CONNECTOR INFORMATION FOR DIAGRAM: P94-2040

A

B

C

D

E

F

G

H

I

J

K

L

45678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

3 12

1. THIS DRAWING AND THE INFORMATION CONTAINED HEREIN ARE PROPRIETARY TO PACCAR INC UNLESS OTHERWISE NOTED AND SHALL NOT BE REPRODUCED, COPIED OR DISCLOSED, IN WHOLE OR IN PART, OR USED FOR MANUFACTURE OR FOR OTHER PURPOSE WITHOUT THE WRITTEN PERMISSION OF PACCAR INC.2. DIMENSIONING AND TOLERANCING PER PACCAR CS0108.3. REMOVE ALL BURRS. BREAK SHARP EDGES.4. PART IDENTIFICATION AND TRACEABILITY REQUIREMENTS TO COMPLY WITH PACCAR CPS0098.5. THIS DRAWING/SPECIFICATION USES SYMBOLS TO CLASSIFY CHARACTERISTICS. THESE SYMBOLS ARE DEFINED IN THE PACCAR SUPPLIER QUALITY STANDARD.6. EMISSION-RELATED PART. CODE: SEE PACCAR CPS0374 FOR REQUIREMENTS.

TOLERANCESUNLESS OTHERWISE SPECIFIED

SCALE

DRAWING

TITLE

DIMENSION UNITS

THIRD ANGLE PROJECTION

DO NOT SCALE DRAWING

DRAWING VERSION

REV

CONNECTOR INFORMATION FOR DIAGRAM: P94-2040

REF_DESNUMBER OFCAVITIES

ONSHEET

PARTNUMBER

DESCRIPTION LOCATION OF CONNECTOR

J009 1 3 P20-1112 BLACK, AMP 1/4" RECEPTACLE, UNSEALED TO LEFT OF STEERING COLUMN, ABOVE CLUTCH PEDAL

J00X 12 4 P20-1352-2212301 BLACK, METRI-PACK, 280 SERIES, UNSEALED BEHIND PANEL 5, TOP OF CROSS CAR BEAM

J00Y 3 4 P20-1288 BLACK, METRI-PACK GT150 SERIES, SEALED BEHIND PANEL 5, BEHIND CROSS CAR BEAM

J00Z 3 4 P20-1288 BLACK, METRI-PACK GT150 SERIES, SEALED BEHIND PANEL 5, BEHIND CROSS CAR BEAM

J01 4 4 P20-1172-1204 BLACK, AMP MQS, UNSEALED BEHIND PANEL 5, ATTACHED TO CVSG GAUGES (JUMPERS)

J01. 3 5 P20-1182-12 BLACK PACKARD GT 150 SEALED PULL TO SEAT LH RAIL, ABOVE FUEL FILTER

J014 8 3 P20-6041 BLACK, DELPHI, METRI-PACK 150 SERIES, UNSEALED PASSENGER SIDE KICK PANEL

J01A 3 4 P20-1288 BLACK, METRI-PACK GT150 SERIES, SEALED BEHIND PANEL 5, BEHIND CROSS CAR BEAM

J01B 3 4 P20-1288 BLACK, METRI-PACK GT150 SERIES, SEALED BEHIND PANEL 5, BEHIND CROSS CAR BEAM

J02 4 4 P20-1172-1204 BLACK, AMP MQS, UNSEALED BEHIND PANEL 5, ATTACHED TO CVSG GAUGES (JUMPERS)

J02. 2 4 P20-1082 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED CONNECTED TO REAR AXLE TEMP SENSOR

J022 2 3 K333-514 CONNECTOR - GRAY PACKARD 56 SERIES UNSEALED BEHIND PANEL 5, ATTACHED CLOCK (GAUGE)

J024 1 3 P20-1112 BLACK, AMP 1/4" RECEPTACLE, UNSEALED BEHIND GAUGE CLUSTER, TOP OF CROSS CAR BEAM




J028 52 3, 4, 5 P20-1172-1252 BLACK, AMP MQS 52-WAY, UNSEALED AT CECU HOTEL, CENTER DASH, BEHIND CUP HOLDER

J029 14 3 P20-1173-1214 BLACK, AMP JPT 2 ROW 14 PIN UNSEALED, UNSEALED BEHIND GAUGE CLUSTER, TOP OF CROSS CAR BEAM

J03 2 4 P20-1082 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED CONNECTED TO REAR AXLE TEMP SENSOR

J030 40 3 P20-1172-1240 BLACK, AMP MQS 40-WAY, UNSEALED AT CECU HOTEL, CENTER DASH, BEHIND CUP HOLDER

J032 4 4 P20-1172-1204 BLACK, AMP MQS, UNSEALED BEHIND PANEL 5, ATTACHED TO FIRST CVSG GAUGE

J033 3 4 P20-1288 BLACK, METRI-PACK GT150 SERIES, SEALED BEHIND GAUGE CLUSTER, BEHIND CROSS CAR BEAM



J040 1 3 P20-1112 BLACK, AMP 1/4" RECEPTACLE, UNSEALED TO LEFT OF STEERING COLUMN, ABOVE CLUTCH PEDAL

J047 6 5 K333-541 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED LH RAIL, FWD OF FORWARD REAR DRIVE AXLE

J048 9 3, 4 P20-1183-1209 BLACK, AMP JPT 9-WAY, UNSEALED AT CECU HOTEL, CENTER DASH, BEHIND CUP HOLDER

J049 24 3 P20-1172-1224 BLACK, AMP MQS 24-WAY, UNSEALED AT CECU HOTEL, CENTER DASH, BEHIND CUP HOLDER

J049. 2 4 K333-387 BLACK, PACKARD, WEATHER PACK, SEALED CONNECTED TO FORWARD REAR AXLE DIFF LOCK SW

J050 9 3 P20-1183-2209 WHITE, AMP JPT 9-WAY, UNSEALED AT CECU HOTEL, CENTER DASH, BEHIND CUP HOLDER

J050. 2 4 K333-387 BLACK, PACKARD, WEATHER PACK, SEALED CONNECTED TO CENTER REAR AXLE DIFF LOCK SW

J051 2 4 K333-387 BLACK, PACKARD, WEATHER PACK, SEALED CONNECTED TO REAR REAR AXLE DIFF LOCK SW

J052 2 4 K333-387 BLACK, PACKARD, WEATHER PACK, SEALED CONNECTED TO REAR REAR AXLE DIFF LOCK SW

J060 10 5 K333-547 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED LH RAIL, 1500mm AFT OF BOC X-MEMBER

J080 1 3 P20-1112 BLACK, AMP 1/4" RECEPTACLE, UNSEALED BEHIND PANEL 5, ATTACHED CLOCK (GAUGE)

J088 8 3 P20-6041 BLACK, DELPHI, METRI-PACK 150 SERIES, UNSEALED DRIVER OR PASSENGER SIDE KICK PANEL

J153 2 5 K333-550-102 BLACK, PACKARD, METRI-PACK 280 SERIES, SEALED LH RAIL, AFT OF BOC X-MEMBER

J154 2 5 K333-550-102 BLACK, PACKARD, METRI-PACK 280 SERIES, SEALED LH RAIL AFT OF PRIMARY FUEL TANK OR RH RAIL

J161 39 5 P20-1314-21530 GREEN, TYCO/AMP MCP 39-WAY SEALED FIREWALL ENGINE SIDE, DRIVER SIDE, BELOW CAB PDC

J491 10 5 K333-547 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED LH RAIL, AFT OF REAR ENGINE MOUNT

P001 46 3 P20-1301-001 BLACK, A-POLE mPDC (ALCOA) FIREWALL, DRIVER CAB SIDE, TOP OF CAB PDC

P002 46 3 P20-1301-002 GRAY, B-POLE mPDC (ALCOA) FIREWALL, DRIVER CAB SIDE, TOP OF CAB PDC

P003 46 3 P20-1301-003 BLUE, E-POLE mPDC (ALCOA) FIREWALL, DRIVER CAB SIDE, TOP OF CAB PDC

P004 46 3 P20-1301-004 DARK GREEN, D-POLE mPDC (ALCOA) FIREWALL, DRIVER CAB SIDE, TOP OF CAB PDC

P006 64 4 P20-1314-32201 GREY, AMP MCP SERIES, UNSEALED FIREWALL CAB SIDE, DRIVER SIDE, BELOW CAB PDC

P00T 8 3 P20-1349 BLACKM, AMP 8-WAY, UNSEALED BEHIND DASH, TO RIGHT OF STEERING COLUMN

P01 6 4 K333-541 PACKARD_MP150_6-WAY_ SEALED LH RAIL, FWD OF FORWARD REAR DRIVE AXLE

P01. 3 5 K333-552 BLACK PACKARD METRI PACK 150 SEALED LH RAIL, ABOVE FUEL FILTER

P011 21 3 P20-1132-1621 BROWN, AMP 21-WAY, UNSEALED BEHIND PANEL 5, TOP OF CROSS CAR BEAM

P01S 21 3 P20-1132-1621 BROWN, AMP 21-WAY, UNSEALED BEHIND PANEL 5, TOP OF CROSS CAR BEAM

P025 2 3 P20-1195-1102 NATURAL, MOLEX MINIFIT 2-WAY, UNSEALED BEHIND CUP HOLDER, LEFT SIDE, ABOVE CECU

P026 2 3 P20-1195-1102 NATURAL, MOLEX 2-WAY MINIFIT, UNSEALED BEHIND CUP HOLDER, LEFT SIDE, ABOVE CECU





P030. 2 3 P20-1195-1102 NATURAL, MOLEX 2-WAY MINIFIT, UNSEALED BEHIND CUP HOLDER, LEFT SIDE, ABOVE CECU

P033 39 5 P20-1314-22531 GREEN, TYCO/AMP MCP 39-WAY SEALED FIREWALL CAB SIDE, DRIVER SIDE, BELOW CAB PDC

P046 6 5 K333-540 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED LH RAIL, FWD OF FORWARD REAR DRIVE AXLE

P087 4 3 16-09173 ORANGE, METRIPACK 150, SEALED BEHIND GAUGE CLUSTER, BEHIND CROSS CAR BEAM

CONNECTOR INFORMATION FOR DIAGRAM: P94-2040

REF_DESNUMBER OFCAVITIES

ONSHEET

PARTNUMBER

DESCRIPTION LOCATION OF CONNECTOR

P103_ 62 4 P20-1314-31230 GRAY, AMP, MCP SERIES, SEALED LH FIREWALL, ENGINE SIDE

P127_ 3 4 P20-1236-1203N BLACK, AMPSEAL 16, SEALED AT AIR CLEANER BRACKET

P151 10 5 P20-1316-2110 BLACK, DELPHI PACKARD GT 150 SERIES, SEALED FIREWALL, DRIVER SIDE, TOP OF CAB PDC

P152 21 5 P20-1314-11110 BLACK, CONNECTOR AMP 21 WAY MCP, SEALED FIREWALL, DRIVER SIDE, TOP OF CAB PDC

P161 21 5 P20-1274-001 BLACK, AMP, MCP SERIES, SEALED BEHIND OVERBELL, OUTBOARD OF LEFT FRAME RAIL

P162 21 5 P20-1274-002 NATURAL/WHITE, AMP, MCP SERIES, SEALED BEHIND OVERBELL, OUTBOARD OF LEFT FRAME RAIL

P163 3 5 K333-553 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED LH RAIL, ABOVE FUEL FILTER

P164 3 5 P20-1316-2103 BLACK, PACKARD, GT 150 SERIES, SEALED ATTACHED TO CAB POWER FEED CABLE, BATTERY BOX

P168 2 5 P20-1040 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED CONNECTED TO AUX TRANS TEMP SENSOR, FWD OF REAR AXLE

P171 10 5 K333-546 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED LH RAIL, 1500mm AFT OF BOC X-MEMBER

P172 21 5 P20-1274-003 LIGHT BLUE, AMP, MCP SERIES, SEALED BEHIND OVERBELL, OUTBOARD OF LEFT FRAME RAIL

P173 2 5 P20-1082 BLACK, PACKARD, METRI-PACK 150 SERIES, SEALED CONNECTED TO TRANS CASE TEMP SENSOR BEHIND MAIN TRANS

P174 10 5 K333-546 BLACK, METRI-PACK 150 SERIES, 10 WAY, SEALED LH RAIL, AFT OF REAR ENGINE MOUNT

P176 12 5 P20-1352-1112101 BLACK, METRI-PACK 150 12-WAY, SEALED LH RAIL, AFT OF BOC X-MEMBER

P492 2 5 P20-1082 BLACK METRI-PACK 150, 2 WAY, SEALED RIGHT LOWER SIDE OF MAIN TRANSMISSION

P791 8 3 P20-6040 BLACK, PACKARD, METRI-PACK 150 SERIES, UNSEALED DRIVER OR PASSENGER SIDE KICK PANEL

P791. 8 3 P20-6040 BLACK, PACKARD, METRI-PACK 150 SERIES, UNSEALED DRIVER OR PASSENGER SIDE KICK PANEL

P795 18 3 P20-1132-1518 GREY, TYCO, MCP SERIES, UNSEALED INSIDE DRIVER/PASSENGER DOOR UNDER TOP DOOR PAD

P795. 18 3 P20-1132-1518 GREY, TYCO, MCP SERIES, UNSEALED INSIDE DRIVER/PASSENGER DOOR UNDER TOP DOOR PAD

T001 1 3 K333-46-22 RING TERMINAL (1/4") FIREWALL, ENGINE SIDE, DRIVER SIDE OUTBOARD, LOW

TABLE 1: WIRE GAUGE

METRIC(mm^2)

STANDARD(AWG)

METRIC(mm^2)

STANDARD(AWG)

0.35 22 5.0 10

0.5 20 8.0 8

0.8 18 13.0 6

1.0 16 19.0 4

2.0 14 32.0 2

3.0 12 40 1

MATERIALPRODUCT DESCRIPTIONPART NUMBERITEMQTY

SHEET 1 OF 8A.4

DIAG-INSTRUMENTATION, NGP

N

DRAWING SCALE

AP94-2040MILLIMETERS

ANGLE = 1(X) = 1

(X.X) = 0.5

ENGINEHARNESS

INSTRUMENTPANEL HARNESS

(IP)

CHASSISHARNESS

TAIL LAMPEXTENSIONHARNESS

CAB POWERDISTRIBUTIONCENTER (PDC)

RH DOORHARNESS

LH DOORHARNESS

TRANSMISSIONHARNESS

DIFFERENTIALLOCK

HARNESS AXLETEMPERATURE

HARNESS

FUEL TANKSECONDARYEXT HARN(OPTIONAL)

AMMETEREXT HARNESS(OPTIONAL)

PRIMARYFUEL TANKHARNESS

GENERAL NOTES: 1) USE ON NGP CHASSIS EQUIPPED WITH NAMUX IV INSTRUMENTATION. 2) HOW TO USE THIS DIAGRAM: EACH CONNECTOR HAS A DISTINCT ALPHANUMERIC "REFERENCE DESIGNATOR" OR "REF DES" ASSOCIATED WITH IT. USE THIS REF DES TO FIND CONNECTOR INFORMATION IN THE CONNECTOR INFORMATION TABLE. CONNECTOR MATING VIEWS SHOWN FOR CONNECTORS WITH 3 OR MORE TERMINALS. 3) DESIGNATES A REFERENCE POINT ON ANOTHER SHEET OR DIAGRAM. 4) DENOTES A TWISTED PAIR OF WIRES. DENOTES A TWISTED PAIR OF JACKETED WIRES. DENOTES A TWISTED TRIPLET OF WIRES. DENOTES OPTIONAL WIRE. MAY OR MAY NOT EXIST, DEPENDS ON OPTION CONFIGURATION. 5) WIRE SIZE IN DIAGRAM IS SPECIFIED IN METRIC UNITS PER SAE STANDARDS J1127 & J1128. TABLE 1 PROVIDED FOR CROSS REFERENCE TO AMERICAN WIRE GAUGE (AWG) UNITS. 6) EMISSIONS RELATED PART CODE: [N] SEE CPS0369 FOR REQUIREMENTS. SPLICE CONTAINS MORE CIRCUITS THAN SHOWN. USED FOR REFERIGERATOR TELLTALE. ACTIVATES BY APPLYING +12V TO CLUSTER PIN 6. (SHEET 3, ZONE K10) EDITABLE TELLTALES ACTIVATED BY APPLYING +12V OR GROUND TO PIN 2 OF THE FOLLOWING IP HARNESS BREAKOUTS (SHEET 3, ZONE E12) WITH TAG LABEL AND REF_DES: TELLTALE POS. 1, P025 TELLTALE POS. 2, P026 TELLTALE POS. 3, P027 TELLTALE POS. 5, P028 TELLTALE POS. 6, P029 TELLTALE POS. 7, P030 EDITABLE ALARMS ACTIVATED BY APPLYING +12V OR GROUND TO THE FOLLOWING IP HARNESS BREAKOUTS (SHEET 3, ZONE D12) WITH TAG LABEL AND REF_DES: ALARM 1A, J027 ALARM 1B, J026 ALARM 1C, J025 ALARM 2, J024

INSTRUMENTATION SYSTEM BLOCK DIAGRAM

THIS SIMPLIFIED BLOCK DIAGRAM SHOWS HARNESSESINVOLVED IN THE INSTRUMENTATION SYSTEM DIAGRAM.LINES REPRESENT HARNESS TO HARNESS & HARNESSTO POWER DISTRIBUTION CENTER CONNECTIONS.

7

X

8

9

10

A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV

SCALE DRAWING VERSION

UNLESS OTHERWISE NOTEDTHIS DRAWING AND THE INFORMATION CONTAINED HEREIN ARE PROPRIETARY TO PACCAR INC.IT SHALL NOT BE REPRODUCED, COPIED OR DISCLOSED, IN WHOLE OR IN PART, OR USED FOR MANUFACTURE OR FOR OTHER PURPOSE WITHOUT THE WRITTEN PERMISSION OF PACCAR INC.

CONNECTOR INFORMATION FOR: J050P20-1183-2209, , (9 CAVITIES)

LABEL: J050,CECU 5 (E)

4

7

1

6

9

3

MATING VIEW


LABEL: J029,GAUGE CLUSTER

MATING VIEW

1

3

5

7

9

11

13

2

4

6

8

10

12

14

CONNECTOR INFORMATION FOR: P08716-09173, , (4 CAVITIES)LABEL: P087,PARK BRAKE SW

A

DB

C

MATING VIEW

CONNECTOR INFORMATION FOR: P001P20-1301-001, BLACK, (46 CAVITIES)

LABEL: P001,mPDC P1

CONNECTOR INFORMATION FOR: P002P20-1301-002, GRAY, (46 CAVITIES)

LABEL: P002,mPDC P2

CONNECTOR INFORMATION FOR: P004P20-1301-004, DARK GREEN, (46 CAVITIES)

LABEL: P004,mPDC P4

CONNECTOR INFORMATION FOR: P003P20-1301-003, BROWN, (46 CAVITIES)

LABEL: P003,mPDC P3

CONNECTOR INFORMATION FOR: P001.P20-1301-001, BLACK, (46 CAVITIES)

LABEL: P001.,mPDC P1

MATING VIEW

A1

B1

B6

A2

A9

B31

B36

A10

TERMINAL INFORMATION FOR: J060K333-547, BLACK, (10 CAVITIES)

LABEL: J060, FRONT CHASSIS HARNESS


LABEL: J491, CHASSIS HARN

MATING VIEW

K F

A E

CONNECTOR INFORMATION FOR: P006P20-1314-32201, GREY, (64 CAVITIES)

LABEL: P006,ENGINE HARNESS

MATING VIEW

41

60 62

CONNECTOR INFORMATION FOR: J00XP20-1352-2212301, , (12 CAVITIES)LABEL: J00X,SPLICE, AIR SENSORS

M

G

A

F


LABEL: J028,CECU 3 (C)

1

14

27

40

13

26

39

52

MATING VIEW


LABEL: J049,CECU 2 (B)

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

MATING VIEW

6

1

24

197 13

12 18


LABEL: J030,CECU 4 (D)

111

21

31

10

2030

40

111

3121

1020

4030

MATING VIEW

CONNECTOR INFORMATION FOR: J161P20-1314-21530, GREEN, (39 CAVITIES)

LABEL: J161,IP/CHASSIS

MATING VIEW

3 1

3739

TERMINAL INFORMATION FOR: P011P20-1132-1621, BROWN, (21 CAVITIES)

LABEL: P011, SPLICE BLOCK GND

TERMINAL INFORMATION FOR: P01SP20-1132-1621, BROWN, (21 CAVITIES)

LABEL: P01S, SPLICE BLOCK BACKLIGHT 2

19 16 13 10 7 4 1

21 18 15 12 9 6 3

MATING VIEW


LABEL: J048,CECU 1 (A)

4

7

1

6

9

3

MATING VIEW

TERMINAL INFORMATION FOR: J088P20-6041, , (8 CAVITIES)

LABEL: J088, LH DOOR SIGNALS


LABEL: J014, RH DOOR SIGNALS

MATING VIEW

HGFE

A

CD

B

CONNECTOR INFORMATION FOR: P00TP20-1349, , (8 CAVITIES)LABEL: P00T,MCS SWITCH

1 4

5 8

MATING VIEW


LABEL: J047, REAR AXLE DIFF LOCK HARNESS

TERMINAL INFORMATION FOR: P01K333-541, BLACK, (6 CAVITIES)

LABEL: P01,

A C

DF

MATING VIEW

TERMINAL INFORMATION FOR: J00YP20-1288, , (3 CAVITIES)

LABEL: J00Y, OPT GAUGE SENS 1

TERMINAL INFORMATION FOR: J00ZP20-1288, , (3 CAVITIES)

LABEL: J00Z, OPT GAUGE SENS 2

TERMINAL INFORMATION FOR: J01AP20-1288, , (3 CAVITIES)

LABEL: J01A, OPT GAUGE SENS 3

TERMINAL INFORMATION FOR: J01BP20-1288, , (3 CAVITIES)

LABEL: J01B, OPT GAUGE SENS 4


LABEL: J033, (REAR) PRIMARY AIR


LABEL: J034, (FRONT) SECONDARY AIR


LABEL: J035, APPLICATION AIR

2 1

3

MATING VIEW

TERMINAL INFORMATION FOR: J01P20-1172-1204, , (4 CAVITIES)

LABEL: J01, RH CVSG


LABEL: J02, RH CVSG


LABEL: J032, RH CVSG

4 13 2

MATING VIEW

CONNECTOR INFORMATION FOR: P033P20-1314-22531, GREEN, (39 CAVITIES)

LABEL: P033,CHASSIS HARNESS

MATING VIEW

31

37 39

CONNECTOR INFORMATION FOR: P103_P20-1314-31230, GRAY, (62 CAVITIES)

LABEL: P103_,IP HARNESS

MATING VIEW

14

58

4952

5356

6062

CONNECTOR INFORMATION FOR: P127_P20-1236-1203N, BLACK, (3 CAVITIES)LABEL: P127_, AIR FILTER RESTRICTION

MATING VIEW

13

CONNECTOR INFORMATION FOR: P151P20-1316-2110, , (10 CAVITIES)

LABEL: P151, MPDC #2

MATING VIEW

E A

K F

CONNECTOR INFORMATION FOR: P152P20-1314-11110,BLACK,(21 CAVITIES)

LABEL: P152,MPDC #1

3 1

1921

MATING VIEW

TERMINAL INFORMATION FOR: P161P20-1274-001, BLACK, (21 CAVITIES)LABEL: P161, CHASSIS NODE PORT A

TERMINAL INFORMATION FOR: P162P20-1274-002, WHITE, (21 CAVITIES)LABEL: P162, CHASSIS NODE PORT B

TERMINAL INFORMATION FOR: P172P20-1274-003, BLUE, (21 CAVITIES)LABEL: P172, CHASSIS NODE PORT C

MATING VIEW

19

13

21

TERMINAL INFORMATION FOR: P795P20-1132-1518, GREY, (18 CAVITIES)LABEL: P795, DOOR SWITCH MODULE

TERMINAL INFORMATION FOR: P795.P20-1132-1518, GREY, (18 CAVITIES)LABEL: P795., DOOR SWITCH MODULE

16 13 10 7 4 1

18 15 12 9 6 3

MATING VIEW


LABEL: P176,ANOLOG RTN SPLICE BLK

A

M

MATING VIEW

TERMINAL INFORMATION FOR: P171K333-546, BLACK, (10 CAVITIES)LABEL: P171, REAR CHASSIS HARN


LABEL: P174, TRANS HARN

KF

E AMATING VIEW

TERMINAL INFORMATION FOR: P791P20-6040, BLACK, (8 CAVITIES)

LABEL: P791, DOOR #1

TERMINAL INFORMATION FOR: P791.P20-6040, BLACK, (8 CAVITIES)

LABEL: P791., DOOR #1

A

CD

HGFE

FRONT VIEW

B

CONNECTOR INFORMATION FOR: P163K333-553, BLACK, (3 CAVITIES)

LABEL: P163,FUEL FIL. RESTR. SENSE

C A

MATING VIEW


LABEL: P164,AMM SENS

MATING VIEW

A C


LABEL: P047, REAR CHASSIS HARNESS


LABEL: P046, REAR AXLE TEMP HARNESS

AC

D F

MATING VIEWSHEET 2 OF 8A.4DRAWING SCALE

AP94-2040


PDC LOAD CENTER SPLICE BLOCKS

HARNESS TO HARNESS

HARNESS TO COMPONENTUSAGE: USE ON NGP CHASSIS EQUIPPED WITHNAMUX IV INSTRUMENTATION.

A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV



WHT1515-011 2.0

RED4210-001 0.5

ORN4330-001 0.8

ORN4323-001 0.8

GRN0811-001 0.75

YEL0811-001 0.75

ORN1220-001, 0.8

"OBD MIL LAMP, IGN"

"GA CLUSTER, BATT"

"INSTRUMENTATI0N GND"

"J1939, I-CAN (+)"

"J1939, I-CAN (-)"

PETERBILT GAUGE CLUSTER

SEE DETAIL BPETERBILT GAUGE CLUSTERSHEET 7 ZONE L9

BRN4388-001 1.0

"SLPR REFER ON"

BRN4330-001 0.5

BRN4323-001 0.5

"WAIT TO START LAMP"

"OBD MIL"

SEE SLPR OPTIONSDIAGRAM

SEE ENG SYSTEMDIAGRAM

"WAIT TO START, IGN"

J029 12 14 11 13 2 1 10 3 9 7 4 5 6 8

021

7

SHEET 3 OF 8A.4DRAWING SCALE

AP94-2040


BATBUS

ACCBUS

CAB PDC

GRA4377-001 0.8

GRA4376-001 0.8

GRA4375-001 0.8

GRA4373-001 0.8

GRA4372-001 0.8

GRA4371-001 0.8

GRA4373-001 0.8

GRA4372-001 0.8

GRA4371-001 0.8

GRA5961-001 0.8

GRA5961-002 0.8

WHT4920-001 0.8

GRA4375-001 0.8

GRA4376-001 0.8

WHT1515-012 32.0

WHT1515-013 8.0

WHT1515-016 2.0

WHT1515-023 8.0

GRA5962-004 0.8

GRA4377-001 0.8GRA5961-003 0.8

GRA4392-001 0.5

WHT1515-011 2.0

GRA4854-001 0.5

GRA4852-001 0.5

GRA4853-001 0.5

GRN4851-001 0.5

GRN4851-001 0.5

YEL4851-001 0.5

YEL4851-001 0.5

"ALARM 1A"

RED4210-001 0.5

RED4920-001 0.8

WHT1515-015 0.5

ORN4330-001 0.8

ORN4323-001 0.8

"ALARM 1B"

"ALARM 1C"

"ALARM 2"

"EDITABLE TELLTALE # 7"

"EDITABLE TELLTALE #6"





"PARK BRAKE SET"

GRN0811-001 0.75,(CTW10)

YEL0811-001 0.75,(CTW10)

"J1939, I-CAN (+)"

"J1939, I-CAN (-)"

BLU3112-002 0.5

GRA3112-002 0.5

BLU3112-001 0.5

"LH/RH DOOR W/U"

ORN1230-001 0.5

ORN1220-001 0.8

RED4210-002 2.0

RED4210-003 2.0

ORN4220-001 0.5

RED4920-001 0.8

RED4210-001 0.5

BRN2620-005 0.5

WHT4920-001 0.8

WHT1515-020 0.8

GRA4392-001 0.5

GRA4855-001 0.5

GRA4855-001 0.5

"MCS BACK"

WHT1515-028 13.0

GRA4854-001 0.5

GRA4853-001 0.5

GRA4852-001 0.5

"GROUND,INSTRUMENT PANEL"WHT4392-001, 0.5

ORN1220-001, 0.8







"ALARM 2"

"ALARM 1C"

"ALARM 1B"

"ALARM 1A"

LH DOOR CONT MOD

RH DOOR CONT MOD

PARK BRAKESWITCH(SHOWN W/ PARK BRAKERELEASED)

MENU CONTROLSWITCH

CECU 4 (D)

CECU 2 (B)

CECU 1 (A)

CECU 5 (E)

CLOCK

WHT3195-001 0.8

GRA3195-001 0.5

WHT3195-001, 0.8

GRA4211-002 0.8

IGNBUS

PROTECTED BY 10AIGN SWITCH FUSESEE CHARGE ANDSTART DIAGRAM

"CECU ACC PWR"

"CECU PWR, IGN"

CECU 4 (D)

"CECU LVD BATT V SENSE"

CECU 3 (C)

CECU 1 (A)

"CECU PWR #2, BATT"

"CECU PWR #1, BATT"

"CECU GROUND"

"MCS SUPPLY"

"MCS GND"

"CLUTCH SWITCH"

"MCS A"

"MCS B"

GRA3195-001 0.5

"MCS BACK"

"MCS SUPPLY"

"MCS GND"

"MCS A"

"MCS B"

"MCS ENTER"

"MCS ENTER"

"ANALOG CLOCK, BATT"

"CLOCK GND"

"DASH/PANEL ILLUMINATION"

FIREWALLGROUND,CAB SIDE

* FUSES ARE ON THE CAB SIDE OF THE PDC "C_" CAB SIDE

"CECU WAKEUP" BLU3112-794 0.5

"CECU WAKEUP" BLU3112-794 0.5

"WAIT TO START, IGN"

"OBD MIL LAMP, IGN"

"GA CLUSTER, BATT"

"INSTRUMENTATI0N GND"

"J1939, I-CAN (+)"

"J1939, I-CAN (-)"

KENWORTH GAUGE CLUSTER

CECU

CECU

CECU

SEE DETAIL AKENWORTH GAUGE CLUSTERSHEET 7 ZONE L9

MISC LOWPOWER GROUNDSPLICE BLOCK

BACK LTPOWER GROUNDSPLICE BLOCK

FRONT VIEW REAR VIEW

PRESS TO CLICK BACK

ROTATE KNOB & PRESS TO SELECT

ORN4355-001, 0.5

BRN4355-004, 0.5

SEE PTO SYSTEMDIAGRAM

"PUMP MODE IGN PWR"

"PUMP MODE SIGNAL"

BRN4388-001 1.0

"SLPR REFER ON"

BRN4330-001 0.5

BRN4323-001 0.5

"WAIT TO START LAMP"

"OBD MIL"

SEE SLPR OPTIONSDIAGRAM

SEE ENG SYSTEMDIAGRAM

GRA4377-001 0.8

GRA4377-001 0.8


(KW ONLY)

(PB ONLY)


GAUGE CL/RKE

5 AMP

C_B3

CECU BATT PWR 2

15 AMP

C_B5

CECU IGN PWR

5 AMP

C_K17

MISC LOW CURR

10 AMP

C_K15

CECU ACC

5 AMP

C_R9

CECU BATT PWR 1

15 AMP

C_K18

006

015

016

J080

T001

J029 14 12 11 13 2 1 10 3 9 7 4 5 6 8

J027

J026

J025

J024

J022

A

B

005

P030

2

P029

2

P028

2

P027

2

P026

2

P025

2

J050

5

J049

1

2

3

13

021

P001

B14

P002

B9

P004

B8

053

P011 1 2

P087

D

C

P00T

6

4

2

3

1

5

7

8

J088

F

J014

F

P01S1 2

A

B

J040

J009

CECU BATT PWR 3

5 AMP

C_J10 P003

B33

P004

B13

P002

B30

P001

B12

P001

B5

I

30

J030 93534721920212324252231302928

J030

1

3

J028

33

J048

2

9

J048

5

4

6

7

7

7

7

7

P791

F

P795

17

P791.

F

P795.

17

USAGE: USE ON NGP CHASSIS EQUIPPED WITHNAMUX IV INSTRUMENTATION.

9

10

9

9

9

9

9

10

10

10

CLUTCHSWITCH(SHOWN W/ CLUTCHRELEASED)

A

B

9

6

21

3PIN 3

PIN 2 (-)

PIN 1 (+)

P030.

29

A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV


UNLESS OTHERWISE NOTEDTHIS DRAWING AND THE INFORMATION CONTAINED HEREIN ARE PROPRIETARY TO PACCAR INC.IT SHALL NOT BE REPRODUCED, COPIED OR DISCLOSED, IN WHOLE OR IN PART, OR USED FOR MANUFACTURE OR FOR OTHER PURPOSE WITHOUT THE WRITTEN PERMISSION OF PACCAR INC. SHEET 4 OF 8A.4DRAWING SCALE

AP94-2040


BLU4511-001 0.5

BLU4515-001 0.5

GRN4511-001 0.5

VIO4511-001 0.5

BLU4511-001 0.5

BLU4512-001 0.5

GRN4515-001 0.5

BLU4515-001 0.5

VIO4512-001 0.5

VIO4515-001 0.5VIO4500-002 0.5

BLU4512-001 0.5

GRN4512-001 0.5

GRN4500-002 0.5

BLU0855-001 0.5

BLK4100-001 0.5

"PWR SUPP SENSOR +5V"

"REAR PRIMARY AIR"

"APPLICATION AIR"

"SECONDARY AIR SUPPLY"

"ANALOG SENSOR RTRN"

VIO4500-001 0.5

GRN4500-001 0.5

YEL4100-001 0.5

GRN1515-001 0.5

"CVSG DATA"

"CVSG GND"

BLU4617-001 0.5

"AIR FILTER REST, SENSE"

VIO4517-001 0.5

GRN4517-001 0.5

"ANALOG GROUND"

GRN4500-003 0.5

VIO4500-003 0.5

GRN4500-004 0.5

GRN4500-005 0.5

GRN4500-006 0.5

GRN4500-007 0.5

VIO4500-004 0.5

VIO4500-005 0.5

VIO4500-006 0.5

VIO4500-007 0.5

BLU4500-004 0.5

BLU4500-005 0.5

BLU4500-006 0.5

BLU4500-007 0.5

VIO4500-007 0.5

GRN4500-007 0.5

VIO4500-006 0.5

GRN4500-006 0.5

VIO4500-005 0.5

GRN4500-005 0.5

VIO4500-004 0.5

GRN4500-004 0.5

BLU4500-007 0.5

BLU4500-006 0.5

BLU4500-005 0.5

BLU4500-004 0.5

"OPT SENSOR SIG #4"

"OPT SENSOR SIG #3"

"OPT SENSOR SIG #2"

"OPT SENSOR SIG #1"

"CVSG POWER"

80855 BLU 0.5

42621 BRN 0.5

54100 WHT 0.5

34100 YEL 0.5

CECU 1 (A)

SPLICE BLOCK INFO THE COMMON CIRCUIT FOR SPLICE BLOCKSTERMINATES AT PINS "A" AND "M".ALL OPTIONAL CIRCUITS ARE TERMINATEDRANDOMLY. CIRCUITS SHOWN IN ORDER FOR CLARITY ONLY.

CVSG DATA

CVSG GND

BACK LT

CVSG POWER

CVSG DATA

CVSG GND

BACK LT

CVSG POWER

RED WARNING LED RED WARNING LED

CVSG JUMPER HARNESS

* SHOWN WITH (2) OPTIONAL CVSG GAUGES.ADDITIONAL GAUGES ARE DAISY CHAINEDUSING ADDITIONAL CVSG JUMPER HARNESSES.

FRONT VIEW FRONT VIEW

REAR VIEW REAR VIEW

BRN2621-001 0.5SEE INTERIOR LIGHTINGSYSTEM DIAGRAM.

AIR FILTERRESTRICTION

PRESSURETRANSDUCEROPT SENSORSIG #2



PRESSURETRANSDUCERAPPLICATIONAIR

PRESSURETRANSDUCER(FRONT)SECONDARYAIR

PRESSURETRANSDUCER(REAR)PRIMARY AIR


BLU4617-001, 0.5BLU4517-101, 0.5

VIO4517-101, 0.5

GRN4517-101, 0.5

SEE PTO AND/OR REMOTETHROTTLE SYSTEM DIAGRAMS

(MX ENG ONLY)

OPTIONAL SENSORS W/NAVIGATION PLUS & VITRUAL GUAGES

OPTION SENSOR W/AIR FILTER RESTRICTION GAUGE

CECU 3 (C)

CECU

IPHARNESS

ENGHARNESS

J032

1

3

2

4

J028 15149113034871261025

J033

3

1

2

J034

3

1

2

J035

3

1

2

013

012

011

P006

46

28

15

19

16

J01B

3

1

2

J01A

3

1

2

J00Z

3

1

2

J00Y

3

1

2

J00X G H J K M L B C D E A F

J048 1

J02

1

3

2

4

J01

4

2

3

1

CVSG GAUGE(OIL TEMPERATURE )

1

3

2

4

CVSG GAUGE(FRONT AXLE)

1

3

2

4


7

P127_

3

2

1

P103_

16

19

15

A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV



94524 GRN 0.8

84524 BLU 0.8

REAR AXLETEMPERATUREHARNESS

FRONT DRIVE AXLETEMP SENSOR

DETAIL "C"WITH ONE OPTIONAL DRIVE AXLE TEMP GAUGE FOR MULTIPLE DRIVE AXLES (DUAL/TRIDEM) SENSORINSTALLED ON FIRST DRIVE AXLE.

P01

D

F

B

C

E

A

J01

A

B

A

B

94524 GRN 0.8

84524 BLU 0.8

94525 GRN 0.8

84525 BLU 0.8


DETAIL "D"WITH TWO OPTIONAL DRIVE AXLE TEMP GAUGES FOR TRIDEM DRIVE AXLES SENSORSINSTALLED ON FRONT & CENTER DRIVE AXLES.


REAR DRIVE AXLETEMP SENSOR

P01

D

F

B

C

E

A

J01

A

B

J02

A

B

A

B

A

B

94524 GRN 0.8

84524 BLU 0.8

94533 GRN 0.8

84533 BLU 0.8

94525 GRN 0.8

84525 BLU 0.8


REAR DRIVE AXLETEMP SENSOR

CENTER DRIVE AXLETEMP SENSOR

DETAIL "E"WITH THREE OPTIONAL DRIVE AXLE TEMP GAUGES


P01

D

F

B

C

E

A

J01

A

B

J02

A

B

J03

A

B

A

B

A

B

A

B


AP94-2040


BLU4522-001 0.5

CECU 3 (C)

BLU4585-151, 0.8

VIO4585-151, 0.8

BLU4523-151, 0.8

BLU4518-151, 0.8

VIO4518-151, 0.8

GRN4581-152, 0.8

BLU4524-151, 0.5

BLU4533-151, 0.5

BLU4525-151, 0.5

BLU4523-151, 0.8

BLU4585-151, 0.8

BLU4518-151, 0.8

GRN4536-151, 0.8

BLU4536-151, 0.8

BLU4581-152, 0.8

BLU4581-151, 0.8

BLU4522-151, 0.5

BLU4522-151, 0.5

GRN4520-151, 0.5

BRN4363-151, 0.8

BRN4362-151, 0.8

BRN4361-151, 0.8

ORN4360-151, 1.0

GRN4522-151, 0.5

GRN4500-151, 0.8

GRN0819-151, 0.75

YEL0819-151, 0.75

RED1121-151, 2.0

RED1122-151, 2.0

GRN4518-151, 0.8

GRN4523-151, 0.8

GRN4581-152, 0.8

GRN4585-151, 0.8

GRN4581-151, 0.8

VIO4500-151, 0.8

GRN4523-151, 0.8

GRN4518-151, 0.8

GRN4585-151, 0.8

GRN4581-151, 0.8

GRN4520-151, 0.5

ORN4360-151, 1.0

BLU4581-151, 0.8

BLU4581-152, 0.8

BLU4522-491 0.8

GRN4522-491 0.8

BRN4362-151 0.8

BRN4363-151 0.8

BRN4361-151 0.8

IGNBUS

FOR CHASSIS NODE POWERSEE EXT LIGHTING SYSTEMDIAGRAM P94-1964

NOT APPLICABLE TOTHIS SYSTEM DIAGRAM

CECU

IP HARNESS

BATBUS

CAB PDC

* FUSES ARE ON THE ENGINE SIDE AND CAB SIDE OF THE PDC. "E_" ENGINE SIDE "C_" CAB SIDE

GRN4524-0, 0.8

GRN4525-0, 0.8

GRN4533-0, 0.8

ORN4360-1, 1.0

BRN4361-0, 0.8

BRN4362-0, 0.8

BRN4363-0, 0.8

ORN4361-1, 0.8

ORN4362-1, 0.8

ORN4363-1, 0.8

GRN4520-0, 1.0

BLU4524-0, 1.0

BLU4524-0, 1.0

BLU4525-0, 1.0

BLU4525-0, 1.0

BLU4533-0, 1.0

BLU4533-0, 1.0

BLU4536-151, 0.8

GRN4536-151, 0.8

GRN4500-151, 0.8 BRN4363-0, 0.8

BRN4362-0, 0.8

BRN4361-0, 0.8

CHASSIS NODE

"3RD (C) REAR AXLE TEMP"

"2ND (R) REAR AXLE TEMP"

"1ST (F) REAR AXLE TEMP"

"ANALOG RETURN"

"F AXLE LOCK IND"

"R AXLE LOCK IND"

"FUEL GUAGE 1"

"FUEL GUAGE 2"

"C AXLE LOCK IND"

"AUX TRANS OIL TEMP"

"FUEL FILTER RESTR SIG"

"AMMETER SIGNAL"

"ANALOG SENSOR +5V .1A"

SPLICE BLOCK INFO THE COMMON CIRCUIT FOR SPLICE BLOCKSWILL ALWAYS TERMINATE AT PIN "1" OR PIN "A"ALL OPTIONAL CIRCUITS ARE TERMINATEDRANDOMLY. CIRCUITS SHOWN IN ORDER FOR CLARITY ONLY.ANALOG SENSOR RETURN SPLICE BLOCK.

CHASSISHARNESS

TRANSMISSIONHARNESS

CHASSISHARNESS

REARCHASSISHARNESS

REARCHASSISHARNESS

REARCHASSISHARNESS

GRN4522-151, 0.5

TRANS CASEOIL TEMPSENSOR

MAIN TRANSOIL TEMPSENSOR

"J1939, F-CAN H"

"J1939, F-CAN L"

AUX TRANSOIL TEMPSENSOR

FUEL LEVELSENSOR 1

FUEL LEVELSENSOR 2

FUEL FILTERRESTRICTIONOPT SENSOR

AMMETERSENSOR

PORT C

PORT A

PORT B

RED1121-151, 2.0

RED1122-151, 2.0

"G1 PWR 25A"

"G2 PWR 25A"

SEE J1939SYSTEMDIAGRAM

"TRANSFER CASE OIL TEMP"

CHASSISHARNESS

"MAIN TRANS OIL TEMP"

W/OPTIONAL DRIVE AXLE TEMP GAUGES

W/OPTIONAL REAR AXLE DIFFERENTIALLOCK SWITCHES SEE DETAIL: "F" FOR SINGLE REAR AXLE"G" FOR TANDEM, FORWARD REAR & REAR REAR AXLES"H" FOR TRIDEM, CENTER REAR & REAR REAR AXLES"J" FOR TRIDEM, FORWARD REAR & REAR REAR AXLES"K" FOR TRIDEM, ALL DRIVE AXLESSEE SHEET 6

W/OPTIONAL TRANSMISSIONOIL TEMP GAUGE

W/OPTIONAL TRANSFER CASEOIL TEMP GAUGE

W/OPTIONAL 2ND FUEL LEVEL GAUGE

W/OPTIONAL AUXTRANSMISSION OIL TEMP GAUGE

PORT B

W/OPTIONAL AMMETER& FUEL FILTER RESTRICTION GAUGESEE DETAIL"L" FOR AMMETER ONLY"M" FOR FUEL FILTER RESTRICTION ONLYSEE SHEET 6

BLU 1.0

YEL 1.0

GRN 1.0

CHASSISHARNESS

FUEL FILTERRESTRICTION

JUMPER

P033

8

165

J153

A

B

J154

A

B

P163

A

B

C

P168

A

B

P164

B

A

C

P173

B

A

P161

15

12

4

16

18

21

6

9

P174

D

G

J161

8

P171

F

E

G

H

A

B

C

D

J

K

P176 B E D L C J H K G M F A

P151

A

P172

16

10

13

1

4

P492

B

A

J491

G

D

SUSP/CHASSIS

10 AMP

C_K14_c0 P001.

B22

CHAS PWR G1

25 AMP

E_J2

CHAS PWR G2

25 AMP

E_L2 P152

7

P152

1

P046

A

E

C

B

F

D

J060

K

J

D

C

B

A

H

G

E

F

.S3

S1

J047

E

C

A

F

D

B


J028

21

P162

8

6

P162

5

17

3

P01.

C

B

A

J01.

A

B

C

A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV



BLU4585-151, 0.8

VIO4585-151, 0.8

GRN4585-151, 0.8

"AMMETER SIGNAL"

ANALOG SENSOR RETURNSPLICE BLOCK.SEE SHT 5 ZONE K13

AMMETERSENSOR

PORT B

DETAIL "L"WITH OPTIONAL AMMETER GAUGE ONLY SHOWN WITH AMMETER EXT HARNESS CHASSIS NODE

"AMMETER SENSE PWR"

CHASSISHARNESS

AMMETERJUMPER

94100 GRN

84585 BLU

71930 VIO

P164

B

A

C

P176 K G P162

5

17

3

P01

C

B

A

J01

A

B

C

BLU4518-151, 0.8

BLU4518-151, 0.8

GRN4518-151, 0.8

VIO4518-152, 0.8

"FUEL FILTER RESTR SIG"

ANALOG SENSOR RETURNSPLICE BLOCK.SEE SHEET 5 ZONE K13

FUEL FILTERRESTRICTIONOPT SENSOR

PORT B

VIO4518-152, 0.8 "FUEL FILTER RESTR PWR"

CHASSIS NODE

DETAIL "M"WITH OPTIONAL FUEL FILTER RESTRICTION GAUGE ONLY

BLU 1.0

YEL 1.0

GRN 1.0

CHASSISHARNESS

FUEL FILTERRESTRICTION

JUMPER

P163

A

B

C

P176 K G P162

5

17

3

P01.

C

B

A

J01.

A

B

C

BRN4363-0, 0.8

ORN4363-0, 0.8

REARAXLE LOCKHARNESS

REARREAR AXLEDIFF LOCKSWITCH

DETAIL "F"WITH SINGLE REAR AXLE

J051

A

B

P047

B

D

F

A

C

E AB

BRN4361-0, 0.8

ORN4361-0, 0.8

BRN4363-1, 0.8

ORN43630-1, 0.8


FORWARDREAR AXLEDIFF LOCKSWITCH


DETAIL "G"WITH TANDEMFORWARD REAR REAR AXLES

J049

A

B

P047

B

D

F

A

C

E

J052

A

B

AB

AB

ORN4362-0, 0.8

BRN4362-0, 0.8

BRN4363-0, 0.8

ORN4363-0, 0.8


CENTERREAR AXLEDIFF LOCKSWITCH


DETAIL "H"WITH TRIDEMCENTER REAR & REAR REAR AXLES

J050

A

B

J051

A

B

P047

B

D

F

A

C

E

AB

AB

BRN4361-0, 0.8

BRN4363-0, 0.8

ORN4361-0, 0.8

ORN4363-0, 0.8




DETAIL "J"WITH TRIDEMFORWARD REAR & REAR AXLES

J049

A

B

J051

A

B

P047

B

D

F

A

C

E

AB

AB

ORN4362-0, 0.8

BRN4361-0, 0.8

BRN4362-0, 0.8

BRN4363-1, 0.8

ORN4361-0, 0.8

ORN4363-0, 0.8



CENTERREAR AXLEDIFF LOCKSWITCH


DETAIL "K"WITH TRIDEMALL THREE REAR AXLES

J049

A

B

J050

A

B

J051

A

B

P047

B

D

F

A

C

E


AP94-2040



A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV



POS.NO.

DESCRIPTION COLOR DRIVEN BY

1 EDITABLE #1 AMBER J1939, I-CAN

2 EDITABLE #2 GREEN J1939, I-CAN

3 EDITABLE #3 RED J1939, I-CAN

4 PUMP MODE (PTO) AMBER TWO LINE DIRECT




8 BRAKE AIR RED J1939, I-CAN

9 PARK BRAKE RED J1939, I-CAN

10 BRAKE FAILURE (HYDRAULIC TRUCK AND HYBRIDS) RED J1939, I-CAN

11 TURN LEFT GREEN J1939, I-CAN

12 HIGH BEAM BLUE J1939, I-CAN

13 TURN RIGHT GREEN J1939, I-CAN

14 REFRIGERATOR GREEN SINGLE LINE DIRECT

15 AUTOMATIC TRACTION CONTROL /ANTI-SKID CONTROL AMBER J1939, I-CAN

16 INTER AXLE/DIFF LOCK AMBER J1939, I-CAN

17 CHECK TRANSMISSION AMBER J1939, I-CAN

18 LVD AMBER J1939, I-CAN

19 HILL HOLD AMBER J1939, I-CAN

20 TRAILER ABS AMBER J1939, I-CAN

21 TRACTOR ABS AMBER J1939, I-CAN

22 WAIT TO START AMBER TWO LINE DIRECT

23 DIESEL PARTICULATE FILTER AMBER J1939, I-CAN

24 HIGH EXHAUST TEMPERATURE (HEST) AMBER J1939, I-CAN

25 SEAT BELT RED J1939, I-CAN

26 ENGINE FAN GREEN J1939, I-CAN

27 STOP ENGINE RED J1939, I-CAN

28 MALFUNCTION INDICATOR LIGHT (MIL) AMBER TWO LINE DIRECT

29 CHECK ENGINE AMBER J1939, I-CAN

30 LOW COOLANT AMBER J1939, I-CAN

31 WARNING LAMP (VOLTMETER) RED J1939, I-CAN

32 WARNING LAMP (ENGINE OIL PRESSURE GAUGE) RED J1939, I-CAN

33 WARNING LAMP (ENGINE COOLANT TEMPERATURE GAUGE) RED J1939, I-CAN

34 WARNING LAMP (FUEL GAUGE) RED J1939, I-CAN

35 WARNING LAMP (BRAKE APPLICATION PRESSURE GAUGE) RED J1939, I-CAN

36 WARNING LAMP (PRIMARY AND SECONDARY AIR GAUGE) RED J1939, I-CAN

37 WARNING LAMP (DEF GAUGE) RED J1939, I-CAN

STD OR CUSTOM TELLTALE CARD(STD CARD SHOWN).INSERTED HERE

FOR TELLTAILE FUNCTIONALITY REFER TO USER'S MANUAL

DRIVER PERFORMANCE CENTER

KENWORTH GAUGE CLUSTER

PART NUMBER LOCATION

DETAIL "A"

34252423222120

33

32

26 27 2829

3037

36

35

19

17

18

161514

31

3

2

1

4

5 6 7 8 11 9 12 10 13

8

9


AP94-2040



A

1

B

C

D

E

F

G

H

I

J

K

L

2345678910111213141516

A

B

C

D

E

F

G

H

I

J

K

L

12345678910111213141516

A0

DWGSIZE

TITLE

DRAWING REV



POS.NO.

DESCRIPTION COLOR DRIVEN

1 LOW COOLANT AMBER J1939, I-CAN

2 CHECK ENGINE AMBER J1939, I-CAN

3 REFRIGERATOR GREEN SINGLE LINE DIRECT

4 TURN LEFT GREEN J1939, I-CAN

5 MALFUNCTION INDICATOR LIGHT(MIL) AMBER TWO LINE DIRECT

6 SEAT BELT RED J1939, I-CAN

7 HIGH BEAM BLUE J1939, I-CAN

8 STOP ENGINE RED J1939, I-CAN

9 BATTERY CHARGING SYSTEM RED J1939, I-CAN

10 ENGINE FAN GREEN J1939, I-CAN

11 HIGH EXHAUST TEMPERATURE(HEST) AMBER J1939, I-CAN

12 TURN RIGHT GREEN J1939, I-CAN

13 DIESEL PARTICULATE FILTER AMBER J1939, I-CAN

14 TRAILER ABS AMBER J1939, I-CAN

15 TRACTOR ABS AMBER J1939, I-CAN

16 PARK BRAKE RED J1939, I-CAN

17 BRAKE AIR RED J1939, I-CAN

18 BRAKE FAILURE(HYDRAULIC TRUCK AND HYBRIDS) RED J1939, I-CAN

19 WAIT TO START AMBER TWO LINE DIRECT

20 AUTOMATIC TRACTION CONTROL/ ANTI-SKID CONTROL AMBER J1939, I-CAN







27 WARNING LAMP(ENGINE COOLANT TEMPERATURE) RED J1939, I-CAN

28 WARNING LAMP(DEF) RED J1939, I-CAN

29 WARNING LAMP(FUEL) RED J1939, I-CAN

30 WARNING LAMP(ENGINE OIL PRESSURE) RED J1939, I-CAN

31 WARNING LAMP(PRIMARY AIR) RED J1939, I-CAN

32 WARNING LAMP(SECONDARY AIR) RED J1939, I-CAN

STD OR CUSTOM TELLTALE CARDINSERT HERE (STD CARD SHOWN).

FOR TELLTALE FUNCTIONALITY REFER TO USER'S MANUAL

DRIVER PERFORMANCE CENTER

PETERBILT GAUGE CLUSTER

PART NUMBER LOCATION

DETAIL "B"

910

131211

23 24 25 262221

876

181716 1915 201429

28

27

1 2 3 4 5

30

31

32

8

9


AP94-2040



CONNECTOR INFORMATION FOR DIAGRAM: P94-2040

Documents

Transcript of CONNECTOR INFORMATION FOR DIAGRAM: P94-2040