Canopy Chassis Firebox

Control Updates

EOG303 BBQ

Page 1 of 1

Issued By: Technical Service

Date Issued: 4-2004

Distribution: Service/Parts

Supercedes:

Subject: Maintenance

Product Type: BBQ

Model No: EOG30/36/52

Bulletin No: 04-06

EOG Maintenance

The EOG BBQ’s can get very dirty and if not properly maintained can develop additional problems. There are several steps to properly maintain the BBQ: Interior Cleaning Steps: 1. Verify that the smoker tray, rotisserie rod and forks have been removed from the grill. 2. Verify that the drip tray has been emptied. 3. Close the canopy completely. 4. Turn all of the burners to the high position. **Do not use the Infrared Rotisserie burner for Self-Cleaning. 5. Allow the canopy mounted temperature gauge to reach 700 degrees (approximately 1 hour), then turn off all of the burners. 6. Allow the grill to cool sufficiently before cleaning both the interior and exterior surfaces. Stainless Steel (u-shape burners) • Mild abrasive cleaners • Abrasive cleaners (limited applications) • Wire Brush Glass (light lens) • Non-abrasive cleaners • Glass cleaners are acceptable • Warm soapy water Exterior Cleaning: Stainless Steel (grills, heat control channels, burner box) • Mild non-abrasive cleaners • De-greasers (such as 409) • Dacor Cooktop Cleaning Cream and wet sponge

Technical Service 1440 Bridge Gate Drive Diamond Bar CA 91765 Phone 800-353-2267 Fax 909-612-1702

EOG303 CANOPY ASSEMBLY

Ref. # Part Number DESCRIPTION1 72642 HANDLE, CANOPY2 72178 ENDCAP, CANOPY HANDLE3 83480 SCREW, PHIL, FLAT HEAD, #4-40 X 1/44 72165 RUBBER BUMPER, HI-TEMP5 27823 WELD CANOPY, EOG3036 72686 TEMPERATURE GAUGE, EOG7 83571 SCREW WASHER HEAD, #8 X 3/8 8 72184 TEMPERATURE GAUGE TRIM RING9 83663 WASHER, 1.87 ODX x .64 IDX x .06T10 83473 LOCK NUT, 1/4 NPT, S.S.11 27826 WELD, CANOPY LINER12 83408 SCREW, PHIL PAN, #8-32 X 3/413 83619 SCREW, WAFER HEAD, #8 X 3/8 S.S.

** 72265 Power Cord

Technical Service 1440 Bridgegate Drive Diamond Bar CA 91765 PH 800-353-2267 FAX 909-612-1702

EOG303 Chassis Assy

Ref. # Part Number DESCRIPTION1 72360 HANDLE, GREASE TRAY (2 SCREWS INCLUDED)2 36626 GREASE TRAY FACIA3 38420 GREASE TRAY4 38413 BOTTOM PANEL5 36809 SIDE PANEL, LH6 83479 SCREW, TRUSS HEAD, S.S.7 72158 CANOPY ARM8 36674 HINGE BRACKET9 83009 NUT, KEPS, #10-2410 83459 HINGE PIVOT, 3/8-1611 83477 HEX NUT, S.S., 3/8-16 X 9/1612 83475 SPLIT 3/8 LOCK WASHER13 83485 1/2 WASHER, FLAT, 17/32 ID., S.S.14 83462 SHOULDER BOLT HINGE GUIDE15 83476 HEX NUT, S.S., 1/4-20 X 7/16 X 3/1616 83474 SPLIT 1/4 LOCK WASHER 17 83484 3/8 WASHER, FLAT, 13/32., S.S.18 36934 FRONT TRIM19 83619 SCREW, WAFER HEAD, #8 X 3/8 S.S.20 36940 SERVICE PANEL21 36945 CHASSIS REAR22 83408 SCREW, PHIL PAN, #8-32 X 3/423 36365 BRACKET TERMINAL BLOCK24 83048 NUT, HEX.KEPS, #8-3225 36675 ROTISSERIE POCKET26 36810 SIDE PANEL, RH

Technical Service 1440 Bridgegate Drive Diamond Bar CA 91765 PH 800-353-2267 FAX 909-612-1702

EOG303 Firebox

REF.# PART# DESCRIPTION

1 27834 WELD, IGNITER SUPPORT

2 36942 ACCESS PANEL, FIREBOX

3 72177 GRILL, 5-1/2”, S.S.

4 72157 GRILL, 11”, S.S.

5 72644 SPIT ROD

6 AGFS SPIT ROD FORK

7 72185 WARMING RACK SUPPORT

8 72643 WARMING RACK

9 36938 FRONT FRAME

10 36650 FIREBOX SIDE, LH

11 36676 FIREBOX LAMP HOUSING

12A62175

HALOGEN LIGHT, 10W, 12V

12B LENS

13 36657 ROTISERIE SPIT BRACKET

**14 27829 WELD, FIREBOX BOTTOM

15 72647 INFRARED BURNER

16 36971BP FIREBOX TOP, BLACK PORCELAIN

**17 27828 WELD, FIREBOX BACK

18 72164 SPARK ELECTRODE

19 27652 I. R. BROILER IGNITER BOX

20 36630 FIREBOX SIDE, RH

21 13540 ASSY, POWER CORD, ROTTISSERIE

22 27734 WELD, ROTISSERIE HOUSING

23 36767Rev.D BRACKET, MOTOR MOUNTING

24 72687 ROTISSERIE MOTOR

25 36628 FLAME SPREADER, LARGE

26 36661 FLAME SPREADER, SMALL

27 72153 U-BURNER, BBQ GRILL

28 72648 GRILL, 4 7/8” S.S.

** 92376 Light Cover

Date: 3-17-05 Re: EOG303 Parts Products Covered: EOG303 Revision Level Change: D to E Condition: Parts were redesigned to prevent the possibility of grease building up and causing flames to flare. up Correction: Description Old Part # New Part # Firebox Bottom 27829 27916 Firebox Back 38415 38555 This change IS NOT backward compatible, new parts can only be used on a unit with a Serial Revision E and above.

Technical Service 1440 Bridgegate Drive Diamond Bar CA 91765 PH 800-353-2267 FAX 909-612-1702

EOG303 Control Panel Assy

EOG303 Control Assy Parts

Technical Service 1440 Bridge Gate Drive Diamond Bar CA 91765 ph 800-353-2267 Fax 909-612-1702

REF.# Part Number DESCRIPTION1 36941 CONTROL SUB-PANEL

2A82086

INDICATOR LIGHT, BLUE NEON2B LENS3 86526 SPARK MODULE, 4 POINT4 62057 TRANSFORMER, CLASS 25 36939 CONTROL PLENUM

6

72662NGSL I.R. JET, NATURAL GAS SEA LEVEL, YELLOW 72662NGHA I.R. JET, NATURAL GAS HIGH ALTITUDE, BLUE72662LPSL I.R. JET, LP SEA LEVEL, ROSE 72662LPHA I.R. JET, LP HIGH ALTITUDE, RED

7 72179 INFRARED GAS TUBING, 3/8”8 72176 I.R. BROILER THERMOCOUPLE

9

72641NGSL MANIFOLD, NATURAL GAS SEA LEVEL, YELLOW72641NGHA MANIFOLD, NATURAL GAS HIGH ALTITUDE, BLUE72641LPSL MANIFOLD, LP SEA LEVEL, ROSE72641LPHA MANIFOLD, LP HIGH ALTITUDE, RED

10 86576 IGNITION SWITCH ASSY.

11

66557NGSL IR MANUAL VALVE, NATIONAL GAS SEA LEVEL, YELLOW66557NGHA IR MANUAL VALVE, NATIONAL GAS HIGH ALTITUDE, BLUE66557LPSL IR MANUAL VALVE, LP SEA LEVEL, ROSE66557LPHA IR MANUAL VALVE, LP HIGH ALTITUDE, RED

12

66561NGSL LEFT MANUAL VALVE, NATIONAL GAS SEA LEVEL, YELLOW66561NGHA LEFT MANUAL VALVE, NATIONAL GAS HIGH ALTITUDE, BLUE66561LPSL LEFT MANUAL VALVE, LP SEA LEVEL, ROSE66561LPHA LEFT MANUAL VALVE, LP HIGH ALTITUDE, RED

13

66936NGSL CENTER MANUAL VALVE, NATIONAL GAS SEA LEVEL, YELLOW66936NGHA CENTER MANUAL VALVE, NATIONAL GAS HIGH ALTITUDE, BLUE66936LPSL CENTER MANUAL VALVE, LP SEA LEVEL, ROSE66936LPHA CENTER MANUAL VALVE, LP HIGH ALTITUDE, RED

14A82343

INDICATOR LIGHT RED14B LENS15 27831 CONTROL PANEL, EOG303 WELDMENT ASSY.16 83571 SCREW WAFER HEAD17 62020C TRIM RING, EPICURE-CHROME18 62021B KNOB, EPICURE19 72169 HALOGEN LIGHT SWITCH20 72645 WIRE HARNESS (NOT SHOWN)21 83009 #10-24 HEX NUTS, KEPS22 83619 SCREW, WFR. HD, #8 X 3/8 S.S.

72596 - ASY, REGULATOR, 4”, NG 72310 - ASY, REGULATOR, 11”, LP (TANK)

106467 - IGNITER WIRE SET 72601 - ASY, REGULATOR, 11”, LP (HARD PIPE)

Date: 10-11-04 Re: Changes Products Covered: EOG303, 36 & 52 Revision Level Change: Revision Level was changed from: C to D on EOG303, EOG303/H, EOG303/LP, EOG303LP/H F to G on EOG36, EOG36/H, EOG52, EOG52/H E to F on EOG36/LP, EOG36/LP/H, EOG52/LP, EOG52/LP/H Part # Changes Model # Description Old Part # New Part # EOG303, 36, 52 Transformer 62057 62808 EOG303 Wire Harness 72645 92111 EOG36 Wire Harness 72385 92110 EOG52 Wire Harness 72382 92109 EOG303 -36941 EOG36, 52 - 36642

Sub Panels were modified to accommodate changes

EOG303 -36941 EOG36, 52 – 36642 Part numbers did not change

This change is not backward compatible.