllabus Defining a guidance or a syllabus to be adapted for the practical elements and/orReplace duration of the practical training (between two weeks and four months) by a fixed content.

Page 15: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 15

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Making a difference between practical training in a Part 147 environment and on the job training in a maintenance organisation environment (OJT)

On the job training for the first type training within a sub-category to be compelled in order to gain experience and competency.

Examination and assessment.

Page 16: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 16

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Some basic questionsDo we need the pre-requisites (eligibility requirement) of each individual applicant to be systematically checked before an applicant enters a training room in order to adapt the syllabus to the competence or experience of the trainee?

(Refer to point n°42 of the NPA where the opinion of the stakeholders is sought)

Do we need to recommend a minimum duration in hours for the theoretical elements?

Page 17: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 17

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

What NPA 2007/07 (task 66-011) will propose….

Page 18: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 18

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Theoretical trainingContent has been re-organised: new table available according to ATA chapter breakdown or subjects (in line with EAMTC proposal).Content has been updated to match new technology and new systemsThe concept of “minimum duration” is accepted (see next slides)

It does not mean that all course duration should be at the minimum: all course application must be supported by detailed training needs analysis.

Where the analysis shows that more hours are needed, course lengths shall be longer that the minimum specified in the table.

This training needs analysis will constitute a tool for the NAAs

Page 19: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 19

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Minimum duration of the theoretical elements

It is not easy to establish different classes or categories of aircraft that covers the wide range of aircraft and technology, only generic classes will be identified and “flexibility” should exist about the variation of that duration.Therefore a guidance about flexibility is given in order to reduce the length of a training course when needed: it should be based on justifications (training need analysis – 1st step towards “competency based training “) that have to be accepted by the NAA.

Page 20: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 20

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Minimum duration of the theoretical elements (…/…)

Therefore, the group decided to remain “generic” and only proposed three categories:

Aeroplanes with a MTOM of more than 5700kg. Aeroplanes with a MTOM of 5700kg and below where type

training is required; Multi-engine helicopters and helicopters where type

training is required.

A proposed guidance material for a better understanding…

Page 21: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 21

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Minimum duration of the theoretical elements (…/…)… GM 66.A.45(g)(1) Type/task training and ratingsThe minimum duration for type training has been determined based on generic categories of aircraft and minimum standard equipment fit.Deviation below the minimum duration is only permissible in exceptional circumstances. Training program reductions for a particular aircraft type must be approved by the competent authority on a case-by-case basis appropriate to the type. For example, while it would be exceptional for a theoretical knowledge course to be below the minimum duration shown for a large transport category aircraft such as an A330 or B757, it would not necessarily be exceptional in the case of a General Aviation (GA) business aircraft such as a Learjet 45 or similar. Typically the training needs analysis (TNA) for a GA aircraft course will demonstrate that a course of a shorter duration satisfies the requirement.

Page 22: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 22

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Aeroplanes with a maximum take-off mass of more than 5700kg:

B1.1: 150h B1.2: 120h B2: 100h C: 25h

Aeroplanes of a maximum take-off mass of 5700kg and below, where type training is required:

B1.1: 120h B1.2: 100h B2: 100h C: 25h

Multi-engine helicopters and helicopters where type training is required:

B1.1: 120h B1.2: 100h B2: 100h C: 25h

Page 23: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 23

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

A better distinction between the practical training and the OJT was proposed

There will be no more duration (“2weeks/4 months)For both cases, assessors should demonstrate training and experience on the assessment process being undertaken

Page 24: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 24

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Practical training A content or a table (list of tasks) is proposed (everything is “mandatory”) and the practical syllabus must be supported by either a detailed syllabus or practical logbook or worksheets showing content and duration

Location / functional or operational test / service and ground handling / removal or installation / MEL / Trouble shooting

Shall be assessed by approved assessorsDemonstration of practical training must be retained during 5 years by the approved organisation

Page 25: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 25

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

The OJTThe OJT is mandatory for the first type training in any subcategory (of the licence) (theoretical and practical) in a sub-category and is optionaloptional for the second or subsequent ones;The OJT shall be conducted by an approved MRO and approved by the NAA.The OJT should cover at least 50% of the Appendix II to AMCs (that has been updated)The OJT should be recorded in a harmonized mannerOJT shall be supervised (supervisor) and shall be assessed by approved assessors (AMC: F4). No pre-requisite management by Part 147

Page 26: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 26

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Why OJT in a maintenance environment?It is commonly accepted that true experience is

mostly gained in an approved maintenance organisation where an aircraft is likely to be more available for training purposes.

Few Part 147 organisations have permanent access to an aircraft and very few training organisations will perform maintenance for training purposes on an aircraft which is fit for fly because true trouble shooting cannot be performed and de-installation-re-installation could lead to a true failure.

Page 27: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 27

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Additional small amendments to fit to the overall changesBased on experience in the application of the current requirements and feedback received, some improvements have been taken into consideration:

The duration of type rating examination questions has been changed from a mixture of 75 and 120 seconds to 90 seconds for all levels in order to standardise question generation.

Page 28: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 28

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Additional small amendments to fit to the overall changes (…/…)

Changes to the number of questions per chapter to simplify the system presently in place.Highlighting that examination question level must be in proportion to the level of training conducted.Clarification on instructor requirements.A form 4 should be filled in for every assessor and proposed to the competent authority.

Page 29: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 29

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Responsibilities of the NAA related to type endorsementPractical training and OJT, when conducted by a maintenance organisation, shall be assessed, approved and audited by the competent authority.

When the type training is conducted in different organisations (PART 147 and/or approved maintenance organisations or direct course approval) the authority shall be satisfied that the interfaces are appropriately handled.

Page 30: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 30

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Responsibilities of the NAA related to type endorsement (…/…)In the case of second or subsequent type rating within a license sub-category the aircraft type has to be granted based on a Part-147 Certificate of Recognition in the case all applicable elements (theoretical and practical part) are performed within an approved part-147 organisation. This point has been raised because of a lack of mutual recognition between Member States.

Page 31: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 31

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Differences training has been addressedSome AMC are now binding (raised at the level of the implementing rules)Consistency with other rulemaking tasks such as 66-006 (privileges of B1/B2 licences engineers)One member suggested that the engine running practical task, presently optional within Part-66 appendix III should be a mandatory practical training task. Dissent area (paragraph 42 to be commented)

Page 32: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 32

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

(SUM-UP)

IMPACT and TRANSITION PERIOD

Page 33: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 33

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

a) for Part-147 Maintenance Training Organisations:

Amendment of MTOEGeneration of Training Needs Analysis (TNA) for all coursesDevelop and amend course materialReview of examination questionsDevelopment of practical training schedules

Page 34: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 34

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

b) for Part-145 / Part-M Maintenance Organisations:

Amendment of MOE / MOMDevelopment of procedures for practical training/ OJTTraining and appointment of practical training/ OJT AssessorsDevelopment of for practical training/ OJT schedules

Page 35: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 35

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

C) for Competent Authorities:Review of existing proceduresDevelop new procedures for the oversight of practical training/ OJTTraining of Surveyors/ Inspectors

Page 36: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 36

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

d) for students:Formal use of logbookRequirement for assessment of practical training

Page 37: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 37

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Transition provisions / Entry into force(a) A period of 90 days has been proposed before entry into force of this Regulation amendment.(b) Applicants for an initial Part-147 maintenance training organisation approval that are already subject to the applicable investigation process on the date of entry into force of this Regulation amendment, are subject to the requirements applicable prior to the entry into force of this Regulation amendment.…/…

Page 38: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 38

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Transition provisions / Entry into force…/…(c) Part-147 approved maintenance training organisations applying for approval of new type courses may elect not to apply this Regulation amendment until 15 months after the date of entry into force of this Regulation amendment. Partial implementation of selective items of this Regulation amendment is not allowed.(d) The provisions of paragraph 2(c) shall also apply to organisations applying to the competent authority for approval of type courses not imparted by Part-147 approved maintenance training organisations.…/…

Page 39: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 39

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Transition provisions / Entry into force (…/…)(e) Competent authorities shall accept and process applications for type course approval submitted under paragraphs 2(c) and 2(d).(f) Type courses approved in accordance with the requirements applicable prior to the entry into force of this Regulation amendment can only be imparted until 15 months after the date of entry into force of this Regulation amendment. Certificates for those type courses issued not later than 15 months after the date of entry into force of this Regulation amendment shall be considered as issued in accordance with this Regulation amendment.

Page 40: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 40

European Aviation Safety Agency

66-011 Type training and examination standard (App III)

Future of this rulemaking task Bridge with rulemaking task 21-039 (some elements

have been already passed to this group) Consistency between 66-011 and 21-039 will have to be and will be enhanced

21-039 will only give the minimum syllabus but it will be responsibility of the training providers to build a course IAW 66-011 guidelines / recommendations

It is unlikely that a catch up program will be mandatory: “optional catch up programme” is more likely to happen: the training syllabus IAW 66-011 will remain valid. In any case, transition period to bridge will be proposed and the former training certificates will remain valid.

If something wrong happen with 21.039, 66-011 will apply. Entry into force for 66-011 would be before 21-039.

Page 41: European Aviation Safety Agency 5 July 2007 EASA Cologne Slide 1.

5 July 2007 EASA Cologne Slide 41

European Aviation Safety Agency

www.easa.europa.eu

END