Catalog Example - Install Supplies
-
Upload
mike-reeves -
Category
Marketing
-
view
425 -
download
10
Transcript of Catalog Example - Install Supplies
Test
Equ
ipm
ent
I
Ann
unci
ator
s an
d Re
lays
Cloc
ks, C
DIs
, and
Inst
rum
ents
Pilo
t Sup
plie
sW
ire M
arki
ng a
nd F
oil
Inst
all S
uppl
ies
Ant
enna
sEL
TsEn
code
rs a
nd A
ir D
ata
Inve
rter
s an
d Co
nver
ters
AVIONICS INTERNATIONAL SUPPLY, Inc.
About Us Disclaimer II Table of Contents IV About Us VIIIInstall Supplies 1Antennas 39ELTs 207Encoders and Air Data 219Inverters and Converters 227Test Equipment 311Annunciators and Relays 339Clocks, CDIs, and Instruments 369Pilot Supplies 393Wire Marking and Foil 411
www.AvionicsInternational.com940.566.0035 - 800.553.2233
II
Product data and information contained in this catalog have been derived from information obtained from Avionics Inter-national Supply, Inc. (AIS) suppliers. Some of this information has been summarized and rearranged to facilitate search-ing the catalog. While AIS attempts to verify the accuracy of this catalog information, AIS does not assume responsibility for errors or omissions. This catalogs information is subject to change without notice, and AIS does not undertake any obligation to provide updates.
The information contained in this catalog is intended for use by persons possessing appropriate technical skill and knowl-edge. Conditions of use of the items listed in the catalog are beyond the knowledge or control of AIS. Consequently, AIS assumes no liability whatsoever for results obtained or loss or damage incurred as a result of the application of the informa-tion presented. All users of this catalog do so at their own risk.
The catalog is neither a parts nor maintenance manual ap-proved by the Federal Aviation Administration (FAA), and it is not intended to replace the manuals provided by the AIS suppliers. Users should independently verify the suitability and legality of each product for its intended purpose before the product is installed on an aircraft by means of an appro-priate parts or maintenance manual, or other approved FAA documentation.
AIS assumes no liability and makes no warranty with respect to claims of patent, trademark or copyright infringement or other similar claims which may arise out of or in connec-tion with the use of any information or product listed in the catalog.
AIS expressly disclaims all warranties, expressed or implied, including but not limited to implied warranties of merchant-ability and fitness for any particular purpose. In no event shall AIS be liable for any injury, expenses, profits, loss or damage, direct, indirect, incidental, consequential, special, punitive or otherwise, arising out of the use or inability to use any information or product described in this catalog.
Because some jurisdictions do not allow the exclusion or limitation of liability for consequential or incidental damages, the limitation in the paragraph immediately above may not apply to you.
TERMS & CONDITIONS:Avionics International supply, Inc. is a wholesale distributor of avionics, installation supplies and support equipment. We support avionics dealers and completion centers throughout the world. We only sell to authorized dealers upon an AIS approval. With this approval, you may purchase with terms of COD or credit card. An open account of net 30 can be achieved with verification of credit references and a signed credit application. This signed application give AIS the right to charge 1% interest per month on past due balances.
AIS WARRANTY & RETURNED MATERIALS POLICY:
GENERAL PROVISIONS:Each returned part must have a Return Material Authorization (RMA) number assigned to it by an AIS Customer Service Rep-resentative before the return will be processed by Avionics In-ternational Supply, Inc. (AIS). Returned parts must have been originally purchased from AIS and must be in their original packaging and properly packaged to prevent shipping and handling damage.
AIS will return to the customer either new, repaired or re-manufactured items or components that are warranted in ac-cordance with the original Manufacturer’s warranty. Products sold by AIS are warranted under the original manufacturer, not AIS. Defective products returned will only be issued credit upon the original manufacturer authorization and all credits, if any, will be account credits against future purchases from AIS.
RMA NUMBERS AND PROCESS:AIS, at its option, may return, unprocessed, and at the send-er’s expense, any item received without a valid RMA number.
To obtain the required RMA numbers, the Customer will contact an AIS Customer Service Representative and provide the AIS Customer Service Representative with the following information:
1. Original AIS Sales Order or Invoice Number2. Customer name or AIS Customer Account Number3. Contact and call-back telephone number4. Serial number and/or part number for each item to be returned5. Reason item is being returned
[Note: The AIS Customer Service Representative may need additional infor-mation depending on the nature of the problem.]
Avionics International Supply, Inc. Catalog Disclaimer
IIIIII
RMA NUMBERS AND PROCESS (cont’d): AIS Customer Service will verify the warranty status of each item before assigning an RMA number. Serial Numbers and purchase date will be verified against all available AIS and manufacturer records. Non-warranty items will require a Customer Purchase Order number to be issued to AIS before repairs will be started on the RMA.
If a product is returned to AIS it may be subject to a re-stock-ing fee at AIS’s discretion.
An RMA number will be assigned to each shipment or each item to be returned.
SHIPPING INFORMATION:Shipment must contain a packing list with the RMA number, Part Numbers and Serial Numbers for each item. RMA num-bers must be clearly marked on the outside of the shipping containers.
Use original packaging for returns. Poor packaging may result in physical damage to the returned part(s). If the shipment is damaged, AIS will document the damage, notify the sender. All costs associated with repair of the damage from shipment will be borne by the sender. In some cases, damage to the shipment may result in the cancellation of the items within that shipment.
The Customer will pre-pay freight to AIS, and AIS will pre-pay return freight to the Customer. AIS will use the most eco-nomical method of shipment. Any special Customer shipping requests will be billed to the Customer.
NO DEFECT FOUND CHARGE:The customer will be charged $125 for each item which is returned for RMA if the item is found to be in sound work-ing condition and found to be free of defects by the original manufacturer. The customer will be notified and a purchase order will be required for the full amount of the charges be-fore the equipment will be returned.
ADVANCED REPLACEMENT PARTS REQUEST:In the event a requirement for an Advanced Replacement Part exists, a Customer Purchase Order must be sent to the AIS Customer Service representative. Expedite Fee’s for advance replacements will be the responsibility of the customer. The customer will be billed for the full price for any part if like or same item is not returned within 30 days under the RMA process.
AIS will use its reasonable best efforts to process the Emer-gency Purchase Order during the same day the order is received. The Customer will pay all shipping costs.
CUSTOMER SERVICE CONTACT INFORMATION:Phone: 1-800-553-2233 or 940-566-0035Fax: 940-566-8656Email: [email protected]
TERMS OF SALE: For established Net 30 days accounts: Full payment is due 30 days from invoice date.
MINIMUM CREDIT PURCHASE: $50.00 Due to the cost of processing charge orders, no dis-counts will be extended for orders less than $50 list price.
RETURNS:Please see the Returned Material Authorization (RMA) proce-dure.
SHIPPING CHARGES:Unless otherwise directed, all orders are shipped via UPS or Fedex Ground, FOB our dock, and may take up to five or six working days to reach regions near the East and West coasts. Expedited shipping is available, at published rates.
IV
ACCESSORIES Adapter Cables 409 Handheld Radios 409 Mini Power Inverters 408 Portable PTT Switches 409
AC TO AC POWER SUPPLIES Light Dimmers FJ20 228 E/L Power Converters FD15 229 60/50Hz Frequency Converters HB200 232 HB Series 230 HS200 232 HS Series 230
AC TO DC POWER CONVERTERS LT-2XX-400 Series 236 PFA1 234 SRP500-14 235 WH120 238 Light Dimmers LT-25 239
ADDITIONAL ITEMS 423
ADD. MID CONTINENT P/N 364
AERO EXPRESS Busmaster 2500 330
AERONAUTICAL TEST KITS & ACCESSORIES 11
AEROSPACE TEST/CAL EQUIP. Master Site Compass 314 Pitot/Static Test Set 313 SA37-P-UNI-2 313 SA3Y-9-LTS 314
AIRSPEED INDICATOR LUN 1106 385 LUN 1107 384 LUN 1115 383 LUN 1116 382 LUN 1170 386
ALTIMETERS LUN 1120 376 LUN 1127 377 LUN 1128 378 LUN 1130 379
AM/FM ANTENNAS CI 222 119
ANNUNCIATOR CONTROL UNITS TAWS/EGPWS Annunciators AK-950-xxx Series 352 MD41-xxxx Series 351 MD41 Series 350 GPS/NAV Annunciators 353
ARTEX ELT TO NAV INTERFACE 214
BRASS & NYLON FITTINGS 6
CABLE MOUNTS & FASTENERS 8 Cable Tie Mounts Braided Nylon Lacing Cord Cradle Cable Tie Mounts Expandable Sleeving Lightning Hole Cable Tie Mount Loop Type Fastener ADEL Clamp Spiral Wrap
CAPITAL AVIONICS CA-323 323 CA320 322
CIRCUIT SAFETY LOCKS 10
CLOCKS AT-1 371 LC-2, LC-2P. LC-2PC 370 LC-20 371 LC-20A 371 LC-2A-5 371 LC-2A-6 371 LC-2E 371 LC-2H 371 LC-2PC 371 LC-6 371 LC-60 371 LC-8 (28v) 371 LC-8 (5v) 370 LC-90 371 LC-C, LC-6PC 370 M800 372 M811B 372 M877 372 w/ Outside Air Temp M803 372 MD-90 Series 373 MD40 Series 374
COLORED BREAKER COLLARS 10
COMDAT ANTENNASCOMDAT SERIES FAQ 41 CI 150-250-L 50 CI 248-180 49 CI 248-30 48 CI 248-5 43 CI 2480-100 44 CI 2480-101 45 CI 2480-200 46 CI 2480-201 47 CI 2480-204 51 CI 2480-206 52 CI 2480-300 53 CI 2480-301 54 CI 2480-304 56 CI 2480-400 57 CI 2480-401 58 CI 2580-200 59 CI 2580-410 60 CI 268-10 61 CI 268-30 62 CI 2680-200 65 CI 2680-204 66 CI 2680-206 67 CI 2680-300 68 CI 2680-301 69 CI 2680-304 70 CI 2680-400 71 CI 2680-401 72 CI 2680-500 73 CI 2728-200 74 CI 2728-410 75 CI 2780-464 76 CI 401-220 77 CI 401-220 77 CI 401-221 77 CI 401-224 79 CI 401-230 80 CI 401-421 81 CI 401-460 82 CI 408-20 78 CI 420-10 84 CI 420-16 85 CI 420-1 83 CI 420-220 92 CI 420-221 55 CI 420-224 86 CI 420-230 87 CI 420-420 88 CI 420-421 89 CI 428-200 90 CI 428-410 91 CI 480-1 63 CI 490-1
CONNECTORS & ADAPTERS BNC Adapters 19 BNC Connectors 18 GPS Notch Filter 18 N Type Connectors 19 SMA & UHF Connectors 19 TNC Connectors 18 Tray Mount RF Connector 18
CONNECTORS & PINS AC/DC Recepticles 23 ARC Transponder Contacts 21 Block Receptacle 20 Clamps 23 Grounding Blocks 20 HD Positioner 21 HD Sub-D Connectors 21 Insertion/Extraction Tools 23 King Double Edge Pins 21 Male Jack Screws 20 Mate-N-Lok Connectors 21 Metrimate Connectors 20 Narco Contacts 21 “PIDG” Splices 20 “PIDG” Splices 20 “PIDG” Terminals 20 “Round Tongue” Terminals 20 “Solistrand” Ring Terminals 20 “Terminal” Ring Terminals 20 Power Connectors 22 Reverse Sex Connectors 22 CPC Connectors 22 Sockets For Grounding 20 Pins 22 Standard Sex Connectors 22 Subminiature D Connectors 21 Wire Caps 20
COOLING FANS & HOSE 30
COPPER BUSS BAR 10
COVER/REDUCER PLATES 3 Dzus Rail Instrument Cover Plates Mu-Metal Reducer Plates Sqeeze Clamps
COUPLER/DIPLEXER CI 502 184 CI 503 185 CI 505 186 CI 507 187 CI 509 188 CI 601 189 CI 1114 190 CI 1115 191 CI 1120 192 CI 1125 193
TABLE OF CONTENTS
VV
CRIMPERS & WIRE STRIPPERS 26 Replacement Die Sets 27
DC TO DC POWER CONVERTERS Unregulated 240 UC14-28 240 UC28-14 241 Light Dimmers AK-551LD-( ) 253 AK-551LD-M-( ) 254 LF10 243 LH14 252 LT-100 244 LT-103 246 LT-248 242 LT-3xx Series 250 LT-52(A) 244 LT-53 246 LT-55( ) Series 248 LT-57( ) Series 248 LT-70 244 LT-73 246 Step Up AK-550-12 255 AK-550-6 255 LS03-05002 261 RB125 256 Step Up (Cont’d) RB126 256 RH28 260 RHB40 258 Step Down AK-551-18M 271 AK-551-40M 271 AK-551-9M 271 BC-14 266 BC-28 266DC TO DC POWER CONV. (CONT’D) Step Down (Cont’d) LS03-05001 272 LT-101 Series 264 LT-4x Series 262 LT-50 267 LT-71 Series 264 N2412-12 272 N2412-24 272 RG28 268 RG40 269 RG56 270 Dual Channel RR18 273
DC TO DC/AC POWER CONVERTERS Light Dimmers DT30 274
DC TO AC STATIC INVERTERS 400Hz MD 26 Series 286 SC-50 281 SC100 284 SC3 275 SCA150 285 SCA3 275 SPC-10( ) Series 277 SPC-10(J) Series 278 SPC-30( ) Series 279 SPC-38( ) Series 280 SPC-5( ) Series 276 SPC-60( ) Series 282 SPC-75( ) Series 283 400Hz E/L SD3 287 SD35 288 SE25 289 400Hz Three Phase SEA150 290 60/50Hz SB200 296 SB Series 294 SPS-1307 Series 292 SPS-1607 Series 292 SPS-2xx Series 291 SPS-3xx Series 291 SPS-750 292 SS200 296 SS50 293 SS50(D) 298 SS Series 294
DME/TRANSPONDER CI 100 Series 152 CI 101 153 CI 105-16 158 CI 105-3 155 CI 105-6 & 7 156 CI 105-9 157DME/TRANSPONDER (CONT’D) CI 105 Series 154 CI 110-40-30 159 CI 110-41-30 160 CI 110-60-30 161 CI 110-61-30 162 CI 305 Series 163 DMNI24/DMNI29 Series 164 DMNI50 Series 165 DMNI52 Series 166 DMNI70 Series 167
DROP CORDS AIS Universal Drop Cords 401 CIX 200 Series 402 CIX 300 Series 403 CIX 400 Series 404 Drop Cord Spare Parts 405
DROP CORD WIRING CONFIG 407
EATON Switches 580/581 Series 341 582 Series 340 584 LED Series 341 584 Series 340 Lamps 343 Master Specialty 10E/10H Twist-Lite Series 343 800/820 Tellite Series 343 90lE/90lH Tellite Series 343 90lK Tellite Series 343 TAWS/EGPWS Annunciators 344 EATON Accessories 346 EATON Specifications Dimensional 347 Electrical 348 Environmental 348 Wiring 347
EATON CONFIG FORM 366
ELECTRIC ATTITUDE GYROS LUN 1241 380
ELT SELECTION GUIDE 208
ELTS, BUSINESS AVIATION C406-1 Series 211 C406-2 Series 211 C406-N Series 212
ELTS, COMMERCIAL AVIATION C406-1 Series 212 C406-2 Series 212 C406-N Series 213 B406 (Boeing) Series 213 ELTS, GENERAL AVIATION ME406 Series 210 G406 Series 210 C406-N Series 210
ELTS, HELICOPTER ME406 Series 213 C406-1 Series 213 C406-2 Series 214 C406-N Series 214
ELTS, OTHER DM ELT 14-1-1 215 AK-450 Series 216 Model E-01 217 3000 Series 218
ELT BATTERIES 214
ELT-NAV INTERFACE KIT CS144-RS 209
ENCODERS A-30 222 AK-350 222 SAE5-35 220 SSD120-(xx)A(E) 223
ENVIRONMENTAL SPLICES 12
FOIL 424
FM ANTENNAS CI 222-1 120
FM/2 METER ANTENNAS CI 177-13 116 CI 177-1 114 CI 177-3 115 CI 177 113 CI 292-3 117 CI 292-4 118
FUSES 12
GLIDE SLOPE CI 193 177 CI 212-2 178 DMN9 Series 179
GPS ATTENUATOR CI 511 194GPS REPEATER KITS 314 L1 Antennas 314
GPS SPLITTERS 315
GROMMETS 10GUAGES Digital VOR Indicator Localizer 903ID-2 375 Morse Code Identifier 903ID-2 375 Density Altitude 665-2 375 Digital Outside Air Temp 301C 375 301F 375
VI
HEADSETS 7000 ANR ProGT/ProGTH 397 7000 Sport LE/LEH 397 David Clark X11 Headset 394 H10-00 394 H10-13.4 394 H10-13X 394 H10-13XL 394 H10-13XP 394 H10-20 395 H10-30 395 H10-56 395 H10-56 HXL 395 H10-60 395 H10-66 396 H10-76 396 H20-10 396 H20-10XL 396 H20-10XP 396 HMEC25-CAP 397 HMEC25-KA 397 HMEC25-KAP 397 HMEC25-KAS 397 HME C25-KAX 397 HMEC300 397 Junior Series P-51C 398 PA 11-20 398 PA 11-40 398 PA 11-60 “The Eliminator” 398 PA 11-90 399 PA 31-70 398 P-51 399 Powercom 2-way Wireless 397 Headset Accessories Booms 399 David Clark Accessories 396 Microphones 399 Microphone Windscreens 399 Peltor Headset Accessories 397
HEAT GUNS 32 Heat Gun Accessories 36
HEAT SHRINK TUBING 9
HEX STANDOFFS 10
HOT STAMP MARKERS SEI-50 416 SEI-150 417 SEI-250 418 SEI-450 419 Upgrade Kits 420
JACK HOUSINGS 3
LABEL MAKERS K-Sun 29 KROY 28
LASER WIRE MARKERS CAPRIS 50-100 PCS 413 Laser System 1 - IR 414 Laser System 1 - UV 415
LASER WIRE MARKING 412
LAVERSAB TEST EQUIP 6300 324 6500 325
LINAIRE ENGINEERING JT-2 327 L-280 326 LA-6 326 LD-4 326 LG-6 326 LI-2 326 LI-3 326 LM-4 326 LR-1 326 LRA-2 326 LT-6 327 LV-6 327 LW-4 327 LXS-4 327
LINE FILTERS 122253-10A 304 AK-950-FTR 303 LS03-01004 304
MARC 70 Card Cages 359 Dimming Modules SA 3 359 Diode Isolation SA 24 358 Logic Inverters SA 15 357 Switching Module SR 263 Series 354 SR 343 355 SR 623 356
MARKER BEACON ANTENNAS CI 102 168 CI 118 169 CI 118-1 170 CI 118-10 172 CI 118-9 171 CI 164 173 CI 165 174 DMN27 Series 175 DMN43 Series 176
MICHEL AVIONICS 3300 Transponder Test Set 329 NC 2210 Tester 328
NAV-AIDS Commuter/Corporate Aircraft 331 Eurocopter Helicopter 336 Helicopter 337 Military Aircraft 338 Transport/Civil Aircraft 335
NITE LITES 16
NUTS AND WASHERS 24
PHASE SYNC BOXES 3PH-B400 299 EL1 300
PITOT STATIC TUBE LUN 1150, 1153 390
PLUGS AND JACKS Data Jacks & USB 2 Intercom Kits & Accessories 2 Mini Plugs & Jacks 2 Plugs & Jacks 2
PORTABLE INTERCOM SYSTEMS DC-COM 200 400 PA 200 400 PA 200E 400 PA 400-3BL / PA 400S-ASC 400
PRESSURE SWITCH 452 392 LUN 1492 391
PUSHBUTTONS & TOGGLES 2TC2 Series 14 2TC2 Series 15 41-3 Series 14 7270-1 Series 14 7270-5 Series 14 7270 Series 15 7271-8 Series 14 7271 Series 15 7274 & 7277 Series 15 7274-11 Series 14 7274-2 Series 14 7277-2 Series 14 7277-5 Series 14 Miniature BAT Toggle 13 Miniature Locking BAT Toggle 13 Miniature Short Toggle 13 Momentary Pushbuttons 13 W23-X1A1G Series 14
PUSHBUTTONS & TOGGLES (CONT’D) W23 Series 15 W31-X2M1G Series 14 W31 Series 15 W58-XC4C12A Series 14 W58 Series 15
RADAR ALTIMETER CI 152-6 180
RAMI VHF 198 GPS 199 Navigation 200 DME/Transponder 201 Couplers 202 Mobile/Base 203 Ground/Air Comm 203 Footprints 204
SCREWS 25
SERIALIZERS IA-RS232C-S 224 3000U 225
SOLDER SLEEVES 12
SPARK TESTERS AS-1390 423
SPEAKERS 17
SPLITTERS AV-534 198 AV-534L 198 AV-568 198 AVT-4 198 CI 5120 195 DMH21 196 DMH69-1 197
SWITCHING RELAYS AIS200-35 362 AIS200-3514 362 AIS240-35 361 AK-950-R 360 T-Bar Hermetically Sealed 363
TEL INSTRUMENTS Product Selection Guide 316 ARINC 429 321 T-30D 317 T-36C 316 TB-2100 320 TR-211 318 TR-220 319
TABLE OF CONTENTS
VIIVII
TEMPERATURE PROBES 392
TERMINAL BLOCKS, BOOTS, & COVERS 10
TEST EQUIPMENT FDB135 308 RM Series 305 RS-M Series 305 SPC-6-1000-3PH Series 309 SPC6-1500 307 SPC6-1501 307 SPC6-750 Series 306 VLS Series 305
THERMAL PRINTERS TM-20 421
TIE WRAPS 7
TRANSFORMERS CC Series 301 CS Series 302
TURN INDICATOR LUN 1216 381
UHF ANTENNAS CI 105-20 121 CI 106 122 CI 177-20 123 CI 200 124
UHF ANTENNAS (CONT’D) CI 271 125 CI 273 126 CI 275-2 127 CI 275-5 128 CI 285 129 CI 306 130 CI 310-20 131 DMC57-1 132
USED TEST EQUIPMENT 312
VERTICAL SPEED INDICATORS LUN 1141 387 LUN 1144 388 LUN 1149 389
VHF ANTENNAS CI 108-1, CI 108-1-L 94 CI 108 93 CI 109 96 CI 119 97 CI 121 95 CI 122 98 CI 138 99 CI 139 100 CI 175 101 CI 196 102 CI 211, CI 211-L 103 CI 211-1, CI 211-1-L 104 CI 211-16 105 CI 268-5 106
VHF ANTENNAS (CONT’D) CI 291 107 CI 292-1 108 CI 292-2 109 DM C50-17 110 DM C60 111 DM C63 112
VINYL TUBING 6
VOR/GS POWER COMBINER CI 120-3 181 CI 120-4 182 CI 120-5 183
VOR/LOC/GS ANTENNAS CI 120-200 G/S 135 CI 120-400 136 CI 120 G/S 133 CI 120 G/S-L 134 CI 135-100 137 CI 157P 138 CI 158C 139 CI 158C-2 140 CI 158C-3 141 CI 159C 142 CI 205-3 143 CI 215 144 CI 259E 145 DMN4-15, DM4-33 147 DMN4-17 Series 148 DMN4-45 149
VOR/LOC/GS ANTENNAS (CONT’D) DMN4-4 System 146 DMN42-1 Loop 150 DMN48 Series Bal. Loop 151
WIRE AND CABLE ADF Wire 5 ADF Wire Components 5 Coil Cord 5 Fiber Optic Cable 5 High Temp Quadraxial 5 Mil-spec Wire & Cable 4 RG Coaxial Cables 4 Shielded Wire 5 Storm Scope Cable 5 Wirespoon 4
WIRE PROCESSING 422
VIII
Avionics International Supply Website
Avionics International Supply, Inc. (AIS) is a combination of three closely held interlinked aerospace companies, all of which share the same facility in Denton Texas. AIS has been in operation for over 20 years and carries a superlative reputation in the industry. The AIS family of companies focus on four various segments of the avionics related business.
AVIONICS INTERNATIONAL SUPPLY, INC.
* Wholesale distribution of avionics parts and supplies to private and commercial repair facilities worldwide.
* Manufacture & distribution of specialized avionics test equipment, aircraft lighting accessories and several one-of-a-kind aviation related items.
* Maintenance, repair, calibration and certification of avionics and avionics test equipment. (FAA Certified
Class I, II, III & IV plus limited accessories, instrument, radio and accessories repair facility, Repair
Station Number: XI7R807J)
* Sales, Service and Installation of some of the nations largest instrument and avionics manufacturers including: Aerosonic, Avidyne, Becker, Garmin, Honeywell-Bendix/King, L-3 Avionics, Mikrotechna, Mid-Continent, Sandel, SigmaTek, Sagem Avionics, and Universal Avionics.
* Acquisition, repair, calibration, certification and resale of previously owned avionics and avionics test equipment.
ABOUT US...
VIII
IXIX
AIS is your full service, one-stop supplier, having the ability to provide new or used parts and equipment and the capacity to repair, calibrate and certify the aircraft owners equipment. The AIS family of companies’ strength is best demonstrated by the products and companies they represent; these include Eaton Aerospace, BFGoodrich Aerospace, Comant, Tel Instruments, Laversab, Capital Avionics, Northstar Technologies, Thomas Betts, David Clark Company Incorporated, Sandia Aerospace, Mid Continent Instruments, RAMI, and KROY just to name a few.
The history of the companies started with the opening of a distribution business in 1984 located in Addison Texas. During the next few years the distribution business was expanded to include an FAA Class I, II, III and full Class IV instrument repair facility including accessories category. Further expansion into a full service calibration shop, the sales of used avionics, and the manufacturing and development of test equipment and lighting accessories expanded the company to its current status.
Since 1984, the core companies have built a team of highly experienced FAA certified technicians and an excellent support team. The company holds an excellent reputation in the industry and is considered one of the top three suppliers nation wide in the avionics market space.
The AIS family of companies’ currently services customers across the spectrum from Major Airlines to General Aviation with a focus toward Corporate Aviation & General Aviation. Major airline customers include Northwest Airlines, UPS, Continental Airlines, American Eagle, Frontier, USAir and others, however the core business is with general aviation repair facilities, Fixed Based Operations (FBOs) and corporate customers such as Frito Lay, Honeywell and Boise Cascade Corporation. In addition, sales to Government entities such as the Department of the Navy, U.S. Customs and Border Protection, U.S. Air Force and Army National Guard demonstrate the variety in our customer base. The company also supports many key OEMs such as Raytheon Aerospace, Gulfstream, Beechcraft, Cessna, Eclipse and Learjet.
Over the past fourteen years AIS has developed a strong customer base in the International market. Some of our Top 100 International customers include: ST Aerospace Engineering; Hawker Pacific; Scandinavian Avionics; Lufthansa; Euro copter; Bombardier and Beechcraft International.
Aerospace Instrument Support, Inc. is the organizations class I, II, II & IV, FAA, JAA, and EASA Certified Instrument and Avionics Repair and Installation facility with limited Accessory and Avionics rating including Weather Radar and Transponder repair and overhaul capabilities as well as being the only Factory Authorized Service Center in North America for KANNAD ELTs. Aerospace is also an authorized Dealer and Installation facility for some of the largest Instrument and Avionics Manufacturers including: Aerosonic, Avidyne, Becker, Garmin, Honeywell Bendix/King, L-3 Avionics, Mikrotechna, Mid-Continent, Sandel, SigmaTek, Sagem, and Universal Avionics.
PROVIDING THE BEST PRODUCTS, SERVICE, AND SUPPORT IN THE AVIONICS INDUSTRY SINCE 1984.
IX
X
A world leader in the manufacturing of Pitot/Static ground support equipment. Not only is Aerospace the manufacturer of new products, we have a highly advanced avionics and instrument certification and repair facility. Aerospace has its own on site calibration equip-ment that well exceeds NIST standards. As a Part 145 certified repair station CRS # XI7R807J, Aerospace has the lab and technical ability for repairs and certification of most manufacturers of avionics and instruments, as well as Pitot/Static and RVSM test boxes.
Aerospace Instrument Support is your source for instru-ment repair and overhaul. A Class I, II, III and partial IV CRS with FAA/JAA approval, Aerospace Instrument Support can provide overhall / exchange as well as quick turn times with competitive pricing. Give us a call for all of your instrument needs.
We specialize in Pitot / Static Test Equipment and RVSM Test Sets including Manufacturing and Certifications. Typical turn around times are between 3 to 5 days!
For more information, please contact:
Brenda LeavellQuality [email protected]
Kevin SummerlinGeneral [email protected]
INSTRUMENT SUPPORT, Inc.
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design DruckBarfieldCastleberry AeroMechanism
Ametek / US Guage Astronautics Mid Continent N.A.T.Sigma-Tek
AerosonicSandelEpo-AireKannadDavtron
oney ell / Bendi / King / Sperry
Arte Smiths CollinsUnited nstruments et / A M
Kollsman / DC General ElectricCentury C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
General Design Druck Barfield Castleberry Aero Mechanism
Ametek / US Guage Astronautics Mid Continent N.A.T. Sigma-Tek
Aerosonic Sandel Epo-Aire Kannad Davtron
oney ell / Bendi / King / Sperry
Arte Smiths Collins United nstruments et / A M
Kollsman / DC General Electric Century C A
Aerospace Instrument Support, Inc.
AEROSPACE INSTRUMENT SUPPORT
Aerospace Instrument Support is an industry leader in the overhaul and repair of an assortment of gyroscopes and avionics instruments, and is a full service FAA and EASA approved instrument repair facility. Aerospace offers far more than just an extensive list of gyroscope products and services, Aerospace can repair Pressure Instruments, Engine Instruments, and External Aircraft Lighting and Powersupplies.Currently, Aerospace Instrument Support has the capabilities of repairing, overhauling, and performing a full functional test including: Collins Proline II, Transponders, DME’s, Radar, Nav / Comm, ADF, VHF, Control Heads, and ARINC Avionics.
XIXI
Call For Complete Capabilities Listing
Aerospace Instrument Support is an approved FAA repair station #X17R807J.
VSI TYPE
AEROSONIC30020-( ) 2000 FPM30030-( ) 3000 FPM30040-( ) 4000 FPM30060-( ) 6000 FPM30230-( ) 3000 FPM30240-( ) 4000 FPM30260-( ) 6000 FPM35060-( ) 6000 FPM35160-() 6000 FPM
UNITED7000 2000 FPM7030 3000 FPM7040 4000 FPM7060 6000 FPM
GYRO TYPE
A.l.M.200-( ) DIR. GYRO205-( ) DIR. GYRO251 -( ) HOR GYRO300-( ) FLT. DIR.305-( ) FLT. DIR.500-( ) HOR. GYRO510-() DIR. GYRO52D54-( ) DIR. GYRO52D66-( ) HOR. GYRO52D67-( ) HOR. GYRO
EDO-AIRE52C77-( ) FLT. DIR.52D54-( ) DIR. GYRO52D66-( ) HOR. GYRO52D67-( ) HOR. GYRO52D136( ) H.S.I.52D137-( ) H.S.I.52D154-( ) DIR. GYRO52D166-( ) HOR. GYRO52D167-( ) HOR. GYRO52D177-( ) FLT. DIR.52D254 DIR. GYRQ
GYRO TYPE
EDO-AIRE52D266-( ) HOR. GYRO52D267-( ) HOR. GYROG502-( ) DIR. GYROG504-( ) DIR. GYROG519-( ) HOR. GYROG520-( ) DIR. GYROG550-( ) FLT. DIR.G1050-( ) FLT. DIR.IG832-( ) H.S.I.
J.E.T.Al804 STBY. GYROAl903 STBY. GYROAl904 STBY. GYRO
KINGKl-255-( ) FLT. DIR.Kl-256-( ) FLT. DIR.KG-102-() DIR. GYROKG-107-( ) DIR. GYROKG-258-( ) HOR. GYROKSG-105-( ) DIR. GYROKl525A-( ) H.S.I.
SPERRYC-14-() DIR. GYROVG-14-( ) HOR. GYROGH-14-( ) HOR. GYRO
COLLINS332D-11-( ) VERT. GYRO332E-4-( ) DIR. GYRO
ADI/HIS TYPE
COLLINS329B-7-( ) ADI329B-8-( ) ADI331A-3-( ) H.S.I.331A-6-( ) H.S.I. 331A-8-( ) H.S.I. 332C-10-( ) H.S.i.
INSTRUMENT REPAIR AND OVERHAUL
AEROSPACE INSTRUMENT SUPPORT
XII
CALIBRATION
We are ANSI Z540 compliant and qualified to calibrate and repair your avionics test equipment and tools. We provide quick turn around times without sacrificing quality service.
ATEC
Authorized Tel-Instruments Service Center
TR-220: Multi-function Test Set
RD300: Weather Radar Test Set
Tektronix Oscilloscope
ATC 600A: DME/Transponder Test Set
Avionics Test Equipment Calibration
Call For A QuotePHONE 940-566-3245 TOLL FREE 800-768-3008 FAX 940-566-9506
�
� In
stal
lati
on
Su
pp
lies
Installation SuppliesPlugs and Jacks 2 DataJacks&USB IntercomKits&Accessories MiniPlugs&Jacks Plugs&JacksJack Housings 3Cover/Reducer Plates 3 DzusRail InstrumentCoverPlates Mu-Metal ReducerPlates SqeezeClampsWire and Cable ADFWire 5 ADFWireComponents 5 CoilCord 5 FiberOpticCable 5 HighTempQuadraxial 5 Mil-specWire&Cable 4 RGCoaxialCables 4 ShieldedWire 5 StormScopeCable 5 Wirespoon 4Vinyl Tubing 6Brass and Nylon Fittings 6Tie Wraps 7Cable Mounts and Fasteners 8 CableTieMounts BraidedNylonLacingCord CradleCableTieMounts ExpandableSleeving LightningHoleCableTieMount LoopTypeFastenerADELClamp SpiralWrapHeat Shrink Tubing 9Copper Buss Bar 10Colored Breaker Collars 10Circuit Breaker Safety Locks 10Grommets 10HEX Standoffs 10Terminal Blocks, Boots, & Covers 10Test Kits and Accessories 11Solder Sleeves 12Environmental Splices 12Fuses 12Pushbuttons and Toggles 2TC2Series 14 2TC2Series 15 41-3Series 14 7270-1Series 14 7270-5Series 14 7270Series 15 7271-8Series 14 7271Series 15 7274&7277Series 15 7274-11Series 14 7274-2Series 14 7277-2Series 14 7277-5Series 14
Pushbuttons and Toggles (Cont) MiniatureBATToggle 13 MiniatureLockingBATToggle 13 MiniatureShortToggle 13 MomentaryPushbuttons 13 W23-X1A1GSeries 14 W23Series 15 W31-X2M1GSeries 14 W31Series 15 W58-XC4C12ASeries 14 W58Series 15Nite Lites 16Speakers 17Connectors and Adapters BNCAdapters 19 BNCConnectors 18 GPSNotchFilter 18 NTypeConnectors 19 SMA&UHFConnectors 19 TNCConnectors 18 TrayMountRFConnector 18Connectors and Pins AC/DCRecepticles 23 ARCTransponderContacts 21 BlockReceptacle 20 Clamps 23 GroundingBlocks 20 HDPositioner 21 HDSub-DConnectors 21 Insertion/ExtractionTools 23 KingDoubleEdgePins 21 MaleJackScrews 20 Mate-N-LokConnectors 21 MetrimateConnectors 20 NarcoContacts 21 “PIDG”Splices 20 “PIDG”Splices 20 “PIDG”Terminals 20 “RoundTongue”Terminals 20 “Solistrand”RingTerminals 20 “Terminal”RingTerminals 20 PowerConnectors 22 ReverseSexConnectors 22 CPCConnectors 22 SocketsForGrounding 20 Pins 22 StandardSexConnectors 22 SubminiatureDConnectors 21 WireCaps 20Nuts and Washers 24Screws 25Crimpers and Wire Strippers 26 ReplacementDieSets 27Label Makers K-Sun 29 KROY 28Cooling Fans 30 CoolingHose 31Heat Guns 32 HeatGunAccessories 36
�
� Installatio
n Su
pp
lies
PLUGS & JACKS
PLUGS & JACKS
DATA JACKS & USB
The images in these diagrams are not to scale.
MINI PLUGS & JACKS
NEXUS / SWITCHCRAFT
PJ055B(Mono)
JJ034(Mono)Withkey
SWC11(Mono)Unkeyed
VE055J(Mono)
TP-101(U174/U)
TP-102(U93A/U)
TJT-120(U92B/U)
TJ-120(U92B/U-R)
TJ-102(U92A/U)
TJS-102V94A/V(WithClip)
PJ068
JJ033(Withkey)
S12B(JJ033Unkeyed)
VEO68J
(JJ033Inline)
SP200(Stereo)
12B(Stereo)
SJ 200(Stereo)
MP-101(U173/U)
MJ-101(U172/U)
27-655MiniStereoJack
27-060MiniStereoPlug
INTERCOM KITS & ACCESSORIESP/NIC2-KIT 2Place(mono)IntercomKitP/NIC2S-KIT 2Place(stereo)IntercomKitP/NIC4-KIT 4Place(mono)IntercomKitP/NIC4S-KIT 4Place(stereo)IntercomKitP/NIC6-KIT 6Place(mono)IntercomKitP/NIC6S-KIT 6Place(stereo)IntercomKit(allkitsincludemic/phonejacksandwashers)S1028 FlatWasher(Insulating)S1029 ShoulderWasher
P/NARJ11 RJ11Jack(nobezel)P/NARJ11W RJ11Jackw/6”pigtailP/NARJ11WC RJ11Jackw/6”pigtail&connectorP/NARJ45 RJ45connectorP/NABE06-00 RJ11BezelP/NABE06-00D RJ11Bezel“DATA”P/NABE06-00F RJ11Bezel“FAX”P/NABE06-00V RJ11Bezel“VOICE”P/NABE06-00M RJ11Bezel“MODEM”P/NABE06-00L RJ11Bezel“LAN”P/NABE08-00 RJ45BezelP/NABE08-00D RJ45Bezel“DATA”P/NABE08-00L RJ45Bezel“LAN”12colorstochoosefrom(CALLAIS)
USB-AB
USB-BB
TJ-101
�
� In
stal
lati
on
Su
pp
lies
JACK HOUSINGSCOVER/REDUCER PLATES
Part # DescriptionFAP09-1 1hole/underpanelmountFAP09-2 2hole/underpanelmountFAP09-3 4hole/underpanelmountFAP09-4 4hole/horizontalmount
FAP09-3 FAP09-4FAP09-1 FAP09-2
FAP09 SeriesAllFAP09seriesmic&jackhousingsaremadefromaluminumandfeatureacrinklefinish.
Ashtray Mountable Jack Housing
P/NAVB
Mu-Metal Usedtocoverandprotectelectronicequipment.
P/N WidthMUMetal4 4”MuMetal15 15”
Dzus Rail Customcutinanysizeupto5feet.
P/NPR3.5-1X5 (FlatRail)PR3.5X5 (Rt.AngleRailRail)PFSC3538A (Fastener)TP35AHT (FastenerTool)
Angled Rail
Flat Rail
Fastener
Sqeeze Clamps
P/N Description9963B 3ATISqeezeClamp1”deep64311B 3ATISqeezeClamp2”deep
Madeofadurable,crinklefinishedplastic,idealfortemporaryorpermanentpanelchanges.
P/N: FAP05-2(3-1/8”CoverPlate)
P/N: FAP05-3(3”ATICoverPlate)
P/N: FAP05-5(1/2ATICoverPlate)
P/N: FAP05-1(2-1/4”CoverPlate)
Instrument Cover Plates
Reducer Plates
FAP04-1(3-1/8-to2-1/4”)
FAP04-2(anygyroto3-1/8”)
FAP04-4(3ATIto2-1/4”)
FAP04-3(3ATIto3-1/8”)
NOT PMA’d.TheKX-99Aofferstremendoussecurityfromradiofailureforverylittlecost.Designedtogoin-linewithaCOMantennacoax,theKX-99Adisconnectstheaircraftradiofromtheantennawhenyouplugintheadaptercable.Thehandheldtranseiverwillnowreceiveandtransmitonanexternalaircraftantenna.Youcanre-establishtheconnectionbetweentheaircraftradioandCOMantennabysimplyunpluggingtheKX-99Aadaptercable.
KX-99A Handheld Transceiver Adapter
AllFAP08seriesmic&jackhousingsaremadefromaluminumandfeatureacrinklefinish.
Part # DescriptionFAP08-1 BlackhousingFAP08-2 TanhousingFAP08-3 RawaluminumhousingFAP08-4 Blackflushmount w/bracket
FAP08 Series
Part# DescriptionFAP08-5 Tanflushmountw/bracketFAP08-6 Un-paintedflushmount w/bracketFAP08-7 BlackdualplacehousingFAP08-8 Tandualplacehousing
�
� Installatio
n Su
pp
lies
WIRE & CABLE
MIL-W-22759/16 Standard WallConductor:TinPlatedCopper Insulation:TEFZELVoltage Rating:600V Temperature Rating:150°C(302°F)Replacexwithcolorcode
Mil-W-22759/16wireincorporatesastandardwallofETFE(ethylenetetrafluoroethylene)insulation.Thiswireisdesignedforaerospaceapplicationswherelightweight,tighttolerancesandexcellentmechani-caltoughnessarerequired.Thisinsulationoffersexceptionalradiationandchemicalresistance.
Conductor:Mil-W-22759/16-Tinplatedcopper
RG393RG179RG142
WirespoonP/N SP1
Mil-spec Wire & Cable
ID No. Base Color ID No Base Color or Band First Stripe or Band Second Stripe
0 Black 90 White Black
1 Brown 91 White Brown
2 Red 92 White Red
3 Orange 93 White Orange
4 Yellow 94 White Yellow
5 Green 95 White Green
6 Blue 96 White Blue
7 Violet 97 White Violoet
8 Gray 98 White Gray
9 White 901 White Black Brown
902 White Black Red
Part Number Gauge Stranding Insulation O.D. (Min-Max) Nominal Wt. (lbs/1000’)
22759/16-24-x 24 19/36 .043-.047 2.45
22759/16-22-x 22 19/34 .050-.054 3.52
22759/16-20-x 20 19/36 .058-.062 5.18
22759/16-18-x 18 19/30 .069-.073 7.65
22759/16-16-x 16 19/29 .077-.081 9.68
22759/16-14-x 14 19/27 .091-.095 14.50
22759/16-12-x 12 37/28 .111-.117 21.80
22759/16-10-x 10 37/26 .136-.142 34.00
22759/16-8-x 8 133/29 .196-.202 61.50
22759/16-6-x 6 133/27 .247-.253 96.90
22759/16-4-x 4 133/25 .308-.316 152.00
22759/16-2-x 2 665/30 .384-.392 231.00
RG/U No. Jkt. OD Jkt. Type OD & Type Dielectric Center Cond. Nom. Imped. Ohms Max Operating Volt. (Rms) Engineering Data
RG58 C/U .195 IIa .116P 19/.0071TC 50.0 1900
RG59 C/U .242 IIa .146P .023CW 75.0 2300
RG142 B/U .195 IX .116T .039SCW 50.0 1900
RG179 .105 IX .093T 7/.04SCW 75.0 1200 High temp miniturized cable
RG188 A/U .110 VII .060T 7/.0067SCW 50.0 1200 High temp miniturized cable
RG213 U .405 IIa .285P 7/.0296C 50.0 3000 Formerly 8A/U
RG214 .425 IIa .285P 7/.0296S 50.0 3000 Formerly 9B/U
RG393 .390 IX .285T 7/.0312 50.0 5000 Moisture proof RG225
RG400 .195 IX .116T 19/.007SPC 50.0 1900 Same as RG142 except stranded center conductor
RG Coaxial Cables
�
� In
stal
lati
on
Su
pp
lies
WIRE & CABLE
XXTG1T14 XXTG3T14
XXTG2T14 XXTG4T14 P/N 14379 (M6370-1) P/N AN 181
22TG2T14
GuageBasic Wire
No. of ConductorsShield Style
Jacket
Shielded Wire
Part Number No. of Conductors Part Number No. of Conductiors
12TG2T14 2 20TG3T14 3
14TG1T14 1 20TG4T14 4
14TG2T14 2 22TG1T14 1
16TG1T14 1 22TG2T14 2
16TG2T14 2 22TG3T14 3
18TG1T14 1 22TG4T14 4
18TG2T14 2 24TG1T14 1
20TG1T14 1 24TG2T14 2
20TG2T14 2 24TG3T14 3
Recommended Temp. Limit: 302˚ F (150˚ C)MIL Number: M27500/18
7Conductor24awgcoilcordBlackCoil Cord
Storm Scope CableP/N480-891 WX1000SynchroCable Clear
P/N481-891 WX1000AntennaCable Blue
P/N482-891 WX1000DisplayCable Red
Fiber Optic CableP/NHCP-M0200T-D01FS
High Temp Quadraxial CableP/ND07802-100
ADF WireP/NAN181 SolidCopperAntennaWire
P/N14379 ADFCoatedAntennaWire
P/N801-175 ADFCoatedAntennaWire
P/N 8603
P/N NAF1086-4
P/N10-125
ADF Wire ComponentsP/N8603 StrainInsulator
P/N10-125 FeedThruInsulator
P/NNAF1086-4 TensionSpring
Black-P/N95-13576-00Gray-P/NAIS/CC
AIS Laser Wire Marking Services
See page 412 for more details.
�
� Installatio
n Su
pp
lies
Poly-Flo Tube Cutter
P/N 307-FP
Poly-Flo TubingImperialEastmanPoly-FloTubing.TobeusedwithImperialEastmanNylonandBrassFittings.
100 Foot Roll, P/N 44PE
IMPERIAL EASTMANNylon Fittings
Union Elbow265N04
Female Connector266N04x02
Male Connector268N04x02
Male Elbow269N04x02
Male Run Tee271N04x02
Male Branch Tee272N04x02
Bulkhead Union282N04
Female Elbow 270N04x02
Inline Connector262N04
Union Tee264N04
Nut261N04
Insert Stabilizer259N04
Not Shown: Plug P/N 259P04
Brass Fittings
Male Run Tee271P04x02
Nut261P04
Male Run Tee282P04
Union Tee264P04
Male Branch Tee 272P04x02
Inline Connector262P04
Male Elbow269P04x02
Male Connector268P04x02
Female Connector 266P04x02
Nylon Insert Fittings Usedwith1/4”hoseortubing
Tee Connector716-153
Elbow Connector 711-153
Inline Connector 701-153
Tee Connector716-015
Elbow Connector 711-015
Inline Connector 706-015
VINYL TUBINGFITTINGS
P/N Diameter LengthSLV-105-1/4 1/4” 100’SLV-105-3/8 3/8” 100’SLV-105-7/16 7/16” 100’SLV-105-1/2 1/2” 100’SLV-105-9/16 9/16” 100’SLV-105-5/8 5/8” 100’SLV-105-3/4 3/4” 100’SLV-105-7/8 7/8” 100’SLV-105-1 1” 100’
Vinyl TubingVinylTubingisanextremelyflexiblematerialdesignedprimarilyforlowtemperatureapplications.ConformstoMIL-1-6310.
�
� In
stal
lati
on
Su
pp
lies
C7-50-LP-0M 7”50lbLowProfileUVBlack 1000C7-50-LP-0C 7”50lbLowProfileUVBlack 100C7-50-LP-9M 7”50lbLowProfileNatural 1000C7-50-LP-9C 7”50lbLowProfileNatural 100C14-120-LP-0C 14”120lbLowProfileUVBlack 100C14-120-LP-0L 14”120lbLowProfileUVBlack 50C14-120-LP-9C 14”120lbLowProfileNatural 100C14-120-LP-9L 14”120lbLowProfileNatural 50
Cobra Low Profile Cable TiesFeatures•Safety•LowProfile•Strength•Smoothflexingcontouredhead•Trimmedstubretractsintocavity•Pick-proofundersidelock•Allroundededges•MeetsULandAS33671specs
Tyton P/N Amp P/N Panduit P/N Length Description Package
NT-4B/C 1-604771-0 PLT1M-C0 4” Black/Nylon18lb. Qty.100NT-4B/M 2-604771-0 PLT1M-M0 4” Black/Nylon18lb. Qty.1000NT-4/C 1-604771-9 PLT1M-C 4” White/Nylon18lb. Qty.100NT-4/M 2-604771-9 PLT1M-M 4” White/Nylon18lb. Qty.1000NT-4IDU/C 1-608701-09 PLM1M-C 4” White/NylonHoriz.18lb. Qty.100
NT-6B/C 1-603227-0 6” Black/Nylon30lb. Qty.100NT-6B/M 2-603227-0 PLT1.5I-M0 6” Black/Nylon30lb. Qty.1000NT-6/C 1-603227-9 PLT1.5I-C 6” White/Nylon30lb. Qty.100NT-6/M 2-603227-9 PLT1.5I-M 6” White/Nylon30lb. Qty.1000
NTM-6/C 1-608693-9 PLC1.5I-S8-C 61/4” White/Nylon#8ScrewMt.30lb. Qty.100
NT-7B/C 1-604772-0 PLT2S-C0 8” Black/Nylon50lb. Qty.100NT-7B/M 2-604772-0 PLT2S-MO 8” Black/Nylon50lb. Qty.1000NT-7/C 1-604772-9 PLT2S-C 8” White/Nylon50lb. Qty.100NT-7/M 2-604772-9 PLT2S-M 8” White/Nylon50lb. Qty.1000NT-8S/C 1-608687-9 PLT2M-C 8” White/Nylon18lb. Qty.100NT-8S/M 2-608687-9 PLT2M-M 8” White/Nylon18lb. Qty.1000NT-7ID/C 1-608702-9 PLM2S-C 8” White/NylonHoriz.50lb. Qty.100NT-11/M 2-604751-9 PLT3S-M 12” White/Nylon50lb. Qty.1000
NTH-14/C 1-604773-9 PLT4H-L 151/4” White/Nylon120lb. Qty.50NT-14B/C 1-604774-0 PLT4S-C0 151/2” Black/Nylon50lb. Qty.100NT-14B/M 2-604774-0 PLT4S-MO 151/2” Black/Nylon50lb. Qty.1000NT-14/C 1-604774-9 PLT4S-C 151/2” White/Nylon50lb. Qty.100NT-14/M 2-604774-9 PLT4S-M 151/2” White/Nylon50lb. Qty.1000NTM-14/C 1-608695-9 PLC4S-S10-C 16” White/Nylon#10ScrewMt.50lb. Qty.100 8-457 Slotted TywrapIDPlate Qty.100
I.D. CABLE TIE STANDARD CABLE TIE
MOUNTING CABLE TIE
T&B P/N Panduit P/N Length StrengthTY23M BT1M-M 3.6” 18LbsTY232M BT2M-M 8” 18LbsTY24M BT1.5I-M 5.5” 30LbsTY242M BT2I-M 8.2” 40LbsTY25M BT2S-M 7.3” 50LbsTY253M 11.4” 50LbsTY26M 11” 40LbsTY28M 14.2” 50Lbs
Standard Cable Ties WithMetalClip,1000Packs
TIE WRAPS
8
� Installatio
n Su
pp
lies
Lightning Hole Cable Tie Mount
P/NLHMS-S6-D “No.6P/NLHMS-S10-D “No.10
Tyton P/N Panduit P/N Strength MountingMB-3A ABMM-A-D 18to30lbs. #4ScrewMB-4A ABM112-A-D 18to50lbs. #8ScrewMB-5A ABM3H-A-L 18to150lbs. #8Screw
Adhesive & Screw Cable Tie Mounts
Tyton P/N Panduit P/N Strength MountingCTM-0 TM2S6-C 18lbs. #6ScrewCTM-1 TM2S8-C 18lbs. #8ScrewCTM-2 TM3S8-C 18to50lbs. #8ScrewCTM-3 TM3S10-C 18to50lbs. #10ScrewCTM-4 TM3S25-C 18to120lbs. 1/4”Screw
Cradle Cable Tie Mounts
P/N SizeMS21919WDG10 5/8”MS21919WDG11 11/16”MS21919WDG12 3/4”MS21919WDG13 13/16”MS21919WDG14 7/8”MS21919WDG15 15/16”MS21919WDG16 1“MS21919WDG17 1&1/16”MS21919WDG18 1&1/8”MS21919WDG19 1&3/16”MS21919WDG2 1/16”MS21919WDG20 1&1/4”MS21919WDG21 1&5/16”MS21919WDG22 1&3/8”MS21919WDG3 1/8”MS21919WDG4 3/16”MS21919WDG5 5/16”MS21919WDG6 3/8”MS21919WDG7 7/16”MS21919WDG8 1/2”MS21919WDG9 9/16”
Loop Type Fastener ADEL Clamp
P/N Size RangeXSL1/8-FR 3/32to1/8XSL1/8W-FR 3/32to1/8XSL1/4FR 1/8to3/8XSL1/4W-FR 1/8to3/8XSL3/8-FR 1/4to1/2XSL3/8W-FR 1/4to1/2XSL1/2-FR 1/4to3/4XSL1/2W-FR 1/4to3/4
P/N Size RangeXSL3/4W-FR 1/2to1XSL1-1/4-FR 1/2to11/4XSL1-1/4W-FR 1/2to11/4XSL13/4-FR 3/4to11/2XSL13/4W-FR 3/4to11/2XSL2-FR 11/4to21/2XSL2W-FR 11/4to21/2
Expandable SleevingDesigned for applications where full cover-age abrasion protection and fray resistanceisarequirement.
Panduitproductavailablebyrequest.
P/N MaxDia.SWP1/8 1/2SWP3/16 1-1/2SWP1/4 2SWP3/8 3
P/N Max Dia.SWP1/2 4SWP3/4 6SWP1 8
Spiral WrapUsed for long continuous runs whereindividual leads may be required tobreakoutatanygivenpoint. Comesin100’spool,NaturalorBlack.
Panduitproductavailablebyrequest.
P/N Color Width Length50NOF17B Black .085 500Yds50NOF17W White .085 500Yds
Braided Nylon Lacing CordLacingcordmeetsMilT43435Bandcomeswithasuregripcoating.500yardspoolsavailableineitherblackorwhite.
CABLOE MOUNTS AND FASTENERS
9
� In
stal
lati
on
Su
pp
lies
Heat Shrink TubingUsedforinsulating,jacketing,bundlingandidentification.Shrinksbetween200°and300°Carerecommended.Shrinkageislessthan5%.MIL-1-23053B/5,Classes1and2.Soldinfourfootsticks,andbythe100’roll.
Part Number DiameterHIX364 3/64”HIX116 1/16”HIX332 3/32”HIX18 1/8”HIX316 3/16”HIX14 1/4”HIX38 3/8”HIX12 1/2”HIX34 3/4”HIX1 1”
Part Number DiameterHSTT05 3/64”HSTT06 1/16”HSTT09 3/32”HSTT12 1/8”HSTT19 3/16”HSTT25 1/4”HSTT38 3/8”HSTT50 1/2”HSTT100 1”HSTT150 11/2”HSTT200 2”
PanduitTitan
Available Colors: 100’ Black White
4’ Black White Clear Red Blue
Available Colors: Black White Clear Red Blue
HEAT SHRINK TUBING
�0
� Installatio
n Su
pp
lies
Colorcodeyourflightcriticalcircuitbreakerswithcoloredbreakercollars.
CB Colored Breaker Collars
P/N Color10164-1 Black10164-2 Ivory10164-3 White10164-4 Orange10164-5 Red10164-7 Green10164-8 Gray10164-9 Yellow10164-10 Blue
Copper Buss Bar with Cadmium Plating
P/NMS25226-2-206-32HolesBusBarP/NMS25226-10-168-32HolesBusBar
Terminal Block CoversMS18029-1S-5 TerminalblockcoverMS18029-1S10 TerminalblockcoverMS18029-1S20 TerminalblockcoverMS18029-23 Knob,TerminalcoverMS18029-6S-16 TerminalblockcoverMS18029-6S-2 TerminalblockcoverMS18029-6S-8 Terminalblockcover
Keepscircuitbreakersfrombeingaccidentallyclosedwhenconnectedtoequipmentthathasbeenremovedorisunderrepair.
P/NS4933959-511SafetyLock(NoTag)P/NS4933959-531SafetyLockwith“Inoperative”tag
Circuit Breaker Safety Locks
HEX Standoffs1/4”outerdiameterHEXaluminum
HTA-4-250A 4-40thread,1/4”length
HTA-4-500A 4-40thread,1/2”length
HTA-4-750A 4-40thread,3/4”length
HTA-4-1000A 4-40thread,1”length
HTA-6-250A 6-32thread,1/4”length
HTA-6-500A 6-32thread,1/2”length
HTA-6-750A 6-32thread,3/4”length
HTA-6-1000A 6-32thread,1”length
HTA-8-250A 8-32thread,1/4”length
HTA-8-500A 8-32thread,1/2”length
HTA-8-750A 8-32thread,3/4”length
HTA-8-1000A 8-32thread,1”length
GrommetsVinylgrommet
G402 3/16”IDx5/16”OD
G403 1/4”IDx3/8”OD
G404 5/16”IDx7/16”OD
G405 3/8”IDx1/2”OD
G406 1/2”IDx5/8”OD
MS27212-1-20 6-32TerminalblockMS27212-2-16 10-32TerminalblockMS27212-6-16 8-32Terminalblock
And Many More! Call AIS
Terminal Blocks
MS25171-1SMS25171-2SMS25171-3SMS25171-4S
Terminal Boots
��
� In
stal
lati
on
Su
pp
lies
Aeronautical Test Kit
Asafe,quickandeasywaytotest99%ofallconnectorsintheaircraft.Kitincludesbothmaleandfemaleinsertsofthesixmostcommonsizesforringingoutallwiring.Compactwalletforeasystorage.
Additionalbackuppinsandsockettestleadsareavailable.
Part No 129392
Insulated ClipPart No 126087/ColorMaximumjawopening26mm(1inch)IEC61010Rating:600VoltsCATIII1000VoltsCatII™20AmpsStandardcolors:Black,Red,Green,Blue,Yellow,White.
Sprung HookPart No 121332/ColorIEC61010RATING:1000VoltsCATIII™30AmpsStandardColors:Black,Red
Part No 121331/Color IEC61010Rating:1000VCatIIIª30AmpsStandardColors:Black,Red
Thin Spike Test Prod
Part No 126088/ColorMaximumjawopening24mm(9.5inches)IEC61010Rating:1000VoltsCATIII™GS38Compliant
Fused Insulated Clip
Fused ProdPart No 121335/ColorFuseRating500mA/1000V/50kAReplacefuseP/N:116048GS38CompliantIEC61010RATING:1000VoltsCATIIIªStandardColors:Black,Red
Part No 124162/ColorEachextenderincreasesthereachofthepinsbyapprox75mm(3Inches)StandardColors:Black,Red
Extenders
Part No 134328/ColorOneendoftheleadisterminatedina4mmright-angledplug;theotherhasa4mmsocketintowhichtheoriginalleadisplugged.Designedtoberobustandsturdy.IEC61010Rating:1000VoltsCATIII™20Amps
�0’ Extender Reel
Part No 121333/Color Forcables2mm-4mm(0.080-0.16inches)IdealforAutomotive&otherapplications.Note:Recommendedforsafevoltagepiercingonly.IEC61010RATING:1000VoltsCATIIIª10AmpsStandardColors:Black,Red
Cable Piercer
TEST KITS AND ACCESSORIES
��
� Installatio
n Su
pp
lies
AGC Fast Blow Fuses MDL Slow Blow Fuses
Solder Sleeves Environmental Splices
P/N ALT#SLC745-14 SMALL(.125) LC-2SLC745-15 MEDIUM(.200) LC-3SLC745-16 LARGE(.300) LC-5
P/N ALT#M83519/2-1 Small / 20 Awg Lead HML-1M83519/2-2 Medium / 20 Awg Lead HML-2M83519/2-3 Large / 20 Awg Lead HML-3M83519/2-7 Medium / 22 Awg Lead HML-7M83519/2-8 Large / 22 Awg Lead HML-8M83519/2-9 X Large / 22 Awg Lead HML-9
P/N ALT#M81824/1-1 Red,RaychemEnv.Splice D436-36M81824/1-2 Blue,RaychemEnv.Splice D436-37M81824/1-3 Yellow,RaychemEnv.Splice D436-38
Usedforwiresplicingwheresizeandweightreductionandenviron-mentalsealingarecritical.
P/N AMP P/N AMP P/N AMP P/N AMP
AGC1 1 AGC5 5 MDL1 1 MDL5 5
AGC2 2 AGC7 7 MDL2 2 MDL7 7
AGC3 3 AGC10 10 MDL3 3 MDL10 10
AGC4 4 AGC15 15 MDL4 4 MDL15 15
SOLDER SLEEVESFUSES
Fuse Holders
Crimp
P/N HHB
with Leads
P/N 150145A
Panel Mount
P/N 342014
RayChemP/N: AD-1377 Alt P/N: 3137CT Daniels: GMT232
Environmental Crimpers
��
� In
stal
lati
on
Su
pp
lies
TYCO/ALCO/GRAYHILL
Miniature BAT Toggle
Miniature Locking BAT Toggle
SPDT Alt #MTA-106D 1571920-3 OnNoneOnMTA-106E 1571320-5 OnOffOnMTA-106F 1571920-7 OnNoneOnMTA-106G 1571920-9 OnOffOnMTA-106H 1571920-1 OnOffOnMTA206PA 1-1571920-1 OnOnOnMTA206R 2-1571920-1 OnNoneOnMTA206S 2-1571920-3 OnOffOnMTA206T 2-1571920-7 OnOffOnMTA206TA 2-1571920-8 OnOnOn
DPDT Alt #MTA-206N 1-1571920-5 OnNoneOnMTA-206P 1-1571920-7 OnOffOn3PDT Alt #MTA-306D 3-1571920-0 OnNoneOnMTA-306E 3-1571920-2 OnOffOn4PDT Alt #MTA-406N 3-1571920- OnNoneOnMTA-406P 4-1571920-0 OnOffOn
SPDT Alt #MTL-106D 1571927-2 OnNone OnMTL-106E 3-1437559-5 OnOff On3PDT Alt #MTL-306D 1-1571927-0 OnNone OnDPDT Alt #MTL-206N 1571927-5 OnNone OnMTL-206P 1571927-7 OnOff On4PDT Alt #MTL-406N 1-1571927-2 OnNone On
Momentary PushbuttonsMPA-206N DPDTMPA-206R DPDT(mom)MPA-103F SPDT,BlackMPA-306F 3PDT(mom)
611-4302 MasonSwitch PTTSwitchthatgoesin mostCessnaAircraft
•Reliable•Economical•ULRecognized•CSACertified
P/N 30-1 Black 30-2 Red 30-3 Black
Sub-miniaturemomen-tarypushbuttonusedinmostPiper,PA-24&PA-28SeriesairplanesforPTTSwitches
P/N 39-1
Sub-miniaturemomen-tarypushbutton.ThisisaN/CSwitch.CanbeusedinsomeAutopilotinstalls.
P/N 39-2 39-3 Short
PUSHBUTTONS AND TOGGLES
SPST:NormOpen,1/4”ThreadsMSPS-103C0 BlackMSPS-103C2 Red
2Circuit,NormOpen-NormClosed,1/2”Threads,MSPF-101BC0 BlackMSPF-101BC2 Red
Miniature Short ToggleP/N Alt #MTG106D04 1571926-3 OnNone OffMTG106E04 1571926-4 OnOff OnMTF106D 1571925-3 OnNone OnMTF106G 1571925-6 OnOff OnMTF206N 1-1571925-6OnNone OnMTF206T 2-1571925-2OnOff On
��
� Installatio
n Su
pp
lies
7274 Mil Spec’dsame size as 7277 Series.
7277-5-.57277-5-.757277-5-17277-5-1.57277-5-27277-5-2.57277-5-37277-5-57277-5-7.57277-5-107277-5-157277-5-20
����-� Series
7270-5-37270-5-57270-5-107270-5-157270-5-207270-5-257270-5-307270-5-35
���0-� Series2TC2-12TC2-22TC2-2.52TC2-32TC2-42TC2-52TC2-7.52TC2-102TC2-152TC2-20
�TC� Series7271-8-37271-8-57271-8-7.57271-8-107271-8-157271-8-207271-8-257271-8-307271-8-35
����-8 Series7270-1-37270-1-57270-1-7.57270-1-107270-1-157270-1-207270-1-257270-1-307270-1-35
���0-� Series
7274-2-.57274-2-17274-2-1.57274-2-27274-2-2.57274-2-37274-2-47274-2-57274-2-7.57274-2-107274-2-157274-2-20
����-� Series7277-2-.57277-2-17277-2-1.57277-2-27277-2-2.57277-2-37277-2-47277-2-57277-2-7.57277-2-107277-2-157277-2-20
����-� Series7274-11-.57274-11-.757274-11-17274-11-1.57274-11-27274-11-2.57274-11-37274-11-47274-11-57274-11-7.57274-11-107274-11-157274-11-20
����-�� Series
KLI
XO
N
W23X1A1G-1W23X1A1G-2W23X1A1G-3W23X1A1G-4W23X1A1G-5W23X1A1G-7.5W23X1A1G-10W23X1A1G-15W23X1A1G-20W23X1A1G-25W23X1A1G-30W23X1A1G-35W23X1A1G-40W23X1A1G-50
W��-X�A�G SeriesW58XC4C12A-1W58XC4C12A-2W58XC4C12A-3W58XC4C12A-4W58XC4C12A-5W58XC4C12A-7W58XC4C12A-10W58XC4C12A-15W58XC4C12A-20W58XC4C12A-25W58XC4C12A-30W58XC4C12A-35
W�8-XC�C��A SeriesW31X2M1G-1W31X2M1G-2W31X2M1G-3W31X2M1G-4W31X2M1G-5W31X2M1G-7.5W31X2M1G-10W31X2M1G-15W31X2M1G-20W31X2M1G-25W31X2M1G-30W31X2M1G-35W31X2M1G-40W31X2MIG-50
W��-X�M�G Series
PO
TTER
& B
RU
MFI
ELD
41-3K14LN2-6041-3K14LN2-70A41-3S14LN2-100
��-� Series
E-T-
A
High Amperage Circuit Breaker
See next page for available Outline Dimension drawings...
PUSHBUTTONS AND TOGGLES
��
� In
stal
lati
on
Su
pp
lies
W�� Series
W�� Series
W�8 Series
���� Series
���� & ���� Series
���0 Series
�TC� Series
PUSHBUTTONS AND TOGGLE DIMENSIONS
��
� Installatio
n Su
pp
lies
AEROSPACE INSTRUMENT SUPPORT, INC.
Nite LitesPart Number Current in mANL21414V 130mANL21428V 50mANL31814V 260mANL31828V 98mANL21414VALT 130mANL21428VALT 50mANL31814VALT 190mANL31828VALT 75mA
This product is approved and has met all PMA / FAA requirements. 2000 PMA number is PQ943SW.
For Blue-White bulbs add BW to end of part number.*
The Nite Lite product line has been approved to be installed on the following aircrafts:
AIS Recommends...
[email protected]@28V0-32Volts.40lbs.L4.75”W1.5”H1.25”[email protected]@28V
Installation:1.Mountdimmermoduleandrheostat2.Routewiringharnessandconnect matingconnectors3.Connectblackwiretoground.4.Connectredwiretocircuitbreaker.5.Connectyellowwiretolightsbeingdimmed.6.Testdimmersystemforproperoperation.
DM-�0 non-PMA’dDimmingModule
...for more dimming modules see the Inverters and Converters Section.
Also available in 5 volt*.
The New Piper Aircraft. Inc.ComancheSeriesPA-24-400,PA-24-260,PA-24-250andPA-24-180ArrowSeriesPA28RT-201,PA28R-180,PA28R-200,andPA-24-201CherokeeSeriesPA-32,andPA-32R“J”SeriesPA-ll,PA-12,PA-14,andPA-16Tri-PacerPA-22Warrior/CadetPA-28-151,andPA-28-161DakotaPA-28-236SaratogaPA-32RNavajoPA-31P,PA-31-350CheyenePA-42-l000,PA-42,PA-31T-500,andPA-31T-620
The Cessna Aircraft Company140Series150Series170Series180Series
Raytheon Aircraft Company / BeechcraftBonanzaSeries33,F33,35,V35B,A36,A36TC,andB36TCDebonair—95TravelAirSeries55A,55B,55C,55D,AND55EBaron55-55EBaron58-58,58TC,and58P
Mooney Aircraft CorporationMooneySeriesM20,M20C,M20G,M20E,M2OF,200S, 20K,23L/M,and252-TSEMooneyBravoM20M *5 Volt and Blue-White itterations are not PMA Approved
��
� In
stal
lati
on
Su
pp
lies
•Flameretardatives•Space-savingdesign•Excellentvoiceclarity•Builttothedemandingspecificationsofaircraftmanufacturers•topperformanceundertoughaltitudeandtemperatureconditions.
Quam Speakers
Part Number Size/Shape Depth Freq ResponsePower
CapacityVoice Coil
ImpedanceMagnet Material
Flame Redardant?
30A05Z8 3” Square 1.281” 150-12 kHz 2W 8 Alnico V N
30C25Z8 3” Square 1.188” 150-14 kHz 5W 8 Ceramic N
35A05Z8 3”x5” Oval 1.500” 130-14 kHz 2W 8 Alnico V N
4C3Z8FR 4” Square 1.625” 200-12 kHz 5W 8 Ceramic Y
52C5FR 51/4” Round 2.000” 100-8 kHz 10W 3.2 Ceramic Y
SC Series(Panel Mount)
Fig. 2
.31".03"
.2506.35
7/1611.11
Length
*0.03 Projections Are Not 45
3/89.52
.03"
15/3211.90
15/1633.3
Knurled Nut
11/8-24 UNS 2A Thread28.57
1.125"28.57
1.220"30.98
LockingFlats
Emitspenetratingsignalatmin.current.Solid-statecircuit--noarcing--noRFnoise,nomechanicalwear,lowestfailureratewithmaximumefficiency.Compact,lightweight,versatile--consumeslesscurrentthannormalindicatorlight.Idealforuseassafetydevice.Alertstomechanicalmalfunctionsincars,communications,computers,firesignals,medicalelectronics,etc.Sonalertsignalsmaybepoweredbymanyelectricalsourcesrangingfromsinglecellbatteriestoindustrialpowerlines.Littleelectricalpowerisrequiredmakingthemideallysuitableforportablebatteryoperatedequipment.ThislowpowerfeatureallowstheSonalertsignaltobeturnedonoroffwithalowpowertransistor,SCR,orintegratedcircuit.Featuresaself-exterminatingblacknyloncase.
Part Number Sound Freq. Tone Sound Level Oper. Volts Oper. Curr. Oper. Temp. Diameter Length Weight
SC628 2900 Hz Continuous 68-80 dB 6-28 DC 3-18 mA -20 C to +65 C 1.687 in 0.812 in 8 oz
SC628D 1900 Hz Continuous 60-75 dB 6-28 DC 6-23 mA -20 C to +65 C 1.687 in 0.812 in 8 oz
SC628P 2900 Hz Pulse/Fast 68-80 dB 6-28 DC 6-26 mA -20 C to +65 C 1.687 in 1.375 in 8 oz
SC628J 2900 Hz Pulse/Slow 68-80 dB 6-28 DC 6-26 mA -20 C to +65 C 1.687 in 1.375 in 8 oz
Sonalert Solid-State Audible Warning Device
Part Number ConfigurationAIS-AUD5025 3”SquareAIS-AUD5030 4”SquareAIS-AUD5026 4”RoundAIS-AUD5040 4”RoundDVC*AIS-AUD5044 4”SquareDVC*AIS-AUD5027 5”RoundAIS-AUD5041 5”RoundDVC*AIS-AUD5032 5”SquareAIS-AUD5045 5”SquareDVC*AIS-AUD5028 5¼”Round
Part Number ConfigurationAIS-AUD5042 5¼”RoundDVC*AIS-AUD5029 6½”RoundAIS-AUD5043 6½”RoundDVC*AIS-AUD5036 4”X6”OvalAIS-AUD5049 4”X6”OvalDVC*AIS-AUD5038 5”X7”OvalAIS-AUD5051 5”X7”OvalDVC*AIS-AUD5039 6”X9”OvalAIS-AUD5052 6”X9”OvalDVC*
DVC = Dual Voice Coil
Avionics International Supply Speakers
SPEAKERS
�8
� Installatio
n Su
pp
lies
5225395-1 Male Dual Crimp BNC, RG58225395-2 Male Dual Crimp BNC, RG59-62225395-3 Male Dual Crimp BNC, RG55-2235225395-6 Male Dual Crimp BNC, RG142-400225395-7 Male Dual Crimp BNC, RG174-316, 225395-8 RG58 Plated Male RG179225395-5 RG58 Plated Male RG141
31-320 BNC Male Crimp RG58 Mil Spec #M233293-0131-320RFX BNC Male Crimp RG58/142/400 Comm Grade31-2RFX Male Solder & Screw BNC, UG88
225397-1 Female Panel Jack BNC Dual Crimp, RG58
5225973-1 Right Angle Male Dual Crimp BNC, RG58, Silver Finish225974-1 Right Angle Male Dual Crimp BNC, RG58, Nickel Finish5225973-4 Right Angle Male Dual Crimp BNC, RG142, 400
225396-1 Female Dual Crimp BNC, RG58225396-2 Female Dual Crimp BNC, RG59-62225396-7 Female Dual Crimp BNC, RG174, RG3162-331351-1 Silver Plated Female Dual Crimp BNC, RG58PE4397 Female Dual Crimp, RG142, RG400
2-225395-1 Male Dual Crimp BNC, RG8-213
31-220NRFX Female to Female Bulkhead BNC, no seal330024 Female to Female Bulkhead BNC, silver w/rubber seal
BNC Connectors TNC Connectors225550-2 Male Dual Crimp TNC, RG58 Silver Finish225555-2 Male Dual Crimp TNC, RG58 Nickel Finish5225555-6 Male Dual Crimp TNC, RG142, 400 Nickel Finish225555-7 Male Dual Crimp TNC, RG8, 213
79075 TNC Right Angle Plug, Clamp & Solder for RG5879125 TNC Right Angle Adapter
225551-2 Female Dual Crimp TNC, RG58225551-6 Female Dual Crimp TNC, RG142
225559-2 Male Right Angle TNC, Dual Crimp RG585225554-6 Male Right Angle TNC, Dual Crimp RG142-400225349-9 Male Right Angle TNC, Dual Crimp RG9, 214
9-30-10 Tray Mount RF Connector
Tray Mount RF Connector
MS16624-1046 Snap Ring for 9-30-10 connector
GPS Notch filter from TED eliminates harmonic noise interference with your GPS receiver.P/N: 4-70-54
GPS Notch Filter
CONNECTORS AND ADAPTERS
�9
� In
stal
lati
on
Su
pp
lies
225532-1 Male Crimp SMA, RG58225532-4 Male Srimp SMA, RG316, 174, 188225532-3 Male Crimp SMA, RG142, 400
SMA & UHF Connectors
226279-1 UHF Connector, RG58
BNC Adapters
221988-1 BNC Female T, Female to Female to Female (Amphenol)
222320-1 BNC Female to UHF Male (AMP)31-28RFX BNC Female to UHF Male (Amphenol)
31-217RFX BNC Male to N Female (Amphenol)
222321-1 BNC Female to N Male (AMP)31-216RFX BNC Female to N Male (Amphenol)
221543-2 BNC Tee, Female to Male to Female (AMP)31-208RFX BNC Tee, Female to Male to Female (Amphenol)
222165-2 BNC Male to Female Rt. Angle (AMP)31-9RFX BNC Male to Female Rt. Angle (Amphenol)
221551-1 BNC Female to Female (AMP)31-219 BNC Female to Female (Amphenol)
31-218RFX BNC Male to Male (Amphenol)
BNC Adapters (CONT’D)
31-221RFX BNC blukhead receptacle front mount, solder cup terminal (Amphenol)
5228226-1 BNC bulkhead adapter Female to Female with no rubber seal.
N Type Connectors
225392-2 N Male Dual Crimp Silver Body Plating RG142, 4005225699-1 Male Dual Crimp Nickle Body Plating “N” RG142, 400
DBFTMA-90 BNC-TNC Right Angle for use with Eaton and Mid-Continent WAAS Kits
CONNECTORS AND ADAPTERS
�0
� Installatio
n Su
pp
lies
324043 8G #10 Ring Terminal324082 8G 1/4 Ring Terminal324046 6G #10 Ring Terminal324047 6G 1/4 Ring Terminal324049 6G 3/8 Ring Terminal
“Terminal” Ring Terminals
320555 22-1 6 Knife Splice/Red320566 16-1 4 Knife Splice/Blue320620 1 2-1 0 Knife Splice/Yellow
“PIDG” Kinfe Splices
323994 26-22 Butt Splice/Gold323975 24-20 Butt Splice/Clear320559 22-16 Butt Splice/Red320562 . 16-14 Butt Splice/Blue320570 12-10 Butt Splice/Yellow
“PIDG” Butt Splices
320553 22-16 #4 Ring Terminal/Red36152 22-16 #6 Ring Terminal/Red320554 22-16 #8 Ring Terminal/Red320551 22-16 #8 Ring Terminal/Red36154 22-16 #10 Ring Terminal/Red320571 22-161/4 Ring Terminal/Red320572 22-16 5/1 6 Ring Terminal/Red320573 22-16 3/8 Ring Terminal/Red328996 16-14 #4 Ring Terminal/Blue320619 16-14 #6 Ring Terminal/Blue320565 16-14 #8 Ring Terminal/Blue36160 16-14#10 Ring Terminal/Blue321045 16-14 1/4 Ring Terminal/Blue
“PIDG” Ring Terminals
32996 8G #8 Ring Terminal33460 8G #10 Ring Terminal33461 8G 1/4 Ring Terminal33462 8G 5/16 Ring Terminal33463 8G 3/8 Ring Terminal321298 6G #10 Ring Terminal321598 6G 1/4 Ring Terminal33466 6G 5/16 Ring Terminal33467 6G 3/8 Ring Terminal
33469 4G 1/4 Ring Terminal33470 4G 5/16 Ring Terminal33471 4G 3/8 Ring Terminal320383 2G 1/4 Ri ng Terminal nal322870 2G 5/16 Ring Terminal321600 2G 3/8 Ring Terminal36918 1/0 7/16 Ring Terminal36919 1/0 1/2 Ring Terminal
“Solistrand” Ring Terminals and Splices
606289-1 4G 1/4 Ring Terminal606290-2 2G 5/16 Ring Terminal606290-5 2G 3/8 Ring Terminal
“Round Tongue” Terminals
324484 White324485 Red324486 Blue324487 Yellow
Wire Caps
Pins201298-1 Receptacle 14200838-2 Receptacle 34
Pins203540-1 Grounding Block 14204814-1 Grounding Block 34
Grounding Blocks
P/N Length Under Head201087-1 1.25 IN203618-1 1.437 IN
Male Jack Screws
P/N AWG Finish66105-1 24/20 Gold/Nickel66105-4 24/20 Sel/Gold/Nickel66101-1 18/16 Gold/Nickel66101-4 18/16 Sel/Gold/Nickel
Sockets For Grounding Block Receptacle
Metrimate Connectors
Pins Plug Width Height4 207015-1 .799 .7126 207152-1 .988 .712
9 207439-1 .988 .945
12 201017-1 1.181 .945
18 201422-1 1.594 .94524 207304-1 1.594 1.11436 207019-1 2.185 1.114
RCPT Width Height207016-1 .799 .712207153-1 .988 .712
207440-1 .988 .945
207018-1 1.181 .945
207443-1 1.594 .945207305-1 1.594 1.114207020-1 2.185 1.114
Strain ReliefN/A
207600-1
207601-1
207602-1
207603-1207088-1207604-1
Pins AWG66103-1 24/2066103-4 24/20
66099-1 18/16
66099-4 18/16
Sockets AWG66105-1 24/2066105-4 24/20
66101-1 18/16
66101-4 18/16
FinishGold/Nickel
Sel/Gold/Nickel
Gold/Nickel
Sel/Gold/Nickel
328998 16-14 5/16 Ring Terminal/Blue328999 16-14 3/8 Ring Terminal/Blue320634 12-10 #6 Ring Terminal/Yellow320568 12-10#8 RingTerminal/Yellow35109 12-10 #10 Ring Terminal/Yellow320569 12-10 1/4 Ring Terminal/Yellow320576 12-10 5/16 Ring Terminal/Yellow320577 12-10 3/8 Ring Terminal/Yellow323784 12-10 1/2 Ring Terminal/Yellow
CONNECTORS AND PINS
��
� In
stal
lati
on
Su
pp
lies
Mate-N-Lok Connectors
Pin AWG60618-1 24/1860618-4 24/1860618-5 24/18 350690-[ ] 24/1860620-1 20/1460620-4 20/1460620-5 20/14 350547-[ ] 20/14350552-[ ] 20/14
Socket Finish60617-1 Brass/Tin60617-4 Phosphor Bronze/Tin60617-5 Brass Gold/Nickel Plate350689-[ ] 60619-1 Brass/Tin60619-4 Phosphor Bronze/Tin60619-5 Brass Gold/Nickel Plate 350550-[ ] 350551-[ ]
Pins Pin Housing Socket Housing6 1-480271-0 1-480270-08 1-480284-0 1-480283-010 1-480286-0 1-480287-012 1-480288-0 1-480287-016 1-480439-0 1-480438-0
Motor MountPins Pin Housing Socket Housing1 1-480350-0 1-480349-0 350865-[ ] 350866-[ ]2 1-480319-0 1-480318-0 350777-[ ] 350778-[ ]3 1-480305-0 1-480303-0 350766-[ ] 350767-[ ]4 1-480426-0 1-480424-0 350779-[ ] 350780-[ ] 5 350809-[ ] 350810-[ ]6 1-480340-0 1-480270-0 350715-[ ] 350781-[ ]8 1-480345-0 1-480283-0 9 350720-[ ] 350782-[ ]10 1-480339-0 1-480285-012 350735-[ ] 350783-[ ]15 350736-[ ] 350735-[ ]
Free HangingPins Pin Housing Socket Housing3 1-480305-0 1-480304-04 1-480426-0 1-480425-06 1-480276-0 1-480273-09 1-480277-0 1-480274-012 1-480278-0 1-480275-0
Panel Mount
Subminiature D Connectors
Pins Plugs Receptacle Plugs Receptacle Backshell9 205204-1 205203-1 747904-4 747905-4 5205729-115 205206-1 205205-1 747908-4 747909-4 205730-125 205208-1 205207-1 747912-4 747913-4 205718-137 205210-1 205209-1 747916-4 747917-4 5205731-150 205212-1 1658640-2 5205732-1
SolderCrimp Back Shell
High Density Sub-D Connectors
Pins Plugs Receptacle 15 204501-1 204500-126 204503-1 204502-144 204505-1 204504-162 204507-1 204506-178 204509-1 204508-1104 204511-1 204510-1
205089-1 24/20
Pins
1-66506-0 24/20
205090-1 24/20
Sockets
1-66504-1 24/20
Latch Clip Assembly206942-1
Male Screw Retainers205980-1
Jack Screw5205817-1
204370-2 22/28
HD Pins
204351-1 22/28
HD Sockets
ALT: M39029/58-360 ALT: M39029/57-354
P/N030-01107-0000Alt P/N: 08-05-0302
King Double Edge Pins
P/N41317
Narco Contacts
ARC Transponder ContactsP/N 66010-2 M22520/2-09(Pin)
M22520/2-06(Socket)
HD Positioner
��
� Installatio
n Su
pp
lies
Power Connector Standard .062” (1.57mm)
Series-Circuit Size 1625-1 1625-2 1625-3 1625-4 2004-4 1625-5 1625-6 1625-9 1625-12 1625-15 1625-24 1772-36
Amperes/Circuit (Max) 5 5 5 5 5 5 5 5 5 5 5 5
Voltage Rating (Max) 250 250 250 250 250 250 250 250 250 250 250 250
Receptacle
Panel Mount N/A 03-06-1022 03-06-1038 03-03-1041 03-06-1043 03-06-1055 03-06-1061 03-06-1091 03-06-1121 N/A 03-06-1241 03-06-1361
Free Hanging 03-06-1011 03-06-1023 03-06-1032 03-06-1042 03-06-1044 03-06-1056 03-06-1062 03-06-1092 03-06-1122 03-06-1152 N/A 03-06-1362
Plug
Panel Mount N/A 03-06-2024 03-06-2033 03-06-2041 03-06-2043 03-06-2054 03-06-2062 03-06-2091 03-06-2121 03-06-2151 03-06-2241 03-06-2261
Free Hanging 03-06-2011 03-06-2023 03-06-2032 03-06-2042 03-06-2044 03-06-2055 03-06-2061 03-06-2092 03-06-2122 03-06-2152 03-06-2242 03-06-2362
Crimp WIre Size Insulation Dia.
Series (Male/Female) Male Female Male Female
18-24 .060/.120 1560/1561 02-06-2101 02-06-1101 02-06-2103 02-06-1103
24-30 .040/.090 1854/1855 02-06-2131 02-06-1131 02-06-2132 02-06-1132
Chain Form Order Numbers Loose Form Order Numbers
Standard Brass .0�0” Pins Tin Plated
Pin AWG66103-1 24/2066103-4 24/2066099-1 18/1666099-4 18/16
Socket Finish66105-1 Gold/Nickel66105-4 Sel/Gold/Nickel66101-1 Gold/Nickel66101-4 Sel/Gold/Nickel
Series � CPC Connectors Series � CPC Connectors
Series 2 CPC uses D-Sub Pins & Sockets
Standard Sex Connectors
Pin Shell SizeSquare Flange
ReceptacleFree-Hanging
Recptacle Plug
4 11 206061-1 206153-1 206060-1
9 13 206705-1 206705-2 206708-1
16 17 206036-1 206036-3 206037-1
24 23 206838-1 206838-2 206837-1
37 23 209151-1 206151-2 206150-1
Pin Shell SizeSquare Flange
ReceptacleFree-Hanging
Recptacle Plug
4 11 206430-1 206430-2 206429-1
14 13 206043-1 206043-3 206044-1
37 23 206306-1 206306-2 206305-1
Reverse Sex Connectors
Standard Sex Connectors
Pin Shell SizeSquare Flange
ReceptacleFree-Hanging
Recptacle Plug
8 11 205841-1 205841-2 205838-1
9 11 206486-1 206486-2 206485-1
28 17 205840-3 206152-1 205839-3
63 23 205843-1 205843-2 205842-1
Reverse Sex Connectors
Pin Shell SizeSquare Flange
ReceptacleFree-Hanging
Recptacle Plug
8 11 206433-1 206433-2 206434-1
28 17 206038-1 206038-2 206039-1
57 23 206438-1 206438-2 206437-1
Pin AWG205089-1 20/24
Socket Finish205090-1 Gold(M39029/63-368)
See N
ext P
age f
or Cl
amps
CONNECTORS AND PINS
��
� In
stal
lati
on
Su
pp
lies
Part Number Color Alt. Num Size
Plastic
M81969/14-01 Green/White 6500-048-22 22D
M81969/14-02 Red/White 294-108 20
M81969/14-03 Blue/White 8522-16 16
M81969/14-04 Yellow/ White 8522-1 12
M81969/14-06 Red 650-018-8 8
M81969/14-10 Red/Orange 6500-055-20 20
M81969/14-11 Red/White 6500-001-0020 20
M81969/16-02 Light Blue/ White 81515-16 16
M81969/39-01 Green/White 6500-045-20 20
M15570-22-1 Yellow/White ATD 1035 22
Metal
M81969/1-01 Green/White 91066-1 22
M81969/1-02 Red/White 91066-4 20
M81969/1-03 Blue/White 91066-3 16
M81969/1-04 Green/White 91067-1 12
Insertion Extraction Tools
Extraction ToolsP/NCL6860-14VP/NCL2400-24VCigaretteLightersocket
P/NQ227-115Snapin115VACPlug
AC/DC Recepticles
P/N Shell Size206062-3 11206966-7 13206070-1 17206138-8 23
Clamps
Flat pin extractor
P/N 11-03-0003
P/N 91285-1
Economical Model 91067-2 has long-lasting metaltips forusewithmost rear-releaseRS-232connec-tors,wiresizes20-24AWG.Oneendof the tool isusedtoinsertcontacts,andtheotherendisusedtoextractcontacts.InterchangeabletipModel91285-1isdesigned to insertandextractHD-22andHD-20contacts, wire sizes 22-28 AWG. Tool comes withfour insertion/extractiontips,hexwrench(tochangetips),andtip-lockingplug.
Insertion/Extraction Tool
��
� Installatio
n Su
pp
lies
U Type Nuts
Part Number Thread SIzeC8095-632-4 6-32
Blackfinish,ExtendedReach
Instrument Clips/Snap Rings
InstrumentMountingClips
MS Part Number NAS Part Number Leg Length Thread SizeMS33737-9C NAS487-13 .067” 6-32MS33737-10C NAS487-14 .096” 6-32MS33737-11C NAS487-15 1/8” 6-32MS33737-12C NAS487-16 .187” 6-32MS33737-13C NAS487-17 1/4” 6-32MS33737-14C NAS487-18 .312” 6-32MS33737-15C NAS487-20 3/8” 6-32MS33737-16C NAS487-21 Universal 6-32
SnapRingMS Part NumberMS16624-1046
Nut SertsInsert,Steel,FlushMount,OpenEnd,KnurledNutSerts
Part Number Thread SIze6-32 6-328-32 8-3210-32 10-32
Rivnut(K=Keyed)Part Number Mil Spac. P/N Thread SizeA6-75 MS27130-7 6-32 6-32A6K-75 MS27130-A7K 6-32A8-75 MS27130-8 8-32A8K-75 MS27130-A8K 8-32
AN Part Number Thread SizeAN256-6 6-32AN256-8 8-32AN256-10 10-32
NutPlate,Selflocking,TwoLug,Floating,LowHeight,C’Bored,ReducedRivetSpacing
NutPlate,Selflocking,TwoLug,Floating,LowHeightMS Part Number NAS Part Number Thread SizeMS21059-L04 NAS686-04 4-40MS21059-L06 NAS686-06 6-32MS21059-L08 NAS686-08 8-32
NutPlate,Selflocking,TwoLug,LowHeight,C’Bore,ReducedRivetSpacingNAS Part Number Thread SizeNAS697-A04 4-40NAS697-A06 6-32NAS697-A06L 6-32NAS697-A08 8-32NAS697-A3 10-32
Anchor Nuts
NutPlate,Selflocking,TwoLug,LowHeightMS Part Number Thread SizeMS21047-L06 6/32MS21047-L08 8-32MS21047-L3 10-32
Washers
LockWasher,CarbonSteel,CadmiumPlated,(MS35338)MS NumberMS35338-40MS35338-41MS35338-42
Screw Size#4#6#8
MS NumberMS35338-43MS35338-44MS35338-45
Screw Size#101/4
5/16
FlatWasher,CarbonSteel,CadmiumPlated,(AN960)
AN NumberAN960-4AN960-6AN960-8AN960-10
Screw Size#4#6#8
#10
AN NumberAN960-416AN960-516AN960-616
Screw Size1/4
5/163/8
LockWasher,CarbonSteel,CadmiumPlated,(MS35333)
MS NumberMS35333-36MS35333-37MS35333-38MS35333-39
Screw Size#4#6#8
#10
MS NumberMS35333-40MS35333-41MS35333-42
Screw Size1/4
5/163/8
FlatWasher,CarbonSteel,CadmiumPlated,(AN970)AN Number Screw SizeAN970-3 #10AN970-4 1/4AN970-5 5/16AN970-6 3/8
NutsNut,SelfLockingNylonInsert,Tall,250°F,Non-CorrosionResistantSteel,(MS21044)MS NumberMS32044N04MS32044N06MS32044N08MS32044N3
Thread Size4-406-328-32
10-32
MS NumberMS32044N4MS32044N5MS32044N6
Thread Size1/4-28
5/16-243/8-24
Nut,SelfLockingAllMetal,450’F,ReducedHexagon,ReducedHeight,RingBase,Non-CorrosionResistantSteel,(MS21042)MS NumberMS21042-04MS21042-06MS21042-08MS21042-3
Thread Size4-406-328-32
10-32
MS NumberMS21042-4MS21042-5MS21042-6
Thread Size1/4-28
5/16-243/8-24
Nut,SelfLockingAllMetal,Tall,550°F,Non-CorrosionResistantSteel,(AN363)
AN NumberAN363-632AN363-832AN363-1032AN363-428AN363-524AN363-624
Alt. Part NumberMS21045-06MS21045-8MS21045-3MS21045-4MS21045-5MS21045-6
Thread Size6-328-32
10-321/4-28
5/16-243/8-24
Nut,SelfLockingNylonInsert,Short,250°F,Non-CorrosionResistantSteel,(MS20364)
MS NumberMS20364-632MS20364C-632MS20364-832MS20364C-832MS20364-1032MS20364C-1032
Alt. Part Number
MS21083C06
MS21083C08
MS21083C3
Thread Size6-326-328-328-32
10-3210-32
Nut, (MachinedSteel)(MS35649&MS35650)MS NumberMS35649-242MS35649-262MS35649-282MS35650-302
Thread Size4-406-328-32
10-32
MS NumberMS35650-3252MS35650-3312MS35650-3382
Thread Size1/4-28
5/16-243/8-24
NUTS AND WASHERS
��
� In
stal
lati
on
Su
pp
lies
Machine Screws
Pan Head, Cross Recessed, Carbon Steel, (StainlessSteel)(MS51957)
MS NumberAN525-10R6AN525-10R8AN525-10R10AN525-10R12AN525-10R16
Length3/81/25/83/4
1
Thread Size10-3210-3210-3210-3210-32
MS NumberAN525-832R6AN525-832R8AN525-832R10AN525-832R12AN525-832R16
Length3/81/25/83/4
1
Thread Size8-328-328-328-328-32
Truss Head, Cross Recessed, Carbon Steel, (StainlessSteel)(AN526)
AN NumberAN526C832R16AN526C832R32AN526C1032R4AN526C1032R8AN526C1032R12AN526C1032R16AN526C1032R24AN526C1032R32
Length12
1/41/23/4
11 1/2
2
Thread Size8-328-32
10-3210-3210-3210-3210-3210-32
AN NumberAN526C632R4AN526C632R8AN526C632R12AN526C632R16AN526C632R24AN526C832R4AN526C832R8AN526C832R12
Length1/41/23/4
11 1/21/41/23/4
Thread Size6-326-326-326-326-328-328-328-32
Pan Head, Cross Recessed, Carbon Steel,(StainlessSteel)(MS51957)
MS NumberMS51957-13MS51957-17MS51957-19MS51957-21MS51957-26MS51957-30MS51957-32
Length1/41/23/4
11/41/23/4
Thread Size4/404/404/404/406-326-326-32
MS NumberMS51957-34MS51957-36MS51957-41MS51957-45MS51957-47MS51957-49MS51957-50
Length1
1 1/21/41/23/4
11 1/8
Thread Size6-326-328-328-328-328-328-32
Flat Countersunk 100” Head, Cross Recessed, Black Brass,(MS24693)
MS NumberMS24693-BB32MS24693-BB36
Length1
1 1/2
Thread Size6-326-32
MS NumberMS24693-BB54MS24693-BB58
Length1
1 1/2
Thread Size8-328-32
MS NumberMS24693-C2MS24693-C4MS24693-C6MS24693-C7MS24693-C8MS24693-C9MS24693-C10MS24693-C24MS24693-C26MS24693-C28 MS24693-C29MS24693-C30MS24693-C31MS24693-C32MS24693-C34MS24693-C36MS24693-C38MS24693-C40MS24693-C46MS24693-C48
Length1/43/81/25/83/47/8
11/43/81/25/83/47/8
11 1/41 1/21 3/4
21/43/8
Thread Size4-404-404-404-404-404-404-406-326-326-326-326-326-326-326-326-326-326-328-328-32
MS NumberMS24693-C50MS24693-C51MS24693-C52MS24693-C53MS24693-C54MS24693-C56MS24693-C58MS24693-C60MS24693-C62MS24693-C268MS24693-C270MS24693-C272MS24693-C273MS24693-C274MS24693-C275MS24693-C276MS24693-C278MS24693-C280MS24693-C282MS24693-C284
Length1/25/83/47/8
11 1/41 1/21 3/4
21/43/81/25/83/47/8
11 1/41 1/21 3/4
2
Thread Size8-328-328-328-328-328-328-328-328-32
10-3210-3210-3210-3210-3210-3210-3210-3210-3210-3210-32
Flat Countersunk 100” Head, Cross Recessed, Carbon Steel, (StainlessSteel)(MS24693)
Pan Head, Cross Recessed, Carbon Steel, Cadmium Plated, (MS35206&MS35207)
MS NumberMS35206-213MS35206-215MS35206-217MS35206-218MS35206-219MS35206-220MS35206-221MS35206-222MS35206-223MS35206-226MS35206-228MS35206-230MS35206-231MS35206-232MS35206-233MS35206-234MS35206-235MS35206-236MS35206-237MS35206-238MS35206-241
Length1/43/81/25/83/47/8
11 1/41 1/21/43/81/25/83/47/8
11 1/41 1/21 3/4
21/4
Thread Size4-404-404-404-404-404-404-404-404-406-326-326-326-326-326-326-326-326-326-326-328-32
MS NumberMS35206-243MS35206-245MS35206-246MS35206-247MS35206-248MS35206-249MS35206-250MS35206-251MS35206-252MS35206-253MS35207-261MS35207-263MS35207-264MS35207-265MS35207-266MS35207-267MS35207-268MS35207-269MS35207-270MS35207-271
Length3/81/25/83/47/8
11 1/41 1/21 3/4
23/81/25/83/47/8
11 1/41 1/21 3/4
2
Thread Size8-328-328-328-328-328-328-328-328-328-32
10-3210-3210-3210-3210-3210-3210-3210-3210-3210-32
Pan Head, Cross Pan Head, Black Brass, (MS35214)
MS NumberMS35214-27MS35214-31MS35214-33
Length1/2
11 1/2
Thread Size6-326-326-32
MS NumberMS35214-42MS35214-46MS35214-48
Length1/2
11 1/2
Thread Size8-328-328-32
SCREWS
��
� Installatio
n Su
pp
lies
Certi-Lok Crimping ToolAMPCerti-Lokcrimpingtoolwithinterchangeablediesets.Thisisabasictoolthatusesinterchangeablesnap-indiesets,whichcanbeeasilyinsertedorremoved.DiesetP/N169404crimpsAMPred/blue/yellowinsulatedterminalsandsplices(22-10AWG).
169400 AMPCerti-LokCrimpTool169404 DieSet(Insulated22-10AWG)169409 Dieset(uninsulated22-10AWG)169414 DieSet(22-12gaugeforpins&sockets)
Positioners & Dies Sold Separately
AF8hasvirtuallylimitlessappli-cationwithinthespecifiedwirerangeof12through26AWG.Theprecisionratchetcontrolscyclingofthetoolinbothdirectionsofhandlemovement.Thisassuresthesameaccuratecrimpeverytime.It’slikehavingaqualitycontrolinspectorateveryworkstation.Positivecrimpdepthiscontrolledbyan8positionselectorknobconvenientlylocatedonthetoolframe.TheAF8measures93/4”x21/2”approximatelyandweighs15oz.
Upper Range Crimp Tool AF8P/N M22520/1-01
QualifiedtoMIL-DTL-22520/2,theDMCAFM8isdesignedformostoftheminiatureandsub-miniatureconnectortypesthataresowidelyusedinalltypesofelectronicsystems.Wiresizes20through32AWG.Crimpdepthisdialedonthe8stepselectorknobbymerelyraisingtheknobandrotatingittotheproperposition.TheAFM8is53/4”inlengthandweighsapproximately10oz.
Lower Range Crimp Tool AFM8P/N M22520/2-01
Positioners & Dies Sold Separately
Dies Sold Separately
P/N M22520/5-01 (HX4)P/N M22520/1 0-01 (HX3)TheDMCHX4andHX3seriescrimptoolsfeatureasystemofinterchangeabledieswhicheliminatetheneedofseparatefixeddiecrimptoolsforeachandeverydifferentapplication.TheHX4is11”inlengthandweighsapprox.21oz.TheHX3is9”inlengthandweighsapprox.11oz.
HX� & HX� Series Crimpers
TheDanielsBatteryPoweredCrimperisalongawaitedanswertotheneedforaneconomical,self-containedportablecrimperwitheaseofoperation,andenoughpowertomakerepeatablecrimpsonawiderangeofapplications. TheHDE37fillsthatneed,andoffersasolutionwherethevolumeofworkexceedsthephysicallimitsofaworkerwithhandtools,andhosesandcablesareunwelcomeorunsafefortheenvironmentwheretheworkisbeingperformed.
Auto-CtimperP/N HDE37
Stripmaster Series
45-092 Stripmaster(8-30 AWG)45-671 StripmasterLite(Economy Size, 12-30 AWG)45-174 StripmasterCustom(6-26 AWG)L-5616 ReplacementFrameOnlyL-5617 ReplacementFrameOnlyL-5562 10-14AWGReplacementBladeDieSetL-5563 16-26AWGReplacementBladeDieSetL-5564 26-30AWGReplacementBladeDieSet
AvailableinStandard,Lite(3/4economysize),andCustomconfigurations,theStripmasterseriesbyIdealIndustriesfeaturesadiecastframewithknife-typebladesforonestep,spring-aidedstrippingaction.TheStripmastCustombuildsonthisalreadyimpressiveproductbyaddingPrecisioncounter-boredie-typeblades(meetsMil-Spec)andashortstoplatchwhichprotectswirestrandsbylimitingthestrippingstroketo5/32”andretainingthesluguntilthewireisreadyfortermination.
TheIdeal28-510isapremiercrimptoolfor24-14AWGopenbarrelcontactcom-mercialtypepinsandsockets.The28-512isalsoapremiercrimptoolfor30-18AWGopenbarrelD-subRS232pinsandsockets.
28-510 OpenBarrelCrimpTool,24-14AWG28-512 OpenBarrelCrimpTool,30-18AWG
Open Barrel Crimp Tool
Solid Barrel Crimp Tool35-465 SolidBarrelCrimpTool,20-26AWG35-466 SolidBarrelCrimpTool,16-22AWG
Industrial CrimpTheIdeal50-2001industrialcrimptoolisfor22-10AWGinsulatedringtongueter-minalsandsplices.Makesanovalizedbarrelcrimpandsupportinonestep.ItcanbeusedonterminalsbyAMP,T&B,3M,Panduitandmore.Thediesinthistoolarecolorcodedtogaugespecifications.
51-0018 Industrialdiesetfor16-26AWGminiature insulatedringsandsplices30-500 22-10AWGTerminalCrimpTool30-572 DieSet26-16AWG,ForTool30-500
T-Stripper Wire Stripper•Precisionform-groundknifeblade•Custom-cushionedgrip•Paintedwiregaugemarkings
16-26AWG P/N45-121
CRIMPERS AND WIRE STRIPPERS
��
� In
stal
lati
on
Su
pp
lies
Crimpmaster Crimp Tool Replacement Die Sets
�8
� Installatio
n Su
pp
lies
KROY K��00 P/N:2561000Kroy’sintroductesit’snewestaddition,theK5100HandheldLabelandWire-MarkingPrinter.ThisprintersurpassesstheK2500,withsuchfeaturesasprintresolutionof300dpi,autosizing,increasedprintspeeds,internalbatterycharger,downloadablefontsandincreasedon-boardmemory.Additionally,theK5100usestheeasytoloadKroyCartridgeSystemallowingyoutochangeyourmediainseconds.IncludesACAdapter.
Size:11.0”Lx6.0”Wx4.0”H
Kroy’sNewK4100DesktopIndustrialPrintersurpassesotherdesktopprinterswithit’sbuilt-inflexibilityandversatility.TheK4100featuresaprintresolutionof300dpi,autosizing,fastprintspeeds,scalablefonts,downloadablefontsandon-boardmemorytostorefilesandfonts.Additionally,theK4100usestheeasytoloadKroyCartridgeSystemallowingyoutochangeyourmediainseconds.IncludesACAdapter.
KROY K��00 P/N:2562000
Size:9.5”Lx8.0”Wx2.75”H
ColorBlackonBlue
BlackonClear
BlackonGold
BlackonGreen
BlackonOrange
BlackonRed
BlackonSilver
BlackonWhite
BlackonYellow
Size1”Tape
1/2”Tape
8/10”Tape1”Tape
1/2”Tape1”Tape
1/2”Tape1”Tape
1”Tape
1/2”Tape
1”Tape
1/2”Tape1”Tape
1/2”Tape
8/10”Tape1”Tape
1/2”Tape
8/10”Tape1”Tape
P/N2438635
22275012464401248790124387012438601
22275262438626
22275392438639
2438648
222753524644352438631
2275212438621
22275162464416248791624387162438616
22275432464443248794324387432438643
ColorBlueonClear
BlueonWhite
GreenonWhite
RedonClear
RedonWhite
WhiteonBlack
WhiteonBlue
WhiteonClear
WhiteonGreen
WhiteonOrange
WhiteonRed
Size1/2”Tape
1/2”Tape1”Tape
1/2”Tape1”Tape
1/2”Tape
1/2”Tape1”Tape
1/2”Tape
1”Tape
1/2”Tape1”Tape
1/2”Tape1”Tape
1/2”Tape1”Tape
1/2”Tape
1/2”Tape1”Tape
P/N2227503
22275172438617
22275192438619
2227520
22275182438618
222752024879202438620
22275322438632
22275022438602
22275402438640
2227549
22275362438636
KROY Tapes
LABEL MAKERS
�9
� In
stal
lati
on
Su
pp
lies
TheK-Sun2011XLBand2011XLB-PCfeaturesasimplebutpowerfulnewfeaturecalled“PeelGuard”.Thisisabuilt-intapetrimmerthatroundslabelcornersforamoreprofessionalappearanceandtoprovidepeelingprotectionformorepermanentindustriallabels.
Whenyouconnectthe2011XLB-PCtoalaptoporPC,theuserfriendlyMaxiLabelProSoftwarecreatesapleasantlabelingexperience.Youcanuseyourcomputertoquicklyimportlogos,graphics,symbolsandmoreintoyourlabeldesigns.The2011XLB-PCcanthenbedisconnectedfromyourPCandtakenouttothejobsite.Ithasitsownkeyboard,display,memoryandaconvenientbuilt-inhandletomakeportabilityeasier.
RunsonstandardAAbatteriesoranoptional110vACadapter.
K-Sun �0��XLB and �0��XLB-PCInadditiontomakinggeneralpurposelabels,the2012XLSTusesKSunindustrialLABELShopheatshrinktubeandwirewrapstomakewireandcablelabels.
The2012XLSTalsoincludesK-Sun’snewlabeltapeedgetrimmercalledPeelGuard.Thistapetrimmer,builtintothelabeler,roundsofflabelcorners.Thisprovidesamoreprofessionallookinglabelandithelpstopreventpeeling--givingyoumorepermanent,long-lastingindustriallabels.
Whereveryougo,there’snoneedtoworryaboutpower.ThislabelerrunsonstandardAAbatteriesoranoptional110vACadapter.SinceitusesAAbatteriesyoudon’tneedtopaythehighcostofspecializedbatteries,andifyou’reinthefieldandneedmorebatteries,youcangetthematanynearbyconveniencestore.
K-Sun �0��XLST and �0��XLST-PC
K-Sun CartridgesTubing
ColorBlackonWhite
BlackonYellow
BlackonRed
WhiteonBlack
Size1/8”1/6”3/16”1/4”3/8”1/2”
1/8”3/16”1/4”1/2”
3/16”1/2”
1/4”
P/N203STBW204BW205STBW208STBW210STBW211STBW
203STBY205STBY208STBY211STBY
205STBR211STBR
206WB
ColorWhiteonBlack
BlackonWhite
BlueonWhite
RedonWhite
BlackonRed
BlackonYellow
Size1”3/8”x26’
1”x26’
3/4”x26’1/4”x3/4”
3/4”x26’
1”x26’
1”x26’
1”x26’
P/N224WB609WB612WB624WB
218BW224SL
305LW
624RW
624BR
624BY
Tape
WE ALSO STOCK CAARTRIDGES FOR BROTHER LABLERS - CALL WITH YOUR CARTRIDGE PART NUMBER
�0
� Installatio
n Su
pp
lies
Providescoolingairforonetofiveavionicsunits.Supplyingupto25ft3ofairperminuteat28Vdc,theACF528caneasilycoolanentirestackofavionics.Unusedportscanbecappedtoprovideadditionalcoolingairthroughactiveports.Usesabrushlessblowermotorthatisratedfor78,000hoursofcontinuousoperation.ProducedbyAmericancraftsmenandwarrantedforthreeyears.
CRB-���� (��-��V) & CRB-������ (��-�8V)
TheCyclone-21isacompact(3X3X1in.)aircraftelectron-icscoolingfanthatdelivers21-cubicfeetperminuteofforcedaircoolingtoavarietyofavionicsequipment.
Features•3UniversalOutletPorts•UniversalMountingBracket•12&24VDCUltraQuietMotor•EasyInstallationevenin confinedareas•MeetsElec.Manufacturers ForcedAirCoolingRequirements•LowAudible&EMINoise•HighReliabilityBallBearings•ElectronicProtection•MadeinU.S.A.
Three Port Cooling Fan
Specifications•Size:3.14X3.14X1.26in.•Weight:12oz.•HousingMeetsUL94V-0forFlammabilityRating•HighReliabilityBallBearings•ElectronicProtection•12VDC.42A& 24VFC.19A(Nominal)•80,000HoursContinuousDuty
LONESTAR
LS0�-0�0�� (��-��V) & LS0�-0�0�� (��-�8V)
TheCyclone600isalightweight,highlyreliablebrushlessDCavionicsblow-erthatdelivers45CFMofforcedairtoonboardaircraftelectronics.Theuniversalmountingsystemmountsvertically,horizontally,orat45degreesforaneasyinstallationforallaircraftmakeandmodels.Features•NewDCBrushlessMotor withFAA/PMAApproval•HighPerformance626ZZ BearingforExtendedLife•HighImpactPhenolicHousing•LaserBalancedImpellerwheel•UniversalFront(4,5,6,Ports)•CableHarness(36”),included.•OverCurrentProtected•LockedRotorProtected
Six Port Cooling Fan
•ReversePolarityProtected•FAA/PMAApproved•DO160DTested•LowNoise
Specifications•Size:4.5X3.0X6.25in.•12-14VDC 600MA•24-48VDC 500MA•Weight:13.6OZ
COOLING FANS
SANDIA
ACF��� and ACF��8
Operatingon14and28Vdcrespectively,theACF314andACF328cansupply25ft3perminute,helpingyouravionicsremainataproperoperatingtemperature.TheSANDIAaerospace’sthreeportfansusehighqualitybrushlessblowermotorsthatareratedfor78,000hoursofcontinuousoperation.Passedstringentenvironmentalteststoensurethattheywillprovideyearsofreliableservice.
•Replaces25CubicFeetofAirPerMinute•CoolsUpto3AvionicsUnits•Availablein14Vdcor28VdcVersion•RatedFor78,000HoursofContinuousOperation•FAA-PMAApproved•ThreeYearWarranty
ACF314 ACF328OperatingVoltage 14Vdc 28VdcCurrentDraw 960rnA 480rnA (1.7Astartup) (.85Astartup)Size: 5.18”x5.18”x2.1” 5.18”x5.18”x2.1”Weight: 1.18Ibs 1.18IbsCertification FAA-PMA FAA-PMA
Three Port FansACF��8
•Replaces25CubicFeetofAirPerMinute•CoolsUpto5AvionicsUnits•Availablein14Vdcor28VdcVersion•RatedFor78,000HoursofContinuousOperation•FAA-PMAApproved•ThreeYearWarranty
SpecificationsOperatingVoltage 28VdcCurrentDraw 480mA(850rnAstartup)size: 5.13”x6.77”x2.1”Weight: 1.18Ibs.Certification FAA-PMA,DO160c
Five Port Cooling Fan
��
� In
stal
lati
on
Su
pp
lies
Cooling Hose
Features•FAA/PMAApproved•SmoothInteriorDesign•FlameRetardant•ResistanttoInteriorCrushing•Material-Polethylene•Temp-30to160Farenheit•UL94V-0-SelftExtinguishingMaterial•Size.625ISD5/8in.•InteriorDesignforMaximumAirFlow•MoistureandWeatheringResistant
Flexible air duct tubing is perfect for low pressurehandlingofhotorcoldair insystemsrequiringmini-mumweight,andwhereairflowandfrictionrequire-mentsarenotsevere.RecommendedforusewithalltheSandia&Ameri-Kingfans.Soldin5’lengths.Specifications: TemperatureRange:-65degreesFto+300degreesResistantTo:Oils,solvents,ozoneandfungus.Diameter:5/8”Length:5’
P/N 5700-1
AK-9�0F-x
TheAmeri-KingAK-950FisanFAAPMA’dapprovedGPS/AvionicsFan,CompactSized,Deliversupto26.6CFMCubicFeetPerMinuteofForcedAirCoolingtoaVarietyofAvionicsEquipment.TheAK-950FFanmaybeMountedUsingHolesProvidedintheUnitBase.ItsInstallationLocationmaybebehindorbeneathaircraftinstrumentpaneloravionicsequipmentrackorcabinpressurebulkhead.• TheFreezingAirBlower• FAA-PMAapproved.• AircraftEligibilityincludesParts23,25,27&29.• Meetsandexceedsallavionicsmanufacturer’s specificationsforforcedaircoolingrequirements.• Powerreversepolarityprotectionincluded• Compactsize• Choiceof1,2,3,5,or10outports• Universalremotemounting• Hoses,connectorkit,allaccess.hardwaresareincl.• Fouryearsextendedwarranty.• PatentPending.MadeinU.S.A.
FAA-PMA APPROVED:• AircraftEligibility: AllParts23,25,27&29Aircraft
PHYSICAL CHARACTERISTICS:• SIZE(3-5)PortsFan: 1.38”Wx5.75”Lx4.85”H• MOUNTING: UniversalRemoteMounting
GENERAL SPECIFICATIONS (STANDARD CONDITIONS):• POWER: (7.2--9.6)WNominal @(10.0-32.2)Vdc• POWERREVERSEPOLARITYPROTECTION:Included• AIRFLOW: 26.6CFM• STATICPRESSURE: 15mmH2O• NOISELEVEL: UltraQuiet• BEARING: BallType,LongLasting• DESIGNLIFE: 80,000hours• OUTLETPORTS: 1/2/3/4/5/10Ports,5/8”Diameter.
-5 -3 -2 -1(mustspecifyvoltage)
AMERI-KING CORP.
P/N LS03-04000
SANDIA
LONESTAR
��
� Installatio
n Su
pp
lies
HEAT GUNS
STEINEL AMERICA
HG ���0 LCDProgrammable IntelliTemp™ Heat Gun with LCD DisplayProgrammableheatgunwithLOCLockableOverrideControl™oftemperatureandairflowoutputsettings.LCDdisplayenablestemperatureselectionin10°Fincrements.Temperature Continuouslyvariable120-1200°FAirflow 3.6-17.6CFMSwitch 1)CoolAirStage(120°F/3.6CFM) 2)VariableTemp&AirflowPrograms Fourcustomizablepre-settemperature/airflowprogramsOutput 1600wattsVoltage 120VAC/60HzWeight 33ozWarranty FullOneYearItem Number 34870
HG ���0 ESDESD Safe Programmable IntelliTemp™ Heat GunESDsafeprogrammableheatgunwithLOCLockableOverrideControl™oftemperatureandairflowoutputsettings.LCDdisplayenablestemperatureselectionin10°Fincrements.Temperature Continuouslyvariable120-1200°FAirflow 3.6-17.6CFMSwitch 1)CoolAirStage(120°F/3.6CFM) 2)VariableTemp&AirflowPrograms Fourcustomizablepre-settemperature/airflowprogramsOutput 1600wattsVoltage 120VAC/60HzWeight 33ozWarranty FullOneYearItem Number 34890
HL �0�0 EIntelliTemp™ Heat Gun with LCD Temperature DisplayMicroprocessorcontrolledheatgunwithLCDdisplayenablingtemperatureselectionin10°Fincrements.STEINEL’sexclusiveDuraTherm™heatingelementensureslonglifeandevenheat.Temperature Continuouslyvariable120-1200°FAirflow 3.6/10.6/17.6CFMSwitch 1)CoolAir(120°F/3.6CFM) 2)VarTemp/10.6CFM 3)VarTemp/17.6CFMOutput 1500watts Voltage 120VAC/60HzWeight 30ozWarranty FullOneYear Item Number 34850
Electronic
Kits Available in industry specific kit presentations.
��
� In
stal
lati
on
Su
pp
lies
STEINEL AMERICA
HL �9�0 EVariable Temperature Electronic Heat GunPowerfulheatgunwithvariabletemperatureandelectronicthermocouplecontrolforflexibleuseandmaximumreliability.STEINEL’sexclusiveDuraTherm™heatingelementensureslonglifeandevenheat.Temperature Continuouslyvariable120-1200°FAirflow 3.6/10.6/17.6CFM Switch 1)120°F/3.6CFM 2)VarTemp/10.6CFM 3)VarTemp/17.6CFM Output 1500watts Voltage 120VAC/60HzWeight 30ozWarranty FullOneYear Item Number 34830
Kits Available in industry specific kit presentations.
HL �8�0 SThree-Stage Professional Heat GunMulti-purposeheatgunwithcoolairstageandchoiceof2temperaturesettingsforconvenienthand-heldorbenchwork.STEINEL’sexclusiveDuraTherm™heatingelementensureslonglifeandevenheat.Temperature 120/750/1100°FAirflow 3.6/10.0/15.9CFMSwitch 1)120°F/3.6CFM 2)750°F/10.0CFM 3)1100°F/15.9CFMOutput 1400watts Element DuraTherm™Ceramic Use Hand-Held,Hands-FreeStableBaseVoltage 120voltsAC/60hzWeight 28ozWarranty FullOneYearItem Number 34820
HL ���0 STwo-Stage Professional Heat GunGeneralpurposeheatgunwithtwotemperaturesettingsisdesignedforsafe,convenientprofessionalandindustrialuse.Lightweight,ergonomicdesignensurescomfortablelong-termoperation.Temperature 575/1000°FAirflow 8.5/14.8CFM Switch 1)575°F/8.5CFM 2)1000°F/14.8CFM Output 1300watts Element ReinforcedCeramic/Mica Use Hand-Held,Hands-FreeStableBaseVoltage 120VAC/60Hz Weight 25ozWarranty FullOneYear Item Number 34810
Professional
NOTE ON PROFESSIONAL HEAT GUNSAirflow must not be restricted. Do not use reduction nozzles intended for use with electronic heat guns only.
��
� Installatio
n Su
pp
lies
IndustrailHG �000 E
STEINELHG5000Eprovidestheultimateinprecisiontechnology.ExclusiveIntelliTemp™controlenablestheusertoselectatargettemperaturetowithin+/-5°FandtoviewactualoutputontheLEDdisplay.HeatingelementsfortheHG5000EareeasilychangeableinthefieldandintegrateSmartChip™technologyallowingtheheatguntoautomaticallyrecalibratetothenewelement.DC Brushless Motor: Guaranteedforthelifeofthetool. Heating Element: Built-inSmartChipholdsspecificdata.500-800hours expectedelementlifespan.Convenientlyfield changeable.Onboard Microprocessor: ReceivesandinterpretsdatafromtheSmartChipto automaticallycalibrateandregulatetheheatingelement.Variable Airflow: Upto28cfm(800liters),3000PaAirPressure Variable Temperature: Selectablefrom80°F-1100°F LED Temperature Display: Indicatesactualandtargettemperatures in10Fincrements.Power Cord: Doubleinsulated,Rubberconstructionforincreased safety.Fieldchangeablewithoutopeninghousing. Outlet Tube: 50mm(approximately2inches) Output: 3,400wattsVoltage: 230VAC/50Hz Certifications: CElisted Full One Year Warranty: FullOneYearWarranty,LifetimeMotorWarranty Item Number: 35025Accessories Acceptsaspeciallydesignedrangeofnozzles andaccessories.
Heavy Duty Heat Gun with microprocessor control and high performance air output (230V).
HG �000 E
STEINELHG4000Eprovidestheultimateinprecisiontechnology.ExclusiveIntelliTemp™controlenablestheusertoselectatargettemperaturetowithin+/-5°FandtoviewactualoutputontheLEDdisplay.HeatingelementsforHG4000EareeasilychangeableinthefieldandintegrateSmartChip™technologyallowingtheheatguntoautomaticallyrecalibratetothenewelement.DC Brushless Motor: Guaranteedforthelifeofthetool.Heating Element: Built-inSmartChipholdsspecificdata. 500-800hoursexpectedelementlifespan. Convenientlyfieldchangeable. Onboard Microprocessor: ReceivesandinterpretsdatafromtheSmartChipto automaticallycalibrateandregulatetheheatingelement.Variable Airflow: Upto21cfm,3000PaAirPressure. Variable Temperature: Selectablefrom80°Fto1100°F.LED Temperature Display: Indicatesactualandtargettemperatures in10Fincrements. Power Cord: Doubleinsulatedrubberconstructionforincreasedsafety. Fieldchangeablewithoutopeninghousing.Outlet Tube: 40mm(approximately11/2inches)Output: 1,750watts.Voltage: 120VAC/60HzCertifications: UL/C-ULlistedFull One Year Warranty: FullOneYearWarranty,LifetimeMotorWarrantyItem Number: 35021Accessories Acceptsaspeciallydesignedrangeofnozzles andaccessories.
Heavy Duty Heat Gun with microprocessor control (120V).
HEAT GUNS
STEINEL AMERICA
��
� In
stal
lati
on
Su
pp
lies
HG ��00 EM
STEINEL’sHG2300EMcombinespowerfuloutputwithanergonomic,easytousedesign.Variabletemperatureandairflowcontrolensuretheperfectjobeverytime.TheHG2300EMfeaturesultraquietoperation,fastheat-up,andrequiresnocool-down.Itsmodularconstructioniseasytorepair,withheatingelementandpowercordbothconvenientlyfield-changeable.Temperature: 80°F–1300°FVariable Airflow: Upto15.4cfm Air pressure: 2940PaPower Cord: Rubberconstructionforincreasedsafety.Field changeablewithoutopeninghousing. Output: 1,750wattsVoltage: 120VAC/60HzNozzle Diameter: 40mm(sameasHG4000E)Certifications: UL/C-ULWarranty: FullOneYear,LifetimeMotorWarrantyItem Number: 35011Accessories: Acceptsaspeciallydesignedrangeofnozzles andaccessories.
Kits Available in industry specific kit presentations.
Ergonomic Heat Gun with Electronic Thermocouple Control.
STEINEL AMERICA
��
� Installatio
n Su
pp
lies
Spreadshotairoverawiderareafordrying,shapingplastic,heatinglargesurfaces,etc.
50mm Surface Nozzle Part # 0701175mm Surface Nozzle Part # 07021
Wide-Jet Nozzles
Protectsadjoiningsurfacesfromoverheating,suchaspanesofglassandcorners.
50mm Window Nozzle Part # 0703175mm Window Nozzle Part # 07041
Deflector Nozzles
Directshotairaroundpipesandtubingforevenheating.Usedforshrinktubing,solderingsinkwireconnectorsandbending.
39mm Reflector Nozzle Part # 07051
75mm Reflector Nozzle Part # 07301
Reflector Nozzles
9mm Reflector Nozzle Part # 07061
14mm Reflector Nozzle Part # 07461
Providesapreciselyconcentratedstreamofhotair.Usedforweldingorsoldering.Canbeusedasabaseforspecializedattachments.9mm Reduction Nozzle Part # 07062 (Also used as a base for attachments)
Reduction Nozzles
14mm Reduction Nozzle Part # 07071 (Also used as a base for attachments)
20mm Reduction Nozzle Part # 07081
Usedforweldingsingleplyroofingmaterialsandplasticsheets.
40mm Andle Slit Nozzle Part # 07511
Angle Slit Nozzle
Wire Protection TubePreventsaccidentalcontactwithhotnozzles
GH 2510 ESD, HG 2310 LCD HL 2010 E, HL 1910 E, and HL 1810 E Part # 07403HG 3002 LCD, HL 2002 LED, HL 1802 E, and HL 1502 S Part # 07401
FOR USE WITH ELECTRONIC HEAT GUNS ONLY
STEINEL AMERICA
HEAT GUN ACCESSORIES
��
� In
stal
lati
on
Su
pp
lies
Plastic Welding Nozzle with 6mm Intake Part # 07091
9mm Reduction Nozzle Attachments
20mm Lap Welding Slit Tip Part # 07101 20mm Rod Welding Slit Tip Part # 07201
75mm Teflon Coated Heat Disk used to butt weld PVC pipe Part # 07211
��mm Reduction Nozzle Attachments
40mm Slit Nozzle for lap welding PVC sheeting and roofing material Part # 07471
DesignedspecificallytofitHG5000Eonly.
Angle Flathead Slit Nozzle 74mm x 3mm For lap welding Part # 092818
HG �000 E Accessories
FLat Nozzle 70mm x 10 mm For concentrating airflow Part # 092719
DesignedspecificallytofitHG4000EandHG2300EMonly.
40mm x 3mm Angle Flathead Slit Nozzle For seam sealing and lap welding Part # 09201
HG �000 E/HG ��00 EM Accessories
20mm x 2mm Angle Flathead Slit Nozzle For seam sealing and lap welding Part # 09211
FOR USE WITH ELECTRONIC HEAT GUNS ONLY
5mm Reduction Nozzle - Produces a precise pinpoint hot air stream for welding and soldering Part # 09221
10mm Reduction Nozzle - Produces a pinpoint hot air flow for welding and soldering applications Part # 09231
10 mm 90 Degree Nozzle - For corners and hard to reach areas Part # 09241
Welding Tip (Fits on 10mm Reducer) For welding plastic rods and coils. Use with 5mm Reduction Nozzle #09221 Part # 07531
High Speed Welding Tip (Fits on 5mm Reducer) For welding plastic rods and coils. Use with 5mm Reduction Nozzle #09221 Part # 09183
STEINEL AMERICA