BATCHING Without Xref RSlogix 500

RSLogix500 Project Report

BATCHING.RSS

Processor Information

Processor Type: 1747-L532C/D 5/03 CPU - 16K Mem. OS302

Processor Name: BATCHING

Total Memory Used: *

Total Memory Left: *

Program Files: 5

Data Files: 9

Program ID: 0

BATCHING.RSS

I/O Configuration

0 1747-L532C/D 5/03 CPU - 16K Mem. OS302 1 1746-NI4 Analog 4 Channel Input Module 2 3 4 1746-I*16 Any 16pt Discrete Input Module 5 1746-O*16 Any 16pt Discrete Output Module 6 1746-O*16 Any 16pt Discrete Output Module 7 8 9 10 11 12

BATCHING.RSS

Channel Configuration

GENERAL Channel 1 Write Protected: No Channel 1 Edit Resource/Owner Timeout: 60 Channel 1 Passthru Link ID: 2

Channel 0 Write Protected: No Channel 0 Edit Resource/Owner Timeout: 60 Channel 0 Passthru Link ID: 1 Channel 0 Current Mode: System Channel 0 Mode Change Enabled: No Channel 0 Mode Change Attention Character: \1b Channel 0 Mode Change System Character: S Channel 0 Mode Change User Character: U

CHANNEL 1 (SYSTEM) - Driver: DH485 Node : 1 (decimal) Baud: 19200 Token Hold Factor: 1 Max Node Address: 31

CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex Source ID: 9 (decimal) Baud: 19200 Parity: NONE Stop Bits: 1 Control Line : No Handshaking Error Detection: CRC Embedded Responses: Enabled Duplicate Packet Detect: Yes ACK Timeout: 50 NAK Retries: 3 ENQ Retries: 3

CHANNEL 0 (USER) - Driver: ASCII Baud: 1200 Parity: NONE Stop Bits: 1 Data Bits: 8 Control Line : No Handshaking Delete mode: Ignore Echo: No XON/XOFF: No Termination Character 1: \d Termination Character 2: \ff Append Character 1: \d Append Character 2: \a

BATCHING.RSS

Program File List

Name Number Type Rungs Debug Bytes

[SYSTEM] 0 SYS 0 No 0 1 SYS 0 No 0MAIN 2 LADDER 21 No 723ANALOG 3 LADDER 4 No 84FAULTS 4 LADDER 8 No 283

BATCHING.RSS

Data File List

Name Number Type Scope Debug Words Elements Last

OUTPUT 0 O Global No 6 2 O:1INPUT 1 I Global No 15 5 I:4STATUS 2 S Global No 0 83 S:82BINARY 3 B Global No 4 4 B3:3TIMER 4 T Global No 48 16 T4:15COUNTER 5 C Global No 48 16 C5:15CONTROL 6 R Global No 3 1 R6:0INTEGER 7 N Global No 16 16 N7:15FLOAT 8 F Global No 2 1 F8:0

BATCHING.RSS

LAD 2 - MAIN --- Total Rungs in File = 21

0000JSR

Jump To SubroutineSBR File Number U:3

JSR

Mixing Tank Scalesand Level Sensor

0001I:4.0/15

1746-I*16

E-STOPClearedPB3

B3:0/1

SystemFault

B3:0/0

SystemEnable

0002B3:0/0

SystemEnable

I:4.0/0

1746-I*16

Start BatchPB1

B3:0/2

SystemBatching

I:4.0/1

1746-I*16

Stop BatchPB2

B3:0/3

BatchComplete

B3:0/2

SystemBatching

0003B3:0/0

SystemEnable

B3:0/2

SystemBatching

B3:0/4

SystemReady

O:5.0/0

1746-O*16

System ReadyPL1

0004B3:0/2

SystemBatching

I:4.0/0

1746-I*16

Start BatchPB1

B3:0/11

BatchStep 2

B3:0/12

BatchStep 3

B3:0/13

BatchStep 4

B3:0/14

BatchStep 5

LB3:0/10

BatchStep 1

0005B3:0/2

SystemBatching

B3:0/10

BatchStep 1

LEQLess Than or Eql (A<=B)Source A N7:0 0<Source B 1275 1275<

LEQ

Weight ofMixing Tank(lbs.)

O:5.0/1

1746-O*16

OpenCity WaterValveAV-CW

O:5.0/2

1746-O*16

AddingWaterPL3

BATCHING.RSS


0006B3:0/10

BatchStep 1

GEQGrtr Than or Eql (A>=B)Source A N7:0 0<Source B 1275 1275<

GEQ


UB3:0/10

BatchStep 1

LB3:0/11

BatchStep 2

0007B3:0/2

SystemBatching

B3:0/11

BatchStep 2


LEQ


O:5.0/3

1746-O*16

OpenQR ValveAV-QR

0008O:5.0/3

1746-O*16

OpenQR ValveAV-QR

I:4.0/4

1746-I*16

QR ValveAV-QRClosedLS-QR1

I:4.0/5

1746-I*16

QR ValveAV-QROpenLS-QR2

O:5.0/4

1746-O*16

RunQR PumpPUMP-QR

O:5.0/5

1746-O*16

AddingQRPL4

0009B3:0/11

BatchStep 2


GEQ


UB3:0/11

BatchStep 2

LB3:0/12

BatchStep 3

0010B3:0/2

SystemBatching

B3:0/12

BatchStep 3


LEQ


O:5.0/6

1746-O*16

OpenKM ValveAV-KM

BATCHING.RSS


0011O:5.0/6

1746-O*16

OpenKM ValveAV-KM

I:4.0/6

1746-I*16

KM ValveAV-KMClosedLS-KM1

I:4.0/7

1746-I*16

KM ValveAV-KMOpenLS-KM2

O:5.0/7

1746-O*16

RunKM PumpPUMP-KM

O:5.0/8

1746-O*16

AddingKMPL5

0012B3:0/12

BatchStep 3


GEQ


UB3:0/12

BatchStep 3

LB3:0/13

BatchStep 4

0013B3:0/2

SystemBatching

B3:0/13

BatchStep 4

EN

DN

TONTimer On DelayTimer T4:0Time Base 1.0Preset 180<Accum 0<

TON

AgitatorRun Time

0014T4:0/EN

AgitatorRun Time

O:5.0/9

1746-O*16

RunMixing TankAgitatorMTR-MTA

O:5.0/10

1746-O*16

BlendingPL6

BATCHING.RSS


0015T4:0/DN

AgitatorRun Time

UB3:0/13

BatchStep 4

LB3:0/14

BatchStep 5

0016B3:0/2

SystemBatching

B3:0/14

BatchStep 5


GEQ

Liquid Level ofMixing Tank (%)

O:5.0/13

1746-O*16

OpenMixing TankValveAV-MT

0017O:5.0/13

1746-O*16


I:4.0/8

1746-I*16

Mixing TankValve AV-MTClosedLS-MT1

I:4.0/9

1746-I*16

Mixing TankValve AV-MTOpenLS-MT2

I:4.0/14

1746-I*16

Filling LineStorage TankReady

O:5.0/11

1746-O*16

RunMixing TankPumpPUMP-MT

O:5.0/12

1746-O*16

Pumping toLinesPL7

0018B3:0/14

BatchStep 5


LEQ


UB3:0/14

BatchStep 5

B3:0/3

BatchComplete

0019JSR

Jump To SubroutineSBR File Number U:4

JSRFaults

0020 END

BATCHING.RSS

LAD 3 - ANALOG - Mixing Tank Scales and Level Sensor --- Total Rungs in File = 4

0000SCP

Scale w/ParametersInput I:1.0 0<Input Min. 0 0<Input Max. 16384 16384<Scaled Min. 0 0<Scaled Max. 2000 2000<Output N7:0 0<

SCP


0001SCP

Scale w/ParametersInput I:1.1 0<Input Min. 0 0<Input Max. 16384 16384<Scaled Min. 0 0<Scaled Max. 100 100<Output N7:1 0<

SCP


0002RET

ReturnRET

0003 END

BATCHING.RSS

LAD 4 - FAULTS - System Faults --- Total Rungs in File = 8

0000O:5.0/1

1746-O*16


I:4.0/3

1746-I*16

City WaterValve AV-CWOpenLS-CW2

O:5.0/1

1746-O*16


I:4.0/2

1746-I*16

City WaterValve AV-CWClosedLS-CW1

EN

DN


TON

ValveAV-CWFault

0001O:5.0/3

1746-O*16

OpenQR ValveAV-QR

I:4.0/5

1746-I*16

QR ValveAV-QROpenLS-QR2

O:5.0/3

1746-O*16

OpenQR ValveAV-QR

I:4.0/4

1746-I*16

QR ValveAV-QRClosedLS-QR1

EN

DN


TON

ValveAV-QRFault

0002O:5.0/6

1746-O*16

OpenKM ValveAV-KM

I:4.0/7

1746-I*16

KM ValveAV-KMOpenLS-KM2

O:5.0/6

1746-O*16

OpenKM ValveAV-KM

I:4.0/6

1746-I*16

KM ValveAV-KMClosedLS-KM1

EN

DN


TON

ValveAV-KMFault

BATCHING.RSS


0003O:5.0/13

1746-O*16


I:4.0/9

1746-I*16

Mixing TankValve AV-MTOpenLS-MT2

O:5.0/13

1746-O*16


I:4.0/8

1746-I*16

Mixing TankValve AV-MTClosedLS-MT1

EN

DN


TON

ValveAV-MTFault

0004T4:1/DN

ValveAV-CWFault

T4:2/DN

ValveAV-QRFault

T4:3/DN

ValveAV-KMFault

T4:4/DN

ValveAV-MTFault

GRTGreater Than (A>B)Source A N7:1 0<Source B 95 95<

GRT


B3:0/15

B3:0/1

SystemFault

BATCHING.RSS


0005B3:0/1

SystemFault

O:5.0/15

1746-O*16

SystemFaultPL2

I:4.0/1

1746-I*16

Stop BatchPB2

O:5.0/15

1746-O*16

SystemFaultPL2

0006RET

ReturnRET

0007 END

BATCHING.RSS

Data File O0 (bin) -- OUTPUT

Offset 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0

O:5.0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1 1746-O*16 - Any 16pt Discrete Output ModuleO:6.0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1746-O*16 - Any 16pt Discrete Output Module

BATCHING.RSS

Data File I1 (bin) -- INPUT

Offset 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0

I:1.0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1746-NI4 - Analog 4 Channel Input ModuleI:1.1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1746-NI4 - Analog 4 Channel Input ModuleI:1.2 0 0 0 0 0 0 1 1 1 1 0 0 1 0 1 1 1746-NI4 - Analog 4 Channel Input ModuleI:1.3 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1746-NI4 - Analog 4 Channel Input ModuleI:4.0 1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1746-I*16 - Any 16pt Discrete Input Module

BATCHING.RSS

Data File S2 (hex) -- STATUS

Main

First Pass S:1/15 = NoIndex Register S:24 = 0Free Running Clock S:4 = 1101-1000-1010-1101Index Across Data Files S:2/3 = NoCIF Addressing Mode S:2/8 = 0Online Edits S:33/11 - S:33/12 = No online edits exist

DD / MM / YYYYDate S:39-37 = 18 / 2 / 2006

HH : MM : SSTime S:40-42 = 13 : 36 : 8

Proc

OS Catalog Number S:57 = 302OS Series S:58 = AOS FRS S:59 = 9Processor Catalog Number S:60 = 532Processor Series S:61 = DProcessor FRN S:62 = 4

User Program Type S:63 = 1User Program Functionality Index S:64 = 65User RAM Size S:66 = 16OS Memory Size S:66 = 480

Scan Times

Maximum (x10 ms) S:22 = 1Average (x10 ms) S:23 = 0Current (x10 ms) S:3 (low byte) = 1Watchdog (x10 ms) S:3 (high byte) = 10Last 1ms Scan Time S:35 = 2Scan Toggle Bit S:33/9 = 1Time Base Selection S:33/13 = 0

Math

Math Overflow Selected S:2/14 = 0Overflow Trap S:5/0 = 0Carry S:0/0 = 0Overflow S:0/1 = 0Zero Bit S:0/2 = 1Sign Bit S:0/3 = 0

Math Register (lo word) S:13 = 0Math Register (high word) S:14-S:13 = 0Math Register (32 Bit) S:14-S:13 = 0

IO

I/O Interrupt Executing S:32 = 0 Interrrupt Latency Control S:33/8 = 0Event Interrupt 10 uS Time Stamp S:44 = 0

I/O Slot Enables: S:11 S:120 10 20 3011111111 11111111 11111111 11111111

I/O Slot Interrupt Enables: S:27 S:280 10 20 3011111111 11111111 11111111 11111111

I/O Slot Interrupt Pending: S:25 S:260 10 20 3000000000 00000000 00000000 00000000

Chan 0

Processor Mode S:1/0- S:1/4 = Remote RunChannel Mode S:33/3 = 1Comms Active S:33/4 = 0Incoming Cmd Pending S:33/0 = 0Msg Reply Pending S:33/1 = 0

DTR Control Bit S:33/14 = 0DTR Force Bit S:33/15 = 0Outgoing Msg Cmd Pending S:33/2 = 0Comms Servicing Sel S:33/5 = 0Msg Servicing Sel S:33/6 = 0Modem Lost S:5/14 = 1

BATCHING.RSS


Ch 0 Nodes

DF1 Half-Duplex Master Channel 0 Active Node Table (S:67-S:82):

Node 0 16 0 0000-0000-0000-0000 0000-0000-0000-0000 32 0000-0000-0000-0000 0000-0000-0000-0000 64 0000-0000-0000-0000 0000-0000-0000-0000 96 0000-0000-0000-0000 0000-0000-0000-0000 128 0000-0000-0000-0000 0000-0000-0000-0000 160 0000-0000-0000-0000 0000-0000-0000-0000 192 0000-0000-0000-0000 0000-0000-0000-0000 224 0000-0000-0000-0000 0000-0000-0000-0000

Chan 1

Processor Mode S:1/0- S:1/4 = Remote RunNode Address S:15 (low byte) = 1 Baud Rate S:15 (high byte) = 19200Comms Active S:1/7 = 0Incoming Cmd Pending S:2/5 = 0Msg Reply Pending S:2/6 = 0

Active Nodes: S:9 S:10

Outgoing Msg Cmd Pending S:2/7 = 0Comms Servicing Sel S:2/15 = 1Msg Servicing Sel S:33/7 = 0

0 10 20 3001000000 00000000 00000000 00000000

Debug

Suspend Code S:7 = 0Suspend File S:8 = 0Compiled For Single Step S:2/4 = Yes

Fault/PowerdownFault/Powerdown (Rung #) S:20 = 20(File #) S:21 = 2

Test Single Step BreakpointRung # S:18 = 0File # S:19 = 0

Test Single StepRung # S:16 = 0File # S:17 = 2

Errors

Fault Override At Power Up S:1/8 = 0Startup Protection Fault S:1/9 = 0Major Error Halt S:1/13 = 0Overflow Trap S:5/0 = 0Control Register Error S:5/2 = 0Major Error Executing User Fault Rtn. S:5/3 = 0M0/M1 Referenced On Disabled Slot S:5/4 = 0Battery Low S:5/11 = 0Fault/Powerdown (Rung #) S:20 = 20(File #) S:21 = 2

ASCII String Manipulation error S:5/15 = 0Fault Routine S:29 = 0Major Error S:6 = 0h

Error Description:

STI

Setpoint (x10ms) S:30 = 0File Number S:31 = 010 uS Time Stamp S:43 = 0Pending Bit S:2/0 = 0Enable Bit S:2/1 = 1

Resolution Select Bit S:2/10 = 0Executing Bit S:2/2 = 0Overflow Bit S:5/10 = 0Lost S:36/9 = 0Interrrupt Latency Control S:33/8 = 0

BATCHING.RSS


DII

Preset S:50 = 0Accumulator S:52 = 0Pending Bit S:2/11 = 0Enable Bit S:2/12 = 1Executing Bit S:2/13 = 0Reconfiguration Bit S:33/10 = 0Overflow Bit S:5/12 = 0Lost S:36/8 = 010 uS Time Stamp S:45 = 0

File Number S:46 = 0Slot Number S:47 = 0Bit Mask S:48 = 0hCompare Value S:49 = 0hReturn Mask S:51 = 0hLast Scan Time (x1 ms) S:55 = 0Max Observed Scan Time (x1 ms) S:56 = 0Interrrupt Latency Control S:33/8 = 0

Protection

Deny Future Access S:1/14 = No

Mem Module

Memory Module Loaded On Boot S:5/8 = 0Password Mismatch S:5/9 = 0Load Memory Module On Memory Error S:1/10 = 0Load Memory Module Always S:1/11 = 0Load Memory Module and RUN S:1/12 = 0Program Compare S:2/9 = 0Data File Overwrite Protection Lost S:36/10 = 0

Forces

Forces Enabled S:1/5 = NoForces Installed S:1/6 = No

BATCHING.RSS

Data File B3 (bin) -- BINARY

Offset 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0 (Symbol) Description

B3:0 0 0 0 0 0 0 0 0 0 0 0 1 0 0 0 1 B3:1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 B3:2 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 B3:3 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

BATCHING.RSS

Data File T4 -- TIMER

Offset EN TT DN BASE PRE ACC (Symbol) Description

T4:0 0 0 0 1.0 sec 180 0 Agitator Run Time T4:1 1 0 1 1.0 sec 1 1 Valve AV-CW Fault T4:2 1 0 1 1.0 sec 2 2 Valve AV-QR Fault T4:3 1 0 1 1.0 sec 2 2 Valve AV-KM Fault T4:4 1 0 1 1.0 sec 2 2 Valve AV-MT Fault T4:5 0 0 0 .01 sec 0 0 T4:6 0 0 0 .01 sec 0 0 T4:7 0 0 0 .01 sec 0 0 T4:8 0 0 0 .01 sec 0 0 T4:9 0 0 0 .01 sec 0 0 T4:10 1 1 0 .01 sec 200 40 T4:11 0 0 0 .01 sec 0 0 T4:12 0 0 0 .01 sec 0 0 T4:13 0 0 0 .01 sec 0 0 T4:14 0 0 0 .01 sec 0 0 T4:15 0 0 0 .01 sec 0 0

BATCHING.RSS

Data File C5 -- COUNTER

Offset CU CD DN OV UN UA PRE ACC (Symbol) Description

C5:0 0 0 0 0 0 0 0 0 C5:1 0 0 0 0 0 0 0 0 C5:2 0 0 0 0 0 0 0 0 C5:3 0 0 0 0 0 0 0 0 C5:4 0 0 0 0 0 0 0 0 C5:5 0 0 0 0 0 0 0 0 C5:6 0 0 0 0 0 0 0 0 C5:7 0 0 0 0 0 0 0 0 C5:8 0 0 0 0 0 0 0 0 C5:9 0 0 0 0 0 0 0 0 C5:10 0 0 0 0 0 0 0 0 C5:11 0 0 0 0 0 0 0 0 C5:12 0 0 0 0 0 0 0 0 C5:13 0 0 0 0 0 0 0 0 C5:14 0 0 0 0 0 0 0 0 C5:15 0 0 0 0 0 0 0 0

BATCHING.RSS

Data File R6 -- CONTROL

Offset EN EU DN EM ER UL IN FD LEN POS (Symbol) Description

R6:0 0 0 0 0 0 0 0 0 0 0

BATCHING.RSS

Data File N7 (dec) -- INTEGER

Offset 0 1 2 3 4 5 6 7 8 9

N7:0 0 0 11 0 0 0 0 0 0 0 N7:10 0 0 0 0 0 0

BATCHING.RSS

Data File F8 -- FLOAT

Offset 0 1 2 3 4

F8:0 0

BATCHING.RSS

CDM 0 - Untitled

Address (Symbol) = Value [Description]

BATCHING.RSS

Data File O0 -- OUTPUT Usage

Offset FW 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0

O:5.0 X . X X X X X X X X X X X X X X 1746-O*16 - Any 16pt Discrete Output ModulO:6.0 . . . . . . . . . . . . . . . . 1746-O*16 - Any 16pt Discrete Output Modul

BATCHING.RSS

Data File I1 -- INPUT Usage

Offset FW 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0

I:1.0 W . . . . . . . . . . . . . . . . 1746-NI4 - Analog 4 Channel Input ModuleI:1.1 W . . . . . . . . . . . . . . . . 1746-NI4 - Analog 4 Channel Input ModuleI:1.2 . . . . . . . . . . . . . . . . 1746-NI4 - Analog 4 Channel Input ModuleI:1.3 . . . . . . . . . . . . . . . . 1746-NI4 - Analog 4 Channel Input ModuleI:4.0 X X . . . . X X X X X X X X X X 1746-I*16 - Any 16pt Discrete Input Module

BATCHING.RSS

Data File S2 -- STATUS Usage

Offset 0 1 2 3 4 5 6 7 8 9

S:0 . . . . . . . . . . S:10 . . . . . . . . . . S:20 . . . . . . . . . . S:30 . . . . . . . . . . S:40 . . . . . . . . . . S:50 . . . . . . . . . . S:60 . . . . . . . . . . S:70 . . . . . . . . . . S:80 . . .

BATCHING.RSS

Data File B3 -- BINARY Usage

Offset FW 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0 (Symbol) Description

B3:0 X X X X X X . . . . . X X X X X B3:1 . . . . . . . . . . . . . . . . B3:2 . . . . . . . . . . . . . . . . B3:3 . . . . . . . . . . . . . . . .

BATCHING.RSS

Data File T4 -- TIMER Usage

Offset FW EN TT DN BASE PRE ACC (Symbol) Description

T4:0 W X . X . . . Agitator Run Time T4:1 W . . X . . . Valve AV-CW Fault T4:2 W . . X . . . Valve AV-QR Fault T4:3 W . . X . . . Valve AV-KM Fault T4:4 W . . X . . . Valve AV-MT Fault T4:5 . . . . . . T4:6 . . . . . . T4:7 . . . . . . T4:8 . . . . . . T4:9 . . . . . . T4:10 . . . . . . T4:11 . . . . . . T4:12 . . . . . . T4:13 . . . . . . T4:14 . . . . . . T4:15 . . . . . .

BATCHING.RSS

Data File C5 -- COUNTER Usage

Offset FW CU CD DN OV UN UA PRE ACC (Symbol) Description

C5:0 . . . . . . . . C5:1 . . . . . . . . C5:2 . . . . . . . . C5:3 . . . . . . . . C5:4 . . . . . . . . C5:5 . . . . . . . . C5:6 . . . . . . . . C5:7 . . . . . . . . C5:8 . . . . . . . . C5:9 . . . . . . . . C5:10 . . . . . . . . C5:11 . . . . . . . . C5:12 . . . . . . . . C5:13 . . . . . . . . C5:14 . . . . . . . . C5:15 . . . . . . . .

BATCHING.RSS

Data File R6 -- CONTROL Usage

Offset FW EN EU DN EM ER UL IN FD LEN POS (Symbol) Description

R6:0 . . . . . . . . . .

BATCHING.RSS

Data File N7 -- INTEGER Usage

Offset 0 1 2 3 4 5 6 7 8 9

N7:0 X X . . . . . . . . N7:10 . . . . . .

BATCHING.RSS

Data File F8 -- FLOAT Usage

Offset 0 1 2 3 4

F8:0 .

BATCHING.RSS

Address/Symbol Database

Address Symbol Scope Description Sym Group Dev. Code ABV BLW

B3:0/0 System Enable B3:0/1 System Fault B3:0/2 System Batching B3:0/3 Batch Complete B3:0/4 System Ready B3:0/10 Batch Step 1 B3:0/11 Batch Step 2 B3:0/12 Batch Step 3 B3:0/13 Batch Step 4 B3:0/14 Batch Step 5 B3:0/15B3:1/0B3:1/1B3:1/15I:1.0 Liquid Weight in Mixing Tank Scales SC-1 I:1/0I:1.1 Liquid Level in Mixing Tank ULS-1 I:4/0 Start Batch PB1 I:4/1 Stop Batch PB2 I:4/2 City Water Valve AV-CW Closed LS-CW1 I:4/3 City Water Valve AV-CW Open LS-CW2 I:4/4 QR Valve AV-QR Closed LS-QR1 I:4/5 QR Valve AV-QR Open LS-QR2 I:4/6 KM Valve AV-KM Closed LS-KM1 I:4/7 KM Valve AV-KM Open LS-KM2 I:4/8 Mixing Tank Valve AV-MT Closed LS-MT1 I:4/9 Mixing Tank Valve AV-MT Open LS-MT2 I:4/14 Filling Line Storage Tank Ready I:4/15 E-STOP Cleared PB3 N7:0 Weight of Mixing Tank (lbs.) N7:1 Liquid Level of Mixing Tank (%) N7:2O:5/0 System Ready PL1 O:5/1 Open City Water Valve AV-CW O:5/2 Adding Water PL3 O:5/3 Open QR Valve AV-QR O:5/4 Run QR Pump PUMP-QR O:5/5 Adding QR PL4 O:5/6 Open KM Valve AV-KM O:5/7 Run KM Pump PUMP-KM O:5/8 Adding KM PL5 O:5/9 Run Mixing Tank Agitator MTR-MTA O:5/10 Blending PL6 O:5/11 Run Mixing Tank Pump PUMP-MT O:5/12 Pumping to Lines PL7 O:5/13 Open Mixing Tank Valve AV-MT O:5/15 System Fault PL2 S:0 Arithmetic Flags S:0/0 Processor Arithmetic Carry Flag S:0/1 Processor Arithmetic Underflow/ Overflow Flag S:0/2 Processor Arithmetic Zero Flag S:0/3 Processor Arithmetic Sign Flag S:1 Processor Mode Status/ Control S:1/0 Processor Mode Bit 0 S:1/1 Processor Mode Bit 1 S:1/2 Processor Mode Bit 2 S:1/3 Processor Mode Bit 3 S:1/4 Processor Mode Bit 4 S:1/5 Forces Enabled S:1/6 Forces Present S:1/7 Comms Active S:1/8 Fault Override at Powerup S:1/9 Startup Protection Fault S:1/10 Load Memory Module on Memory Error S:1/11 Load Memory Module Always S:1/12 Load Memory Module and RUN S:1/13 Major Error Halted S:1/14 Access Denied S:1/15 First Pass S:2/0 STI Pending S:2/1 STI Enabled S:2/2 STI Executing S:2/3 Index Addressing File Range S:2/4 Saved with Debug Single Step S:2/5 DH-485 Incoming Command Pending S:2/6 DH-485 Message Reply Pending S:2/7 DH-485 Outgoing Message Command Pending S:2/15 Comms Servicing Selection S:3 Current Scan Time/ Watchdog Scan Time S:4 Time Base S:5/0 Overflow Trap S:5/2 Control Register Error S:5/3 Major Err Detected Executing UserFault Routine S:5/4 M0-M1 Referenced on Disabled Slot S:5/8 Memory Module Boot S:5/9 Memory Module Password Mismatch S:5/10 STI Overflow

BATCHING.RSS



S:5/11 Battery Low S:6 Major Error Fault Code S:7 Suspend Code S:8 Suspend File S:9 Active Nodes S:10 Active Nodes S:11 I/O Slot Enables S:12 I/O Slot Enables S:13 Math Register S:14 Math Register S:15 Node Address/ Baud Rate S:16 Debug Single Step Rung S:17 Debug Single Step File S:18 Debug Single Step Breakpoint Rung S:19 Debug Single Step Breakpoint File S:20 Debug Fault/ Powerdown Rung S:21 Debug Fault/ Powerdown File S:22 Maximum Observed Scan Time S:23 Average Scan Time S:24 Index Register S:25 I/O Interrupt Pending S:26 I/O Interrupt Pending S:27 I/O Interrupt Enabled S:28 I/O Interrupt Enabled S:29 User Fault Routine File Number S:30 STI Setpoint S:31 STI File Number S:32 I/O Interrupt Executing S:33 Extended Proc Status Control Word S:33/0 Incoming Command Pending S:33/1 Message Reply Pending S:33/2 Outgoing Message Command Pending S:33/3 Selection Status User/DF1 S:33/4 Communicat Active S:33/5 Communicat Servicing Selection S:33/6 Message Servicing Selection Channel 0 S:33/7 Message Servicing Selection Channel 1 S:33/8 Interrupt Latency Control Flag S:33/9 Scan Toggle Flag S:33/10 Discrete Input Interrupt Reconfigur Flag S:33/11 Online Edit Status S:33/12 Online Edit Status S:33/13 Scan Time Timebase Selection S:33/14 DTR Control Bit S:33/15 DTR Force Bit S:34 Pass-thru Disabled S:34/0 Pass-Thru Disabled Flag S:34/1 DH+ Active Node Table Enable Flag S:34/2 Floating Point Math Flag Disable,Fl S:35 Last 1 ms Scan Time S:36 Extended Minor Error Bits S:36/8 DII Lost S:36/9 STI Lost S:36/10 Memory Module Data File Overwrite Protection S:37 Clock Calendar Year S:38 Clock Calendar Month S:39 Clock Calendar Day S:40 Clock Calendar Hours S:41 Clock Calendar Minutes S:42 Clock Calendar Seconds S:43 STI Interrupt Time S:44 I/O Event Interrupt Time S:45 DII Interrupt Time S:46 Discrete Input Interrupt- File Number S:47 Discrete Input Interrupt- Slot Number S:48 Discrete Input Interrupt- Bit Mask S:49 Discrete Input Interrupt- Compare Value S:50 Processor Catalog Number S:51 Discrete Input Interrupt- Return Number S:52 Discrete Input Interrupt- Accumulat S:53 Reserved/ Clock Calendar Day of the Week S:55 Last DII Scan Time S:56 Maximum Observed DII Scan Time S:57 Operating System Catalog Number S:58 Operating System Series S:59 Operating System FRN S:61 Processor Series S:62 Processor Revision S:63 User Program Type S:64 User Program Functional Index S:65 User RAM Size S:66 Flash EEPROM Size S:67 Channel 0 Active Nodes S:68 Channel 0 Active Nodes S:69 Channel 0 Active Nodes S:70 Channel 0 Active Nodes S:71 Channel 0 Active Nodes

BATCHING.RSS



S:72 Channel 0 Active Nodes S:73 Channel 0 Active Nodes S:74 Channel 0 Active Nodes S:75 Channel 0 Active Nodes S:76 Channel 0 Active Nodes S:77 Channel 0 Active Nodes S:78 Channel 0 Active Nodes S:79 Channel 0 Active Nodes S:80 Channel 0 Active Nodes S:81 Channel 0 Active Nodes S:82 Channel 0 Active Nodes S:83 DH+ Active Nodes S:84 DH+ Active Nodes S:85 DH+ Active Nodes S:86 DH+ Active Nodes T4:0 Agitator Run Time T4:1 Valve AV-CW Fault T4:1/DNT4:2 Valve AV-QR Fault T4:3 Valve AV-KM Fault T4:4 Valve AV-MT Fault T4:10T4:15T4:15/DNU:3 Mixing Tank Scales and Level Sensor U:4 Faults

BATCHING.RSS

Instruction Comment Database

Address Instruction Description

BATCHING.RSS

Symbol Group Database

Group_Name Description

BATCHING Without Xref RSlogix 500

Documents

Transcript of BATCHING Without Xref RSlogix 500