Confined Space Entry. Safety Through Teamwork “Nothing is so important that it can not be done...
-
Upload
shayna-manners -
Category
Documents
-
view
219 -
download
1
Transcript of Confined Space Entry. Safety Through Teamwork “Nothing is so important that it can not be done...
Confined Space EntryConfined Space Entry
Safety Through Teamwork
“Nothing is so important that it can not be done safely.”
Training Outline
IntroductionOSHA RegulationsGeneral HazardsAtmospheric TestingSafety ProceduresChecklistsBLD 4020Practical Evaluation
Introduction
Confined space definition:Is large enough that an
employee can enter and perform assigned work
Has limited or restricted means for entry or exit
Is not designed for continuous employee occupancy
Introduction
Examples of confined spaces:storage tankspitssilosvatstunnelssewers shaftsexhaust ducts
IntroductionRegulatory Requirements
OSHA- employee safety- permit confined spaces- 29 CFR 1910.146
The employer must assess the workplace to determine if hazards are present that necessitate the use of PPE
Permit Space Hazards
• Hazardous atmosphere (too little or too much oxygen, flammable or toxic air)
• Engulfment• Danger from unexpected movement of
machinery• Electrocution• Heat stress• Becoming wedged into a narrow space and
suffocating
Reducing Risks of HazardsDevelop and use a written Standard Operating
Procedures for confined space rescue teamConduct air monitoring and other tests to
identify and evaluate hazards in each permit space
Ventilate, eliminate, or control the space’s atmospheric hazards before entry into the space
Lock-Out/Tag-Out ensure and place our Lock-out/ Tag out kit on were needed.
Preparation of Permit Space
Post signs and put up barriers to protect entrants from traffic and pedestrians
Blind or disconnect and cap all input lines so that no hazardous materials can enter the space
Empty space of any materials that may be hazardous
Verify breathing safety by air testing
Safety Procedures
Authorized entrants can enter a permit space only after it’s been tested and found safe for entry
The assigned entrant has to know what equipment to use- and how to use it
Once prepared, you want to get in and do the assigned task as quickly and efficiently as possible
Alert the attendant immediately if you recognize a sign or symptom of exposure to a dangerous situation
NFPA
7.1.4 A confined space rescue team shall be made up of a minimum of six individuals for organizations operating at the technician level, and a minimum of four individuals for organizations operating at the operations level.
LEVELS OF RESUCE CERTS.
AWARNESSOPERATIONSTECHNICIAN
We operate at the Technician Level
ASSESMENT OF THE SCENE
(1) Hazards such as engulfment potential, environmental hazards (e.g., chemical, atmospheric, temperature), harmful forms of energy (e.g., electrical, mechanical, movement due to gravity, hydraulic), configuration hazards (e.g., diverging walls, entrapment, obstructions, trip/fall hazards), and so forth
(2) Risk/benefit analysis (body recovery versus rescue) (3) Available/necessary additional resources (4) Establishment of control zones (5) Magnitude of the hazard and isolation procedures (6) Effectiveness of the non-entry or qualifying entry-type
rescue (7) Overall safety of rescue operations (8) Level of rescue response (appropriate for the type of
rescue being attempted) (9) Current and projected status of the planned response (10) Personnel accountability
Site Safety Plan
A site safety plan can also provide useful
information for consideration during size-up and should include the following:
(1) Rescue team notification (2) Acceptable entry conditions for
rescue (3) Hazard identification (4) Risk assessment of hazards (5) Site map
Site Safety Plan
6) Hazard abatement (including control zones, ventilation, and lock-out/tag-out procedures)
(7) Use of buddy system (where applicable)
(8) Communications (e.g., site, rescue attendant to rescue entrant)
(9) Command post (10) Incident management
organizational chart
Site Safety Plan
(11) Standard operating guidelines
(12) Safe work practices (13) Medical assistance (14) Pre-entry safety briefings (15) Pre- and post-entry physicals
(if indicated)
CHECKLIST
CHECKLIST
CONFINED SPACE ENTRY CHECK LIST Rescue Sector
CONFINED SPACE IS 1. LARGE ENOUGH TO ENTER. 2. LIMITED OR RESTRICTED OPENINGS. 3. NOT DESIGNED FOR COMTINUOUS WORKER OCCUPANCY. CALL FOR CONFINED SPACE RESCUE TEAM & EQUIPMENT! CONTACT ATTENDANT (WHO CALLED) YES NO READ ENTRY PERMIT YES NO READ MSDS YES NO WHAT KIND OF WORK IS BEING DONE ? WHAT ARE THE HAZARDS ? IS THIS A RESCUE BODY RECOVERY HOW MANY VICTIMS ? CAN SELF RESCUE BE COMPLETED YES NO SAFETY OFFICER CHECKED ALL LOCK OUT / TAG OUT YES NO MECHANICAL EQUIPMENT BLOCKED OR DISENGAGED YES NO LINES UNDER PRESSURE BEEN BLANKED & BLED YES NO IF NO THEN ACCOMPLISH
CHECK LIST Rescue Sector
OXYGEN LEVEL BETWEEN 19.5% - 23.5% YES NO IF NO USE PROPER PPE READINGS TOP % MIDDLE % BOTTOM % LOWER EXPLOSIVE LIMITS (LEL) < 10% YES NO IF NO USE PROPER PPE READINGS TOP % MIDDLE % BOTTOM % DO NOT ENTER IF LEL IS > 10% UNTIL YOU CAN LOWER IT IF OXYGEN IS NOT NORMAL THAN THE LEL WILL BE OFF TOXIC HAZARD < PERMISSIBLE EXPOSURE LIMIT (PEL) YES NO IF NO USE PROPER PPE READINGS TOP % MIDDLE % BOTTOM % DO RESCUERS NEED SPECIAL PROTECTIVE CLOTHING YES NO IF YES WHAT ? DOES THE AREA NEED VENTILATION YES NO CONTINUOUS ATMOSPHERE MONITORING YES NO IS THE HEIGHT > 5’ YES NO IF YES HARNESS & LIFTING DEVICE REQUIRED WILL RESCUERS & VICTIM NEED DECON YES NO WILL VICTIM NEED FIRST AID, CPR, IMMOBILIZATION, LIFTING DEVICE YES NO WERE RESCUERS BRIEFED ON HAZARDS, EXPOSURE SYMPTOMS, # VICTIMS, & EVACUATION WARNINGS YES NO
Summary
What is a confined spacePermit required spacesChecklistsHow we are going to do itAny questions?Practical stationsPractical Eval.