Electric wiring kit for towbars / 7-pin / 12N / 12 Volt ......Toyota Pro Ace 04/2013 - 01/2016...

1/14

Revision: 0 / 24.06.2019PE-059-B1U

ECS Electronics UKThe Old DyehouseMacclesfieldCheshire, SK11 7RN UK

Email-sales: [email protected]: [email protected]

SALE: +44 (0) 7980 847124TECHNICAL: +44 (0) 7440 202052WEB: www.ecs-electronicsuk.co.uk

Part No: PE-059-B1U

This electric kit has to be installed by a professional workshop or a suitable qualified person.The installation instructions must have been read and fully understood before the start of any installation. Please contact your wiring kit provider or the hotline shown in the footer should you need assistance!Make sure the vehicle is approved/homologated by the manufacturer to tow a trailer! Also please check that there is a definite compatibility between this vehicle and the electric kit!Following the installation of the electric kit, the fitting instructions should be kept together with the vehicle service document and vehicle handbook. The fitting instructions contain important information relating to the use and function of the towing kit as well as for any diagnostic or activation process, that might have to be repeated in the future (e.g. after the performance of a vehicle software update).All warranty claims will be forfeited if the electric kit or components contained therein are used incorrectly or modified. If a towing socket adaptor has been used to connect to the trailer or bike rack, this must be removed from the trailer socket once the trailer or bike rack has been disconnected.If the trailer or bike rack is not equipped with a rear fog lamp, depending on the towing vehicle type, the correct function of the towing kit cannot be guaranteed. In such cases, a rear fog lamp should be retro fitted.This towing electric kit will not be covered under warranty if any technical or electrical modifications or software updates have been performed by the vehicle manufacturer after the initial commissioning of the kit. That applies especially to modifications or updates which may cause malfunctions in the trailer socket or any other part of the trailer electrical equipment!Depending on the type of trailer module used in this electric kit, diagnostic interrogation with the vehicle’s electrical system may be limited or will not function. The error memory inside the trailer module may not be able to be accessed by vehicle manufacturers diagnostic system.Error logs relating to the trailer electrical equipment, that may be generated in the vehicle manufacturers diagnostic system as a result of a test procedure, may be due to the incorrect installation of the towing electric kit or the false activation of the trailer module.We always recommend whenever possible, the following troubleshooting process: An analysis of the vehicle’s error memory and possibly clearing of all faults before the start of the installation! Try disconnecting the trailer module from the towing harness and re-start the fault clearing process! If in doubt, limit the time for troubleshooting to a max of 0,5 hours and call our Technical Support Team!Please follow our instructions carefully and always test the towing electrics using a true lighting board or a specifically designed bulb tester. If an LED tester is used, ensure it is equipped with correct load resistors or malfunctions will occur! This instruction is subject to changes and we reserve the right to make changes to design, colour etc. All of the data and illustrations may not be an exact representation but the text contained in this instruction must be observed!

Citoen Jumpy 01/2007-Fiat Scudo 01/2007-Peugeot Expert 01/2007-Toyota Pro Ace 04/2013 - 01/2016

Electric wiring kit for towbars / 7-pin / 12N / 12 Volt / ISO 1724

3-7

8-12

2/14

Revision: 0 / 24.06.2019PE-059-B1U




Fog off extension harness

Optional SP-161-ZZ

Pag. 8-9

30 Amp.

30 Amp.

20 Amp.

20 Amp. U3

3x 3x 2x

1x

1x1x1x

1x 1x 1x1x

L2

X

L1

L3

G

M

F 1x

U1

M

2x 4x

*************** -->

Part No: *********

1/**

Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK

SALETE

Revision: * / **********RC-MIT001-7 /*******

Web: www.rightEmail: sales@right


SALETE

Web: wwwEmail: sales@righ

Product overview

Pag. 14

UN-243-YZ

Optional reverse lamp pre-wire extension included

20 Amp.

20 Amp.

3/14

SYMBOL EXPLANATION

TOOLS

ATTENTION!

ATTENTION!

Left (58-L) respectivelyRight (58-R) tail light

Stop light (54) / high mounted, third stop light (54)

Turn signal indicator left

Turn signal indicator right

Rear fog light(s)

Reversing light(s)

Trailer / trailer recognition

Permanent current power supply

Ground or Earth (31)

Ground connection battery terminal lug

Permanent power supply / 13pin socket, chamber 9

Charging wire for trailer battery / 13pin socket, chamber 10

+

15+

+

30+

Positive connection battery terminal lug

54 STOP

L

R

Reverse

B+/30

Fuse / fuse capacity 20 Ampère

Cigarette lighter /accessory socket

Loudspeaker / buzzer

Park Distance Control

Switch / source of function

Connect together

Disconnect

Look at / See further information

Look carefully at selected area

Present / Occupied / OK

Not present / Not occupied / Not OK

Acoustic indication

Attention / important advice

20 Amp.

20 Amp.

12V

In order to avoid mal-functions and damage to the vehicle’s electrical system the earth terminal must be disconnected from the vehicle’s battery before starting work!

Both the trailer module and the vehicle’s control unit for the electrical system can be damaged during workon the data bus connections if the battery is not disconnected!

Please pay attention to the manufacturer’s instructions when disconnecting and reconnecting the vehicle’s battery!

The vehicle's cooling capacity may have to be increased when retrofitting a trailer coupling!You must observe the manufacturer's instructions!!

!Code

3:3

Note: It may be necessaryto check if this vehicle hasa stored radio code beforedisconnecting the battery!

Co

Co

1

Revision: 0 / 24.06.2019PE-059-B1U




4/14

2

4

Revision: 0 / 24.06.2019PE-059-B1U




3

2

1

X

B

C

A

ø 35mm

X

X

X

5/14

5

8

6

7

Revision: 0 / 24.06.2019PE-059-B1U




M

M M

1

3 4

2

X

!

!

SOCKET CONNECTION

1-7 STOP

1/L 2 3/31 4/R 5/58-R 6/54 7/58-L

21W21W 21W 42W 3x21W 42W

DIN/ISO 1724

Pmax

Yellow Blue White Green Brown Red BlackColour

OPTION A OPTION B

6/14

9

10

Revision: 0 / 24.06.2019PE-059-B1U




L2

OPTION A OPTION B

L2

1 2

3 4

L1

M

10 mm

G

2

1

7/14

11

Revision: 0 / 24.06.2019PE-059-B1U




1312

! Code3:3

30 Amp.

Pos. 2

20 Amp.

20 Amp.

L3

8/14

Revision: 0 / 24.06.2019PE-059-B1U




14

17

15

16

OPTION SP-161-ZZ

Consult your supplier.

SP-161-ZZ

Optional SP-161-ZZ

ON

OFFTEST

Tester L.E.D.

Tester lamp

C2

GarageDiagnoseDiagnose

PARK DISTANCE CONTROL

PARK DISTANCE CONTROL

Only forO.E.M. PDC

R STOP LTESTReverse


Optional SP-161-ZZ


Optional SP-161-ZZ

17 OPTION SP-161-ZZ

Pag. 3

9/14

Revision: 0 / 24.06.2019PE-059-B1U




18

19

OPTION SP-161-ZZ INFO

SP-161-ZZ PE-059-B1U

R

G

F

OPTION SP-161-ZZ INFO

F

1X SP-161-ZZ

Citroen JumpyFiat ScudoPeugeot Expert

2X SP-161-ZZ

Toyota Pro Ace

#2052B

M

F

10/14

20

22

Revision: 0 / 24.06.2019PE-059-B1U




Trailer Simulator for 7- and13-pin Sockets

Optional

Consult your supplier.

21

!

L R

MENUOK

P 500 miles6666 miles

Driving Aids

6:00 AM 36 F

C H0

1

23 4 5

6

7

8

RPMx1000

1/210

20

40

6080

100

120

140

160

20

40

60

80100

120 140160

180

200

220

240

260km/h

LED

RL

L

54 STOP

RReverse

11/14

23

25

Adapter socket

Optional

*************** -->

Part No: *********

1/**


SALETE

Revision: * / **********RC-MIT001-7 /*******

Web: www.rightEmail: sales@right


SALETE

Web: wwwEmail: sales@righ

Product overview

Revision: 0 / 24.06.2019PE-059-B1U




24

7-pin 13-pin

12/14

Revision: 0 / 24.06.2019PE-059-B1U




YellowBlueWhiteGreenBrownRedBlack

1234567

L trailer54G trailerGroundR trailer58 R trailer 54 trailer58 L trailer

L2

L3

XG

M

13 1411 129 107 85 6

1 21

2

LABEL

+30

12 V

20 Amp.

L

R

58L

58R

L

R

54

54G

Ground/31

F

3 41 2

OPTIONSP-161-ZZ

L1

1

1

62 73 84 95 10

M 1234567891011121314

RedOrange-YellowRedBlueBlackBrownYellowWhiteRedWhiteGreenBlueBrownBlackRedOrange

54 trailer+30 (12 V)-L trailer5458 L trailerCan LGroundCan HR trailer54G trailer58 R trailerBUT+30

outin-outinoutin-inoutoutoutoutin

L1 12345678910

BrownYellowRedWhite---RedBlue----

Can LCan H---54----

outout---out----

L2 12

Red-

+30 (12 V)-

out-

Can 54

12

OrangeRed

+30 (12 V)+30 (12 V)

outinL3

FOPTION1 Blue 54G trailer out

G White Ground -

INFO POWER SCHEDULE PE-059-B1U

13/14

Revision: 0 / 24.06.2019PE-059-B1U




Blue 54G in


SP-161-ZZ

F

R 12

3456789

-BlueBlue--GreyRed-White

-54 G trailer54 G trailer--54G R54G-Ground

-inout--outin--

R

F F

GLABEL

Blue 54G trailer out

1 2 34 5 67 8 9

PE-059-B1U

PE-059-B1U

Grey

Red

54G R

54G

out

in

SP-161-ZZ

FSP-161-ZZ (2) SP-161-ZZ

OPTION

Pag. 13

INFO POWER SCHEDULE SP-161-ZZ

11 9 5 3 113 7

2

1

3

4 5

11 9 5 3 113 7

M

V

Y

V

1

2

3 Reverse

UN-243-YZ W

W

Y

M1

MM1

M1

M1

M1

A

B

M

UN-243-YZ Reverse lamp pre-wire extension

MAX = 21W

MAX = 21W

14/14

Revision: 0 / 24.06.2019PE-059-B1U




Electric wiring kit for towbars / 7-pin / 12N / 12 Volt ......Toyota Pro Ace 04/2013 - 01/2016...

Documents

Transcript of Electric wiring kit for towbars / 7-pin / 12N / 12 Volt ......Toyota Pro Ace 04/2013 - 01/2016...