Projekt EU Chemlog Intermodal Transport in Richtung der Ukraine und Russland
Chemlog Intermodal Slovakia en FinalFP p
-
Upload
cvijica635 -
Category
Documents
-
view
216 -
download
0
Transcript of Chemlog Intermodal Slovakia en FinalFP p
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
1/90
ChemLog Chemical Logistics Cooperation in Central and Eastern Europe
Chemical Logistics Cooperation in Central and Eastern Europe
Feasibility Study
DEVELOPMENT OF RAILWAY TRANSPORT OFCHEMICALS IN SLOVAKIA IN RELATION TOADJACENT COUNTRIES AND PREPARED
COMBINED TRANSPORT TERMINALS
Date: October 2010
Partner:
ZVZ CHEMICKHO A FARMACEUTICKHO PRIEMYSLU SLOVENSKEJ
REPUBLIKY
ASSOCIATION OF CHEMICAL AND PHARMACEUTICAL INDUSTRY OF THE SLOVAK REPUBLIC
Authors:Prof. Ing. Jozef Gnap, PhD., Prof. Ing. Marin ulgan, PhD.,Prof. Ing. Jozef Majerk, prof. Ing. Libor Ivolt, PhD.,
Doc. Ing. Jozef Gapark, PhD.,Ing. Juraj Jagelk, PhD. , Ing. Jn Libetin, PhD.
www.chemlog.info
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
2/90
ChemLog Chemical Logistics Cooperation in Central and Eastern Europe
This project is implemented through the CENTRAL EUROPE Programmecofinanced by the ERDF. Any liability for the content of this publication lies with the
authors. The European Commission is not responsible for any use that may be madeof the information contained herein.
www.central2013.eu
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
3/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
FEASIBILITY STUDYDevelopment of railway transport of chemicals inSlovakia in relation to adjacent countries and prepared
combined transport terminals
CHEMLOG PROJECT PARTNER
ZVZ CHEMICKHO AFARMACEUTICKHO PRIEMYSLU SLOVENSKEJ REPUBLIKY
ASSOCIATION OF CHEMICAL AND PHARMACEUTICAL INDUSTRY OF THE SLOVAK REPUBLIC
PREPARED BY:
Prof. Ing. Jozef Gnap, PhD., Prof. Ing. Marin ulgan, PhD., Prof. Ing. Jozef Majerk, PhD.,prof. Ing. Libor Ivolt, PhD., Doc. Ing. Jozef Gapark, PhD.,
Ing. Juraj Jagelk, PhD. , Ing. Jn Libetin, PhD.
University od ilina, Faculty of Operation and Economics of Transport and Communications
October 2010Association of chemical and pharmaceutical industry of the Slovak republic, University of ilina, 2010
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
4/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
Content
Introduction ................................................................................................... 6
1. Chemical industry in Slovakia and international trade ...................... 61.1. International trade ................................................................................................................ 8
2. Bans for transport of dangerous goods in Slovakia and possibilities of
rail and intermodal transport ........................................................... 18
2.1. Classification of tunnels in Slovakia..................................................................................... 20
3. Intermodal transport equipments for chemical industry .................. 22
4. Intermodal transport in Slovakia and in relation to Europe .............. 28
4.1. Performances in intermodal transport in Slovakia ............................................................. 28
4.2. Present intermodal terminals in Slovakia ........................................................................... 29
4.2.1 Intermodal terminal Dobr........................................................................................ 30
4.2.2. Intermodal terminal Bratislava NS.......................................................................... 30
4.2.3. Intermodal terminal Bratislava - Plenisko............................................................... 31
4.2.4 Intermodal terminal ilina.......................................................................................... 32
4.2.5 Intermodal terminal Koice........................................................................................ 33
4.2.6 Intermodal terminal Koice Vek Ida..................................................................... 34
4.2.7 Intermodal terminal Dunajsk Streda........................................................................ 35
4.2.8. Intermodal terminal Sldkoviovo............................................................................ 36
4.2.9. Characteristics of terminals out of order ............................................................... 37
4.3. Planned intermodal terminals in Slovakia at the state level ............................................... 424.3.1. Intermodal terminal ilina Teplika........................................................................ 42
4.3.2 Intermodal terminal Koice........................................................................................ 44
4.3.3 Intermodal terminal Bratislava................................................................................... 45
4.3.4. Intermodal terminal Leopoldov ................................................................................ 46
4.3.5 Operational Programme TransportIntermodal transport infrastructure ............... 47
4.4. Multimodal transport corridors and their impact on the solved issue ............................... 48
5. Possibilities of using the Eastern Slovak Transshipment Yards for the
development of rail and intermodal transport of chemicals ............. 50
5.1. Possibilities of using chemical fluids transfer in ierna nad Tisou...................................... 515.2. Possibilities of using transhipment station in Dobr for transcontinental transport......... 545.3. Support of intermodal transport in Slovakia: ...................................................................... 55
5.3.1. Zkon . 514/2009 Z.z. odoprave na drhach (Act No. 514/2009 Coll. on Railway
Transport) ............................................................................................................................ 55
5.3.2. Maximum allowable dimensions and weights of road vehicles ................................ 56
5.3.3 Zkon . 8/2009 Z.z. o cestnej premvke (Act No. 8/2009 Coll. on Road Tr affic) ...... 56
5.3.4. Zkon 582/2004 o miestnych daniach a miestnom poplatku za komunlne odpady a
drobn stavebn odpady (Act No. 582/2004 Coll. on Local Taxes and Local Charges for
Municipal and Minor Construction Waste) ......................................................................... 57
5.3.5. Regulation (EC) No 1692/2006 as amended by Regulation (EC) 923/2009 .............. 57
5.4. Support of intermodal transport in the Czech Republic ..................................................... 57
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
5/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
6. Support of the development of chemical transportations in the
railway sector .................................................................................. 59
6.1. Issue of the access to railway infrastructure ....................................................................... 596.1.1. Report of the timetable .......................................................................................... 60
6.1.2. Charging of access to railway infrastructure .......................................................... 61
6.2. Innovation of forming of trains on SR............................................................................... 686.2.1. The current situation of single wagon consignments in the Slovak Republic ........ 69
7. Proposed development of intermodal transport in the Slovak
Republic in relation to neighboring countries and prepared terminals
........................................................................................................ 73
8. Comparison of the cost ratio of railway, road and intermodal
transport ......................................................................................... 77
8.1. Transportation of chemical substances in IBC containers by road and railway transport . 77
8.1.1. Domestic and international transport according to the TR1 .................................... 77
8.1.2. Special transit prices D Cargo ZSSK Cargo for consignments of Ukraine - Germany
and vice versa ...................................................................................................................... 81
8.2. Summary in relation to the transport of dangerous goods ................................................ 82
9. Feasibility of selected projects and measures .................................. 83
Literature......................................................................................................87
List of abreviations ........................................................................................ 89
Annex of the study on CD .............................................................................. 90
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
6/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
6
Introduction
Within the frame of doing SWOT analysis of transporting chemicals in Slovakia, there were
formulated problems relating to transport logistic, in the project ChemLog:
mountainous terrain in Slovakiahigh infrastructure costsbridges, tunnels congested road network, traffic jams
not sufficient network of highways, expressways, rail corridors and modern multimodal
terminals
inland navigation possible only on Danube, as part of Rhine Main Danube Canal, withseasonal and local restrictions
inland stateno direct access to the sea
not existing classification of tunnels according to ADR (the transport of dangerous goods is
banned in all tunnels) and new bans are introduced in transporting of dangerous goods on
the important international transit roads, which have the impact to reducing the safety and
efficiency of transporting dangerous goods in road freight transport.
Constructions of public intermodal transport terminals
This created conditions for rail and intermodal transport of chemicals. Therefore, the study of
viability is focused on Development of railway transport of chemicals in Slovakia in relation to
adjacent countries and prepared combined transport terminals1.
1. Chemical industry in Slovakia and international tradeChemical industry is mainly located in Western Slovakia around Bratislava. This industry was built as
a part of eastern chemical industry based on Russian supplies. Big chemical companies use supplies
carried via pipeline network of crude petroleum Druba and natural gas. Small companies usually use
supplies of raw material from Europe.
The area of basic chemicals is represented by the companies as Slovnaft Bratislava, Duslo aa,
Novcke chemick zvody andChemko Strske.
In Bratislava as a business centre of Slovakia there are several chemical companies as refinery
Slovnaft and DusloIstrochem.
Several companies e.g. Duslo a.s. aa, Chemolak Smolenice, Zentiva Hlohovec, Slovkord Senica are
located in western Slovakia.
Middle part of Slovakia is represented by NCHZ Novky, Petrochema Dubov, Chemosvit Flie Svit,
Matador Continental Pchov.
1Given the well-established terminology of Ministry of Transport, Construction and Regional Development of the
Slovak Republic, in the next part oft he study, we will use the term intermodal transport.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
7/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
7
Eastern part of Slovakia is represented by Chemko Strske, Chemes Humen, Diakol Stske, Duslo
Hnojiv Strske.
The area of waste processing is represented by Detox Bansk Bystrica, MACH trade Sere andSitaSlovensko. Paints, varnishes and similar coatings are represented by Chemolak Smolenice, SlovZink
Koeca, Farbol Bratislava, EuroVat Alekince, Primalex Slovakia Doln Kubn, Pam-ak Chorvtsky
Grob, Inex Bratislava. Primalex Slovakia, Novochema Levice,
Pharmaceutical industry is represented by Zentiva Hlohovec and Degussa Slovakia Slovensk upa.
The biggest Slovak pharmaceutical producer - Zentiva Hlohovec is the part of the corporation Zentiva.
The biggest chemical company in Slovakia is refinery SLOVNAFT, a.s. located in Bratislava. The
company core business is production, warehousing, wholesale and retail sales and distribution.
SLOVNAFT Plc. dispose with the largest retail network in SK offering top quality motor fuels and
lubricants as well as related customer services.After intensive modernisation is these refinery very flexible and one of the tree most modern
refineries in Europe.
Installed conversion processes and high-density deep desulfurization allow produce of only sulphur-
free fuels.
Duslo a.s. aa is oriented on processing of natural gas to ammonia, urea, fertilizer based on
ammonium nitrate and other inorganic nitrogen products. Within organic chemistry there are rubber
industry chemicals, glues, agrochemicals, glues, dispersions, polypropylene fibres. Duslo as a part of
AGROFERT Holding is a part of the second biggest producer and distributor of fertilizers. In Bratislava,
there is located former company Istrochem, which is now fully integrated into the organizational
structure of Duslo a.s. This company produces rubber additives and agrochemicals. In the area of the
former company Istrochem is located branch office of the company Explozia Pardubice (continuator
of the Alfred Nobel tradition) as producer industrial explosives.
NCHZ Novky are focused on processing industrial salt by electrolysis to products of inorganic
chemistry (chlorine, sodium hydroxide, hydrogen, hydrochloric acid). In the field of inorganic
chemistry, NCHZ Novkyare the most important exporter of the calcium carbide, next in the field of
organic chemistry, they produce PVC and PVC products (window profile, siding, granulation products)
and also some products of organic chemistry and polyols.
Chemko is located in Strske and in it`s area there are located several companies - Chemza, Diakol,Duslo Hnojiv. Distribution of chemicals represent Brenttag Slovakia, BASF Slovensko, Messer
Tatragas, SIAD Slovensko, Safina Slovensko.
The start of the Millennium has brought new challenges as significant increase in competition from
Asia, strong globalization trends, strengthening of the Slovak crown course, strong growth of the
Slovak automotive and electronics industries, thanks to the state support too. Production volume of
chemical industry compared to named fields did not increase a lot, so the proportion of chemical and
pharmaceutical industry decreased from 17,2 % in 2000 to 15 % of Slovak industry turnover in 2006.
Similarly, the number of workers dropped from 18 791 to 11 573 in years 2000-2006 in the field of
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
8/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
8
chemicals and chemical products production. Share of export dropped from 26,7 % in 2000 to 23,1 %
in 2006.
At present, the chemical industry tries to keep its position in intensification international
competition, strict chemical legislation and total despite of the public to chemistry.
Actual crisis threatens chemical industry by decrease in sales and drop in prices of products.
Chemical industry is developing as a supplier of plastics and rubber products for the evolving
branches of automotive and building industry.
Fig. 1 Member firms ZCHFP SR
1.1. International trade
The data for international trade are available in Slovakia only according to TARIC. Following TARIC
chapters are presented for chemical industry.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
9/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
9
Chapter Name
27 MINERAL FUELS, MINERAL OILS AND PRODUCTS OF THEIR DISTILLATION; BITUMINOUS SUBSTANCES; MINERAL WAXES
28 INORGANIC CHEMICALS; ORGANIC OR INORGANIC COMPOUNDS OF PRECIOUS METALS, OF RARE-EARTH METALS, OF RADIOACTIVE
ELEMENTS OR OF ISOTOPES
29 ORGANIC CHEMICALS
30 PHARMACEUTICAL PRODUCTS
31 FERTILISERS
32 TANNING OR DYEING EXTRACTS; TANNINS AND THEIR DERIVATIVES; DYES, PIGMENTS AND OTHER COLOURING MATTER; PAINTS
AND VARNISHES; PUTTY AND OTHER MASTICS; INKS
33 ESSENTIAL OILS AND RESINOIDS; PERFUMERY, COSMETIC OR TOILET PREPARATIONS
34 SOAP, ORGANIC SURFACE-ACTIVE AGENTS, WASHING PREPARATIONS, LUBRICATING PREPARATIONS, ARTIFICIAL WAXES, PREPARED
WAXES, POLISHING OR SCOURING PREPARATIONS, CANDLES AND SIMILAR ARTICLES, MODELLING PASTES, DENTAL WAXES AND
DENTAL PREPARATIONS WITH A BASIS OF PLASTER
35 ALBUMINOIDAL SUBSTANCES; MODIFIED STARCHES; GLUES; ENZYMES
36 EXPLOSIVES; PYROTECHNIC PRODUCTS; MATCHES; PYROPHORIC ALLOYS; CERTAIN COMBUSTIBLE PREPARATIONS
37 PHOTOGRAPHIC OR CINEMATOGRAPHIC GOODS
38 MISCELLANEOUS CHEMICAL PRODUCTS
39 PLASTICS AND ARTICLES THEREOF
40 RUBBER AND ARTICLES THEREOF
54 MAN-MADE FILAMENTS; STRIP AND THE LIKE OF MAN-MADE TEXTILE MATERIALS
55 MAN-MADE STAPLE FIBRES
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
10/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
10
Fig. 2: Chemicals export
Fig. 3: Chemicals import
Tab. 1 Share of chemicals export from GDP
Export quota in % 2000 2001 2002 2003 2004 2005 2006 2007 2008
Manufacture of chemicals and chemical
products TARIC 28-38,54,55 5,49 5,53 5,15 4,07 3,98 3,93 3,93 2,93 2,65
Manufacture of plastic and rubber
products TARIC 39,40 4,46 4,59 4,83 4,68 4,72 4,99 5,20 4,50 3,66
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
11/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
11
Tab. 2 Share of chemicals export in the total Slovakia exports
Export quota in % 2000 2001 2002 2003 2004 2005 2006 2007
Manufacture of chemicals and chemical
productsTARIC 28-38,54,55
6,63% 6,41% 6,18% 4,50% 4,54% 4,60% 4,28% N/A
Manufacture of plastic and rubber
productsTARIC 39,40
5,39% 5,32% 5,80% 5,18% 5,38% 5,84% 5,66% N/A
Tab. 3 Import of chemicals in Mio EUR - SLOVAKIA
Import of chemicals in Mio EUR TARIC 2000 2001 2002 2003 2004
Manufacture of refined petroleum products 27 3432,9 3607,4 3328,8 3302,8 3940,5
Manufacture of basic chemicals 28,29 601,6 608,1 583,1 552,7 623,8
Manufacture of pesticides and other agro-chemical
products 31 28,2 33,4 32,1 26,3 39,5
Manufacture of paints, varnishes and similar
coatings, printing ink and mastics 32 176,1 194,5 208,8 222,8 249,9
Manufacture of pharmaceuticals, medicinal
chemicals and botanical products 30 532,5 627,2 709,4 709,3 895,4
Manufacture of soap and detergents, cleaning and
polishing preparations, perfumes and toilet
preparations 33,34 190,7 231,2 250,4 250,8 291,5
Manufacture of other chemical products 35,36,37,38 292,5 356,0 395,3 362,1 386,4
Manufacture of man-made fibres 54,55 223,1 265,8 270,0 262,6 255,8
Manufacture of chemicals and chemical products 28-
38,54,55 2044,6 2316,1 2449,1 2386,6 2742,1
Manufacture of rubber products 40 283,0 331,8 417,8 557,3 585,8
Manufacture of plastic products 39 734,8 897,6 1094,1 1335,0 1403,0
Manufacture of plastic and rubber products 39,40 1017,8 1229,3 1511,9 1892,3 1988,8
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
12/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
12
Continuation of the table
Import of chemicals in Mio EUR TARIC 2005 2006 2007 2008
Manufacture of refined petroleum products 27 4664,0 5882,2 5350,9 6535,8
Manufacture of basic chemicals 28,29 715,4 809,7 773,7 742,4
Manufacture of pesticides and other agro-chemical
products 31 39,3 54,6 78,9 140,6
Manufacture of paints, varnishes and similar coatings,
printing ink and mastics 32 269,9 330,8 330,5 316,3
Manufacture of pharmaceuticals, medicinal chemicals and
botanical products 30 985,9 1074,1 1147,7 1236,0
Manufacture of soap and detergents, cleaning and polishing
preparations, perfumes and toilet preparations 33,34 319,3 335,2 362,5 370,6
Manufacture of other chemical products 35,36,37,38 422,9 462,0 532,8 530,2
Manufacture of man-made fibres 54,55 248,6 260,0 241,0 195,6
Manufacture of chemicals and chemical products 28-38,54,55 3001,3 3326,4 3467,1 3531,7
Manufacture of rubber products 40 615,5 744,8 837,4 847,0
Manufacture of plastic products 39 1498,4 1814,3 1942,9 2005,0
Manufacture of plastic and rubber products 39,40 2113,9 2559,2 2780,4 2852,1
Source: Statistical office of the Slovak RepublicData for 2007, 2008 are preliminary data
Fig. 4 IMPORTManufacture of chemicals and chemical products
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
13/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
13
The continuous increase of import of chemical to Slovakia from 2000 is notable. The development of
the industry requires more chemical imports. Basic chemicals and pharmaceuticals have the highest
share.
Fig. 5 IMPORTManufacture of plastic and rubber products
There is a continuous increase of especially plastic products import in this segment. Because of
development of automotive industry in recent years, there is a need for more imports of plastics.
Tab. 4 Export of chemicals in Mio EUR
Export of chemicals in Mio EUR TARIC 2000 2001 2002 2003 2004
Manufacture of refined petroleum products 27 1273,9 1336,6 1311,6 1381,8 1910,5
Manufacture of basic chemicals 28,29 526,8 526,5 521,9 426,9 465,9
Manufacture of pesticides and other agro-chemical
products 31 88,1 107,9 91,8 97,8 124,9
Manufacture of paints, varnishes and similar coatings,
printing ink and mastics 32 15,9 17,3 13,5 12,5 14,5
Manufacture of pharmaceuticals, medicinal chemicals
and botanical products 30 114,4 141,7 150,3 143,2 178,0
Manufacture of soap and detergents, cleaning and
polishing preparations, perfumes and toilet
preparations 33,34 74,8 89,4 91,8 84,6 86,6
Manufacture of other chemical products 35,36,37,38 97,6 117,2 161,2 142,9 150,3
Manufacture of man-made fibres 54,55 290,5 300,2 308,0 292,5 332,5
IMPORT - Manufacture of plastic and rubber products
0,0
500,0
1 000,0
1 500,0
2 000,0
2 500,0
3 000,0
2000 2001 2002 2003 2004 2005 2006 2007 2008
Mil.
EUR
Manufacture of rubber products**** Manufacture of plastic products*****
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
14/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
14
Export of chemicals in Mio EUR TARIC 2000 2001 2002 2003 2004
Manufacture of chemicals and chemical products 28-
38,54,55 1208,1 1300,2 1338,5 1200,5 1352,7
Manufacture of rubber products 40 333,1 434,3 559,3 653,2 755,6
Manufacture of plastic products 39 648,0 644,4 695,7 728,2 847,9
Manufacture of plastic and rubber products 981,1 1078,8 1255,0 1381,5 1603,5
Continuation of the table
Export of chemicals in Mio EUR TARIC 2005 2006 2007 2008
Manufacture of refined petroleum products 27 2236,6 2408,1 2301,7 2589,1
Manufacture of basic chemicals 28,29 515,1 542,7 513,2 524,9
Manufacture of pesticides and other agro-
chemical products 31 126,7 132,9 138,4 201,9
Manufacture of paints, varnishes and similar
coatings, printing ink and mastics 32 25,3 151,7 77,8 66,4
Manufacture of pharmaceuticals, medicinal
chemicals and botanical products 30 245,1 261,6 247,5 265,2
Manufacture of soap and detergents, cleaning
and polishing preparations, perfumes and toilet
preparations 33,34 100,0 113,2 118,9 186,1
Manufacture of other chemical products 35,36,37,38 177,0 202,1 203,0 217,2
Manufacture of man-made fibres 54,55 324,2 345,5 308,7 258,2
Manufacture of chemicals and chemical products 28-38,54,55 1513,4 1749,7 1607,5 1719,8
Manufacture of rubber products 40 850,4 924,8 933,3 945,3
Manufacture of plastic products 39 1070,1 1389,6 1530,9 1425,2
Manufacture of plastic and rubber products 39,40 1920,5 2314,4 2464,2 2370,5
Source: Statistical office of the Slovak RepublicData for 2007, 2008 are preliminary data
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
15/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
15
Fig. 6: EXPORTManufacture of chemicals and chemical products
The biggest share of chemicals and chemical products export has manufacture of basic chemicals,
manufacture of pharmaceuticals, medicinal chemicals and botanical products and manufacture of
man-made fibres.
Fig. 7 IMPORTManufacture of plastic and rubber products
There is an increasing trend with a slight decrease in 2008 in this sector. The most dominating share
has manufacture of plastic products.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
16/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
16
Tab. 5: Geographic breakdown of chemicals export in %
Geographic
breakdown of
chemicals export in %
2000 2001 2002 2003 2004 2005 2006 2007 2008
EU 27 87,42 88,10 88,95 89,70 88,36 86,94 87,65 88,68 88,62
EU 15 40,10 42,73 47,29 49,02 48,56 46,05 47,26 48,42 46,58
Estonia, Latvia,
Lithuania, Malta,
Poland, Slovenia,
Czech Republic,
Hungary, Cyprus 44,81 42,81 38,96 37,97 37,06 37,88 37,68 37,37 39,19
Bulgaria, Romania 2,51 2,56 2,70 2,70 2,74 3,01 2,72 2,89 2,86
Rest of Europe 5,37 5,30 5,08 4,92 5,93 6,75 7,12 7,44 7,51
NAFTA (USA, Canada,
Mexico) 2,92 2,31 1,92 1,83 2,10 1,97 1,24 0,87 0,66
Latin America and the
Caribbean 0,38 0,32 0,25 0,20 0,29 0,34 0,33 0,33 0,42
Asia 3,40 3,48 3,09 2,79 2,74 3,39 3,10 2,08 2,11
Africa 0,29 0,35 0,56 0,38 0,45 0,48 0,52 0,56 0,63
Australia / Oceania 0,22 0,15 0,15 0,19 0,14 0,13 0,05 0,05 0,05
Source: Statistical office of the Slovak RepublicData for 2007, 2008 are preliminary data.
Geografic breakdown of chemicals export is for TARIC codes28-40, 54-55
Fig. 8 Geografic breakdown of chemicals export for TARIC codes28-40. 54,55
More than 90 % of all export of chemicals is to European countries with more than 40 % to EU 15.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
17/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
17
Tab. 6 Geographic breakdown of chemicals import in %
Geographic breakdown of
chemicals import in %
2000 2001 2002 2003 2004 2005 2006 2007 2008
EU 27 85,04 84,81 84,49 85,03 84,16 85,17 83,35 82,46 81,93
EU 15 59,22 61,04 62,30 62,92 60,83 58,40 55,07 55,05 55,01
Estonia, Latvia, Lithuania,
Malta, Poland, Slovenia, Czech
Republic, Hungary, Cyprus
25,50 23,56 21,91 21,85 22,93 26,45 27,96 27,04 26,52
Bulgaria, Romania 0,32 0,21 0,27 0,25 0,40 0,32 0,31 0,37 0,40
Rest of Europe 7,04 7,01 6,42 5,82 5,67 5,56 6,22 6,37 6,35
NAFTA (USA, Canada, Mexico) 2,79 2,80 3,00 2,63 2,47 2,09 1,97 1,86 1,99
Latin America and the
Caribbean 0,22 0,17 0,17 0,52 0,94 0,98 1,05 1,01 1,03
Asia 4,81 5,10 5,76 5,82 6,56 5,98 7,16 8,12 8,48
Africa 0,08 0,09 0,11 0,11 0,13 0,15 0,17 0,11 0,16
Australia / Oceania0,02 0,02 0,05 0,08 0,07 0,05 0,09 0,07 0,06
Source: Statistical office of the Slovak RepublicData for 2007, 2008 are preliminary data. Geografic
breakdown of chemicals export is for TARIC codes28-40, 54-55
Fig. 9 Geografic breakdown of chemicals import for TARIC codes28-40. 54,55
About 90 % of all imported chemicals are from European countries with about 60 % from EU 15.
The above analysis shows, that there are sources of transportation for the application of intermodal
rail transport of chemicals from Slovakia to Europe and conversely.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
18/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
18
Because of this volume of chemicals export and import listed above, it is clear, that the basic
transport infrastructure can not be built just for chemical industry. On the opposite site, the
transportation of chemicals is very important and because of road transport restrictions on
chemicals, railway and intermodal transport can be alternative to road transport.
2. Bans for transport of dangerous goods in Slovakia and
possibilities of rail and intermodal transport
By now, there has not been established the classification of tunnels according to ADR in Slovakia (the
transport of dangerous goods is banned in all tunnels) and new bans are introduced in transporting
of dangerous goods on the important international transit roads, what have the impact to reducing
the safety and efficiency of transporting dangerous goods in road freight transport.
Below road traffic bans for transport of dangerous goods in Slovakia, also on the main motorway
network. These prohibitions in road freight transport create the opportunities for the development
of intermodal transport of dangerous goods in Slovakia.
Slovak Road Administration, Department Road Databank, focuses also on variable and non-variable
parameters of road communications.
Road Databank department collects data by track-measuring cars, all kinds of traffic signs but
because of their large number, the collection is realized according to certain rules.
There are only 49 traffic signs B21 a B22 (January 15, 2010) in database of Slovak Road
Administration (see Fig. 11). They are collected only on the new build road network sections, where
measurements were carry out over the last months
Fig. 10 Traffic signs B21 and B22 on the Slovak road network (Source: Road Databank of SlovakRoad Administration)
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
19/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
19
Following figures show more detailed maps of bans for transport of dangerous goods in selection
sections of Slovakia road network.
Fig. 11 Traffic signs B21 and B22 in the area of Bratislava (D1, D2 Sitina Tunnel and motorway
connection to Austria) and the area of Pieany (no entry to D1 and alternative route through the
Pieany city)
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
20/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
20
Fig. 12 Total bans for transport of dangerous goods through the Branisko tunnel and alternative
routes over Branisko mountain range.
2.1. Classification of tunnels in Slovakia
By now, there has not been established the classification of tunnels according to ADR in Slovakia. At
present, the transport of dangerous goods is banned in all tunnels in Slovakia (including vehicles
carrying empty not cleaned packages and tanks). Classification of tunnels is prepared according to
ADR.
Building motorways through the north part of Middle Slovakia is technically and financially very
difficult. It is needed to build many bridges and road tunnels in this area. Figure 14 show the planned
location of road tunnels in Slovakia. Operated tunnels are Sitina, Horelica, Brik and Branisko (blackcolour). Branisko tunnel is the longest tunnel (4975 m) at present. Oviarsko, Poana and Viove
tunnels are under construction (red colour). When Viove tunnel is in operation, it will be the
longest tunnel in Slovakia with a length of 7460 m. By gradual construction of motorway D1 between
Bratislava and Koice, planned motorway D3 from ilina to Warsaw and Bratislava bypass, it should
be constructed another 15 road tunnels.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
21/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
21
Fig. 13 Layout of tunnels in Slovakia2
Because of the information listed above, it can be said, that the transport of dangerous goods in
Slovakia will be also after motorway network construction restricted by bans which have the effect
on traffic safety and efficiency of road transport. Because of that, there is a space for development of
railway respectively intermodal transport of dangerous goods.
2Source: National Highway Company - www.ndsas.sk
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
22/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
22
3. Intermodal transport equipments for chemical industry
In regard of the scope of the feasibility study for development of intermodal transport of chemicals,
we had to analyse intermodal transport equipments for chemical industry.
In practice, we recognize a number of loading units3 for cargo transport, the chemical industry
including. Transportation of chemicals can be divided as follows:
Chemicals can be classified as safe and dangerous cargo. Method of transport unit selection depends
on this basis. The cargo can be divided into general cargo and bulk cargo in solid, liquid and gaseous
state. The selection of the adequate transport unit for intermodal transport is based on the kind of
cargo.
According to the regulations for the transport of dangerous goods, this transport can be divided into
transportation:
General cargo (packages, IBC containers, large packages)
o By Open-top vehicles, wagons, containers and swap bodies
o By closed vehicles, wagons and containers
o Sheeted vehicles, wagons and containers
Bulk cargo
In tanks
o Road tankers, tank wagons
3In practice, it is using the concept: intermodal transport unit, the loading unit of intermodal transport.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
23/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
23
o Demountable tanks
o Battery vehicles
o MEGC - Multiple-Element Gas Container
o Tank containers
o Portable tanks (IMDG, ADR, RID)
o Tank swap bodies
General cargo transportation can be realized by following intermodal transport units:
Containers
o Shipping containers ISO series 1
Gcontainers for general use
Vcontainers for general use with ventilation
R, HThermal containers UOpen Top containers
o ACTS containers
Swap bodies
o Class A (to 32 tons)
o Class C (to 16 tons)
Trailers
o For RO-RO and LO-LO handling
Standard ( LO-LO only basket wagons or special reloading)
With points for pair of tongs - handling suspension frame
Bulk cargo transportation can be realized by following intermodal transport units:
Containers
o Shipping containers ISO series 1
BBulk containers (for dry bulk materials)
Ttank containers
TNfor safe liquid with codes T0T2
TDfor dangerous liquid with codes T3T6
TGfor gases with codes T7T9
o ACTS containers
Swap bodies
o Tank swap bodies
o Bulk swap bodies
Trailers
o Tank trailers
Large containers, portable tanks and tank containers which verify the definition of container in the
CSC can not be used for transportation of dangerous goods, when the large container or the frame of
the portable tank or the tank container does not comply with provisions CSC or with Letters UIC No.
591 and 592-2592-4.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
24/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
24
Large container can be used for transportation only if it was structurally serviceable.
In the case of transport of dangerous goods in road tanker, tank wagon and portable tanks, the
deciding thing for the correct choice of transport unit is the code of the tank according to ADR, RID or
the code of the portable tank according to IMDG, ADR, RID and chemical compatibility of the tank
material with transported substance.
ADR, RID, IMDG definitive also a hierarchy of tanks, i.e. there can be transported the substance with
its code with substance with lower code in hierarchy in one tank, if it is in regard to chemical
compatibility.
Fig. 14 Container EMT5ADR/RID - L4BH - 37 000 L in stainless boiler designit can be
transported 78 % liquids according to ADR/RID, where the transport of liquids is allowed
Fig. 15 22T6ADR/RID/IMDG portable tanks UN T22 for dangerous liquid17 500 lfor
substances with instructions T1 to T22
Class
Code of tank
3 4.1 5.1 6.1 6.2 8 9 Grand total
L1.5BN 43 43
L4BH 82 276 2 2 362
L4BN 65 15 202 1 283
LGAV 1 2 3
LGBF 330 330
LGBV 1 3 14 2 20
Grand total 522 3 29 276 2 202 7 1041
from1328liquids
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
25/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
25
Fig. 16 22T9portable tank for not chilling liquefied gases UN T50 with sun protection24 000 l -
68 substances in class 2
Tab. 7 Number of dangerous substances which are suitable for transportation in type approved
vehicles for transport in tanks according to ADR agreement
Vehicle/ Classes of dangerous AT EX/III FL OX Transport in tanks not allowed Grand total
1 2 373 375
2 97 77 55 229
3 2 558 12 572
4.1 62 68 130
4.2 82 23 105
4.3 85 10 31 126
5.1 144 2 21 167
5.2 4 16 20
6.1 592 106 9 707
6.2 3 7 10
7 3 22 25
8 325 31 11 367
9 16 23 39
Grand total 1415 2 782 2 671 2872
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
26/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
26
Tank containers and portable tanks owned by carrier hauliers or hired in abroad are using in practice.
Some road carrier hauliers use portable tanks instead of road tanker. For overseas transportations,
producers of chemicals and forwarding companies use hired tank containers from their owners
respectively landlords. Rental price for tank container is from 7 to 15 per day4.
Standard ISO shipping containers are held by marine carriers and can be used mainly for maritime
transport.
Inland containers park with doors on the side of the SKDS Intrans period has tumbled-down and
now they are not available. They are available in abroad to a lesser degree (eg MSC).
There are a very few swap bodies in Slovakia, same as manipulable road trailers.
There are many reasons and they can be summarized as follows. Not all intermodal terminals are
equipped with technical equipments for handling of swap bodies and manipulable road trailers, i.e.
pairs of tongs, which are assembling as a folding fitted in the most modern execution to the
spreader. So comes into existence the universal container hanging frame for all known and
standardized intermodal loading units. According to the surveys and ascertaining of the Ministry of
transport, posts and telecommunications of the Slovak Republic, from the November 1, 2010
Ministry of Transport, Construction and Regional Development of the Slovak Republic, the existing
operators of containers terminals privatized in the 90`s and intermodal terminals, that has been built
later from private sources are aimed at so-called hinterland port service, it means overseas
intermodal transport realized only in containers according to ISO. According to surveys, these
terminal operators do not think about the introduction of continental intermodal transport that isusually realized in swap bodies or manipulable road trailers. Exceptions are only tank containers,
which are used in overseas as well as in continental intermodal transport. It implies the recognition,
that there is minimal interest in continental intermodal transport at present. Continental intermodal
transport is much extended in Western Europe, especially in chemical industry and already, there is a
pressure from forwarders to implement this kind of transport to Central and Southeast Europe and it
will rise.
Owners of swap bodies or manipulable road trailers are forwarding companies and carrier hauliers,
which realize continental intermodal transport. There is a major producer of swap bodies KEREX
Michalovce in Slovakia, but these the most exported. Important producer of wagons for intermodaltransport is TatraVagnka Poprad. Based on the recorded information from the producer of trailers,
the different between the price of platform trailer and trailer designed for vertical reloading is
approximately 2000 .
Tankcontainers for chemical industry can carry several types of chemical products, but there are also
specialized tankcontainers, which can carry only one product.
4
Source: Podstawka,V.: Tankkontejner: Prostedek pro vce druh peprav. In: Nebezpen nklad 5/2010,str.10-12, ISSN 1803-1579
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
27/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
27
Bogies for tank containers and portable tanks are usually design for 20` and 30` dimensions and they
are shorter than for 40` containers, and it can be saved about 1 ton from 44 tons of total weight of
road train and it can be very interesting. There is a problem in Slovakia because of the legislation5,
which determines the maximum permissible weight of vehicles and road trains and it says about total
weights 44 tones of road train for transporting ISO container(40 feet) in intermodal transport.In
preparation of this legislation we sent the comments to creators on this formulation, where we were
reminded the issue of higher total weight also for 20`and 30`containers, but our comments weren`t
incorporated. The legislative Council of the Government did not pass the proposal of the
Government about allowance of the total weight not only for transport of tank containers, but also
for manipulable road trailers in the territory of Slovakia. European Union allows exceptions like this
for the territory of Member states and for Member states is this ability for intermodal transport
sufficient, because it is sufficient for collection or distribution to the nearest appropriate intermodal
terminal.
5Nariadenie vldy 349/2009 Z.z. o najvch prpustnch rozmeroch vozidiel a jazdnch sprav, najvch
prpustnch hmotnostiach vozidiel a jazdnch sprav, alch technickch poiadavkch na vozidl a jazdnspravy v svislosti s hmotnosami a rozmermi a o oznaovan vozidiel a jazdnch sprav (GovernmentRegulation No. 349/2009 about the largest allowable dimensions of vehicles and road trains, the largest
weights of vehicles and road trains, other technical requirements for vehicles and road trains in relation toweights and dimensions and about marking of vehicles and road trains.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
28/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
28
4. Intermodal transport in Slovakia and in relation to Europe
4.1. Performances in intermodal transport in Slovakia
The intermodal transport in Slovakia has gone over the complex evolution since 1993. It was because
of the break in continuity of the transport growing and it was because of the:
- market collapse in countries of the Council for Mutual Economic Assistance (CMEA),
- formation of the Slovak Republic
- changes in regulations of a market economy
Between years 19911994 there was a decrease in intermodal transport, but since 1995 volume of
the intermodal transport has grown up. In 1994 the share of intermodal transport in total railwaytransportation increased to the 0,33 % and in 2002 to 1,53 %. In this year, there has been
transported 756 300 tons in intermodal transport. From 1993 to 2006 intermodal transport in
Slovakia developed with 16 % of annual increment. Big share of the intermodal transport had transit
transport and its share in total volume of transportation has still declined and it has come up to
Slovak import and export. In 2006 the growth of intermodal transport slowed down and in 2007 it
increased about 12 %, what was due to the start of production in KIA MOTORS in Teplika nad
Vhom, the start of the terminal operation in Dunajsk Streda and expansion of container terminal in
ilina.
The following table shows the volumes of the transported goods in intermodal transport in 2009.
Fig. 17 Volume of transported goods to the year 2009 [Source: Ministry of Transport, Construction
and Regional Development of the Slovak Republic]
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
29/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
29
Fig. 18 ZSSK Cargo traffic flows in intermodal transport in 2009
4.2. Present intermodal terminals in Slovakia
Existing intermodal terminal was originally built as container terminals of the evolving container
transport system in terms of the cooperation of former CMEA countries. After the change of political
system and transition to a market economy, also intermodal terminals were privatized by private
sector. There was a vision, that private capital has modernized slowly decadent transhipment centres
and revitalized them. But this assumption was not fulfilled. Most transhipment centres gradually
decayed and some of them were closed ( Ruomberok) or aborted (Nitra, Bansk Bystrica). Revival of
some transhipment centres was after some years or decades, when investors from abroad started to
move their activities to Slovakia, what evocated demand for transportation. Increase of
performances in freight transport (also in intermodal transport) resulted that excepted that the
original container terminals were revitalized, there were built or adopted new intermodal terminals
such as in Dunajsk Streda or Sldkoviovo (private).
At present, there are 8 intermodal terminals in service in Slovakia:
Dobr TransContainer - Slovakia, a.s.
Bratislava UNSSKD Intrans, a.s.
Bratislava Plenisko Maersk
ilina SKD Intrans, a.s.
Koice SKD Intrans, a.s.
Haniska pri Koiciach - Metrans (Danubia), a.s.
Dunajsk Streda Metrans (Danubia), a.s.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
30/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
30
Sldkoviovo Green Logistics Slovakia
With exception of the intermodal terminals in Dunajsk Streda and Dobr, the location of all other
intermodal terminals are not suitable for next widening to be according to AGTC, especially tracklength, capacity and layout of areas and connection to the major rail and road network. All the
existing intermodal terminals do not verify non-discriminatory demand of access to terminal services,
i.e. openness and trade neutrality (all of them are owned by private operators, who realize here
especially their own commercial activities and activities for their needs).
4.2.1 Intermodal terminal Dobr
The intermodal terminal was put into service on August 10, 2002. Strategic priority of the terminal
was set by AGTC agreement. Financially, the building was secured from state budget (334,6 mil. )
and from private source of ZSR (117,983 mil. ). At present the intermodal terminal is hired byTransContainerSlovakia, a.p. In more detail, intermodal terminal is characterized in chapter 5.2.
Fig. 19 Intermodal terminal Dobr on the border with Ukraine
4.2.2. Intermodal terminal Bratislava NS
The intermodal terminal was put into service in 1978 and it is directly connected to the AGTC lines.
Operator is SKD Intrans, a.s. The total area is 49 950 m2. Theoretical transhipment capacity is more
than 28 000 ITU per year. Storage area is 15 000 m2. Intermodal terminal has 2 transhipment tracks
with a length of 300 m on which work 2 reachstackers Kalmar with load capacity of 41 tons and with
the possibility of transhipment of large containers (also 9,5 ft. Container, so called High Cube
container), swap bodies and road trailers. On the handling track no. 403 is built front drive-up ramp
allowing horizontal loading of road trains on the special railway trains transported in RO-LA system.
As extension and backup transhipment equipment is there older construction side forklift type
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
31/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
31
Battioni e Pagani with load capacity of 35 tons. Intermodal terminal is suitable for transhipment,
storage, marking of chemicals and dangerous substances (in tank containers, respectively tank swap
bodies and trailers). There are connections to thermal containers in terminal. Terminal is enclosure
and guarded by SBS. From terminal, container trains lead to Koper, with transhipment via Prague to
Hamburg, Bremerhaven and Rotterdam.
Fig. 20 Intermodal terminal Bratislava NS (source: SKD Intrans)
Fig. 21 Stacking crane Kalmar and side forklift Battioni e Pagani
4.2.3. Intermodal terminal Bratislava - Plenisko
This intermodal terminal is the only three-modal (road-railway-waterway transport) terminal
in Slovakia. It has a good geographical location. It is located nearly in the middle of
international waterway connecting - Black Sea and North Sea (also by Danube - MainRhine
Canal) and it is also connected to AGTC lines and available from the main road corridors in Slovakia
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
32/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
32
(motorways D1 and D2). Operator of this terminal is Maersk. Total area of the terminal is 15 000 m2,
the storage area is 12 700 m2. It has three transhipment tracks with a useful length of 250 m. The
terminal is equipped with two gantry cranes KSB with load capacity of 32 and 20 tons and with three
crane lifts with a boom LUNA with load capacity of 40, 40 and 42 tons. There can be transhipment
only large containers (including thermal and tank containers) in the terminal. From the terminal are
dispatched complete container trains on relation BratislavaMelnikBremerhaven.
Next expansion of the terminal is not possible because of geographic terms.
Fig. 22 Intermodal terminal BratislavaPlenisko (source: authors)
4.2.4 Intermodal terminal ilina
The intermodal terminal was put into service in 1981, it is located in the area of the marshalling yard
(nov harfa) in the urban area of ilina and it has direct connection to AGTC lines and easy access to
motorway D3. Operator is SKD INTRANS, a.s. Because of the growing performances associated with
development of automotive industry round ilina, the terminal expands, but only to length. Because
of the location of the terminal in densely built-up urban area of ilina, complex terminal extension is
impossible. The expansion of the terminal area from the original 9000 m2to 26 000 m
2is in the final
phase. The terminal is equipped with three crane lifts with a boom with load capacity of 41 and 51
tons and they can stack large containers in 4 - 5 layers. Transhipment is possible between road and
rail.
Theoretical transhipment terminal capacity is over 200 000 ITU per year and the storage capacity is
1 500 TEU. The terminal has four handling tracks with length of 430 m, 330 m and 450 m.
To the terminal are directed especially complete containers trains from the port of Koper. Apart from
the main terminal operations, there are realized many complementary services, such as loading and
unloading of containers, fixation of shipments, storage of goods, customs services, thermal container
supplying, handling and storage of chemicals and dangerous substances, transhipment of steel coils,
etc. Excepting large containers, it is possible to handle also with swap bodies or road trailers. The
terminal is enclosure and guarded, it is customs area. Operator (Intrans SKD) is owner of AEO
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
33/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
33
Certificate (authorized economic operator), whose main advantages are simplified and accelerated in
customs procedure.
Fig. 23 Intermodal terminal ilina (source: SKD Intrans)
4.2.5 Intermodal terminal Koice
The terminal is located in railway station Koice, where it forms an independent circuit and it was put
into service in 1978. Operator in terminal is SKD Intrans, a.s. Transhipment is possible between road
and rail. The total area of intermodal terminal is 17 800 m2. Transhipment capacity of the terminal is
43 690 ITU per year. There are two handling tracks with useful length of 350 m in the terminal. The
terminal is equipped with one stacking crane lifts with a boom with load capacity of 41 tons.
At present, the terminal is due to the lack of goods exploited only partially and it has limited
operation. Because of the inconvenient geographical conditions, opportunities of terminal
development are limited.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
34/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
34
Fig. 24 Intermodal terminal Koice (source: authors)
4.2.6 Intermodal terminal Koice Vek Ida
Terminal is in operation since 2007 and is located in U.S. Steel Koice area on the siding Iterport 6.
Terminal operator is Metrans (Danubia), a.s. Transhipment is possible between road and rail. The
total area of intermodal terminal is 25 000 m2 with storage capacity of 3000 TEU. Terminal is
equipped with two tracks with useful length of 300 m and large containers are transhipped by two
stacking crane lifts with a boom with load capacity of 42 tons and large empty containers are
transhipped by one stacking crane lifts with a boom with load capacity of 8 tons. In terminal, it is
possible to manipulate only with containers including ISO 1 tank containers. Terminal also offers
services of cleaning, repairing and deposition of empty containers (2000 TEU). Terminal has train
connection through intermodal terminal Dunajsk Streda to the port of Koper and through
intermodal terminals Dunajsk Streda and Prague to ports of Hamburg, Bremerhaven and
Rotterdam.
Fig. 25 Intermodal terminal Koice Vek Ida (source:www.metrans.cz)
6Source: www.metrans.cz, [December 16, 2010]
http://www.metrans.cz/http://www.metrans.cz/http://www.metrans.cz/http://www.metrans.cz/ -
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
35/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
35
4.2.7 Intermodal terminal Dunajsk Streda
Intermodal terminal Dunajsk Streda is private terminal of the Metrans (Danubia), a.s.
Dunajsk Streda and this company is also the terminal operator. The terminal was put into
service in 2007 and partially according to AGTC standards. Transhipment is possible between road
and rail. Terminal has annual operating capacity of 550 000 TEU and total area of 285 000 m2with
storage capacity up to 25 000 TEU. The capacity of stockpiling area for empty large containers is
15 000 TEU. There are 3 gantry track cranes with load capacity of 36 tons, 4 stacking crane lifts with a
boom for handling with empty containers with load capacity of 8 tons. Terminal is equipped with
nine tracks (every with useful length of 650 m). In terminal, it is possible to manipulate with
containers ISO 1(including tank and tank containers). Terminal offers also complementary services
like cleaning, repairing and deposition of the empty large containers. Terminal has direct train
connection to Koper and through Prague to Hamburg, Bremerhaven and Rotterdam.
Fig. 26 Intermodal terminal Dunajsk Streda (source:www.metrans.cz)
http://www.metrans.cz/http://www.metrans.cz/http://www.metrans.cz/http://www.metrans.cz/ -
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
36/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
36
4.2.8. Intermodal terminal Sldkoviovo
Terminal Sldkoviovo is non-public terminal owned by Green Integrated Logistics Ltd. company. It is
located at premises of the sugar factory and it is specially focus on the operating with regular trains
from Bremerhaven, Rotterdam and Koper at Samsung company in Galanta. Total area of intermodal
terminal is 60 000 m2, the storage area represent 45 000 m
2of total area. Terminal is equipped with
three transhipment tracks with useful length of 1 474 m, 496 m and 174 m. There is one track crane
with load capacity of 36 tons for handling with large containers and three stacking crane lifts with a
boom with load capacity of 45 tons. Theoretical terminal transhipment capacity is 30 000 TEU per
year and storage capacity is 8 000 TEU.
Fig. 27 Intermodal terminal Sldkoviovo (scheme) (source: Green Integrated Logistics)
Fig. 28 Overhead container crane in intermodal terminal Sldkoviovo (source: Green Integrated
Logistics)
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
37/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
37
Tab. 8 Performance of terminals in Slovakia in 2009 (Source: Ministry of Transport, Construction
and Regional Development of the Slovak Republic)
Terminal Tons ITU
Dunajsk Streda - Metrans 802 178 64 847Bratislava Plenisko - Maersk 221 980 22 040
Sldkoviovo- Green Logistics 133 900 6 905
ilina - Intrans 196 225 16 600
Dobr - TransContainer 12 835 1 406
Bratislava UNS - Intrans 59 887 2 114
Koice - Intrans 13 044 282
Total 1 440 049 114 194
Fig. 29 Quantity of transported goods through terminals in 2009
4.2.9. Characteristics of terminals out of order
There are 4 intermodal terminals out of order in Slovakia:
Ruomberok Liskov
RO-LA tranship center Nov Zmky
RO-LA tranship center Trsten
ierna nad Tisou
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
38/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
38
4.2.9.1. Intermodal terminal Ruomberok Liskov
Terminal was built from own investments of SR. It is a terminal with regional significance which
should be oriented to the production of pulp-mill in Ruomberok. It is intended for transhipment oflarge containers and for collection and distribution in attraction circuit. Total area of terminal is
35 372 m2. Theoretical terminal transhipment capacity is 33 000 ITU per year. Intermodal terminal
has three transhipment tracks with useful length of 360 m, 310 m and 310 m. Terminal is equipped
with one gantry track crane with load capacity of 40 tons. At present, its operation is stopped.
Fig. 30 Intermodal terminal in Ruomberok (source: SR)
4.2.9.2 RO-LA transshipment Nov Zmky
This was a transshipment centre of transport system for transportation of road train RO-LA system.
Construction of this transshipment center secured private company OZN, Ltd. Nov Zmky underconditions of Support programme for development of intermodal transport in Slovakia and by
Government approved Concept of transport development. Tranship centre was built on the
crossroads AGTC (C-E52, C-L61). After marketing research of potential interested persons for RO-LA
system from existing carrier hauliers, the operation of the terminal was launched on November 2,
1998. During the operation of tranship centre (from 11-02-1998 to 06-01-1999) on the line Nov
Zmky Wels went 180 train sets with 800 road trains. Despite the public grants from the state
budget and vantage determination of collection and distribution distance (150 km) around Wels
without transport conditions, terminal had problems with capacity utilization. The line was at the end
cancelled due to removing of the wagons Saadkms by the Austrian partner for transport in Austria. At
present, rail yard is physically destroyed.
4.2.9.3 RO-LA Tranship centre Trsten
In the district of Trsten station can be loaded and unloaded road trains on level reinforced handling
track, beside which it is possible to place the mobile front ramp for loading and unloading of road
trains on special railway wagons with sunken floor. These transportations were performed as a test
and since that time, they have not been realized.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
39/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
39
Fig. 31 Unloading of road trains at the railway station Trsten (source: authors)
4.2.9.4 Intermodal terminal ierna nad Tisou
Intermodal terminal was situated at premises of railway station in ierna nad Tisou. Because of the
lack of load and existing of nearly new modern terminal in Dobr, terminal in ierna nad Tisou was
cancelled. At present, handling area of the former terminal and gantry overhead track crane are used
for transhipment of steel products.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
40/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
40
Fig. 32 Intermodal terminals relation to road and rail network in Slovakia and selected companies
of chemical industry
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
41/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
41
Fig. 33 Regular intermodal connections for transhipments from Slovakia
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
42/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
42
4.3. Planned intermodal terminals in Slovakia at the state level
4.3.1. Intermodal terminal ilina Teplika
Terminal should start its operation in 2012. Planned terminal is located between the rail track ilina
Vrtky and water dam ilina in close vicinity of train formation yard (TFY) Teplika nad Vhom.
Terminal will perform handling of intermodal transport units (ITU) from road to rail and vice versa as
well as storage of ITU. There is planned the construction of 5 tracks in the final version of the
terminal, of which 4 will be operated by two gantry track cranes with lifting capacity of 45 tons,
transhipping goods between vehicles themselves (train/train, train/truck and vice versa) or from
means of transport to the storage area and vice versa. One rail track will be able to used for RO-LA
transport (road trains will be loaded trough the front ramp to the platform of special railway wagonand will continue by train). Terminal will perform transhipment of ITU from ilina region and
northern part of Trenn region, eventually it will complement RO-LA lines from north to south.
Terminal lays on the crossing of rail tracks AGTC CE40 and CE63 and its attraction circuit with the
range of 80 km is possible to serve the whole ilina region, northern parts of Trenn region and
Ostrava region in Czech Republic and south part of Katovice region in Poland. Terminal is projected to
be an input and connecting terminal for transports in all ways and it will be a part of logistic centre of
northern Slovakia in the future. Inland layout of terminal is designed with track groups and functional
units side by side. They will be from railway to site pound lock in this order:
Road to ensure mutual access to mobile front ramps for loading and unloading ofroad trains transported under the RO-LA system
Entrance and exit group of tracks with one track for RO-LA transport
Handling tracks of terminal
Terminal
Road for circumvention of the terminal
Reserve space for future storage and handling areas for spoil-tit
Intermodal terminal ilina will be a powerful terminal with a big capacity and it will performe a
function of terminal in connection to logistic centres and because of that, there are designed
equipments and technology below:
2 gantry track cranes
1 light construction stacker for empty loading units
Handler transhipment technology with elements of current work method with one circuit
Vertical container transhipment of swap bodies and trailers
The possibility of horizontal loading and unloading of road trains under the RO-LA
Complementary services provided in terminal
Customs clearance
Repairs and revisions of containers and swap bodies Social facilities and food services
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
43/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
43
Logistics services
Advisory and information services
In the time of the anticipated starting-up operation of the terminal (it is expected earliest in 2012), in
the first year of terminal operation, transport flow inbound to the attraction circuit should achieve
around 200 000 tons of goods for intermodal transport and transport flow outbound from attraction
circuit around 300 000 tons (without volumes of goods from KIA Motors). In routine operation, it can
be expected gradual growing of the volume of transported goods. This implies the need for
intermodal transportation around 500 000 tons per year of goods in the region. This volume of good
represent around 30 000 ITU per year, if there are 16,5 tons in one ITU. The total number of ITU in
the crane radius is 3598 TEU. The total number of empty ITU in the storage area is 1998 TEU. There
are 33 lay-bys for swap bodies in terminal. The area of stored ITU in the crane radius is 31 587 m2.
The area of empty stored ITU is 23 817 m
2
. Length of the crane track is same for both cranes - 750 m,so it is possible to serve whole train without sliding. Minimal length of the tracks under the crane
must be 750 m, according to AGTC. In the interest of using crane track, all designed handling tracks
are longer than 750 m.
Fig. 34 Visualization of new terminal in ilina Teplika
7
7Prochc E.: Terminal of intermodal transport ilina, Conference Infrastructure of intermodal transport
www.intermodal.sk
http://www.intermodal.sk/http://www.intermodal.sk/http://www.intermodal.sk/ -
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
44/90
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
45/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
45
4.3.3 Intermodal terminal Bratislava
Terminal will be established in the Port of Bratislava area, next to Plenisko dock. The proposal is
being prepared so the terminal, after the start of operation could show required performance limit of
105 000 ITU per year. The proposal terminal is a three-modal terminal trhee modal part is situated
next to the existing port edge of Plenisko pool with length of around 300 m, and this allows, that
crane can operate three Danube Europe II boats docked to the edge at the same time. The location
of bimodal part of terminal (rail-road) is proposed in the continuation of three-modal part with so
length to the total length of direct railway tracks located under cranes in terminal according to AGTC
min. 750 m. In terminal, there are proposed 2 gantry cranes for ITU handling and 1 mobile handling
equipment for empty loading units. The span of track crane must be sufficient to it was possible to
handle all tracks, hard surfaces for short-time storage of ITU, roads for loading and unloading of ITUfrom and to vehicles, in three-modal part also boats. For handling of hard surfaces for long-time
storage of ITU (especially empty) is intended mobile handling equipment. Gantry track cranes should
be designed so, that the movement of their chassis and trolley speed can handle desired tracks and
area of dock. Technical parameters of cranes should be 40 manipulations by one crane per hour.
Mobile handling equipment should be used only for handling with empty ITU and due to its sufficient
loading capacity is 15 tons. For this weight, it is necessary to dimension hard surfaces for storage of
empty ITU. There should be placed 4 handling tracks under cranes in terminal with direct length of
750 m and in the direct impact of gantry cranes.
Road transport in intermodal terminal area will be provided by new road network of inside-area
service communications, which road load will be constructed for road trains with total weights of 44
tons. Layout of local roads and design of their routing must be based on future transport
organization in intermodal terminal.
Layout of local roads and design of their routing must be based on future transport organization in
intermodal terminal.
Intermodal terminals in Bratislava will be connected with existing road network on Prstavn street
with connection to D1 motorway by existing fly-over crossroad under the Pristavn bridge.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
46/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
46
Fig. 35 Planned location of new intermodal terminal Bratislava8
4.3.4. Intermodal terminal Leopoldov
Terminal in Leopoldov should be the main terminal with a big capacity not only for Western Slovakia
territory, but also as a HUB terminal for all Slovak republic, as a central distribution terminal for
Slovakia. Terminal will serve as terminal for bimodal transhipment of ITU between rail and road
transport. Intermodal terminal should be located in ulekovo location next to the track line
Leopoldov - Galanta. If there is in future an increase of intermodal transport volume and the capacity
of terminal Leopoldov is full, it is thinking about building the second image terminal.It is thinking
about building logistics centres in the vicinity to terminal. For handling with ITU, there should be 2
gantry track cranes and one mobile handling equipment in terminal. The span of track crane must be
sufficient to it was possible to handle all tracks, hard surfaces for short-time storage of ITU, roads for
loading and unloading of ITU from and to vehicles. For handling of hard surfaces for long-time
storage of ITU (especially empty) is intended mobile handling equipment. Gantry track cranes should
be designed so, that the movement of their chassis and trolley speed can handle desired tracks andareas. Technical parameters of cranes should be 40 manipulations by one crane per hour. Mobile
handling equipment should be used only for handling with empty ITU and due to its sufficient loading
capacity is 15 tons. For this weight, it is necessary to dimension hard surfaces for storage of empty
ITU.
Trains intended for intermodal terminal should be handled in railway station Leopoldov, respectively
in railway station Siladice and because of that, there have not been designed no tracks for own
entrance/exit groups of tracks in terminal. Terminal should be connected with track line Leopoldov -
8
Buovsk, J.: Terminal of intermodal transport Bratislava, Conference Infrastructure of intermodal transport www.intermodal.sk
http://www.intermodal.sk/http://www.intermodal.sk/http://www.intermodal.sk/ -
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
47/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
47
Galanta on the both ends of terminal, in the direction to Siladice by construction of individual track
to the railway station Siladice or with direct connection from open track line in self station. There
should be placed 4 handling tracks under cranes in terminal with direct length of 750 m and in the
direct impact of gantry cranes. One of these tracks should be designed for RO-LA transport.
Road transport in intermodal terminal area will be provided by new road network of inside-area
service communications, which road load will be constructed for road trains with total weights of 44
tons. Layout of local roads and design of their routing must be based on future transport
organization in intermodal terminal. Intermodal terminals will be connected with existing road
networkroad II/513 by crossroad.
4.3.5 Operational Programme TransportIntermodal transport infrastructure
Described terminals are built with contribution from European UnionCohesion Fund. All terminals,
which are prepared to the construction according to terms of European Commission and valid legal
acts of European Union will their services provide non-discriminatory, it means that they will be
commercially neutral with open access to all customers, who perform necessary technical conditions
(e.g. rail operator licence, etc.) Every member state of the European Union has to guarantee the
provision of Council Directive91/440/EEC on the development of the Community's railways, in
section III, Article 6, paragraph 6, which state:
Track access to, and supply of services in, the terminals and ports linked to rail activities referred toin paragraphs 1, 2 and 3, serving or potentially serving more than one final customer, shall be
provided to all railway undertakings in a non-discriminatory and transparent manner and requests by
railway undertakings may be subject to restrictions only if viable alternatives by rail under market
conditions exist
This in practice means, that if terminal operator used terminal services for his own need, he cannot
follow any rules, but if the terminal operator offer terminal services to other interested person, he
has to offer these services to all of interested persons and under the same conditions.
Because of the fact, that planned terminals are built from public financial funds, there is a condition
of public access and consequently also condition of service provision under the same conditions.
In the programme period 20072013 will be built 3 terminals from all planned intermodal terminals
and one will be postponed to the next programme period 2014 2020. This will mainly depend on
the end of the project preparation and which one will successfully get so called land use decision.
Except the postponed terminal, there is a plan to build the last intermodal terminal in Zvolen area in
the next programme period what provide territory cover of Slovakia by non-discriminatory access to
intermodal terminal services.
It should create good conditions for development of competition in combined transport sector.
Because of this action, state expects the development of combined transport, especially continental
and also accessing of this transport technology to all candidates in the future, including chemical
logistic.
http://eur-lex.europa.eu/LexUriServ/LexUriServ.do?uri=CELEX:31991L0440:EN:NOThttp://eur-lex.europa.eu/LexUriServ/LexUriServ.do?uri=CELEX:31991L0440:EN:NOT -
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
48/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
48
4.4. Multimodal transport corridors and their impact on the solved issue
Continually change of the political orientation of central and eastern states in Europe evocateddemand on extension and linking of the transport infrastructure towards these countries for purpose
of producing uniform Pan-European transport network.
Common mission of countries in Western, Central and Eastern Europe is to ensure trade exchange
and economic development with respect of democratic values and social standards of national
cultures. With this intent European Commission developed transport line conception corridor
conception linking Western Europe with Eastern on the multimodal base. In this study, we dealt
with the amount of the European transport corridors, which pass Slovakia. Detailed analysis of
multimodal corridors is defined in Annex no. 1 of this study.
Under the newRegulation (EU) No 913/2010 of the European Parliament and of the Council of 22
September 2010 concerning a European rail network for competitive freight member states of
European Union have to take into account the new legislation, which establishes international rail
freight corridors and strong preference for freight transport on these corridors.
Provisions which were in contrary to this regulation, must be revised by European Union member
states. New European Regulation helps to create rail freight corridors and its purpose is to improve
interstate freight transport.
For every rail corridor should be created separate management structure, respectively corridor
management. It should consist of several agencies (Executive board, Administration board), in which
would be represented particular countries. Administration board establishes the procedure for
handling requirements for international railway lines. For handling requests about railway lines is
necessary to establish so-called One Stop Shop for every corridor, which processes and allocates
requirements for railway lines and its decision sent to the national place for railway lines allocation.
It also defined the proceeding for operation management in corridor in the case of disturbances or
disruption. Regulation also recommends to infrastructure managers to impose sanctions to rail
companies for booked but not used railway lines, i.e. cancellation reservation. In the case of disputes
decides National regulatory agency to which is prescribed international cooperation.
Executive board provides the volume of freight transport. It means in practice partial withdrawal of
infrastructure control by its national operator.
There is a supposition in the regulation, that international good-trains will have a priority in defined
corridors in allocation of routes, what can affect passenger regional and long-distance transport.Some member states are concerned that this Regulation will have a bad affect to passenger
transport. But the there is pointed the fact in the regulation that passenger transport must be
reflected.
In regulation were approved following freight corridors (including date of the latest establishment):
1. Rotterdam/ZeebruggeAntwerpDuisburgBaselMilanGenova (established to 10
november 2013)
2. Rotterdam Antwerp Luxembourg Metz Dijon Lyon/Basel (established to 10
november 2013)
http://eur-lex.europa.eu/LexUriServ/LexUriServ.do?uri=OJ:L:2010:276:0022:0032:EN:PDFhttp://eur-lex.europa.eu/LexUriServ/LexUriServ.do?uri=OJ:L:2010:276:0022:0032:EN:PDFhttp://eur-lex.europa.eu/LexUriServ/LexUriServ.do?uri=OJ:L:2010:276:0022:0032:EN:PDFhttp://eur-lex.europa.eu/LexUriServ/LexUriServ.do?uri=OJ:L:2010:276:0022:0032:EN:PDF -
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
49/90
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
50/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
50
5. Possibilities of using the Eastern Slovak Transshipment Yards for
the development of rail and intermodal transport of chemicals
At present, The Eastern Slovak Transshipment Yards (ESTY) provide transshipment to over 90% of all
goods and raw materials imported in Slovakia by rail from Eastern Europe and Asia. Its importance is
underlined by its uniqueness of the largest transshipment yard providing a comprehensive service
package within transition of goods from broad gauge (1520mm) to general gauge (1435mm) and vice
versa in Slovakia. Within its activities, ESTY provides a complete transshipment service and
communicates with executive administration bodies acting in the matter of import and export of
goods and vehicles across crossing border stations ierna nad Tisou Chop and Uzgorod (Ukraine)Maovce.
Transportation of goods in ESTY between the Ukrainian and Slovak railways is executed via crossing
border stations:
ierna nad Tisou - Chop:
1. Track of 1520 mm track gauge. Broad-gauge rail track is terminated in ierna nad Tisou,where consignments are handed over and transshipped from broad-gauge wagons to
general-gauge wagons,
2. Track of 1435 mm track gauge. General-gauge rail track continues through ierna nad Tisouto Chop-Batev transshipment complex and enables transport of goods to Rumania viaborder crossing station Diakovo-Halmeu with no transshipment. Goods can be carried by this
connection, except from dangerous goods and out-of-gauge load.
Transshipment of goods to be exported from Slovakia to Eastern Europe and Asia is executed in a
transshipment center in Chop (Ukraine).
UzgorodMaovce:
Consignments determined at private siding and tenements in railway stations Haniska pri Koiciach,Trebiov, Vojany, Budkovce and Maovce can be transported across border crossing station Uzgorod-Maovce. In BCS Maovce, the consignment transhipment facility is limited to transhipment of bulkmaterials, as iron ore and coal. The transhipment of other types of substrates may be performed
after a contractual agreement with the Centre of freight transport Maovce.Broad gauge track, 88 km long, continues from the railway station Maovce to the railway station
Haniska pri Koiciach and its utilization is focused predominantly on transport of bulk materials,especially iron ore, for U.S. Steel Koice, s.r.o.All dangerous goods, which are listed in Regulations for international transportation of dangerous
goods RID, directed to the west across railway border crossing Uzgorod-Maovce, can be transferredfrom broad-gauge to general-gauge due to wagon bogie change at the border crossing station
Maovce.Thus the conditions for a direct transportation of consignments under an international CIM
consignment note from all COTIF member countries to destination stations in Ukraine located at
track section with the gauge of 1435mm - Chop, Esen, Batevo, Barkasovo, Strabievo, Mukaevo(, , , , , ) are created.Besides the listed stations, the change from SMGS to CIM traffic conditions and vice versa is
performed.
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
51/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
51
5.1. Possibilities of using chemical fluids transfer in ierna nad Tisou
The aim of the project was modernisation of fluids transhipment facility in Cierna nad Tisou
at Ukrainian border from broad gauge rail tank wagons to standard gauge rail tank wagons.
This fluids transhipment complex can transfer luquids from broad gauge (1520 mm) tank
wagons into normal gauge (1435 mm) tank wagons. Nowadays the facility is the most
modern fluids transhipment facility at Ukrainian border with high transhipment
performance. It fulfils strict environmental and work safety requirements. Transhipment is
managed by modern computerised system with monitoring of the whole transhipment
process.
The old fluids transhipment facility was dangerous from the point of work safety and
environment protection and present water resources. This means there was necessary toprepare modernisation of facility otherwise environmental authorities will close the facility.
The chemicals presented 3% of transshiped goods in 2008 at Ukrainian border. Alcohols
presented 88% of all chemicals transhipped in 2008 at Ukrainian borde. Other commodities
include benzene, acetates, oils and fuels.
Fig. 37: Comodity structure of fluids transhipment facility in 2008
Performance of transhippment facility in thousands tons in 2008 is showed in following figure .
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
52/90
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
53/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
53
Fig. 40 Views on the particular positions in transfer station
Transhipment of corrosive substances (Class 8) is performed only by boogie shifting in
Maovce transhipment yard at the border with Ukraine, where the broad gauge bogies of rail
tanks are changed to normal gauge boogies. The capacity of the facility is 88 cars in both
directions per 24 hours. In terms of chemical enterprises in Slovakia and Czech republic
there is an interest to transfer corrosive substances (Class 8) from broad gauge rail tank
wagons to normal gauge rail tank wagons because of russian and ukrainian tanks are not
according to RID rules, but they are acoording to Annex 2 of SMGS and esk drhy (Czech
railways) do not transport them, but in Slovakia they can be transported.
Fig. 41 Boogie shifting facility in Maovce
-
8/9/2019 Chemlog Intermodal Slovakia en FinalFP p
54/90
FEASIBILITY STUDY Chemical logistics corporation
In Central and Eastern Europe
54
5.2. Possibilities of using transhipment station in Dobr fortranscontinental transport
Fig. 42 Intermodal terminal Dobr
The intermodal terminal was put into service on August 10, 2002. Strategic priority of the terminal
was set by AGTC agreement. Financially, the building was secured from state budget (334,6 mil. )
and from private source of ZSR