Dorman Products - Engineered · 2017-04-24 · Tailgate Lock Actuator Motors Electric motor that...

Spring 2017 Service Dealer Guide

Volume. 1

www.NAPACanada.com

Transfer Case Shift Motor

Steering Column Lock Actuator

Engine Cylinder Deactivation Solenoid

Diesel Emissions Fluid Pump

NOx Sensor

EGR Cooler Kits

ENGINEERED SOLUTIONS DESIGNED TO CORRECT KNOWN OE FAILURE MODES

Engineered

http://www.napacanada.com/

2

Failed

Pin

Extended

Alignment Pin

OE PROBLEM:

Original actuator fork typically fails due to

broken alignment pin and excessive wear

on contact pads

Completely redesigned actuator fork, with an extended

alignment pin and contact pads, help prevent wear

When you see this

You Know It’s FIXED

Part Shown:4WD Actuator Fork

OES 600-2017-1: Ascender, Bravada, Rainier, Trailblazer, Envoy, 9-7x 2002-2009

Tech Support Available: 1-800-868-5777

Engineered

Engineered solutions designed to correct known OE failure modes

Engineered

BODY

32017 SERVICE DEALER GUIDE • VOLUME 1

Engineered

Center Console LatchesSecures console lid in closed positionOES 730-0232-1: Ford F-150 2003

OVER 10 SKUS AVAILABLE

Air Bag ClockspringsRelays power to steering wheel functions and air bag*OES 685-2031-1: Buick 2004-2005, Chevrolet 2002-2005, GMC 2002-2005, Oldsmobile 2002-2004


Console Lid KitsReplacement lid for a center console assembly*OES 730-6376: Buick 2006-2007, Chevrolet 2006-2009,

GMC 2006-2009

• Complete Kit - Includes all necessary hardware for a complete repair (where applicable)

• Reduce Repair Cost - Replace just the broken lid, instead of the entire console assembly


CHECK ENGINE BATTERY ALERT OIL PRESSURE TPMS LIGHT ABS LIGHT BRAKE SYSTEM AIRBAG FAULT LAMP OUT LED Diod Windsheild Washer Light

• Restores airbag system to its original performance• Secure direct-fit connectors are pre-attached; no wire

splicing necessary

Failure Mode:• Over time and regular use, wire ribbons become frayed

OE PROBLEM:The Dealer’s only repair option is the complete replacement of the entire console assembly Design makes it possible to replace the failed latch,

saving time, money and labor

Cruise Control SwitchesSteering wheel mounted cruise control switch assembly*OES 730-7562-1: Ford 1998-2004, Mercury 1998-2001

• Controls various functions of the cruise control system• Replacement switch matches the original in look and design

Other Colors Available

*See ProLink or PartsPro SE for complete application details

BODY

4

Door Jamb SwitchesActivates cab lights when the vehicle door is openedOES 730-7579-1: Kia Forte 2010-2013, Forte Koup 2010-2013, Forte 5 2012-2013

Door Latch AssembliesControls the vehicle’s locks and holds the door shut while drivingOES 644-4106-1: GM Trucks: Express / Savana Van 1998-2016; Escalade, Suburban, Tahoe, Yukon 1998-1999


• Quality tested to ensure trouble-free installation, durability and a longer service life

Failure Mode:• Internal electrical or mechanical failure, resulting in door

jamb switch failing to activate interior lights when car door is opened

• Plug-and-play, no wire spicing necessary like found on some other alternatives

• Direct Fit

Failure Mode:• Mechanical components wear, crack or become frozen into

position from corrosion, resulting in vehicle doors not able to open, close or lock properly

Visit NAPACanada.com

to view our entire collection of Tech Trays

NAPA SOLUTIONS ASSORTMENT TRAYS

Over 15 Time Saving Tech Trays Available

Install Videos at YouTube.com/NAPASolutions


BODY


Door Lock Actuator MotorsElectric motor located inside door latch used to control lock and unlock functions*OES 655-8085-1: Chrysler 2008-2010, Dodge 2008-2012, Jeep 2011-2015, Ram 2011-2015


OES 644-0902-1:Chrysler, Dodge, Jeep: 2011-2015

Cherokee, Journey, 200, 300



• NAPA Solutions has the superior coverage needed to stay ahead of replacement demand• Leading coverage for today’s most in-demand domestic and import vehicles

HIGH GROWTH POTENTIALAs integrated door lock actuators become increasingly common in today’s new vehicles, NAPA Solutions helps keep you ahead of replacement demand through the continuous introduction of new applications.

FOR ADDITIONAL INFORMATION PLEASE VISIT US AT:WWW.NAPACANADA.COM

NAPA SOLUTIONS ASSORTMENT TRAYS

Also Available

OES 655-6845-1:Toyota Highlander 2001-2007

OES 644-0900-1:Chrysler, Dodge, Jeep: 2011-2017 Cherokee, Dart, Journey, 200, 300



DOOR LOCK ACTUATOR PROGRAM



BODY

6

Fuel Filler Door SwitchesRemotely operates fuel door lock mechanismOES 730-7641-1: Kia Sorento 2011-2014, 2009

Hood Latch AssembliesKeeps the vehicle’s hood closedOES 876-0200-1: GM Trucks: Silverado, Sierra, Suburban, Tahoe, Yukon, Escalade 2007-2014; Impala 2006-2016

Liftgate Lock ActuatorsElectric motor that opens, locks and unlocks the vehicle liftgateOES 655-6262-1: Chrysler, Dodge Journey & Minivan 2008-2010; Jeep Liberty 2009-2010


• Built with upgraded electrical motor• Direct-fit replacement for a proper fit every time

Failure Mode:• Original electrical motor wears out over time resulting in

inoperable liftgate

• Restores the ability to release the fuel door Failure Mode:• Internal electrical or mechanical failure, resulting in fuel

door not opening

Also AvailableOES 730-7622-1:

Volkswagen Beetle 1998-2010

• Design consolidates two OE SKUs into one unique NAPA Solutions part!

• Durable steel construction features protective coating for added corrosion resistance

Failure Mode:• Original latch will wear or corrode resulting in latch

becoming inoperable

Also Available OES 876-0201-1:

GM Trucks: Silverado/Sierra 1999-2002; Suburban, Tahoe,

Yukon, Escalade 2000-2006

Think It’s Dealer Only? Check NAPA Solutions First!

Located in trunk of vehicle


BODY


Liftgate Pull HandleHandle to close liftgateOES 926-0810-1: Dodge Durango 2011-2015, Jeep Cherokee 2014-2015


Power Steering ReservoirsProvides power steering fluid to the pumpOES 605-3657-1: Audi TT 1997-2006; Volkswagen Jetta, Golf 1999-2010

• Built with upgraded plastic construction to withstand the effects of heat & vibration generated within the engine compartment• Includes reservoir cap and level sensor (where applicable)


Radiator Mount BracketsMounts radiator to vehicle frameOES 523-0057-1: GM full size pickups & SUVs 1999-2007


GM full size pickups & SUVs 1999-2007

• Built with higher quality material to stand up to everday use and general wear and tear

• Application-specific, matching overall aesthetic design of the original handle

Failure Mode:• Cracked plastic or loose original liftgate handle, resulting in

handle no longer able to aid in opening the liftgate

• In-demand replacement due to rust prone original part• Includes all hardware necessary for a complete repair

Failure Mode:• Rust and corrosion results in clunking noise from

mounting area

NAPA SOLUTIONS 2017 GROWTH CATEGORY

Located under hood


BODY

8

Engineered

Sun VisorsBlocks harsh rays of the sun, protecting driver’s eyes from glareOES 744-4438-1: Honda Civic 2006-2008

Sun Visor Repair KitsRepairs a sagging or drooping sun visorOES 730-6511-1: Jeep Wrangler 1998-2002


Spare Tire HoistsHolds spare tire in place underneath the vehicleOES 730-6583-1: Dodge Ram 2500/3500 2006-2010,

Ram 2500/3500 2011-2012

• Coated finish to prevent rust and corrosion• Includes mounting hardware for a complete repair

(where applicable)


Steering Column Shift MechanismEnables driver to shift smoothly in and out of desired gear*OES 600-3518: Cadillac 1999-2000, Chevrolet 1995-2009,

GMC 1995-2009, Isuzu 2005-2008, Oldsmobile 1996-1997

Failure Mode:• Wear and fatigue from normal use results in the inability to

shift into gears properly

• Designed to match the original, maintaining your vehicle’s overall interior look

• Mounting hardware included for a complete repair (where applicable)

Failure Mode:• Original hinges wear out or crack, resulting in sagging or

damaged sun visor, improperly aligned against vehicle headliner

OE PROBLEM:A worn bracket leads to failure, however OE only offers replacement of entire assembly Engineered with all new components, upgraded to

stronger aluminium parts




Honda Civic 2009-2011

BODY


Trunk Lock Actuator MotorsControls the remote locking and unlocking of the vehicle trunkOES 655-6404-1: Volkswagen Passat 2001-2005, Volkswagen Phaeton 2004-2006, Volkswagen Touareg 2004-2010


Tailgate Lock Actuator MotorsElectric motor that remotely opens, locks and unlocks vehicle tailgatesOES 655-6263-1: Dodge Caliber 2007-2012, Jeep Compass 2007-2015, Jeep Grand Cherokee 2005-2006


Truck Cab Mount KitsBracket used to mount the trucks cab body to the vehicle frameOES 730-6277-1: Ford Ranger 1986-1997


Chrysler, Dodge Town and Country 2008-2010

Also Available OES 730-6280:

Ford Ranger 1990-1997

• Internal components are upgraded with thicker materials (whenever possible)

Failure Mode:• Original electric motor wears out, resulting in lock

becoming inoperable

• Includes all necessary components for a complete repair• Replacement bracket eliminates vibration and helps protect

against potential damage to truck cab

Failure Mode:• Original mounts fail over time due to cracks and corrosion,

leading to loose truck body on vehicle frame

• Internal components are upgraded with thicker materials (whenever possible)

• Integrated with a high-quality electric motor

Failure Mode:• Inability to remotely lock and unlock vehicle trunk

Located in trunk of vehicle


BODY

10

OES 605-3661-1:Volkswagen Golf 1999-2001

OES 605-3534-1:Mazda 6 2005-2008

OES 605-0155-1:Dodge Ram Pickup

2006-2010

OES 605-3646-1:Ford Freestyle 2005-2007

OES 605-3645-1:Chrysler 200 2011-2014,

Sebring 2007, Dodge Avenger 2010-2014

OES 605-3647-1:Chrysler Town & Country 2008-2010,

Chrysler Voyager 2008, Dodge Grand Caravan 2008-2010

Washer Fluid ReservoirsProvides fluid to the windshield washer systemOES 605-3531-1: Chrysler 300 2008-2010, Dodge Challenger 2008-2010, Charger 2008-2010, Magnum 2005-2008

Over 100 Washer Fluid SKUs Available

OES 605-3532-1:Chrysler PT Cruiser 2001-2010

OES 605-3658-1:Audi A3 2006-2010,

Volkswagen Eos 2007-2010, Jetta 2005-2007, Rabbit 2006-2009

• Built with thicker, more durable plastic to withstand the expansion and cracking from severe temperature fluctuations

• Reduce repair time, all windshield reservoirs include: • Reservoir cap, level sensor and pump (where applicable) • Mounting bracket (where applicable)

Failure Mode:• Collision damage, road debris that can puncture the bottle,

or cracked or missing cap results in leaking washer fluid

OES 605-3643-1:Nissan Altima 2007-2013,

Maxima 2008-2013

OES 605-3618-1:Chevrolet Malibu 2004-2008

OES 605-3533-1:Honda Fit 2007-2008

OES 605-0160-1:Toyota Sienna 2004-2015

WASHER FLUID PROGRAM

Install Videos at YouTube.com/NAPA Solutions


BODY


Windshield Wiper LinkagesProvides mechanical connection between the wiper motor and wiper bladesOES 819-9009-1: Saab 9-3 2005-2011


OES 819-9000-1:Jeep Wrangler 2007-2015

OES 819-9001-1Jeep Compass 2007-2015

OES 819-2168:Honda CR-V 2002-2006

OES 819-9051-1:Ford Escape 2007-2012,

Mercury Mariner 2007-2011

OES 819-2130:Toyota Avalon 2000-2005

Windshield Wiper ArmsConnects the wiper transmission to windshield wiper bladeOES 819-0096: Chrysler Aspen 2007-2009, Dodge Durango 2004-2009


• Designed with upgraded spring to maintain better wiper blade contact with windshield to avoid streaking (where applicable)

Failure Mode:• The original wiper arm fails due to damage incurred during

automated car washes and snow and ice removal


Chrysler Aspen 2007-2009, Dodge Durango 2004-2009

• Built with upgraded bushing material for a longer service life• Easy to install, direct-fit replacement

Also Available

OES 819-9002-1Jeep Patriot 2007-2015

Failure Mode:• Original plastic bushing fails over time resulting in

inoperable wiper blades

Located behind the cowl


BRAKE

12

Brake Dust ShieldsProtects vehicle wheel from brake dust build up, keeping the braking system clean*OES 610-3057-1: Chevrolet 2006-2010, GMC 2006-2010


Brake Light SwitchIlluminates vehicle brake lights when the brake pedal is pressedOES 730-7408-1: GM T500, T6500, T7500, T8500 Truck 1997-2009; Isuzu Truck FSR, FTR, FVR 1997-2009

• Designed for long-lasting durability against harsh road and weather conditions• Direct-fit replacement for OE designs

Brake Master Cylinder ReservoirsStores reserve hydraulic fluid for the braking system*OES 605-3660-1: Audi 1999-2006, Volkswagen 1998-2010

5 SKUS AVAILABLE


Audi A4, A6 2002-2005; Volkswagen Passat 1997-2001

• Reduce Repair Cost - replace the worn original brake reservoir, instead of the entire master cylinder assembly

• Includes reservoir cap

Failure Mode:• Cracking/fracturing due to extreme temperatures, road

debris, resulting in loss of brake fluid, reduced braking power or complete loss of braking

• Manufactured with a rust resistant coating for a longer service life and extra protection against debris and other contaminants

• Two part construction saves hub disassembly time

Failure Mode:• Visible rust and corrosion, resulting in rattling noise from

brake area of vehicle and excessive brake dust in engine bay



CHASSIS


Body MountsSecures frame or subframe to vehicle body and dampens road noise and vibration*OES 924-0041-1: Buick 2004-2007, Chevrolet 2002-2009, GMC 2002-2009, Oldsmobile 2002-2004

• All necessary bushings and hardware are included for a complete repair (where applicable)• Constructed of upgraded material to resist compression, cracking and separating


Jounce BumpersPrevents damage to the vehicle’s control arm, frame, shock mount and other suspension components*OES 523-0258-1: Dodge 2008-2010, Jeep 2007-2016, Ram 2011-2015


Shock MountsBracket used to mount the shock or strut to inside fender well*OES 600-3427: Chevrolet 1988-2000, GMC 1988-2000


• Constructed of upgraded material to resist compression, cracking and separating

• Mounting hardware included for a complete repair (where applicable)

• Built with upgraded bushings for long-lasting resistance to wear and tear

Failure Mode:• Rust, corrosion and deterioration resulting in unstable

suspension

• Made of polystyrene foam for long-lasting durability

Located behind the dust cover

Also Available *OES 730-6780:

Chevrolet, GMC 1988-2000


Chevrolet S10 1994-2004, GMC Sonoma 1994-2004


CHASSIS

14

*OES 7-1220:Cadillac, Chevrolet, GMC 2007-2013, Hummer 2008-2009

Steering Shaft Universal JointRestores proper steering function*OES 7-3066: Ford 1997-2012

Steering ShaftsRestores proper rotation to vehicle steering wheelOES 7-8517: Dodge Durango 2011-2014, Jeep Grand Cherokee 2011-2014

OES 7-8523:Chevrolet C3500 1988-2002, Chevrolet C3500HD 1991-2002,

GMC C3500 1988-2000, GMC C3500HD 1991-2002

OES 7-0159-1: GM Express & Savana Vans 1996-2002

OES 7-3072:Kia Sedona 2002-2006

• U-joints use precision engineered needle bearings for smooth operation

• Easy to install - no special tools needed

Failure Mode:• Loose steering and/or complete inability to steer

vehicle properly

• Pre-assembled, with high-quality bearings and forged end fittings for strength and durability

• Effectively eliminates clunking and binding

Failure Mode:• Failure results in a clunking sound, binding of steering shaft

and an inability to steer properly

Located behind driver side wheel behind cover

Over 50 Steering Shaft SKUs Available



CHASSIS


Suspension Shock / Strut Mount BushingUpper mounting point for the strut or shockOES 523-0220-1: Cadillac SRX 2004-2009

Suspension Knuckle BushingsBushing used as the mounting point between the knuckle and suspension arms or linkOES 523-0213-1: Ford Explorer 2006-2010, Ford Explorer Sport Trac 2007-2010, Mercury Mountaineer 2006-2010


Suspension Trailing Arm BushingsConnects trailing arm to vehicle frameOES 523-0246-1: Ford Fusion 2006-2012, Lincoln MKZ 2007-2012, Lincoln Zephyr 2006, Mercury Milan 2006-2011


• Reduce Repair Cost - replace the failed bushings, instead of the entire steering knuckle assembly

• This direct-replacement restores a smooth ride, directional stability and agile handling

Failure Mode:• Rubber deterioration over time resulting in clunking noise

from suspension area

• Reduced Repair Cost - Replace just the failed bushing instead of the entire control arm assembly, saving you time and money

Failure Mode:• The original bushing rubber deteriorates over time, resulting

in knocking and clunking noise from vehicle suspension

• Reduce Repair Cost - replace the worn bushing, instead of the entire trailing arm assembly, saving you time and money

Failure Mode:• The original bushing rubber deteriorates over time, resulting

in knocking and clunking noise from vehicle suspension


Cadillac CTS 2003-2007, Cadillac SRX 2004-2009


MEDIUM DUTY

A GROWING CATEGORY OFTOW TRUCKS LANDSCAPERS CABLE / TV SERVICE UTILITY COMPANIES MUNICIPALITIES REFUSE TRUCKS

16

Fuel Injector Control ModuleOES 600-5566: 6.0L V8 Engine 2004-2010

Coolant ReservoirOES 448-5104: 3000, 4000, 7000, 8000 Series; IC School Bus w/DT466 Engine 2006-2007

EGR ValveOES 600-9962-1: 1000, 3000, 4000, 7000 Series; IC School Bus w/DT466 & MaxxForce DT Engines 2007-2010

Coolant ReservoirOES 605-0141-1: M2 2012-2016

Radiator Grille*OES 424-5202:Freightliner 2000-2014

EGR CoolerOES 600-3693: 6.0L V8 Engine 2004-2010



FordOVER 550 SKUS

InternationalOVER 80 SKUS

FreightlinerOVER 35 SKUS

MEDIUM DUTY

TOW TRUCKS LANDSCAPERS CABLE / TV SERVICE UTILITY COMPANIES MUNICIPALITIES REFUSE TRUCKS

OVER 1,600 SKUS IDEAL FOR:


Coolant ReservoirOES 448-5751: 165, 185, 238, 258LP, 268, 338, Dutro, FD, 145, 258ALP, 268A, 338CT, 358, 308 2005-2010

Headlight AssemblyOES 800-5759 [R] & OES 800-5760 [L]:258ALP, 258LP, 268, 268A, 338, 338CT, 145, 165, 185 2006-2014

Transfer Case MotorOES 600-2291: C4500, C5500 Kodiak; RPO Code NP1 (Electronic Shift, 2 Speed Case); NP263 Case; w/3 Position Selector Switch 2005-2009

Throttle Body Position SensorOES 600-2614: NPR, NPR-HD w/ 6.0L V8 2003-2007

Engine Oil Dipstick TubeOES 819-2203: NPR, NPR-HD w/6.0L Gas Eng 2003

Roof Marker LightOES 735-5026: C4500, C5500, C6500, C7500, C8500 Kodiak 2005-2009


HinoOVER 55 SKUS

ChevroletOVER 700 SKUS

IsuzuOVER 240 SKUS

DIESEL

18

Diesel Emissions Fluid (DEF) ModuleSupplies fluid to the diesel exhaust pipeOES 599-0995-1: Ram 3500/ 4500/ 5500 2011-2012

• 100% new providing both high-quality materials with upgraded internal electronic components

• Upgraded internal electronic components withstand temperature swings caused by extreme heat and cold


Diesel Emissions Fluid (DEF) PumpSupplies fluid to the SCR module*OES 731-1035-1: Chevrolet 2010-2016, GMC 2010-2016

• Mounting hardware included for a complete repair• Plug and play design for an easy installation

EGR Cooler KitsCools recirculating exhaust gas*OES 600-9937-1: International 2004-2009



EGR TubesRoutes exhaust gases into the intake manifoldOES 600-7447-1: Ford Expedition 2003-2004, F-150 2002-2003, F-150 Heritage 2004

• Built with flex point to reduce the possibility of damage due to heat and vibration• Stainless steel construction protects against stress, fractures, corrosion and blockage from carbon build-up


Also Available*OES 600-9917-1:

International 2004-2009


Ford Explorer 1997-2001, Mercury Mountaineer 1997-2001

• 100% new, not remanufactured - no core charge• Material upgraded to stainless steel to prevent corrosion



DIESEL


NOx (Nitrogen Oxide) SensorDetects nitrogen oxide levels in the vehicle’s exhaust systemOES 731-7824-1: Ram 2500 2014-2016, 3500 2015-2016, 4500/ 5500 2016


• Anti-seize coating pre-applied to prevent damage to sensor from high engine temperatures

• Required to pass state emissions

Failure Mode:• Debris and contamination causes failure• Illumination of the check engine light and vehicle going into

limp mode


Ram 2500/ 3500/ 4500/ 5500 2013-2016

Fuel Line Disconnect ToolsUnlocks fuel fittings from fuel lineOES 904-0484-1: GM Trucks with diesel eng. 2011-2016

• Also comes packed in an assortment that contains both tools

Fuel Tank Sending UnitRestores proper fuel gauge readingsOES 223-9011: Mack GU7, GU8 2008-2011

• Gasket included for a complete repair• Direct-fit replacement for original equipment designs

LIVE TECH SUPPORT AVAILABLE!

Need help with a technical question?Connect online live or call our ASE certified technicians(toll-free).www.NAPASolutionsChat.com • 866.933.2911


http://www.napasolutionschat.com/

DRIVETRAIN

20

Auto Trans Oil CoolersCools transmission fluid to ensure consistent transmission operationOES 827-5668-1: Nissan Frontier 2005-2015, Nissan Pathfinder 2005-2007, Nissan Xterra 2005-2015


Auto Trans Oil Cooler Hose AssembliesTransfers fluid from engine to radiatorOES 827-5925-1: Dodge Ram 2500/3500 2006-2009


Also AvailableOES 827-5921-1: Chrysler Concorde/ Intrepid 1998-2004, Dodge Intrepid 1998-2004, Jeep Liberty 2005-2006

Differential Lock Sensor ConnectorSupplies voltage to the differential lock sensorOES 666-2050-1: Jeep Wrangler 2007-2016

Failure Mode:• Connector fails to supply voltage to lock sensor

Differential Lock SensorSignals driver of differential lock activationOES 666-2051-1: Jeep Wrangler 2007-2016

• Direct-fit replacement for OE designs

Failure Mode:• Lock sensor light fails to illuminate on instrument cluster

• Coated for high corrosion resistance and increased protection against the elements

• Durable aluminum construction for a long-lasting service life

Failure Mode:• Collision, road debris & corrosion results in cooler leaks &

transmission overheating

• Hose material upgraded to metal and rubber to resist corrosion (where applicable)

• Leak-resistant design helps prevent common problem of transmission fluid loss

Failure Mode:• Rubber deteriorates over time and metal tubes rust

or corrode leading to transmission fluid leaks



DRIVETRAIN


Drive Belt Idler Pulley Adjustment Bolt KitsMaintains belt tension*OES 917-0148-1: Lexus 1993-2007, Toyota 1995-2008

Differential Mount BushingsProvide cushion at the mounting point for the vehicle differential*OES 523-0071-1: Cadillac 2007-2016, Chevrolet 2007-

2016, GMC 2007-2016

• Includes necessary mounting hardware for a complete repair

• Replacement eliminates knocking and clunking noise from vehicle differential

Differential MountsMounts differential to vehicle suspensionOES 523-02061: Toyota RAV4 1996-2005

• Upgraded bushings for added durability and a longer service life

• Direct replacement ensures a proper fit every time


Drive Shaft Center Support BearingsServes as a mounting point on chassis for two or three piece driveshaftsOES 883-0050-1: Lexus NX200t 2015, Lexus NX300h 2015, Toyota RAV4 2006-2015


• Includes necessary components for a complete adjuster repair

• Very large Toyota VIO makes this an in-demand service item

Failure Mode:• Corrosion or threads seize on original idler bolt, resulting in

the inability to service engine belt

• Reduce Repair Cost - replace the failed original center support bearing, instead of the entire driveshaft assembly

• Mounting bracket included for a complete repair

Failure Mode:• Corrosion or rubber degrades around bearing, resulting in

squeaking or rattling of driveshaft


Subaru Forester 2002-2007, Impreza 2001-2007,

Legacy 2000-2009


DRIVETRAIN

22

Transfer Case MotorsEngages four wheel driveOES 666-2056-1: BMW X3 2004-2010, X5 2004-2006

• Direct-fit replacement for OE designs• Motor is sealed for corrosion-resistance


Also Available *OES 666-2057-1: BMW 2006-2010

OES 600-2705-1:Ford Explorer 2002-2005,

Mercury Mountaineer 2002-2005

*OES 600-2706-1:Buick 1997-2009, Cadillac 1999-2000,

Chevrolet 1995-2016, GMC 1995-2005, Oldsmobile 1996-2004, Pontiac 1997-2005

Shift Interlock SolenoidsKeeps vehicle from shifting out of park until the brake pedal is depressed *OES 600-2707-1: Cadillac 2002-2006, Chevrolet 1998-2016, GMC 1998-2016, Oldsmobile 1998-2001


*OES 600-2712-1:Chevrolet 2004-2007,

Pontiac 2005-2006

• Extremely high original failure rate makes this part in-demand for over 12 million GM vehicles on the road today

• Direct-fit replacement for original equipment designs

Failure Mode:• Original shifter fails to actuate due to internal short circuit,

resulting in the inability to shift vehicle out of park

Also Available

Failure Mode:• Water intrusion causes rust damage, resulting in inoperable

four-wheel drive (4WD) system



ELECTRONICS


Backup CameraCaptures image behind vehicle when in reverse, eliminating blind zones OES 731-1019-1 Chevrolet Cruze, Equinox, Orlando, 2013-2014, GMC Terrain 2010-2013

Electronic Throttle Body ModuleControls the throttle body by opening and closing the throttle plate through signals that are sent from the accelerator pedalOES 599-0959-1 Nissan Altima 2007-2010, Maxima 2009

• Completely remanufactured from higher-quality materials for increased durability and quality assurance

• Upgraded internal electronic components withstand fluctuating temperatures caused by extreme heat and cold

Door Window SwitchesDriver and passenger side switch to adjust vehicle power window*OES 730-7612-1 Chevrolet 2001-2002, GMC 2001-2002


• Designed to match the exact fit, form and function of the original switch

• Easy plug-and-play installation, no programming required

Failure Mode:• Electrical or mechanical failure of internal components,

resulting in the inability to operate power windows

High Intensity Discharge Control BallastsRegulates electrical voltage to the vehicle headlightsOES 731-8091-1 Lexus LS430 2004-2006,

Toyota Prius 2004-2005, Sienna 2004-2010

• Direct-fit wiring harness - no wire splicing necessary


Direct replacement eliminates the need to retrofit or wire


ALSO AVAILABLE*OES 731-8080-1

Chevrolet 2009, GMC 2009

• Upgraded camera lens provides a wider angle • Mounting bracket included to assist with installation

ELECTRONICS

24

Engineered

* Patent pending programming tool

UPGRADED GEAR MATERIAL

Parking Aid SensorsAlerts drivers to close-proximity objectsOES 731-7761-1: Volvo XC90 2007-2014

• Sensor is sealed to prevent moisture and debris from entering unit

• Comes with matching connectors and fully compatible electronics for a complete repair (where applicable)


HVAC Control ModulesControls a variety of climate control settingsOES 599-2040-1: Chrysler 200 2011-2014, Sebring 2010,

Dodge Avenger 2010-2014

• Ready to install, plug and play design requires no programming

• Fully remanufactured and tested, includes backlight replacement bulbs and O-rings (where applicable)


Original Unit


Steering Column Lock ActuatorReceives signal from ECU and smart remote to unlock vehicle steering wheelOES 731-1033-1: Nissan Altima 2007-2010, Maxima 2009

OE PROBLEM:Weak internal gears frequently cause original unit to fail, resulting in a ‘no start’ situation

Design uses stronger gears to eliminate the original failure mode


Transfer Case Control ModulesShifts vehicle in and out of 4WDOES 599-0252-1: Cadillac 2003-2005,

Chevrolet 2003-2005, GMC 2003-2005, Hummer 2003-2007

• Completely remanufactured and tested for quality assurance• Plug and play design for easy installation, no programming

required


Transmission Control ModulesRestores your vehicle’s ability to shift in and out of gearOES 609-0300-1: Ford Fiesta 2011-2014,

Ford Focus 2012-2014

• Completely remanufactured and vehicle simulator tested for durability and quality assurance

• Contains all new gaskets, grommets and seals


ENGINE


Engineered

Engine Cylinder Deactivation SolenoidAlso Known As Multiple Displacement Solenoid*OES 610-0151-1: Chrysler, Dodge, Jeep 2005-2009

• Made from upgraded materials for increased durability and a longer service life

• OE part is highly prone to failure

Engine Variable Timing SolenoidsActivates variable valve timing by controlling air flow and pressure*OES 600-3714: BMW 2006-2013, 2000-2001

• 100% Tested - All Engine Variable Timing Solenoids go through vehicle simulator testing for quality assurance

• Complete Kit - Includes all gaskets needed for a complete repair (where applicable)


Engine Variable Timing SprocketsAdjusts camshaft timing for optimal engine performance and efficiency*OES 600-5521: Ford 2004-2011, Lincoln 2005-2011, Mercury 2006-2010


*OES 600-3715:Buick 2010-2013, Chevrolet, Pontiac, Saturn 2006-2012, GMC

2010

*OES 599-9912-1:Buick 2009-2011, Buick 2006-2007,

Chevrolet 2006-2011, Pontiac 2006-2010, Saturn 2006-2009

VVT SOLUTIONS PROGRAM MARKET LEADING

COVERAGE

OE PROBLEM:The original sprocket wears leading to poor engine performance

New rotor design reduces friction and provides smoother engagement for a longer service life; and improves overall performance

Additional Camshaft Phasers Also Available


NAPA Solutions’ VVT program provides the aftermarket’s most comprehensive coverage for over 196 million installation opportunities.


IMPROVED ROTOR

STRONGER ALLOY PLATE

ENGINE

26

Engineered

Engineered

Engine Valve CoversProtects valve train components and seals oil flowOES 600-3769-1: Volkswagen Beetle, Golf, Jetta,

Passat 2005-2015 w/2.5L Eng.

• Built-in PCV diaphragm helps to prevent oil leaks and sludge build up on engine



Exhaust Manifold KitsChannels exhaust gas away from engine and through exhaust systemOES 601-3691-1: Dodge Durango 2011-2015,

Jeep Grand Cherokee 2011-2015

• Complete Kit - Includes all necessary gaskets and hardware


Engine Oil Filter Bypass ValveMaintains continuous flow of filtered oil in the vehicle engine*OES 719-0992-1: Chrysler, Dodge, Jeep 2011-2013, Ram 2012-2013

Exhaust Manifold to Cylinder Head Repair ClampsSeals leaking manifold*OES 601-0535-1: Ford Trucks 1988-1997 with 7.5L Eng.

OE PROBLEM:The only OE Dealer repair option offered is the complete replacement of the entire assembly

New replacement option for the failed valve, avoiding the need to replace the entire assembly - saving shop time and money


OE PROBLEM:Broken studs require time-consuming drilling and re-tapping to remove. In some cases, the entire cylinder head must be removed to extract broken studs

New exhaust manifold clamp eliminates the need to remove failed original studs by applying clamping pressure to eliminate exhaust leaks


FUEL & EMISSIONS


Engineered

Secondary Air Injection PumpsInjects fresh air into the exhaust system to reduce emissionsOES 776-5154-1: BMW X5 2001-2003


Fuel Pressure SensorsPart of the EVAP system that monitors fuel tank pressure levels*OES 600-5991-1: Ford 2000-2014, Lincoln 2007-2009, Mercury 2002-2010

Vacuum PumpsProvides vacuum source for brake booster*OES 776-0156-1: Audi 2012-2013,

Volkswagen 2006-2014



Secondary Air Injection Check ValvesPrevents exhaust backflow from damaging the air pumpOES 776-5262-1: Ford Fusion 2006-2009,

Mercury Milan 2006-2009

• Direct-fit replacement for original equipment designs• Necessary replacement for passing inspection

(in applicable states)





Vapor Canister Vent ValvesSeals the EVAP system during leak detection testsOES 776-5020-1: Hyundai Sonata 1999-2005, XG300 2001,

XG350 2002-2005; Kia Optima 2001-2006

• Replacement clears the OBD code and fixes refueling issues



OE PROBLEM:When original sensor fails, the Dealer only offers a complete replacement of both the hose and sensor assembly

Replacement sensor saves money by enabling the replacement of only the failed original part


HEATING & COOLING

28

AC Bypass PulleysReplaces seized air conditioning compressor to restore vehicle function without shortening beltOES 660-1972-1: Acura MDX 2001-2002,

Honda Odyssey 1999-2004, Pilot 2003-2004

• Mounting bracket included for a complete repair• Eliminates the need to install a completely new A/C

compressor


Engine Coolant ReservoirsProvides coolant to the engine*OES 605-3642-1: Chevrolet, GMC, 2003-2016

• Redesigned with a more durable plastic construction to withstand the effects of stress generated within the engine compartment

• Includes cap, drain tube and sensor (where applicable)


OES 605-3663-1:Volvo C30 2007-2013, C70 2006-2013,

S40 2004-2012, V50 2005-2011

OES 605-3654-1:Mercedes-Benz 300CE/ 300E/ 300TE 1993

OES 730-6689:BMW 525i, 530i 2001-2003, BMW 528i, 528it 1999-2000

Engine Coolant PipesTransfers coolant from the radiator to the engine blockOES 605-3274-1: Ford Thunderbird 2002-2005,

Lincoln LS 2000-2006

• Includes O-ring for a complete repair• Built with higher quality plastic to withstand harsh

underhood conditions


Failure Mode:• Collision damage and cracking results in loss of coolant and

overheating

Also Available

OES 605-3640-1:Dodge Ram 1500 2002-2003,

Ram 2500/ 3500 2003

OES 448-5127-1:Freightliner FLD 132/ 120/

120SD 2002-2004

OES 605-3529-1:Toyota RAV4 2006-2016

Install Videos at YouTube.com/NAPASolutions


HEATING & COOLING


Engineered

HVAC Heater Blend Door ActuatorsElectronic motor controlling the blend door that adjusts interior temperatures*OES 655-1745-1: Peterbilt 1994-2011

• Re-engineered with upgraded motor and internal material for improved durability and performance (where applicable)


HVAC Heater Hose AssembliesEnsures proper coolant circulationOES 827-5738-1: Dodge Journey 2009-2010

• Includes clamps and/or fittings for a complete repair (where applicable)• Reduce Repair Cost - Replace the failed hose, instead of the entire heater hose assembly, saving time, money and labor


HVAC Blower Motor SwitchControls the blower motor functionOES 731-8034-1: Peterbilt 384 2008-2015

• Reduce Repair Cost - replace just the failed original HVAC switch, instead of the entire HVAC control module

Power Steering CoolersCools the vehicle’s power steering system*OES 827-0031-1: Chevrolet 2003-2016, GMC 2003-2016

Also Available*OES 827-0030-1: Chevrolet,

GMC 1988-2002


OE PROBLEM:Original Y-connectors are made of plastic and frequently leak due to cracking Upgraded Y-connector material to aluminum for increased

durability and a longer service life

• Coated for extra protection against corrosion for increased durability and a longer service life

• Hoses and clamps included for a complete repair (where applicable)

Failure Mode:• Road debris damage, cracks in brazing, connector failure,

collision and rust damage which can result in power steering system overheating and external leaks


HYBRID

30

Engineered

Hybrid Battery PacksIncludes modules (such as ECU) - no need to reuse from the old batteryOES 200-1015-1: Toyota Prius C 2012-2014

• Completely remanufactured and tested• Each unit and individual cell is tested to confirm optimal battery pack performance


OES 200-1016-1 Lexus ES300h 2013,

Toyota Avalon 2013-2014, Camry 2012-2014

OES 200-1030-1 Lexus RX400h 2006-2007, Toyota Highlander 2006-2007

CHECK ENGINE BATTERY ALERT OIL PRESSURE TPMS LIGHT ABS LIGHT BRAKE SYSTEM AIRBAG FAULT LAMP OUT LED Diod Windsheild Washer LightCHECK ENGINE BATTERY ALERT OIL PRESSURE TPMS LIGHT ABS LIGHT BRAKE SYSTEM AIRBAG FAULT LAMP OUT LED Diod Windsheild Washer Light

OE PROBLEM:The original bus bars quickly corrode, leading to electrical failure Design uses plated bus bars to reduce corrosion

Also Available

Industry experts believe that by the year 2020, one in five vehicles sold worldwide will be powered by a hybrid powertrain

Did You Know?


HUNDREDS OF EXCLUSIVE NEW PARTS DELIVERED TO YOUR EMAIL EVERY MONTH!SIGN UP TODAY!

VISIT NAPASOLUTIONSEMAIL.COM

FREE NEW PRODUCT ALERTS!

ABOUT FORMERLY “DEALER ONLY” PARTSABOUT FORMERLY “DEALER ONLY” PARTS

www.DormanProducts.com/Signup

@

ABOUT FORMERLY “DEALER ONLY” PARTS

@

ABOUT FORMERLY “DEALER ONLY” PARTS

@@

@

ABOUT FORMERLY “DEALER ONLY” PARTSwww.DormanProducts.com/Signup

ABOUT FORMERLY “DEALER ONLY” PARTSwww.DormanProducts.com/Signup

@


http://www.dormanproducts.com/Signup

BODY


OES 600-1999-1Honda Civic 2002-2005

OES 600-1988-1Chrysler 300 2005-2008, Dodge Charger 2006-2008, Dodge Magnum 2005-2008

OES 600-1989-1Infiniti I30 2000, Nissan Maxima 2000

OES 600-1992-1Ford Edge 2011-2015,

Lincoln MKX 2011-2015

OES 600-1993-1Ford Edge 2011-2015,

Lincoln MKX 2011-2015

OES 600-1996-1Hyundai Elantra 2000-2006

OES 813-7603Chevrolet Impala 2000-2005,

Chevrolet Monte Carlo 2000-2005

OES 600-3108Dodge Ram 1500 2004-2008

*OES 600-3109BMW 1999-2006

*OES 600-3155Chrysler 1998-2004, Dodge 1998-2004

OES 600-3161Chrysler Town & Country 2004, Dodge

Caravan 2004, Dodge Grand Caravan 2004

Power Steering Return HosesTransfers power steering fluidOES 600-2131-1: Toyota Camry 2002-2006, Solara 2004-2008


OES 600-1998-1Toyota Camry 2007-2011

Also Available

• Bracket included for a complete repair • Zinc plated for long-lasting corrosion resistance (where applicable)

NAPA Solutions, Inc. | 3400 East Walnut Street | Colmar, PA 18915 • Corporate Office and Customer Service: 1-800-523-2492 • New Product Idea Hotline: 1-800-336-3575©2017 No reproduction in whole or in part without prior written approval.

NP-UAP-SDG2017v1

Think It’s Dealer Only? Check NAPA Solutions First! www.NAPACanada.com

• New Product Alerts

• Service Dealer Guide Alerts

• Special Events

JOIN NOW!GET ALERTS ON HUNDREDS OF NEW PRODUCTS RELEASED EACH MONTH!

Sign up or visit napasolutionsemail.com

• New Product Videos

• Training and Installation Videos

NEW VIDEOS ADDED EACH WEEK!

For instant access or visit YouTube.com/NAPASolutions

VIEW OUR VIDEOS!


Dorman Products - Engineered · 2017-04-24 · Tailgate Lock Actuator Motors Electric motor that...

Documents

Transcript of Dorman Products - Engineered · 2017-04-24 · Tailgate Lock Actuator Motors Electric motor that...