BJP1-BALL JOINT PRESS MASTER SET · bjp1-ball joint press master set item no. part no. description...

ZBJP1B rev B 06/11/2014 1

BJP1-BALL JOINT PRESS MASTER SET

Item

No.

Part

No.

Description

1 BJP1-1A SLEEVE ADAPTER

2 BJP1-2 PRESSURE SCREW

3 BJP1-3A LARGE FACED (BALL JOINT)

PRESSURE PAD

4 BJP1-4A SMALL FACED (UNIVERSAL

JOINT) PRESSURE PAD

5 BJP1-5A ADAPTER

6 BJP1-6A ADAPTER/EXTENSION

7 BJP1-7A ADAPTER

8 BJP1-8A ADAPTER

9 BJP1-9A ADAPTER: ANGLE

10 BJP1-10A ADAPTER: ANGLE

11 BJP1-11A ADAPTER

12 BJP1-12A ADAPTER

13 BJP1-13B ADAPTER

14 BJP1-14A ADAPTER

15 BJP1-16A ADAPTER

16 BJP1F PRESS FRAME

17 BJP1-17 GREASE FITTING

18 ME9A34 STEEL BALL

19 ME7A207 RETAINING RING

20 ME7A208A LARGE SNAP RING

(11 RINGS REQ’D.)

21 ME7A209A SMALL SNAP RING

22 PAKPB061 CARRYING/STORAGE CASE

(Some component assembly required. See component assembly sections.)

Visit the Snap-on web site, www.snapon.com, for vehicle application

information and complete listing of available adapters.

19

BJP1-BALL JOINT

PRESS MASTER SET

20 21

18 17

22

16

ZBJP1B rev B 06/11/2014 2

SAFETY INFORMATION IMPORTANT SAFETY INSTRUCTIONS This manual contains important safety and operating instructions for

the Snap-on® Ball Joint Press Master set. Refer to the information in

this manual as required for safe operation.

READ ALL INSTRUCTIONS

Read all the instructions in this manual. Read, understand and follow

all safety messages and instructions in this manual, and on all ball

joint press part components. Safety messages in this section contain

a signal word, a three-part message, and in some cases, an icon.

Safety symbols, when present, give a graphical description of the

potential hazard or how to avoid potential hazard.

WARNING

Wear safety goggles, user and bystander.

Be sure all adapter-to-adapter connections are secure.

Avoid misalignment of ball joint press assembly when

tightening pressure screw on ball joint and control arm.

If misalignment occurs, STOP tightening screw.

Unthread screw until assembly is loose. Properly realign

press assembly on ball joint and control arm.

WARNING

Refer to manufacture’s service manual for properly supporting and

raising of vehicles in a safe and secure manner.

ZBJP1B rev B 06/11/2014 3

Ball Joint Press Component Assembly Insert steel ball (ME9A34) into opening of pressure screw (BJP1-2) as shown in FIG.

Secure steel ball inside screw by inserting small snap ring (ME7A209A) into internal

snap ring groove of screw as follows:

1. Place snap ring partially into groove while compressing ring so that the ends

overlap as shown in FIG. 1.

2. Press ring into screw opening until ring snaps securely into groove.

WARNING

Insert large snap ring (ME7A208A) into internal snap ring groove of each of the (11)

adapters in the parts list on page one (adapters BJP1-5A through BJP1-16A) as

follows:

1. Place snap ring partially into groove while compressing ring so that the ends

overlap as shown in FIG. 2.

2. Press ring into adapter opening until the ring snaps securely into groove.

WARNING

FIGURE - 1

FIGURE - 2

ME7A209A

ME9A34

BJP1-2

ME7A208A

BJP1-14A

ZBJP1B rev B 06/11/2014 4

Ball Joint Press Component Assembly

Slide sleeve adapter (BJP1-1A) into hole of press frame (BJP1F) and secure with

retaining ring (ME7A207) as shown in FIG. 3. Use snap ring pliers with proper tip

size. Thread grease fitting (BJP1-17) into tapped hole of press frame as shown using

5/16” socket.

WARNING

Maintenance

The pressure screw threads need to be wiped clean and re-lubricated with chassis

grease on a regular basis. Use grease fitting (installed on screw side arm of frame)

to apply grease to the screw threads.

BJP1 - Operating Information The BJP1 ball joint master set is designed to be used without removing the control

arm from the vehicle on most cars and trucks that have press-fit type ball joints.

NOTE: Some vehicles have the upper ball joint spot-welded to the control

arm. The weld must be cut before attempting to remove the ball joint.

BJP1F

ME7A207

BJP1-1A

BJP1-17

FIGURE - 3

ZBJP1B rev B 06/11/2014

5

Operating Instructions Ball Joint Removal (Refer to the safety information section for required safety instructions.)

1. Refer to the proper automotive service manual used for repair procedures on the specific vehicle

being serviced. Follow indicated procedures for removing all suspension components to obtain

clear access to the vehicle’s ball joint and control arm.

2. Refer to application chart to select the proper adapters for removing most types of ball joints on

most vehicle makes and models.

3. Thread pressure screw (BJP1-2) into end of frame. Insert ball joint pressure pad (BJP1-3A) into

pressure screw. (Force pressure pad completely down into pressure screw.)

4. Snap the selected adapters onto adapter sleeve (BJP1-1A) and ball joint pressure pad as shown in

FIG. 4.

5. Position press assembly over ball joint and control arm, as shown in FIG. 4.

6. Tighten pressure screw until removal adapters are snug against ball joint and control arm. Check

that the entire assembly is properly aligned. If not, STOP tightening screw, then loosen assembly

and re-align.

7. Apply torque to pressure screw until ball joint has been pressed out of control arm and into

receiving adapter.

CONTROL

ARM

BJP1F

BJP1-2

ADAPTER

ADAPTER

BJP1-3A

BALL JOINT

FIGURE - 4

BJP1-1A

WARNING

ZBJP1B rev B 06/11/2014

6

Operating Instructions

Ball Joint Installation (Refer to the safety information section for required safety instructions.)

1. Clean knuckle and control arm. Coat bore of control arm with a suitable lubricant.

2. Insert replacement ball joint into control arm bore as straight as possible and align properly in

bore.

3. Refer to application chart to select the proper adapters for replacing most types of ball joints on

most vehicle makes and models.

4. Snap selected adapters into place in the same manner as in the ball joint removal procedure. Use

adapter BJP1-6A between pressure pad (BJP1-3A) and adapter if additional length is needed, as

shown in FIG. 5.

5. Position press assembly over ball joint and control arm, as shown in FIG. 5.

6. Tighten pressure screw until installation adapters are snug against ball joint and control arm.

Check that the entire assembly is properly aligned. If not, STOP tightening screw, then loosen

assembly and re-align.

7. Apply torque to pressure screw until the ball joint flange is securely seated against face of control

arm bore.

ADAPTER

PRESS ASSEMBLY

BALL JOINT

ADAPTER

CONTROL ARM

FIGURE - 5

BJP1-6A Extension (Some Applications)

WARNING

ZBJP1B rev B 06/11/2014

7

UJP1 - Operating Instructions The UJP1 universal joint set is designed to replace U-joints, either on or off the vehicle, on most cars and

trucks.

Universal Joint Removal

(Refer to the safety information section for required safety instructions.)

1. If necessary, remove ball joint pressure pad from pressure screw. Then insert universal joint

pressure pad (BJP1-4A) into pressure screw. (Force pressure pad completely down into pressure

screw.)

2. Securely support the drive shaft yoke assembly. Remove all external and/or internal locking rings.

3. If necessary, select one or a combination of adapters (BJP1-1A, BJP1-7A, BJP1-8A) to assist in U-

joint replacement.

4. Position press assembly around drive shaft yoke and align pressure pad with face of needle bearing

caps, as shown in FIG. 6 and FIG. 7.

5. Tighten pressure screw until one side of U-joint has been pressed completely out of yoke assembly.

6. Reposition press assembly, in the same manner as step-4, and tighten screw to remove the

remaining U-joint.

WARNING

FIGURE - 6

DRIVE SHAFT ASSEMBLY

PRESS ASSEMBLY

U - JOINT

BJP1-4A

U-JOINT PRESSURE

PAD

ZBJP1B rev B 06/11/2014

8

UJP1 - Operating Instructions Universal Joint Installation

(Refer to the safety information section for required safety instructions.)

1. Securely support the drive shaft yoke assembly.

2. If necessary, select one or a combination of adapters (BJP1-1A, BJP1-7A, BJP1-8A) to assist in

replacing the new U-joint.

3. Carefully follow the manufacture’s instructions for lubrication of the new U-joint.

4. Position press assembly around drive shaft yoke and align pressure pad with face of needle

bearing caps, as shown in FIG. 7.

5. Tighten pressure screw until one side of U-joint has been completely pressed into assembly.

6. DO NOT OVER TIGHTEN. Damage to U-joint and reduced service life may occur.

7. Reposition press assembly, in the same manner as step-4, and tighten screw until the other

side of the U-joint has been completely pressed into yoke assembly.

WARNING

Snap-on is a trademark of Snap-on Incorporated

©2004 Snap-on Incorporated. All Rights Reserved. Kenosha, WI 53143 Printed in U.S.A.

FIGURE – 7

PRESS ASSEMBLY

DRIVE SHAFT

U - JOINT

U-JOINT NEEDLE BEARING CAPS

BJP1-4A

U-JOINT PRESSURE PAD

VEHICLE APPLICATIONS

ZBJP1B rev B 06/11/2014 9

MODEL ADDITIONAL

INFORMATION

LOWER BALL JOINT UPPER BALL JOINT

Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

AC

UR

A

CL 1997-2003 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-24A BJP1-1A BJP1-22A &

BJP1-6A BJP1-5A & BJP1-6A

BJP1-11A

Integra 1989-2001 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

Legend

1991-95 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

1986-90 BJP1-24A Not

in BJP1 kit BJP1-22A BJP1-24A

BJP1-5A & BJP1-6A

BJP1-24A N/A - NO REPLACEMENT AT THIS TIME

MDX 2007-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

2001-2006 BJP1-3A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

RDX 2007-2014 N/A - BOLT IN BALL JOINT N/A - STRUT

RL

2005-2012 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

1996-2004 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

RSX 2002-2006 BJP1-6A BJP1-11A BJP1-5A & BJP1-6A

BJP1-11A N/A - STRUT

SLX 1996-99 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

TL

2009-2013 BJP1-29A Not

in BJP1 kit BJP1-8A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-29A N/A - CONTROL ARM REPLACE

2004-2008 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-24A BJP1-22A &

BJP1-6A BJP1-1A BJP1-5A BJP1-11A

1999-2003 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

1995-98 BJP1-24A &

BJP1-22A Not in BJP1 kit

BJP1-1A BJP1-11A &



BJP1-6A BJP1-5A BJP1-11A

TSX

2009-2013 BJP1-29A Not

in BJP1 kit BJP1-8A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A


2004-2008 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-24A BJP1-3A BJP1 11A &


BJP1-11A

Vigor 1992-94 BJP1-22A Not

in BJP1 kit N/A - NO REPLACEMENT AT THIS TIME BJP1-1A

BJP1-22A & BJP1-6A

BJP1-5A BJP1-11A

ZDX 2010-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

AU

DI

80 1990-92 N/A - BOLT IN BALL JOINT N/A - STRUT


100 1990-93 N/A - CONTROL ARM REPLACE N/A - STRUT


100 Quattro 1990-94 N/A - CONTROL ARM REPLACE N/A - STRUT

200 Quattro 1990-91 N/A - CONTROL ARM REPLACE N/A - STRUT

80 Quattro 1990-92 N/A - BOLT IN BALL JOINT N/A - STRUT

90 Quattro 1990-95 N/A - BOLT IN BALL JOINT N/A - STRUT

A3 2006-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

A3 Quattro 2006-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

A4 2009-2013 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE


A4 Avant 1999-2009 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT


ZBJP1B rev B 06/11/2014 10

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

AU

DI

A4 Quattro 2009-2013 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE






A6 Avant 1999-2006 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT




A8 1997-99 N/A - CONTROL ARM REPLACE N/A - STRUT



Allroad Quattro


Cabriolet 1994-98 N/A - BOLT IN BALL JOINT N/A - STRUT

Coupe Quattro

1990-91 N/A - BOLT IN BALL JOINT N/A - STRUT

Q5 2009-2012 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE

Q7 2007-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

R8 2008-2012 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

RS4 2007-2006 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

RS6 2003-2004 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

RS7 2014 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE

S4 2010-2012 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE


S4 Avant 2001-2006 N/A - CONTROL ARM REPLACE N/A - BOLT IN BALL JOINT

S5 2008-2012 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE

S6

2012 N/A - PINCH BOLT N/A - CONTROL ARM REPLACE


1995 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

S6 Avant 2002-2004 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

S8 2007-2009 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE


TT 2000-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

V8 Quattro 1990-1994 N/A - CONTROL ARM REPLACE N/A - STRUT

BM

W

1 Series 2008-2012 N/A - REPLACE CONTROL ARM N/A - STRUT

3 Series

2012-2013 N/A - REPLACE CONTROL ARM N/A - STRUT




5 Series

2011-2013 N/A - REPLACE CONTROL ARM N/A - REPLACE CONTROL ARM




ZBJP1B rev B 06/11/2014 11

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

BM

W

6 Series 2012-2013 N/A - REPLACE CONTROL ARM N/A - REPLACE CONTROL ARM

2004-2010 N/A - REPLACE CONTROL ARM N/A- STRUT

7 Series




8 Series 1996-97 N/A - REPLACE CONTROL ARM N/A - REPLACE CONTROL ARM


M1 2012 N/A - REPLACE CONTROL ARM N/A - STRUT

M3

2012 N/A - REPLACE CONTROL ARM N/A - STRUT



1993-99 BJP1-22A Not

in BJP1 kit BJP1-7A BJP1-22A BJP1-5A BJP1-11A N/A - STRUT


M5





M6 2013 N/A - REPLACE CONTROL ARM N/A - REPLACE CONTROL ARM


X3 2004-2014 N/A - BOLT IN BALL JOINT N/A - STRUT

X5 2007-2012 N/A - REPLACE CONTROL ARM N/A - STRUT


X6 2010-2014 N/A - REPLACE CONTROL ARM N/A - REPLACE CONTROL ARM

Z3 1996-2002 BJP1-22A Not


Z4 2003-2014 N/A - REPLACE CONTROL ARM N/A - STRUT

Z8 2000-2003 N/A - REPLACE CONTROL ARM N/A - STRUT

BU

IC

K

Apollo 1975 BJPI-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B

N/A - BOLT IN BALL JOINT

Century


1973-1981 BJPI-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B


Electra 1985-1990 N/A - BOLT IN BALL JOINT N/A - STRUT

Enclave 2008-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Encore 2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Estate Wagon

1977-90 BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B


LaCrosse

2010-2013 w/Performance

Suspension N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

2010-2013 w/o

Performance Suspension

N/A - CONTROL ARM REPLACE N/A - STRUT


ZBJP1B rev B 06/11/2014 12

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

BU

IC

K

LaCrosse (cont.)


LeSabre 1990-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Lucerne 2006-2011 N/A - CONTROL ARM REPLACE N/A - STRUT

Park Avenue 1991-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Rainier 2004-2007 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Reatta 1990-1991 N/A - BOLT IN BALL JOINT N/A - STRUT

Regal

2011-2013 w/Performance

Suspension N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

2011-2013 w/o

Performance Suspension

N/A - CONTROL ARM REPLACE N/A - STRUT




Rendezvous 2002-2007 N/A - BOLT IN BALL JOINT N/A - STRUT

Riviera 1990-1999 N/A - BOLT IN BALL JOINT N/A - STRUT

Roadmaster 1991-96 BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B


Skylark 1990-98 N/A - BOLT IN BALL JOINT N/A - STRUT

Terraza 2005-2007 N/A - BOLT IN BALL JOINT N/A - STRUT

Verano 2012-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

CA

DILLA

C

60 Special 1993 N/A - BOLT IN BALL JOINT N/A - STRUT

Allante 1990-1993 N/A - BOLT IN BALL JOINT N/A - STRUT

ATS 2013-2014 N/A - CONTROL ARM REPLACE N/A - STRUT

Brougham 1990-92 BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B


Catera 1997-2001 N/A - BOLT IN BALL JOINT N/A - STRUT

Commercial Chassis

1992 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

CTS 2008-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

2003-2007 BJP1-7A BJP1-11A BJP1-5A BJP1-11A BJP1-11A BJP1-12A BJP1-6A BJP1-14A

Deville 1990-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

DTS 2006-2011 BJP1-8A BJP1-13A/ BJP1-13B

BJP1-12A BJP1-14A N/A - STRUT

Eldorado 1990-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

Escalade

2007-2012 Cast Iron Arm BJP1-8A BJP1-16A BJP1-3A BJP1-12A N/A - CONTROL ARM REPLACE

2007-2012 Aluminum Arm BJP1-12A BJP1-11A BJP1-3A BJP1-13B N/A - CONTROL ARM REPLACE


Fleetwood 1990-96 BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B

NA - BOLT IN BALL JOINT

Seville 1986-2004 NA - BOLT IN BALL JOINT NA - STRUT

SRX 2010-2013 NA - BOLT IN BALL JOINT NA - STRUT

2004-2009 BJP1-3A BJP1-7A BJP1-5A BJP1-11A BJP1-12A BJP1-11A BJP1-3A BJP1-13B


ZBJP1B rev B 06/11/2014 13

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

CA

DILLA

C

STS 2010-2011 NA - BOLT IN BALL JOINT NA - STRUT

2005-2009 BJP1-3A BJP1-7A BJP1-5A BJP1-11A BJP1-12A BJP1-11A BJP1-3A BJP1-13B

XLR 2004-2009 BJP1-8A BJP1-7A BJP1-5A BJP1-11A BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B

CH

EV

RO

LE

T

Astro

1990-2005

4WD N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

2WD BJP1-11A BJP1-12A BJP1-8A BJP1-13A/ BJP1-13B




Avalanche

2007-2013 Cast Iron Arm BJP1-8A BJP1-16A BJP1-3A BJP1-12A N/A - REPLACE CONTROL ARM

2007-2013 Aluminum

Control Arm BJP1-12A BJP1-11A BJP1-3A BJP1-13B N/A - REPLACE CONTROL ARM

Avalanche 1500


Avalanche 2500

2002-2006 BJP1-13A/ BJP1-13B

BJP1-11A BJP1-3A BJP1-14A BJP1-7A BJP1-11A BJP1-6A BJP1-12A

Aveo 2004-2011 N/A - BOLT IN BALL JOINT N/A - STRUT

Beretta 1987-96 N/A - BOLT IN BALL JOINT N/A - STRUT

Blazer

2000-2005 2WD BJP1-11A BJP1-12A BJP1-6A

BJP1-13A/ BJP1-13B



1993-99 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

1990-92 BJP1-22A Not

in BJP1 kit BJP1-22A BJP1-8A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

C10 1971-1986 BJP1-8A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B


C20 1971-1986 BJP1-6A BJP1-14A BJP1-12A BJP1-13A/ BJP1-13B


C30

1971-1986 BJP1-12A BJP1-13A/ BJP1-13B

BJP1-6A BJP1-14A N/A - BOLT IN BALL JOINT

1960-71 BJP1-11A BJP1-13A/ BJP1-13B


C1500 1988-1999 BJP1-8A BJP1-13A/ BJP1-13B

BJP1-6A BJP1-13A/ BJP1-13B


C2500 1988-2000 BJP1-8A BJP1-13A/ BJP1-13B


C3500

1991-2000 BJP1-8A BJP1-13A/ BJP1-13B


1988-90

Independent Suspension



Solid Axle BJP1-12A BJP1-13A/ BJP1-13B



ZBJP1B rev B 06/11/2014 14

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

CH

EV

RO

LE

T

Camaro

2010-2013 N/A - CONTROL ARM REPLACE N/A - STRUT



Caprice 1990-96 BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B


Captiva Sport


Cavalier 1982-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Celebrity 1982-90 N/A - BOLT IN BALL JOINT N/A - STRUT

Classic 2004-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Cobalt 2005-2010 N/A - BOLT IN BALL JOINT N/A - STRUT

Colorado 2004-2012 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Corsica 1987-96 N/A - BOLT IN BALL JOINT N/A - STRUT

Corvette 1990-96 BJP1-8A BJP1-1A BJP1-6A BJP1-13A/ BJP1-13B


Cruze 2011-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Equinox 2010-2013 N/A - BOLT IN BALL JOINT N/A - STRUT


Express 1500


1996-2002 BJP1-8A BJP1-13A/ BJP1-13B


Express 2500

2003-2013

7300lb GVW BJP1-8A BJP1-16A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

8500 & 8600lb GVW

BJP1-12A BJP1-16A BJP1-3A BJP1-14A BJP1-3A BJP1-11A BJP1-5A BJP1-12A

1996-2002 BJP1-8A BJP1-13A/ BJP1-13B


Express 3500


1996-2002 BJP1-8A BJP1-13A/ BJP1-13B


Express 4500


G10 1971-1995 BJP1-8A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B


G20



1971-1981

Disc Brakes BJP1-12A BJP1-13A/ BJP1-13B


Drum Brakes BJP1-8A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B


G30

1971-1995 BJP1-12A BJP1-13A/ BJP1-13B


1971-1972

Disc Brakes BJP1-12A BJP1-13A/ BJP1-13B


Drum Brakes BJP1-11A BJP1-13A/ BJP1-13B


HHR 2006-2011 N/A - BOLT IN BALL JOINT N/A - STRUT


ZBJP1B rev B 06/11/2014 15

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

CH

EV

RO

LE

T

Impala


1994-96 BJP1-11A BJP1-12A BJP1-6A

BJP1-13A/ BJP1-13B


K10 1971-1986 BJP1-6A BJP1-11A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

K20 1970-1986 BJP1-6A BJP1-11A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

K30 1977-1986 N/A - BOLT IN BALL JOINT OR KINGPIN N/A - BOLT IN BALL JOINT OR KINGPIN

K1500 1996-1999

BJP1-13A/ BJP1-13B

BJP1-11A BJP1-3A BJP1-14A N/A - BOLT IN BALL JOINT


K2500 1996-2000

BJP1-13A/ BJP1-13B



K3500 1996-2000

BJP1-13A/ BJP1-13B



LLV (Mail truck)



Lumina 1990-1999 N/A - BOLT IN BALL JOINT N/A - STRUT

Lumina APV 1990-96 N/A - BOLT IN BALL JOINT N/A - STRUT

Malibu 1997-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

Metro 1998-99 N/A - CONTROL ARM REPLACE N/A - STRUT

Monte Carlo 1995-2007 N/A - BOLT IN BALL JOINT N/A - STRUT

P10 Van 1971-1982 BJP1-8A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B


P20 Van

1971-1989 BJP1-12A BJP1-13A/ BJP1-13B


pre 1971 BJP1-11A BJP1-13A/ BJP1-13B


P30 Van

1973-1997

Rear drum brakes



Rear disc brakes

BJP1-8A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B


DANA Axle N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

1971-1972 all BJP1-12A BJP1-13A/ BJP1-13B


pre 1971 all BJP1-11A BJP1-13A/ BJP1-13B


Prizm 1998-2002

N/A - BOLT IN BALL JOINT N/A - STRUT

R10 1987-88 BJP1-8A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B




R30 1987-88 BJP1-12A BJP1-13A/ BJP1-13B



ZBJP1B rev B 06/11/2014 16

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

CH

EV

RO

LE

T



R2500 1989-1990 BJP1-12A BJP1-13A/ BJP1-13B


R3500 1989-1990 BJP1-12A BJP1-13A/ BJP1-13B


S10 Truck 1982-2004




S-10 Blazer 1983-2005


2WD BJP1-5A BJP1-13A/ BJP1-13B



Silverado 1500

2007-2012

Cast Iron Arm N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Aluminum Control Arm

BJP1-12A BJP1-11A BJP1-3A BJP1-13B N/A - CONTROL ARM REPLACE

1999-2006 4WD BJP1-8A BJP1-16A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

2WD N/A - BOLT IN BALL JOINT BJP1-8A BJP1-11A BJP1-5A BJP1-12A

Silverado 2500

2000-2010 4WD BJP1-13A/ BJP1-13B


2005-2010 2WD coil spring

BJP1-13A/ BJP1-13B

BJP1-16A BJP1-4A BJP1-14A N/A - CONTROL ARM REPLACE

2000-2004 2WD N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

Silverado 3500

2001-2010 BJP1-13A/ BJP1-13B


Sonic 2012-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Spark 2013 N/A - BOLT IN BALL JOINT N/A - STRUT

SSR 2003-2006 BJP1-12A BJP1-16A BJP1-3A BJP1-14A BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Suburban 1500

2007-12

Cast Iron Arm N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT




Suburban 2500

2011-13 Aluminum

Control Arm BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-3A BJP1-11A BJP1-5A BJP1-12A

2000-2010 BJP1-13A/ BJP1-13B


Tahoe

2007-2012 Cast Iron Arm BJP1-8A BJP1-16A BJP1-3A BJP1-12A N/A - CONTROL ARM REPLACE

Aluminum Arm BJP1-12A BJP1-11A BJP1-3A BJP1-13B N/A - CONTROL ARM REPLACE

2002-2006 BJP1-12A BJP1-16A BJP1-4A BJP1-14A N/A - CONTROL ARM REPLACE

1995-2001 2WD BJP1-8A BJP1-12A BJP1-6A

BJP1-13A/ BJP1-13B



Trailblazer 2002-2009 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Traverse 2009-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Uplander 2005-2008 N/A - BOLT IN BALL JOINT N/A - STRUT

V10 1987-1988 BJP1-6A BJP1-11A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A



ZBJP1B rev B 06/11/2014 17

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

CH

EV

RO

LE

T V30 1988 N/A - BOLT IN BALL JOINT OR KINGPIN N/A - BOLT IN BALL JOINT OR KINGPIN



V3500 1989-1990 N/A - BOLT IN BALL JOINT OR KINGPIN N/A - BOLT IN BALL JOINT OR KINGPIN

Venture 2003-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Volt 2011-2014 N/A - CONTROL ARM REPLACE N/A - STRUT

CH

RY

SLE

R

300 2005-2013 RWD BJP1-11A BJP1-7A BJP1-5A BJP1-13B N/A - CONTROL ARM REPLACE

300M 1998-2004 N/A - CONTROL ARM REPLACE N/A - STRUT

Aspen 2007-2009 BJP1-12A BJP1-16A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

Cirrus 1995-2000 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-7A BJP1-5A BJP1-11A

Concord 1993-2004 N/A - CONTROL ARM REPLACE N/A - STRUT

Crossfire 2004-08 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

Imperial 1991-93 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Intrepid 1993-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

LeBaron 1992-95 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

LHS 1994-2001 N/A - CONTROL ARM REPLACE N/A - STRUT

Neon 1995-99 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

New Yorker 1994-96 N/A - CONTROL ARM REPLACE N/A - STRUT


Pacifica 2004-2008 BJP1-8A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Prowler 2001-2002 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

PT Cruiser 2001-2010 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Sebring

2001-2006

Coupe BJP1-6A BJP1-11A BJP1-6A BJP1-11A N/A - STRUT

Sedan & Convertible


1995-2000 Coupe N/A - CONTROL ARM REPLACE BJP1-3A BJP1-7A BJP1-5A BJP1-8A

Convertible N/A - CONTROL ARM REPLACE BJP1-3A BJP1-7A BJP1-5A BJP1-11A

Town & Country


N/A - STRUT


DA

EW

OO

Lanos 1998-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

Leganza 1998-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

Nubria 1998-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

DA

IH

AT

SU

Charade 1988-92 N/A - BOLT IN BALL JOINT N/A - STRUT


ZBJP1B rev B 06/11/2014 18

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

DO

DG

E

Avenger 1995-2000 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-7A BJP1-5A BJP1-8A

Caliber 2007-2012 BJP1-22A Not In BJP1 Kit

BJP1-7A BJP1-22A BJP1-3A BJP1-11A N/A - STRUT

Caravan 1984-2007 BJP-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Challenger 2009-2013 BJP1-11A BJP1-7A BJP1-5A BJP1-13B N/A - CONTROL ARM REPLACE

Charger 2006-2013 BJP1-11A BJP1-7A BJP1-5A BJP1-13B N/A - CONTROL ARM REPLACE

Colt 1985-94 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

Dakota (2WD)


1986-1996 BJP1-8A BJP1-12A BJP1-6A BJP1-12A N/A - BOLT IN BALL JOINT

Dakota





Dart 2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Daytona 1991-93 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Dynasty 1988-93 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Durango

2011-2013 BJP1-12A BJP1-11A BJP1-3A BJP1-13B N/A - CONTROL ARM REPLACE


2000-2003

2WD N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE


BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

1998-1999 2WD N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

4WD BJP1-1A BJP1-11A BJP1-3 BJP1-12A N/A - BOLT IN BALL JOINT

Grand Caravan


N/A - STRUT



Intrepid 1993-2004 N/A - CONTROL ARM REPLACE N/A - STRUT

Magnum (RWD)


Monaco 1990-92 N/A - BOLT IN BALL JOINT N/A - STRUT


Nitro 2007-2012 BJP1-12A BJP1-16A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

Power Ram W150

pre 1990-93


Power Ram W250

pre 1990-93


Power Ram W350

pre 1990-93


Raider 1987-89 N/A - BOLT IN BALL JOINT BJP1-8A BJP1-7A BJP1-5A BJP1-12A

Ram 50 1992-93 N/A - BOLT IN BALL JOINT BJP1-3A BJP1-7A BJP1-5A BJP1-11A

Ram 1500


2006-2008

5 Lug BJP1-11A BJP1-8A BJP1-6A BJP1-14A BJP1-7A BJP1-11A BJP1-5A BJP1-12A

8 Lug 2WD BJP1-11A BJP1-16A BJP1-3A BJP1-11A BJP1-7A BJP1-11A BJP1-5A BJP1-12A

8 Lug 4WD BJP1-11A BJP1-16A BJP1-3A BJP1-11A BJP1-11A BJP1-16A BJP1-5A BJP1-12A


ZBJP1B rev B 06/11/2014 19

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

DO

DG

E

Ram 1500 (cont.)



4WD BJP1-6A BJP1-8A BJP1-3A BJP1-11A BJP1-3A BJP1-11A BJP1-5A BJP1-12A

1994-99 2WD BJP1-12A BJP1-11A BJP1-3A BJP1-14A BJP1-3A BJP1-11A BJP1-6A

BJP1-13A/ BJP1-13B


Ram2500

2006-2010


4WD BJP1-28A Not

in BJP1 kit

BJP1-28A (short side) & BJP1-6A


(long side) & BJP1-6A

BJP1-11A BJP1-28A

(short side) BJP1-5A BJP1-12A

2003-2005

2WD BJP1-6A BJP1-11A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

4WD BJP1-28A Not

in BJP1 kit




BJP1-11A BJP1-28A


2000-2002



BJP1-3A BJP1-12A BJP1-3A BJP1-11A BJP1-5A BJP1-10A

1994-99

2WD BJP1-6A BJP1-11A BJP1-3A BJP1-13B BJP1-3A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B

4WD Dana 44 Axle


4WD Dana 60 Axle


Ram 3500

2006-2010


4WD BJP1-28A Not

in BJP1 kit




BJP1-11A BJP1-28A


2003-2005

2WD BJP1-6A BJP1-11A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

4WD BJP1-28A Not

in BJP1 kit




BJP1-11A BJP1-28A


2000-2002

2WD Independent Suspension

N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

4WD & 2WD Solid Axle



1994-99

2WD

Independent Suspension

BJP1-24A Not in BJP1 Kit

BJP1-24A BJP1-11A BJP1-3A BJP1-13B BJP1-3A BJP1-11A BJP1-6A BJP1-13A/ BJP1-13B

4WD & 2WD Solid Axle


Ram D150 1991-93 BJP1-8A BJP1-12A BJP1-6A BJP1-12A N/A - BOLT IN BALL JOINT

Ram D250 1992-93 Except 4000lb

Axle BJP1-8A BJP1-12A BJP1-6A BJP1-12A N/A - BOLT IN BALL JOINT


ZBJP1B rev B 06/11/2014 20

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

DO

DG

E

Ram D250 (cont.)

1992-93 4000lb Axle BJP1-11A BJP1-13A/ BJP1-13B


Ram D350 1991-93

Except 3800lb & 4000lb Axle

BJP1-8A BJP1-12A BJP1-6A BJP1-12A N/A - BOLT IN BALL JOINT

3800lb & 4000lb Axle



Ram Van 1500


Ram Van 2500

1999-2003

3300lb Axle BJP1-8A BJP1-12A BJP1-6A BJP1-12A N/A - BOLT IN BALL JOINT

3800lb & 4000lb Axle




Ram Van 3500

1994-2003


4000lb Axle BJP1-11A BJP1-13A/ BJP1-13B


Ram Van B100


Ram Van B150


Ram Van B200


Ram Van B250


Ram Van B300

1971-80




Ram Van B350

1981-93




Ramcharger 1974-1993 2WD BJP1-8A BJP1-12A BJP1-6A BJP1-12A N/A - THREAD IN BALL JOINT


Shadow 1991-94 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Spirit 1991-95 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Sprinter 2500

2003-2008 BJP1-18A Not

in BJP1 kit BJP1-12A

BJP1-13A/ BJP1-13B


Sprinter 3500

2003-2006 BJP1-18A Not


BJP1-13A/ BJP1-13B


Stealth 1992-97 N/A - CONTROL ARM REPLACE N/A - STRUT

Stratus 2000-2006 BJP1-6A BJP1-12A BJP1-6A BJP1-12A BJP1-7A BJP1-11A BJP1-5A BJP1-11A

Viper 1997-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

1992-95 N/A - CONTROL ARM REPLACE N/A - THREAD IN BALL JOINT

EA

GLE

Premier 1988-92 N/A - BOLT IN BALL JOINT N/A - STRUT

Summit 1989-96 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

Talon 1995-98 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-7A BJP1-5A BJP1-8A



ZBJP1B rev B 06/11/2014 21

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

EA

GLE

Vision 1993-98 N/A - CONTROL ARM REPLACE N/A - STRUT

Vista 1989-92 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

FIA

T


FO

RD

Aerostar 1986-97 FWD BJP1-11A BJP1-12A BJP1-6A

BJP1-13A/ BJP1-13B


1986-97 AWD BJP1-7A BJP1-11A BJP1-3A BJP1-11A N/A - BOLT IN BALL JOINT

Aspire 1994-97 N/A - CONTROL ARM REPLACE N/A - STRUT

Bronco pre 1975 -

1996 BJP1-8A BJP1-11A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-3A BJP1-12A

Bronco II 1984-1990 BJP1-7A BJP1-8A BJP1-5A BJP1-11A BJP1-7A BJP1-8A BJP1-5A BJP1-11A

C-Max 2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Contour 1995-2000 N/A - BOLT IN BALL JOINT N/A - STRUT

Country Squire



Crown Victoria

2003-2011

Forged Upper Control Arm


BJP1-11A BJP1-8A BJP1-5A BJP1-12A BJP1-8A BJP1-24A &


2003-2004

Stamped Upper Control Arm BJP1-24A Not in BJP1 kit

BJP1-11A BJP1-8A BJP1-5A BJP1-12A BJP1-8A BJP1-24A &





E150 Van

2008-2010 BJP1-11A BJP1-13A/ BJP1-13B



Pre 1992 N/A - KINGPIN WITH BUSHINGS N/A - KINGPIN WITH BUSHINGS

E250 Van 1992-2012 BJP1-11A

BJP1-13A/ BJP1-13B


pre 1992 N/A - KINGPIN WITH BUSHINGS N/A - KINGPIN WITH BUSHINGS

E350 Van 1992-2012 BJP1-11A

BJP1-13A/ BJP1-13B



E450 Van 2000-2012 BJP1-11A BJP1-13A/ BJP1-13B


E550 Van 2003 BJP1-11A BJP1-13A/ BJP1-13B


Edge 2007-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A NA - STRUT

Escape 2001-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A NA - STRUT

Escort 1990-2003 N/A - BOLT IN BALL JOINT N/A - STRUT


ZBJP1B rev B 06/11/2014 22

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

FO

RD

Excursion 2000-2005

2WD Twin I-Beam


2WD & 4WD Mono-Beam


Expedition




Explorer


2006-2010 BJP1-27A Not


2002-2005 BJP1-27A Not


1995-2001 BJP1-27A Not

in BJP1 kit BJP1-12A BJP1-16A BJP1-3A BJP1-27A N/A - CONTROL ARM REPLACE

1991-1994

2WD/4WD Dana 28 Axle


4WD Dana 35 Axle


F100 trucks



1979-1980 N/A - KINGPIN WITH BUSHINGS N/A - KINGPIN WITH BUSHINGS

1966-1978 2WD N/A - KINGPIN WITH BUSHINGS N/A - KINGPIN WITH BUSHINGS


F150




4WD N/A - CONTROL ARM REPLACE BJP1-8A BJP1-12A BJP1-5A BJP1-14A






1980 2WD N/A - KINGPIN WITH BUSHINGS N/A - KINGPIN WITH BUSHINGS




F250 & F250 SuperDuty

1999-2013 SuperDuty




1997

2WD, 5.8L, 7.3L & 7.5L

Engine BJP1-11A BJP1-12A BJP1-3A BJP1-12A BJP1-7A BJP1-8A BJP1-5A BJP1-11A

4WD, 5.8L, 7.3L & 7.5L

Engine BJP1-11A BJP1-16A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-3A BJP1-12A


ZBJP1B rev B 06/11/2014 23

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

FO

RD

F250 & F250 SuperDuty (cont.)

1997 (cont.)

4.6L & 5.4L Engine

BJP1-12A BJP1-8A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

1991-1996


4WD 3850lb Axle


4WD 4600lb Axle


1980-1990


4WD <4500lb Axle


4WD 4500lb or 4600lb Axle



F350 & F350 SuperDuty

1999-2013 2WD BJP1-11A

BJP1-13A/ BJP1-13B








F450 2005-2013


BJP1-13B BJP1-14A BJP1-8A BJP1-25A BJP1-11A BJP1-10A BJP1-7A BJP1-6A & BJP1-12A


F550 2005-2013


BJP1-13B BJP1-14A BJP1-8A BJP1-25A BJP1-11A BJP1-10A BJP1-7A BJP1-6A & BJP1-12A


Festiva 1988-93 N/A - CONTROL ARM REPLACE N/A - STRUT

Fiesta 2011-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Five Hundred


Flex 2009-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Focus 2012-2013 N/A - CONTROL ARM REPLACE N/A - STRUT


Freestar 2004-2007 N/A - CONTROL ARM REPLACE N/A - STRUT

Freestyle 2005-2007 N/A - CONTROL ARM REPLACE N/A - STRUT

Fusion 2006-2012 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-11A BJP1-5A BJP1-11A

LTD Crown Victoria



Mustang





N/A - STRUT

Probe 1989-97 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

Ranger 2003-2011 BJP1-12A BJP1-8A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE


ZBJP1B rev B 06/11/2014 24

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

FO

RD

Ranger (cont.)

1998-2002 Coil Spring BJP1-12A BJP1-8A BJP1-3A BJP1-14A BJP1-7A BJP1-11A BJP1-5A BJP1-11A

Torsion Bar BJP1-12A BJP1-8A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE


Taurus


1996-2007 BJP1-7A BJP1-11A &




Taurus X 2008-2009 N/A - CONTROL ARM REPLACE N/A - STRUT

Tempo 1983-94 N/A - CONTROL ARM REPLACE N/A - STRUT

Thunderbird 1989-97 BJP1-8A BJP1-11A BJP1-5A BJP1-12A N/A - CONTROL ARM REPLACE

Windstar 1995-2003 N/A - CONTROL ARM REPLACE N/A - STRUT

GE

O Metro 1989-97 N/A - CONTROL ARM REPLACE N/A - STRUT

Prizm 1990-97 N/A - BOLT IN BALL JOINT N/A - STRUT

Storm 1990-93 N/A - BOLT IN BALL JOINT N/A - STRUT

Tracker 1990-97 N/A - BOLT IN BALL JOINT N/A - STRUT

GM

C

Acadia 2007-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Canyon 2004-2012 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Envoy 2003-2009 BJP1-12A BJP1-11A BJP1-3A BJP1-14A BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Jimmy 1992-2005 BJP1-11A BJP1-12A BJP1-6A

BJP1-13A/ BJP1-13B



Safari 1990-2005




Savana 1500


1996-2002 BJP1-8A BJP1-13A/ BJP1-13B


Savana 2500

2003-2013

7300lb GVW BJP1-8A BJP1-16A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

8500 & 8600lb GVW


1996-2002 BJP1-8A BJP1-13A/ BJP1-13B


Savana 3500


1996-2002 BJP1-8A BJP1-13A/ BJP1-13B


Sierra 1500

2007-2012



Cast Iron Control Arm

BJP1-8A BJP1-16A BJP1-3A BJP1-12A N/A - CONTROL ARM REPLACE

1999-2006


4WD & 2WD With Torsion

Bar BJP1-8A BJP1-16A BJP1-3A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A


ZBJP1B rev B 06/11/2014 25

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

GM

C

Sierra 2500 1999-2010 BJP1-13A/ BJP1-13B


Sierra 3500 2007-2010 BJP1-13A/ BJP1-13B


Sierrra Denali


Sonoma 1990-2004




Terrain 2010-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Typhoon 1992-93 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Yukon

2007-2012 Steel Arm BJP1-8A BJP1-16A BJP1-3A BJP1-12A N/A - CONTROL ARM REPLACE



1992-99



4WD BJP1-13A/ BJP1-13B


Yukon XL 1500

2007-2012 Steel Arm BJP1-8A BJP1-16A BJP1-3A BJP1-12A N/A - CONTROL ARM REPLACE



Yukon XL 2500

2011-2012 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-3A BJP1-11A BJP1-5A BJP1-12A

2000-2010 BJP1-13A/ BJP1-13B


HO

ND

A

Accord

2008-2012 BJP1-29A Not

in BJP1 kit BJP1-8A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A


1990-2007 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

1986-89 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A


Civic

2006-2011 N/A - BOLT IN BALL JOINTS N/A - STRUT

2001-2005 BJP1-6A BJP1-11A BJP1-5A & BJP1-6A


1988-2000 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

Crosstour 2010-2013 BJP1-29A Not

in BJP1 kit BJP1-8A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A


CR-V

2007-2013 N/A - BOLT IN BALL JOINTS N/A - STRUT

2002-2006 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A


1996-2001 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

CRX 1988-91 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

CR-Z 2011-2013 N/A - CONTROL ARM REPLACE N/A - STRUT


ZBJP1B rev B 06/11/2014 26

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

HO

ND

A

Del Sol 1993-97 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

Element 2003-2011 N/A - BALL JOINT SOLD IN KNUCKLE N/A - STRUT

Fit 2009-2013 BJP1-3A BJP1-7A BJP1-5A BJP1-7A N/A - STRUT


Insight 2010-2013 BJP1-3A BJP1-7A BJP1-5A BJP1-7A N/A - STRUT

Odyssey




1999-2004 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A


1995-1998 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



BJP1-11A

Passport 1994-2002 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Pilot 2009-2012 N/A - CONTROL ARM REPLACE N/A - STRUT


Prelude

1997-2001 BJP1-24A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-24A BJP1-3A BJP1-11A BJP1-5A BJP1-8A

1992-96 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



1983-1991 BJP1-22A Not

in BJP1 kit BJP1-1A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-22A N/A - BALL JOINT BOLTS IN

Ridgeline 2006-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

S2000 2000-2009 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

HU

MM

ER

H1 1992-2006 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

H2 2003-2009 BJP1-13A/ BJP1-13B &


H3 2006-2010 BJP1-11A BJP1-8A BJP1-3A BJP1-13B N/A - CONTROL ARM REPLACE

HY

UN

DA

I

Accent 2006-2012 N/A - BOLT IN BALL JOINT N/A - STRUT


Azera 2006-2011 BJP1-22A Not

in BJP1 kit N/A - BOLT IN BALL JOINT BJP1-5A BJP1-7A BJP1-5A BJP1-22A

Elantra




Entourage 2007-2009 N/A - BOLT IN BALL JOINT N/A - STRUT

Equus 2011-2013 N/A - BALL JOINT SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE

Excel 1986-94 N/A - BOLT IN BALL JOINT N/A - STRUT

Genesis 2009-2012 N/A - BALL JOINT SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE

Genesis Coupe


Sante Fe 2001-2012 BJP1-6A BJP1-12A BJP1-5A BJP1-12A N/A - STRUT

Scoupe 1991-95 N/A - BOLT IN BALL JOINT N/A - STRUT

Sonata 2011-2013 N/A - BOLT IN BALL JOINT N/A - STRUT


ZBJP1B rev B 06/11/2014 27

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

HY

UN

DA

I

Sonata (cont.)

2006-2010 BJP1-22A Not


1999-2005 BJP1-22A Not




Tiburoun 1997-2008 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Tucson 2005-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Veloster 2012-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

Veracruz 2007-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

XG300 2001 BJP1-22A Not


XG350 2002-2005 BJP1-22A Not


IN

FIN

IT

I

EX SUV's 2008-2012 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

FX SUV's 2009-2010 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE


G20


1991-96 BJP1-22A Not

in BJP1 kit BJP1-1A BJP1-7A BJP1-5A BJP1-22A N/A - CONTROL ARM REPLACE

G25 2011-2012 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE



I30


1996-1999 BJP1-22A Not


I35 2002-2004 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

J30 1993-97 N/A - CONTROL ARM REPLACE N/A - STRUT

M30 1990-92 N/A - CONTROL ARM REPLACE N/A - STRUT

M35 2006-2010 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

M35H 2012 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE





Q45 1997-2006 N/A - CONTROL ARM REPLACE N/A - STRUT

1990-1996 N/A - CONTROL ARM REPLACE N/A - KINGPIN

QX4 1997-2003 N/A - BOLT IN BALL JOINT N/A - STRUT

QX56 2007-2011 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

2004-2006 N/A - CONTROL ARM REPLACE BJP1-7A BJP1-8A BJP1-5A BJP1-11A

IS

UZ

U Amigo 1989-2000 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Ascender 2003-2008 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Axiom 2002-2004 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT


ZBJP1B rev B 06/11/2014 28

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

IS

UZ

U

Hombre 1996-2000 2WD BJP1-11A BJP1-12A BJP1-6A

BJP1-13A/ BJP1-13B



Impulse 1983-92 N/A - BOLT IN BALL JOINT N/A - STRUT

i-Series 2006-2008 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Oasis 1996-99 BJP1-22A Not


Pickup 1981-95 2WD & 4WD N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Rodeo 1991-2004 2WD & 4WD N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Stylus 1991-93 N/A - BOLT IN BALL JOINT N/A - STRUT

Trooper 1984-2002 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Vehicross 1999-2001 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

JA

GU

AR

XF 2009-2013 N/A - BALL JOINT SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE

XJ 2009-2013 N/A - BALL JOINT SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE

XJ-Type

2004-2008 N/A - BALL JOINT SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE



XJR 1995-2000 N/A - CONTROL ARM REPLACE BJP1-7A BJP1-8A BJP1-5A BJP1-11A

XK 2009-2013 N/A - BALL JOINT SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE

XK-Type 2007-2008

N/A - BALL JOINT SOLD IN KNUCKLE BJP1-7A BJP1-8A BJP1-5A BJP1-11A


X-Type 2002-2008 N/A - CONTROL ARM REPLACE N/A - STRUT

JEE

P

Cherokee, Grand Cherokee, Wagoneer, Grand Wagoneer




pre 1974-1983


CJ5, CJ6, CJ7, CJ8

pre 1972-1986


Commander 2006-2010 BJP1-18A Not

in BJP1 kit BJP1-12A BJP1-18A BJP1-3A BJP1-14A BJP1-7A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A

BJP1-11A

Compass 2007-2013 BJP1-7A BJP1-22A BJP1-3A BJP1-11A N/A - STRUT

Liberty


2003-2007 BJP1-11A &

BJP1-6A BJP1-1A

BJP1-5A & BJP1-6A


Patriot 2007-2013 BJP1-22A Not


Trucks - J10, J20, Honcho, Laredo


Wrangler 2007-2012 BJP1-8A BJP1-11A BJP1-3A BJP1-10A BJP1-3A BJP1-10A BJP1-5A BJP1-12A



ZBJP1B rev B 06/11/2014 29

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

KIA

Amanti 2004-2006 BJP1-22A Not


Borrego 2009 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

Forte 2010-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Optima


2006.5-2010


2001-2006 BJP1-22A Not


Rio 2012-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT


Rio 5 2012-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT


Rondo 2007-2010 N/A - BOLT IN BALL JOINT N/A - STRUT

Sedona 2003-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

Sephia 1994-2001 N/A - BOLT IN BALL JOINT N/A - STRUT

Sorento 2011-2013 BJP1-6A BJP1-12A BJP1-5A BJP1-12A N/A - STRUT


Soul 2010-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

Spectra 2004-2009 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT


Sportage 2011-2013 N/A - BOLT IN BALL JOINT N/A - STRUT


LA

ND

RO

VE

R

Defender 1993-97 N/A - KINGPIN WITH BUSHINGS N/A - KINGPIN WITH BUSHINGS

Discovery 1996-2004 BJP1-11A BJP1-8A BJP1-3A BJP1-13B BJP1-3A BJP1-8A BJP1-5A BJP1-12A

Freelander 2002-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

LR2 2008-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

LR3 2005-2009 BJP1-12A BJP1-8A BJP1-5A BJP1-14A BJP1-7A BJP1-8A BJP1-5A BJP1-13A/ BJP1-13B

LR4 2010-2013 BJP1-12A BJP1-8A BJP1-5A BJP1-14A BJP1-7A BJP1-8A BJP1-5A BJP1-13A/ BJP1-13B

Range Rover 2003-2012 N/A - CONTROL ARM REPLACE N/A - BOLT IN BALL JOINT


Range Rover Evoque


Range Rover Sport

2006-2013 BJP1-12A BJP1-8A BJP1-5A BJP1-14A BJP1-7A BJP1-8A BJP1-5A BJP1-13A/ BJP1-13B

LE

XU

S

CT200 2011 N/A - CONTROL ARM REPLACE N/A - STRUT

ES Models 1990-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

GS Models 1993-2011 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

GX Models

2010-2012 N/A - CONTROL ARM REPLACE BJP1-7A BJP1-11A BJP1-5A BJP1-13A/ BJP1-13B


HS250 2010-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

IS Models 2001-2013 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE


ZBJP1B rev B 06/11/2014 30

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

LE

XU

S LS Models 1990-2012 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

LX Models 2008-2011 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE


RX Models 1999-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

SC Models 1992-2010 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

LIN

CO

LN

Aviator 2003-2005 BJP1-27A Not


Blackwood 2002 BJP1-12A BJP1-8A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

Continental 1995-2002 BJP1-7A

BJP1-11A & BJP1-6A

BJP1-5A & BJP1-6A



Mark LT 2006-2008 BJP1-12A BJP1-16A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

Mark VII 1990-98 BJP1-8A BJP1-11A BJP1-5A BJP1-12A N/A - CONTROL ARM REPLACE

MKS 2009-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

MKT 2010-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

MKX 2007-2013 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

MKZ 2013 N/A - CONTROL ARM REPLACE N/A - STRUT


Navigator




Town Car


2003-2006

Stamped Arm BJP1-24A Not


BJP1-24A & BJP1-6A

BJP1-5A BJP1-12A

Forged Arm BJP1-24A Not


BJP1-24A & BJP1-6A

BJP1-5A BJP1-11A




Zephyr 2006 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-11A BJP1-5A BJP1-11A

MA

ZD

A

MAZDA2 2011-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

MAZDA3


2004-2009 BJP1-22A Not


MAZDA5 2006-2013 BJP1-22A Not


MAZDA6 2009-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE



626 1988-2002 BJP1-22A Not


929 1992-95 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE



ZBJP1B rev B 06/11/2014 31

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

MA

ZD

A

B Series Trucks


1998-2002

Coil Spring BJP1-22A Not


Torsion Bar BJP1-12A BJP1-8A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE



CX-5 2013 N/A - CONTROL ARM REPLACE N/A - STRUT

CX-7 2007-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

CX-9 2007-2012 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

Miata 1990-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Millenia 1995-2002 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

MPV 2000-2006




MX3 1992-95 N/A - BOLT IN BALL JOINT N/A - STRUT

MX6 1988-97 BJP1-22A Not


Navajo 1992-94 2WD BJP1-7A BJP1-8A BJP1-5A BJP1-11A BJP1-7A BJP1-8A BJP1-5A BJP1-11A


Protégé, Protégé 5


RX-7 1990-95 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

RX-8 2004-2011 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Tribute 2001-2011 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

ME

RC

ED

ES

BEN

Z

C-Class 2001-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

1994-2000 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

2008-2013 W216 Chassis N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

CL-Class 2000-2006 W215 Chassis BJP1-8A BJP1-7A BJP1-4A BJP1-11A &



CLK-Class 1998-2009 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

CLS-Class


2006-2011 W219 Chassis BJP1-7A BJP1-8A BJP1-4A BJP1-12A &

BJP1-6A N/A - BOLT IN BALL JOINT

Midsize &

E-Class


2003-2009 W211

Chassis

BJP1-7A BJP1-8A BJP1-4A BJP1-12A &

BJP1-6A N/A - BOLT IN BALL JOINT

4MATIC N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

1995-2002 W210 Chassis N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE

1986-95 W124 Chassis BJP1-8A BJP1-11A BJP1-5A BJP1-12A N/A - CONTROL ARM REPLACE

G-Class 2002-2012 N/A - SWIVEL BALL N/A - BOLT IN BALL JOINT

GLK-Class 2010-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

S-Class 2007-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE


ZBJP1B rev B 06/11/2014 32

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

ME

RC

ED

ES

BEN

Z S-Class

(cont.)

2000-2006 W220

Chassis

BJP1-8A BJP1-7A BJP1-4A BJP1-11A &


4MATIC N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE


SL-Class 2003-2012 R230 Chassis BJP1-8A BJP1-7A BJP1-5A BJP1-12A N/A - BOLT IN BALL JOINT

1990-2002 R129 Chassis BJP1-8A BJP1-11A BJP1-5A BJP1-12A N/A - CONTROL ARM REPLACE

SLK-Class




SLS 2011-2012 N/A - SOLD IN KNUCKLE N/A - CONTROL ARM REPLACE

Sprinter 2010-2012 BJP1-18A Not


BJP1-13A/ BJP1-13B


ME

RC

UR

Y

Capri 1991-94 N/A - BOLT IN BALL JOINT N/A - STRUT

Colony Park 1990-91 BJP1-11A BJP1-12A BJP1-6A BJP1-13A/ BJP1-13B


Cougar J999-2002 N/A - BOLT IN BALL JOINT N/A - STRUT


Grand Marquis


2003-2006 Stamped Arm BJP1-11A BJP1-8A BJP1-5A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-12A

Forged Arm BJP1-11A BJP1-8A BJP1-5A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-11A




Marauder 2003-2004 BJP1-11A BJP1-8A BJP1-5A BJP1-12A BJP1-8A BJP1-11A BJP1-5A BJP1-11A

Mariner 2005-2011 BJP1-7A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

Milan 2006-2011 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-11A BJP1-5A BJP1-11A

Montego 2005-2007 N/A - CONTROL ARM REPLACE N/A - STRUT

Monterey 2004-2007 N/A - CONTROL ARM REPLACE N/A - STRUT

Mountaineer

2006-2010 BJP1-27A Not


2002-2005 BJP1-27A Not

in BJP1 kit BJP1-12A BJP1-16A BJP1-3A BJP1-27A BJP1-7A BJP1-8 BJP1-5A BJP1-11A


Mystique 1995-2000 N/A - BOLT IN BALL JOINT N/A - STRUT

Sable


1996-2005

BJP1-7A BJP1-11A &




Topaz 1990-94 N/A - CONTROL ARM REPLACE N/A - STRUT

Tracer 1990-99 N/A - BOLT IN BALL JOINT N/A - STRUT

Villager 1993-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

MIN

I

Cooper 2002-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Cooper Countryman



ZBJP1B rev B 06/11/2014 33

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

MIT

SU

BIS

HI

3000GT & VR-4



Diamante 1997-2004 BJP1-7A

BJP1-8A & BJP1-6A



Eclipse


2000-2005 BJP1-22A Not




Endeavor 2004-2011 N/A - CONTROL ARM REPLACE N/A - STRUT

Expo 1992-95 N/A - CONTROL ARM REPLACE N/A - STRUT

Galant


1999-2003 BJP1-22A Not




Lancer 2007-2013 N/A - CONTROL ARM REPLACE N/A - STRUT


Mirage 1997-2002 N/A - CONTROL ARM REPLACE N/A - STRUT


Montero 1991-2000 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Montero Sport


Outlander 2003-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Outlander Sport


Precis 1987-94 N/A - BOLT IN BALL JOINT N/A - STRUT

Raider 2006-2009 BJP1-12A BJP1-8A BJP1-3A BJP1-14A N/A - CONTROL ARM REPLACE

NIS

SA

N

200SX 1995-98 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

240SX 1995-98




300ZX 1992-96 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - CONTROL ARM REPLACE

350Z 2003-2009 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

370Z 2009-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Altima



1993-97 BJP1-22A Not


Armada 2005-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Cube 2009-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Frontier 2005-2013 BJP1-11A BJP1-8A BJP1-6A BJP1-13B BJP1-7A BJP1-11A BJP1-6A BJP1-12A



ZBJP1B rev B 06/11/2014 34

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

NIS

SA

N

GT-R 2009-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Juke 2011-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Leaf 2011-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Maxima



1995-99 BJP1-22A Not



Murano 2009-2013 N/A - CONTROL ARM REPLACE N/A - STRUT


NV1500 2012-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

NV200 2013 N/A - CONTROL ARM REPLACE N/A - STRUT



NX 1991-93 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

Pathfinder




Quest




Rogue 2008-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Sentra



1985-90 BJP1-22A Not


Titan 2004-2013 BJP1-11A BJP1-8A BJP1-6A BJP1-13B BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Versa 2007-2012 BJP1-22A Not


Xterra 2005-2013 BJP1-11A BJP1-8A BJP1-6A BJP1-13B BJP1-7A BJP1-11A BJP1-6A BJP1-12A


OLD

SM

OB

ILE

Achieva 1992-98 N/A - BOLT IN BALL JOINT N/A - STRUT

Alero 1999-2004 N/A - BOLT IN BALL JOINT N/A - STRUT

Aurora 1995-2003 N/A - BOLT IN BALL JOINT N/A - STRUT

Bravada 2002-2004 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-8A BJP1-5A BJP1-11A


Cutlass, Ciera

1990-99


Eighty-Eight 1986-99 N/A - BOLT IN BALL JOINT N/A - STRUT

Intrigue 1998-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

Ninety-Eight 1991-96 N/A - BOLT IN BALL JOINT N/A - STRUT

Regency 1997-98 N/A - BOLT IN BALL JOINT N/A - STRUT

Silhouette 1990-2004 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

Tornado 1990-92 N/A - BOLT IN BALL JOINT N/A - STRUT


ZBJP1B rev B 06/11/2014 35

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

PLY

MO

UT

H

Acclaim 1989-95 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT

Breeze 1996-2000 N/A - CONTROL ARM REPLACE BJP1-3A BJP1-7A BJP1-5A BJP1-11


Laser 1990-94 BJP1-7A BJP1-8A BJP1-5A BJP1-11A N/A - STRUT

Grand Voyager




Prowler 1997-2001 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Sundance 1991-94 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT


Voyager 1991-2000 BJP1-3A BJP1-7A BJP1-5A BJP1-11A N/A - STRUT


PO

NT

IA

C


Aztek 2001-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Bonneville 2000-2005 N/A - BOLT IN BALL JOINT N/A - STRUT


Firebird 1990-2002



G3 Wave 2005-2009 N/A - BOLT IN BALL JOINT N/A - STRUT

G5 2007-2009 N/A - BOLT IN BALL JOINT N/A - STRUT

G6 2005-2010 N/A - CONTROL ARM REPLACE N/A - STRUT

G8 2008-2009 N/A - CONTROL ARM REPLACE N/A - STRUT

Grand Am 1985-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Grand Prix 1988-2008 N/A - BOLT IN BALL JOINT N/A - STRUT

GTO 2004-2006 N/A - CONTROL ARM REPLACE N/A - STRUT

LeMans 1990-1993 N/A - BOLT IN BALL JOINT N/A - STRUT

Montana 1999-2006 N/A - BOLT IN BALL JOINT N/A - STRUT

Pursuit 2005-2006 N/A - BOLT IN BALL JOINT N/A - STRUT

Solstice 2006-2009


N/A - CONTROL ARM REPLACE

Sunbird 1985-94 N/A - BOLT IN BALL JOINT N/A - STRUT

Sunfire 1995-2005 N/A - BOLT IN BALL JOINT N/A - STRUT

Torrent 2006-2009 N/A - BOLT IN BALL JOINT N/A - STRUT

Transport 1990-98 N/A - BOLT IN BALL JOINT N/A - STRUT

Vibe 2003-2010 N/A - BOLT IN BALL JOINT N/A - STRUT

PO

RS

CH

E


928 1990-95 N/A - BOLT IN BALL JOINT N/A - CONTROL ARM REPLACE



Boxster 1997-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Cayenne 2003-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE

Cayman 2006-2008 N/A - CONTROL ARM REPLACE N/A - STRUT

Panamera 2010-2013 N/A - CONTROL ARM REPLACE N/A - CONTROL ARM REPLACE


ZBJP1B rev B 06/11/2014 36

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

RA

M

C/V 2012-13 BJP1-11A BJP1-12A BJP1-5A BJP1-13A/ BJP1-13B

N/A - STRUT

Dakota 2011 BJP1-12A BJP1-16A BJP1-5A BJP1-14A N/A - CONTROL ARM REPLACE

1500 2011-13 N/A - CONTROL ARM REPLACE BJP1-8A BJP1-11A BJP1-5A BJP1-12A

2500 2011-13

4WD BJP1-28A Not

in BJP1 kit




BJP1-11A BJP1-28A



3500 2011-13

4WD BJP1-28A Not

in BJP1 kit




BJP1-11A BJP1-28A



SA

AB



9-2X 2005-2006 BJR1 Not in

BJP1 kit BJR1 TO REMOVE BALL JOINT N/A - STRUT

9-3 1999-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

9-3X 2010-2012 N/A - CONTROL ARM REPLACE N/A - STRUT

9-4X 2011 BJP1-3A BJP1-7A BJP1-5A BJP1-11A BJP1-12A BJP1-11A BJP1-3A BJP1-13B

9-5 1999-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

9-7X 2005-2009 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-8A BJP1-5A BJP1-11A

SA

TU

RN

All 1991-2008 N/A - BOLT IN BALL JOINT OR CONTROL ARM REPLACE N/A - STRUT

SC

IO

N

FR-S 2013 N/A - CONTROL ARM REPLACE N/A - STRUT

iQ 2012-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

tC 2005-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

xA 2004-2006 BJP1-22A Not


xB


2004-2007 BJP1-22A Not


xD 2008-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

SM

AR

T

Fortwo



SU

BA

RU

Baja 2003-2006 BJR1 Not in


BRZ 2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Forester 1998-2013 BJR1 Not in

BJP1 kit BJR1 TO REMOVE BALL JOINT

N/A - STRUT

Impreza 1993-2013 N/A - STRUT

Legacy 1990-2013 N/A - STRUT


ZBJP1B rev B 06/11/2014 37

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

SU

BA

RU

Outback 1995-2013 BJR1 Not in


Tribeca 2006-2013 BJR2 Not in


SU

ZU

KI

Aerio 2002-2007 N/A - CONTROL ARM REPLACE N/A - STRUT

Equator 2009-2012 BJP1-11A BJP1-8A BJP1-6A BJP1-13B BJP1-7A BJP1-11A BJP1-6A BJP1-12A

Esteem 1995-2002 N/A - CONTROL ARM REPLACE N/A - STRUT

Forenza 2004-2007 N/A - BOLT IN BALL JOINT N/A - STRUT

Grand Vitara 1999-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Kizashi 2010-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Reno 2005-2008 N/A - BOLT IN BALL JOINT N/A - STRUT

Sidekick 1989-98 N/A - BOLT IN BALL JOINT N/A - STRUT

Swift 1995-2001 N/A - CONTROL ARM REPLACE N/A - STRUT

SX4 2007-2013 N/A - CONTROL ARM REPLACE N/A - STRUT

Verona 2004-2006 N/A - BOLT IN BALL JOINT N/A - STRUT

Vitara 1999-2004 N/A - CONTROL ARM REPLACE N/A - STRUT

X-90 1996-98 N/A - BOLT IN BALL JOINT N/A - STRUT

XL-7 2002-2006 N/A - CONTROL ARM REPLACE N/A - STRUT

TO

YO

TA

4runner


2003-2009 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-11A BJP1-5A BJP1-13A/ BJP1-13B

1996-2002 N/A - BOLT IN BALL JOINT BJP1-7A BJP1-8A BJP1-5A BJP1-11A

Avalon 1995-2012 N/A - BOLT IN BALL JOINT N/A – STRUT

Camry 1992-2013 N/A - BOLT IN BALL JOINT N/A – STRUT

Celica 1986-2005 N/A - BOLT IN BALL JOINT N/A – STRUT

Corolla 1989-2013 N/A - BOLT IN BALL JOINT N/A – STRUT

Echo 2000-2005 BJP1-22A Not

in BJP1 kit BJP1-3A BJP1-7A BJP1-5A BJP1-22A N/A – STRUT

FJ Cruiser


2007-2009 BJP1-12A BJP1-11A BJP1-3A BJP1-13B BJP1-7A BJP1-11A BJP1-5A BJP1-13A/ BJP1-13B

Highlander 2001-2013 N/A - BOLT IN BALL JOINT N/A – STRUT

Landcruiser 2008-2013 BJP1-12A BJP1-16A BJP1-7A BJP1-14A N/A - CONTROL ARM REPLACE


Matrix 2003-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

MR2 2000-2005 N/A - BOLT IN BALL JOINT N/A - STRUT


Paseo 1992-99 N/A - BOLT IN BALL JOINT N/A - STRUT

Prius 2001-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Prius V 2012 N/A - BOLT IN BALL JOINT N/A - STRUT

RAV4 2001-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Sequoia




ZBJP1B rev B 06/11/2014 38

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

TO

YO

TA

Sequoia (cont.)


Sienna 1998-2013 N/A - BOLT IN BALL JOINT N/A – STRUT

Solara 1999-2008 N/A - BOLT IN BALL JOINT N/A – STRUT

Tacoma

2005-2013 BJP1-22A Not

in BJP1 kit BJP1-12A BJP1-11A BJP1-3A BJP1-14A BJP1-7A BJP1-22A BJP1-5A

BJP1-13A/ BJP1-13B



Tundra




Venza 2009-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Yaris


2007-2008 BJP1-22A Not


VO

LK

SW

AG

ON

Beetle 1998-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Cabrio 1995-2002 N/A - BOLT IN BALL JOINT N/A - STRUT

CC 2009-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

EOS 2007-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Eurovan 1993-2003 N/A - BOLT IN BALL JOINT BJP1-11A BJP1-8A BJP1-3A BJP1-12A

Golf 1995-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

GTI 2006-2012 N/A - BOLT IN BALL JOINT N/A - STRUT

Jetta 1995-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Passat 2001-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Phaeton 2004-2006 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

R32 2009 N/A - BOLT IN BALL JOINT N/A - STRUT

Rabbit 2006-2009 N/A - BOLT IN BALL JOINT N/A - STRUT

Routan 2009-2012 BJP1-6A BJP1-11A BJP1-6A BJP1-14A N/A - STRUT

Tiguan 2009-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

Touareg 2004-2013 N/A - BOLT IN BALL JOINT N/A - BOLT IN BALL JOINT

VO

LV

O

240 Series 1975-93 N/A - BOLT IN BALL JOINT N/A - STRUT







C30 2006-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

C70 1998-2013 N/A - BOLT IN BALL JOINT N/A - STRUT

S40 2005-2011 N/A - BOLT IN BALL JOINT N/A - STRUT






ZBJP1B rev B 06/11/2014 39

MODEL ADDITIONAL

INFORMATION


Install ram Install

receiver Remove

ram Remove receiver

Install ram Install

receiver Remove

ram Remove receiver

VO

LV

O


V40 2000-2004 BJP1-3A BJP1-11A BJP1-5A BJP1-11A N/A - STRUT

V50 2005-2011 N/A - BOLT IN BALL JOINT N/A - STRUT



XC60 2009-2013 N/A - BOLT IN BALL JOINT N/A - STRUT



YU

GO

GV 1986-91 N/A - CONTROL ARM REPLACE N/A - STRUT

BJP1-BALL JOINT PRESS MASTER SET · bjp1-ball joint press master set item no. part no. description...

Documents

Transcript of BJP1-BALL JOINT PRESS MASTER SET · bjp1-ball joint press master set item no. part no. description...