Chap05 Variable Control Charts

68
Chapter 5 1 Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery. Copyright (c) 2005 John Wiley & Sons, Inc.

Transcript of Chap05 Variable Control Charts

Page 1: Chap05 Variable Control Charts

Chapter 5 1Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 2: Chap05 Variable Control Charts

Chapter 5 2Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 3: Chap05 Variable Control Charts

Chapter 5 3Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 4: Chap05 Variable Control Charts

Chapter 5 4Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 5: Chap05 Variable Control Charts

Chapter 5 5Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 6: Chap05 Variable Control Charts

Chapter 5 6Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Subgroup Data with Unknown and

Page 7: Chap05 Variable Control Charts

Chapter 5 7Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 8: Chap05 Variable Control Charts

Chapter 5 8Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 9: Chap05 Variable Control Charts

Chapter 5 9Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 10: Chap05 Variable Control Charts

Chapter 5 10Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 11: Chap05 Variable Control Charts

Chapter 5 11Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Phase I Application of and R Charts

• Eqns 5-4 and 5-5 are trial control limits– Determined from m initial samples

• Typically 20-25 subgroups of size n between 3 and 5

– Any out-of-control points should be examined for assignable causes• If assignable causes are found, discard points from calculations and

revise the trial control limits• Continue examination until all points plot in control• Adopt resulting trial control limits for use• If no assignable cause is found, there are two options

1. Eliminate point as if an assignable cause were found and revise limits2. Retain point and consider limits appropriate for control

– If there are many out-of-control points they should be examined for patterns that may identify underlying process problems

x

Page 12: Chap05 Variable Control Charts

Chapter 5 12Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 13: Chap05 Variable Control Charts

Chapter 5 13Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 14: Chap05 Variable Control Charts

Chapter 5 14Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 15: Chap05 Variable Control Charts

Chapter 5 15Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 16: Chap05 Variable Control Charts

Chapter 5 16Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 17: Chap05 Variable Control Charts

Chapter 5 17Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 18: Chap05 Variable Control Charts

Chapter 5 18Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Revision of Control Limitsand Center Lines

• Effective use of control charts requires periodic review and revision of control limits and center lines

• Sometimes users replace the center line on the chart with a target value

• When R chart is out of control, out-of-control points are often eliminated to recompute a revised value of which is used to determine new limits and center line on R chart and new limits on chart

x

x

R

Page 19: Chap05 Variable Control Charts

Chapter 5 19Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Phase II Operation of Charts

• Use of control chart for monitoring future production, once a set of reliable limits are established, is called phase II of control chart usage (Figure 5-4)

• A run chart showing individuals observations in each sample, called a tolerance chart or tier diagram (Figure 5-5), may reveal patterns or unusual observations in the data

Page 20: Chap05 Variable Control Charts

Chapter 5 20Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 21: Chap05 Variable Control Charts

Chapter 5 21Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 22: Chap05 Variable Control Charts

Chapter 5 22Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 23: Chap05 Variable Control Charts

Chapter 5 23Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Control vs. Specification Limits

• Control limits are derived from natural process variability, or the natural tolerance limits of a process

• Specification limits are determined externally, for example by customers or designers

• There is no mathematical or statistical relationship between the control limits and the specification limits

Page 24: Chap05 Variable Control Charts

Chapter 5 24Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Rational Subgroups

• charts monitor between-sample variability• R charts measure within-sample variability• Standard deviation estimate of used to construct

control limits is calculated from within-sample variability

• It is not correct to estimate using

x

Page 25: Chap05 Variable Control Charts

Chapter 5 25Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Guidelines for Control Chart Design

• Control chart design requires specification of sample size, control limit width, and sampling frequency– Exact solution requires detailed information on statistical

characteristics as well as economic factors– The problem of choosing sample size and sampling frequency is one of

allocating sampling effort

• For chart, choose as small a sample size is consistent with magnitude of process shift one is trying to detect. For moderate to large shifts, relatively small samples are effective. For small shifts, larger samples are needed.

• For small samples, R chart is relatively insensitive to changes in process standard deviation. For larger samples (n > 10 or 12), s or s2 charts are better choices.

x

Page 26: Chap05 Variable Control Charts

Chapter 5 26Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 27: Chap05 Variable Control Charts

Chapter 5 27Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 28: Chap05 Variable Control Charts

Chapter 5 28Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 29: Chap05 Variable Control Charts

Chapter 5 29Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

• An assumption in performance properties is that the underlying distribution of quality characteristic is normal– If underlying distribution is not normal, sampling distributions can be derived

and exact probability limits obtained

• Burr (1967) notes the usual normal theory control limits are very robust to normality assumption

• Schilling and Nelson (1976) indicate that in most cases, samples of size 4 or 5 are sufficient to ensure reasonable robustness to normality assumption for chart

• Sampling distribution of R is not symmetric, thus symmetric 3-sigma limits are an approximation and -risk is not 0.0027. R chart is more sensitive to departures from normality than chart.

• Assumptions of normality and independence are not a primary concern in phase I

x

x

Page 30: Chap05 Variable Control Charts

Chapter 5 30Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 31: Chap05 Variable Control Charts

Chapter 5 31Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 32: Chap05 Variable Control Charts

Chapter 5 32Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 33: Chap05 Variable Control Charts

Chapter 5 33Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 34: Chap05 Variable Control Charts

Chapter 5 34Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 35: Chap05 Variable Control Charts

Chapter 5 35Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 36: Chap05 Variable Control Charts

Chapter 5 36Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 37: Chap05 Variable Control Charts

Chapter 5 37Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 38: Chap05 Variable Control Charts

Chapter 5 38Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 39: Chap05 Variable Control Charts

Chapter 5 39Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 40: Chap05 Variable Control Charts

Chapter 5 40Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 41: Chap05 Variable Control Charts

Chapter 5 41Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 42: Chap05 Variable Control Charts

Chapter 5 42Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 43: Chap05 Variable Control Charts

Chapter 5 43Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 44: Chap05 Variable Control Charts

Chapter 5 44Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 45: Chap05 Variable Control Charts

Chapter 5 45Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 46: Chap05 Variable Control Charts

Chapter 5 46Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 47: Chap05 Variable Control Charts

Chapter 5 47Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 48: Chap05 Variable Control Charts

Chapter 5 48Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 49: Chap05 Variable Control Charts

Chapter 5 49Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 50: Chap05 Variable Control Charts

Chapter 5 50Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 51: Chap05 Variable Control Charts

Chapter 5 51Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 52: Chap05 Variable Control Charts

Chapter 5 52Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 53: Chap05 Variable Control Charts

Chapter 5 53Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 54: Chap05 Variable Control Charts

Chapter 5 54Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 55: Chap05 Variable Control Charts

Chapter 5 55Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 56: Chap05 Variable Control Charts

Chapter 5 56Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 57: Chap05 Variable Control Charts

Chapter 5 57Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 58: Chap05 Variable Control Charts

Chapter 5 58Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Average Run Lengths

• Crowder (1987b) showed that ARL0 of combined individuals and moving-range chart with conventional 3-sigma limits is generally much less than ARL0 (= 370) of standard Shewhart control chart

• Ability of individuals chart to detect small shifts is very poor– Rather than narrowing the 3-

sigma limits, correct approach to detecting small shifts is a cumulative-sum or exponentially weighted moving-average control chart (Chapter 8)

Page 59: Chap05 Variable Control Charts

Chapter 5 59Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Normality

• Borrer, Montgomery, and Runger (1999) found in-control ARL is dramatically affected by nonnormal data

• One approach for nonnormal data is to determine control limits for individuals control chart based on percentiles of correct underlying distribution– Requires at least 100 and

preferably 200 observations

Page 60: Chap05 Variable Control Charts

Chapter 5 60Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 61: Chap05 Variable Control Charts

Chapter 5 61Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 62: Chap05 Variable Control Charts

Chapter 5 62Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 63: Chap05 Variable Control Charts

Chapter 5 63Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 64: Chap05 Variable Control Charts

Chapter 5 64Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 65: Chap05 Variable Control Charts

Chapter 5 65Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 66: Chap05 Variable Control Charts

Chapter 5 66Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 67: Chap05 Variable Control Charts

Chapter 5 67Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.

Page 68: Chap05 Variable Control Charts

Chapter 5 68Introduction to Statistical Quality Control, 5th Edition by Douglas C. Montgomery.Copyright (c) 2005  John Wiley & Sons, Inc.