Distiller Questionnaire
-
Upload
rahul-choubey -
Category
Documents
-
view
212 -
download
0
Transcript of Distiller Questionnaire
8/12/2019 Distiller Questionnaire
http://slidepdf.com/reader/full/distiller-questionnaire 1/2
Questionnaire OnMulti Stage Flash Distiller
Name: -
Select the right answer.
1. What are the main consumers of sea water supply system?
a) SW spray to traveling screens
!) SW to "emin. an# $hlorination plantc) SW to %istillers
#) SW to %ump con#ensers
e) SW to &ower 'slan#.(. he parts of the plant not fe# !y SW as cooling me#ium are
a) *vaporator
!) +acuum systemc) $on#ensate system
,. SW recirculation pump remains in service #uringa) Winter season
!) Summer seasonc) SW temperature ($.
/. 0n increase in SW flow through reect section causes
a) oo low !rine temperature in the last stage !) 2igh con#uctivity of #istillate
c) %emisters cho3ing 4 #amage.
. he main factor to a#ust the re5uire# flow through heat reect section isa) 6ottom !rine temperature
!) SW inlet temperature
c) SW inlet pressure.7. he amount of water re-circulate# !y recirc.pump is controlle# !y
a) 8%&/900191
!) 8%&900991
c) 8%&900191. SW pressure at heat reect inlet is measure# !y loop &'0 8%&(9$&991 that gives
a) 'n#ication !oth in fiel# an# in %$S
!) 0larmc) "ecor#ing.
;. SW temperature at heat reect outlet is measure# !y loop '" 8%&/9$991that
gives
a) 'n#ication in %$S !) 0larm in %$S
c) "ecor#ing in %$S.
<. &ressure at heat reect outlet is measure# !y loop &' 8%&/9$&991tht gives a) 0larm in %$S
!) "ecor#ing an# in#ication in %$S.
19. &art of the SW coming from the heat reect outlet is sent toa) *vaporator stage ((
1
8/12/2019 Distiller Questionnaire
http://slidepdf.com/reader/full/distiller-questionnaire 2/2
!) %eaerator as ma3e up
c) SW recirc. pump as ma3e up.
11. he ma3e up flow rate is a#uste# !y the 8%&900191 to maintaina) Stage (( level
!) Salinity of the recycle !rine
c) SW flow to vacuum system.1(. Normally the ma3e up flow is e5ual to
a) hree times the #istillate flow
!) %ifference of #rain flow from total SW to heat reect flowc) %ifference of the sum of #rain an# recycle flow from total SW flow to
heat reect section.
1,. he ma3e up flow rate signal a#usts the #osing rate of
a) 0ntiscale !) So#ium sulphite
c) 0nti foam.
1/. =ow SW flow to evaporator along with high pressure is an in#ication of
a) %rain flow control v4v malfunctioning !) 2eavy fouling of heat reect section>s tu!es
c) 'ncorrect operation of flow control loop.1. Which con#ition of the process to !e chec3e# if !rine !low #own pump #ischarge
pressure starts increasing?
17. What two most important con#itions #o !rine !low #own pumps maintain?
1. Which one is at higher pressure
a) *vaporator stage ((
!) +ent con#enserc) 1st stage con#enser.
1;. Why the filtere# !rine is supplie# to the shaft seals of the !rine !low #own
pumps.
"* 4@0=S*
1<. 0nti foam solution is inecte# into thea) Aa3e up line
!) %eaerator
c) SW reect outlet line.(9. 0nti foam #osing flow alarm will not initiate if
a) &ump #ischarge v4v is lea3ing
!) &ump suction filter is !loc3e#c) Suction or #elivery line is !loc3e#
#) @low meter !y pass v4v not fully shut.
(