DSC 500 SPECIFICATIONS - Diagramas dediagramas.diagramasde.com/audio/DSC 500 Service manual...
35
SPECIFICATIONS: Source Unit Section • Signal Format System: NTSC/PAL • Video Signal-to-Noise Ratio (DVD) : 60 dB • Audio Frequency Response DVD (PCM) : 20Hz - 20 kHz (±1 dB) • Audio Frequency Response CD : 20Hz - 20 kHz (±1 dB) • Signal-to-Noise Ratio: >80 dB • Total Harmonic Distortion: 0,0001 • Dynamic Range: DVD (PCM): >85 dB • Dynamic Range: CD: >85 dB Audio Section • Surround Formats: Dolby Digital - DTS - Dolby Pro Logic • Frequency Response at 1W (+0dB, -3dB): 45Hz - 20 kHz • Signal-to-Noise Ratio (IHF-A): 80 dB Satellite Section • Frequency Response (-6db): 120 Hz-20 kHz • Sensitivity (2.83V @ 1m): 84 dB • Nominal Impedance: 4 Ohms • Recommended Amplifier Power: 35 Watts RMS • Titanium Laminate HF: 12 mm • Paper Cone Midrange : 75 mm • Dimensions (H x W x D): 111 x 81 x 92 mm • Weight: 0.5 kg • Finish: silvergray Center Section • Frequency Response (-6db): 120 Hz-20 kHz • Sensitivity (2.83V @ 1m): 86 dB • Nominal Impedance: 4 Ohms • Recommended Amplifier Power: 35 Watts RMS (in sub) • Titanium Laminate HF: 12 mm • Paper Cone Midrange : dual 75 mm • Dimensions (H x W x D): 83 x 194 x 95 mm • Weight: 0.8 kg • Finish: silvergray Subwoofer Section • Low Frequency Cut-off: 35 Hz • High Frequency Cut-off: 160 Hz • Built-in Power Amplifier (RMS): 35 Watts x 5 + 100 Watts • Paper Cone Long Throw Driver : 200 mm • Dimensions (H x W x D): 450 x 250 x 360 mm • Weight: 13.6 kg • Finish: beech General Section • Power Requirement: 230V/50-60Hz • Power Consumption: 100 Watts • Dimensions (H x W x D): 75 x 431 x 352 mm • Weight: 7.9 kg Service Manual DSC 500
Transcript of DSC 500 SPECIFICATIONS - Diagramas dediagramas.diagramasde.com/audio/DSC 500 Service manual...
SPECIFICATIONS:
Source Unit Section • Signal Format System: NTSC/PAL • Video Signal-to-Noise Ratio (DVD) : 60 dB • Audio Frequency Response DVD (PCM) : 20Hz - 20 kHz (±1 dB) • Audio Frequency Response CD : 20Hz - 20 kHz (±1 dB) • Signal-to-Noise Ratio: >80 dB • Total Harmonic Distortion: 0,0001 • Dynamic Range: DVD (PCM): >85 dB • Dynamic Range: CD: >85 dB Audio Section • Surround Formats: Dolby Digital - DTS - Dolby Pro Logic • Frequency Response at 1W (+0dB, -3dB): 45Hz - 20 kHz • Signal-to-Noise Ratio (IHF-A): 80 dB Satellite Section • Frequency Response (-6db): 120 Hz-20 kHz • Sensitivity (2.83V @ 1m): 84 dB • Nominal Impedance: 4 Ohms • Recommended Amplifier Power: 35 Watts RMS • Titanium Laminate HF: 12 mm • Paper Cone Midrange : 75 mm • Dimensions (H x W x D): 111 x 81 x 92 mm • Weight: 0.5 kg • Finish: silvergray Center Section • Frequency Response (-6db): 120 Hz-20 kHz • Sensitivity (2.83V @ 1m): 86 dB • Nominal Impedance: 4 Ohms • Recommended Amplifier Power: 35 Watts RMS (in sub) • Titanium Laminate HF: 12 mm • Paper Cone Midrange : dual 75 mm • Dimensions (H x W x D): 83 x 194 x 95 mm • Weight: 0.8 kg • Finish: silvergray Subwoofer Section • Low Frequency Cut-off: 35 Hz • High Frequency Cut-off: 160 Hz • Built-in Power Amplifier (RMS): 35 Watts x 5 + 100 Watts • Paper Cone Long Throw Driver : 200 mm • Dimensions (H x W x D): 450 x 250 x 360 mm • Weight: 13.6 kg • Finish: beech
General Section
• Power Requirement: 230V/50-60Hz • Power Consumption: 100 Watts • Dimensions (H x W x D): 75 x 431 x 352 mm • Weight: 7.9 kg
Service Manual
DSC 500
JLudwigs
BPL40003-0102
JLudwigs
GSP400008-0101
JLudwigs
HSP140071-3160
JLudwigs
FSA213012-1801
JLudwigs
HSP140054-1080
JLudwigs
BRF400006-0001
JLudwigs
BRF400005-0001
JLudwigs
BPF405006-01011
JLudwigs
BPA400007-01011
JLudwigs
FSA243010-1801
JLudwigs
APE200080-0001
JLudwigs
TWEETER
JLudwigs
IVM110001-0001
JLudwigs
YLB1060003-0002
JLudwigs
DSC500 CENTER SPEAKER : AFK200003-0001
JLudwigs
DSC500 SATELLITE : AFK200002-0001
JLudwigs
BPL400003-0102
JLudwigs
GSP400002-0102
JLudwigs
FSA213012-1401
JLudwigs
BPF405003-0101
JLudwigs
BPA400004-0101
JLudwigs
BRF400005-0001
JLudwigs
BRF400006-0001
JLudwigs
IVM000002-0004
JLudwigs
TWEETER
JLudwigs
FSA243010-1801
JLudwigs
APE200040-0001
5
2
1
3
4
25
6
7
8
27
26
9
11
10
12
24
23
22
20
13
14
16
15
17
18
21
19
LOGO BADGELOGO BADGE
DOOR LENSDOOR LENS
WINDOW LENSWINDOW LENS
VOLUME KNOBVOLUME KNOB
FRONT PANELFRONT PANEL
TOP BRACKET TOP BRACKET
CONTROL PCBCONTROL PCB
RUBBER FOOT(FRONT)RUBBER FOOT(FRONT)
PLASTIC FOOTPLASTIC FOOT
RUBBER FOOT(BACK)RUBBER FOOT(BACK)
BOTTOM CABINETBOTTOM CABINET
TUNER PCBTUNER PCB
FM HOLDERFM HOLDER
REAR PANELREAR PANEL
TOP COVERTOP COVER
LINE CORD LINE CORD
SWITCHING POWER PCBSWITCHING POWER PCB
DVS LOADERDVS LOADER
LOADER HOLDERLOADER HOLDER
POWER KNOBPOWER KNOB
FUNCTION KNOBFUNCTION KNOB
BPL200001-0001BPL200001-0001
BPD200003-0001BPD200003-0001
BPN200002-0001BPN200002-0001
BPN210002-0001BPN210002-0001
BPK222001-0001BPK222001-0001
GAL200002-0001GAL200002-0001
33
11
22
55
44
66
BPF200002-0001BPF200002-0001
GSE200006-0001GSE200006-0001
GSE200003-0001GSE200003-0001
GSE200004-0001GSE200004-0001
GSE200005-0001GSE200005-0001
APE101700-0001APE101700-0001
APE200100-0001APE200100-0001
BPE100018-0001BPE100018-0001
BPH100025-0000BPH100025-0000
APE200230-0001APE200230-0001
DSS100025-0001DSS100025-0001
BRF200004-0001BRF200004-0001
VPE003012-0020VPE003012-0020
BRB200002-0001BRB200002-0001
1010
77
88
99
1212
1111
1313
1717
1414
1515
1616
1919
1818
2020
BPH210003-0001
BPK212001-0001
BPK202001-0001
IVE200008-0001
GSE200035-0001
WVD100002-0004
APE200090-0001APE200090-0001
2424
2121
2222
2323
2626
2525
2727
DVD DOORDVD DOOR
AL PANELAL PANEL
11
11
11
11
11
11
SPACERSPACER
MAIN PCBMAIN PCB
11
11
11
11
22
22
11
11
22
11
11
11
11
11
BRACKETBRACKET
SPONGESPONGE
11
11
11
11
11
11
11
JLudwigs
Exploded view source unit
Head unit - Main board Installation Point Description Material No. Qty.
MAIN PCB ASSY APE101700-0001 1 CN901 CONNECTOR B12B-XH-A 12 PIN CCN250000-0112 1 CN103 CONNECTOR 20x2 PIN PLUG BASE CCN254020-0440 1 CN101 CN201 CONNECTOR 15 PIN PITCH=2.0mm CCN200000-0115 2 JK101 RCA+DIN JK 4P DIN+2RCA W/GND CJC010001-3010 1 JK401 RCA JACK 6P REDx3/WHTx3 STAND 2 RCA HOLE CJR006601-0010 1 JK201 SCART SOCK 21PIN PITCH=3.81mm CSS021001-1030 1 JK203 RCA JACK 1P BLACK W/GEND PIN CJR001301-0010 1 XL101 CRYSTAL 27 MHZ HC-49US 30ppm JQC023101-2760 1 C071 C072 C1001 C1102 C4001 C4003 COND ELECT 100uF 16V 20% PRE039540-1010 25 C534 COND ELECT 220 uF 16V 20% PRE039540-2210 1 C1000 C1009 C1010 C1012 C1015 C1016 COND ELECT 10 uF 50V 20% PRE039570-1000 51 C603 COND ELECT 1uF 50V 20% PRE039570-1090 1 C163 COND ELECT 3.3 uF 50V 20% PRE039570-3390 1 C453 C456 COND MYLAR 0.015 uF 100V 5% PRM0373A0-1530 2 C454 C457 COND METAL 0.47uF 100V 5% PRN0263A0-4740 2 C452 C455 COND MYLAR 0.0082 uF 100V 5% PRM0373A0-8220 2 Q008 Q010 Q506 Q102 Q103 XISTR NPN 2SC945P RAN200945-0001 5 Q401 Q402 XISTR NPN 2SC2878-A (TE2,.M) RAN202878-0001 2 Q009 Q011 Q403 XISTR PNP 2SA733Q,P NEC RAP200733-0001 3 R540 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 1 R542 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 1 R462 R463 R496 R497 RESISTOR 150 OHM 1/6W 5% CF QAF065000-1510 4 R543 RESISTOR 6.8K OHM 1/6W 5% CF QAF065000-6820 1 D102 D505 D506 D507 D509 DIODE SW; 1N4148 RAD114148-0010 16ZD101 ZD102 ZD104 ZD105 ZD106 ZD107 ZD108 ZD109 ZD103 ZD401 ZD402 ZD403 DIODE ZENR 6.9-7.2V 0.5W RAZ005007-0020 13 L101 L102 L103 L108 CHOKE 10 uH 10% SAN001600-1000 4 L602 L603 INDUCTOR 100 uH 10% SAN001600-1010 2 L104 L105 L106 L107 INDUCTOR 2.4 uH 10% SHN001600-2490 4 L601 L605 FIXED (COLOUR) INDUC70R 0.68uH 10% SAN001600-6880 2 FB101 FB102 FB108 FB109 BEAD FERIT DIA3.5x6mm SFB001001-0030 4 J001 J003 WIRE BARE 22 GA TINNED XJP220000-0001 2 C1104 C401 C402 C403 C404 C405 C406 CHIP CAP 100 pF 50V 5% PYL410370-1010 7 C135 EMC101 EMC102 EMC103 CHIP CAP 1000 pF 50V 5% PYL410370-1020 4C216 C217 C218 C219 C220 C221 C222 C223 C224 C225 CHIP CAP 15 pF 50V 5% PYL410370-1500 10 C133 C134 C419 C421 CHIP CAP 22 pF 50V 5% PYL410370-2200 4 C168 C173 C178 C183 C188 CHIP CAP 150 pF 50V 5% PYL410370-1510 5C1017 C1018 C1105 C1106 C1107 C230 C416 C413 CHIP CAP 47 pF 50V 5% PYL410370-4700 8 C601 C610 C612 C615 CHIP CAP 56 pF 50V 5% PYL410370-5600 4 C492 C1 C2 C3 C4 C5 C6 C4119 C4117 CHIP CAP 560 pF 50V 5% PYL410370-5610 9 C4113 CHIP CAP 4700 pF 50V 20% PYL439570-4720 1 C193 CHIP CAP 3300 pF 50V 20% PYL439570-3320 1
JBL DSC500 230V
C101 C102 C1020 C1021 C1022 CHIP CAP 0.1 uF 50V 5% PYL456370-1040 66 C191 C192 CHIP CAP 0.0056 uF 50V 5% PYL456370-5620 2 C1005 C1006 C1007 C1008 C1011 C4010 CHIP CAP 0.1 uF 50V 10% PYL456470-1040 25 R111 R170 CHIP RES. 0 OHM JUMP WIRE QCF015020-0000 2 R109 CHIP RES. 10 OHM 1/10W 5% QCF015020-1000 1 R236 R451 R452 R453 R454 R455 R456 R179 R115 R116 R117 R118 CHIP RES. 100 OHM 1/10W 5% QCF015020-1010 12 R121 R124 R125 R128 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020 32 R168 R4001 R4002 R4003 R4004 R4005 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030 50 R419 R420 R171 R052 CHIP RES. 100K OHM 1/10W 5% QCF015020-1040 4 R422 R424 R449 R4120 R4116 R4121 R4101 CHIP RES. 12K OHM 1/10W 5% QCF015020-1230 7 R152 CHIP RES. 18K OHM 1/10W 5% QCF015020-1830 1 R235 CHIP RES. 200 OHM 1/10W 5% QCF015020-2010 1 R054 R058 R457 R458 R459 R460 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230 17 R114 CHIP RES. 270 OHM 1/10W 5% QCF015020-2710 1 R106 R107 R151 R155 CHIP RES. 33 OHM 1/10W 5% QCF015020-3300 18 R427 R428 CHIP RES. 150K OHM 1/10W 5% QCF015020-1540 2 R053 R055 R057 R101 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 20 R056 R406 R425 R429 CHIP RES. 47K OHM 1/10W 5% QCF015020-4730 15 R4117 CHIP RES. 24K OHM 1/10W 5% QCF015020-2430 1 R153 CHIP RES. 560 OHM 1/10W 5% QCF015020-5610 1 R143 R147 R148 R149 R150 R471 R477 R483 R489 R495 CHIP RES. 5.6K OHM 1/10W 5% QCF015020-5620 10 R108 R4118 CHIP RES. 56K OHM 1/10W 5% QCF015020-5630 2 R411 R412 R413 R414 R417 R418 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820 6 R426 R435 R436 R437 CHIP RES. 68K OHM 1/10W 5% QCF015020-6830 4 R177 R605 R607 CHIP RES. 75 OHM 1/10W 5% QCF015020-7500 3 R401 R402 R403 R404 R409 R410 R448 CHIP RES. 8.2K OHM 1/10W 5% QCF015020-8220 7 RA112 RA113 RA114 RES ARRAY 10 OHMx4 1/10W 5% QCP015081-1000 3 RA101 RA102 RA103 RA104 RA105 RA106 RES ARRAY 33 OHMx4 1/10W 5% QCP015081-3300 12 RA117 RA118 RES ARRAY 4x4.7K 1/10W 5% QCP015081-4720 2 IC108 IC 54 PIN 4MX16 Y3V TW StarRam RCI400160-0001 1 IC107 IC 8 PIN AT24C02N-10SI-2.7 TI RCI024002-0002 1 IC101 IC 40 PIN MX29F080TC-90CE RCI290080-0002 1 IC401 IC 16 PIN TC4052BFN CHIP RCI004052-0001 1 IC408 IC 16 PIN TC4053BFN TOSHIBA RCI004053-0001 1 IC116 IC 28 PIN AK4112BVF RCI004112-0001 1 IC110 IC111 IC112 IC402 IC403 IC409 IC411 IC412 IC413 IC414 IC415 IC416 IC417 IC419 IC420 IC421 IC 8 PIN JRC4558M JRC RCI004558-0001 16 IC103 IC 208 PIN ES6018 RCI006018-0001 1 IC410 IC 42 PIN M62446FP MITSUBISHI RCI062446-0001 1 IC104 IC 14 PIN TC74HC04AFN TOSHIBA RCI740004-0001 1 IC117 IC118 IC 20 PIN SN74HCT244DW T.I RCI740244-0001 2 IC105 IC106 IC119 IC 20 PIN 74HC374 RCI740374-0002 3 IC115 IC 20 PIN WM8739 2CH A/D RCI008739-0001 1 IC109 IC 28 PIN WM8746 6CH D/A RCI008746-0001 1 IC113 IC 3 PIN RT9164-33CLR RCI916433-0001 1
FB103 FB104 FB105 FB106 FB107 FB201 FB202 FB203 FB204 FB205 FB206 FB207 FB208 CHIP BEAD 600 OHM AT 100MHz SCB008050-6010 13 C147 C148 C150 C151 CHIP CAP 470 pF 50V 5% PYL410370-4710 8 C152 C153 C154 C149 R4006 R4016 R4026 R4056 R4066 R4046 CHIP RES. 5.1K OHM 1/10W 5% QCF015020-5120 6 R4100 R470 R476 R482 R488 R494 CHIP RES. 1.5K OHM 1/10W 5% QCF015020-1520 6 IC120 IC 3 PIN IMP809 SOT23 RESETVOL 2.93V RCI000809-0003 1 R447 CHIP RES. 3K OHM 1/10W 5% QCF015020-3020 1 C466 C471 C476 C481 C486 CHIP CAP 330 pF 50V 5% PYL410370-3310 5 C166 C167 C171 C181 C186 C182 C177 C172 C176 C187 CHIP CAP 0.01 uF 50V 5% PYL456370-1030 10 IC121 IC 4 PIN B1117N-2.85 SOT-223 1A RCI011170-0001 1 R178 CHIP RES. 120 OHM 1/10W 5% QCF015020-1210 1 IC601 IC 25PIN BH7860FP VIDEO SIGNAL PROCESSOR RCI007860-0001 1 R4112 CHIP RES. 1.2K OHM 1/10W 5% QCF015020-1220 1 R415 R416 CHIP RES. 390 OHM 1/10W 5% QCF015020-3910 2 R180 CHIP RES. 3.9K OHM 1/10W 5% QCF015020-3920 1 L606 L604 INDUCTOR 2.7uH SAN201601-2790 2 R4230 RESISTOR 150 OHM 1/4W 5% CF QAF045000-1510 1 ZD405 DIODE ZENR 6.0-6.3V 0.5W RAZ005006-0030 1 R541 RESISTOR 39K OHM 1/6W 5% CF QAF065000-3930 1 EMCD01 DIODE 1N5392 1.5A 100V RAD115392-0010 1 C616 COND ELECT 22uF 50V 20% PRE039570-2200 1 C498 C499 C495 C496 C497 C494 COND ELECT 4.7 uF 50V 20% PRE039570-4790 6 EMC001 EMC004 EMC005 EMC010 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 4 EMC006 EMC008 EMC007 EMC009 EMC102 COND DISC 0.001 uF 50V +80-20% PRD249670-1020 5
12P 200mm 2468#26 RAINBOW A=2.5 B=2512V VFLC01312-2000 1 CN401 D-SUB JACK 15P D-SUB 90* CGIC RC CJF015001-2002 1
WIRE 26 GA 90 mm BLACK 4-4 VWR0151BB-0090 1COND DISC 0.1 uF 50V +80-20% PRD249670-1040 2WIRE 26 GA 60 mm BLACK 4-4 VWR0151BB-0060 1
Head unit - Control board (Front board)Installation Point Description Material No. Qty.
CONTROL PCB ASSY APE200100-0001 1 XL201 CRYSTAL 4.5000 MHZ HC-49/S JQC023101-4550 1 CN203 CONNECTOR 3 PIN PITCH=2.0mm CCN200000-0103 1 IC201 IC 18 PIN CTM8B56EN(MCU1226) RHI008056-0001 1 C216 COND DISC 4700 pF 50V 10% PRD235470-4720 1 C201 COND ELECT 10uF 16V 20% PRE039540-1000 1 C208 C209 C210 C214 COND DISC 15 pF 50V 5% PRD113370-1500 4 C204 C205 COND DISC 22 pF 50V 5% PRD113370-2200 2 C220 C221 COND DISC 100 pF 50V 5% PRD113370-1010 2 C202 C206 C211 COND ELECT 100uF 16V 20% PRE039540-1010 3 C203 C207 C212 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 3 C226 COND DISC 220 pF 50V 10% PRD235470-2210 1 C218 COND MULTI 0.33UF 10% 50V X7R PRL156470-3340 1 C215 COND DISC 820 pF 50V 10% PRD235470-8210 1
Q204 XISTR NPN 2SC945P RAN200945-0001 1 R225 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 1 D201 D202 D203 D204 D208 DIODE SW; 1N4148 RAD114148-0010 5 R224 RESISTOR 68K OHM 1/6W 5% CF QAF065000-6830 1 R207 R211 R212 R213 R226 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010 5 R206 R208 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 2 R209 RESISTOR 560 OHM 1/6W 5% CF QAF065000-5610 1 R230 R231 R201 R202 R203 R204 R205 R210 R215 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 9 R219 RESISTOR 56K OHM 1/6W 5% CF QAF065000-5630 1 TA210 TA209 TA208 TA202 TA203 TA204 TA201 TA207 AI TACT SW SKHVBE3520 MAW060001-0010 8 R227 RESISTOR 2K OHM 1/6W 5% CF QAF065000-2020 1 JW201 JW202 JW203 JW204 JW205 JW206 JW207 JW208 JW209 JW210 JW211 JW212 JW213 JW214 JW215 JW216 JW217 WIRE BARE 22 GA TINNED XJP220000-0001 17 R233 RESISTOR 6.8 OHM 1/4W 5% CF QAF045000-6890 1 Q205 Q206 XISTR PNP 2SA733Q,P NEC RAP200733-0001 2
SPONGE L10 X W10 X T13.5mm IVE200009-0001 1 SN201 IRT SENSOR RPM6938-V4 RHO693804-2001 1
LCD FILTER L110xW27xT0.27mm PVC WHITE BFT211001-0001 1LCD HOLDER ABS BPH200002-0001 1LCD TOP ABS BPH210002-0001 1COND FLAT CABLE 15P 250mm 2468#26 A=2mm VFLF01246-2500 1
D207 LED HI-BRIG 2x4.6mm BLUE KED600052-0010 1 POT2 R-ENCODER ;EC16B24204 ALPS MSW005007-0010 1
3P 190mm 2468#26 RAINBOW VFL301245-1900 1 CN2 CONNECTOR 4 PIN PITCH=2.0mm CCN200000-0104 1 IC202 IC 80 PIN PT6583 LCD DRIVER RCI006583-0001 1 IC201 DISPLAY IC DTE102251AIP KEYMOS KLD000052-0010 1
FILTER LENS PMMA BPN200003-0001 1Head unit - Power board (power supply)Installation Point Description Material No. Qty.
POWER PCB ASSY APE200090-0001 1 IC7 IC 3 PIN 7812 12V 1A RHI007812-0001 1 IC6 IC 3 PIN 7912 RHI007912-0001 1 CN902 CN907 CONNECTOR 4 PIN P=3.96mm CCN396021-0104 2 IC2 IC 3 PIN TL431 RHI004310-0001 1 T901 PWR TRANS 230V 50Hz EI28 AXIAL TTA123011-0010 1 RL001 RELAY GJ-SH-112DM MRL012004-0011 1 PH IC 4 PIN PC817A RHI008170-0001 1 IC1 IC 8 PIN DIP NCP1002P DIP FOR CNTL RHI001002-0001 1 IC5 IC 3 PIN; LM317 POS ADJ REG. RHI003170-0001 1 C3 C4 C11 COND SAFTY 0.0022uF 400V 20% PVY1705K0-2222 3 C5 COND ELECT 68 uF 400V 20% PVE0395K0-6800 1 C54 COND SAFTY 0.01uF 250V 20% PVY2705F0-1031 1 C15 C18 COND ELECT 1000 uF 10V 20% PME039530-1020 2 Q3 Q4 XISTR NPN 2N3904 FAIRCHILD RAN203904-0001 2 C1 C2 COND SAFETY 0.22uF 275V X2P 20% PVX2705G0-2240 2
C9 C17 C21 C29 C35 C37 C39 C42 C44 C46 C47 C19 C28 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 13 C10 C12 C48 COND ELECT 1uF 50V 20% PRE039570-1090 3 C6 COND ELECT 2.2 uF 50V 20% PRE039570-2290 1 C24 COND ELECT 4.7 uF 50V 20% PRE039570-4790 1 C51 C52 COND ELECT 10 uF 50V 20% PRE039570-1000 2 C8 COND ELECT 100uF 50V 20% PRE039570-1010 1 C53 COND ELECT 220 uF 50V 20% PME039570-2210 1 q5 q6 XISTR NPN 2SC945P RAN200945-0001 2 C33 C34 C36 C40 C41 C43 C30 C45 C38C31 C32 COND ELECT 330uF 25V 20% PRE039550-3310 11 C20 COND ELECT 470uF 16V 20% PRE039540-4710 1 R34 R35 RESISTOR 1.0 OHM 1/4W 5% CF QAF045000-1090 2 R4 R6 R23 RESISTOR 1.0K OHM 1/4W 5% CF QAF045000-1020 3 R1 RESISTOR 1.0M OHM 1/4W 5% CF QAF045000-1050 1 D22 D23 D20 D21 DIODE;RECTIFIER 1N4001 RAD114001-0010 4 D1 D2 D3 D4 DIODE 1N4007 RAD114007-0010 4 D6 DIODE SW; 1N4148 RAD114148-0010 1 R19 RESISTOR 4.7K OHM 1/4W 5% CF QAF045000-4720 1 ZD14 DIODE ZENR 5.6-5.9V 0.5W RAZ005006-0020 1 R33 RESISTOR 10 OHM 1/6W 5% CF QAF065000-1000 1 R16 R30 R31 R32 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 4 R5 RESISTOR 22 OHM 1/6W 5% CF QAF065000-2200 1 R15 RESISTOR 24K OHM 1/6W 5% CF QAF065000-2430 1 R14 RESISTOR 33K OHM 1/6W 5% CF QAF065000-3330 1 R7 RESISTOR 68 OHM 1/4W 5P% CF QAF045000-6800 1 R18 RESISTOR 47K OHM 1/6W 5% CF QAF065000-4730 1 R10 RESISTOR 2.7K OHM 1/6W 5% CF QAF065000-2720 1 R9 RESISTOR 3K OHM 1/6W 5% CF QAF065000-3020 1 R17 R21 R22 RESISTOR 3K OHM 1/6W 5% CF QAF065000-3020 3 D7 D8 D9 D11 MBR 1100 1A 100V SHOTTKY BARRIER RAD101100-0010 4 D5 DIODE MUR160E 1A 800V RAD100160-0010 1 R8 RESISTOR 100 OHM 1/4W 5% CF QAF045000-1010 1 D13 DIODE ZENR 11.9-12.4V 0.5W RAZ005012-0010 1 JW3 JW4 JW5 JW6 WIRE BARE 22 GA TINNED XJP220000-0001 4 R3 RESISTOR 22K 2W 5% W/O KINK HI-AXIAL CF QHF205000-2230 1 D12 MBR1045 10A 45V MOT DRIVER W/KEY I/P FUN RHD101045-0010 1
FUSE CLIP DIA5xL20mm FUSE CFC011000-1001 2TIN PLATE L26.5xW25xT0.8mm BRACKET GTP200002-0001 1
CONA 12P 200mm 2468#26 RAINBOW A=2.5 B=2512V VFLC01312-2000 1 L1 LINE FILTER 22mH D0.37x110TS JFT001003-0010 1 TR ER-29/32 230V 600uH PWR TRANS TSB023001-0010 1 L2 L3 L4 L5 COIL 3.3uH/3A VERTICAL PITCH 7mm SIL206001-3390 4 RV SURGE ABSORBER 10N471K RHU100471-2001 1 C7 CAP 0.01uF 1KV +80%-20% Y5 PLD3336Q0-1030 1
TIN PLATE BRACKET T=0.8mm GTP200003-0001 1 CONB CONNECTOR B4B-XH-A 4 PIN CCN250000-0104 1 C50 COND ELECT 220 uF 50V 20% PME039570-2210 1 RT NTC 5 OHM 5A DIA=13 mm RNT005130-5090 1
WIRE 22 GA 80 mm RED 14-14 mm VWR0333GG-0080 1WIRE 22 GA 90mm RED 4-4 VWR0333BB-0090 1SCREW T3.0xL6xP1.06mm HSP140054-1060 4
C13 COND SAFTY 0.01uF 250V 20% PLY2705F0-1030 1 FU FUSE 3.15A 250V SLOW(WALTER TSD) KSA020315-0120 1
FUSE COVER;ID19.6xW11xH5.5mm UL DCR030001-0001 1Head unit - mechanics parts Installation Point Description Material No. Qty. IC5 IC7 IC8 IC6 HEAT SINK 10.5x15x24mm AL GAL100040-0002 4
FRONT PANEL HIPS BPF200002-0001 1FUNCTION KEY ABS BPK202001-0001 1POWER KEY ABS BPK212001-0001 1VOLUME KNOB ABS BPK222001-0001 1DVD DOOR HIPS PAINT PMS877C BPD200003-0001 1DOOR LENS PMMA BPN200002-0001 1WINDOW LENS PMMA BPN210002-0001 1LOGO PLATE JBL ABS BPL200001-0001 1DVD HOLDER HIPS BPD210003-0001 1FRONT PANEL AL GAL200002-0001 1BOTTOM CAB. SECC T=0.8mm GSE200003-0001 1BACK PANEL SECC T=0.8mm GSE200004-0001 1TOP COVER SECC T=0.6mm GSE200005-0001 1TOP BRACKET SECC T=1.0mm GSE200006-0001 1SCREW T3.0xL8xP1.06mm HSP140054-1080 8SCREW M3.0xP0.5x8 HST143084-1080 3SCREW T3.0x1.06PxL8mm HST140054-1080 11SCREW M3.0xP0.5x6 HST143084-1060 13BUSHING AC LINE BUSHING DBU001005-0010 1WIRE TIE GT-90M 90mm DWT000001-0900 3SPACER A=8.0mm B=1.3-1.7 PINGOOD SCB-8 DSS100022-0004 5SPACER A=15.6 B=1.2-1.6 DSS100026-0001 2SPONGE L100 x W8 x T1.5mm IVE200008-0001 1SPONGE L10 X W10 X T13.5mm IVE200009-0001 1RUBBER FOOT 19.5 x 2.5 MM BRF200004-0001 2SCREW M3.0 X 0.5P TYPE TRIANGLE HSF143084-1080 6LINE CORD 2P 1980mm BLK VDE W/3.96VH 4P VPE003252-0010 1
Mecha DVD LOADER DSL-710A DVS ATRAPI WVD100002-0006 1
Head unit - Tuner Installation Point Description Material No. Qty.
TUNER PCB ASSY APE200230-0001 1 CF103 CER FILTER 450 KHZ JFT005001-0030 1 CF101 CER FILTER 10.7 MHZ JFT005002-0020 1 CF102 CER FILTER 10.7 MHZ JFT005002-0040 1 XL152 CRYSTAL 4.5000 MHZ HC-49/U JQC013101-4550 1 TC001 COND TRIM 3 - 10 PF NP0 MVC001001-0010 1 TC002 COND TRIM 4.2 - 20 PF N450 MVC001002-0010 1 C166 COND ELECT 3.3 uF 16V 20% PVE939540-3390 1 C117 C171 COND ELECT 47 uF 16V 20% PVE939540-4700 2
C014 COND POLY 560pF 50V 5% PVP026370-5610 1 VD001 VD002 DIODE TUNG AM TOSHIBA 1SV149B RHV100149-0001 2 L103 COIL 39 mH 10% D6xH11xP5mm SIL106003-3930 1 T102 AM IFT 455KHz Q=130 SIF010001-0040 1 T105 FM IFT 10.7MHz Q=60 MIN SIF020001-0050 1 T002 ANT OSC AM 4-6:10T 1-3:86T SIL013009-0011 1 T101 BIAS COIL 78 KHz SIL016001-0010 1 T103 T104 BIAS COIL 16 KHz SIL016001-0020 2 T003 OSC COIL 108uH (796 KHz) COIL SIL013010-0012 1 T001 OSC FM SUMIDA S-8N SIL013012-0010 1
SHLD CALBE 160mm BLACK 75 OHM VSW243BB2-0160 1ANT JACK 2P+ANT PLUG BLK-BLK CJA005001-1010 1
C113 COND ELECT 47 uF 16V 20% PVE939540-4700 1 C107 COND ELECT 22 uF 16V 20% PVE939540-2200 1 EF001 TUNER PACK KWANGSUN KST-F404VA2 WTP000011-0001 1 XL151 CRYSTAL 4.332 MHZ HC-49/U JQC013101-4351 1 C104 C106 COND ELECT 33 uF 10V 20% PRE939530-3300 2 C109 C125 C126 C151 COND ELECT 10 uF 16V 20% PRE939540-1000 4 C012 C143 C163 C156 C157 COND ELECT 47 uF 16V 20% PRE939540-4700 5 C139 C140 COND ELECT 4.7 uF 16V 20% PRE939540-4790 2 C118 C123 C127 COND ELECT 1 uF 50V 20% PRE939570-1090 3 C124 COND ELECT 0.47 uF 50V 20% PRE939570-4780 1 C005 COND DISC 5 pF 50V +-0.25pF PRD113870-5090 1 C007 COND DISC 0.1 uF 50V +80-20% PRD339670-1040 1 C015 C101 C164 C167 COND DISC 0.022 uF 50V +80-20% PRD249670-2230 4 Q001 FET 2SK192A-Y/GR RAM200192-1001 1 Q104 Q105 XISTR NPN 2SC945P RAN200945-0001 2 Q101 Q102 XISTR NPN 2SC1675L NEC RAN201675-0001 2 Q103 XISTR PNP 2SA733Q,P NEC RAP200733-0001 1 R105 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010 1 R155 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 1 R007 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 1 R005 R104 RESISTOR 330 OHM 1/6W 5% CF QAF065000-3310 2 R110 RESISTOR 47 OHM 1/6W 5% CF QAF065000-4700 1 R123 RESISTOR 4.7K OHM 1/6W 5% CF QAF065000-4720 1 D001 D002 D003 D004 D101 DIODE SW; 1N4148 RAD114148-0010 5 L102 L104 L153 L154 L151 L152 CHOKE 10 uH 10% SAN001600-1000 6 J101 J102 J103 J104 WIRE BARE 22 GA TINNED XJP220000-0001 20 C165 CHIP CAP 1000 pF 50V 5% PYL410370-1020 1 C110 CHIP CAP 200 pF 50V 5% PYL410370-2010 1 C120 C154 C155 C173 C174 CHIP CAP 22 pF 50V 5% PYL410370-2200 5 C111 CHIP CAP 30 pF 50V 5% PYL410370-3000 1 C001 CHIP CAP 33 pF 50V 5% PYL410370-3300 1 C013 CHIP CAP 8 pF 50V 5% PYL410370-8090 1 C003 C009 C010 C105 C116 C122 C133 CHIP CAP 0.022 uF 50V 20% PYL439570-2230 13 C134 C144 C145 C169 C170 C011 C112 C114 C115 CHIP CAP 0.047 uF 50V 20% PYL439570-4730 3 C016 C006 C108 C161 CHIP CAP 0.1 uF 50V 10% PYL456470-1040 4 C135 C136 C119 CHIP CAP 1500 pF 50V 10% PYL456470-1520 3
C137 C138 CHIP CAP 0.015 uF 50V 10% PYL456470-1530 2 C008 C129 C130 C141 C142 CHIP CAP 0.0022uF 50V 10% PYL456470-2220 5 C131 C132 CHIP CAP 0.0047 uF 50V 10% PYL456470-4720 2 R107 CHIP RES. 10 OHM 1/10W 5% QCF015020-1000 1 R006 R138 CHIP RES. 100 OHM 1/10W 5% QCF015020-1010 2 R004 R009 R116 R125 R157 R135 R136 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020 7 R002 R003 R109 CHIP RES. 100K OHM 1/10W 5% QCF015020-1040 3 R154 R151 CHIP RES. 1M OHM 1/10W 5% QCF015020-1050 2 R117 CHIP RES. 180K OHM 1/10W 5% QCF015020-1840 1 R139 CHIP RES. 220 OHM 1/10W 5% QCF015020-2210 1 R133 R134 CHIP RES. 2.2K OHM 1/10W 5% QCF015020-2220 2 R167 R168 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230 2 R137 CHIP RES. 2.7K OHM 1/10W 5% QCF015020-2720 1 R101 R106 CHIP RES. 270K OHM 1/10W 5% QCF015020-2740 2 R124 CHIP RES. 3K OHM 1/10W 5% QCF015020-3020 1 R103 R114 CHIP RES. 330 OHM 1/10W 5% QCF015020-3310 2 R112 R115 R156 R158 CHIP RES. 3.3K OHM 1/10W 5% QCF015020-3320 4 R122 VR102 CHIP RES. 3.9K OHM 1/10W 5% QCF015020-3920 2 R102 R118 CHIP RES. 47 OHM 1/10W 5% QCF015020-4700 2 R129 R130 R159 R160 R161 R162 R163 R165 R152 R153 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 10 R126 CHIP RES. 47K OHM 1/10W 5% QCF015020-4730 1 R119 CHIP RES. 51 OHM 1/10W 5% QCF015020-5100 1 R001 R131 R132 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820 3 IC101 0IC 30 PIN LA1837 SANYO RCI001837-0001 1 IC152 IC 20 PIN LC72131M SANYO RCI072131-0001 1 R108 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030 1 C152 CHIP CAP 560 pF 50V 5% PYL410370-5610 1 IC151 IC 24 PIN LC72720NM RCI072720-0002 1 C153 CHIP CAP 330 pF 50V 5% PYL410370-3310 1 R008 RESISTOR 10 OHM 1/6W 5% CF QAF065000-1000 1
HOLDER FM HOLDER BPH100025-0000 1SCREW M3.0xL6.0 mm x P0.5 HSP143084-1060 1CON/WIRE 15P 110mm 2547#28/2468#26 VWA200098-0001 1PAN HEAD SCREW STEEL T3.5x1.41PxL24 HSP140074-1240 2SUPPORT ABS PCB SUPPORT TOP BPS101020-0001 2SUPPORT ABS PCB SUPPORT BTM BPS101021-0001 2FOOT CHROME 50X9mm BPE100018-0002 2T=2.0 OD=39.8mm, ID=16.2mm BRB200002-0001 2SCREW M3.0x4 NICKLE HSP143084-1040 2TUBING SRK DIA=8 L=20 mm BLACK DTB008000-0200 2CON/WIRE 4P 120mm 1617#18x2P VWA310013-0011 1BEAD FERIT DIA25x15x10 mm SFB001001-0200 4CON/WIRE 4P 220mm 1007#22 RD-BK-BK-YL VWA330040-0001 1ATAPI CABL 40P 220mm 2551#28 VWA410001-0011 1ROCKER SWITCH(TV-2) W/O MARK MSW008003-0020 1BRACKET SECC T=0.8mm GSE200035-0001 1FLAT HEAD SCREW STEEL M3x0.5PxL12 HSF143084-1120 4SCREW T3xL16xP1.06mm HSP140054-1160 2
LED PCB ASSY APE200330-0001 1 CP2 CON/WIRE 4P 140mm UL2468#26 BLK A=2.0mm VFL41124B-1400 1 D211 D212 D213 D214 D215 D217 D218 CHIP LED WHITE SMD0805 KCD900805-0010 7 R235 R236 R237 R238 R239 R240 R241 CHIP RES. 75 OHM 1/10W 5% QCF015020-7500 7
SCREW STEEL SCREW M3xP0.5xL6mm FLAT HEAD HSF143084-1060 5NUT M3.0xOD5.5xT2.5mm HNT130550-1230 1
Head unit - PackingInstallation Point Description Material No. Qty.
POLY BAG L80xW220mm IVA000001-0019 1POLY BAG L610xW540mm IVA000001-0061 1SOLDER LUG/WIRE180mm UL1007#22 BLK CSL507035-0200 1SPONGE L25xW15xT21mm FIREPROOF IVE110002-0001 1SPONGE L10 X W10 X T13.5mm IVE200009-0001 1SPONGE L20xW10xT0.5mm IVE100157-0001 2SCREW M3x10x0.5P HST143084-1100 1WASHER FIB OD8.0xID3.5xT1.0 mm HWF118035-6100 1PLYFOAM BOTTON ITF200012-0001 1PLYFOAM TOP ITF200013-0001 1MASTER CARTON ICC200004-0001 1OWNER'S MANUAL YOM200001-0001 1
Satellites speakerInstallation Point Description Material No. Qty.
SATE. SPK ASSY JBL AFK200002-0001 1SPK REAR ABS BLK BPA400004-0101 4SPK FRONT ABS BLK BPF405003-0101 4LOGO PLATE L12xW10xT2mm BPL400003-0102 4RUBBER FOOT OD12.5xID6xT2.5mm BRF400005-0001 8RUBBER FOOT OD12.5xID6.2xT6.8mm BRF400006-0001 4SPK GRILLE L80xW100xT0.6mm GSP400002-0102 4ACCOUSTIC L80xW80xT30mm FIBER W/UL IVM000002-0004 4SPK DRIVER D22.4mm 30W TWEETER FSA243010-1801 4SPK DRIVER 70x70mm 4OHM 30W FOR SATE. FSA213012-1401 4PROTECT PCB ASSY FOR REAR/SATE. APE200040-0001 4
R1 RESISTOR#6 OHM 10W 5% HI QVEA05000-6090 4 R2 RESISTOR ESC360 QVE505000-1890 4 C1 COND ELECT 100 uF 50V 20% NON-POLAR PRE399570-1010 4 C2 COND ELEC 1.5uF 100V VON-POLAR 5% BP PRE3993A0-1590 4 RB3 SPK WIRE 100mm 2P 2468#22 RD-BLK VWS331000-0100 4 PTC1 PTC 0.5Ax60x050 MEXICO RPT005001-0020 4 RB1 CON/WIRE AY 2P 130mm 2468#20 RD-BK VWA350013-0001 4 RB2 TEM WIRE 130mm 2468#20 RD-BLK A+6.4/-3.7 VWT130431-0130 4
SCREW T3.0xL8xP1.06mm HSP140054-1080 8SCREW T3.5xL8xP1.41mm HSF140074-3120 8SCREW T3.5xP1.41x16mm HSP140071-3160 16ACOUSTIC ABSORB L80xW80xT10 FIBER WHT IVM110001-0001 4
Center spaekerInstallation Point Description Material No. Qty.
CENTER SPK ASSY JBL AFK200003-0001 1SPK REAR ;ABS BLK (JBL) BPA400007-0101 1
SPK FRONT ABS BLK BPF405006-0101 1LOGO PLATE L12xW10xT2mm BPL400003-0102 1RUBBER FOOT OD12.5xID6xT2.5mm BRF400005-0001 1RUBBER FOOT OD12.5xID6.2xT6.8mm BRF400006-0001 1SPK DRIVER D22.4mm 30W TWEETER FSA243010-1801 1SPK DRIVER 70x70mm 8OHM 30W FOR CENTER FSA213012-1801 2SPK GRILLE L187xW74xH13.5mm GSP400008-0101 1PROTECT PCB ASSY FOR CENTER APE200080-0001 1PROTECT PCB CEM-1 45x 40mm LCG200080-0401 1
C1 COND ELECT 100 uF 50V 20% NON-POLAR PRE399570-1010 1 C2 COND ELEC 1.5uF 100V VON-POLAR 5% BP PRE3993A0-1590 1 R1 R1A RESISTOR ESC360 QVE505000-1200 2 PTC1 PTC 0.5Ax72x050 MEXICO RPT005001-0010 1 RB3 SPK WIRE 80mm RD-BLK 2468#22 VWS331000-0080 1 RI1 CON/WIRE AY 2P 130mm 2468#20 RD-BK VWA350013-0001 1 RO1 RO2 TEM.WIRE 2P 140mm 2468#20 RD-BLK JBL VWT130431-0140 2 R2 WIRE BARE 22 GA TINNED XJP220000-0001 1
SCREW T3.0xL8xP1.06mm HSP140054-1080 2SCREW T3.5xP1.41x16mm HSP140071-3160 8ACOUSTIC ABSORB L80xW80xT10 FIBER WHT IVM110001-0001 2
Speaker accessoriesInstallation Point Description Material No. Qty.
WALL BRACKET BPH200003-0001 4BRACKET BPH200004-0001 4WIRE ASSY L=12240mm BLK P=5mm VWP010003-0040 1D-SUB 15P CABLE 4000mm BLK VWP000010-0010 1WIRE ASSY L=3040mm BLK P=5mm VWP010003-0030 1POLY BAG L260xW180mm PO IVA000001-0134 5RUBBER FOOT NR3 BLACK 13.5xT2.0mm W/ADHE BRF200001-0001 2POLYFORM BTM FOR SPK ASSY JBL DSC500 ITF130261-0001 1POLYFORM TOP EPS FOR SPK ASSY JBL DSC500 ITF130260-0001 1SILICA GEL 3 g DOT040001-0003 2POLY BAG L300x W180xT0.03mm W/RECYCLE IVA102014-0010 1POLY BAG L240xW180mmxT0.03mm W/RECYCLE IVA000001-0088 5POLY BAG L100xW130xT0.03mm W/RECYCLE IVA102015-0010 17SCART CABL SC/G-SC/G,1000mm VSC000002-0010 1SPEAKER LABEL L40xW10mm 135SISSAT YLB106003-0001 4CERTRE SPK LABEL L40mmxW10mm 500CC YLB106003-0002 1
SUB - main boardInstallation Point Description Material No. Qty.
MAIN PCB ASSY APE200051-0001 1 J14 CONNECTOR B7B-XH-A 7 PIN CCN250000-0107 1 J15 CONNECTOR B3B-XH-A 3 PIN CCN250000-0103 1 J20 CONNECTOR 4 PIN CL3962WVO CCN396020-0104 1 J21 ON/WIRE 6P 500mm 1007#18W/BEA VWA310006-0007 1 J12 CON/WIRE 13P 500mm 1007#26FLAT VWA200097-0002 1 U1 U2 U5 IC 11 PIN LM3886T RHI003886-0001 3 IC8 IC 8 PIN JRC4558D JRC RHI004558-0001 1
SOLDR WIRE TIN 60/40% D1.2mm XSD106040-1200 1
THINER FLX UNION SOLTEK T22 XTN000022-0001 1 RL1 RL2 RL5 INDUCTOR 0.4uH 1 OHM 2W 5% SHN002501-4080 3 JP13 CON/WIRE 6P 100/80/120 1533#28 VWA020011-0001 1 JP7 CON/WIRE 2P 150mm 26AWG VFL21131B-1500 1 JP8 CON/WIRE 2P 500mm BLK VFL21131B-5000 1 C153 C253 C553 COND DISC 560 pF 50V 10% PRD235470-5610 3 C192 C292 C293 C592 C593 C193 COND DISC 0.1 uF 50V +80-20% PRD339670-1040 6 C151 C251 C31 C551 COND MYLAR 0.1 uF 100V 5% PRM0373A0-1040 4 QA01 QA02 XISTR NPN 2SC945P RAN200945-0001 2 Q4 XISTR NPN 2SC2001L NEC RAN202001-0001 1 Q5 Q6 XISTR NPN 2SC2878-A (TE2,.M) RAN202878-0001 2 Q3 XISTR PNP 2SA733Q,P NEC RAP200733-0001 1 CA02 COND ELECT 10uF 16V 20% PRE039540-1000 1 C1 C10 C11 C12 C2 C3 C4 C5 C6 C7 C8 C9 COND ELECT 100uF 25V 20% PRE039550-1010 12 C601 COND ELECT 47uF 25V 20% PRE039550-4700 1 C190 C191 C290 C590 C591 C291 COND ELECT 100uF 50V 20% PRE039570-1010 6 C101 C112 C201 C212 C301 C312 C401 C412 C501 C512 COND ELECT 1uF 50V 20% PRE039570-1090 10 C609 COND ELECT 2.2 uF 50V 20% PRE039570-2290 1 CA04 COND ELECT 4.7 uF 50V 20% PRE039570-4790 1 CA03 COND ELECT 10 uF 16V 20% PRE339540-1000 1 R155 R255 R555 RESISTOR 4.7 OHM 1/2W 5% CF QAF025000-4790 3 R1 R10 R11 R12 R2 R3 R4 R5 R6 R7 R8 R9 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010 12 R152 R154 R252 R254 R552 R554 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 6 R151 R251 R551 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 3 R33 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 1 R153 R253 R553 RESISTOR 20K OHM 1/6W 5% CF QAF065000-2030 3 R34 RESISTOR 2.2K OHM 1/6W 5% CF QAF065000-2220 1 R35 RESISTOR 22K OHM 1/6W 5% CF QAF065000-2230 1 R30 R32 RESISTOR 270K OHM 1/6W 5% CF QAF065000-2740 2 R36 RESISTOR 470K OHM 1/6W 5% CF QAF065000-4740 1 R31 RESISTOR 5.6K OHM 1/6W 5% CF QAF065000-5620 1 D4 DIODE SW; 1N4148 RAD114148-0010 1
WIRE BARE 22 GA TINNED XJP220000-0001 57 C610 CHIP CAP 47 pF 50V 5% PYL410370-4700 1 C608 CHIP CAP 0.022 uF 50V 5% PYL456370-2230 1 R607 RA02 RA03 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020 3 R100 R103 R200 R203 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030 52 RA08 CHIP RES. 1M OHM 1/10W 5% QCF015020-1050 1 R102 R202 R302 R402 R502 CHIP RES. 5.6K OHM 1/10W 5% QCF015020-5620 5 RA05 CHIP RES. 2.2K OHM 1/10W 5% QCF015020-2220 1 R603 R604 R610 RA04 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230 4 R101 R201 R301 R401 R501 R601 CHIP RES. 27K OHM 1/10W 5% QCF015020-2730 6 R611 CHIP RES. 36K OHM 1/10W 5% QCF015020-3630 1 RA01 R113 R213 R313 R413 R513 R612 CHIP RES. 3.9K OHM 1/10W 5% QCF015020-3920 7 RA10 CHIP RES. 470K OHM 1/10W 5% QCF015020-4740 1 RA07 CHIP RES. 56K OHM 1/10W 5% QCF015020-5630 1 R123 R122 R121 R120 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820 29 R606 CHIP RES. 68K OHM 1/10W 5% QCF015020-6830 1
R605 CHIP RES. 8.2K OHM 1/10W 5% QCF015020-8220 1 DA01 DA02 CHIP DIODE LL4148 TELEFUNKEN RCD104148-0010 2 IC1 IC2 IC3 IC4 IC5 IC6 IC 14 PIN TL074CD RCI000740-0001 6 IC101 IC201 IC301 IC401 IC501 IC601 IC7B IC 8 PIN TL072CD RCI000720-0001 7 CA05 CHIP CAP 1000 pF 50V 5% PYL410370-1020 1 C103 C203 C303 C403 C503 C120 C220 C320 C420 C520 C620 CHIP CAP 220 pF 50V 5% PYL410370-2210 11 C15 C16 C17 C18 C19 CHIP CAP 0.1 uF 50V 5% PYL456370-1040 38 C602 C603 CHIP CAP 0.018 uF 50V 10% PYL456470-1830 2 C607 CHIP CAP 0.068 uF 50V 10% PYL456470-6830 1 R106 R107 R206 R207 R307 R406 R407 R506 R507 R603A R604A R605A C502 C102 C202 C302 C402 R306 CHIP RES. 0 OHM JUMP WIRE QCF015020-0000 18 C604 CHIP CAP 0.027 uF 50V 5% PYL456370-2730 1 R104 R304 R404 R504 R204 CHIP RES. 12K OHM 1/10W 5% QCF015020-1230 5 C110 C210 C310 C410 C510 C111 C211 C311 C411 C511 CHIP CAP 0.0022 uF 50V 5% PYL456370-2220 10 R111 R211 R311 R411 R511 R112 R212 R312 R412 R512 CHIP RES. 150K OHM 1/10W 5% QCF015020-1540 10 R114 R314 R414 R514 CHIP RES. 1.2K OHM 1/10W 5% QCF015020-1220 4 R613 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 1 R214 CHIP RES. 750 OHM 1/10W 5% QCF015020-7510 1 R609 CHIP RES. 220K OHM 1/10W 5% QCF015020-2240 1 R602 CHIP RES. 30K OHM 1/10W 5% QCF015020-3030 1 C152 C552 C252 COND ELECT 22 uF 25V 20% PRE039550-2200 3 C32 COND ELECT 22uF 50V 20% PRE039570-2200 1SUB - Amp boardInstallation Point Description Material No. Qty.
AMP PCB ASSY APE200052-0001 1 GSE0215-001 TO PCB SCREW ;T3.0x1.06PxL6mm HSW050054-3060 4 J10 CONNECTOR B2B-XH-A 2 PIN CCN250000-0102 1 J7 CONNECTOR 2 PIN LEOCO 3951 CCN396020-0102 1 J22 CONNECTOR 6 PIN CL3962WVO CCN396020-0106 1 U3 U4 U6 IC 11 PIN LM3886T RHI003886-0001 3 RL3 RL4 RL6 INDUCTOR 0.4uH 1 OHM 2W 5% SHN002501-4080 3 JP3 JP4 JP6 CON/WIRE 7P 200nn 1533x2&2547 VWA010032-0001 3 C353 C453 C653 COND DISC 560 pF 50V 10% PRD235470-5610 3 C392 C393 C492 C493 C692 C693 COND DISC 0.1 uF 50V +80-20% PRD339670-1040 6 C390 C391 C490 C491 C690 C691 COND ELECT 100uF 50V 20% PRE039570-1010 6 C352 C452 C652 COND ELECT 22 uF 25V 20% PRE039550-2200 3 C351 C451 C651 COND MYLAR 0.1 uF 100V 5% PRM0373A0-1040 3 R455 R655 R355 RESISTOR 4.7 OHM 1/2W 5% CF QAF025000-4790 3 R352 R354 R452 R454 R652 R654 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 6 R351 R451 R651 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 3 R453 R353 R653 RESISTOR 20K OHM 1/6W 5% CF QAF065000-2030 3JW40 JW41 JW42 JW43 JW44 JW45JW46 JW47 JW48 WIRE BARE 22 GA TINNED XJP220000-0001 9
HEAT SINK AL ANODIZING GAL200014-0001 1SUB - Jack board (input board)
Installation Point Description Material No. Qty.JACK PCB ASSY APE200053-0001 1
L501 L502 L503 L504 L505 RF COIL 1 uH MDEC T40818-08 SIL001003-1090 5 JK501 TERMINAL IACK ASSY 5 SLOT ABS BLK COT080005-0001 1 JP16 TO J93 FLAT CABLE 3P 100mm 2468#26 A=2.5mm VFL31131B-1000 1 CN401B D-SUB JACK 15P D-SUB 90* CGIC RC CJF015001-2002 1 C515 C516 C517 C518 C519 COND DISC 1000 pF 50V 10% PRD235470-1020 5 J23 CON/WIRE 4P 450mm 1007#18/BEA VWA310006-0003 1 JP23 CONNECTOR 4 PIN CL3962WVO CCN396020-0104 1 JP21 CONNECTOR 6 PIN CL3962WVO CCN396020-0106 1 CON2 CONNECTOR 13 PIN PITCH=2.0mm CCN200000-0113 1
WIRE BARE 22 GA TINNED XJP220000-0001 1FUSE 4A 250V SLOW (WALTER TSD) KSA020400-0121 1
SUB - Control boardInstallation Point Description Material No. Qty.
CNTL LED PCB ASSY APE200054-0001 1 LD1 LED 2.94DIA BLUE ROUND 2P P=2.54mm KED600003-0040 1 LED TO FRONT CAB LED HOLDER 2P H5.0xOD4.2mm LED3-5 DLH010007-0005 1 JP30 CON/WIRE 2 P 500mm P=2.0 BLK VFL21124B-5000 1
CHIP CAP 0.1 uF 50V 10% PXL456470-1040 1
SUB - mechanics partsInstallation Point Description Material No. Qty.
MICA SHEET;L22xW26xT0.1mm HIM000001-0007 6SI RUBBER W13xH18xT0.3 mm HIS000001-0001 2FOOT METALLIC GREY-SILVER BPE400005-0102 4FRONT PORT METALLIC GREY-SILVER BPR410009-0101 1RUBBER FOOT NR3 BLACK 13.5xT2.0mm W/ADHE BRF200001-0001 8SILICA GEL 3 g DOT040001-0003 2Woofer SPK DRIVER 60W 4 OHM FSA026080-0402 1SONW PAD L340x W148 xH55mm EPS ICF000058-0005 2SPONGE L7xW5xT7mm BLACK IVE000032-0007 1DRIVER SPONGE OD210xID184xT1.0mm IVE000041-0001 1SPONGE OD97xID67xT5mm BLK EVA IVE000246-0004 1SPONGE L190 xW15xT1mm BLK IVE000246-0006 1SOFT SHEET L100xW80mm IVH002001-0006 1
SUB - Power board (power supply 2/3)Installation Point Description Material No. Qty.
POWER PCB ASSY APE200200-0001 1DC POWER PCB ASSY APE200201-0001 1
F1 F2 FUSE 4A 250V SLOW (WALTER TSD) KSA020400-0121 2 F3 F4 FUSE 8A 250V SLOW KSA020800-0130 2 F5 F6 FUSE 1A 250V SLOW (WALTER TSD) KSA020100-0120 2 J95 CONNECTOR 3 PIN CL3962WVO CCN396020-0103 1 J96 J97 CONNECTOR 6 PIN CL3962WVO CCN396020-0106 2 J25 CONNECTOR 2 PIN PITCH=2.0mm CCN200000-0102 1
F1 F2 F3 F4 F5 F6 FUSE CLIP DIA5xL20mm FUSE CFC011000-1001 6 D1 D2 SLEEVING OD3xID2.5xL10mm DSL001001-0100 2 C17 C18 COND ELECT 2200 uF 35V 20% PVE039560-2220 2 C13 C14 COND ELECT 3300 uF 50V 20% PVE039570-3320 2 C15 C16 COND ELECT 4700 uF 50V 20% PVE039570-4720 2
CON/WIRE 3P 300mm 2877#26 BLK VFL31131B-3000 1CON/WIRE 4P 300mm 1015#18 VWA310007-0001 1
U1 IC 3 PIN 7815 15V 1A RHI007815-0001 1 U2 IC 3 PIN AN7915T SAMSUNG RHI007915-0001 1 D2 BRIDGE KBU808 8A 800V UL RHD208080-0010 1 D1 BRIDGE RECTIFIER;RS402L 4A 100V UL RHD204010-0010 1 D3 BRIDGE RS202L 2A 100V UL RHD202010-0010 1 C19 COND DISC 0.22 uF 50V +80-20% PRD249670-2240 1C1 C10 C11 C12 C2 C20C3 C4 C5 C6 C7 C8 C9 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 13 C22 COND ELECT 1uF 50V 20% PRE039570-1090 1 C21 COND ELECT 2.2 uF 50V 20% PRE039570-2290 1JW90 JW91 JW92 JW93 JW94 JW95 JW96 JW97 JW98 WIRE BARE 22 GA TINNED XJP220000-0001 9 R3 RESISTOR 22K OHM 1/4W 5% CF QAF045000-2230 1 D4 DIODE;RECTIFIER 1N4001 RAD114001-0010 1
SUB - AC Power board (power supply 1/3)Installation Point Description Material No. Qty.
AC POWER PCB ASSY APE200202-0001 1 J94 CONNECTOR B2B-XH-A 2 PIN CCN250000-0102 1 J93 CONNECTOR B3B-XH-A 3 PIN CCN250000-0103 1 J91 J92 CONNECTOR 4 PIN CL3962WVO CCN396022-0104 2 CX1 COND SAFTY 0.01uF 250V 20% PLY2705F0-1030 1 K1 RELAY 6V 250V AC/5A MRL006001-0010 1 C25 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 1 R1 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 1 R2 RESISTOR 18 OHM 1/6W 5% CF QAF065000-1800 1
WIRE TIE GT-90M 90mm DWT000001-0900 1PCB BRACKET-R SECC GSE000253-0001 1PCB BRACKET-L SECC GSE000254-0001 1FUSE HOLDR FUSE HOLDER FH-B02 CFC021001-1001 1SLEEVING OD2xID1xL18mm DSL001002-0180 2BUSHING AC LINE BUSHING DBU001001-0010 1TUBING; DIA=4 L=20mm BLACK DTB004000-0200 2LINE CORD 2P 1980mm BLK VDE VPE003012-0020 1PCB CVR F ABS BPA400010-0101 1PCB CVR B ABS BPA400011-0101 1WIRE TIE GT-90M 90mm DWT000001-0900 4JACK PLATE SECC 218 x 98x3mm GSE400074-0102 1EVA SPONGE L192xW49.6 xT1mmBLK IVE000246-0001 1SCREW T3.0xL10xP1.06mm HSP140054-3100 17EVA SPONGE L192xW34xT1mm BLK IVE000246-0002 2SPONGE L216xW97.5xT2mmBLK IVE000246-0005 1
BEAD FERIT OD25.0xID15xH12.0 SFB001001-0060 1CON/WIRE 4P 120mm 1617#18x2P VWA310013-0011 1SPONGE L100xW30xT2mm IVE000085-0001 1GSB BKT R SECC T=1.0mm GSE200010-0001 1PCB BKT L SECC T=1.0mm GSE200011-0001 1AC CONNTOR AC CONNTECOR (HW-C3) (J3615) COT010002-0001 1POWER TRANSFORMER 230V EI-105 TTL023010-0050 1CON/WIRE 6P 250mm 1015#18 VWA310002-0008 1CON/WIRE AY 2 COND 430mm VWT503221-0430 1FUSE 4A 250V SLOW (WALTER TSD) KSA020400-0121 1SCREW M4.0xP0.7xL20 mm HSD143103-3200 4WASHER OD8.5xID4.3xT0.6 mm HWT168543-1060 4WASHER OD16 ID4.5 T1.0 HWS11G045-1100 4NUT M4.0xOD7.0xT3.0mm HNT140700-1300 4SCREW T4xL20xP1.59mm HSP140091-3200 16SCREW T3.0xL8xP1.06mm HSW140054-3080 18WASHER OD14xID3.2xT1.0mm HWS11E032-4100 1SCREW TRUSS HEAD TYPE ABT3.0XP1.06XL20mm HST140051-3200 4SCREW T4.0x1.59PxL16mm HSP140091-3160 8PORT EDGE ABS W/SPRAY MA4810 BPR000020-0001 1SCREW T3.5xP1.41x14mm HST140071-3140 8TUBE SHKNG DIA=20 L=50 T=0.4 UL DTB020000-0500 1TUBE SHKNG DIA=12 L=60mm BLACK DTB012000-0600 1RUBBER PAD DIA14.5mm ICH080007-0001 4WASHER OD6xID3xH2.5mm 602S-V0 DHU201001-0001 7
SUB - accessoriesInstallation Point Description Material No. Qty.
D-SUB 15P CABLE 4000mm BLK VWP000010-0010 1SOFT BAG L550xW150xT0.5mm IVY001012-0001 1SOFT SHEET L100xW80mm IVH002001-0006 1POLY BAG L240xW355mm IVA000001-0048 1POLY BAG L80xW220mm IVA000001-0019 1POLY BAG L600xW850xD100mm IVA000001-0026 1POLY BAG L240xW180mmxT0.03mm W/RECYCLE IVA000001-0088 1POLY FOAM FOR SUBWOOFER ITF200021-0001 2BATTERY D10x44mm UM-4 1.5V FBY006415-0003 2ANT ASS'Y INCL.VTA9300-009&021 ASL100034-0003 1LOOP ANT SHINTA PS-100 VTA100001-0020 1FM ANTENNA 1500 mm 75 OHM MALE VTA400001-0030 1ZONE LABEL L12xW12mm (EARTH 2) YLB424013-0001 3SAFETY MANUAL L210xH297mm YOM100183-1001 1SCREW T3.0xP1.06x8mm HST140054-3080 8SPONGE L120xW80xT2.0mm IVE100270-0003 1
Remote control Installation Point Description Material No. Qty.
X'MITT ASSY 50 KEY AIR250001-4301 1FRONT PANEL ABS R/C BPI200001-0001 1BACK CAB. FOR R/C ABS BPI200002-0001 1BATTERY COVER BPI200003-0001 1
INLAY 50 KEY PVC BNI250001-0001 1SPRING(+ -) DSP201002-0001 1SPRING(+) DSP201003-0001 1SPRING(-) DSP201001-0001 1KEY PAD 54 KEY RUBBER BRK201054-0001 1X'MITT PCB ASSY APE200150-0001 1
R3 CHIP RES. 1 OHM 1/10W 5% QCF015020-1090 1 D3 CHIP DIODE LL4148 TELEFUNKEN RCD104148-0010 1 R2 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 1 C3 COND ELECT 4.7 uF 50V 20% PRE039570-4790 1 C1 C2 CHIP CAP 200 pF 50V 5% PYL410370-2010 2 XL1 RESONATOR MURATA CSB 455EB JRN002001-0010 1 Q1 XISTR NPN SMT (2SC945) RCN200945-0001 1 D1 DIODE IRT LTE-5208AC RHO005208-2001 1 IC1 IC 24 PIN PT2222-001 PTC RCI002222-0001 1
X'MITT PCB HB 210x56 MM LHI200150-0301 1SCREW T2.2xP0.79xL8.0mm HSP140034-3080 1
JLudwigs
DSC500 SUB Main and Amp layout
JLudwigs
DSC 500 SUB Power supply layout
JLudwigs
Tuner
JLudwigs
Tuner
JLudwigs
Source unit power supply
JLudwigs
Source unit main
1 2 3 4
A
B
C
D
4321
D
C
B
A
ESS6018
WM8746 6CH AUDIO D/A
VIDEO FILTER
MEMORYFLASH 8M (29F080B)SDRAM 64M(4M*16SDRAM 9ns)
AT
AP
I
LCD
RDS: BU1923F
PLL: LC72131M
LA1837
FM
AM
VOL/TREBLE/BASS CTL
M62446AFP
AUDIOINPUTSELECT
AC-3/DTS Decode
EARPHONE
PT6583
TV ENCODE
WM8739 2CH AUDIO A/D
FILTER
FILTER
FILTER
Bass management
SUB
FLFRCSLSR
FL FR C SL SR SU
B
DIR
AK4112SWITH
I/O PORTEXPAND
AUX1
SCART IN( ANOLOG)
FL FR C SL SR SU
B
LT=L-0.707SL-0.707SR+0.707C
RT=R+0.707SL+0.707SR+0.707C
LINE OUT
L
R
EARPHONE AMPTDA2822M
TUNER
74F24474LS374*3
74F244
CD4052
VIDEO OUT
CVBSY/G/Y
C/R/PBB/PR
M62446 OUT PORT
DATA
SUB
FR
FL
C
SL
SR
FR
FL
C
SL
SR
SUB
CABLE
LOADER
OUT
POWER BOARD
MAIN BOARD
EEPROM(24C02A)
EXTERNAL COAXIAL
L/R
L/R
L/RL/R
1.SCART(PRB.YG.PBR.CVBS)2.COMPOSITE(CINCH)3.COMPONENT(YUV)4.S-VIDIO
AUDIO
TRANSMITTER
SCART OUT
(SMPS)MAINS POWER(ECO STANDBY<1W)
AUX1L/R
CD4053
BALANCEOUT
JLudwigs
Source unit Block diagram
Balance receiver EQ AMPLIFIER
R-IC101 R IC1 R U2
R+ TL072 TL074 LM3886
C-IC201 C IC2 C U5
C+ TL072 TL074 LM3886
L-IC301 L IC3 L U1
L+ TL072 TL074 LM3886
SR-IC401 SR IC4 SR U4
SR+ TL072 TL074 LM3886
SL-IC501 SL IC5 SL U3
SL+ TL072 TL074 LM3886
SW-IC601 SW IC6 SW U6
SW+ TL072 TL074 LM3886
MUTE FROM DVD
DSC500SUB BLOCK DIAGRAM
BA
LA
NC
E IN
PU
T F
RO
M D
VD
R
C
L
SR
SL
SW
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
A
B
C
D
16151413121110987654321
D
C
B
A
LA0LA1LA2LA3LA4LA5LA6LA7LA8LA9LA10LA11LA12LA13LA14LA15LA16LA17LA18LA19
LA21
LD0LD1LD2LD3LD4LD5LD6LD7
HRD#HWR#HIORDYHRST#
HA2
DB0DB1DB2DB3DB4DB5DB6DB7DB8DB9DB10DB11DB12DB13DB14DB15
DMA11DMA10DMA9DMA8
DMA3DMA2DMA1DMA0
SPD
IF
AUX0AUX1
DMA7DMA6DMA5DMA4
MA0MA1MA2MA3
MA4MA5MA6MA7
MA8MA9MA10MA11
MA0MA1MA2MA3
MA6
MA4
MA7
MA5
MA11
MA9MA10
MA8
CKE
CS0#
RAS0#
DQMX
BANK0BANK1
DB0DB1DB2DB3DB4DB5DB6DB7DB8DB9DB10DB11DB12DB13DB14DB15
DB[0..15]MA[0..11]
CAS#
WE#
LA0LA1LA2LA3LA4LA5LA6LA7LA8LA9LA10LA11LA12LA13LA14LA15LA16LA17
LOE#
LCS3#
LD0LD1LD2LD3LD4LD5LD6LD7
LD[0..15]
LA18LA19
LA[0..19]
VREF
LCS1#
HA1HA0
HIRQ
HCS3#HCS1#HIOCS16#
EARDEC
LD8LD9LD10LD11LD12LD13LD14LD15
WRHL#
LCS2#
1 82 73 64 5
RA10433x4
ZD1017V
1 82 73 64 5
RA105 33x4
ZD1027V
FB104FERB
1 82 73 64 5
RA106 33x4
1 82 73 64 5
RA107 33x4
C139104
R112
4.7K
1 82 73 64 5
RA114
10x4
R109 10 OHM
R105
4.7K
R106 33 OHM
(15PF)1 82 73 64 5
RA103 33x4
VCC 1
DQ0 2DQ1 4
VSSQ 6
DQ2 5
DQ3 7
VCCQ 3
DQ4 8
DQ5 10
VSSQ 12
DQ6 11DQ7 13
VCCQ 9
DQML15
WE16CAS17RAS18
CS19
A1135 A1022
A023A124
A225
A326
VCC 14
VSS 28
A429
A530A631A732
A833A934
NC36
CKE37
CLK38
DQMH39
NC40
VCCQ 43
DQ8 42DQ9 44
VSSQ 46
DQ10 45
DQ11 47
VCCQ 49
DQ12 48
DQ13 50
VSSQ 52
DQ14 51
DQ15 53
VSS 41
BA020
BA121
VCC 27
VSS 54
IC108
4Mx16 SDRAM (9ns)
C147470PF
C148470PF
R115100 OHM
HD0/DCI[0]/EAUX1[0]122
DCS0 100
HD1/DCI[1]/EAUX1[1]123
YUV0/CAMYUV2 106
HD2/DCI[2]/EAUX1[2]124
VC2
59
HD3/DCI[3]/EAUX1[3]125
YUV1/VREF 107
HD4/DCI[4]/EAUX1[4]126
VC2
535
HD5/DCI[5]/EAUX1[5]127
YUV2/CDAC 108
HD6/DCI[6]/EAUX1[6]128
VC3
31
HD7/DCI[7]/EAUX1[7]131
YUV3/COMP 109
HD8/DCI_FDS/EAUX2[0]132
AV
CC(V
DA
C)11
1
HD9/EAUX2[1]133
YUV4/RSET 110
HD10/EAUX2[2]134
VC2
583
HD11/EAUX2[3]135
YUV5/YDAC 113
HD12/EAUX2[4]136
VC3
318
HD13/EAUX2[5]137
YUV6/VDAC 114
HD14/EAUX2[6]140
VC2
512
1
HD15/EAUX2[7]141
YUV7CAMYUV3 115
VC2
513
9
VC3
327
VC2
517
2
VC2
544
VC3
359
VC3
368
VC3
375
VC3
392
VC3
399
AV
CC(P
LL)
51
VC3
310
4V
C33
130
VC3
314
8
VC3
315
7V
C33
159
VC3
316
4V
C33
183
VC3
319
3
VC3
320
1V
SS12
9
DMA0 53
LA42
DMA1 54
DMA2 55
LA53
DMA3 56
LA64
DMA4 57
LA75
DMA5 58
LA86
LA97
VSS
8
LA1010LA1111
LA1212
LA1313LA1414
LA1515LA1616
VSS
17
LA1719
LA1820LA1921
LA2022LA2123
RESE
T24
TDMDX/RSEL25
VSS
26
TDMDR28TDMCLK29
TDMFS30
TDMTSC31
TWS/SEL_PLL2 32TSD0/SEL_PLL0 33
VSS
34
TSD1/SEL_PLL1 36TSD2 37
TSD3 38
MCLK 39
TBCK 40
SPD
IF/S
EL_P
LL3
41
NC/
CAM
VS
42
VSS
43
RSD 45RWS 46RBCK 47
NC/
APL
L48
XIN 49XOUT 50
AV
SS(P
LL)
52
VSS
60
DMA6 61
DMA7 62DMA8 63
DMA9 64
DMA10 65DMA11 66
VSS
67
DCAS 69
DSCK/DOE 70
DWE 71DRAS0 72
DBANK0/DRAS1 73DBANK1/DRAS2 74
VSS
76
DB0 77DB1 78
DB2 79DB3 80
DB4 81
DB5 82
VSS
84
DB6 85
DB7 86DB8 87
DB9 88
DB10 89DB11 90
VSS
91
DB12 93
DB13 94DB14 95
DB15 96
DCS1 97
VSS
98
DQM 101
DSCK 102
VSS
103
CLK 105
AV
SS(V
DA
C)11
2
PCLK2XSCN/CAMYUV4 116
PCLKQSCN/CAMYUV5/AUX3[2] 117
VSSCN/CAMYUV6/EAUX3[1] 118HSSCN/CAMYUV7/EAUX3[0] 119
VSS
120
VSS
138
HWRQ/DCI_REQ/EAUX4[1]142
HRDQ/EAUX4[0]143HIRQ/DCI_ERR/EAUX4[7]144HRST/EAUX3[5]145
HIORDY/EAUX3[3]146
VSS
147
HWR/DCI_CLK/EAUX4[5]149
HRD/DCI_ACK/EAUX4[6]150
HIOCS16/CAMPCLK/EAUX3[4]151HCS1FX/EAUX3[7]152
HCS3FX/EAUX3[6]153HA0/EAUX4[2]154
HA1/EAUX4[3]155
VSS
156
HA2/EAUX4[4]158
AUX0 160
AUX1 161AUX2 162
VSS
163
AUX3 165AUX4 166AUX5 167
AUX6 168AUX7 169
LOE170
VSS
171
LCS0173
LCS1174
LCS2175LCS3176
VSS
177
LD0178LD1179
LD2180
LD3181LD4182
VSS
184
LD5185LD6186
LD7187
LD8188LD9189
LD10190
LD11191
VSS
192
LD12194
LD13195LD14196
LD15197
LWRLL198
LWRHL199
VSS
200
CAM
YU
V0
202
CAM
YU
V1
203
LA0204LA1205
LA2206LA3207
VSS
208
IC103
L104
2.4UH
R104 4.7K
1 82 73 64 5
RA112
10x4
1 82 73 64 5
RA111
33x4
R113
4.7K
1 82 73 64 5
RA113
10x4
A0 12
A1 11
A2 10A3 9
A4 8A5 7
A6 6
A7 5A8 27
A9 26A10 23A11 25
A12 4A13 28
A14 29
A15 3
D013
D114
D215D317
D418D519
D620
D721
A16 2
CE 22
OE 24
A18 31A17 30
A19 1
VCC32
GND16
WE#34 RESET33
IC102
27C080-90
R114 270
C138 104
VCC33
VCC27VCC33E
VCC33P
VCC
VCC33E
VCC
VCC
VCC
VCC33
VCC
VCC
VCC33E
ES6018ES6018ES6018ES6018
SERIAL EEPROM
VIDEO OUT
8MBIT EPROM
R4121
12K
C4113472
R4117
24K
C1102100UF
C4117561
C449
104
C448
104
67
5
8
IC110B4558
67
5
8
IC111B4558
C4115104
X012X113
Y02
Y11
Z05
Z13
INH6
A11
B10C9
VEE 7
X 14
Y 15
Z 4
VCC 16
GND8
IC408
4053
R442 47KR443 47K
R445 47KR444 47K
R446 47KR447 3K
21
4
3
IC409A
4558
R449 12K
R450 47K
C4119 561
67
5
8
IC112B4558
C4114
10UF
C4120104
C4118104
R448 8.2K
R4116
12K
C4112104
C4111104
R412012K
LA12
LA9
LA5
LA11
LA4
LA16
LA1
LA15
LA3
LA18LA17
LA13
LA2
LA8
LA14
LA10
LA7LA6
Vcc
LD5LD4
LD2
LD0LD1
LD3
LD7LD6
LA0
RESET
LOE#
LCS3#
LA19 A191A182
A173A164
A155
A146A137
A128CE#9Vcc10
NC11RESET#12
A1113
A1014A915
A816A717
A618
A519A420 A3 21A2 22A1 23A0 24DQ0 25DQ1 26DQ2 27DQ3 28GND 29GND 30VCC 31DQ4 32DQ5 33DQ6 34DQ7 35RY/BY# 36OE# 37WE# 38NC 39NC 40
IC101 AM29F080B
AMD Vcc
ZD1037V
ZD1047V C149
470PFC150470PF
R116100 OHM
L105
2.4UH
VCC33E
ZD1057V
ZD1067V C151
470PFC152
470PF
R117100 OHM
L106
2.4UH
VCC33E
ZD1077V
ZD1087V C153
470PFC154470PF
R118100OHM
L107
2.4UH
VCC33E
1 82 73 64 5
RA109
33x4
R176 33 OHMR175 33 OHM
MCLKTBCKTWSTSD0TSD1TSD2
AMCLKBICK
LRCKSD0SD1SD2
R110
4.7K
XL101
27MC133
22P
R108 56K
C13422P
1213
IC104F
TC74HC04AFN
1011
IC104E
74ALS04
L10110uH
C135102
CLK
R107 33 OHM
8 9
IC104D
74ALS04
5 6
IC104C
74ALS04
34
IC104B
74ALS04 1 2
IC104A
74ALS04
HD0HD1HD2HD3HD4HD5HD6HD7HD8HD9HD10HD11HD12HD13HD14HD15
18
27
36
45
RA11
74.
7Kx4
18
27
36
45
RA1184.7Kx4
D0 3Q02D1 4Q15
D2 7Q26
D3 8Q39D4 13Q412
D5 14Q515D6 17Q616
D7 18Q719
OE 1
CLK 11
IC106 74HC374
DD0DD1DD2DD3
DD4DD5DD6DD7
DD8DD9DD10DD11
DD12DD13DD14DD15
TDM-FS
TDM-CLKTDM-DA
D03 Q0 2
D14 Q1 5
D27 Q2 6D38 Q3 9
D413 Q4 12D514 Q5 15
D617 Q6 16
D718 Q7 19
OE1CLK11
IC105 74HC374
LD0LD1LD2LD3LD4LD5LD6LD7
LCS1#
LCS2#
LCS0#
6583OUT
REMOTE
CDAC
UDAC
SD
1 2 3
IC113BA033T
FB101
100
FB102
100
VCC+5V
C14010UF
C14110UF C143
10UFC14510UF
C142104 C144
104C146104
VCC33
C111104
C1011104
C101210UF
C1007104
C101010UF
C125104
C100910UF
C12610UF
C1006104
C1005104
C1008104
C13610UF
C120104
C121104
C118104
C119104
C12310UF
C108104
C109104
C110104
C107104
C11310UF
C122104
C101104
C106104
C102104
C103104
C116
104C104104
C105104
C137104
VC33
VCC33
VCC
SDRAM
EPROM
OSC74LS04
-12V
R144 1K
R143 5.6K
R142 4.7K
C193332
C192562
C191562
R141 1KC190
10UF
67
5
8
IC409B4558
C194104
R140 1K
R139 22K
R138 4.7KC188 151
C187103
C186103
R137 1KC185
10UF
21
4
3 IC112A4558
C189104
R136 1K
R135 22K
R134 4.7K
C183151
C182103
C181103
R133 1KC180
10UF
C184104
R132 1K
R131 22K
R130 4.7K
C178151
C177103
C176103
R129 1KC175
10UF
21
4
3 IC111A4558
C179104
R128 1K
R127 22K
R126 4.7K
C173151
C172103
C171103
R125 1KC170
10UF
C174104
R124
1K
R123 22K
R122 4.7K
C168151
C167103
C166103
R121 1KC165
10UF
21
4
3 IC110A4558
C1001 100UF
C169104
L10210uH
C15510UF
C156104
VD33
FB103FERB
C114
10UF
C115104
EAUX30
1 82 73 64 5
RA110
33x4
RCLK
C157 104
C158104
L10310uH
C16010UF
C159104
VCCAVCC33
VD33
VCCA
C16110UF
C162104
C163
3.3U
FC1
6410
4HWRQ#
C129104
C131104
C13210UF
VCC VCC
C
VDAC
CVBS andCOLOR DIFFERENCE
PRUDAC
R,G,BCVCV
YDAC G
R
YYPB BCDAC
S-VIDEOCVBS and
B
EC
Q102
C945
ZD1097V
R146
1K
R145
4.7K
+12V
HD0HD1HD2HD3
HD4HD5HD6HD7
HD8HD9HD10HD11
HD12HD13HD14HD15
1 82 73 64 5
RA108
33x4
HD[0..15]
HRD#HWR#HIRQHWRQ#
DRD#
OKDECDIRQDWR#
VCC33
1
2
3
4
8
9
5
6
7
JK401
X012X114
X215
X311
Y01Y15
Y22
Y34
INH6A10
B9VEE 7
X 13
Y 3
VDD 16
GND8
IC401 4052
R431
4.7K
R440
4.7K
R401 8.2K
R402 8.2K
R403 8.2K
R404 8.2K
C405101C406101
C401101C402101
C403101C404101
R406 47K
R408 47K
R41
16.
8KR
412
6.8K
R41
36.
8KR
414
6.8K
R422 12K
R42
010
0K
C413 47PC411
10UF
R4211K
C1015
10UF
ZD4017V
R496
150
C407100UF
C408104
ZD4027V
R497
150
C409100UF
C410104
+12V
-12V
67
5
8
IC402B4558
C415 104
R424 12K
C426100UF
R41
910
0K
C416 47PC412
10UF
R4231K
C1016
10UF
21
4
3IC402A4558
C418 104
C425100UF
R430
47KC420
10UF
C419 22P
C422
10UF
67
5
8
IC403B4558
C42122P
R439
47K
R41
539
0 O
HM
R41
639
0 O
HM
21
4
3IC403A4558
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
CN201
R43310K
Q403A733
OUT41OUT32
OUT23OUT14
AVDD5
SWIN6GNDS7
SRIN8
SLIN9GNDS10
CIN11GNDR12
RIN13
GNDL14LIN15
BYPASSR16BAPASSL17LTRE18
LBASS319LBASS220
LBASS121 RBASS1 22RBASS2 23RBASS3 24RTRE 25CR2 26CR1 27CL2 28CL1 29AVSS 30LOUT 31ROUT 32COUT 33SLOUT 34SROUT 35SWOUT 36AGND 37DGND 38LATCH 39DATA 40CLK 41DVDD 42
IC41
0M
6244
6AFP
C45
5 822
C456
153
C457474
C459 10UF
C458 10UF
ZD4037V
ZD4047V
R462150
R463150
+12V -12V
C461100UF C462
100UF
C46
510
0UF
R456 100
R455 100
C45
282
2
C453153
C454474
VOL-SRVOL-SLVOL-C
VOL-LVOL-R
C46
410
4
R407 1K
R453 100R452 100
R454 100
R451 100
R46133
R405 1K
C423104
C424104
+12V
+5V
TO L
OA
DER
LO
RO
Q402C2878
Q401C2878
R4321K
R4411K
4052A4052B
R054
22KR0534.7K
Q009A733
R05110K
R052100K
Q008C945
C071100UF
R058
22KR0574.7K
Q011A733
R0554.7K
R05647K
Q010C945
C072100UF
TU12V
TU5V
C450100UF
C451100UF
C463104C460
104
1234
CN501
C531104
C530104
R52410K
R52510K
R5294.7
R5284.7
+12V
R533
56KR53410K
+12V
R522
22K
C524
10UFQ502
C945
R530
4.7K
R523
22K
C525
10UFQ503
C945 1
4
3
2
5
6
7
-
+
+
-
8
IC504
TDA2822M
L50710uH
L50810uH
C53310uF
C526
100UF
C527
100UF
C528
220UF
C529
220UF
C4110
10uF
DIRQ
DD2DD1
DD8
DRST#
DD13
DD0
DACS1#
DD9 DD6
DD14
DD5DD10
DD15
DA0DA1
DD7
DD4DD11DD12 DD3
DWR#DRD#DIORDY
DA2
DIOCS16#
DD[0..15]
DACS3#
R1024.7K
R1014.7K
RESET1 GND 2D73 D8 4
D65 D9 6D57 D10 8
D49 D11 10
D311 D12 12D213 D13 14
D115 D14 16
D017 D15 18GND19 KEY 20
DRQ21 GND 22IOW23 GND 24
IOR25 GND 26
IOCHRDY27 BALE 28DACK29 GND 30
IRQ1431 IOCS16 32A133 RESERVED 34A035 A2 36
CS037 CS1 38ACTIVITY39 GND 40
CN103
HDR20X2-100
VCC
VCC
EAUX30
C1000
10UF
C199
10UF
C198
10UF
C197
10UF
C196
10UF
C195
10UF
123456
JK101
BNC
VGND
R46022K
R45922K
R45822K
R45722K
+5V
R41
76.
8KR
418
6.8K
R41
08.
2KR
409
8.2K
+12V
+12V
-12V +7V
-7V
+7V
-7V
VCC
1 82 73 64 5
RA102 33x4
1 82 73 64 5
RA101 33x4
HA2HA1HA0HCS3#
HCS1#
HIORDYHRST#
HIOCS16#
DRST#DIORDYDIOCS16#DACS1#
DACS3#DA0DA1DA2
+12V
R412
410
KR4
125
10K
R412
710
KR4
128
10K
R412
610
K
R412
910
K
SWIN
SRINSLIN
CIN
RIN
LIN
DVDD1
DVSS2TVDD3
VTX4
XTI5XTO6
PDN7R8AVDD9
AVSS10RX111
RX2/DIF012
RX3/DIF113RX4/DIF214 AUTO 15P/S 16FS96 17ERF 18LRCK 19SDTO 20BICK 21DAUX 22MCK02 23MCK01 24OCKS0/CSN 25OCKS1/CCLK 26CM1/CDTI 27CM0/CDTO 28
IC116
AK4112B
C101847P
C101747P
R1505.6K
R1485.6K
R147
5.6K
1A12
1A241A36
1A48
2A1112A213
2A3152A417
1G12G19
1Y1 18
1Y2 161Y3 14
1Y4 12
2Y1 92Y2 7
2Y3 52Y4 3
IC117 74F244
R149
5.6K
L108 10uHC101910UF C1020
104
VCC33
LD8LD9LD10LD11LD12LD13LD14LD15
LD8LD9
LD11LD15
R158 33R159 33R160 33R161 33R162 33
R164 33R165 33R166 33
C1021104
1 82 73 64 5
RA115
33x4
MCLK
TBCKTWSTDA
TBCK1TWS1
TDA1
MCLK1
R425 47K
R427 150K
R426 68K
R428 150K
R429 47K
R434 47K
R436 68KR435 68K
R437 68KR438 47K
-12V
R154 1K
R155 33
R156 33
R157 33
C1026104
C102710UF
C1024104
C102510UF
C1022104
C102310UF
VCC33
R151 33CLK
R152 18K
C1014104
A161A152
A143A134
A125
A116A97
A88WE#9NC10
NC11NC12
A1813
A714A615
A516A417
A318
A219A120 A0 21CE# 22GND 23OE# 24DQ0 25DQ1 26DQ2 27DQ3 28NC 29VCC 30VCC 31DQ4 32DQ5 33DQ6 34DQ7 35A10 36A19 37NC 38GND 39A17 40
IC114 SST39LF080/016
LA12
LA9
LA5
LA11
LA4
LA16
LA1
LA15
LA3
LA18
LA17
LA13
LA2
LA8
LA14
LA10
LA7LA6
LD5LD4
LD2
LD0LD1
LD3
LD7LD6
LA0
LOE#
LCS3#
LA19
SST VC33
+12V
-12V
C1028104
C102910UF C1030
104
VCC VCC
S0 1
S1 2S2 3
GND 4SDA5 SCL6 WC7 VCC8
RESET
ENCO
DE1
ENCO
DE2
D102 1N4148
ENCODE1ENCODE2
67
5
8
IC414B4558
+12V
R411856K
1A121A24
1A361A48
2A111
2A2132A315
2A417
1G1
2G19
1Y1 181Y2 16
1Y3 141Y4 12
2Y1 9
2Y2 72Y3 5
2Y4 3
IC118 74F244
MCLK
D03 Q0 2
D14 Q1 5D27 Q2 6
D38 Q3 9D413 Q4 12
D514 Q5 15
D617 Q6 16D718 Q7 19
OE1CLK11
IC119 74HC374
DVDD1SCK12
BCKIN3LRCIN4
DIN05
DIN16DIN27
MODE8
LRCIN210
DGND11ML/I2S12
MC/IWL13
MD/DM14 AVDD2 15CAP 16OUT2L 17GR2 18OUT2R 19AGND1 20OUT1L 21GR1 22OUT1R 23AGND2 24OUT0L 25
MUTE9
GR0 26OUT0R 27AVDD1 28IC109
WM8746
VCCA
SDIN1SCLK2
MCLK3
XO4DCVDD5
DGND6DBVDD7
BCLK8
NC10 ADCDAT 11ADCLRC 12NC 13AVDD 14AGND 15VMID 16RLINEIN 17LLINEIN 18MODE 19CSB 20
NC9
IC115
WM8739
WM8746DAWM8746CLK
C1101
104
R16810K
B
EC
Q103
C945
R169
4.7K
VCC
LD0LD1LD2LD3LD4LD5LD6LD7
WM8746CLKWM8746DAWM8746CE
R167 33 WM8739CE
WM8739CE
C1103104
WM8746CLKWM8746DA
WM8746CE
VCC33
FB105 FERBFB106 FERBFB107 FERB
C1107
47P
C1105
47P
C1106
47P
AMUTE
R111 0
VC33VCC33
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
CN101CON15
+12VGND-12V
+5V
SMPS
D513 1N4148
R54010K
R542
100KQ506C945
D505 1N4148
+12V
D504 1N4148
D506 1N4148
D511 1N4148
BMUTE
R5436.8K
D510 1N4148
R54110K
C534220UF
D512 1N4148
D5151N4148
D507 1N4148
D5141N4148D508 1N4148
D509 1N4148D516 1N4148
D519 1N4148
D518 1N4148
D520 1N4148AM
UTE
+6V
COMPOSITE
S-VHS
2CH.ANALOG OUTPUT
LINE IN AUX1
LINE IN AUX2
TU-L
TU-R
PBRYG
CVBS
VDAC
PRE-MUTE
WRLL#
WRLL#
WRLL#
WRLL#
RESE
T
Q501A733
R5324.7k
R531
4.7k
R527
3.3K
R526
3.3K
+5V
GNDGND
+12V
CONTINUOUS READING SEEKING & SPIN UP
500mA(AVERAGE)
300mA(AVERAGE)
0.8A(MAXIMUM)
1.5A(MAXIMUM)
SMPS
C532
100uF
CVBS-OUT1
YDACUDAC
CDAC
R153 560
C1104101
6583IN
6583
IN
FB206 601
FB205 601
FB204 601
FB203 601
FB207 601FB208 601
FB202 601
FB201 601
C21615P
C21915P
C21815P
C21715P
AOR 1
AOL 3
B GND 5
B 7
G GND 9
G 11
R GND 13
R 15
VGND 17
VOUT 19
SHIELD 21
AIR2
AGND4
AIL6
SWTCH8
CLKOUT10
DATA12
DATAGND14
BLNK16
BLNKGND18
VIN20
JK201
SCART_21PIN
C21510UF
C21410UF
VGND
C22415P
C22515P
C22115P
C22015P
C22215P
C22315P
JK203
R235
200R236
100 C23047P
VGND
OUTMUTE
OUTMUTE
C-INPUT
SL-INPUT
SR-INPUT
SW-INPUT
R4011 10K
R401010K
21
4
3 IC416A
4558
C4012104
R4013 10K
R4012 10K
C4010104
+12V
67
5
8
IC416B
4558
-12V
L-INPUTL+
R4014 10K
R4016 5.1K
R4015 10K
L-
R4001 10K
R400010K
21
4
3 IC415A
4558
C4002104
R4003 10K
R4002 10K
C4000104
+12V
67
5
8
IC415B
4558
C4001100UF
C4003100UF
-12V
R-INPUTR+
R4004 10K
R4006 5.1K
R4005 10K
R-
R4051 10K
R405010K
21
4
3 IC420A
4558
C4052104
R4053 10K
R4052 10K
C4050104
+12V
67
5
8
IC420B
4558
-12V
SL-INPUTSL+
R4054 10K
R4056 5.1K
R4055 10K
SL-
R4041 10K
R404010K
21
4
3 IC419A
4558
C4042104
R4043 10K
R4042 10K
C4040104
+12V
67
5
8
IC419B
4558
C4041100UF
C4043100UF
-12V
SR-INPUTSR+
R4044 10K
R4046 5.1K
R4045 10K
SR-
L-INPUT
R-INPUT
R4021 10K
R402010K
21
4
3 IC417A
4558
C4022104
R4023 10K
R4022 10K
C4020104
+12V
67
5
8
IC417B
4558
-12V
C-INPUTC+
R4024 10K
R4026 5.1K
R4025 10K
C-
C4021100UF
C4023100UF
R4061 10K
R406010K
21
4
3 IC421A
4558
C4062104
R4063 10K
R4062 10K
C4060104
+12V
67
5
8
IC421B
4558
-12V
SW-INPUTSW+
R4064 10K
R4066 5.1K
R4065 10K
SW-
123456789101112131415
CN401
CON15
123456789101112
CN901
CON12
L+L-R+R-SR+SW+SW-SL+SL-SR-C-C+GND
C602
104
L602
100UH
C601
51p
R60175 OHM
L601
0.68UH
C605104
C604100UF
1
2
3
4
5
6
7
8
9
10
11
12
13 14
15
16
17
18
19
20
21
22
23
24
25
IC601 BH7860FP
CDAC
+5V
L603
100UHC607104
C606100UF
+5V
R602
75 OHM
C603
1UFYDAC
C610
51p
L604
2.7UH
C611
104
R605
75 OHM
C612
51p
L6050.68UH
R607
75 OHM
C613
100UF
R609
75OHM
C614100UF
R611 0
R612 0
C616 22UF
C615
51p
L606 2.7UH
CVBS-OUT1
CVBS-OUT1
R177
75 OHM
VIDEO DRIVER BUFFER
+5V
/STA
ND
BYPC
ON
LOA
DER
CMU
TEREMOTE6583OUT
6583CLK6583CE
+5V/STANDBYPCON
POWERDOWN
LOADER-CONAUDIO 5.1 CHANLE BALANCE OUT
1234
1
2
J001
JUMPER
1
2
J003
JUMPER
21
4
3
IC414A4558
C4116104 -12V
7346CLK7346DA7346CE
7346CE7346DA
7346CLK
6583CLK6583CE
BMUTE
LOADER
OPT
ICA
L
HPMUTE
+5V
+5V
-12V
-12V
IC105-12
C494
4.7UF
+12V
C469104
C472104
R470
1.5K
R471
5.6K
R476 1.5K
C495
4.7UF
R477
5.6KR4103
1K
R4102
1K
C471 331
R4122 1K
R46922K
R474 1K
R47522K
C496
4.7UF
C4124104
C482104
R482
1.5K
R483
5.6K
R488 1.5K
C497
4.7UF
R489
5.6KR4107
1K
R4105
1K
C476 331
C481 331
R480 1K R48122K
R486 1K R48722K
C498
4.7UF
C484104
C493104
R494
1.5K
R495
5.6K
R4100 1.5K
C499
4.7UF
R4101
12KR4111
1K
R4109
1K
C486 331
C492561
R492 1K R49322K
R498 1K R49922K
-12V
C466 331
C1561
C2561
C3561
C4561
C5561
C6561
R171100K
C1200104
123
IC120
LM809
VCC33
R170
0RESET
21
4
3IC411A
4558
67
5
8
IC411B
4558
21
4
3
IC412A
4558
67
5
8
IC412B
4558
21
4
3
IC413A
4558
67
5
8
IC413B
4558
C4123100UF
C4122100UF
C4201
10uF
C4202
10uF
C4203
10uF
C4204
10uF
C4205
10uF
C4206
10uF
C535104
ZD4056V
R4230
150+12V
R613
0R614 0
YDAC
C-OUT
L
R
R
L
FB108100
FB109100
AUXOUT/MUTE
1 2 3
IC1219164CG
VCC27
R179100
R178
120
VCC
R412310K
R410410K
R410610K
R410810K
R411010K
R41121.2K
YDACCDAC
P-OFF
P-O
FF
JLudwigs
Source unit Main board Sch DSC500
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A
T i t l e
Num be r R evisionSize
A2
Date : 23-Oct-2002 Sheet of Fi le : E : \ C JH\DSC500\DSC500\Dsc500e .ddb Drawn By:
C21110UF
C212104
R22468k
TA207
TA202
D202 1N4148
D2031N4148
123SN201
C206100UF
C207104
TA208
TA203
TA209
TA204 TA201
R207
100
R227560
R21
110
0
R21
210
0
R21
310
0
C20
915
P
C21
015
P
C20
815
P
R208100K
POW E R1
SOUR C E2
GND3
R E S E T4
GND5
PL AY6
O P E N7
F18
IR9 F2 10LOADER 11
OFF 12F313VDD14XIN15XOUT 16
PC ON 17MUTE 18
IC201
CF745
TA210
R20
110
K
R20
210
K
R20
310
K
R20
410
K
R20
510
K
C20110UF
D20
11N
4148
XL2014M
R206100K
C204
22P
C205
22P
C202100UF
C203104
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
RB202CONS15
R209
560
Q204C945
Q205PNP
R21010K
123
RB203
C ON3
123
CN203
C ON3
C226221
60 59 58 3 2 1456789101112131415161718192021222324252627282930313233343536373839404142434445464748495051525354555657
DP201 LCD-171
KI4
KI3
KI2
KI1
VCC
OSC
11 22 33
44
55
66
77
88
99
1010
1111
1212
1313
1414
1515
1616
1717
1818
1919
2020
2121
2222
2323
2424
2525
2626
2727
2828
2929
3030
3131
3232
3333
3434
3535
3636
3737
3838
3939
4040
4141
4242
4343
4444
4545
4646
4747
4848
4949
5050
5151
5252
5353
5454
5555
5656
5757
5858
59 59
60 60
6161
6262
63 63
64 64
6565
6666
6767
6868
6969
7070
7171
7272
7373
7474
7575
7676
7777
7878
7979
8080
IC202
PT6583
SG5
SG6
SG7
SG8
SG9
SG
10
SG
11
SG
12
SG
13
SG
14
SG
15
SG
16
SG
17
SG
18
SG
19
SG
20
SG
21
SG
22
SG
23
SG
24
SG
25
SG
26
SG
27
SG
28
SG
29
SG
30
SG
31
SG
32
SG
33
SG
34
SG
35
SG
36
SG
37
SG
38
SG
39
SG
40
SG
41
SG
42
SG
43
SG
44
SG
45
SG
46
SG
47
SG
48
SG
49
SG
50
SG
51
SG
52
SG
53
SG
54
SG
55
SG
56
SG
57
SG1 SG
2 SG3 SG
4
COM1COM2COM3
KS3KS4
C2160.047uF
C215
820pF
R2251K
VCC
EN
CO
DE
1
EN
CO
DE
2
R22
610
0
C21
415
P
R228 100
C218 334
R229100
+5V
CE
CL
K
DIN
DO
UT
VOLUMEPOT2
ENCODE1
ENCODE2
CE
CL
K
DO
UT
VC
C
DIN
RE
MO
TE
MU
TE
LO
AD
ER
PCO
N
+5V
1234
CN2
C ON4
D205 L E D
D206 L E D
1234
CP2
C ON4
R230
10K
R231
10K
C220100
C221100
VCC
D207
L E D
Q206PNP
R21956K
D2041N4148
D208 1N4148
R21510K
D209 L E DR233 100
JLudwigs
Source unit Front board SCH
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A
Title
Number Revisio nSize
A3
Date: 23-Oct-2002 Sh eet o f File: E:\CJH\DSC500\DSC500\Dsc500e.dd bDrawn By:
FL+
FL-
10
11
13
16
14
12
15
18
16
98
73
1
17
TR
AC90V-260V
IN1 OUT 3
GN
D2
IC7
MC7812CT
IN2 OUT 3
GN
D1
IC6
MC7912CT
C3 1330uF/25V
1234
CONB
CON4
11
2 2
33
44
55
66
77
88
IC1
NCP1002
GNDK(4PIN12V)GND+5 V(1 .5 A)GND-12VGND+12V
+5V(500mA)
+12V(300 mA)GND
12
CN902
CON2
PH
PC81 7
C3 2
330u
F/2
5V
C1
0.22
uF/2
75V
C2
0.22
uF/2
75V
C3
2200
PF
/275
V
C4
2200
PF
/275
V
C9
0.1u
F/2
5V
C7
0.01
uF/6
30V
t
RT
10D5
FU
3 .15A/250V(CE)
L127mH
D1
1N
40
07
D2
1N
40
07
D31
N4
00
7D4
1N
40
07
D5
MU
R18
0
C5
68uF
/400
V
C8
100u
F/2
5V
C6
2.2u
F/2
5V
R11M
R3
22K
/2W
R4
1K R5
2 2
C4 2
0.1u
F/2
5V
C4 4
0.1u
F/2
5V
C3 5
0.1u
F/2
5V
C3 7
0.1u
F/2
5V
C4 6
0.1u
F/2
5V
C3 9
0.1u
F/2
5V
C4 70.1uF/25V
C2 8
0.1uF/25V
C2 9
0.1u
F/2
5V
C1 9
0.1uF/16V
C1 7
0.1uF/16V
C1 1
2200PF/400V
C4 1
330u
F/2
5V
C3 3
330u
F/2
5V
C3 6
330u
F/2
5V
C4 3
330u
F/2
5V C4 5
330u
F/2
5V
C3 8
330u
F/2
5V
C4 0
330u
F/2
5V
C3 4
330u
F/2
5V
R2 2
3K
R2 1
3K
D7
MB
R1
10
0
D8MBR1100
D9 MBR1100
D1 1
MBR1100
L4
3.3uH/3A
L5
3.3uH/3A
L3
3.3u
H/3
A
C1 5
1000uF/10V
C4 8
1uF/25V
C1 2
1uF/25V
C1 8
1000uF/10V
C1 01uF/25V
C2 0
470uF/16V
C2 1
0.1uF/25V
R1 9
4.7K
R1 6
10K
R1 7 3K
R1 524K R1 8
47K
R1 433K
R7
6 8
R8100
R61K
R1 02.7K
R93K
IC2TL43 1
Q3
2 N3904
Q4
2 N3904
D6
1 N4148
C3 0
330uF/16V
D1 312V/1 W
L2 3.3uH/3A
R2 0 4.7M
t RV
10D
471K
1 2
D1 2MBR1045
AD
J1
IN3 OUT 2
IC5
LM317
C2 4
4.7uF/25V
D2 11 N4001
D2 21 N4001
D2 01 N4001
1234
CN907
C5 4
103/250VAC
1 2 3
4 5 6
T9011 2
3 4
RL00 1
R3 41 R3 5
1
1234
RB907
R3 010K
Q5C945
ZD1 45.6V
R3 110K
Q6 C945
D2 3
1 N4001
R3 210K R3 3
1 0
C5 110uF/25V
C5 2
4.7uF/25VC5 3
220uF/25V
C5 0220uF/25V
1234567891 01 11 2
CONA
CON1 2
GNDDTSR5V(100mA)
GNDDTSR5V(100mA)
max 13.5v
7.6--8.6v
JLudwigs
Source unit Power supply SCH
1 2 3 4
A
B
C
D
4321
D
C
B
A
C00
322
3
C10
810
4
C111
30
C105223
C110200
D00
11N
4148
G
SD
Q001SK192
TC001(22P)
AN
T1
NC
2
AG
C3
GN
D4
VT
5
B+
6
IF/O
7
OSC
8
EF001
C001
33P
4
5
1
2 3 T003 SHV2020-001
4
5
1
2 3
T002 AHV0491-101
VD001SV1498
CF10110.7M
VC
O15
FM
DE
C9
AM
SD
12
FMIF
1
AM
MIX
2
FMIF
B3
AM
IF4
GN
D5
TU
LE
D6
ST L
ED
7
VC
C8
EN
DE
C23
NP
XIN
22
MP
XL
21
MP
XR
20
LIN
19
RIN
18
LO
UT
17
RO
UT
16
MU
TE
IF13
AM
/FM
14
FM S
D11
AM
CF
10
AM
DE
C24
AM
AG
C25
AFC
26
AM
RF
27
RE
G28
OSC
29
AM
OSC
30
IC101
LA1837
D00
21N
4148
D00
31N
4148
D00
41N
4148
R00
16.
8KR
002
100K
C0055P
C006104
Q1012SC1675
Q1022SC1675
R103330
R104330
R106 270K
R105100
R10247
R107
10
CF10210.7M
2
4
1
3
5
T101 TSHV1492-003
R113NC
TC002(22P)
VD002SV149
C0138P
C014
561
L10
339
mH
C106
33UF
C12510UF
C109 10UF
C10
722
UF
C10433UF
R11
53.
3K
R11
61K
2
4
1
3
5
T103 TSHV1492-004
2
4
1
3
5
T104 TSHV1492-004
C12610UF
C131472
C129222
C13
515
2
C13
615
2
C133223
C132472
C130
222
C134223
C138
M153
R1304.7K
C137
M153
R1294.7K
C142222
R1342.2K
C141222
R1332.2K
C12
40.
47U
F
C12
31U
F
C139
4.7UF
C140
4.7UF
C127
1UF
C11
81U
F
R12
43K
VR1023.9K
C11
547
3
C11
447
3R
119
51
R11
847
L10
410
uH
C11
747
UF
C11
622
3
CF103450KHz
C11347UF
C112473
4
5
1
2 3 T102
SHI9724-058
R117180K
XIN
1
CE
2
DI
3
CL
4
DO
5
BO
16
BO
27
BO
38
BO
49
IO1
10IF
IN11
IO2
12A
MIN
13FM
IN14
VD
D15
PD
16A
IN17
AO
UT
18V
SS19
XO
UT
20
IC152LC72131M
C1663.3UF
XL
152
4.5M
C17427P
C173 27P
R15
83.
3KR
157
1K
R15
63.
3K
C16347UF
C164223
R1551K C171
47UC170223
R1594.7K
L153 10uH
R00
41K
C161104
Q105C945
R16
34.
7K
R003100K
R101270K
C010223
C101223
Q104C945
R00
91K
Q103A733
R108
10K
R00
810
0 R114330
C167223
R109100K
L10
2 10u
H
C009223
R006100
R005330
C01247UF
C011
223
R007 100K
C168101
R1251K
R1234.7K
R122
3.9K
R126
47K
R138100
C122223
C12022P
R11
0
47
C119
152
C15
333
1
R1326.8K
R1316.8K
R16
54.
7KR
161
4.7K
R16
24.
7KR
160
4.7K
12
T105
R13
72.
7K
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
RB101CON15
4
5 1
2
3T001
CON3JK001ANT
R168 22KR167 22K
R1123.3K
C121NC C145
223
SD
RDS-DATA
TU
-CE
TU
-DI
TU
-CL
YU
-DO
TU-R
TU-L
TU+12VTU+5V
C144223
C14
3
47U
F
L154 10uH
D101 1N4148
C169223
C008222
C165102
C01
610
4
C007 104
R15
41M
C15
110
UF
C15
256
1
C15647U
XL
151
4.33
2M
C155
22P
C154
22P
L15210UH
C15747U
VR
EF
1
NP
XIN
2
VD
DA
3
VSS
A4
FL
O5
CIN
6
T17
T28
T39
T410
T511
XO
UT
12X
IN13
VD
D14
VSS
15T6
16T7
17S
YN
C1819
D0
20C
L21
DI
22C
E23
SY
R24
IC15
1L
C72
720
R1534.7K
R15
24.
7K
L151 10UH
SYR
R15
11M
R13547K
R136
47K
C015
223
R13
9
220
JLudwigs
Source unit Tuner SCH
1 2 3 4 5 6
A
B
C
D
654321
D
C
B
A
Title
Number RevisionSize
B
Date: 23-Oct-2002 Sheet of File: E:\CJH\DSC500\DSC500\Dsc500e.ddbDrawn By:
R1 4.7K
R2 4.7K
KI21
KI32
KI43
KI54
KI65
KI76
REM7
Vdd8
SEL9
OSCO10
OSCI11
Vss12
LMP13
KI/O7 14KI/O6
15KI/O516KI/O417
KI/O3 18KI/O2 19KI/O1
20KI/O021
CCS 22KI0 23KI1
24IC1
PT2222
K17
K18
K19
K20
K21
K22
K23
K24
K25
K26
K27
K28
K29
K30
K31
K32
K33
K34
K35
K36
K37
K38
K39
K40
K41
K42
K43
K44
K45
K46
K47
K48
K49
K50
K51
K52
K53
K54
K9
K10
K11
K12
K13
K14
K15
K16
K1
K2
K3
K4
K5
K6
K7
K8
VCC
X1 455
C1200PF
C2
200PF
VCC
+ C34.7uF b
ec
Q1C945
R3
1E
12
D31N4148
1 2
D1
LED
12
D41N4148
12
D51N4148
JLudwigs
Source unit Remote control SCH
1 2 3 4 5 6 7 8 9 10 11 12
A
B
C
D
121110987654321
D
C
B
A
+3
-2 o 1v+
4v-
11
IC1ATL074
+5
-6 o 7
IC1BTL074
+10
-9 o 8
IC1C
TL074
+12
-13 o 14
IC1DTL074
R10310K
R100
10K
R10127K
R1025.6K
C103220p
C102O ohm
C101
1/50
R1056K8
R10412K
R106
JP
JP
JP
R110
N/C
R108N/C
R109
N/C
C106N/C
C107
N/C
C109
N/C
C108N/C
C110
222p
C111
222p
R111
150k
R112150k
R1141K2
R113
3K9C100100p
C104
0.1
C105
0.1
+3
-2 o 1
v+4
v-11
IC2ATL074
+10
-9 o 8
IC2C
TL074
+3
-2 o 1
v+4
v-11
IC3ATL074
+12
-13 o 14
IC3DTL074
R203 10K
R200
10K
R20127K
R2025.6K
C203220p
C202
O ohm
C201
1/50
R205
6K8
R20412K
R206
JP
R207
JP
R210
N/C
R208N/C
R209
N/C
C206
N/C
C207
N/C
C209
N/C
C208N/C
C210
222p
C211
222p
R211
150k
R212150k
R214750 ohm
R213
3K9C200100p
C204
0.1
C205
0.1
+5
-6 o 7
IC2BTL074
+12
-13 o 14
IC2DTL074
+5
-6 o 7
IC3BTL074
+10
-9 o 8
IC3CTL074
R303
10K
R300
10K
R30127K
R3025.6K
C303220p
C302O ohm
C301
1/50
R305
6K8
R30412K
R306
JP
R307
JP
R310
N/C
R308N/C
R309
N/C
C306
N/C
C307
N/C
C309
N/C
C308N/C
C310
222p
C311
222p
R311
150k
R312150k
R3141K2
R313
3K9C300100p
C304
0.1
C305
0.1
+3
-2 o 1
v+4
v-11
IC4ATL074
+10
-9 o 8
IC4C
TL074
+3
-2 o 1
v+4
v-11
IC5ATL074
+10
-9 o 8
IC5CTL074
R403
10K
R400
10K
R40127K
R4025.6.K
C403220p
C402O ohm
C401
1/50
R405
6K8
R40412K
R406
JP
R407
JP
R410
N/C
R408N/C
R409
N/C
C406
N/C
C407
N/C
C409
N/C
C408N/C
C410
222p
C411
222p
R411
150k
R412150k
R4141K2
R413
3K9C400100p
C404
0.1
C405
0.1
+5
-6 o 7
IC4BTL074
+12
-13 o 14
IC4D
TL074
+5
-6 o 7
IC5BTL074
+12
-13 o 14
5DTL074
R503
15K
R500
10K
R50127K
R5025.6K
C503220p
C502O ohm
C501
1/50
R505
6K8
R50412K
R506
JP
R507
JP
R510
N/C
R508N/C
R509
N/C
C506
N/C
C507
N/C
C509
N/C
C508N/C
C510
222p
C511
222p
R511
150k
R512150k
R5141K2
R513
3K9C500100p
C504
0.1
C505
0.1
+3
-2
o 1
v+4
v-11
IC6ATL074 +5
-6 o 7
IC6BTL074
+10
-9
o 8
IC6CTL074
+12
-13
o 14
IC6D
TL074
R602
30K
R600
10K
R60127K
R607
1KC602
.018
C603
.018
R603
22K
R604
22K
R605
8K2C604
.03
R60668K
C605.1
C606
.1
R608
10K
R609220K
R610
22KR611
36K
C608.022
C607
.068R612
3K9
R6134K7
C601
47/25
C600100p
123456
JP13
4999A
1234567
J14
XH-7
+ 3
- 2o1
v+8
v-4
IC7A
TL072
+5
-6 0 7
IC7B
TL072B
RA08
1M
RA09
10K
RA06
10K
RA07
56K
CA03
10/16
DA02
1N914B
DA011N914B
CA044.7/25
RA10470K
RA1110K
QA022SC945
QA012SC945
RA04
22K
RA031K
RA1210K
RA021K
CA02
10/16
RA05
2K2
RA01
3K9
C609
2.2/50
R13
100
R14
100
V+
C13100/25
C14100/25
V+
V-
R11
100
+15V
R12
100
-15V
C11100/25
C12100/25
C27.1
C28.1
V+
V-
+15V
-15V
C25.1
C26.1
R9
100
R10
100
C9100/25
C10100/25
V+
V-
+15V
-15V
C23.1
C24.1
R7
100
R8
100
C7100/25
C8100/25
V+
V-
+15V
-15V
C21.1
C22.1
R5
100
R6
100
C5100/25
C6100/25
V+
V-
+15V
-15V
C19.1
C20.1
R3
100
R4
100
C3100/25
C4100/25
V+
V-
+15V
-15V
C17.1
C18.1
R1
100
R2
100
C1100/25
C2100/25
V+
V-
+15V
-15V
C15.1
C16.1
123
J15
XH-3
+15V
-15V
ESC380E EQ BOARD
A
C112
1/50
C212
1/50
C3121/50
C4121/50
C5121/50
C61047p
CA051000pF
+3
-21
8
IC101ATL072
-6
+57
4
IC101BTL072
R124
10k
R127
10k
R12610k
R12510k
R128
10k
R12910k
+3
-21
8
IC201ATL072
-6
+57
4
IC201BTL072
R224
10k
R227
10k
R22610k
R22510k
R228
10k
R22910k
+3
-21
8
IC301ATL072
-6
+57
4
IC301BTL072
R324
10k
R327
10k
R32610k
R32510k
R328
10k
R32910k
+3
-21
8
IC401ATL072
-6
+57
4
IC401BTL072
R424
10k
R427
10k
R42610k
R42510k
R428
10k
R42910k
+3
-21
8
IC501ATL072
-6
+57
4
IC501BTL072
R524
10k
R527
10k
R52610k
R52510k
R528
10k
R52910k
+3
-21
8
IC601ATL072
-6
+57
4
IC601BTL072
R624
10k
R627
10k
R62610k
R62510k
R628
10k
R62910k
R120
6k8
R121
6K8
C120220p
R122
6K8
R123
6K8
R (- In )
R (+ In )
R220
6k8
R221
6k8
C220220p
R222
6k8
R223
6k8
C (- In )
C (+ In )
R320
6k8
R321
6k8
C320220p
R322
6k8
R323
6k8
L (- In )
L (+ In )
R420
6k8
R421
6k8
C420220p
R422
6K8
R423
6k8
SR (- In )
SR (+ In )
R520
6k8
R521
6k8
C520220p
R522
6k8
R523
6k8
SL (- In )
SL (+ In )
R620
6k8
R621
6k8
C?220p
R622
6k8
R623
6k8
SW (- In )
SW (+ In )
F1
4A/250V
F2
4A/250V
F3
8A/250V
F4
8A/250V
F5
1A/250V
F6
1A/250V
123
J95
CON3
123456
J6
3962-6
T1
OPT
K1
JQ-1a
1
2
3
4
D1RHD0402-001
1
2
3
4
D2RHD0010-001
1
2
3
4
D3BRIDGE1
C133300/50
C143300/50
C154700/50
C164700/50
C172200/35
C182200/35
123456
J97
3962-6
C190.22uF
C200.1uF
C212.2uF
C221uF
IN2 OUT 3U2
7915
IN1 OUT 3U1
7815
1 2 3
J93XH-3
12
J94XH-2
R1
10K
12
J92
CON2
12
J91
CON2
C1.1
C2.1 C4
.1
C3
.1
C7
.1
C8
.1
C5.1
C6.1
C9.1
C10.1 C12
.1
C11
.1
123
JP995003
12
J25
CON2
R3
1K5
1234
J98
3962-4
D4
IN4148
R247
C25
0.1
C260.1
CX10.01
VDE PLUG 230V 50Hz
!
!Fuse
4A 250V Type-T12
JP
CON2
!
!
!
NC
11V
IN+
10V
IN-
9M
UTE
8G
ND
7N
C6
V+
5V
-4
O/P
3N
C2
V+
1
U1LM3886
R152 1K
R1541K
R153 20K
L1 0.7uH
+VCC1
-VCC1
C1510.1uF
R1554.7
C153560p
R15110K
NC
11V
IN+
10V
IN-
9M
UTE
8G
ND
7N
C6
V+
5V
-4
O/P
3N
C2
V+
1
U2LM3886
R252 1K
R2541K
R253 20K
L3 0.7uH
+VCC1-VCC1
C2510.1uF
R2554.7
C253560p
R25110K
NC
11V
IN+
10V
IN-
9M
UTE
8G
ND
7N
C6
V+
5V
-4
O/P
3N
C2
V+
1
U4LM3886
R552 1K
R5541K
R553 20K
L2 0.7uH
+VCC1
-VCC1
C5510.1uF
R5554.7
C553560pR551
10K
+3
-2
o 1
v+8
v-4
IC8ATL072
+5
-6
0 7
IC8
TL072B
R33
100KR32270K
Q42SC2001
Q3
2SA733
R342K2
R30270K
D4
1N4148
C310.1uF
R31
5K6
12
JP1
4999A
12
JP4
4999A
12
JP2
4999A
+15V
-15V
Mute
123456
J213962-6
+Vcc1
-Vcc1
Amp1
A
12
JP7
50032
C192.1
C193.1
C592.1
C593.1
C292.1
C293.1
C190100/50
C590100/50
C290100/50
C191100/50
C591100/50
C291100/50
C15222uF
C55222uF
C25222uF
C3222/35uF
12
JP8
50032
1234
J20
3962-4
Q52SC2878
R35
22K
MUTE
Q62SC2878
R36
470K
NC
11V
IN+
10V
IN-
9M
UTE
8G
ND
7N
C6
V+
5V
-4
O/P
3N
C2
V+
1
U6LM3886
R652 1K
R6541K
R65320K
L1 0.7uH
C6510.1uF
R6554.7
C653560pR651
10K
NC
11V
IN+
10V
IN-
9M
UTE
8G
ND
7N
C6
V+
5V
-4
O/P
3N
C2
V+
1
U4LM3886
R452 1K
R4541K
R453 20K
L3 0.7uH
+VCC1-VCC1
C4510.1uF
R4554.7
C453560pR451
10K
NC
11V
IN+
10V
IN-
9M
UTE
8G
ND
7N
C6
V+
5V
-4
O/P
3N
C2
V+
1
U3LM3886
R352 1K
R3541K
R353 20K
L2 0.7uH
+VCC1
-VCC1
C3510.1uF
R3554.7
C353560pR351
10K
12
JP3
4999A
12
JP4
4999A
12
J7
3962-2
+Vcc2-Vcc2
1234
J23
3962-4
123456
J22
3962-6
+Vcc1
-Vcc1+Vcc2
-Vcc2
Mute12
J10
XH-2
C692.1
C693.1
C392.1
C393.1
C492.1
C493.1
C690100/50
C691100/50
C390100/50
C391100/50
C490100/50
C491100/50
C65222uF
C35222uF
C45222uF
123
JP6
4999A
1 2 3 4 5 6 7 8 9 10
JK501HEADER CON
1 2 3 4
JP233962
1 2 3 4 5 6
JP213962
C518102
C519102
C520102
C521102
C522102
L501 10uH
L503 10uH
L502 10uHL504 10uH
L505 10uH
123
JP12
XH-3
+6VAGND
InMute
C1210.1
C1220.1
C2210.1
C2220.1
C3210.1
C3220.1
C4210.1
C4220.1
C5210.1
C5220.1
C6210.1
C6220.1
192103114125136147158
CON1
CON401B
12345678910111213
CON2
XH-12
PIN9PIN4PIN7PIN2PIN5PIN11PIN3PIN12PIN1
MUTE
PIN10
+6V
PIN8
GND
PIN6
123
JP12
CON3
SR+SR-R-SL-R+SL+L-SW-L+SW+C-C+
123456789101112
CON2
XH-12
SR+SR-R-SL-R+SL+L-SW-L+SW+C-C+
R13
100
R14
100
C13100/25
C14100/25
V+
V-
+15V
-15V
C27.1
C28.1
C27.1
R13100
C28
.1
JBL DSC500 SUBWOOFER
JLudwigs
DSC500 Subwoofer Schematic
