8/12/2019 Erect Scaffolding

1/2

Talisman Malaysia LimitedHS&E Section

Job Safety Analysis

Doc. No: PM3-HSE-GEN-PR-F-00!

Re"ision: 0Date: J#ne $00%Pae: A''en(i) 3

JOB SAFETY ANALYSIS WORKSHEETS

JOB SAFETY ANALYSIS DATE PERMIT NO:

JOB Erect scaffolding.WORK TEAM Scaffolder

SEQUENCE OF BASIC JOB STEPS POTENTIAL ACCIDENTS OR HAZARDS RECOMMENDED SAFE JOB PROCEDURES

1. Raise Cold Work Permit for the job. Conf lict with others activities.

2. Insect the site location. Wrong location. Refer to drawing and s!ervisor.

". Sort o!t the scaffold material needed andtransfer to the site location.

#and$ finger inj!ries% &inger inched. 'ri and fall. Wear rigger(s gloves. Coordinate lifting andmaterial handling.

). Scaffolder climbs str!ct!re and rearesfo!ndation$ sec!res anchor fittings.

Sli and fall. Wear safet* harness.

+. #andling of scaffolding materials at height andtighten co!lers in lace.

&alling materials. ,aterial handling well coordinated.

-. Install ladder for safe access. Insect and !tSC/&'/0(.

Sli and fall. se roer bod* harness.

WHAT TO CHECK AND NOT LIMITED TO WITH REFERENCE TO APPENDIX 1 & 2 OF THE JOB SAFETY ANALYSIS SECTION OF MOGP MANUAL

EXPERIENCE YES NO YES NO

#ave *o! done this job before $/re *o! knowledgeable with the job to beerformed

$

#ave *o! referred to technical drawing$vendorroced!re$SSP

$ Is s!ervision$e3erienced assistance re4!ired $

PPE YES NO YES NO

#ard hat $ Work vest $

Safet* 0lasses $ /ron $

Safet* shoes $ 0oggle $

Ear l!gs $ &ace shield $

Right t*e of gloves $ Resirator* rotection $

Safet* harness $POTENTIAL HAZARDS YES NO YES NO

Slier* floor $ 'raed ress!re $

Congested area $ Press!ri5ed e4!iment$vessel ha5ard $

'riing $ &ire$e3losion ha5ards $

6verhead work $ Escae ro!te $

Working at height $ Shock$electricit*$static $

TML MANAGING OPERATIONS WITH GENERAL PROCEDURES Rev. 0

8/12/2019 Erect Scaffolding

2/2

Talisman Malaysia LimitedHS&E Section

Job Safety Analysis

Doc. No: PM3-HSE-GEN-PR-F-00!

Re"ision: 0Date: J#ne $00%Pae: A''en(i) 3

Scaffolding $ 7reaker rack o!t $

Sec!re ladder $ 8alve isolation $

#eav* load $ 0!ard rotating e4!iment $

#ammer strikes $ Power tools ha5ards $Pinch$tra finger% hand $ #igh noise area% do!ble ear rotection $

7ack inj!r* ha5ard $ Sark$hot slag $

Swinging object $ 7!rn 9heat$chemical: $

&alling object $ ;ear radioactive materials$so!rces $

6thers closeb* $ Environmental sill $

Shar object $ #ose connection $

E*e inj!r* $ Wind* $

0rating$deck oening $

7locked drains $

Preared b*=>.................................... Reviewed b*= >>>>>>>>>>.. Closed o!t= ?????????????????????????

TML MANAGING OPERATIONS WITH GENERAL PROCEDURES Rev. 0