Clarion Dxz838rmp

Service ManualRDS-EON FM/MW/LW Radio CD/MP3

/WMA/Combination with DVD/MD/CD

Changer/DAB/TV Control

Model

-1- DXZ838RMP

Clarion Co., Ltd.50 Kamitoda, Toda-shi, Saitama 335-8511 JapanService Dept.: 5-66 Azuma, Kitamoto-shi, Saitama 364-0007 JapanTel: +81-48-541-2335 / 2432 FAX: +81-48-541-2703

Published by Service Dept.

298-6040-00 FEB. 2003 X

Printed in P.R.C.

(PE-2565E-A )

SPECIFICATIONSRadio sectionTuning system: PLL synthesizer tuner

Receiving frequencies: FM 87.5 to 108MHz

(0.05MHz steps)

MW 531 to 1602kHz

(9kHz steps)

LW 153 to 279kHz

(3kHz steps)

CD player sectionSystem: Compact disc digital audio

system

Frequency response: 5Hz to 20kHz(+1/-1dB)

Signal to noise ratio: 100dB(1kHz) IHF-A

Dynamic range: 95dB(1kHz)

Harmonic distortion: 0.01%

GeneralOutput power: 4x31W(DIN45324, +B=14.4V)

Power supply voltage: 14.4V DC(10.8 to 15.6V allowable),

negative ground

Power consumption: Less than 15A

Speaker impedance: 4ohm(4ohm to 8ohm allowable)

Auto antenna rated current: 500mA or less

Weight: Source unit 1.6kg

Remote control unit

30g(including battery)

Dimensions(mm): Source unit

178(W)x50(H)x155(D)

Remote control unit

44(W)x110(H)x27(D)

NOTE* We cannot supply PWB with component parts in principle. When a

circuit on PWB has failure, please repair it by component parts

base. Parts which are not mentioned in service manual are not

supplied.

* Only CDs and CD-ROMs having the or mark can be

used in this unit.

Some CDs recorded in CD-R mode may not be usable. Even when

recorded in CD-RW mode, some CDs not be usable.

* Specifications and design are subject to change without notice for

further improvement.

COMPONENTSPE-2565E-ASource unit 1

Mounting bracket 300-7742-00 1

DCP case 335-6035-20 1

Escutcheon(OUT-ES) 370-6038-00 1

Extension lead 854-6362-54 1

Remote control unit RCB-130- 700 1

Battery(SUM-3) 1

Parts bag

Removal key 331-2497-00 2

Rubber spacer 345-3653-20 1

A-lead 850-6681-50 1

Screw 716-0726-01 1

vk

Störungen bei Cd wenn das Gerät kalt ist IC15 und IC18 kälteempfindlich

To engineers in charge of repair or inspecti-

on of our products.Before repair or inspection, make sure to follow the inst-

ructions so that customers and Engineers in charge of

repair or inspection can avoid suffering any risk or injury.1. Use specified parts.

The system uses parts with special safety features against fire

and voltage. Use only parts with equivalent characteristics when

replacing them.

The use of unspecified parts shall be regarded as remodeling for

which we shall not be liable. The onus of product liability (PL) shall

not be our responsibility in cases where an accident or failure is as

a result of unspecified parts being used.

2. Place the parts and wiring back in their original positions after

replacement or re-wiring.

For proper circuit construction, use of insulation tubes, bonding,

gaps to PWB, etc, is involved. The wiring connection and routing to

the PWB are specially planned using clamps to keep away from

heated and high voltage parts. Ensure that they are placed back

in their original positions after repair or inspection.

If extended damage is caused due to negligence during repair, the

legal responsibility shall be with the repairing company.

3. Check for safety after repair.

Check that the screws, parts and wires are put back securely in

their original position after repair. Ensure for safety reasons there

is no possibility of secondary ploblems around the repaired spots.

If extended damage is caused due to negligence of repair, the


4. Caution in removal and making wiring connection to the parts for

the automobile.

Disconnect the battery terminal after turning the ignition key off.

If wrong wiring connections are made with the battery connected,

a short circuit and/or fire may occur.

If extensive damage is caused due to negligence of repair, the


5. Cautions regarding chips.

Do not reuse removed chips even when no abnormality is obse-

rved in their appearance. Always replace them with new ones.

(The chip parts include resistors, capacitors, diodes, transistors,

etc). The negative pole of tantalum capacitors is highly suscepti-

ble to heat, so use special care when replacing them and check

the operation afterwards.

6. Cautions in handling flexible PWB

Before working with a soldering iron, make sure that the iron tip

temperature is around 270 C. Take care not to apply the iron tip

repeatedly (more than three times) to the same patterns. Also take

care not to apply the tip with force.

7. Turn the unit OFF during disassembly and parts replacement.

Recheck all work before you apply power to the unit.

8. Cautions in checking that the optical pickup lights up.

The laser is focused on the disc reflection surface through the lens

of the optical pickup. When checking that the laser optical diode

lights up, keep your eyes more than 30cms away from the lens.

Prolonged viewing of the laser within 30cms may damage your

eyesight.

9. Cautions in handling the optical pickup

The laser diode of the optical pickup can be damaged by electro-

static charge caused by your clothes and body.

Make sure to avoid electrostatic charges on your clothes or body,

or discharge static electricity before handling the optical pickup.

-2-

9-1.Laser diode

The laser diode terminals are shorted for transportation in

order to prevent electrostatic damage.

After replacement, open the shorted circuit. When removing

the pickup from the mechanism, short the terminals by sold-

ering them to prevent this damage.

9-2.Actuator

The actuator has a powerful magnetic circuit. If a magnetic

material is put close to it. Its characteristics will change.

Ensure that no foreign substances enter through the ventila-

tion slots in the cover.

9-3.Cleaning the lens

Dust on the optical lens affects performance. To clean the

lens, apply a small amount of isopropyl alcohol to lens paper

and wipe the lens gently.

CAUTIONSThis appliance contains a laser system and is classified as a

"CLASS 1 LASER PRODUCT". To use this model properly, read

this Owner's Manual carefully and keep this manual for your futu-

re reference. In case of any trouble with this player, please cont-

act your nearest "AUTHORIZED service station". To prevent dir-

ect exposure to the laser beam, do not try to open the enclosure.

USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE

OF PROCEDURES OTHER THAN THOSE SPECIFIED IN THE

OWNER'S MANUAL MAY RESULT IN HAZARDOUS RADIATION

EXPOSURE.

MODEL

Bottom view of source unit

NOTES OF ISO CONNECTOR1. For VW and Audi vehicles, change the position of fuse installation

as shown on the diagram. (Figure 1)

EXTENSION CABLE type

Initial setting of ex-lead

3A

15A

Fuse YellowFuse

Yellow

Yellow

Red Red

Blue/White Blue/White

Green/White Green/White

DXZ838 RMP

-3-

For models 1992 and later For models up to 1991

Figure 1

3. When the Main unit is also connected to an external amplifier,

connect REMOTE on the external amplifier to remote turn on

lead.

Figure 2

*Never let the terminals make contact with the metal

plate parts of the car.

Yellwo

Yellwo

Red

Yellwo

Red

Yellwo

Yellwo

Red RedRemote turn-on

Insulation tape

Insulate the terminal

Blue/White Blue/White

2. When the car stereo is installed in 1998 and later Volkswagen

models, remove the auto antennal leads (Blue/White). Be

sure to insulate both the ISO connector side terminal and the

main unit side terminal with insulation tape, respectively.

(Figure 2)

TROUBLESHOOTING

Problem Cause MeasureThe microprocessor has

malfunctioned due to noise, etc.

Turn off the power, then press the

[RELEASE]

the DCP.

DCP.

Press the reset button with a thin

rod.

Nothing happens when buttons

are pressed.

Display is not accurate.

button and remove Reset button

ERROR DISPLAYSIf an error occurs, one of the following displays is displayed. Take the measures described below to eliminate the problem.

Error Display Cause Measure

A DISC is loaded upside-down inside the CD deck anddoes not play.

Eject the disc then reload it properly.

ERROR 2 A DISC inside the CD changer is not loaded. This is a failure of CD changer’s mechanism.

ERROR 3 A DISC inside the CD changer cannot be played due toscratches, etc.

Replace with a non-scratched, non-warped disc.

ERROR 6 A DISC inside the CD changer cannot be played beca-use it is loaded upside-down.


ERROR 2 An MD inside the MD changer is not loaded. This is a failure of MD changer’s mechanism.

ERROR 3 An MD inside the MD changer cannot be played due to

scratches, etc.

Replace with a non-scratched, non-warped disc.

ERROR 6 An MD inside the MD changer cannot be played be-

cause it is loaded upside-down.


If an error display other than the ones described above appears, press the reset button.

ERROR H Displayed when the temperature in the MD changer is

too high and playback has been stopped automatically.

Lower the surrounding temperature and wait for

a while to cool off MD changer.

A DISC is caught inside the CD deck and is not ejected. This is a failure of CD deck's mechanism.ERROR 2

ERROR 3 A DISC cannot be played due to scratches, etc. Replace with a non-scratched, non-warped disc.

Displayed when a non-recorded MD is loaded in the

MD changer.

Load a pre-recorded MD in the MD changer.

CD/MP3/ WMA

CD

changer

MD

changer

ERROR 3 A DISC cannot be played due to scratches, etc. Retry or replace with a non-scratched, non-warped

disc.

ERROR 6 A DISC inside the DVD changer cannot be played be-

cause it is loaded upside-down.


ERROR P Parental level error. Set the correct Parental level.

ERROR 2 A DISC inside the DVD changer cannot be played. This is a failure of DVD mechanism.

Region code error. Eject the disc and replace correct region code

disc.

DVD

changer

ERROR R

Mode

ERROR 6

DXZ838 RMP

-4pin 1 : PLL CE : O : The chip enable signal output to the PLL IC. pin 57 : VOL STB : O : The strobe pulse output to the volume IC.pin 2 : TIME BASE : IN : Time base pulse input. pin 58 : VOL DT : O : The serial data output to the volume IC.pin 3 : CD SBSY : IN : The sub Q data request command input fr- pin 59 : VOL CK : O : The clock pulse output to the volume IC. om the CD IC. pin 60 : VCC : - : Positive supply voltage.pin 4 : NU : - : Not in use. pin 61 : CATS LED : O : CATS LED drive output.pin 5 : NU : - : Not in use. pin 62 : VSS : - : Negative supply voltage.pin 6 : BYTE : IN : Connect to the ground. pin 63 : MOTOR REM : O : Power supply ON signal output for the slo-pin 7 : CN VSS : IN : Connect to the ground. pe mechanism motor.pin 8 : INITIAL 1 : IN : The destination setting terminal. Refer Ta- pin 64 : SLOPE MTR- : O : The slope motor control signal output. ble 2. pin 65 : SLOPE MTR+ : O : The slope motor control signal output.pin 9 : INITIAL 2 : IN : The destination setting terminal. Refer Ta- pin 66 : SLOPE V CNT : O : The slope voltage control signal output. ble 2. pin 67 : OPEN POSI : IN : The open position detect signal input.pin 10 : RESET : IN : Reset signal input. pin 68 : NU : - : Not in use.pin 11 : X OUT : O : Crystal connection. pin 69 : CLOSE POSI : IN : The close position detect signal input.pin 12 : VSS : - : Negative supply voltage. pin 70 : KEY ILL REM : O : Key illumination ON signal output.pin 13 : X IN : IN : Crystal connection. pin 71 : 5V REM : O : 5V power supply ON signal output.pin 14 : VCC : - : Positive supply voltage. pin 72 : AMP REM DT : IN : Remote controller wire short detection.pin 15 : NMI : IN : Connect to the ground. pin 73 : RDS CLK : IN : RDS clock pulse input.pin 16 : ACC DET : IN : ACC detection signal input. pin 74 : SYS MUTE : O : System muting signal output.pin 17 : BU DET : IN : Backup detection signal input. pin 75 : LINE MUTE : O : The line mute signal output.pin 18 : KEY INT : IN : Key interrupting signal input. pin 76 : AMP MUTE : O : Muting signal output to the Audio Power A-pin 19 : 27pinConnect : IN : Connect to pin 27. mplifier.pin 20 : SPEED SEL 1 : O : The time constant select signal output for pin 77 : SYS ACC : O : ACC detect signal output. the speed pulse counter. pin 78 : AUTO ANT : O : Motor antenna control signal output.pin 21 : SPEED SEL 1 : O : The time constant select signal output for pin 79 : PHONE INT : IN : The telephone interrupt signal input. the speed pulse counter. pin 80 : NAVI MUTE : O : Muting signal output to suppress the noise pin 22 : BEEP OUT : O : Beep out. at Navigation sound interrupting.pin 23 : NU : - : Not in use. pin 81 : RDS TEST ST : O : Outputting "H" without the test mode.pin 24 : CLK REF : O : Reference clock pulse output. pin 82 : MUTE SPD UP : O : Station detection speed up command out-pin 25 : DCP DET : O : DCP detection signal output. put for RDS.pin 26 : PULSE DIMM : O : Dimmer pulse output for LCD back light. pin 83 : RDS DATA : IN : RDS serial data input.pin 27 : IE BUS RX : IN : IE Bus serial data input. pin 84 : NOISE DCHG : O : RDS noise discharge signal output.pin 28 : IE BUS TX : O : IE Bus serial data output. pin 85 : RDS MUTE : O : RDS mute signal output.pin 29 : DSP INIT RST : O : The reset signal output to DSP IC. pin 86 : ST SD : IN : At receiving the FM station, this port dete-pin 30 : DSP RST : O : Reset pulse output to the DSP IC. cts the stereo signal. At seeking or scanni-pin 31 : AUDIO SEL 1 : O : The select signal output to the audio sign- ng, this port detects the station detection al input selector. Refer Table 1. signal.pin 32 : AUDIO SEL 2 : O : The select signal output to the audio sign- pin 87 : KEY AD : IN : Input terminal of A/D converter for Key ju- al input selector. Refer Table 1. dgment.pin 33 : DSP SO : O : Serial data output to the DSP IC. pin 88 : S METER : IN : The input terminal of internal A/D convert-pin 34 : DSP SI : IN : Serial data input from the DSP IC. er to monitor the radio field strength.pin 35 : DSP SCK : O : The clock pulse output to DSP IC. pin 89 : NOISE 1 : IN : Input terminal of the internal ADC to sense pin 36 : DSP RDY : IN : Ready signal input from the DSP IC. the RDS-noise-level.pin 37 : DSP RQ : O : Request signal output to the DSP IC. pin 90 : W ILL Amber : O : The amber LED control signal output.pin 38 : CD ZMT CUT : O : Zero cross mute cutting signal output. pin 91 : W ILL Green : O : The green LED control signal output.pin 39 : DSP S MUTE : O : Soft muting starting signal output to the D- pin 92 : AMP REM OUT : O : Amplifier ON signal output terminal. SP IC. pin 93 : DIMMER IN : IN : Voltage detector input terminal for Autom-pin 40 : LD MUTE : O : Muting signal output to the CD mechanism. atic Dimmer.pin 41 : LD CONT : I/O : Communication line with the CD mechani- pin 94 : A VSS : - : Analog ground. sm. pin 95 : ILL DET : IN : Illumination ON signal input.pin 42 : CD TR A : IN : The photo sensor signal input from the CD pin 96 : Vref : - : Reference voltage. mechanism. pin 97 : A VCC : - : Positive supply voltage for the internal an-pin 43 : CD TR B : IN : The photo sensor signal input from the CD alog section. mechanism. pin 98 : PLL SI : IN : Serial data input from the PLL IC.pin 44 : CD CHK SW : IN : CD disc chucking signal input. pin 99 : PLL SO : O : Serial data output to the PLL IC.pin 45 : CD SSTOP : IN : At loading, detects the chucking. And next, pin100 : PLL SCK : O : The clock pulse output to the PLL IC. detects the inside limit of the pick up position. pin 46 : CD RESET : O : The reset pulse output to the CD IC. pin 47 : CD CCE : O : The chip enable signal output to the CD IC. pin 48 : CD BU CK : O : CD IC clock pulse output. pin 49 : CD BUS 3 : I/O : The data bus. pin 50 : CD BUS 2 : I/O : The data bus. pin 51 : CD BUS 1 : I/O : The data bus. pin 52 : CD BUS 0 : I/O : The data bus. pin 53 : CD 5V : O : Power supply control signal output for the CD IC / DAC IC. "H"= ON. pin 54 : CD 8V : O : Power supply control signal output for the motor / photo IC. "H"= ON. pin 55 : AUDIO SEL 3 : O : The select signal output to the audio signal input selector. Refer Table 1. pin 56 : BUS I/O : O : The audio signal select command output f- or Ce-NET.

-

1.Terminal Description

EXPLANATION OF IC:052-3385-00 M30626MHP-5Y2GP Main System controller

DXZ838 RMP

pin 1 : NU : - : Not in use. interface-receiver.pin 2 : TIME BASE : IN : Time base pulse input. pin 57 : DIG RESET : O : The reset pulse output.pin 3 : REMOCON : IN : Remote controller signal input terminal. pin 58 : DAC DATA : O : The serial data output to DAC.pin 4 : NU : - : Not in use. pin 59 : DAC CLK : O : The clock pulse output to DAC.pin 5 : SPEED PULSE : IN : The speed pulse input. pin 60 : VCC : - : Positive supply voltage.pin 6 : BYTE : IN : The data length selection(8bit/16bit). pin 61 : DAC SCAN : O : The chip select signal output to DAC.pin 7 : CN VSS : IN : Connect to VSS. pin 62 : VSS : - : Negative supply voltage.pin 8 : JOG CW : IN : Jog key signal input. pin 63 : OPEN POSI : IN : The open position detect signal input.pin 9 : JOG CCW : IN : Jog key signal input. pin 64 : NU : - : Not in use.pin 10 : RESET : IN : Reset signal input. pin 65 : ST SD : IN : At receiving the FM station, this port dete-pin 11 : X OUT : O : Crystal connection. cts the stereo signal. At seeking or scanni-pin 12 : VSS : - : Negative supply voltage. ng, this port detects the station detection pin 13 : X IN : IN : Crystal connection. signal.pin 14 : VCC : - : Positive supply voltage. pin 66 : NOISE DCHG : O : RDS noise discharge signal output.pin 15 : NU : - : Not in use. pin 67 : MUTE SPD UP : O : Station detection speed up command out-pin 16 : ACC DET : IN : ACC detection signal input. put for RDS.pin 17 : BU DET : IN : Backup detection signal input. pin 68 : RDS TEST SD : O : For the test.pin 18 : KEY INT : IN : Key interrupting signal input. pin 69 : RDS MUTE : O : RDS mute signal output.pin 19 : 27pin connect : IN : Connect to 27pin. pin 70 : RDS DATA : IN : RDS serial data input.pin 20 : MOTOR+ : O : The control signal output to the motor. pin 71 : CLOSE POSI : IN : The close position detect signal input.pin 21 : MOTOR- : O : The control signal output to the motor. pin 72 : DIG 5V : O : The ON signal output to the power supply pin 22 : BEEP : O : Beep out. section.pin 23 : MOTOR REM : O : Motor power ON signal output. pin 73 : RDS CLK : IN : RDS clock pulse input.pin 24 : DIRREF : O : Sub clock pulse output to the digital-audio- pin 74 : E VOL CLK : O : Clock pulse output to the volume IC.

interface-receiver. pin 75 : E VOL DATA : O : The serial data output to the volume IC.pin 25 : CATS LED : O : CATS LED drive output. pin 76 : BUS IN/OUT : O : The audio signal control for Ce-NET.pin 26 : NU : - : Not in use. pin 77 : LINE MUTE : O : The line mute signal output.pin 27 : IE BUS RX : IN : IE Bus serial data input. pin 78 : AMP MUTE : O : Muting signal output to the Audio Power A-pin 28 : IE BUS TX : O : IE Bus serial data output. mplifier.pin 29 : NU : - : Not in use. pin 79 : NAVI MUTE : O : Muting signal output to suppress the noise pin 30 : NU : - : Not in use. without Navigation sound interrupting.pin 31 : NU : - : Not in use. pin 80 : SYS MUTE : O : System muting signal output.pin 32 : NU : - : Not in use. pin 81 : PHONE INT : IN : The telephone interrupt signal input.pin 33 : LCD SO : O : The serial data output to the LCD driver. pin 82 : ILL DET : IN : Illumination ON signal input.pin 34 : LCD SI : IN : The serial data input from the LCD driver. pin 83 : AMP REM DT : IN : Remote controller wire short detection.pin 35 : LCD CLK : O : The clock pulse output to the LCD driver. pin 84 : NU : - : Not in use.pin 36 : LCD KEY REQ : O : LCD Key request signal output. pin 85 : AUTO ANT : O : Motor antenna control signal output.pin 37 : LCD CS : O : Chip select signal output to LCD. pin 86 : 5V REM : O : ON signal output to the 5V power supply.pin 38 : NU : - : Not in use. pin 87 : NOISE : IN : The noise level for RDS.pin 39 : NU : - : Not in use. pin 88 : S METER : IN : The input terminal of internal A/D convert-pin 40 : MP3 SRQ : IN : MP3 request signal input. er to monitor the radio field strength.pin 41 : MP3 CS : O : MP3 chip selection signal output. pin 89 : KEY AD : IN : Input terminal of A/D converter for Key ju-pin 42 : MP3 WP : O : MP3 wakeup signal output. dgment.pin 43 : MP3 RESET : O : MP3 reset signal output. pin 90 : DIMMER IN : IN : The automatic dimmer detection.pin 44 : NU : - : Not in use. pin 91 : DISP +B : O : The ON signal output to the power supply pin 45 : INIT 1 : IN : The initial setting input. section.pin 46 : INIT 2 : IN : The initial setting input. pin 92 : AMP REM : O : The control signal output to internal audio pin 47 : FIL CONT 1 : O : The cut off control signal output to the filter. power amplifier.pin 48 : FIL CONT 2 : O : The cut off control signal output to the filter. pin 93 : SYS ACC : O : ACC detect signal output.pin 49 : PLL CE : O : The chip enable signal output to the PLL IC. pin 94 : A VSS : - : Analog ground.pin 50 : PLL SCK : O : The clock pulse output to the PLL IC. pin 95 : OFFSET DET : IN : The emergency signal input from the pow-pin 51 : PLL SI : IN : Serial data input from the PLL IC. er IC.pin 52 : PLL SO : O : Serial data output to the PLL IC. pin 96 : Vref : - : Reference voltage.pin 53 : VARI SCL : O : Variable color clock output. pin 97 : A VCC : - : Positive supply voltage for the internal an-pin 54 : VARI SDA : O : Variable color serial data output. alog section.pin 55 : DIR EMPI : IN : The emphasis data input for the digital-au- pin 98 : MP3 SI : IN : MP3 serial data input.

dio-interface-receiver. pin 99 : MP3 SO : O : MP3 serial data output.pin 56 : DIR ERROR : IN : The error flag input from the digital-audio- pin100 : MP3 SCK : O : MP3 clock output.

ADJUSTMENTFM section

Item Procedure Measuringinstrument

S-meter 1.Input the 98.1MHz/30dBu/400Hz(main90%+pilot10%)signal. SG2.Turn on the power and press the CD PLAY button & PRESET No.6 button at the same time for about 2 seconds.(TEST MODE)3.Adjust the reading of LCD display to [24---- ](24+2/-2) by VR101.4.Push the CD PLAY button & PRESET No.6 button at the same time for 2 seconds once again or do power off to cancel the TEST MODE.

- -

BLOCK DIAGRAM

bit

DXZ838 RMP5

-6-

EXPLODED VIEW PARTS LIST:DCP section

DXZ838 RMP

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY1 DCP-423-700 DCP ASSY 1 1-31 347-6980-00 DOUBLE FACE 2

1-1 373-1001-03 DIAL CVR 1 1-32 347-6978-00 DOUBLE FACE 11-2 371-5736-04 FACE PANEL 1 1-33 347-6988-00 DOUBLE FACE 11-3 370-6030-01 ESCUTCHEON 1 1-34 347-6976-00 SHADE 11-4 380-5553-00 KNOB 1 1-35 345-5308-00 CUSHION 21-5 345-5228-00 RUBBER RING 1 1-36 345-5307-00 CUSHION 21-6 380-5552-00 INNER KNOB 1 1-37 345-5316-00 CUSHION 21-7 382-6619-01 BUTTON(FF/FB) 1 1-38 347-6977-00 COVER FILM 11-8 382-6620-01 BUTTON(ENT/1) 1 1-39 716-3443-01 SCREW 21-9 382-6621-01 BUTTON(2) 1 1-40 716-0872-01 PAD SCREW 5

1-10 382-6622-01 BUTTON(3) 1 1-41 716-0872-12 PAD SCREW 41-11 382-6623-01 BUTTON(4) 1 1-42 051-6057-00 IC 11-12 382-6679-01 BUTTON(5) 1 1-43 331-3557-00 LCD CVR 11-13 382-6680-01 BUTTON(6/P/A) 1 1-44 379-1256-50 INDICATOR 11-14 382-6624-04 BUTTON(T/D/I) 1 1-45 347-6984-00 FILM 11-15 335-6902-00 ILLUMI PLATE 1 1-46 331-3620-00 LCD CVR 11-16 382-6626-02 BUTTON(TA) 1 1-47 379-1258-10 INDICATOR 11-17 382-6650-00 BUTTON(COLOR) 1 1-48 345-5310-00 RUBBER CONNECTOR 11-18 382-6617-01 BUTTON(BEQ) 1 1-49 347-6983-00 FILM 11-19 382-6625-01 BUTTON(EJECT) 1 1-50 335-6878-00 ILLUMI PLATE 11-20 382-6618-01 BUTTON(A-M) 1 1-51 347-6982-00 REFLECTOR 11-21 382-6616-00 BUTTON(FNC/BND) 1 1-52 335-6877-00 LCD HOLDER 11-22 382-6628-01 BUTTON(RELEASE) 1 1-53 076-0708-02 PLUG 21-23 750-6720-00 SPRING 1 1-54 016-9900-85 ENCODER-SW 11-24 335-6901-00 ILLUMI PLATE 1 1-55 076-0647-00 PLUG 11-25 060-4017-90 IR-RECEIVE 1 1-56 039-2305-01 SWITCH PWB 11-26 335-6900-00 ILLUMI PLATE 1 (WITHOUT COMPONENT)1-27 335-6899-00 REAR CVR 1 1-57 013-6312-50 SWITCH 151-28 331-3576-00 SCREW PLATE 2 1-58 013-6507-50 SWITCH 51-29 347-6979-00 DOUBLE FACE 1 1-59 001-7072-90 DIODE 51-30 378-0537-00 BADGE 1

-7-DXZ838 RMP

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY1 716-1715-02 SCREW(M2) 10 21 347-6527-00 CUSHION 12 074-1278-01 OUTLET SOCKET 1 22 750-3457-00 SPRING 13 347-6528-00 INSULATOR 1 23 291-0102-00 STICKER 14 039-1862-00 PWB 1 24 345-8701-00 CUSHION 1

(WITHOUT COMPONENT) 25 345-8265-00 CUSHION 15 331-3115-00 DCP HOLDER 1 26 346-0150-02 LEATHER SHEET 16 335-6903-00 ARM COVER 1 27 716-0872-00 PAD SCREW(M1.7x5) 47 335-6904-00 ARM COVER 1 28 750-3304-20 SPRING 18 716-1468-20 SCREW(M2x2.5) 10 29 854-4380-01 EX-LEAD 19 335-6506-00 HOOK 1 30 309-0772-01 FRONT PLATE 1

10 750-3431-02 SPRING 1 31 613-0719-00 ARM-GEAR 111 341-1736-00 SHAFT 1 32 750-3432-00 SPRING 112 335-6499-00 CN-CVR 1 33 613-0720-00 HUS-GEAR 113 370-5935-05 INNER-ES 1 34 746-0768-20 WASHER( 1.0/t0.5) 114 331-3117-01 LEVER-UP 1 35 613-0717-00 INPUT GEAR 115 331-3118-01 LEVER-LO 1 36 634-0023-00 MOTOR ASSY 116 335-6505-00 ILLUMI PLATE 1 37 750-3303-20 SPRING 117 331-3119-00 LEVER-LO 1 38 347-6275-00 FILM 118 331-3120-00 LEVER-UP 1 39 946-0079-01 GEAR BOX ASSY 119 716-1758-00 PAD SCREW(M2x5) 2 40 947-0513-02 T-LIM GEAR ASSY 120 341-1740-00 ROLLER 1

Greaseapplication

Note)Grease uses FLOIL G-31SB.

Inner-Escutcheon section

-8-

Main section

DXZ838 RMP

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY1 347-7018-00 INSULATOR 1 20 313-1651-21 HEAT SINK 12 335-0833-01 LEAD HOLDER 1 21 313-1715-20 HEAT SINK 13 074-1106-12 OUTLET SOCKET 2 22 313-1845-00 HEAT SINK 14 880-2090C TUNER 1 23 313-1844-00 HEAT SINK 15 076-0313-02 PLUG 1 24 013-7106-00 DETECTOR SWITCH 16 331-2869-00 SHIELD CASE 1 25 331-3378-00 SW-HOLDER 17 013-5102-00 SLIDE SWITCH 1 26 331-2255-20 IC HOLDER 18 013-6100-00 SWITCH 1 27 855-5480-50 RCA PIN CORD 19 042-0576-00 DOUBLE LAYER C 1 28 855-5424-50 RCA PIN CORD 1

10 051-2051-00 IC 1 29 731-3006-80 TAPTIGHT(M3x6) 111 074-1214-00 OUTLET SOCKET 1 30 714-3006-81 MECHINE SCREW(M1.7x5) 412 074-1194-00 OUTLET SOCKET 1 31 731-3008-87 TAPTIGHT(M3x8) 213 092-4000-51 ANT RECEPT 1 32 039-2304-00 MAIN PWB 114 101-0941-00 TRANSISTOR 1 (WITHOUT COMPONENT)15 103-2012-00 TRANSISTOR 1 33 076-0659-12 PLUG 216 102-3420-00 TRANSISTOR 1 34 039-2306-00 SUB PWB 117 305-0274-01 SIDE CVR 1 (WITHOUT COMPONENT)18 305-0275-00 SIDE CVR 1 35 001-7062-90 DIODE 119 307-0616-03 REAR CVR 1 36 074-1198-68 OUTLET SOCKET 1

-9-DXZ838 RMP

ELECTRICAL PARTS LISTMain PWB section (B1)

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONBL 1 880-2090C TUNER C 113 043-0506-50 0.1uF C 286 166-2211-50 50V 220pFC 1 168-2232-55 25V 0.022uF C 114 043-0506-50 0.1uF C 287 168-1042-78 25V 0.1uFC 2 163-4753-55 35V 4.7uF C 115 043-0506-50 0.1uF C 288 163-2273-25 10V 220uFC 4 163-1053-65 50V 1uF C 116 043-0506-50 0.1uF C 301 163-2263-15 6.3V 22uFC 5 168-1832-55 25V 0.018uF C 121 163-1063-35 16V 10uF C 302 163-2263-15 6.3V 22uFC 6 168-1832-55 25V 0.018uF C 122 163-1063-35 16V 10uF C 303 163-2263-35 16V 22uFC 7 183-4763-37 16V 47uF C 123 163-1063-35 16V 10uF C 304 163-1063-35 16V 10uFC 8 168-2232-55 25V 0.022uF C 124 163-1063-35 16V 10uF C 305 163-1063-35 16V 10uFC 9 168-2232-55 25V 0.022uF C 125 166-4711-50 50V 470pF C 306 163-2263-15 6.3V 22uFC 10 168-6822-55 50V 6800pF C 126 166-4711-50 50V 470pF C 307 163-2263-15 6.3V 22uFC 11 042-0631-50 10V 100uF C 127 166-4711-50 50V 470pF C 308 163-1063-35 16V 10uFC 12 042-0631-50 10V 100uF C 128 166-4711-50 50V 470pF C 309 163-1063-35 16V 10uFC 13 168-1032-55 50V 0.01uF C 129 166-4711-50 50V 470pF C 310 163-1063-35 16V 10uFC 16 168-1042-78 25V 0.1uF C 130 166-4711-50 50V 470pF C 311 163-1063-35 16V 10uFC 17 168-1222-55 50V 1200pF C 131 166-4711-50 50V 470pF C 312 163-1063-35 16V 10uFC 18 163-1053-65 50V 1uF C 132 166-4711-50 50V 470pF C 313 163-1063-35 16V 10uFC 19 168-8222-55 50V 8200pF C 133 168-1022-55 50V 1000pF C 314 168-4732-78 25V 0.047uFC 20 163-4763-15 6.3V 47uF C 201 042-0545-00 16V 2200uF C 315 168-4732-78 25V 0.047uFC 22 166-1011-50 50V 100pF C 202 172-2231-15 50V 0.022uF C 316 163-2253-65 50V 2.2uFC 23 166-1011-50 50V 100pF C 203 042-0563-71 16V 100uF C 317 163-2253-65 50V 2.2uFC 24 166-3311-50 50V 330pF C 204 183-2263-37 16V 22uF C 318 163-1063-35 16V 10uFC 25 166-1501-50 50V 15pF CH C 205 168-4732-78 25V 0.047uF C 319 168-1042-78 25V 0.1uFC 26 166-1801-50 50V 18pF CH C 206 168-1042-78 25V 0.1uF C 320 163-1063-35 16V 10uFC 28 168-3332-78 25V 0.033uF C 210 163-2263-15 6.3V 22uF C 321 163-2253-65 50V 2.2uFC 29 168-2232-55 25V 0.022uF C 211 163-2263-35 16V 22uF C 322 163-2253-65 50V 2.2uFC 55 166-2201-50 50V 22pF CH C 216 182-1073-35 16V 100uF C 323 163-1063-35 16V 10uFC 66 166-2201-50 50V 22pF CH C 222 183-4763-37 16V 47uF C 324 163-1063-35 16V 10uFC 67 168-1032-55 50V 0.01uF C 223 168-2232-55 25V 0.022uF C 325 163-1063-35 16V 10uFC 68 168-1022-55 50V 1000pF C 224 172-4731-15 0.047uF C 326 168-1042-78 25V 0.1uFC 101 178-4742-78 25V 0.47uF C 230 042-0631-50 10V 100uF C 327 168-1042-78 25V 0.1uFC 102 178-4742-78 25V 0.47uF C 241 183-1063-37 16V 10uF C 328 168-1042-78 25V 0.1uFC 103 178-4742-78 25V 0.47uF C 243 042-0631-50 10V 100uF C 332 163-1063-35 16V 10uFC 104 178-4742-78 25V 0.47uF C 245 168-1042-78 25V 0.1uF C 333 163-1063-35 16V 10uFC 106 042-0560-84 16V 47uF C 279 183-1073-17 6.3V 100uF C 334 163-1063-35 16V 10uFC 107 042-0560-56 50V 3.3uF C 280 042-0416-60 25V 10uF TAN C 335 163-1063-35 16V 10uFC 108 042-0560-63 16V 22uF C 281 042-0452-81 10V 220uF C 337 163-2253-65 50V 2.2uFC 109 043-0506-50 0.1uF C 282 042-0631-50 10V 100uF C 338 163-2253-65 50V 2.2uFC 110 043-0506-50 0.1uF C 283 042-0631-50 10V 100uF C 350 168-1042-78 25V 0.1uFC 111 043-0506-50 0.1uF C 284 168-2232-55 25V 0.022uF C 351 168-1032-55 50V 0.01uFC 112 043-0506-50 0.1uF C 285 168-1042-78 25V 0.1uF C 353 042-0398-53 16V 3.3uF TAN

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY37 013-7206-50 DETECTOR SWITCH 1 50 347-5918-00 INSULATOR 138 074-1138-70 OUTLET SOCKET 1 51 716-0717-10 SCREW 239 347-6215-00 SPACER FILM 1 52 731-3006-80 TAPTIGHT(M3x6) 740 286-6176-00 SETPLATE 1 53 714-2603-80 MECHINE SCREW(M2.6x3) 741 290-7672-00 LABEL 1 54 816-2626-50 FLAT CABLE 142 304-0460-01 LOWER CVR 1 55 780-2005-00 SCREW(M2x5) 243 303-0472-00 UPPER CVR 1 56 331-2744-00 STOPPER 144 331-3581-00 MECH BRKT 1 57 347-6245-00 FILM 145 331-3324-00 MECH BRKT 1 58 345-8701-00 CUSHION 146 929-0240-81 CD MECH MODULE 1 59 347-6536-00 PROTECT SHEET 147 345-3799-20 RUBBER PART 8 60 345-5318-00 CUSHION 148 347-6821-00 SPACER FILM 2 61 347-7017-00 DOUBLE FACE 149 347-6705-00 INSULATOR 1

- -10DXZ838 RMP

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONC 354 168-1042-78 25V 0.1uF C 802 166-8211-50 50V 820pF IC 101 051-2051-00 LA47506C 356 168-1042-78 25V 0.1uF C 803 166-6811-50 50V 680pF IC 220 051-3201-90 AN77L06C 357 042-0416-54 16V 10uF TAN C 804 168-1032-55 50V 0.01uF IC 230 051-1014-08 TA7291FC 358 042-0416-54 16V 10uF TAN C 805 168-2232-55 25V 0.022uF IC 280 051-3605-90 NJM2360AC 359 168-1042-78 25V 0.1uF C 807 163-2253-65 50V 2.2uF IC 301 051-5020-90 M61508FPC 360 042-0397-50 16V 1uF TAN C 808 166-3311-50 50V 330pF IC 302 051-3034-90 NJM4558VC 361 168-1022-55 50V 1000pF C 809 166-5611-50 50V 560pF IC 303 051-7232-08 74VHC4066C 362 168-1042-78 25V 0.1uF C 810 166-4701-50 50V 47pF CH IC 304 051-6327-08 LC89051VC 401 042-0563-71 16V 100uF C 811 166-5601-50 50V 56pF CH IC 305 051-6370-08 AK4380C 415 168-4732-78 25V 0.047uF C 812 163-4763-15 6.3V 47uF IC 401 051-5830-90 UPD5701C 416 168-4732-78 25V 0.047uF C 813 168-1042-78 25V 0.1uF IC 406 051-3034-90 NJM4558VC 417 163-1063-35 16V 10uF C 904 168-1032-55 50V 0.01uF IC 407 051-3034-90 NJM4558VC 418 163-1063-35 16V 10uF C 905 168-1032-55 50V 0.01uF IC 408 051-3034-90 NJM4558VC 419 163-1063-35 16V 10uF C 907 168-1032-55 50V 0.01uF IC 602 051-6600-38 CA0008AMC 420 163-1063-35 16V 10uF C 910 166-1011-50 50V 100pF IC 604 052-3385-00 M16C/62PC 421 163-1063-35 16V 10uF C 911 166-1011-50 50V 100pF IC 605 051-5437-08 S-80821ANMPC 422 163-1063-35 16V 10uF C 930 168-1042-78 25V 0.1uF IC 606 051-0869-55 NJM2103MC 423 163-1063-35 16V 10uF C 931 168-4722-55 50V 4700pF IC 801 051-3034-90 NJM4558VC 424 163-1063-35 16V 10uF D 101 001-2403-90 MIF60 IC 802 051-4607-90 SAA6581TC 430 163-1063-35 16V 10uF D 102 001-2403-90 MIF60 IC 901 051-1964-08 TC7S14FC 439 168-2222-55 50V 2200pF D 103 001-2403-90 MIF60 J 201 074-1214-00 OUTLET SOCKETC 440 168-2222-55 50V 2200pF D 104 001-2403-90 MIF60 J 601 074-1194-00 OUTLET SOCKETC 441 168-2222-55 50V 2200pF D 105 001-2403-90 MIF60 J 602 074-1198-68 OUTLET SOCKETC 442 168-2222-55 50V 2200pF D 106 001-2403-90 MIF60 J 603 074-1138-70 OUTLET SOCKETC 443 168-2222-55 50V 2200pF D 107 001-2403-90 MIF60 J 604 076-0313-02 PLUGC 444 168-2222-55 50V 2200pF D 108 001-2403-90 MIF60 L 1 010-2275-53 220uHC 445 168-1032-55 50V 0.01uF D 201 001-0592-00 RM4Z L 52 010-4046-00 30uHC 446 168-1032-55 50V 0.01uF D 203 001-0504-46 HZS9B2L L 101 010-8026-00 COILC 447 168-1032-55 50V 0.01uF D 211 001-0516-90 MA111 L 201 010-2285-58 BLM21A102FPBC 448 168-1032-55 50V 0.01uF D 212 001-0516-90 MA111 L 211 010-3407-59 5.6uHC 449 168-1042-78 25V 0.1uF D 221 001-0466-90 S5688B L 280 010-3406-66 22uHC 450 163-2273-25 10V 220uF D 222 001-0466-90 S5688B L 281 010-3406-66 22uHC 451 163-1073-15 6.3V 100uF D 223 001-0516-90 MA111 L 282 010-6003-03 270uHC 456 163-1063-35 16V 10uF D 225 001-0466-91 S5688G L 283 010-2285-56 BLM21B222SC 457 163-1063-35 16V 10uF D 226 001-0466-91 S5688G L 301 010-3406-66 22uHC 605 042-0505-80 25V 1uF D 227 001-0516-90 MA111 L 302 010-3406-66 22uHC 606 168-4732-78 25V 0.047uF D 229 001-0466-90 S5688B L 305 010-2285-58 BLM21A102FPBC 613 042-0576-00 5.5V 0.1F D 230 001-0466-90 S5688B L 308 010-2285-58 BLM21A102FPBC 614 168-1032-55 50V 0.01uF D 231 001-0466-90 S5688B L 309 010-2285-58 BLM21A102FPBC 615 042-0577-00 6.3V 100uF D 241 001-0504-45 HZS9B1L L 310 010-2285-58 BLM21A102FPBC 616 163-1063-35 16V 10uF D 242 001-0504-50 HZS11A2L L 311 010-2285-58 BLM21A102FPBC 617 168-1022-55 50V 1000pF D 280 001-2606-90 MIFS4 L 312 010-2285-58 BLM21A102FPBC 619 168-4732-78 25V 0.047uF D 301 001-0529-34 MA8062L L 313 010-2285-58 BLM21A102FPBC 620 178-2242-78 0.22uF D 401 001-0516-90 MA111 L 314 010-2285-58 BLM21A102FPBC 630 166-1011-50 50V 100pF D 402 001-0516-90 MA111 L 401 010-3406-66 22uHC 631 166-1011-50 50V 100pF D 403 001-0529-44 MA8082M L 601 010-2198-56 2.2uHC 632 168-2232-55 25V 0.022uF D 404 001-0516-90 MA111 L 602 010-2198-56 2.2uHC 633 168-2232-55 25V 0.022uF D 405 001-0516-90 MA111 L 603 010-2198-56 2.2uHC 634 168-1032-55 50V 0.01uF D 603 001-0516-90 MA111 L 604 010-2198-56 2.2uHC 635 166-1011-50 50V 100pF D 606 001-0516-90 MA111 L 605 010-2323-53 2.2uHC 636 166-1011-50 50V 100pF D 610 001-0516-90 MA111 L 801 010-2275-53 220uHC 637 166-1011-50 50V 100pF D 651 001-7062-90 DIODE L 901 010-2285-51 COILC 638 166-1011-50 50V 100pF D 801 001-0516-90 MA111 L 902 010-2285-51 COILC 639 166-1011-50 50V 100pF D 802 001-0516-90 MA111 P 500 074-1106-12 OUTLET SOCKETC 640 168-2232-55 25V 0.022uF D 901 001-0516-90 MA111 P 501 074-1106-12 OUTLET SOCKETC 641 168-2232-55 25V 0.022uF D 902 001-0516-90 MA111 Q 2 125-0199-93 KRA103SC 642 166-1011-50 50V 100pF F 101 060-8023-58 CHIP FUSE Q 3 193-1306-00 2SD1306C 643 166-1011-50 50V 100pF F 102 060-8023-58 CHIP FUSE Q 6 190-1162-00 2SA1162C 645 166-1011-50 50V 100pF FIL 301 060-3110-90 NFM4516P13C204 Q 7 190-1162-00 2SA1162C 801 168-2232-55 25V 0.022uF IC 1 051-6201-90 LC72146M Q 8 125-2199-93 KRC103S

DXZ838 RMP- -11

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONQ 9 198-0669-00 2SK669 R 25 119-1521-15 1/16W 1.5Kohm R 302 119-2231-15 1/16W 22KohmQ 200 125-0002-96 RN2406 R 26 119-1031-15 1/16W 10Kohm R 303 119-2231-15 1/16W 22KohmQ 201 102-3420-00 2SC3420 R 27 119-1021-15 1/16W 1Kohm R 304 119-3311-15 1/16W 330ohmQ 202 108-0241-50 2SK241 R 28 119-1021-15 1/16W 1Kohm R 305 119-3311-15 1/16W 330ohmQ 210 190-1298-00 2SA1298 R 29 119-1021-15 1/16W 1Kohm R 306 119-2221-15 1/16W 2.2KohmQ 211 125-2199-96 KRC106S R 30 119-1041-15 1/16W 100Kohm R 308 119-1021-15 1/16W 1KohmQ 212 190-1162-00 2SA1162 R 31 119-1031-15 1/16W 10Kohm R 310 119-1021-15 1/16W 1KohmQ 213 1922712-00 2SC2712 R 101 119-1231-15 1/16W 12Kohm R 312 119-2231-15 1/16W 22KohmQ 214 190-1298-00 2SA1298 R 102 119-1031-15 1/16W 10Kohm R 313 119-2231-15 1/16W 22KohmQ 222 190-1162-00 2SA1162 R 109 119-2291-15 1/16W 2.2ohm R 314 119-3311-15 1/16W 330ohmQ 223 125-2199-93 KRC103S R 110 119-2291-15 1/16W 2.2ohm R 315 119-3311-15 1/16W 330ohmQ 224 101-0941-00 2SB941 R 111 119-2291-15 1/16W 2.2ohm R 316 119-1021-15 1/16W 1KohmQ 225 190-1162-00 2SA1162 R 112 119-2291-15 1/16W 2.2ohm R 317 119-1021-15 1/16W 1KohmQ 226 192-2712-00 2SC2712 R 113 119-2291-15 1/16W 2.2ohm R 318 119-1021-15 1/16W 1KohmQ 227 193-1802-60 2SD1802 R 114 119-2291-15 1/16W 2.2ohm R 319 119-4721-15 1/16W 4.7KohmQ 228 125-2199-93 KRC103S R 115 119-2291-15 1/16W 2.2ohm R 320 119-1021-15 1/16W 1KohmQ 230 190-1298-00 2SA1298 R 116 119-2291-15 1/16W 2.2ohm R 321 119-4721-15 1/16W 4.7KohmQ 231 190-1416-00 2SA1416 R 209 119-1021-15 1/16W 1Kohm R 325 032-0140-52 1/10W 33Kohm(F)Q 232 125-0199-92 KRA102S R 210 119-1031-15 1/16W 10Kohm R 326 032-0140-52 1/10W 33Kohm(F)Q 233 125-2199-93 KRC103S R 211 119-4731-15 1/16W 47Kohm R 327 032-0140-52 1/10W 33Kohm(F)Q 235 125-2199-93 KRC103S R 212 119-1531-15 1/16W 15Kohm R 328 032-0140-52 1/10W 33Kohm(F)Q 236 190-1162-00 2SA1162 R 213 119-1031-15 1/16W 10Kohm R 329 032-0140-89 1/10W 47Kohm(F)Q 240 125-2199-93 KRC103S R 214 119-4731-15 1/16W 47Kohm R 330 032-0140-89 1/10W 47Kohm(F)Q 242 125-2199-93 KRC103S R 215 119-2221-15 1/16W 2.2Kohm R 331 119-1041-15 1/16W 100KohmQ 244 125-0199-92 KRA102S R 216 119-2221-15 1/16W 2.2Kohm R 332 119-1041-15 1/16W 100KohmQ 245 125-2199-96 KRC106S R 218 119-1021-15 1/16W 1Kohm R 333 119-1041-15 1/16W 100KohmQ 250 103-2012-00 2SD2012 R 219 119-1031-15 1/16W 10Kohm R 334 119-1041-15 1/16W 100KohmQ 252 125-2199-96 KRC106S R 220 119-1031-15 1/16W 10Kohm R 335 119-1041-15 1/16W 100KohmQ 301 193-1306-00 2SD1306 R 221 119-3921-15 1/16W 3.9Kohm R 336 119-1041-15 1/16W 100KohmQ 302 193-1306-00 2SD1306 R 222 119-1801-15 1/16W 18ohm R 337 119-1041-15 1/16W 100KohmQ 303 193-1306-00 2SD1306 R 223 119-1031-15 1/16W 10Kohm R 338 119-1041-15 1/16W 100KohmQ 304 193-1306-00 2SD1306 R 224 116-1591-15 1/4WS 1.5ohm R 339 119-4731-15 1/16W 47KohmQ 305 125-2199-96 KRC106S R 225 116-1591-15 1/4WS 1.5ohm R 340 119-1011-15 1/16W 100ohmQ 306 125-0002-96 RN2406 R 226 119-4731-15 1/16W 47Kohm R 341 119-1011-15 1/16W 100ohmQ 308 125-2199-93 KRC103S R 227 119-3321-15 1/16W 3.3Kohm R 342 119-1011-15 1/16W 100ohmQ 401 125-0199-92 KRA102S R 228 119-3321-15 1/16W 3.3Kohm R 343 119-1011-15 1/16W 100ohmQ 414 125-2199-96 KRC106S R 229 116-1591-15 1/4WS 1.5ohm R 344 032-0140-89 1/10W 47Kohm(F)Q 415 192-2712-00 2SC2712 R 230 119-2231-15 1/16W 22Kohm R 345 119-1041-15 1/16W 100KohmQ 416 125-0002-96 RN2406 R 231 116-1591-15 1/4WS 1.5ohm R 346 119-1041-15 1/16W 100KohmQ 602 125-2199-93 KRC103S R 233 119-1031-15 1/16W 10Kohm R 347 032-0140-89 1/10W 47Kohm(F)Q 603 190-1162-00 2SA1162 R 234 119-1021-15 1/16W 1Kohm R 350 119-2711-15 1/16W 270ohmQ 617 125-2199-93 KRC103S R 236 119-1031-15 1/16W 10Kohm R 351 119-2711-15 1/16W 270ohmQ 801 125-2199-92 KRC102S R 238 119-1031-15 1/16W 10Kohm R 352 119-2711-15 1/16W 270ohmR 1 119-1021-15 1/16W 1Kohm R 239 119-1221-15 1/16W 1.2Kohm R 353 119-3341-15 1/16W 330KohmR 3 119-3311-15 1/16W 330ohm R 240 116-4711-15 1/4WS 470ohm R 354 119-2431-15 1/16W 24KohmR 5 119-4721-15 1/16W 4.7Kohm R 242 116-4711-15 1/4WS 470ohm R 355 119-2421-15 1/16W 2.4KohmR 6 119-1021-15 1/16W 1Kohm R 243 119-1031-15 1/16W 10Kohm R 356 119-5121-15 1/16W 5.1KohmR 7 119-5621-15 1/16W 5.6Kohm R 244 116-1811-15 1/4WS 180ohm R 357 119-1511-15 1/16W 150ohmR 8 119-1031-15 1/16W 10Kohm R 247 119-1011-15 1/16W 100ohm R 359 119-2711-15 1/16W 270ohmR 10 119-2221-15 1/16W 2.2Kohm R 248 119-1031-15 1/16W 10Kohm R 360 119-2711-15 1/16W 270ohmR 12 116-3311-15 1/4WS 330ohm R 249 116-1221-15 1/4WS 1.2Kohm R 361 119-2711-15 1/16W 270ohmR 14 119-5631-15 1/16W 56Kohm R 252 116-1521-15 1/4WS 1.5Kohm R 362 119-4701-15 1/16W 47ohmR 16 119-2221-15 1/16W 2.2Kohm R 260 119-2221-15 1/16W 2.2Kohm R 363 119-1021-15 1/16W 1KohmR 17 119-5631-15 1/16W 56Kohm R 261 119-1031-15 1/16W 10Kohm R 364 119-1021-15 1/16W 1KohmR 18 119-1031-15 1/16W 10Kohm R 281 119-2291-15 1/16W 2.2ohm R 365 119-1021-15 1/16W 1KohmR 19 119-1031-15 1/16W 10Kohm R 282 119-2291-15 1/16W 2.2ohm R 366 119-1021-15 1/16W 1KohmR 20 119-1231-15 1/16W 12Kohm R 283 119-2721-15 1/16W 2.7Kohm R 408 119-3931-15 1/16W 39KohmR 21 119-1021-15 1/16W 1Kohm R 284 119-1531-15 1/16W 15Kohm R 409 119-1021-15 1/16W 1KohmR 23 119-2711-15 1/16W 270ohm R 285 116-3911-15 1/4WS 390ohm R 410 119-1021-15 1/16W 1KohmR 24 119-1521-15 1/16W 1.5Kohm R 301 119-1021-15 1/16W 1Kohm R 415 119-1021-15 1/16W 1Kohm

- -12DXZ838 RMP

Sub PWB (B2) section

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONC 500 042-0397-54 10V 2.2uF P 500 076-0659-12 PLUG R 528 119-1031-15 1/16W 10KohmC 505 042-0397-54 10V 2.2uF P 501 076-0659-12 PLUG R 529 119-2231-15 1/16W 22KohmC 507 042-0397-54 10V 2.2uF Q 501 193-1306-00 2SD1306 R 530 119-2231-15 1/16W 22KohmC 508 042-0397-54 10V 2.2uF Q 502 193-1306-00 2SD1306 R 531 119-2231-15 1/16W 22KohmC 509 042-0416-56 10V 22uF Q 503 193-1306-00 2SD1306 R 532 119-2231-15 1/16W 22KohmC 510 042-0416-56 10V 22uF Q 504 193-1306-00 2SD1306 R 533 119-2231-15 1/16W 22KohmC 511 042-0416-56 10V 22uF Q 505 193-1306-00 2SD1306 R 534 119-2231-15 1/16W 22KohmC 512 042-0416-56 10V 22uF Q 506 193-1306-00 2SD1306 R 535 119-2231-15 1/16W 22KohmC 513 042-0416-56 10V 22uF R 511 119-2231-15 1/16W 22Kohm R 536 119-2231-15 1/16W 22KohmC 515 042-0416-56 10V 22uF R 512 119-2231-15 1/16W 22Kohm R 537 119-3311-15 1/16W 330ohmC 530 042-0397-54 10V 2.2uF R 513 119-1031-15 1/16W 10Kohm R 538 119-3311-15 1/16W 330ohmC 533 166-2201-50 50V 22pF R 514 119-1031-15 1/16W 10Kohm R 539 119-3311-15 1/16W 330ohmC 534 166-2201-50 50V 22pF R 519 119-1041-15 1/16W 100Kohm R 540 119-3311-15 1/16W 330ohmC 535 166-2201-50 50V 22pF R 520 119-1041-15 1/16W 100Kohm R 541 119-3311-15 1/16W 330ohmC 536 166-2201-50 50V 22pF R 521 119-1041-15 1/16W 100Kohm R 542 119-3311-15 1/16W 330ohmC 537 166-2201-50 50V 22pF R 522 119-1041-15 1/16W 100Kohm R 543 119-1021-15 1/16W 1KohmC 538 166-2201-50 50V 22pF R 523 119-2231-15 1/16W 22Kohm R 544 119-1021-15 1/16W 1KohmC 541 042-0397-54 10V 2.2uF R 524 119-1031-15 1/16W 10Kohm R 545 119-1021-15 1/16W 1KohmIC 501 051-3026-90 NJM4580V R 525 119-1031-15 1/16W 10Kohm R 587 119-1041-15 1/16W 100KohmIC 502 051-3026-90 NJM4580V R 526 119-2231-15 1/16W 22Kohm R 588 119-1041-15 1/16W 100KohmIC 503 051-3026-90 NJM4580V R 527 119-1031-15 1/16W 10Kohm R 596 119-1021-15 1/16W 1Kohm

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONR 416 119-1021-15 1/16W 1Kohm R 483 119-8221-15 1/16W 8.2Kohm R 659 119-1011-15 1/16W 100ohmR 417 119-1021-15 1/16W 1Kohm R 484 119-1021-15 1/16W 1Kohm R 660 119-4721-15 1/16W 4.7KohmR 418 119-1021-15 1/16W 1Kohm R 485 119-2231-15 1/16W 22Kohm R 661 119-4721-15 1/16W 4.7KohmR 446 032-0140-50 1/10W 10Kohm(F) R 486 119-1021-15 1/16W 1Kohm R 671 119-4731-15 1/16W 47KohmR 447 032-0140-56 1/10W 12Kohm(F) R 603 116-6801-15 1/4WS 68ohm R 673 119-1041-15 1/16W 100KohmR 448 119-2231-15 1/16W 22Kohm R 604 119-3321-15 1/16W 3.3Kohm R 674 119-2711-15 1/16W 270ohmR 449 119-3311-15 1/16W 330ohm R 607 119-2231-15 1/16W 22Kohm R 677 119-1031-15 1/16W 10KohmR 450 032-0140-50 1/10W 10Kohm(F) R 608 119-1031-15 1/16W 10Kohm R 678 119-1031-15 1/16W 10KohmR 451 032-0140-56 1/10W 12Kohm(F) R 609 119-4731-15 1/16W 4.7Kohm R 690 119-4721-15 1/16W 4.7KohmR 452 119-3311-15 1/16W 330ohm R 610 119-4721-15 1/16W 4.7Kohm R 691 119-4721-15 1/16W 4.7KohmR 453 032-0140-50 1/10W 10Kohm(F) R 611 119-1031-15 1/16W 10Kohm R 695 119-1031-15 1/16W 10KohmR 454 032-0140-56 1/10W 12Kohm(F) R 619 119-3311-15 1/16W 330ohm R 696 119-1041-15 1/16W 100KohmR 455 119-2231-15 1/16W 22Kohm R 623 119-1521-15 1/16W 1.5Kohm R 801 119-3331-15 1/16W 33KohmR 456 032-0140-50 1/10W 10Kohm(F) R 637 119-1041-15 1/16W 100Kohm R 802 119-1031-15 1/16W 10KohmR 457 032-0140-56 1/10W 12Kohm(F) R 638 119-4731-15 1/16W 47Kohm R 803 119-1041-15 1/16W 100KohmR 458 032-0140-50 1/10W 10Kohm(F) R 639 119-4721-15 1/16W 4.7Kohm R 804 119-2211-15 1/16W 220ohmR 459 032-0140-56 1/10W 12Kohm(F) R 640 119-3331-15 1/16W 33Kohm R 805 119-1231-15 1/16W 12KohmR 460 119-2231-15 1/16W 22Kohm R 641 119-1831-15 1/16W 18Kohm R 806 119-3321-15 1/16W 3.3KohmR 461 119-3311-15 1/16W 330ohm R 642 119-1031-15 1/16W 10Kohm R 901 119-6801-15 1/16W 68ohmR 462 032-0140-50 1/10W 10Kohm(F) R 643 119-5621-15 1/16W 5.6Kohm R 902 119-6801-15 1/16W 68ohmR 463 032-0140-56 1/10W 12Kohm(F) R 644 119-1541-15 1/16W 150Kohm R 903 119-3331-15 1/16W 33KohmR 464 119-3311-15 1/16W 330ohm R 645 119-8221-15 1/16W 8.2Kohm R 904 119-1021-15 1/16W 1KohmR 465 032-0140-50 1/10W 10Kohm(F) R 646 119-4321-15 1/16W 4.3Kohm S 401 013-5102-00 SLIDE SWITCHR 466 032-0140-56 1/10W 12Kohm(F) R 650 119-1011-15 1/16W 100ohm S 601 013-6100-00 SWITCHR 467 119-2231-15 1/16W 22Kohm R 651 119-1011-15 1/16W 100ohm S 602 013-7106-00 TKR00120670MMR 468 032-0140-50 1/10W 10Kohm(F) R 652 119-1511-15 1/16W 150ohm S 603 013-7206-50 SPPB530701R 469 032-0140-56 1/10W 12Kohm(F) R 653 119-1511-15 1/16W 150ohm SUP 51 060-0122-91 DSP-141N-S00BR 478 119-1041-15 1/16W 100Kohm R 654 119-1511-15 1/16W 150ohm VR 101 012-6009-65 470KR 479 119-1241-15 1/16W 120Kohm R 655 119-1011-15 1/16W 100ohm X 1 061-1066-00 7.2MHZR 480 119-1021-15 1/16W 1Kohm R 657 119-1511-15 1/16W 150ohm X 601 060-1505-50 10MHZR 481 119-1221-15 1/16W 1.2Kohm R 658 119-1521-15 1/16W 1.5Kohm X 801 061-3013-00 4.33M

DXZ838 RMP- -13

Switch PWB (B3) section

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONC 701 168-1042-78 25V 0.1µF Q 705 192-2712-00 TRANSISTOR R 748 119-1011-15 1/16W 100ohmC 702 168-1042-78 25V 0.1µF Q 706 192-2712-00 TRANSISTOR R 749 119-1011-15 1/16W 100ohmC 703 168-1032-55 50V 0.01uF Q 707 192-2712-00 TRANSISTOR R 750 032-0140-00 1/10W 56Kohm(F)C 705 042-0416-54 16V 10µF TAN Q 708 125-2199-93 KRC103S R 751 032-0140-53 1/10W 2.2Kohm(F)C 706 168-1042-78 25V 0.1µF Q 709 190-1298-00 2SA1298 R 752 032-0140-98 1/10W 330ohm(F)C 707 042-0416-54 16V 10µF TAN Q 710 125-2017-96 RN1426 R 753 119-4731-15 1/16W 47KohmC 708 042-0416-50 16V 4.7µF TAN Q 711 125-2017-96 RN1426 R 754 119-4731-15 1/16W 47KohmC 710 168-1042-78 25V 0.1µF Q 712 125-2017-96 RN1426 R 755 032-0140-89 1/10W 47Kohm(F)C 711 042-0416-50 16V 4.7µF TAN Q 713 125-2017-96 RN1426 R 756 032-0140-89 1/10W 47Kohm(F)C 718 168-1022-55 50V 1000pF Q 714 125-2017-96 RN1426 R 760 119-3921-15 1/16W 3.9KohmC 719 168-1022-55 50V 1000pF Q 715 125-2017-96 RN1426 R 761 119-1041-15 1/16W 100KohmC 720 168-1022-55 50V 1000pF Q 716 190-1298-00 2SA1298 R 762 119-1011-15 1/16W 100ohmC 721 042-0398-53 16V 3.3µF TAN Q 717 125-2199-93 KRC103S R 771 119-1021-15 1/16W 1KohmC 722 042-0398-53 16V 3.3µF TAN R 714 119-4711-15 1/16W 470ohm R 772 119-1021-15 1/16W 1KohmC 723 042-0398-53 16V 3.3µF TAN R 715 119-2711-15 1/16W 270ohm R 773 119-1021-15 1/16W 1KohmC 725 166-1011-50 50V 100pF R 716 119-2711-15 1/16W 270ohm R 774 119-1041-15 1/16W 100KohmC 726 166-1011-50 50V 100pF R 717 119-4711-15 1/16W 470ohm R 775 119-1041-15 1/16W 100KohmD 701 001-7072-90 FRGB1304B R 718 119-2711-15 1/16W 270ohm R 776 119-1041-15 1/16W 100KohmD 702 001-7072-90 FRGB1304B R 719 119-2711-15 1/16W 270ohm R 780 119-3301-15 1/16W 33ohmD 703 001-7072-90 FRGB1304B R 720 119-4711-15 1/16W 470ohm R 781 119-3301-15 1/16W 33ohmD 704 001-7072-90 FRGB1304B R 721 119-2711-15 1/16W 270ohm R 782 119-3301-15 1/16W 33ohmD 705 001-7072-90 FRGB1304B R 722 119-2711-15 1/16W 270ohm R 783 119-3301-15 1/16W 33ohmD 706 001-0529-32 MA8056M R 723 119-2211-15 1/16W 220ohm S 701 013-6312-50 SWITCHD 707 001-0516-90 MA111 R 724 119-1811-15 1/16W 180ohm S 702 013-6312-50 SWITCHD 708 001-0516-90 MA111 R 725 119-1811-15 1/16W 180ohm S 703 013-6312-50 SWITCHD 711 001-0516-90 MA111 R 726 119-2211-15 1/16W 220ohm S 704 013-6312-50 SWITCHD 712 001-0516-90 MA111 R 727 119-1811-15 1/16W 180ohm S 705 013-6312-50 SWITCHD 713 001-0516-90 MA111 R 728 119-1811-15 1/16W 180ohm S 706 013-6312-50 SWITCHD 714 001-0516-90 MA111 R 729 119-3911-15 1/16W 390ohm S 707 013-6312-50 SWITCHD 715 001-0516-90 MA111 R 730 119-3911-15 1/16W 390ohm S 708 013-6312-50 SWITCHD 716 001-0516-90 MA111 R 731 119-3311-15 1/16W 330ohm S 709 013-6312-50 SWITCHD 717 001-0516-90 MA111 R 732 119-3311-15 1/16W 330ohm S 710 013-6507-50 LUMI SWITCHD 718 001-0516-90 MA111 R 733 119-5611-15 1/16W 560ohm S 711 013-6312-50 SWITCHD 719 001-0516-90 MA111 R 734 119-5611-15 1/16W 560ohm S 712 013-6312-50 SWITCHIC 701 051-6057-00 ML9090-01 R 735 119-2211-15 1/16W 220ohm S 713 013-6507-50 LUMI SWITCHIC 702 051-1974-08 TC7S86FU R 736 119-2211-15 1/16W 220ohm S 714 013-6507-50 LUMI SWITCHIC 703 051-5829-90 NJM555 R 737 119-2211-15 1/16W 220ohm S 715 013-6312-50 SWITCHIC 704 051-6636-08 M62333FP R 738 119-2211-15 1/16W 220ohm S 718 013-6507-50 LUMI SWITCHIR 701 060-4017-90 RS-671 R 739 119-2711-15 1/16W 270ohm S 719 013-6312-50 SWITCHP 701 076-0647-00 DCP CONECTOR R 740 119-2711-15 1/16W 270ohm S 720 013-6507-50 LUMI SWITCHQ 701 190-1162-00 2SA1162 R 741 119-1031-15 1/16W 10Kohm S 721 013-6312-50 SWITCHQ 702 192-2712-51 2SC2712GL R 742 119-2221-15 1/16W 2.2Kohm S 722 013-6312-50 SWITCHQ 703 060-4011-80 PHOTO-TR R 743 119-1031-15 1/16W 10Kohm S 723 016-9900-85 ENCODER-SWQ 704 192-2712-00 TRANSISTOR R 744 119-2221-15 1/16W 2.2Kohm

-14-

EXPLANATION OF IC

DXZ838 RMP

1.Terminal Description

052-5054-00 MN102H60KCL Microcomputer

CD mechanism section 929-0240-81

BLOCK DIAGRAM:CD mechanism section

MP3&WMA Encoded disc/CD-DA disc (CD-ROM ISO9660)

CD Mecha. P/U CP-5

J2 10pin J1 15pin

3.3V

DRIVER RF AMP 3.3V

*BA5996FP*AN8399SA 3.3V(I/O) 1.6V(Core) *LOGIC

DRAMDECODER SN74LV139

*K4S641632E*TMS320DA150

-TC753.3V (CD-ROM I/F) *LOGIC

(1M×16bit×4B) DSP (ECC) SN74LV74 *MN6627482WB (Mpeg audio decode

(Digital servoservo)DAC

(WMA decode)

(DF/DAC) (ESP)

3.3V

CPUFLASH ROM

*MN102H60K *LOGIC*MBM29DL400BC(16bit)

SN74LV273

(4Mbit)(256K ROM)×2

Audio(10K RAM)

*regulator *regulator3.3V 1.6V 5V 3.3V regufator*regulator * LOGIC D-OUT

5V--3.3V5V 3.3V SN74HCT08

ACC5VB/U5V V-BUS

J3 J420pin CONNECTOR 7 pin CONNECTOR

HPI DATA BUS

ACC8V

SN74LV273

pin 1 : MODE SEL : IN : Selection signal input V-Bus or Jig.pin 2 : OE : O : The read enable command output.pin 3 : BYTE : O : The strobe pulse output for HPI.pin 4 : WRITE ENBL : O : The write enable signal output.pin 5 : CHIP SEL : O : The chip select signal output.pin 6 : NU : - : Not in use.pin 7 : NU : - : Not in use.pin 8 : CHIP SEL : O : The chip select signal output.pin 9 : TR A : IN : Photo sensor signal input from the CD mechanism.pin 10 : TR B : IN : Photo sensor signal input from the CD mechanism.pin 11 : LATCH : O : The latch pulse output.pin 12 : GND : - : Ground.pin 13 : NU : - : Not in use.pin 14 : DR MUTE : O : The driver mute.pin 15 : LD / SLD : O : Loading/Sled selection.pin 16 : LD CONT : O : The Loading control signal output.pin 17 : VDD : - : Positive supply voltage.pin 18 : CK OUT : O : The closk pulse output.pin 19 : GND : - : Ground.pin 20 : SB CLK In : IN : Sub clock.pin 21 : SB CLK Out : O : Sub clock.pin 22 : VDD : - : Positive supply voltage.pin 23 : OSC IN : IN : Oscillation input.pin 24 : OSC OUT : O : Oscillation output.pin 25 : CNNCT VCC : - : Pull up.pin 26 : M CLK O : O : The clock pulse output.pin 27 : M DATA O : O : The serial data output.pin 28 : M LD O : O : MLDB.pin 29 : M RESET : O : The reset pulse output.pin 30 : NU : - : Not in use.pin 31 : NU : - : Not in use.pin 32 : NU : - : Not in use.pin 33 : NU : - : Not in use.pin 34 : A VDD : - : Positive supply voltage for the Analog section.pin 35 : NU : - : Not in use.pin 36 : NU : - : Not in use.pin 37 : NU : - : Not in use.pin 38 : NU : - : Not in use.pin 39 : A 16 : O : Address signal output.pin 40 : A 17 : O : Address signal output.pin 41 : A 18 : O : Address signal output.pin 42 : A 19 : O : Address signal output.pin 43 : GND : - : Ground.pin 44 : H CNTL 0 : O : TI DSP H CNTL 0pin 45 : H CNTL 1 : O : TI DSP H CNTL 1pin 46 : NU : - : Not in use.pin 47 : H R/W : O : TI DSP H R/W.

pin 48 : NU : - : Not in use.pin 49 : NU : - : Not in use.pin 50 : SBCK : O : CD DSP SBCK.pin 51 : SUBC : IN : CD DSP SUBC.pin 52 : HRDY : IN : TI DSP HRDY.pin 53 : SQCK : O : CD DSP SQCK.pin 54 : Vref : - : Reference voltage.pin 55 : SUBQ : IN : CD DSP SUBQ.pin 56 : TRESET : O : TI DSP RESET.pin 57 : NU : - : Not in use.pin 58 : LIMIT : IN : Inside limit switch signal input for the pickup.pin 59 : LDRCTL : O : LDRCTLpin 60 : SENSE : IN : CD DSP SENSEpin 61 : A VSS : - : Analog ground.pin 62 : CMUTE : O : VBUS AMUTEpin 63 : CSRQ : O : VBUS SRQpin 64 : 0BMUTE : O : 0BIT MUTEpin 65 : CHUCK : IN : CD MECHA CHUCKpin 66 : VDD : - : Positive supply voltage.pin 67 : CSCK : IN : VBUS SCKpin 68 : CMSI : IN : VBUS MSIpin 69 : CMSO : O : VBUS MSOpin 70 : STAT : IN : CD DSP STATpin 71 : RWSEL : O : RF RWSELpin 72 : SYSP : O : SYSTEM POWERpin 73 : PUR1 : IN : For flash memory.pin 74 : PUR2 : IN : For flash memory.pin 75 : NMI : IN : Connect to VCC.pin 76 : BLKCK : IN : CD DSP BLKCKpin 77 : CCS : IN : VBUC CSpin 78 : DQSY : IN : CD DSP DQSYpin 79 : WUP : IN : VBUS WUPpin 80 : HINT : IN : TI DSP HINTpin 81 : ADSEP : IN : GNDpin 82 : RESET : IN : Reset signal input.pin 83 : VDD : - : Positive supply voltage.pin 84 : A 0 :I/O: Address input/output.pin 85 : A 1 :I/O: Address input/output.pin 86 : A 2 :I/O: Address input/output.pin 87 : A 3 :I/O: Address input/output.pin 88 : A 4 :I/O: Address input/output.pin 89 : A 5 :I/O: Address input/output.pin 90 : A 6 :I/O: Address input/output.pin 91 : A 7 :I/O: Address input/output.pin 92 : VSS : - : Negative supply voltage.pin 93 : A 8 :I/O: Address input/output.pin 94 : A 9 :I/O: Address input/output.pin 95 : A 10 :I/O: Address input/output.pin 96 : A 11 :I/O: Address input/output.pin 97 : A 12 :I/O: Address input/output.pin 98 : A 13 :I/O: Address input/output.pin 99 : A 14 :I/O: Address input/output.pin100 : A 15 :I/O: Address input/output.


-15 -DXZ838 RMP

39B2

46

B2

D1

G13

B1

D2G12 M1

H3

H2H1

G5

G14

G15G16G2

E2

G13

A1

A8G6

J1 G12

J1J2

H5

H4

J2A2 C2

A3

G7G8

G9

G4

E1

G10G11

G3

G1G14 G5G16

G15

H7H6H5H4H3H2H1

G6

I1

H8

A2

A6

G2

A1

A4

A7 G3

D2

A8

A3

F1A5D1

I2

I1

H7H6

K2K1

C3

H8

C1

C4

L1

C3

L2

C4C5

K1

K2C3

C3

C1

C4

C5C5

C4

G7 G10

M1C5

G9G8

G11

B1

G16

G16

C2

G1

I2

G4

E2

A6

A7

F1

A5

A4

E1

48

46

39

54

52

31

13

52

7419

15

3

74

20

58

4262

1040 8

9

63

43

7

6144

17

6018

59

36

35

53

21

5

67

54

1

53

1137 29

3330

27

26

28

56

56

2

38

49

45

14

55

73

4

64

64

51

53

2265

53

66

12

6

24

50 53

50

253

717270 6869

32

47

57

34

41

16

23

EXPLODED VIEW PARTS LIST:

- -16DXZ838 RMP

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY

1 966-0595-25 DRIVE PLATE ASSY 1 37 621-0620-20 THREAD GEAR A 1

2 969-0065-90 PICK UP UNIT 1 38 621-0621-20 THREAD GEAR B 1

3 039-1944-21 LED PWB 1 39 621-0622-21 ROLLER SLEEVE 2

(WITHOUT COMPONENT) 40 621-0623-22 LS-HOLDER 1

4 039-2290-00 CD PWB 1 41 621-0624-22 GUIDE RAIL 1

(WITHOUT COMPONENT) 42 621-0708-20 CLAMPER RING 1

5 SMA-182-100MOTO ASSY(SPINDLE) 1 43 621-0626-21 STOPPER LINK 1

6 SMA-183-100MOTO ASSY(SLED) 1 44 621-0627-21 DISC STOPPER 1

7 620-1022-25 CLAMPER LINK 1 45 621-0709-20 SH-BASE 1

8 620-1023-23 CLAMPER PLATE 1 46 621-0629-20 LOADING ROLLER 2

9 620-1024-23 SENSOR ARM 1 47 716-1670-00 SPECIAL SCREW 2

10 620-1025-22 ID-LOCK PLATE 1 48 622-1660-20 ROLLER SHAFT 1

11 620-1026-21 SPRING PLATE 1 49 624-0018-01 LEAD SCREW 1

12 620-1585-20 LOWER CHASSIS 1 50 629-0086-20 DAMPER F 2

13 620-1028-23 UPPER CHASSIS 1 51 629-0087-20 DAMPER R 1

14 966-0638-20 SH-RACK ASSY 1 52 714-2003-81 MACHINE SCREW 2

15 621-0598-26 UPPER GUIDE 1 53 716-1507-00 SCREW 7

16 621-0718-21 ROLLER GUIDE 1 54 716-1733-00 SCREW 2

17 621-0600-26 SHIFT LEVER 1 55 716-3469-00 SPECIAL SCREW 2

18 621-0601-21 RACK 1 56 716-3446-00 SCREW 2

19 621-0602-22 LOCK ARM(L) 1 57 750-3465-21 ROLLER SPRING(L) 1

20 621-0603-25 LOCK ARM(R) 1 58 750-3466-20 ROLLER SPRING(R) 1

21 621-0724-20 GEAR BASE 1 59 750-3467-21 SHIFT SPRING 1

22 621-0605-22 GEAR COVER 1 60 750-3468-20 RACK SPRING 1

23 621-0723-20 IDLE CASE 1 61 750-3469-20 CLAMPER SPRING 1

24 345-8704-20 CUSHION RUBBER 1 62 750-3470-20 ID-LOCK SPRING 1

25 621-0608-21 SECOND GEAR 1 63 750-3471-20 SENSOR SPRING 1

26 621-0609-20 BASE GEAR 1 64 750-3472-21 DR-SPRING F 2

27 621-0610-20 IDLE GEAR A 1 65 750-3473-20 DR-SPRING RA 1

28 621-0611-20 IDLE GEAR B 1 66 750-3474-20 DR-SPRING RB 1

29 621-0612-21 ROLLER GEAR A 1 67 750-3475-21 DR-SPRING C 1

30 621-0719-20 ROLLER GEAR B 1 68 803-4906-60 VINEL-COAT-WIRE 1

31 621-0720-20 ROLLER GEAR C 1 69 816-2590-00 SPECIAL LEAD 1

32 621-0721-20 ROLLER GEAR D 1 70 816-2591-00 SPECIAL LEAD 1

33 621-0616-20 POWER GEAR A 1 71 816-2592-00 SPECIAL LEAD 1

34 621-0617-20 POWER GEAR B 1 72 816-2593-00 SPECIAL LEAD 1

35 621-0618-20 POWER GEAR C 1 73 816-2624-50 FLAT WIRE 1

36 621-0619-20 POWER GEAR D 1 74 716-3473-00 SPECIAL SCREW 2

-17- DXZ838 RMP

LED PWB (B5) section

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTIONC1 168-4732-78 0.047uF C71 168-1045-56 0.1uF Q1 125-0002-92 RN2402TE85LC2 046-3922-58 3900pF C72 168-1045-56 0.1uF Q02 125-2004-92 RN1402TE85LC3 046-3332-78 0.033uF C75 046-1032-78 0.01uF Q3 131-1188-50 2SB1188C4 045-2201-50 22pF C76 168-1045-56 0.1uF Q4 190-1586-50 2SA1586C5 045-3901-50 39pF C77 163-2273-05 4V 220uF Q5 125-2004-92 RN1402TE85LC6 168-4732-78 0.047uF C78 168-1045-56 0.1uF Q50 125-2004-92 RN1402TE85LC7 045-2096-50 2pF C80 168-1045-56 0.1uF R1 033-3341-15 1/16W 330KohmC8 042-0416-52 10V 10uF C81 168-1045-56 0.1uF R2 033-4741-15 1/16W 470KohmC9 042-0416-52 10V 10uF C82 178-1052-78 1uF R3 033-1521-15 1/16W 1.5KohmC10 046-5622-58 5600pF C83 046-4722-58 4700pF R4 033-3321-15 1/16W 3.3KohmC11 178-1052-78 1uF C84 178-1052-78 1uF R5 033-4721-15 1/16W 4.7KohmC12 163-1073-05 4V 100uF C85 046-1032-78 0.01uF R6 117-1001-15 1/10W 10ohmC13 178-1052-78 1uF C86 168-1045-56 0.1uF R7 033-2251-15 1/16W 2.2MohmC14 168-1045-56 0.1uF C87 168-1045-56 0.1uF R8 033-6831-15 1/16W 68KohmC15 046-6822-58 6800pF C88 045-1011-50 100pF R9 033-1021-15 1/16W 1KohmC16 046-3332-78 0.033uF C89 045-1011-50 100pF R10 033-3331-15 1/16W 33KohmC17 178-2242-78 0.22uF C90 046-1032-78 0.01uF R11 033-1231-15 1/16W 12KohmC18 168-4732-78 0.047uF C91 046-1032-78 0.01uF R12 033-1231-15 1/16W 12KohmC19 045-1511-50 150pF C92 168-1045-56 0.1uF R17 033-1811-15 1/16W 180ohmC20 046-2212-58 220pF C93 046-1032-78 0.01uF R30 033-1011-15 1/16W 100ohmC21 178-1052-78 1uF C94 045-1201-50 12pF R31 033-6811-15 1/16W 680ohmC22 046-4722-58 4700pF C95 168-1045-56 0.1uF R32 033-6811-15 1/16W 680ohmC23 163-1073-05 4V 100uF C96 163-4763-05 4V 47uF R33 033-2211-15 1/16W 220ohmC30 168-1045-56 0.1uF C97 042-0416-52 10V 10uF R35 033-3311-15 1/16W 330ohmC31 163-1073-05 4V 100uF C98 168-1045-56 0.1uF R36 033-5631-15 1/16W 56KohmC32 046-1032-78 0.01uF C99 046-1032-78 0.01uF R37 033-8231-15 1/16W 82KohmC33 046-1032-78 0.01uF CCT1 050-0145-54 1/16W 47Kohm R38 033-5631-15 1/16W 56KohmC34 168-1045-56 0.1uF CCT2 050-0145-54 1/16W 47Kohm R39 033-3331-15 1/16W 33KohmC35 168-1045-56 0.1uF CCT6 050-0145-54 1/16W 47Kohm R40 033-8221-15 1/16W 8.2KohmC36 046-1022-58 1000pF CCT9 050-0145-54 1/16W 47Kohm R41 033-1031-15 1/16W 10KohmC37 042-0416-52 10V 10uF D1 001-2610-90 RB480K R42 033-2731-15 1/16W 27KohmC38 046-4722-58 4700pF D2 001-2610-90 RB480K R43 033-1031-15 1/16W 10KohmC39 178-2242-78 0.22uF D3 001-0367-91 1SS226TE85L R44 033-1531-15 1/16W 15KohmC40 168-1045-56 0.1uF D4 001-2610-90 RB480K R45 033-5621-15 1/16W 5.6KohmC41 046-2232-78 0.022uF IC1 051-5709-90 AN8399SA R46 033-4741-15 1/16W 470KohmC42 046-6812-58 680pF IC2 051-6393-00 MN6627482WB R47 033-3341-15 1/16W 330KohmC43 046-1022-58 1000pF IC3 051-6062-08 BA5996FM-E2 R48 033-2241-15 1/16W 220KohmC50 168-1045-56 0.1uF IC4 051-7221-58 SN74AHC1G04D R50 117-6811-15 1/10W 680ohmC51 045-1011-50 100pF IC5 052-5054-00 MN102H60K R51 033-1031-15 1/16W 10KohmC52 046-1522-58 1500pF IC6 051-6372-00 TMS320DA150 R52 033-1031-15 1/16W 10KohmC53 046-1522-58 1500pF IC7 051-3314-90 TMS48S033F R53 033-1031-15 1/16W 10KohmC54 046-6812-58 680pF IC8 051-3315-90 TPS76316DBVR R54 033-1031-15 1/16W 10KohmC55 163-1073-35 16V 100uF IC9 051-5442-08 BD4826 R55 033-8221-15 1/16W 8.2KohmC56 168-1045-56 0.1uF IC10 051-9813-00 MBM29DL400BC R56 033-1041-15 1/16W 100KohmC57 046-1022-58 1000pF IC11 051-7519-08 SN74LV273APWR R57 033-1011-15 1/16W 100ohmC60 045-1801-50 18pF IC12 051-7519-08 SN74LV273APWR R62 033-1041-15 1/16W 100KohmC61 045-1801-50 18pF IC13 051-7239-38 SN74HCT08PW R63 033-1041-15 1/16W 100KohmC62 046-1032-78 0.01uF IC14 051-9330-00 K4S641632E- R66 119-4741-15 1/16W 470KohmC63 168-1045-56 0.1uF IC15 051-7518-08 SN74LV139APWR R82 033-3311-15 1/16W 330ohmC64 168-1045-56 0.1uF IC16 051-7203-48 SN74LV74APWR R83 033-1011-15 1/16W 220ohmC65 168-1045-56 0.1uF IC17 051-3263-90 NJU7200U33 R94 033-1041-15 1/16W 100KohmC66 046-1032-78 0.01uF IC18 051-7222-48 SN74AHC1G08D R95 033-2231-15 1/16W 22KohmC67 168-1045-56 0.1uF J1 074-1138-65 10p R96 033-1021-15 1/16W 1KohmC68 046-1032-78 0.01uF J2 074-1138-60 10p R97 033-4721-15 1/16W 4.7KohmC70 168-1045-56 0.1uF J3 074-1237-70 10p

REF No. PART No. DESCRIPTIOND101 001-7058-90 AN1105W-RRD102 001-7058-90 AN1105W-RRJ101 074-1138-60 10pQ101 060-4015-90 PS1192HQ102 060-4015-90 PS1192HS101 013-7414-50 CHUCKINGS102 013-7413-50 LIMIT

ELECTRICAL PARTS LISTCD mechanism(B4) section 929-0240-81

-18-

PRINTED WIRING BOARD:

DXZ838 RMP


LED PWB (B5)-A

LED PWB (B5)-B

CD PWB (B4)

61

20

TO J

603

OF

MA

IN P

WB

Pag

e 22

I C 5 0 1

Q 5 0 1Q 5 0 2

Q 5 0 5Q 5 0 3

Q 5 0 6

Q 5 0 4

I C 5 0 2I C 5 0 3

TO P501 OF Main PWB Page 22

Q 7 0 4

Q 7 0 1

Q 7 0 2

Q 7 0 3

I C 7 0 3

I C 7 0 2

Q 7 0 7

Q 7 0 6Q 7 0 5

I C 7 0 1

I C 7 0 4

Q 7 1 2

Q 7 1 6

Q 7 1 0Q 7 0 8Q 7 1 7Q 7 1 3Q 7 1 4Q 7 1 5

Q 7 0 9

Q 7 1 1

TO P500 OF Main PWB Page 22

1

1

DXZ838

PRINTED WIRING BOARD:Sub PWB (B2) section/Switch PWB (B3) section

RMP-19-

1

103

39

65

1

5

1

5

Sub PWB (B2) section

Switch PWB (B3) section

TO

J60

2 O

F M

ain

PW

B P

age

22

116

DXZ838

CIRCUIT DIAGRAM:Sub PWB (B2) section

RMP-20-

TO P

501

OF

M

ain

PW

B P

age

26

TO P

500

OF

M

ain

PW

B P

age

26

TO J602 OF Main PWB Page 23

CIRCUIT DIAGRAM:Switch PWB (B3) section

-21- DXZ838 RMP

213

3 4 5 6

7 8 9 10

11 12

1

1

5

1

5

1

8

1

9

1

5

1

13

1

13

1

9

1

19

1

11

1

5

1

5

1

9

1

5

126

7651

1

1

5

118

1

12

BL 1

120

1 23

-22-

PRINTED WIRING BOARD:Main PWB (B1)

I C 8 0 1

Q 2 5 0

Q 8 0 1

Q 2 4 4Q 3 0 1

Q 2 4 5

Q 4 0 1

Q 3 0 6Q 2 2 4

Q 3 0 5

Q 2 0 0

I C 1 0 1

I C 4 0 7

Q 4 1 6Q 2 3 5Q 2 5 2

Q 4 1 4Q 2 3 6

Q 6 0 3

Q 6 0 2

Q 2 1 3

Q 2 3 2Q 2 3 0

Q 2 2 2

I C 9 0 1

Q 2 3 1Q 2 3 3Q 2 4 0

Q 2 2 6

I C 2 8 0

BUS 14V

L-CH(+)

J601

Q 2 0 1

Q 2 0 2

Q 6Q 7Q 9Q 2Q 3Q 8

I C 8 0 2

I C 4 0 6I C 3 0 2

I C 1

I C 3 0 3Q 3 0 2Q 3 0 3Q 3 0 4Q 3 0 8Q 2 1 4

I C 2 2 0

I C 3 0 5I C 3 0 4

I C 4 0 1I C 4 0 8

Q 4 1 5Q 2 1 2

Q 2 2 5

I C 2 3 0I C 6 0 4

I C 6 0 5

I C 6 0 6Q 6 1 7

Q 2 4 2

Q 2 1 0

Q 2 2 3

Q 2 1 1

Q 2 2 8

Q 2 2 7

I C 6 0 2

I C 3 0 1

EXT-A (+)

EXT-A (-)

RESERVE

WHT

RED

RED

WHT

RED

WHT

RED

WHT RED

BLK

GRY

PUR

855-5424-50

855-5480-50

LEFT

RIGHT

LEFT

RIGHT

LEFT

RIGHT

LEFT

RIGHT

FRONT

REAR

NON-FADER

AUX-IN

854-6362-54

TO

J3

OF

CD

ME

CH

AN

ISM

(B

4) P

age1

8

CE-NET LINE

DXZ838 RMP

1

1

12

039-1862-00 FPCTo Inner Escutcheon section

(Switch PWB(B3) Section P701)

2

11

122

11

SS

TO P

500

OF

SU

B P

WB

(B

2)

TO P501 OF SUB PWB (B2)Page 19

Pag

e 19

24

26

2525

24

25

26

24

2626

25

25

24

26

44

4/4

4

4

4

4

4

4

4

4

4

4

4

4/4

4

4

4

4

4

4 4/4

4

4

4

4/4

4

4

4

4/4

4

r

rr

r

r r

r

TO P701 OFSW PWB (B3) Section Page 21

TO J3 OF CD MECHANISM (B4) Page28

CIRCUIT DIAGRAM:Main PWB (B1) section 1/4

-23- DXZ838 RMP

*REF No. with "r(small letter)" like "r232" means a jumper wire.

vk

2523

26

44

4/4

4

r r


-24- DXZ838 RMP


26

23

24

23

23

24

26

23

26

4

4

4

4/4

4

4

4

4

4

4

4

4

4/4

4

4

4

4

4

4

4

4/4

4

4

4

4

4

r

r


-25- DXZ838 RMP


B/U

A I

H P

25

23

25

23

25

24

23

2523

4

4

4

4

4

4

4

4

4

r

r

r

r

r

r

r

TO P500 OF SUB PWB (B2) Page 20

1

12

TO P501 OF SUB PWB (B2) Page 20


-26- DXZ838 RMP


CIRCUIT DIAGRAM:CD PWB(B4) section 1/2

-2 -7 DXZ838 RMP

LED PWB (B5)-B

LED PWB (B5)-A

S101

S102

D102D101AN1105W-RR AN1105W-RR

Q102PS1192H PS1192H

Q101

TR-ATR-B

J101

816-2624-50 FLAT WIRE

TO PICK UP UNIT

TO 2

8 PA

GE

CD

PW

B S

EC

TIO

N2/

2 TO

28

PAG

E C

D P

WB

SE

CT

ION

2/2

TO 2

8 PA

GE

CD

PW

B S

EC

TIO

N2/

2

CIRCUIT DIAGRAM:CD PWB(B4) section 2/2

-2 -8 DXZ838 RMP

TO J603 OF Main PWB Page 23

TO 2

7 PA

GE

CD

PW

B S

EC

TIO

N1/

2 TO

27

PAG

E C

D P

WB

SE

CT

ION

1/2

TO 2

7 PA

GE

CD

PW

B S

EC

TIO

N1/

2

TO 27 PAGE CD PWB SECTION1/2

Clarion Dxz838rmp

Documents

Transcript of Clarion Dxz838rmp