)BMM 45/% )€¦ · )BMM 45"/% ) " Created Date: 2/21/2013 8:40:51 AM
ENVIRONMENT MONITORING REPORT · BMM Ispat Ltd., for their valuable co-ordination & support during...
Transcript of ENVIRONMENT MONITORING REPORT · BMM Ispat Ltd., for their valuable co-ordination & support during...
BBeellllaarr
ENVIRONMENT MONITORING REPORT
BMM Ispat Ltd.,
DDaannaappuurr VViillllaaggee,, HHoossppeett TTaalluukk,,
rryy DDiissttrriicctt,, PPIINN--558833222222,, KKaarrnnaattaakk
ENVIRONMENT MONITORING REPORT
SSttaaggee 22 UUnniittss
FFoorr
JJUULLYY--22001166
Prepared By
GLOBAL ENVIRONMENT & MINING SERVICES
NABL Accredited Laboratory (Consulting Engineers, Mine Designers, Geologists & Surveyors)
3rd main road, Basaveswara badavane
HOSPET – 583201, Dist., Bellary (Karnataka)
Tel : 08394 – 651111,229433
Mobile : +919448479433/9449830533
e-mail : [email protected]
Website : globalmining.in
BMM Ispat Ltd.,
kkaa
ENVIRONMENT MONITORING REPORT
ENVIRONMENT & MINING SERVICES
(Consulting Engineers, Mine Designers, Geologists & Surveyors)
, Dist., Bellary (Karnataka)
Mobile : +919448479433/9449830533
BMM Ispat Ltd.,
PREFACE
The Industries should monitor environmental parameters as per the frequency and
locations given in the CFE/CFO. And the same should be submitted on every month to the
respective pollution control board.
As part of the conditions and inherent concern on health of the employees and
surroundings M/s. BMM Ispat Ltd., as appointed M/s. Global Environment & Mining Services,
HOSPET, to carry out the environmental pollution monitoring on Fugitive monitoring
within the plant, Stack monitoring and Noise pollution and submit the same to the Pollution
Control Board.
Accordingly, M/s. Global Environment & Mining Services, HOSPET, carried out the pollution
monitoring as per the standard sampling methods prescribed by CPCB, for Fugitive
monitoring within the plant, Stack monitoring for all chimneys, and Noise monitoring as
per the CFO. These monitoring has been carried out in a frequency as mentioned in the CFO
and the same report is being submitted to the Board.
We sincerely thank to officials of M/s. BMM Ispat Ltd., for their valuable co-ordination &
support during the sampling and reporting.
for GLOBAL Environment & Mining Services
Place: Hospet
Date: 05.08.2016 S. Kameswara Rao
(Managing partner)
ENVIRONMENTAL MONITORING
GLOBAL Environment & Mining Services
1.0 EXECUTIVE SUMMARY
1.1 INTRODUCTION
The journey of the BMM Group is a reflection of the path tread by every
entrepreneur who believes in the human potential and one’s own ability to bring
life affirming change that transcends time. BMM Group was born out of this committed
belief of Late Shri Udaichand
Entrenched in the Indian ethos, with an astute understanding of market needs,
values and sensibilities Mr. Dinesh Kumar Sin
has built the BMM Group on sound fundamentals since 1998. He steered the company
towards growth by being the first mining company to establish a power generation plant
for captive use, and creating a steel plant
BMM has been able to add value to every relationship under his able and dynamic
leadership.
Today, BMM is a 4900 Crores
optimal usage of technology to
always believed in the principle of sharing and hence continues to transfer this benefit
derived from sustained growth to its employees, partners and associates. The unique value
proposition that defines the very fabric of the BMM culture is the firm's belief in
unleashing this 'potential in tones’ in terms of its human capital, continuous growth and
consistent benefits to its stakeholders.
The human potential at BMM is reflected in the depth of domain
diverse sectors and dynamism of youth at various levels in the Organization. Business
operations lead by professionals with decades of market understanding and a dynamic
team enables BMM to deliver superior product quality. It is this hum
keeps BMM attuned to scaling new heights and meeting customer expectations. While
consistently adding value to its partners, BMM is sensitive to its responsibility towards the
environment by implementing best practices in its Business Ope
society through various social Endeavours’
RING REPORT M/S. BMM ISPAT LIMITED
GLOBAL Environment & Mining Services .1
EXECUTIVE SUMMARY
INTRODUCTION
The journey of the BMM Group is a reflection of the path tread by every
entrepreneur who believes in the human potential and one’s own ability to bring
life affirming change that transcends time. BMM Group was born out of this committed
Singhi.
Entrenched in the Indian ethos, with an astute understanding of market needs,
Mr. Dinesh Kumar Singhi inherited the legacy from his father and
has built the BMM Group on sound fundamentals since 1998. He steered the company
towards growth by being the first mining company to establish a power generation plant
for captive use, and creating a steel plant from the captive ore mine. Over the last 12 years,
BMM has been able to add value to every relationship under his able and dynamic
00 Crores Company due to its focus on market orientation and
optimal usage of technology to achieve process efficiency and value addition. BMM has
always believed in the principle of sharing and hence continues to transfer this benefit
derived from sustained growth to its employees, partners and associates. The unique value
es the very fabric of the BMM culture is the firm's belief in
unleashing this 'potential in tones’ in terms of its human capital, continuous growth and
consistent benefits to its stakeholders.
The human potential at BMM is reflected in the depth of domain expertise across
diverse sectors and dynamism of youth at various levels in the Organization. Business
operations lead by professionals with decades of market understanding and a dynamic
team enables BMM to deliver superior product quality. It is this human potential that
keeps BMM attuned to scaling new heights and meeting customer expectations. While
consistently adding value to its partners, BMM is sensitive to its responsibility towards the
environment by implementing best practices in its Business Operations and contribution to
society through various social Endeavours’.
. BMM ISPAT LIMITED.,
The journey of the BMM Group is a reflection of the path tread by every
entrepreneur who believes in the human potential and one’s own ability to bring about a
life affirming change that transcends time. BMM Group was born out of this committed
Entrenched in the Indian ethos, with an astute understanding of market needs,
inherited the legacy from his father and
has built the BMM Group on sound fundamentals since 1998. He steered the company
towards growth by being the first mining company to establish a power generation plant
from the captive ore mine. Over the last 12 years,
BMM has been able to add value to every relationship under his able and dynamic
ompany due to its focus on market orientation and
achieve process efficiency and value addition. BMM has
always believed in the principle of sharing and hence continues to transfer this benefit
derived from sustained growth to its employees, partners and associates. The unique value
es the very fabric of the BMM culture is the firm's belief in
unleashing this 'potential in tones’ in terms of its human capital, continuous growth and
expertise across
diverse sectors and dynamism of youth at various levels in the Organization. Business
operations lead by professionals with decades of market understanding and a dynamic
an potential that
keeps BMM attuned to scaling new heights and meeting customer expectations. While
consistently adding value to its partners, BMM is sensitive to its responsibility towards the
rations and contribution to
ENVIRONMENTAL MONITORING
GLOBAL Environment & Mining Services
BMM has a commitment of being a
achieving business goals through ethical means. BMM hence has been able to have deeper
relevance to society by creating value that is inclusive and truly benefits all.
1.2 PROMOTERS OF THE PROJECT
BMM Group, one of the leading Steel,
achieved the present level under the leadership and guidance of Sri Dinesh Kumar
Singh, the Founder & Chairman
to globalize the company business and do value addition
and in a sustainable manner in exploring, exploiting, excavating and processing
minerals followed by setting up steel plant facilities.
BMM is a step towards forward integration
works is located at:
BMM ISPAT LIMITED
(Registered Office & Works)
#114, Danapura
Hospet
Bellary Dist., Karnataka
Phone
Fax -
1.3 Site Location
BMM ISPAT LIMITED is located at Danapur about 15 Kms away from
Karnataka. The plant site can be connected
1 km away from the NH-13 near Danapura village. The nearest railway station is Hospet;
BMM ISPAT plant view
RING REPORT M/S. BMM ISPAT LIMITED
GLOBAL Environment & Mining Services .2
BMM has a commitment of being a good Corporate Citizen and is
achieving business goals through ethical means. BMM hence has been able to have deeper
by creating value that is inclusive and truly benefits all.
PROMOTERS OF THE PROJECT
BMM Group, one of the leading Steel, Power & Mining companies in India that has
achieved the present level under the leadership and guidance of Sri Dinesh Kumar
Chairman of the group, is promoting the project. His vision is
to globalize the company business and do value addition by operating responsibly
and in a sustainable manner in exploring, exploiting, excavating and processing
minerals followed by setting up steel plant facilities.
is a step towards forward integration has set up new merchant Bar
BMM ISPAT LIMITED
(Registered Office & Works)
114, Danapura
Hospet - 583 222
Bellary Dist., Karnataka
Phone +91 08394-264000, +91 9686550808/09
- 08394 264010
BMM ISPAT LIMITED is located at Danapur about 15 Kms away from
Karnataka. The plant site can be connected by national highway, viz. NH-13. The plant is
13 near Danapura village. The nearest railway station is Hospet;
plant view
. BMM ISPAT LIMITED.,
good Corporate Citizen and is committed to
achieving business goals through ethical means. BMM hence has been able to have deeper
Mining companies in India that has
achieved the present level under the leadership and guidance of Sri Dinesh Kumar
. His vision is
by operating responsibly
and in a sustainable manner in exploring, exploiting, excavating and processing
merchant Bar Mill. The
BMM ISPAT LIMITED is located at Danapur about 15 Kms away from Hospet in
13. The plant is
13 near Danapura village. The nearest railway station is Hospet;
ENVIRONMENTAL MONITORING
GLOBAL Environment & Mining Services
Bangalore is at a distance of 300 kms. Seaport is Belikere and Karwar,
is in the private sector belonging to JSW, a Jindal Group company at Thoranagallu
(Vidyanagar).
M/s. BMM ISPAT Ltd., Has accorded Environmental Clearance for 2.0 MTPA
Integrated Steel Plant, with the following facilities.
S.N.
1 Iron ore beneficiation plant 2 Palletizing Plant 3 DRI Plant4 Coke Oven5 Sinter Plant6 Blast furnace7 EAF & BOF Steel making 8 Continuous casting machines
9 Rolling mills : Structurals/wire rods
10 Oxygen Plant11 Calcining12 Cement Plant13 Power Plant
Out of the above units, presently
Thermal Power Plants have been commissioned on August 2011
Pellet Plant-2 are commissioned on March
have commissioned on Jan 2013
plants are commissioned on August 2015.
implementation.
Hence environmental pollution
iron plants, 1X70 MW Thermal Power Plant, 1.3MTPA Benefici
Plant, 2X70MW Power plant, SMS, and RML
1.4 The report includes environmental monitoring data collected at above site for the
month of July-2016. The Parameters monitored are:
� Fugitive Dust Level
� Stack Emission
RING REPORT M/S. BMM ISPAT LIMITED
GLOBAL Environment & Mining Services .3
Bangalore is at a distance of 300 kms. Seaport is Belikere and Karwar, the nearest Airport
is in the private sector belonging to JSW, a Jindal Group company at Thoranagallu
M/s. BMM ISPAT Ltd., Has accorded Environmental Clearance for 2.0 MTPA
Integrated Steel Plant, with the following facilities.
Items Capacity Iron ore beneficiation plant 3.40 MTPAPalletizing Plant 1.20 MTPADRI Plant 0.70 MTPACoke Oven 0.80 MTPASinter Plant 2.50 MTPABlast furnace 1.70 MTPAEAF & BOF Steel making shop 2.30 MTPAContinuous casting machines Slab Caster Billet Caster
1.10 MTPA1.10 MTPA
Rolling mills : Hot strip mill Structurals/wire rods
1.00 MTPA1.00 MTPA
Oxygen Plant 2x500 TPDCalcining 1,080 TPDCement Plant 1.40 MTPAPower Plant 230 MW
Out of the above units, presently 4 x 500 TPD Sponge Iron Plants and
have been commissioned on August 2011. Beneficiation plan
commissioned on March 2012. 2X70 MW Thermal based power plants
have commissioned on Jan 2013, EAF, Steel Making Shop, CCM, Rolling Mill, Oxygen
plants are commissioned on August 2015. Remaining units are under various stages of
pollution monitoring is being carried out for 4 x 500 TPD sponge
iron plants, 1X70 MW Thermal Power Plant, 1.3MTPA Beneficiation, 1.2MTPA Pellet
, SMS, and RML.
The report includes environmental monitoring data collected at above site for the
. The Parameters monitored are:
Fugitive Dust Level
Stack Emission
. BMM ISPAT LIMITED.,
the nearest Airport
is in the private sector belonging to JSW, a Jindal Group company at Thoranagallu
M/s. BMM ISPAT Ltd., Has accorded Environmental Clearance for 2.0 MTPA
3.40 MTPA 1.20 MTPA 0.70 MTPA 0.80 MTPA 2.50 MTPA 1.70 MTPA 2.30 MTPA
1.10 MTPA 1.10 MTPA
1.00 MTPA 1.00 MTPA 2x500 TPD
TPD 1.40 MTPA
230 MW
and 1X70 MW
Beneficiation plant-2,
70 MW Thermal based power plants
, EAF, Steel Making Shop, CCM, Rolling Mill, Oxygen
Remaining units are under various stages of
s being carried out for 4 x 500 TPD sponge
ation, 1.2MTPA Pellet
The report includes environmental monitoring data collected at above site for the
ENVIRONMENTAL MONITORING
GLOBAL Environment & Mining Services
Important Note: Ambient Air Quality & Water Quality data are common for both
Stage-I & Stage-II. Hence,
1.5 Study:
The data collection programmeis givenbelow:
1.6 Fugitive Emission Monitoring
Ambient Air Quality was monitored
for SPM analyzed by gravimetric method
Plant area, and material handling
night) &Annexure – 1/B(2ndFort night)
1.7 Stack Monitoring
Vayubhodhan Stack sampler VSS1 stack
gas. Sulphur dioxide and oxides of Nitrogen in the flue gas
gas solution respectively and the analysis of the pollutants were done as per the Indian
Standard procedures prescribed by CPCB/BIS. Stack
the statutory requirement on twice in a month, and the results given in
Fort night)& Annexure – 2/B
1.8 Stack Emissions Monitoring Methodology
1.9 Sampling Procedure
Pre Sampling Activities
Weigh the properly conditioned thimble/filter and place it into the clean, air tight
Container. Designate appropriate label or ID No. to each thimble/filter container.
Particulate matter emission of “Stack Monitoring
Sampling.
Field activity starts with the collection of detailed information from the industry
about the products, raw materials, fuels, and stack dimensions.
1.10 Traverse Point Calculation
Calculate the traverse point and accordingly mark the distance from t
Nozzle, on Pitot tube and probe. Do not forget to add the collar length of port to the
RING REPORT M/S. BMM ISPAT LIMITED
GLOBAL Environment & Mining Services .4
Ambient Air Quality & Water Quality data are common for both
II. Hence, Please refers Stage-I report for the same.
collection programmeis givenbelow:
Emission Monitoring
Ambient Air Quality was monitored 48 samples were collected from the
by gravimetric method.Work Zone Air quality was monitored at all
handling area air quality status given in Annexure –
Fort night) .
ampler VSS1 stack monitoring was used for drawing the flue
gas. Sulphur dioxide and oxides of Nitrogen in the flue gas were sampled by bubbling flue
gas solution respectively and the analysis of the pollutants were done as per the Indian
Standard procedures prescribed by CPCB/BIS. Stack Emission level was monitored as per
the statutory requirement on twice in a month, and the results given in Annexure
2/B(2nd Fort night)
Stack Emissions Monitoring Methodology
Sampling Procedure Activities
Weigh the properly conditioned thimble/filter and place it into the clean, air tight
Container. Designate appropriate label or ID No. to each thimble/filter container.
matter emission of “Stack Monitoring – Material and Methodology for
Field activity starts with the collection of detailed information from the industry
about the products, raw materials, fuels, and stack dimensions.
Traverse Point Calculation
Calculate the traverse point and accordingly mark the distance from t
Nozzle, on Pitot tube and probe. Do not forget to add the collar length of port to the
. BMM ISPAT LIMITED.,
Ambient Air Quality & Water Quality data are common for both
samples were collected from the analyzed
Work Zone Air quality was monitored at all
1/A (1 st Fort
used for drawing the flue
by bubbling flue
gas solution respectively and the analysis of the pollutants were done as per the Indian
Emission level was monitored as per
Annexure – 2/A(1st
Weigh the properly conditioned thimble/filter and place it into the clean, air tight
Container. Designate appropriate label or ID No. to each thimble/filter container.
Material and Methodology for iskinetic
Field activity starts with the collection of detailed information from the industry
Calculate the traverse point and accordingly mark the distance from tip of the
Nozzle, on Pitot tube and probe. Do not forget to add the collar length of port to the
ENVIRONMENTAL MONITORING
GLOBAL Environment & Mining Services
calculated traverses. For detailed calculation of “Stack Monitoring
Methodology for iskinetic sampling
1.11 Determination of Dust Concentration
Determine the mass of dust collected in the thimble by difference i.e. weighing the
thimble before and after the run. Dry the thimble in an oven for about 2 hours at
120o C prior to sampling. After sampling, cool, dry and again weigh the thimble
along with dust maintaining the same condition as prior to sampling
1.12 Fortnightly fugitive air quality was 159.1 µg/m3, maximum valueFugitive Monitoring results of
0
500
1000
1500
2000
2500
3000
3500
1 2 3 4 5 6
1ST FORTNIGHT FUGITIVE AIR QUALITY DATA
SPM
(µg/m3)
0
500
1000
1500
2000
2500
1 2 3 4
2ND FORTNIGHT FUGITIVE AIR QUALITY DATA
RING REPORT M/S. BMM ISPAT LIMITED
GLOBAL Environment & Mining Services .5
calculated traverses. For detailed calculation of “Stack Monitoring– Material and
sampling.
Determination of Dust Concentration
Determine the mass of dust collected in the thimble by difference i.e. weighing the
thimble before and after the run. Dry the thimble in an oven for about 2 hours at
C prior to sampling. After sampling, cool, dry and again weigh the thimble
dust maintaining the same condition as prior to sampling
Fortnightly fugitive air quality was monitored all plant area SPM value , maximum value 1825 µg/m3,and average value 477.69
Fugitive Monitoring results of 2 nd
Fortnight is mentioned in graph.
7 8 9 10 11 12 13 14 15 16 17 18 19 20
1ST FORTNIGHT FUGITIVE AIR QUALITY DATA
SPM
(µg/m3) Standard
5 6 7 8 9 10 11 12 13
2ND FORTNIGHT FUGITIVE AIR QUALITY DATA
SPM
(µg/m3)
SPM
(µg/m3) Standard
. BMM ISPAT LIMITED.,
Material and
Determine the mass of dust collected in the thimble by difference i.e. weighing the
thimble before and after the run. Dry the thimble in an oven for about 2 hours at
C prior to sampling. After sampling, cool, dry and again weigh the thimble
SPM value minimum 477.69 µg/m3. The
20 21 22
13 14
ENVIRONMENTAL MONITORING
GLOBAL Environment & Mining Services
1.13 Stack emission level was
2nd Fort Night Minimum
Average Value 48.57 mg/Fortnight is mentioned in graph
1.15 Conclusion
All the monitored Environmental parameters were found to be well within the
statutory norms– and the same are enclose
0
20
40
60
80
100
120
1 2
1 st FORTNIGHT STACK MONITORING RESULTS
0
20
40
60
80
100
120
140
160
1 2 3
2 nd FORTNIGHT STACK MONITORING RESULTS
RING REPORT M/S. BMM ISPAT LIMITED
GLOBAL Environment & Mining Services .6
Stack emission level was monitored all chimneys’ PM values (g/Nm3)
Minimum Value 27.6 mg/Nm3, Maximum Value 92.4
mg/Nm3. The Stack Monitoring results of 1
st Fortnight
ortnight is mentioned in graph.
All the monitored Environmental parameters were found to be well within the
and the same are enclosed as follows.
3 4 5 6 7 8 9
1 st FORTNIGHT STACK MONITORING RESULTS
PM
(mg/ Nm3)
Standard
4 5 6 7 8 9 10 11 12 13
2 nd FORTNIGHT STACK MONITORING RESULTS
PM
(mg/ Nm3)
Standard
. BMM ISPAT LIMITED.,
)
92.4 mg/Nm3 &
ortnight & 2 nd
All the monitored Environmental parameters were found to be well within the
10
13 14
FORTNIGHTLY FUGITIVE AIR QUALITY
1. Name of the Industry : BMM Ispat
2. Sample collected by : GLOBAL Environment & Mining Services NABL Certificate No. Date of Validity 0
3. Particulars of sample collected : RDS Sampler
4. Report to sent : 05
5. Method adopted : IS 5182 (Part
Sl.N0. Location / Plant
I. Beneficiation Plant-II
1. Ball Mill Area (Zero Meter)
2. Between Concentrate & Tailing Thickner
3. FC 25 conveyor
II. Pellet Plant-II
4. TG Zero Meter
5. Boiler Furnace
6. PGP
III. Sponge Iron Division -2 (Kiln 1 & 2)
7. Control room
8. Near Weigh bridge (dispatch)
9. Pellet Storage bin
IV. Sponge Iron Division -2 (Kiln 3 & 4)
10. Near Control room
11. Near Coal crusher
12. Near Product bin
V. Wagon Tipper/RMHS
13. Near Tipping point
14. CPU DE System
15. Old Compressor room
VI. Power Plant-70 MW
16. 70MW-DM Plant (Near R.O. Plant)
17. Coal Screen (near gate weigh bridge)
18. CFBC boiler
VII. 2X70MW Power Plant
19. Near Boiler
20. Near Coal storage Shed
VIII . SMS Area
21 Stock House/Vibro feeders
22 Laddle Tapping
23 Slag Pouring Area
IX. BAR MILL
24 Near Reheating Furnace
Note: SPM - Suspended Particulate matter (µg/m
Analyzed By Environmental Engineer (G.Aarathi)
Note: 1. The result listed refers only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. 2. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.3. This report is not to be reproduced wholly or in part & cannot be used as
advertising media without special permission in writing.4. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to
GLOBAL ENVIRONMENT & MINING SERVICES
Annexure-1/A (1 st Fort Night)FORTNIGHTLY FUGITIVE AIR QUALITY DATA MONITORING JU
BMM Ispat Ltd., Danapur, Hospet Taluk, Bellary District.
: GLOBAL Environment & Mining Services, Hospet. NABL Certificate No.T- 3553 Date of Validity 06.08.2017 RDS Sampler (AAS 217 BL) (GEMS-01, GEMS-02,GEMS-03, GEMS
5.08.2016
IS 5182 (Part 4) : 2006
Location / Plant Date Of
Monitoring
Date Of
Sample Receipt
SPM
(µg/m
01.07.2016 02.07.2016 334.5
Between Concentrate & Tailing Thickner 01.07.2016 02.07.2016 224.3
01.07.2016 02.07.2016 617.8
SHUTDOWN
01.07.2016 02.07.2016 205.2
2 (Kiln 1 & 2)
02.07.2016 04.07.2016 441.2
Near Weigh bridge (dispatch) 02.07.2016 04.07.2016 571.9
02.07.2016 04.07.2016 217.4
2 (Kiln 3 & 4)
02.07.2016 04.07.2016 1014.0
04.07.2016 05.07.2016 249.2
04.07.2016 05.07.2016 1213.1
04.07.2016 05.07.2016 464.5
04.07.2016 05.07.2016 258.7
05.07.2016 06.07.2016 402.3
DM Plant (Near R.O. Plant) 05.07.2016 06.07.2016 260.5
Coal Screen (near gate weigh bridge) 05.07.2016 06.07.2016 338.8
05.07.2016 06.07.2016 296.4
06.07.2016 07.07.2016 245.0
06.07.2016 07.07.2016 337.6
06.07.2016 07.07.2016 445.5
06.07.2016 07.07.2016 208.9
07.07.2016 08.07.2016 320.1
07.07.2016 08.07.2016 235.0
µg/m3) INFERENCE: The Measured Values are within the limits
Authorised sign Technical Manager
(G.Aarathi) (K.Ramakrishna Reddy)
only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.
ced wholly or in part & cannot be used as evidence in the Court of law & should not used any special permission in writing.
Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Hospet jurisdiction only.
ENVIRONMENT & MINING SERVICES
(1 st Fort Night) JULY -2016
03, GEMS-04)
SPM
µg/m3) Standard
334.5 2000
224.3 2000
617.8 2000
2000
2000
205.2 2000
441.2 2000
571.9 2000
217.4 2000
1014.0 2000
249.2 2000
1213.1 2000
464.5 2000
258.7 2000
402.3 2000
260.5 500
338.8 500
296.4 500
245.0 500
337.6 500
445.5 3000
208.9 3000
320.1 3000
235.0 3000
Authorised signatory Technical Manager
(K.Ramakrishna Reddy)
only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.
in the Court of law & should not used any
jurisdiction only.
FORTNIGHTLY FUGITIVE AIR QUALITY
1. Name of the Industry 2. Sample collected by : GLOBAL Environment & Mining Services
3. Particulars of sample collected 4. Report to be sent 5. Method adopted
Sl.N0. Location / Plant
I. Beneficiation Plant-II
1. Ball Mill Area (Zero Meter)
2. Between Concentrate & Tailing Thickner
3. FC 25 conveyor
II. Pellet Plant-II
4. TG Zero Meter
5. Boiler Furnace
6. PGP
III. Sponge Iron Division -2 (Kiln 1 & 2)
7. Control room
8. Near Weigh bridge (dispatch)
9. Pellet Storage bin
IV. Sponge Iron Division -2 (Kiln 3 & 4)
10. Near Control room
11. Near Coal crusher
12. Near Product bin
V. Wagon Tipper/RMHS
13. Near Tipping point
14. CPU DE System
15. Old Compressor room
VI. Power Plant-70 MW
16. 70MW-DM Plant (Near R.O. Plant)
17. Coal Screen (near gate weigh bridge)
18. CFBC boiler
VII. 2X70MW Power Plant
19. Near Boiler
20. Near Coal storage Shed
VIII . SMS Area
21 Stock House/Vibrofeeders
22 Laddle Tapping
23 Slag Pouring Area
IX.BAR MILL
24 Near Reheating Furnace
Note: SPM - Suspended Particulate matter
Analyzed By
Environmental Engineer G.Aarathi
Note: 1. The result listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor i2. Samples will be destroyed after one month from 3. This report is not to be reproduced wholly or in part & cannot be used as
advertising media without special permission in writing.4. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to
GLOBAL ENVIRONMENT & MINING SERVICES
Annexure-1/BFORTNIGHTLY FUGITIVE AIR QUALITY DATA MONITORING JU
Name of the Industry : BMM Ispat Ltd., Danapur, Hospet Taluk, Bellary District Sample collected by : GLOBAL Environment & Mining Services
NABL Certificate No.T- 3553 Date of Validity 06.08.2017
Particulars of sample collected : RDS Sampler (AAS 217 BL) (GEMS-01, GEMS-02,GEMS
: 05.08.2016 Method adopted : IS 5182 (Part 4 ) : 2006
Location / Plant Date Of
Monitoring
Date Of
Sample Receipt (µg/m
25.07.2016 26.07.2016 257.3
Between Concentrate & Tailing Thickner 25.07.2016 26.07.2016 243.9
25.07.2016 26.07.2016 159.1
SHUTDOWN
25.07.2016 26.07.2016 216.2
2 (Kiln 1 & 2)
26.07.2016 27.07.2016 530.8
Near Weigh bridge (dispatch) 26.07.2016 27.07.2016 314.3
26.07.2016 27.07.2016 187.4
2 (Kiln 3 & 4)
26.07.2016 27.07.2016 712.8
27.07.2016 28.07.2016 817.9
27.07.2016 28.07.2016 1672.6
27.07.2016 28.07.2016 361.9
27.07.2016 28.07.2016 1825.4
28.07.2016 Due to Rain
Plant) 28.07.2016
Due to Rain Coal Screen (near gate weigh bridge) 28.07.2016
28.07.2016
30.07.2016 31.07.2016 1
30.07.2016 31.07.2016 824.7
29.07.2016
Due to Rain 29.07.2016
29.07.2016
29.07.2016 Due to Rain
Suspended Particulate matter (µg/m3) INFERENCE: The Measured Values are within the limits
Analyzed By Authorised signatory Environmental Engineer Technical Manager
K.Ramakrishna Reddy
The result listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor iSamples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.This report is not to be reproduced wholly or in part & cannot be used as evidence in the Court of law & should not used any
special permission in writing. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Hospet jurisdiction only.
ENVIRONMENT & MINING SERVICES
/B (2nd Fort Night) JULY-2016
: BMM Ispat Ltd., Danapur, Hospet Taluk, Bellary District
02,GEMS-03, GEMS-04)
SPM
µg/m3) Standard
257.3 2000
243.9 2000
159.1 2000
2000
2000
216.2 2000
530.8 2000
314.3 2000
187.4 2000
712.8 2000
817.9 2000
1672.6 2000
361.9 2000
1825.4 2000
2000
500
500
500
171.8 500
824.7 500
3000
3000
3000
3000
The Measured Values are within the limits.
Authorised signatory Technical Manager K.Ramakrishna Reddy
The result listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. the date of issue of test certificate unless otherwise specified.
in the Court of law & should not used any
jurisdiction only.
STACK MONITORING RESULTS
1. Name of the Industry : BMM Ispat Ltd., Danapur,
2. Sample collected by : GLOBAL Environment & Mining Services
3. Particulars of sample collected : Vayubodhan Stack sampler
Si.
No Stack Attached to
Date of
Monitoring Fuel Used
1 Pellet Plant-2 ESP
2 2X500TPD Sponge iron kiln1&2 ESP 02.07.2016
3 2X500TPD Sponge iron kiln3&4 ESP 04.06.2016
4 1 X 70MW-CFBC Boiler ESP 01.07.2016
5 2X70MW -CFBC Boiler ESP 01.07.2016
6 SMS 05.07.2016
7 Bar mill 05.06.2016 Furnace Oil
Chimneys attached to Bag Filter (De dusting Units)
Beneficiation Plant-2
1 Iron Ore Cone Crusher
2 Iron Ore Screening
Pellet Plant-2
3 Additive grinding mill
4 Mixer building
5 Pellet discharge point
2 X 500 TPD Sponge Iron Kiln 1 & 2
6 Cooler Discharge -1&2 02.07.2016
7 Coal stock house 02.07.2016
8 Production Separation bin-1&2 02.07.2016
9 Production Separation bin-3&4 04.06.2016
10 Transfer House 04.06.2016
Analyzed By Environmental Engineer
G.Aarathi Note:
1. The results listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. 2. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.3. This report is not to be reproduced wholly or in part & cannot be used as 4. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdic
Parameter
Particulate Matter (mg/Nm3) IS : 11255 (Part 1) - 1985 (reaffirmed 200
SO2 (mg/Nm3) IS :11255 (Part 2) : 1985 (reaffirmed
NO2 (mg/Nm3) IS :11255 (Part 7) : 2005
GLOBAL ENVIRONMENT & MINING SERVICES
STACK MONITORING RESULTS Annexure
Danapur, Hospet Taluk, Bellary district
: GLOBAL Environment & Mining Services NABL Certificate No.T- 3553 Date of Validity 06.08.2017Particulars of sample collected : Vayubodhan Stack sampler VSS 1 Sl.No. 304 DTB 07 Month : JULY
Fuel Used Ta OC
TS OC
V
m/Sec
HEIGHT
(m)
Diameter
(m) PM
mg/Nm3 mg/Nm
Coal SHUTDOWN
Coal 29 148 5.93 70 3.00 68.2
Coal 29 147 5.97 70 3.00 72.4
Coal 70 3.00 Due to Rain
Coal 110 8.00 Due to Rain
Coal 86 2.40 Due to Rain
Furnace Oil 87 3.00 Due to Rain
NOT IN OPERATION
SHUTDOWN
--- --- 30 1.20 46.4
--- --- 30 1.20 36.8
--- --- 30 1.20 41.6
--- --- 30 1.20 43.4
--- --- 30 1.20 46.8
Note :
SO2 - Sulphur dioxide
NO2 - Nitrogen dioxide
PM - Particulate matter
Analyzed By Authorised signatory Environmental Engineer Technical Manager
G.Aarathi K.Ramakrishna Reddy
applicable parameters. Endorsement of products is neither inferred nor implied. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.
t be used as evidence in the Court of law & should not used any advertising media withoutTotal liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdiction only.
Protocol
1985 (reaffirmed 2009)
11255 (Part 2) : 1985 (reaffirmed 2014)
11255 (Part 7) : 2005 (reaffirmed 2005)
ENVIRONMENT & MINING SERVICES
Annexure – 2/B (2nd Fort Night)
Date of Validity 06.08.2017
LY - 2016 Results Standards
PM
(mg/ Nm 3)
SO2
mg/Nm3
NO 2
mg/Nm3
50
66.72 30.64 100
54.84 24.82 100
Due to Rain 100
Due to Rain 50
Due to Rain 150
Due to Rain 150
50
50
50
50
50
---- ---- 50
---- ---- 50
---- ----- 50
---- ---- 50
---- ---- 50
Authorised signatory
K.Ramakrishna Reddy
without special permission in writing.
STACK MONITORING RESULTS
1. Name of the Industry : BMM Ispat
2. Sample collected by : GLOBAL Environment & Mining Services
3. Particulars of sample collected : Vayubodhan Stack sampler
4. Month : JULY -
Sl.
No Stack Attached to
Date of
Monitoring
Chimneys attached to Bag Filter (De dusting Units)
2X500 TPD Sponge Iron Kiln 3&4
12 Coal Primary Screen
13 Coal Stock House -1 & coal stock house-2
14 Cooler Discharge -1 04.07.2016
15 Cooler Discharge -2 & PSB transfer tower 04.07.2016
16 Production Bunker & Intermediate bin
17 Production Separation bin 04.07.2016
18 Pellet Stock house
19 Dolochar Stock House 1 & 2
20 CPU Building
Analyzed By Environmental Engineer
G.Aarathi
Note:
1. The result listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. 2. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.3. This report is not to be reproduced wholly or in part & cannot be used as evidence in the Court of law & should not used any advertising media without special permission in writing.4. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdic
Parameter
Particulate Matter (mg/Nm3) IS : 11255 (Part 1) - 1985 (reaffirmed 2009)
SO2 (mg/Nm3) IS 11255 (Part 2) : 1985 (reaffirmed 2014)
NO2 (mg/Nm3) IS 11255 (Part 7) : 2005 (reaffirmed 2005)
GLOBAL ENVIRONMENT & MINING SERVICES
STACK MONITORING RESULTS
BMM Ispat Ltd., Danapur , Hospet Taluk, Bellary district.
Sample collected by : GLOBAL Environment & Mining Services NABL Certificate No.T- 3553 Date of Validity 06.08.2017Particulars of sample collected : Vayubodhan Stack sampler VSS 1 Sl.No. 304 DTB 07
2016 (2nd Fort Night)
Monitoring
Fuel
Used
Ta OC
TS OC
V
m/Sec
HEIGHT
(m)
Diameter
(m) PM
mg/Nm3
--- --- 30 1.20 Not in Operation
--- --- 30 1.20
.2016 --- --- 30 1.20 41.2
.2016 --- --- 30 1.20 36.4
--- --- 30 1.20 Not in
.2016 --- --- 30 1.20 42.8
--- --- 30 1.20
Not in Operation--- --- 30 1.20
--- --- 30 1.20
Note :
SO2 - Sulphur dioxide
NO2 - Nitrogen dioxide
PM - Particulate matter
Authorised signatory Technical Manager
K.Ramakrishna Reddy
applicable parameters. Endorsement of products is neither inferred nor implied. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.
cannot be used as evidence in the Court of law & should not used any advertising media without special permission in writing.Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdiction only.
Protocol
1985 (reaffirmed 2009)
IS 11255 (Part 2) : 1985 (reaffirmed 2014)
IS 11255 (Part 7) : 2005 (reaffirmed 2005)
ENVIRONMENT & MINING SERVICES
Annexure – 2/B
Date of Validity 06.08.2017
Results Standards
PM
(mg/ Nm3) SO2
mg/Nm3
NO 2
mg/Nm3
Not in Operation 50
50
---- ---- 50
---- ---- 50
Not in Operation 50
---- --- 50
Not in Operation
50
50
50
Sulphur dioxide
Nitrogen dioxide
Authorised signatory
cannot be used as evidence in the Court of law & should not used any advertising media without special permission in writing.
STACK MONITORING RESULTS
1. Name of the Industry : BMM Ispat Ltd.,
2. Sample collected by : GLOBAL Environment & Mining Services
3. Particulars of sample collected : Vayubodhan Stack sampler
Si.
No Stack Attached to
Date of
Monitoring
1 Pellet Plant-2 ESP
2 2X500TPD Sponge iron kiln1&2 ESP 25.07.2016
3 2X500TPD Sponge iron kiln3&4 ESP 27.07.2016
4 1 X 70MW-CFBC Boiler ESP 28.07.2016
5 2X70MW -CFBC Boiler ESP 28.07.2016
6 SMS 29.07.2016
7 Bar mill 29.07.2016
Chimneys attached to Bag Filter (De dusting Units)
Beneficiation Plant-2
1 Iron Ore Cone Crusher
2 Iron Ore Screening
Pellet Plant-2
3 Additive grinding mill
4 Mixer building
5 Pellet discharge point
2 X 500 TPD Sponge Iron Kiln 1 & 2
6 Cooler Discharge -1 & 2 26.07.2016
7 Coal stock house 26.07.2016
8 Production Separation bin-1 & 2 26.07.2016
9 Production Separation bin-3&4 26.07.2016
10 Transfer HouseE 26.07.2016
Analyzed By Environmental Engineer
G.Aarathi Note:
1. The results listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. 2. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.3. This report is not to be reproduced wholly or in part & cannot be used as 4. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdic
Parameter
Particulate Matter (mg/Nm3) IS : 11255 (Part 1) - 1985 (reaffirmed 200
SO2 (mg/Nm3) IS :11255 (Part 2) : 1985 (reaffirmed 20
NO2 (mg/Nm3) IS :11255 (Part 7) : 2005
GLOBAL ENVIRONMENT & MINING SERVICES
STACK MONITORING RESULTS Annexure – 2/B(2nd Fort Night
BMM Ispat Ltd., Danapur, Hospet Taluk, Bellary district.
Sample collected by : GLOBAL Environment & Mining Services NABL Certificate No.T- 3553 Date of Validity 06.08.2017Particulars of sample collected : Vayubodhan Stack sampler VSS 1 Sl.No. 304 DTB 07 Month : JU
Fuel
Used
Ta OC
TS OC
V
m/Sec
HEIGHT
(m)
Diameter
(m) PM
mg/Nm3
Coal SHUTDOWN
Coal 31 148 5.61 70 3.00 92.4
Coal 29 146 5.78 70 3.00 86.8
Coal 31 144 5.90 70 3.00 27.6
Coal 30 159 6.18 110 8.00 46.6
Coal 30 109 13.22 86 2.40 42.0
- 27 261 8.34 87 3.00 30.6
NOT IN OPERATION
SHUTDOWN
--- --- 30 1.20 49.2
--- --- 30 1.20 32.7
--- --- 30 1.20 46.1
--- --- 30 1.20 42.5
--- --- 30 1.20 48.9
Note :
SO2 - Sulphur dioxide
NO2 - Nitrogen dioxide
PM - Particulate matter
Analyzed By Authorised signatory Environmental Engineer Technical Manager
G.Aarathi K.Ramakrishna Reddy
applicable parameters. Endorsement of products is neither inferred nor implied. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.
t be used as evidence in the Court of law & should not used any advertising media withoutTotal liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdiction only.
Protocol
1985 (reaffirmed 2009)
11255 (Part 2) : 1985 (reaffirmed 2014)
11255 (Part 7) : 2005 (reaffirmed 2005)
ENVIRONMENT & MINING SERVICES
2nd Fort Night)
Date of Validity 06.08.2017
JULY- 2016 Results Standards
PM
(mg/ Nm 3)
SO2
mg/Nm3
NO 2
mg/Nm3
50
62.84 26.48 100
52.68 18.24 100
76.82 31.84 100
64.28 22.46 50
- - 150
- - 150
50
50
50
50
50
---- ---- 50
---- ----
---- ---- 50
---- ----- 50
---- ---- 50
Authorised signatory
K.Ramakrishna Reddy
without special permission in writing.
STACK MONITORING RESULTS
1. Name of the Industry : BMM Ispat
2. Sample collected by : GLOBAL Environment & Mining Services
3. Particulars of sample collected : Vayubodhan Stack sampler
4. Month : JULY -
Sl.
No Stack Attached to
Date of
Monitoring
Chimneys attached to Bag Filter (De dusting Units)
2X500 TPD Sponge Iron Kiln 3&4
12 Coal Primary Screen
13 Coal Stock House -1 & coal stock house-2
14 Cooler Discharge -1 27.07.2016
15 Cooler Discharge -2 & PSB transfer tower 27.07.2016
16 Production Bunker & Intermediate bin
17 Production Separation bin 27.07.2016
18 Pellet Stock house
19 Dolochar Stock House 1 & 2
20 CPU Building
Analyzed By Environmental Engineer
G.Aarathi
Note:
1. The result listed refer only to the tested samples & applicable parameters. Endorsement of products is neither inferred nor implied. 2. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.3. This report is not to be reproduced wholly or in part & cannot be used as evidence in the Court of law & should not used any advertising media without special permission in writing.4. Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdic
Parameter
Particulate Matter (mg/Nm3) IS : 11255 (Part 1) - 1985 (reaffirmed 2009)
SO2 (mg/Nm3) IS 11255 (Part 2) : 1985 (reaffirmed 2014)
NO2 (mg/Nm3) IS 11255 (Part 7) : 2005 (reaffirmed 2005)
GLOBAL ENVIRONMENT & MINING SERVICES
STACK MONITORING RESULTS
BMM Ispat Ltd., Danapur , Hospet Taluk, Bellary district.
Sample collected by : GLOBAL Environment & Mining Services NABL Certificate No.T- 3553 Date of Validity 06.08.2017Particulars of sample collected : Vayubodhan Stack sampler VSS 1 Sl.No. 304 DTB 07
- 2016 (2nd Fort Night)
Monitoring
Fuel
Used
Ta OC
TS OC
V
m/Sec
HEIGHT
(m)
Diameter
(m) PM
mg/Nm3
--- --- 30 1.20 Not in Operation
--- --- 30 1.20
27.07.2016 --- --- 30 1.20 48.4
27.07.2016 --- --- 30 1.20 47.9
--- --- 30 1.20 Not in Operation
27.07.2016 --- --- 30 1.20 48.2
--- --- 30 1.20
Not in Operation--- --- 30 1.20
--- --- 30 1.20
Note :
SO2 - Sulphur dioxide
NO2 - Nitrogen dioxide
PM - Particulate matter
Authorised signatory Technical Manager
K.Ramakrishna Reddy
applicable parameters. Endorsement of products is neither inferred nor implied. Samples will be destroyed after one month from the date of issue of test certificate unless otherwise specified.
cannot be used as evidence in the Court of law & should not used any advertising media without special permission in writing.Total liability of our laboratory is limited amount. Any dispute arising out of this report is subject to Bangalore jurisdiction only.
Protocol
1985 (reaffirmed 2009)
IS 11255 (Part 2) : 1985 (reaffirmed 2014)
IS 11255 (Part 7) : 2005 (reaffirmed 2005)
ENVIRONMENT & MINING SERVICES
Annexure – 2/B
Date of Validity 06.08.2017
Results Standards
PM
(mg/ Nm3) SO2
mg/Nm3
NO 2
mg/Nm3
Not in Operation 50
50
---- ---- 50
---- ---- 50
Not in Operation 50
---- --- 50
Not in Operation
50
50
50
Sulphur dioxide
Nitrogen dioxide
Authorised signatory
cannot be used as evidence in the Court of law & should not used any advertising media without special permission in writing.