AUTOMATIC TRANSMISSION F4A41, F4A42, F4A51 - | · PDF fileAUTOMATIC TRANSMISSION (E–W)...
Transcript of AUTOMATIC TRANSMISSION F4A41, F4A42, F4A51 - | · PDF fileAUTOMATIC TRANSMISSION (E–W)...
GENERAL INFORMATION 23A-0-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1. SPECIFICATIONS 23A-1-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TRANSMISSION MODEL TABLE 23A-1-1. . . . . . . . . . . . . . . . . . . . . . . . GENERAL SPECIFICATIONS 23A-1-2c. . . . . . . . . . . . . . . . . . . . . . . . . . . SERVICE SPECIFICATIONS 23A-1-2d. . . . . . . . . . . . . . . . . . . . . . . . . . . . VALVE BODY SPRING IDENTIFICATION TABLE 23A-1-3. . . . . . . . . SNAP RING, SPACER, THRUST WASHER, THRUST RACE AND PRESSURE PLATE FOR ADJUSTMENT 23A-1-4. . . . . . . . . . . . TORQUE SPECIFICATIONS 23A-1-9. . . . . . . . . . . . . . . . . . . . . . . . . . . . SEALANTS 23A-1-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2. SPECIAL TOOLS 23A-2-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3. TRANSMISSION 23A-3-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4. OIL PUMP 23A-4-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5. UNDERDRIVE CLUTCH AND INPUT SHAFT 23A-5-1. . . . . . . . . . . . . . . 6. REVERSE CLUTCH AND OVERDRIVE CLUTCH 23A-6-1. . . . . . . . . . . . 7. OVERDRIVE PLANETARY CARRIER
<F4A41, F4A42 without ONE-WAY CLUTCH> 23A-7-1. . . . . . . . . . . . . . 7a. PLANETARY CARRIER ASSEMBLY
<F4A42 with ONE-WAY CLUTCH, F4A51> 23A-7a-1. . . . . . . . . . . . . . . . . 8. LOW-REVERSE BRAKE 23A-8-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9. SECOND BRAKE 23A-9-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10. OUTPUT SHAFT 23A-10-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11. TRANSFER DRIVE GEAR
<F4A41 up to Dec. 1997, F4A42 up to Dec. 1997> 23A-11-1. . . . . . . . . . 12. DIFFERENTIAL 23A-12-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13. VALVE BODY 23A-13-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14. SPEEDOMETER GEAR 23A-14-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15. DRIVE SHAFT OIL SEAL 23A-15-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
23A-0-1
AUTOMATICTRANSMISSION
F4A41, F4A42, F4A51CONTENTS
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
23A-0-2
PWEE9514� May 1995Mitsubishi Motors Corporation
NOTES
��������� ��������� � ��� � ������� ����������� �������
� �� � ��������� ��� ��� ��� � ��������������� ������ �� � � ���� ���� ���� ��� ������� � �� ��� �
������� ��� ����� ������ ������ ��� ���� ������ � �������� ��� � ��������� ���� �� � ���� �� � � ���� ���� ������ � �� ����������
� �� � ���������� ��� ���� � ������ ��� ��� ��������� � ��� � ������� ��� ��� ��� ��� � ���� ������
� � ��� ����� ������ ��� ��� ��������� ����� ��� � ������� � ������ ��� �������� � ! ������� ���� � ����� � � ���"�� �������� � ��� ���� ������� � � ���� � ������ � ���� �����#� ��� ���� � �� ���� ���� ����� �� � ������� � ���
��!�� ����� ������ ����
�"�#�$%� &'()� � *+�, �������#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� �����������������)
� ������ 0� �1 )�)( +/ �� !�2, (&&34
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� ����������� ������'
1 )�)( ���� *��, (&&64
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� �����������������7
1 )�)��( +/ �� !�2, (&&34
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� ����������� ������7�
1 )�)��( ���� *��, (&&64
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� �����������������7-
1 )�)��� 8��.�+� ����8�9 2�+�2.4
� �('�)
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� ����������� ������72
1 )�)��� 8��. ����8�9 2�+�2.4
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� �����������������7$
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
! �� �� ���� ��� $
��������� ��������� � ��� � ������� ����������� ������3
1 )�'(4
� �(&&'
�$$�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� �����������������6
;<!����� �������9/� 8��. �=������ ��� ������
( � � ) '
7 3 6 &
(�
(( (�
(�
()
(' (7 (3 (6
(& �� �( �� ��
�) �' �7
�3
�6��
�( ��
�&
!%���
� �('&6
�� %�"���� �������� &����"���� ���$��� '�� � ���$� � ( ������"� ������#� )"�����"� ������*� &����"���� ���������+� '�� � ���������,� ( ������"� ���������-� )"�����"� ����������.� /���� ��������� 0�������� "��"� 1��� 0�������� "��"� 2��� /���� ������ � ��� "��"�� � '������ � "��"��#� &����"���� �������� � ��� "��"��*� '�� � �������� � ��� "��"��+� ( ������"� �������� � ��� "��"�
�,� )"�����"� �������� � ��� "��"��-� /���� ������ � ��� ��� ��
"��"��.� &����"���� ��� �� "��"���� '�� � ��� �� "��"���� ( ������"� ��� �� "��"���� )"�����"� ��� �� "��"�� � ��3�� � "����� �������� � ���
"��"��#� %������� "��"��*� 4� ��� "��"��+� )�� �������,� )�� �������-� )�� �� �.� )�� ������ %����� "��"���� )�� ����� ��
�"�#�$%� &'()� � *+�, �������#+-�#.� �����# ���/�������
��������� ��������� � ��� � ������� ����������� ������&
;<!����� �������9/� 8��.�+� �=������ ��� ������
( � � ) '
7 3 6 &
(�
(( (�
(�
()
(' (7 (3 (6(& �� �( �� ��
�)�' �7
�3
�6
�� �(�&
!%���
� ���&)
�� %�"���� �������� &����"���� ���$��� '�� � ���$� � ( ������"� ������#� )"�����"� ������*� &����"���� ���������+� '�� � ���������,� ( ������"� ���������-� )"�����"� ����������.� /���� ��������� 0�������� "��"� 1��� 0�������� "��"� 2��� /���� ������ � ��� "��"�� � '������ � "��"��#� &����"���� �������� � ��� "��"��*� '�� � �������� � ��� "��"��+� ( ������"� �������� � ��� "��"�
�,� )"�����"� �������� � ��� "��"��-� /���� ������ � ��� ��� ��
"��"��.� &����"���� ��� �� "��"���� '�� � ��� �� "��"���� ( ������"� ��� �� "��"���� )"�����"� ��� �� "��"�� � ��3�� � "����� �������� � ���
"��"��#� %������� "��"��*� 4� ��� "��"��+� )�� �������,� )�� �� �-� )�� ����.� %����� "��"���� )�� ����� ��
�$$�$%� &'()� � *+�, �������#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2���2�����# ����(�(
(, �% �� ���������������� ��! � ��:� ��! � (&&7
��� ����� ��� '������������ ���� 0� �� ���� ���� 5������ ��� 6 �� � ���
0 1 ����4%1 ��7�* �. � /1�1 8-�
0 1 ����4,1� ��7�* �. � 9: 1� 9; 1 8-�6(%
0 1 ����4,1� ��7�* �. � 9:�1 8��
0 1 ����4%1 ��7�* �. � /1�1 8-�
0 1 ����4,1 ��7�* �. � 9:�1 8�#
0 1 ����4,1� ��7�* �. � 9: 1 8-�6<=
0 1 ����4,1 ��7�* �. � 9;�1 8�#
0 1 ����4,1# ��7�* �. � 9;�1 8��
��! � (&&3
��� ����� ��� '������������ ���� 0� �� ���� ���� 5������ ��� 6 �� � ���
0 1 ����4+1 �.7�* �. � 61�1� 61�> 8*�6(%
0 1 ����6*1 �-7�* ��++. 61#1� 61#> *1��
0 1 ����4*1 �-7�* �. � 61�1 8-�
0 1 ����4*1� �-7�* �. � 61�1 8*�
0 1 ����4+1 �.7�* �. � 61�1 8*�6<=
0 1 ����(*1� �-7�* � .+ 61 1 *1��
0 1 ����6*1 �-7�* ��++. 61#1 *1��
0 1#����6#2 �,7�* ��+�# 0�*1 *8+�
��! � (&&6
��� ����� ��� '������������ ���� 0� �� ���� ���� 5������ ��� 6 �� � ���
0 1 ����4,1� ��7�* �. � 9: 1 8-�
0 1 ����4,1# ��7�* �. � 9:�1� 9;�1 8��
0 1 ����4,1* ��7�* �. � /1�1 8-�
6(% 0 1 ����6,1 ��7�* ��++. /1�1 8-��8/!
0 1 ����4+1 �.7�* �. � 61�1� 61�> 8*�
0 1 ����4,1� ��7�* �. � /1�1 8-�
0 1 ����6*1 �-7�* ��++. 61#1� 61#> *1��
�"�#�$%� &'()�!� *+�, (&&6���#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Specifications23A-1-2
F4A41-1-M8A1 31/36 4.042 CJ4A, CK4A 4G92
F4A41-1-M8A4 31/36 4.042 CJ2A, CK2A 4G15
F4A41-1-M8A5 31/36 4.042 CK1A 4G13
EXP F4A42-1-M6A 29/36 4.042 EA1A 4G93
F4A42-1-M6A2 29/36 4.042 EA2A 4G63
F4A42-2-E6A 29/36 3.770 EA5A 6A13
F4A51-2-E5B 28/36 3.735 F36A 6G72
MODEL 1999
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
F4A42-1-U5A1 28/36 4.407 N61W 4G93-GDI
EURF4A42-2-E6B 29/36 3.770 EA3A, EA3W 4G64-GDI
EURF4A42-2-E6B1 29/36 3.770 EA5A, EA5W 6A13
F4A42-2-M5B1 28/36 4.042 N84W 4G64-GDI
EXPF4A42-2-E6B1 29/36 3.770 EA5A 6A13
EXPF4A42-2-M5B 28/36 4.042 N84W 4G64-S4
MODEL 2000
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
F4A41-1-M8A1 31/36 4.042 CJ4A 4G92
F4A41-1-M8A5 31/36 4.042 CJ1A 4G13
EURF4A41-1-U8A2 31/36 4.407 DA1A 4G92
EURF4A42-1-M7A1 30/36 4.042 DA2A 4G93
F4A42-1-U5A2 28/36 4.407 N63W 4G63
F4A42-2-M5B1 28/36 4.042 N64W, N84W 4G64
F4A41-1-M8A1 31/36 4.042 CJ4A, CK4A 4G92
F4A41-1-M8A4 31/36 4.042 CJ2A, CK2A 4G15
F4A41-1-M8A5 31/36 4.042 CJ1A, CK1A 4G13
EXP F4A42-1-M6A 29/36 4.042 EA1A 4G93
F4A42-1-M6A2 29/36 4.042 EA2A 4G63
F4A42-2-E6B1 29/36 3.770 EA5A 6A13
F4A42-2-M5B 28/36 4.042 N84W 4G64
AUS F4A42-2-M5B 28/36 4.042 N84W 4G64
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications 23A-1-2a
MODEL 2001
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
F4A42-1-NZA1 – 4.406 N63W 4G63
F4A42-2-JZB2 – 4.041 N64W 4G64
F4A42-2-JZB2 – 4.041 N84W 4G64
F4A41-1-J8A 31/36 4.041 CJ4A 4G92
EURF4A42-1-J8A 31/36 4.041 DG5A 4G93
EURF4A41-1-N7A 30/36 4.406 DA1A 4G92
F4A42-1-J7A 30/36 4.041 DA2A 4G93
F4A42-1-J6A 29/36 4.041 EA2A, W 4G63
F4A42-2-F6B 29/36 3.769 EA3A, W 4G64
F4A42-2-F6B1 29/36 3.769 EA5A, W 6A13
F4A42-1-JZA – 4.041 EA2W 4G63
F4A42-2-JZB1 – 4.041 N84W 4G64
F4A42-2-FZB2 – 3.769 N84W 4G64
F4A41-1-NZB1 – 4.406 CS3A 4G18
EXPF4A41-1-NZB2 – 4.406 CS1A 4G13
EXPF4A41-1-J8A 31/36 4.041 CJ4A 4G92
F4A41-1-J8A1 31/36 4.041 CJ2A 4G15
F4A42-1-JZA2 – 4.041 EA1A 4G93
F4A42-1-JZA – 4.041 EA2A 4G63
F4A42-1-FZB – 3.769 EA5A 6A13
F4A41-1-M8A1 31/36 4.042 CJ2A 4G15
AUS F4A42-1-J8A1 31/36 4.041 CJ5A 4G93
F4A42-2-JZB1 – 4.041 N84W 4G64
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications23A-1-2b
MODEL 2002
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
F4A42-2-JZB2 – 4.041 N84W 4G64
F4A42-1-J7A 30/36 4.041 DA3A 4G93
F4A41-1-NZA – 4.406 DA1A 4G92
EUR F4A42-1-JZA3 – 4.041 DA2A 4G93
F4A41-1-J8A 31/36 4.041 CJ4A 4G92
F4A41-1-NZA2 – 4.406 DG3A 4G18
F4A42-1-JZA3 – 4.041 DG5A 4G93
F4A42-2-JZB1 – 4.041 N84W 4G64
F4A42-2-FZB2 – 3.769 N84W 4G64
F4A41-1-NZB1 – 4.406 CS3A 4G18
F4A41-1-NZB2 – 4.406 CS1A 4G13
EXPF4A42-1-JZA – 4.041 EA2A, W 4G63
EXPF4A42-1-JZA2 – 4.041 EA1A 4G93
F4A42-1-JZA1 – 4.041 EA7A 4G94
F4A42-2-FZB – 3.769 EA5A 6A13
F4A41-1-J8A 31/36 4.041 CJ4A 4G92
F4A41-1-J8A1 31/36 4.041 CJ2A 4G15
F4A42-2-JZB1 – 4.041 N84W 4G64
AUSF4A42-1-JZB3 – 4.041 CJ6A 4G93
AUSF4A41-1-J8A1 31/36 4.041 CJ2A 4G15
F4A42-1-J8A1 31/36 4.041 CJ5A, CK5A 4G93
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications 23A-1-2c
MODEL 2003
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
F4A41-1-NZA – 4.406 DA1A 4G92-S4
F4A42-1-JZA3 – 4.041 DA2A 4G93-GDI
F4A41-1-J8A 31/36 4.041 CJ4A 4G92-S4
F4A42-1-J6A 29/36 4.041 EA2A, W 4G63-S4
EUR F4A42-2-F6B 29/36 3.769 EA3A, W 4G64-GDI
F4A42-2-F6B1 29/36 3.769 EA5A, W 6G13-S4
F4A41-1-NZA2 – 4.406 DG3A 4G18-S4
F4A42-1-NZA2 – 4.406 DG5A 4G93-S4
F4A42-2-JZB2 – 4.041 N84W 4G64-GDI
F4A42-2-JZB1 – 4.041 N84W 4G64-S4
F4A42-2-FZB2 – 3.769 N84W 4G64-GDI
F4A4A-1-N1Z – 4.406 CS1A 4G13-S4
F4A4A-1-NZB2 – 4.406 CS1A 4G13-S4
EXP F4A42-2-FZB1 – 3.769 CS5W 4G93-GDI
F4A41-1-J8A 31/36 4.041 CJ4A 4G92-S4
F4A42-1-JZA – 4.041 EA2A, W 4G63-S4
F4A42-1-JZA1 – 4.041 EA7A 4G94-GDI
F4A42-2-FZB – 3.769 EA5A 6A13-S4
F4A42-2-JZB1 – 4.041 N84W 4G64-S4
AUSF4A42-1-JZB3 – 4.041 CS6A 4G94-S4
AUSF4A41-1-J8A1 31/36 4.041 CJ2A 4G15-S3
F4A42-1-J8A1 31/36 4.041 CJ5A, CK5A 4G93-S4
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications23A-1-2d
MODEL 2004
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
F4A41-1-NZA2 – 4.406 DG3A 4G18-S4
EUR F4A42-1-NZA2 – 4.406 DG5A 4G93-S4
F4A42-2-JZB2 – 4.041 N84W 4G64-GDI
F4A42-2-JZB1 – 4.041 N84W 4G64-S4
F4A42-2-FZB2 – 3.769 N84W 4G64-GDI
EXPF4A4A-1-N1Z – 4.406 CS1A 4G13-S4
EXPF4A42-1-JZA – 4.041 EA2A 4G63-S4
F4A42-1-JZA1 – 4.041 EA7A 4G94-GDI
F4A42-2-FZB – 3.769 EA5A 6A13-S4
AUSF4A42-2-JZB1 – 4.041 N84W 4G64-S4
AUSF4A4B-1-J1Z – 4.041 CS6A 4G94-S4
MODEL 2005
Transmission model Speedometergear ratio Final gear ratio Vehicle model Engine model
EXP F4A4A-1-N1Z – 4.406 CS1A 4G13-S4
AUS F4A4B-1-J1Z – 4.041 CS6W 4G94-S4
RevisedPWEE9514-K� Feb. 2004Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications 23A-1-2e
GENERAL SPECIFICATIONS
Items F4A41 F4A42-1 F4A42-2 F4A51
Torque converter type 3-element,1-stage, 2-phase
type
3-element,1-stage, 2-phase
type
3-element,1-stage, 2-phase
type
3-element,1-stage, 2-phase
type
Transmission type 4-speed forward,1-speed reverse
4-speed forward,1-speed reverse
4-speed forward,1-speed reverse
4-speed forward,1-speed reverse
1st 2.842 2.842 2.842 2.842
2nd 1.529 1.529 1.529 1.495
Gear ratio 3rd 1.000 1.000 1.000 1.000
4th 0.712 0.712 0.712 0.731
Reverse 2.480 2.480 2.480 2.720
Number of underdrive clutchdisc
3 4 4 4
Number of overdrive clutchdisc
3 4 4 4
Number of reverse clutchdisc
2 2 2 2
Number of low-reversebrake disc
4 5 6 6
Number of second brakedisc
2 3 3 4
RevisedPWEE9514-K� Feb. 2004Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications23A-1-2f
SERVICE SPECIFICATIONS
Items Standard value
Output shaft preload mm 0.01 – 0.09
Brake reaction plate end play mm 0 – 0.16
F4A41 1.05 – 1.51
Low-reverse brake end play mm F4A42-1 1.35 – 1.81
F4A51, F4A42-2 1.65 – 2.11
F4A41 0.49 – 0.95
Second brake end play mm F4A42 0.79 – 1.25
F4A51 1.09 – 1.55
Underdrive sun gear end play mm 0.25 – 0.45
Input shaft end play mm 0.70 – 1.45
Differential case end play mm F4A41 0.045 – 0.165
Differential case preload mm F4A42, F4A51 0.045 – 0.105
Underdrive clutch end play mmF4A41 1.2 – 1.4
Underdrive clutch end play mmF4A42, F4A51 1.6 – 1.8
Reverse and overdrive clutch return spring retainer end play mm 0 – 0.09
Overdrive clutch end play mmF4A41 1.2 – 1.4
Overdrive clutch end play mmF4A42, F4A51 1.6 – 1.8
Reverse clutch end play mm 1.5 – 1.7
Backlash between differential side gear and pinion mm 0.025 – 0.150
RevisedPWEE9514-K� Feb. 2004Mitsubishi Motors Corporation
��������� ��������� � ��� � �/�2���2�����# ����(��
0��0 :�!< �%�� �! �� ������ ��:�
'��� � >��� ������� )������ ������� 0��� �� ��� ?���� � ���
%������� "��"� ���� � ��, �#�+ ,*�+ �
( ������"� �������� � ��� "��"����� �
.�+ +�* �+�+ �#
)"�����"� �������� � ��� "��"����� �
.�+ +�* �+�+ �#
&����"���� �������� � ���"��"� ���� �
.�+ +�* �+�+ �#
'�� � �������� � ��� "��"����� �
.�+ +�* �+�+ �#
��3�� � "����� ���� � ��* ���� � � ���#
/���� ������ � ��� "��"� ���� � .�+ #�- �,�� �-
0�������� "��"� 1 ���� � .�+ ,�- ���- -�#
/��� � "��"� ���� � ��. +�+ �#�, �+
&� � ������ "��"� ���� � ��. +�. �+�� �.
)������ ����$ ���� ���� � .�# �# �+�� �#
�"�#�$%� &'()��� �", (&&'���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2���2�����#����(�)
��% ��> �%�� > �;��� ���; > �;��� �� �! % ��� %��� � �!*���� �
=��� �� ����$ ��� !�� �������� ���� =��� ?�
������ ������ ��, �, 4/+# #.-�0� ��@���� � � � ��� ����� � � ����� ��. �. 4/+# #.,
��� �� 4/+# #.+
�� � 4/+#�+-�
��* �* 4/+#�+-
��, �, 4/+#�+-#
' �� �� �A 0 1 �� 0 1 � ��* ? � 4/+#-***�0� ��@���� � � � ������"� ������ � � "�����"� ��+ 2��� 4/+#-**+������ � � ������
��, 2�� 4/+#-**,
��- ? � 4/+#���
��. 2��� 4/+#���#
��� 2�� 4/+#���*
��� ? � 4/+#���+
��� 2��� 4/+#���,
�� 2�� 4/+#���-
��# ? � 4/+#���.
��* 2��� 4/+#����
��+ 2�� 4/+#����
��, ? � 4/+#����
��- 2��� 4/+#���
��. 2�� 4/+# *,.
' �� �� �A 0 1#� ��* 2�� 4/+#--*.�0� ��@���� � � � ������"� ������ � � "�����"� ��+ ? � 4/+#--*������� � � ������
��, 2��� 4/+#--*�
��- 2�� 4/+#--*�
��. ? � 4/+#., �
��� 2��� 4/+#., �
��� 2�� 4/+#., �
��� ? � 4/+#.,
�� 2��� 4/+#., #
��# 2�� 4/+#., *
��* ? � 4/+#., +
��+ 2��� 4/+#., ,
��, 2�� 4/+#., -
��- ? � 4/+#.,#.
��. 2��� 4/+#.,#�
' �� �� �A 0 1 �� 0 1 � ��� 2��� 4/+# +,*�0� ��@���� � � �����"���� ���$� � � ��� � ��� 2�� 4/+# +,+���$� ������ ������ � � ������
�� ? � 4/+#,� .
��# 2��� 4/+#,� �
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2���2�����# ����(�'
=��� �� =��� ?�!�� �������� ��������$ ���
' �� �� �A 0 1#� ��� ? � 4/+#*+, �0� ��@���� � � �����"���� ���$� � � ��� � ��� 2��� 4/+#*+,#���$� ������ ������ � � ������
�� 2�� 4/+#,##�
��# ? � 4/+#,##�
=������� �����A 0 1 �� 0 1 � ��* & 4/+#-#*+�0� ��@���� � � �����"���� ���$� � � ��� � ��, � 4/+#- � ���$� � � �����
��. . 4/+#- �#
��� � 4/+#- �*
�� 4/+#- �+
��* * 4/+#- �,
��, , 4/+#- �-
��. / 4/+#- �.
=������� �����A 0 1#� ��* 0 4/+#-#*,�0� ��@���� � � �����"���� ���$� � � ��� � ��, 6 4/+#- �#���$� � � �����
��. / 4/+#- �*
��� 9 4/+#- �+
�� 2 4/+#- �,
��* 1 4/+#- �-
��, . 4/+#- �.
��. � 4/+#- ��
' �� �� �A 0 1 �� 0 1 � ��* ? � 4/+*�.,#�0� ��@���� � � ��"���� ������ � � ����� ��+ 2��� 4/+*�.,*
��, 2�� 4/+*�.,+
��- ? � 4/+#���+
��. 2��� 4/+#���,
��� 2�� 4/+#���-
��� ? � 4/+#�� .
��� 2��� 4/+#�� �
�� 2�� 4/+#�� �
��# ? � 4/+#�� �
��* 2��� 4/+#��
��+ 2�� 4/+#�� #
��, ? � 4/+#�� *
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2���2�����#����(�7
=��� �� =��� ?�!�� �������� ��������$ ���
' �� �� �A 0 1#� ��* ? � 4/+*�..,�0� ��@���� � � ��"���� ������ � � ����� ��+ 2��� 4/+*�.,-
��, 2�� 4/+*�.-.
��- ? � 4/+#,- +
��. 2��� 4/+#**-.
��� 2�� 4/+#**-�
��� ? � 4/+#**-�
��� 2��� 4/+#**-�
�� 2�� 4/+#**-
��# ? � 4/+#**-#
��* 2��� 4/+#**-*
��+ 2�� 4/+#**-+
��, ? � 4/+#**-,
' �� �� � �� , 2�� 4/+##*..�0� ��@���� � � ��"���� ������ � � "�����"� ��#� ? � 4/+##*.������� ���� � ����� ��� � � ������
��#, 2��� 4/+##*.�
��*� 2�� 4/+##*.�
������ ���� ��* � 4/+.+�*+�0� ��@���� � � � ������"� �� ���� � � ����� ��+ � 4/+#-*,�
��, � 4/+��.*
��- � 4/+# +-
��. � 4/+.+�*,
��� � 4/+# +-#
��� � 4/+��.*#
��� � 4/+# +-*
�� � 4/+� �#,
��# � 4/+# +-+
��* � 4/+# +-,
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2���2�����# ����(�3
=��� �� =��� ?�!�� �������� ��������$ ���
'����� ��,, ,, 4/+#*#+-�0� ��@���� � � ����� ����� ������� ��-� -� 4/+#*#,.
��-* -* 4/+#*#,�
��.. .. 4/+#*#,�
��. . 4/+#*#,�
��., ., 4/+#*#,
���� �� 4/+#*#,#
���* �* 4/+#*#,*
���. �. 4/+#*#,+
��� � 4/+#*#,,
���, �, 4/+#*#,-
���� �� 4/+#*#-.
���* �* 4/+#*#-�
�� . . 4/+#*#-�
�� 4/+#*#-�
�� , , 4/+#*#-
��#� #� 4/+#*#-#
��#* #* 4/+#*#-*
��*. *. 4/+#*#-+
��* * 4/+#*#-,
��*, *, 4/+#*#--
��+� +� 4/+*.*,#
��+* +* 4/+*.*,*
'�����A 0 1 � ���, ? 4/+�. #,�0� ��@���� � � ������� ���� ���� � � ����� ���+ = 4/+�. *.
�� * % 4/+�. *�
��## � 4/+�. *
��* 5 4/+�. **
��+� < 4/+�. *,
��,� B 4/+�. +.
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2���2�����#����(�6
=��� �� =��� ?�!�� �������� ��������$ ���
'�����A 0 1 �� 0 1#� .�+� +� 4/+# +#�0� ��@���� � � ������� ���� ���� ������� .�+ + 4/+�+**.
.�++ ++ 4/+# +*
.�,. ,. 4/+�+**�
.�,� ,� 4/+�.-�+
.�,* ,* 4/+�.-�,
.�,- ,- 4/+�.-�-
.�-� -� 4/+�.- .
.�-# -# 4/+�.- �
.�-, -, 4/+�.- �
��.� .� 4/+�.- �
��. . 4/+�.-
��.+ .+ 4/+�.- #
���. : 4/+�. #
���� / 4/+..�+.
���* ; 4/+�. ##
���- & 4/+�. #*
���� 8 4/+..�+�
���# 4 4/+�. #+
���, ? 4/+�. #,
���� 6 4/+.*#+
��� ) 4/+�. #-
���+ = 4/+�. *.
'����� .�+# � .�,� � 4/+��-,*�0� ��@���� � � ���$���� ������ ������� ���� .�,� � .�-� � 4/+��-,#���� ���� � � �� � �
.�-� � ��.. � 4/+��-,
��.� � ��., � 4/+��-,�
��.- � ���* � 4/+��-,�
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Specifications 23A-1-9
TORQUE SPECIFICATIONS
Items Nm
Transmission Roll stopper bracket 70
Wiring harness bracket 23
Control cable bracket 23
Eye bolt 31
Oil cooler feed tube (to transmission case) 10
Oil cooler feed tube (to roll stopper bracket) 11
Oil filter <Externally mounted> 12
Input shaft speed sensor 11
Output shaft speed sensor 11
Manual control lever 22
Inhibitor switch 11
Speedometer gear <If equipped> 5
Sealing cap <Type without speedometer gear> 5
Valve body cover 11
Valve body mounting bolt 11
Fluid temperature sensor 11
Manual control shaft detent 6
Rear cover 23
Torque converter housing 48
Oil pump <up to Mar. 2000> 23
Oil pump <from Apr. 2000> 29
Transfer drive gear bearing <F4A41 up to Dec. 1997, F4A42 up to Dec. 1997>
19
Transfer drive gear bearing <F4A41 from Jan. 1998, F4A42-1from Jan. 1998, F4A42-2 with one-way clutch, F4A51>
34
Output shaft lock nut 170
Output shaft bearing retainer <F4A41 up to Mar. 2000, F4A42up to Mar. 2000>
23
Output shaft bearing retainer <F4A41 from Apr. 2000, F4A42from Apr. 2000>
29
Output shaft bearing retainer <F4A51> 54
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Specifications23A-1-10
Items Nm
Components Transfer drive gear lock nut <F4A41 up to Dec. 1997, F4A42 up to Dec. 1997>
195
Differential drive gear 135
Valve body 11
Solenoid valve support 6
Plate 6
SEALANTS
Items Specified sealant
Rear cover Mitsubishi genuine sealant Part No. MD974421 or equivalent
Torque converter housing Mitsubishi genuine sealant Part No. MD974421 or equivalent
Valve body cover Mitsubishi genuine sealant Part No. MD974421 or equivalent
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
��������� ��������� � ��� � �/�2��� ����#��������� ��������� � ��� � �/�2��� ����# ������(
�, �% ���� �����
�� ?���� ?�� (��
42--.*.+ ��3�� ��� ����$��
%�"�� � � � �������� � ����� ����� ��$ ��
42--.-�, ! ������� ������� %�"�� � ��� ���� ���"� ���� ����� �C0 1 �� 0 1 �D
42--.-�. ! ������� ������� ! �������� � ����� ����� ����� ����� ����� ����� ����
42--.-�� ! ������� ������� ! �������� � ���
42--.-�# ! ������� ������� ! �������� � ������� ���� ����� ����� ����� ����� ���� C0 1 �D
42--.-�* ! ������� ������� ! �������� � ������� ���� ����� ����� ����� ����� ���� C0 1#�D! �������� � ����� ����� ����� ����� ����� �C0 1 �� 0 1 �D
42--.-�+ ! ������� ������� ! �������� � ����� ����� ����� ����� ����� �C0 1#�D
42--.-�, E� ��� � ! �������� � � ��� ����� ���� ����� �� (�� ���� � ������� �������
42--�*�# '������ ��$�� � �� %�"�� � � � �������� � ����� ����� ��$ ��
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2��� ����#�������
�� (��?��?����
42--�*�* '�$�� �*.� %�"�� � � � �������� � ��� ���� ���"� ������$ �� C0 1 �� 0 1 �D
42--�*�, '��� � ������� � %�"�� � � � �������� � �����"�������$� � �� �� � C0 1 �� 0 1 �D
� 4������� � � � ������"� ������ � �"�����"� ������ � � ����� C0 1 ��0 1 �D
42--�*�- '��� � ������� 4������� � � � ������"� ������ � � "������"� ������ � � ����� C0 1#�D
42--�*�� 9����� �� ��������
4������� � � �����"���� ���$� � ���� � ���$� � � ����� C0 1 �� 0 1 �D
42--�*�� 9����� �� ��������
4������� � � �����"���� ���$� � ���� � ���$� � � ����� C0 1#�D
42--�+,- '��� � ������� 4������� � � ��"���� ������ � � ����C0 1#�D
42--�+-. '��� � ������� 4������� � � ��"���� ������ � � ����C0 1 �� 0 1 �D
4/--,��� )�� ��� ��"�� %�"�� � �� ���
4/--,�� )�� ���� � ������� ! �������� � �� ��� �� ����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2��� ����# �������
�� (��?��?����
4/--,��, '��� � ��������
%�"�� � � � �������� � �����"���� ���$�� �� �� � C0 1#�D
4/--,� , 2���� � � � ����������
%�"�� � ��� ���� ���"� ���� ����� �
4/--,�#. 2���� � � ������� ! �������� � ����� ������ ������ ����� �
4/--, �� 8���� ! �������� � �� ��� � � ��� ���� ���"� ����
4/--,,.. )�� ���� � ������� ! �������� � ���"� ����� �� ����
4/--,,.� 2���� � ��"�� %�"�� � ���� ����� �
4/--,,�� ! ������� ��� (�� ���� � ������� � � � ������� ��������
4/--,,�� ! ������� � �.. (�� ���� � ������� ��� � � � ������� ��������
4/--,,� ! ������� � �.. (�� ���� � ������� ��� � � � ������� ��������
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �/�2��� ����#������)
�� (��?��?����
4/--,,�- ! ������� �������� .�
! �������� � ������� ���� ���� ����� � C0 1 �D
4/--,,�. ! ������� �������� ��
! �������� � ������� ���� ����� ����� ����� �C0 1 �D
4/--,,�� ! ������� �������� ,�
! �������� � ����� ����� ����� ����� ����� �C0 1 �� 0 1 �D� ��� ���� ���"� ���� C0 1 ��0 1 �D
4/--,,� ! ������� ��������#.�
! �������� � ��� ���� ���"� ���� C0 1#�D�������� ���� ����� ����� ����� � C0 1#�D
4/--,,�+ ! ������� ��������#*�
! �������� � ����� ����� ����� ����� ����� �C0 1#�D
4/--,,�- ! ������� ��������*.�
! �������� � ��� ���� ���"� ���� ����� �C0 1 �� 0 1 �D
4/--,-.� '��� � ������� %�"�� � � � �������� � ����� ������� �� ���� � �� �� � C0 1 �D
4/--,-.+ '��� � ������� %�"�� � � � �������� � � ������"� ������� �� �� �
4/--,-�� /��� ��������� ��
4������� � � �����"���� ���$� � ���� � ���$� � � �����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Special Tools 23A-2-5
Tool Number Name Use
MD998917 Bearing remover Removal of output shaft taper roller bearing (except F4A51)
MD998924 Spring compressorretainer
� Removal and installation of low-reversebrake snap ring
� Measurement of underdrive clutch andoverdrive clutch end plays
MD999590 Spring compressor Removal and installation of overdrive clutchsnap ring
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
��������� ��������� � ��� � ����#��##��� ������(
�, ���������!����� �:�< �! ��� �:�< 1 )�)( +/ �� !�2, (&&3> )�)��( +/ �� !�2,(&&3 ��$ )�)��� 8��.�+� ����8�9 2�+�2.4
(( �
(( � �� �
(( �
(� �
�( �
&
' �
3� �
7 �
3� �
(( �
((
(�
6
�
)()
�
(�
(�
7
3
(7
(3
'
('
�
(
(( �
1 )�)(�(���> )�)����$��(&&74
1 )�)(�(��6�> �6�(>�6��> �6�)> �6�'> )�)����$�� (&&34
�( �
(� �
7(( �7�( �
3
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
� �(&&7
�� �
�� ��3�� � "������� %�� ������ ����$���� E�� ��� ����$�� � 9 ��� ����� ������ ����$��#� )�� ��"�� �����*� 6�� ���+� )�� ���� ���� ����,� )�� ������-� )�� ������ ���$��
�.� ! ��� ����� ����� �� ����� )����� ����� ����� �� ����� 4� ��� � ��� ��"����� ! ������ ������� � '�������� �����#� 5��"� ��� �"���*� 4� ��� � ��� ����� ���� � ���� �
C4��� �--* ��D�+� 4� ��� � ��� ����� ���� �
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##����������
(( �
(( �
�(
��
�&
�'
�6�3
�)�(��
��
��
�7
(&
(6
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
�,� 0���� ���������� �� ���-� 5��"� ����.� '���� ������� 8��$����� ' �� �� ���� '�� �� "��"� ��� ���� � '���� ��
�#� '�� � ���$� ����� �� �� �����*� 1�������� ���� �+� 1�������� ���� ��,� 1�������� ���� ��-� 4� ��� � ��� ��"�� ����� ������.� 4� ��� � ��� ��"�� �������� =��$� � ���� ��
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##��� �������
)6 �
)6 �
�� �
�'�7
)))'
�6
�'�)
�&
)�
)(
)�
)�
��
�3
��
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
��� ��3�� � "����� ���� ���� /������ ���� C0 1 �D� � '����� C0 1 �D�#� '����� C0 1 ����4%1 ��D�*� /������ ���� C0 1 �D�+� )�� �������,� )�� ���
�-� 8��$�� .� ������ ������ F� �� ( ������"� ������ � � � ��� ����� �� ������ ����� � F� �� ( ������"� ������ ��� � )���� ���� C0 1 �D #� '����� C0 1 �D
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##���������)
�, �� :��?� !�#2# ��$ %����#
2��$� 4��� 2��$� /��� 2��$� =����
&����"���� 0 1 � ����$�
0 1 ��� #
0 1 ��� * #
'�� � 0 1 � � ����$�
0 1 ���0 1 ���
� �
(3� �
�� �
�� �
(& �
6'6766&�
&(&�
6&&)
&�63
3'
3)3736
3&6)
6�6�6(6�3�
3�
3�
3(
7&
7673
7(
7�
7�7�
7'777)
'&
'6'3
'7
''')
'�
'� '(
'� )7
)3)&)6
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
33
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##��� ������'
*� %��� �"�� +� ������ ���� F, ,� '��� �� � -� ! ��� ����� ���� ����� �#.� ������ ����� � F+#�� %�"���� � � "�����"� ������#�� ������ ����� � F*#�� )"�����"� ������ ���# � ������ ����� � F###� =�� ����� ��"���� �� ����#*� ' �� �� �#+� '�� � ���$� ���� #,� %���� ���� �#-� =������� �����*.� '�� � ���$� ����*�� '�� � ���$� �����*�� )"�����"� ��� ����� �������*�� ������ ����� � F * � )����� ��� ����� �������*#� ( ������"� �� ����**� ������ ����� � F�*+� ' �� �� �*,� %����� �����*-� ' �� �� �+.� &����"���� ���$� ����
+�� &����"���� ���$� �����+�� =������� �����+�� >�"� ���� �+ � =��$� � ���� �����+#� '�����+*� =��$� � ���� ���� �++� =��$� � ����� ������ �����+,� =��$� � ����+-� =��$� � ����� ������,.� ' �� �� �,�� '��� � ����� ��,�� %���� ���� �,�� &����"���� ���$� ���� , � ��� ���� ���"� ����,#� 9��,*� &�$ ��,+� )����� �����,,� ����� ����� ����� �,-� 9����-.� )���� ����-�� '�����-�� ' �� �� �-�� )���� ����- � ��� ����� ����
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-5a
DISASSEMBLY AND REASSEMBLY <F4A41 from Jan. 1998 and F4A42-1 fromJan. 1998>
11 Nm
14
11 Nm
10
812 Nm
23 Nm
3
4
11
5 Nm
2
70 Nm
22 Nm
12
9
270 Nm
11 Nm
15
31 Nm
11 Nm6
5 Nm
1
6
Apply automatictransmission fluid toall moving partsbefore installation.
<Type without speedometer gear>
<Type with speedometer gear>
14
31 Nm13
11 Nm
7
10 Nm
5
6 Nm16
8
<Externally mounted type>
<Air breather type>
1. Torque converter2. Roll stopper bracket3. Harness bracket4. Control cable support bracket5. Oil level gauge6. Eye bolt7. Oil cooler feed tube8. Oil filter <Externally mounted type>
Air breather <Air breather type>9. Oil filter gasket <Externally
mounted type>
10. Input shaft speed sensor11. Output shaft speed sensor12. Manual control lever13. Inhibitor switch14. Speedometer gear <If equipped>
Sealing cap <Type withoutspeedometer gear>
15. Valve body cover16. Manual control shaft detent
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-5b
11 Nm
11 Nm
30
29
28
24
2726
232019
21
22
25
18
17
Apply automatictransmission fluid toall moving partsbefore installation.
17. Fluid temperature sensor*18. Valve body19. Steel ball20. Gasket21. Snap ring22. Solenoid valve harness23. Strainer
*: Not applicable to type with solenoidvalve harness incorporating fluidtemperature sensor
24. Second brake retainer oil seal25. Accumulator piston26. Accumulator spring27. Accumulator spring28. Manual control lever shaft roller29. Manual control lever shaft30. Parking pawl rod
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-5c
33
34
3242
43 39
41
38
36
35
37
40
48 Nm
48 Nm
23 Nm <up to Mar. 2000>29 Nm <from Apr. 2000>
31
Apply automatictransmission fluid toall moving partsbefore installation.
31. Torque converter housing32. Differential <F4A41>33. Spacer <F4A41>34. Differential <F4A42-1>35. Oil filter36. Oil pump37. Gasket
38. Thrust washer #139. Underdrive clutch and input shaft40. Thrust bearing #241. Underdrive clutch hub42. Outer race <F4A42-1>43. Spacer <F4A42-1>
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-5d
No. of Brake Discs and Plates
Brake Model Brake Disc Brake Plate
Low-reversebrake
F4A41 4 3brake
F4A42-1 5 4
Secondbrake
F4A41 2 1brake
F4A42-1 3 2
82
74
89
75
76
84
8085
72
73
77
92
83
8179
91
8790
88
7871
70
86
68
67
6665
62
64
46
55
51
50
59
48
49
52
54
57
47
44
56
63
58
6061
53
45
34 Nm
170 Nm
23 Nm
Apply automatictransmission fluid toall moving partsbefore installation.
69
23 Nm <up to Mar. 2000>29 Nm <from Apr. 2000>
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
��������� ��������� � ��� � ����#��##���������'�
� %��� �"�� #� ������ ���� F, *� '��� �� � +� ! ��� ����� ���� ����� � ,� ������ ����� � F+ -� %�"���� � � "�����"� ������#.� ������ ����� � F*#�� )"�����"� ������ ���#�� ������ ����� � F##�� =�� ����� ��"���� �� ����# � ' �� �� �##� '�� � ���$� ���� #*� %���� ���� �#+� =������� �����#,� '�� � ���$� ����#-� '�� � ���$� �����*.� )"�����"� ��� ����� �������*�� ������ ����� � F *�� )����� ��� ����� �������*�� ( ������"� �� ����* � ������ ����� � F�*#� ' �� �� �**� %����� �����*+� ' �� �� �*,� &����"���� ���$� ����
*-� &����"���� ���$� �����+.� =������� �����+�� >�"� ���� �+�� =��$� � ���� �����+�� '�����+ � =��$� � ���� ���� �+#� =��$� � ����� ������ �����+*� =��$� � ����++� =��$� � ����� ������+,� ' �� �� �+-� '��� � ����� ��,.� %���� ���� �,�� &����"���� ���$� ���� ,�� ��� ���� ���"� ����,�� 9��, � &�$ ��,#� )����� �����,*� ����� ����� ����� �,+� 9����,,� )���� ����,-� '�����-.� ' �� �� �-�� )���� ����-�� ��� ����� ����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-5f
DISASSEMBLY AND REASSEMBLY <F4A42-2 with one-way clutch>
11 Nm
14
11 Nm
10
812 Nm
23 Nm
3
4
11
5 Nm
2
70 Nm
22 Nm
12
9
270 Nm
11 Nm
15
31 Nm
11 Nm6
5 Nm
1
6
Apply automatictransmission fluid toall moving partsbefore installation.
<Type without speedometer gear>
<Type with speedometer gear>
14
31 Nm13
11 Nm
7
10 Nm
5
6 Nm16
8
<Externally mounted type>
<Air breather type>
1. Torque converter2. Roll stopper bracket3. Harness bracket4. Control cable support bracket5. Oil level gauge6. Eye bolt7. Oil cooler feed tube8. Oil filter <Externally mounted type>
Air breather <Air breather type>9. Oil filter gasket <Externally
mounted type>
10. Input shaft speed sensor11. Output shaft speed sensor12. Manual control lever13. Inhibitor switch14. Speedometer gear <If equipped>
Sealing cap <Type withoutspeedometer gear>
15. Valve body cover16. Manual control shaft detent
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-5g
11 Nm
11 Nm
30
29
28
24
2726
232019
21
22
25
18
17
Apply automatictransmission fluid toall moving partsbefore installation.
17. Fluid temperature sensor*18. Valve body19. Steel ball20. Gasket21. Snap ring22. Solenoid valve harness23. Strainer
*: Not applicable to type with solenoidvalve harness incorporating fluidtemperature sensor
24. Second brake retainer oil seal25. Accumulator piston26. Accumulator spring27. Accumulator spring28. Manual control lever shaft roller29. Manual control lever shaft30. Parking pawl rod
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-5h
31
40
32
41
3638
39
35
34
33
37
48 Nm
48 Nm
Apply automatictransmission fluid toall moving partsbefore installation.
23 Nm <up to Mar. 2000>29 Nm <from Apr. 2000>
31. Torque converter housing32. Differential33. Oil filter34. Oil pump35. Gasket36. Thrust washer #1
37. Underdrive clutch and input shaft38. Thrust bearing #239. Underdrive clutch hub40. Outer race41. Spacer
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-5i
65
47
52
88
5570
64
67
87
59
49
46
69
56
79
62
82
81
78
63
60
86
57
50
8485
58
48
5354
45
66
71
44
83
51
4372
76
7375 74
77
23 Nm
170 Nm
34 Nm
80
42
68
Apply automatictransmission fluid toall moving partsbefore installation.
TFA2048
61
23 Nm <up to Mar. 2000>29 Nm <from Apr. 2000>
42. Rear cover43. Thrust race #844. Seal ring45. Input shaft rear bearing46. Thrust bearing #747. Reverse and overdrive clutch48. Thrust bearing #649. Overdrive clutch hub50. Thrust bearing #551. Planetary reverse sun gear52. Snap ring53. Second brake piston54. Return spring55. Pressure plate56. Second brake disc57. Second brake plate58. Planetary carrier assembly59. Snap ring60. Reaction plate61. Snap ring62. Low-reverse brake disc63. Low-reverse brake plate64. Pressure plate65. Wave spring
66. Parking pawl shaft67. Spacer68. Parking pawl spring69. Parking roller support shaft70. Parking pawl71. Parking roller support72. Snap ring73. One-way clutch inner race74. O-ring75. Spring retainer76. Return spring77. Low-reverse brake piston78. Transfer drive gear79. Cap80. Lock nut81. Output shaft82. Taper roller bearing83. Collar84. Outer race85. Spacer86. Snap ring87. Outer race88. Transmission case
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
��������� ��������� � ��� � ����#��##��� ������'@
!����� �:�< �! ��� �:�< 1 )�'(4
(( �(( ��� �
(( �
�� �' �
3� �
7 �
3� �
(( �
&
6
�
)(�
�
(�
((
7
3
()
'
(�
�(
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
(� �
� �(&6�
�� ��3�� � "������� %�� ������ ����$���� E�� ��� ����$�� � 9 ��� ����� ������ ����$��#� )�� ��"�� �����*� )�� ������ C6���� ���� � ��� ����D+� )�� ������ ���$�� C6���� ����
� ��� ����D
,� ! ��� ����� ����� �� ��-� )����� ����� ����� �� ���.� 4� ��� � ��� ��"����� ! ������ ��������� '�������� ������� 5��"� ��� �"��� � 4� ��� � ��� ����� ���� �
�"�#�$%� &'()� � *+�, �������#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-5k
11 Nm
11 Nm
28
27
26
22
25
24 2118
17
19
2023
1615
Apply automatictransmission fluid toall moving partsbefore installation.
TFA1981
15. Fluid temperature sensor*16. Valve body17. Steel ball18. Gasket19. Snap ring20. Solenoid valve harness21. Strainer
*: Not applicable to type with solenoidvalve harness incorporating fluidtemperature sensor
22. Second brake retainer oil seal23. Accumulator piston24. Accumulator spring25. Accumulator spring26. Manual control lever shaft roller27. Manual control lever shaft28. Parking pawl rod
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-5l
30
29
37
3538
31
3436
3332
39
48 Nm
48 Nm
Apply automatictransmission fluid toall moving partsbefore installation.
23 Nm <up to Mar. 2000>29 Nm <from Apr. 2000>
29. Torque converter housing30. Differential31. Oil filter32. Oil pump33. Gasket34. Thrust washer #1
35. Underdrive clutch and input shaft36. Thrust bearing #237. Underdrive clutch hub38. Outer race39. Spacer
RevisedPWEE9514-I� May 2002Mitsubishi Motors Corporation
��������� ��������� � ��� � ����#��##���������'�
737)
6�
)7
))
)(
7&
37 )6
)3
)&
6(7�
)�
76
)�
6�
7(
6)
33
6'
36
)�
6�
77
3'
3�3�
')
''
'�
'�
'�'(
3(3�
'6
'&
7�
�) �
�� �
') �
(3� � '3
67
'7
)'
3&
7�
3)
7'
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
.� %��� �"�� �� ������ ���� F, �� '��� �� � �� ! ��� ����� ���� ����� � � ������ ����� � F+ #� %��� � � "�����"� ������ *� ������ ����� � F* +� )"�����"� ������ ��� ,� ������ ����� � F# -� =�� ����� ��"���� �� ����#.� ' �� �� �#�� '�� � ���$� ���� #�� %���� ���� �#�� =������� �����# � '�� � ���$� ����##� '�� � ���$� �����#*� =�� ����� ������� �������#+� ' �� �� �#,� %����� �����#-� ' �� �� �*.� &����"���� ���$� ����*�� &����"���� ���$� �����*�� =������� �����*�� >�"� ���� �
* � =��$� � ���� �����*#� '�����**� =��$� � ���� ���� �*+� =��$� � ����� ������ �����*,� =��$� � ����*-� =��$� � ����� ������+.� ' �� �� �+�� ) ����� ������ � �� ����+�� )��� �+�� '��� � ����� ��+ � %���� ���� �+#� &����"���� ���$� ���� +*� ��� ���� ���"� ����++� 9��+,� &�$ ��+-� )����� �����,.� ����� ����� ����� �,�� 9����,�� )���� ����,�� '�����, � ' �� �� �,#� )���� ����,*� ��� ����� ����
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/������� �$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-5n
DISASSEMBLY
Caution1. Because the automatic transmission is manufactured
from high-precision parts, sufficient care must betaken not to scratch or damage these parts duringdisassembly and reassembly.
2. The working area should be covered with a rubbermat to keep it clean at all times.
3. Do not wear any cloth gloves and do not use anyrags during disassembly. Use nylon cloth or papertowels if you need to use something.
4. Parts which have been disassembled should all becleaned. Metal parts can be cleaned with normaldetergent, but they should be dried completely usingcompressed air.
5. Clutch discs, plastic thrust plates and rubber partsshould be cleaned with automatic transmission fluid(ATF) so that they do not become dirty.
6. If the transmission body has been damaged,disassemble and clean the cooler system also.
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-6
(1) Remove the torque converter.(2) Use the dial gauge to measure the input shaft end play.(3) Remove each bracket.(4) Remove the oil level gauge.(5) Remove the eye bolt, gasket and the oil cooler feed tube.(6) Remove the oil filter. <Externally mounted type>
(6a)Remove the air breather by jabbing a screwdriver intothe air breather and prying it up. <Air breather type>
(7) Remove the input shaft speed sensor and output shaftspeed sensor.
(8) Remove the manual control lever, and then remove theinhibitor switch.
CautionMake sure that the valve body is installed beforeremoving the manual control lever installation nut.
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
Input shaft speedsensor
Output shaft speed sensor
Manual control lever
Inhibitorswitch
AUTOMATIC TRANSMISSION (E–W) – TransmissionAUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-7
(9) Remove the speedometer gear or sealing cap.
(10)Remove the valve body cover.
(11)Remove the manual control shaft detent spring and themanual control shaft detent. <Model 1996>
Remove the manual control shaft detent. <from Model1997>
(12)Disconnect the solenoid valve harness from the valvebody by undoing the fluid temperature sensor (only inthe harness that incorporates the sensor) and all theconnectors.
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
Manual controlshaft detent
Manual control shaftdetent spring
Manual controlshaft detent
TFA1877
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-8
(13)Remove the valve body mounting bolts (28 pieces).(14)Remove the fluid temperature sensor. (This step is
unnecessary if the sensor is incorporated in the solenoidvalve harness).
CautionMake sure that the manual control lever and the inhibitorswitch are removed.
(15)Remove the valve body, gasket and the steel balls (2pieces).
CautionDo not lose the steel balls (2 pieces).
(16)Remove the snap ring, and then remove the solenoidvalve harness.
(17)Remove the strainer and the second brake retainer oilseal.
(18)Remove each accumulator piston and spring.
No. Name
1 For low-reverse brake
2 For underdrive clutch
3 For second brake
4 For overdrive clutch
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
TFA1387Fluid temper-ature sensor
Steel balls
Second brake retainer oil seal
Strainer
4321
��������� ��������� � ��� � ����#��##��� ������&
��-�%�"� ��� � ��� � ��� ��"�� ����� ��������.�%�"� ��� � ��� � ��� ��"�� ����� � � ��� ���$� �
���� ���
����%�"� ��� ��3�� � "����� ���� � � �� � ������, �������� � � ��� ��"� ��� ��3�� � "��������� ��
����%�"� ��� )��� �� �� ��������
����%�"� ��� ������� ���� � � ��� ��������� �� ������0 1 ����4%1 ���� C0 1 �D� � � �
�� �%�"� ��� ������� ����� C0 1 �� 0 1#�D
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
=��$� ����� ��
4� ��� � �����"�� �����
)��� ��
'������
��������� ��������� � ��� � ����#��##���������(�
��#�%�"� ��� �� �������
��*�%�"� ��� �� ��� � �� � ���� �* ����������+�! ����� ��� ������� �� �4/--,���� � ��� ��� 1�
��,�'���� ��� ������� �� � ��"� ��� �� ������-�%�"� ��� �� ��� ���$���
��.�%�"� ��� ������ ������ F��
����E�� ��� � ��� ������ � � ��� ��"� ��� � ������"��������
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
4/--,���
������������ F�
��������� ��������� � ��� � ����#��##��� ������((
����%�"� ��� ������ ����� � F��
����%�"� ��� � ������"� ������ ����
�� �%�"� ��� ���� �"�����#�%�"� ��� ������ ���� F,���*�%�"� ��� ���� �� �� � ����������+�%�"� ��� � ��� ����� ���� ����� ��
��,�%�"� ��� )��� �� �� ��������
��-�%�"� ��� ��"���� � � "�����"� ������ � � ��� ����������� � F+�
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
������ ����� � F�
)��� ��
����������� � F+
��������� ��������� � ��� � ����#��##���������(�
� .�%�"� ��� "�����"� ������ ��� � � ��� ������ ����� �F*�
� ��%�"� ��� ������ ����� � F#�
� ��%�"� ��� ��� ����� ��"���� �� �����
� ��%�"� ��� � �� �� ��
� �%�"� ��� ��� � ���$� ���� � � ��� ����� ���� ��
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
����������� � F*
������ ����� � F#
��������� ��������� � ��� � ����#��##��� ������(�
� #�%�"� ��� �������� ������ ���$� ����� � � ���$����������
�, �� -��?� $�#2# ��$ /����#
4��� 2��$� ���� 2��$� ����� =������������
0 1 � � � �
0 1 � � � �
0 1#� � �
� *�%�"� ��� "�����"� ��� ����� ������� C0 1 �� 0 1 ���� � 0 1 ��� ������ ����� ������D � ��� ����� �������������� C0 1 ��� ���� ����� ������ � � 0 1#�D�
� +�%�"� ��� ����� ��� ����� ������� � � ��� ������ ����� �F � C0 1 �� 0 1 ��� � � 0 1 ��� ������ �����������D
� ,�%�"� ��� � ������"� �� ���� � � ��� ������ ����� �F� �� ��� ����� ��� ����� �������� C0 1 �� 0 1 ���� � 0 1 ��� ������ ����� ������D
� -�%�"� ��� � �� �� ��
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
����������� � F�
��������� ��������� � ��� � ����#��##���������()
�#.�%�"� ��� ������ ����� � � ��� ���$� �����
�#��%�"� ��� � �� �� ��
�#��%�"� ��� ���$� ������� ���$� ����� � � �������� ������
�, �� -��?� $�#2# ��$ /����#
4��� 2��$� ���� 2��$� ����� =������������
0 1 � � �
0 1 ��� # �
0 1 ���� 0 1#� * # �
�#��%�"� ��� ��"� ���� ��
�# �%�"� ��� ���$� � ���� ������ � � ��� ��"� ��������� � � ���� ��
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##��� ������('
�##�%�"� ��� �� ���$� � ����� ������ ������� � � ��� ��"� ��� ���$� � ���� ���� � � ���$� � ����� �������
�#*�(�� ��� ������� �� � ��"� ��� � �� �� ���#+�%�"� ��� ����� ������ � �� ���� C0 1 ��� ����
����� ������ � � 0 1#�D� )��� � C0 1 ��� ���� ����� ������ � � 0 1#�D� ���� � ����� ��� ����� ���� �� � ��� �����"���� ���$� ���� �
�#,�%�"� ��� ��� ���� ���"� ���� ����� � � �� � ������ �����A0 1 �� 0 1 ��� � � 0 1 ��� ������ ����� ������A
%�"� ��� � �� � �����0 1 ��� ���� ����� ������A 0���� ��"� � � �����
��� ��� ��� ���� �7, ��� � #�� � � ��"� ������� � � � � ���� �+ ���� � ������
0 1#�A 0���� ��"� ����� ��� ��� ��� ���� �7, ��� � #�� � � ��"� ��� ���� � � ���� �, ���� � ������
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
42--�*�,
1 )�)(> )�)��( ��$ )�)��� 8��.�+�����8�9 2�+�2.4
4/--,-�
4/--,-.�
1 )�)��� 8��. ����8�9 2�+�2.44/--,-�
1 )�'(4 4/--,��,
4/--,-�
��������� ��������� � ��� � ����#��##���������(7
�#-�%�"� ��� ��� ���� ���"� �����
�*.�%�"� ��� ����
�*��'�������� ��� ��$� � ��� � ��� ����� ����� ��$ ���
�*��(�� ��� ������� �� � ��"� ��� ����� ����� ��$ ���
��+�����.� ��2? �+� �# � �����.��$�$ #2��8,
1 )�)(> )�)��( ��$ )�)��� 8��.�+�����8�9 2�+�2.4
1 )�)��� 8��. ����8�9 2�+�2. ��$ )�'(4
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
42--�*�#
42--.*.+
��������� ��������� � ��� � ����#��##��� ������(7�
�*��%�"� ��� ����� � ����� �� � �� � ����
�* ���� ��� ���� � ��� ����� ����� � ��"� ��� ����������� ����� ����� ����� � � � ��� ������
�*#�%�"� ��� ������ � � ��� ���� ������**�%�"� ��� � �� �� ��
�*+�%�"� ��� ������� ���� ����� � ���� ���� � � �������� ��� ��3�� � "����� ��� �� C0 1 �� 0 1#�D
�*,�%�"� ��� ������� ���� ����� � ���� ���� �� ������ ����� ����� C0 1 �� 0 1#�D
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##���������(7-
�$$�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
! �� �� ���� ��� $
��������� ��������� � ��� � ����#��##��� ������(3
��� �:�<
��+����(, �"�� ��+#� �.� 5�#?��> �����5> ��� #���> ��2, ��8�9#
��/��2� 8��. � ��8 ��� 8.�� ���##��-���5,�, �"�� +#� 5���#� ��.�� �.�� -�+� /�������+� @���9
��$ 8.��� 0�#�����,�, �//�9 �� �� ���2���� 2��/�����#> �������5 /���#> ��$
#��$��5 /���# -����� ��#���������, �����#� � ��8 2�+�2.$�#2 �� -��?� $�#2 �� �� ��� �� ���#� �8� .�+�# -������##��-���5 �.��,
), �"�� �//�9 #������ �� �$.�#�"� �� 5�#?��#,', �.�� ��/��2��5 � -+#.��5> ��/��2� �.� �##��-�9
8.�2. �� -����5# ��,7, �"�� +#� ��9 2���. 5��"�# �� ��9 ��5# $+���5
���##��-�9, �#� �9��� 2���. �� /�/�� ��8��# �� 9�+���$ �� +#� #����.��5,
3, �.��5� �.� ��� �� �.� 2����� #9#���,
��� (�� ��� ������� ��� � ��� ��� ������� ���� ����� � �������� � ��� ��� ����� ����� C0 1 �� 0 1#�D
4��� '������ ��� ?�
0 1 � 42--.-�#� 42--.-�,
0 1#� 42--.-�*� 42--.-�,
��� (�� ��� ������� ��� � ��� ��� ����� ����� ����� � �������� � ��� ��� ����� �����
��� ! ����� ��� ���� ������ � � � �� �� ��
� � (�� ��� ������� �� � � ����� ��� ��� ���� ���"� �����C0 1 � �� :� � �--,� 0 1 ��� �� :� � �--,�0 1 ��� ���� ����� ������ � � 0 1#�D
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
42--.-�,
42--.-�# �42--.-�*
42--.-�,
42--.-�.
42--, ��
��������� ��������� � ��� � ����#��##���������(6
� �������� ��� � �� � ���� � ��� ��� ���� ���"� ��������� � � ��� ��������� ��3��� C0 1 � �� :� � �--,�0 1 ��� �� :� � �--,� 0 1 ��� ���� ����� ������� � 0 1#�D0 1 � � � 0 1 ��� G � �� � ����0 1 ��� ���� ����� ������ G + � �� � ����0 1#� G , � �� � ����
�#� ! ����� ��� �����"���� ���$� ���� � ����� ���� � � ����� � ����� ���
�#��9���$ ��� ������ � � ��� ��� �������� ����� � ��� ����� ������ � �� ����� ! ����� ��� ����� ������ � ������ ���� )��� � � ��� ��� ���� ���"� ���� ����� � ����� ��� ����� ���� �� � ��� 1 � 1 �� �� C0 1 ��� ���� ����� ������ � � 0 1#�D
�#��(�� ��� ������� ��� � � ����� ��� � �� �� ��
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
1 )�)��� 8��. ����8�9 2�+�2. ��$ )�'(4
!�� �������� �����
��� ����� ����
�
�
42--�*�,
1 )�)(> )�)��( ��$ )�)��� 8��.�+�����8�9 2�+�2.4
42--,-�
4/--,-� 4/--,-.�
1 )�)��� 8��. ����8�9 2�+�2.4
��������� ��������� � ��� � ����#��##��� ������(&
�*� ! ����� ��� ��"� ���� ��
�+� ! ����� ��� ���$� ����� ���$� ����� � � ������� �� � �� �� �� � �� ��� � ��� �������
��+������ ��2�##��9> ��?� �.� ���#+������# �� #��/# & ��(6 ����� ��/��2��5 �.� /��##+�� /����> -��?� /���� ��$-��?� $�#2,
?)�6/ � � ����� ��� �������� ����� �� ���� ����
+�-�� �� -��?� $�#2# ��$ /����#
4��� 2��$� ���� 2��$� ����� '������ ��
0 1 � � �
0 1 ��� # �
0 1 ���� 0 1#� * # �
�,� ! ����� ��� ������ ����� � � ��� ���� � �� �� ���-� 4"� ��� ������� �� � ������ ��� � � ����� � � ���
������� ��� � �� �� � � ������� � ���� �,� � ��@��� ���� � ���� � ��� ���� "�����
����$��$ "��+�A � � �,(7 ��
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,-�
1 )�'(4 4/--,��,
' �� �� �
42--�*��
1 )�)( +/ �� !�2, (&&3> )�)��( +/ �� !�2, (&&3
%����� �����
�01�+++
��$ )�)��� 8��.�+�����8�9 2�+�2.4
' �� �� �
42--�*��
1 )�)( ����*��, (&&64
%����� �����
42--�*��
1 )�)��( ����*��, (&&64
' �� �� �%����� �����
��������� ��������� � ��� � ����#��##���������(&�
��.�! ����� ��� ���$� ����� ���$� ����� � � ������� ��42--�*�� C0 1 �� 0 1 �D � 42--�*�� C0 1#�D ����� � ��� �������
+�-�� �� -��?� $�#2# ��$ /����#
4��� 2��$� ���� 2��$� �����
0 1 � � �
0 1 � � �
0 1#� �
����! ����� ��� ����� ���� �� ��� � ���$� ���� � � � ���� ��
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
1 )�)��� 8��.����8�9 2�+�2.4 ' �� �� �
%����� �����
42--�*��
' �� �� �
1 )�'(4
%����� �����
42--�*��
' �� �� �
42--�*��
1 )�)( +/ �� !�2, (&&3> )�)��( +/ �� !�2, (&&3��$ )�)��� 8��.�+� ����8�9 2�+�2.4
'�� � ���$�����
%���� ���� �
�01�++,
1 )�)( ����*��, (&&64
' �� �� �42--�*��
'�� � ���$�����
%���� ���� �
' �� �� �42--�*��
'�� � ���$� ����
%���� ���� �
1 )�)��( ����*��, (&&64
��������� ��������� � ��� � ����#��##��� ������(&-
����4"� ��� ������� �� � � ������ ��� "�� ��'����� � �������� ����� ���� ����$ ��� ������ ��� ��� ������� �� � � "�� � �� ��� ����� �������
����$��$ "��+� �� ��$ /��9 �������2��A�,)& � �,&' �� 1 )�)(4�,3& � (,�' �� 1 )�)�4(,�& � (,'' �� 1 )�'(4
%��##+�� /���� ��� )�)( ��$ )�)�
4"�� � �� � ����$ ��� !/ ���� =��� ?�
0 1 � 0 1 �
.�� � .�# .�* � .�, ��* & 4/+#-#*+
.�# � .�+ .�, � ��. ��, � 4/+#- �
.�+ � .�- ��. � ��� ��. . 4/+#- �#
.�- � ��� ��� � �� ��� � 4/+#- �*
��� � ��� �� � ��* �� 4/+#- �+
��� � ��# ��* � ��, ��* * 4/+#- �,
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
1 )�)��� 8��. ����8�9 2�+�2.4
' �� �� �42--�*��
'�� � ���$� ����
%���� ���� �
42--�*��
1 )�'(4
' �� �� �
'�� � ���$� ����
%���� ���� �
42--�*�� �42--�*��
42--�*��
�01�++-
1 )�)( +/ ��!�2, (&&3> )�)��( +/ �� !�2,(&&3 ��$ )�)��� 8��.�+�����8�9 2�+�2.4
4"�� ��� �
4"�� ��� �
1 )�)( ���� *��, (&&64
��������� ��������� � ��� � ����#��##���������(&2
%��##+�� /���� ��� )�'(
4"�� � �� � ����$ ���
!/ ���� =��� ?�
��� � ��� ��, 6 4/+#- �#
��� � ��# ��. / 4/+#- �*
��# � ��+ ��� 9 4/+#- �+
��+ � ��- �� 2 4/+#- �,
��- � ��� ��* 1 4/+#- �-
��� � ��� ��, . 4/+#- �.
����%�"���� ��� ��� ����� ��� �! ����� ��� ������� �� �4/--,-��� � � ���� ������ � �
��� "� ��� ������� �� �42--�*�� � 42--�*���� � ������ ��� "�� ��'����� � �������� ����� ���� ����$ ��� ������ ��� ��� ������� �� � � "�� � �� ��� ����� �������
����$��$ "��+� �� ��$ /��9 �������2��A(,�' � (,'( �� 1 )�)(4(,�' � (,6( �� 1 )�)��(4(,7' � �,(( �� 1 )�)��� ��$ )�'(4
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
1 )�)��( ����*��, (&&64
4"�� ��� �
1 )�)��� 8��. ����8�9 2�+�2.4
4"�� ��� �
1 )�'(4
4"�� ��� �
4/--,-��
42--�*�� �42--�*��
4/--,-��
42--�*���01�+,.
1 )�)( +/ �� !�2, (&&3> )�)��( +/ �� !�2, (&&3��$ )�)��� 8��.�+�����8�9 2�+�2.4
4"�� ��� �
��������� ��������� � ��� � ����#��##��� ������(&$
%��##+�� /���� ��� )�)( ��$ )�)�
4"�� � �� � ����$� !/ =��� ?�
0 1 � 0 1 ��� 0 1 ��� ���
����
.�+ � .�- ��. � ��� ��� � ��# ��* & 4/+#-#*+
.�- � ��� ��� � �� ��# � ��+ ��, � 4/+#- �
��� � ��� �� � ��* ��+ � ��- ��. . 4/+#- �#
��� � ��# ��* � ��, ��- � ��� ��� � 4/+#- �*
��# � ��+ ��, � ��. ��� � ��� �� 4/+#- �+
��+ � ��- ��. � ��� ��� � ��# ��* * 4/+#- �,
��- � ��� ��� � �� ��# � ��+ ��, , 4/+#- �-
��� � ��� �� � ��* ��+ � ��- ��. / 4/+#- �.
%��##+�� /���� ��� )�'(
4"�� � �� � ����$ ���
!/ ���� =��� ?�
��. � ��� ��* 0 4/+#-#*,
��� � �� ��, 6 4/+#- �#
�� � ��* ��. / 4/+#- �*
��* � ��, ��� 9 4/+#- �+
��, � ��. �� 2 4/+#- �,
��. � ��� ��* 1 4/+#- �-
��� � �� ��, . 4/+#- �.
�� � ��* ��. � 4/+#- ��
��#�%�"� ��� ����� � ������� �� ����� �*� � �� ����*�! ����� ��� ����� ����� � ��� ��� ����� ���� � � ������
��� � �� � ���� � ��� ����� ����� ����� � ����� ��� ��� ��������� ��3���
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
1 )�)( ���� *��, (&&644/--,-��
4"�� ��� �
42--�*��
1 )�)��( ����*��, (&&64
4"�� ��� �
4/--,-��
42--�*��
4"�� ��� �
4/--,-��1 )�)��� 8��. ����8�92�+�2.4
42--�*��
1 )�'(4
4"�� ��� �
4/--,-��
42--�*��
��������� ��������� � ��� � ����#��##�����������
��+�(�� ��� ������� �� � � ����� ��� ����� � � ����� ���������� � � ��� ����� ������
��,�1���� 1�0 � � �� ��$ ��� � � ��� ��� ������� ��� ������ ��� ��$ �� � ��� ��������� ��3��� ��� ��� ���$ � ��� � � � ������ � ��� ��������� ��3�� ���� �
��+�����.� ��2? �+� �# � �����.��$ #2��8,
��-�4"� ��� ����� ����� � ������ ������ � �� � �1��� � ��� ������� ��� ������ � ������� � ���� ��� ����� �� � ����� ����$ ��� �� ����� ��� ����� � "�����
B� ��/������5 ���+��� C : ��.�2?��## �� �.� ��$ #/�2���C �,�( ��� �� B� ��/������5 ���+��� C : ��.�2?��##�� �.� ��$ #/�2��� C �,�& ��D
��.�'��$� ��� ��$ �� ���� � �� �� ��� ��������
����! ����� ��� ��� �� ��� � ��� �������
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,�#.
42--�*�#42--.*.+
42--.-�,
��# � ��.
42--.-��
��������� ��������� � ��� � ����#��##��� �������(
����(�� ��� ������� �� � � ����� ��� ��� ���� ���"� �����C0 1 � �� � /��� �--+� 0 1 ��� �� � /��� �--+ � �0 1 ��� ������ ����� ������D
���������� ��� ��� � �� � ���� � ��� ��� ���� ���"� ����� ��� ��������� ��3��� C0 1 � �� � /��� �--+� 0 1 ����� � /��� �--+ � � 0 1 ��� ������ ����� ������D
�� �! ����� ��� ���$� � ����� ������� � � ���� �� ��� � �������� ���$� � ���� ������
��#�! ����� ��� ���$� � ����� ������� � � ��� ��� �� ���$� ������ ������ �������
��*�! ����� ��� � ������"� �� ���� � � ������ ����� � F�� ��� ����� ��� ����� �������� C0 1 �� 0 1 ��� � �0 1 ��� ������ ����� ������D
��+����:� 2����+� �-�+� �.� ��#��������� $���2���� �� �.� �.�+#�-�����5,
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
42--, ��
=��$� � ���� �����
=��$� � ����������� �����
������ ����� � F�
��������� ��������� � ��� � ����#��##�����������
E6 E3 E7 E' E) E� E� E(
1 )�)(> )�)�4
�! �� ������ � �;��� : ����> �;��� �� �> �! �;��� ���; �
'���� )�/� !�/� ����$�
��� =��� ���� '���� )�/� !�/� ����$�
��� =��� ����
��, 4/+# #.- ��* 4/+.+�*+
��. 4/+# #., ��+ 4/+#-*,�
��� 4/+# #.+ ��, 4/+��.* F� #- +
�� 4/+#�+-� ��- 4/+# +-
��* 4/+#�+- ��. 4/+.+�*,
��, 4/+#�+-# ��� 4/+# +-#
F� - �* ��* 4/+#*, *F, ,�- �+
��� 4/+��.*#
F� - �* ��* 4/+#*, * ��� 4/+# +-*
F #�� �� ��� 4/+#+* + �� 4/+� �#,
F# - �* ��* 4/+#*, * ��# 4/+# +-+
F* - �* ��* 4/+#*, *
F+ #- �+ ��, 4/+# #-#��* 4/+# +-,
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##��� ���������
E6 E3 E7 E' E) E� E� E(
1 )�'(4
�01�-,-
�! �� ������ � �;��� : ����> �;��� �� �> �! �;��� ���; �
'���� )�/� !�/� ����$�
��� =��� ���� '���� )�/� !�/� ����$�
��� =��� ����
��, 4/+# #.- ��* 4/+.+�*+
��. 4/+# #., ��+ 4/+#-*,�
��� 4/+# #.+ ��, 4/+��.* F� #- +
�� 4/+#�+-� ��- 4/+# +-
��* 4/+#�+- ��. 4/+.+�*,
��, 4/+#�+-# ��� 4/+# +-#
F� - �* ��* 4/+#*, *F, ,�- �+
��� 4/+��.*#
F� - �* ��* 4/+#*, * ��� 4/+# +-*
F ##� �,�# ��� 4/+*�*,� �� 4/+� �#,
F# #+ �,�# �� 4/+#,##* ��# 4/+# +-+
F* #+ �,�# �� 4/+#,##*
F+ #- �+ ��, 4/+# #-#��* 4/+# +-,
�$$�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##�����������-
�$$�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
! �� �� ���� ��� $
��������� ��������� � ��� � ����#��##��� ��������
��+�! ����� ��� ����� ��� ����� ������� � � ������ ����� � F �C0 1 �� 0 1 ��� � � 0 1 ��� ������ ����� ������D
��+����:� 2����+� �-�+� �.� ��#��������� $���2���� �� �.� �.�+#�-�����5,
��,�! ����� ��� "�����"� ��� ����� ������� C0 1 �� 0 1 ���� � 0 1 ��� ������ ����� ������D � ��� ����� �������������� C0 1 ��� ���� ����� ������ � � 0 1#�D�
��-�! ����� ��� ��� ����� ��"���� �� �����
��.�! ����� ��� ��"� ���� ��
����! ����� ��� �������� ������ ���$� ����� � � ���$� ������
+�-�� �� -��?� $�#2# ��$ /����#
4��� 2��$� ���� 2��$� ����� =������������
0 1 � � �
0 1 ��� # �
0 1 ���� 0 1#� * # �
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
����������� � F
��������� ��������� � ��� � ����#��##����������)
����! ����� ��� � �� �� ��
����! ����� ��� ������ ������
�� �! ����� ��� � �� �� ��
��#�! ����� ��� ���$� ����� ���$� ������ � � �������� ������
��*�! ����� ��� ����� ���� � � � ��� � ���$� ���� �
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ����#��##��� �������'
��+�! ����� ��� � �� �� ��
��,�! ����� ��� ������ ����� � F#�
��+����:� 2����+� �-�+� �.� ��#��������� $���2���� �� �.� �.�+#�-�����5,
��-�! ����� ��� "�����"� ������ ��� � � ������ ����� � F*� ��� ��"���� � � "�����"� �������
��+����:� 2����+� �-�+� �.� ��#��������� $���2���� �� �.� �.�+#�-�����5
� .�! ����� ��� ��"���� � � "�����"� ������� � � ������ ����� �F+�
��+����:� 2����+� �-�+� �.� ��#��������� $���2���� �� �.� �.�+#�-�����5
� ��! ����� ��� ����� )��� ���
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
������ ����� � F#
������ ����� � F+
)��� ��
��������� ��������� � ��� � ����#��##����������7
� ��(�� ������� �� � � ��� ��� � ��� ����� ����� � � ������� �"���
� ��! ����� ��� ��� ���� �� �� � ��� ��"�� � ��� ���� �"���
� �! ����� ��� ��� ��� ������ ���� F, �����$ ��� ��* A ����?� 4/+.+�*+� ������ ����� � F+� ��� � ����� ������� �"�� � � ������ ��� ���� � ��� ��������� ��3���
� #�4������ � � ���� � ��� � ������"� �� ���� � � �������� ������� � "�����
?)�6! ������ � ��� � ������"� ������ ��� �$�� �� ���� ������� ��� � � ���� � ��� � ������"� �� �����
����$��$ "��+�A �,�' � �,)' ��
'����� � ������ ���� F, ���� ����$ ��� ������ ��� ��� ������� "���� �� ��� ����� ����� � � ���������� ������ ���� � ������� � ���� � � ���� ��� �������� ��
4������� � "���� ����$ ��� =��� ?�
.�� � .� ��* 4/+.+�*+
.� � .�# ��+ 4/+#-*,�
.�# � .�* ��, 4/+��.*
.�* � .�+ ��- 4/+# +-
.�+ � .�, ��. 4/+.+�*,
.�, � .�- ��� 4/+# +-#
.�- � ��. ��� 4/+��.*#
��. � ��� ��� 4/+# +-*
��� � ��� �� 4/+� �#,
��� � ��� ��# 4/+# +-+
��� � �� ��* 4/+# +-,
� *�'3���H� �� ��� ��3��� ���$�� � ��* � �������� � ����� �� � ��� ��� �� �� � ��� ���� �"���
��F+�$ 5�#?��A�����:��;� 5��+��� #������ %��� �, �!&3))�(�� �F+�"�����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
42--.-�,
( ������"������� ���
��������� ��������� � ��� � ����#��##��� �������3
� +�! ����� ��� ���� �"��� � � ������ ��� � �� � ���� ���� ��������� ��3���
� ,�! ����� ��� � ������"� ������ ����
� -�! ����� ��� ������ ����� � F��
��+������#���� �.� �.�+#� -�����5 �� 2����2� $���2����,
�#.�E�� ��� � ��� ������ � � � ����� ��� � ������"� �������
�#.�� =���� �� ����� � ����� I���� �. � �� ���� ��#� �������J ��� � ������"� ������ ����� �� �� ��� � ��� ���������� �
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
������ ����� � F�
( ������"������� ����� ��
�� ������ �����
! ��� �����
��������� ��������� � ��� � ����#��##����������3�
�#.�� ! ����� ������� �� � ��� ����������� �������#.�� ! ����� ��� �� ��� � ��� ��� ����� �����
?)�6/ � � ����� ��� �� ��� ���$�� �� ���� ����
�#.�� ������ ��� �� ��� � �� � ���� �* ������� � ������������ ��3���
�#.�� %�"� ��� �� ��� � �� � ������#.�� (�� � ������� ��� ��"� ��� �� ���� � � ��� ��$�
�� ��� ������� �������
�#.�� (�� � ������� � ������ ��� ����$ ��� � ���������� ����� ����� � � ����� ��� ������� "�����
�#.�� '����� � ������ ������ F � ���� ����$ ��� ������ ��� ��� ������� "���� �� ����� �����
4������� �"����
����$ ���
!/ ���� =��� ?�
���# � �� # ��, �, 4/+# #.-
�� # � ��*# ��. �. 4/+# #.,
��*# � ��,# ��� �� 4/+# #.+
��,# � ��.# �� � 4/+#�+-�
��.# � ���# ��* �* 4/+#�+-
���# � �� # ��, �, 4/+#�+-#
�#��! ����� ��� ���� ������ ������ F� ���� ��� �������� � ���� �#.�� ��� � ������"� ������ ����� ���
4/--, ��
4/--,���
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
������������ F�
��������� ��������� � ��� � ����#��##��� �������3-
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
! �� �� ���� ��� $
��������� ��������� � ��� � ����#��##����������6
�#��(�� ��� ������� �� � � ����� � �� �� ��� ���$��� � �� ����
��+�����"�� ��+#� �.� ��$ 5�#?��,
�#�������� ��� �� ���� �� ����� � ��� ��������� ��3���
�# �4�$� ���� ���� ��� � ��� ����� � � �������� ��� ��� ����"�����
����$��$ "��+�A �,3� � (,)' ��
�##�! ����� ��� �� �������
�#*�! ����� ��� ������ �0 1 ����4%1 ���� � � ��� ���������� ����� C0 1 �D
�#+�! ����� ��� ������� ����� C0 1 �� 0 1#�D
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--, ��
1 )�)(4
1 )�)�> )�'(4
��������� ��������� � ��� � ����#��##��� �������&
�#,�! ����� ��� ���#������$ ������� C0 1 ����4%1 ��D�#-�=���� � ����� ������� �. � �� ���� � � ��������
��� ������� ���� �� ��� � ��� ������� C0 1 �D
�*.�=���� � ����� ������� �. � �� ���� � � ��������� � ���� ���� ��� ��3�� � "����� ���� � �� ��� � ��� ������� C0 1 �� 0 1#�D
�*��! ����� ��� ��3�� � "����� ���� � � ��� ��� ����� ���� ������ ������ � ����� �� ������ ��� � �� � ����� ��� ��������� ��3���
�*��&�� ��� ����� � � ��"� ��� ���� ���� C0 1 ��0 1#�D � � ������
�*��(�� � ������� � ������ ��� ����$ ��� ��� � ���������� ������ '����� � ������ ����� ����$ ��� �� ����� ��� ����� � "�����
)�)(�� � �,�)' ��� �� �� � �,(7' ���
)�)�> )�'(�� C �,�)' ��� �� �� C �,(�' ���
�* �=���� ��� ������ �������� � ��� ��"� ����� C0 1 �D
�"�#�$%� &'()� � *+�, �������#+-�#.� �����# ���/�������
'�����
'�����
'������
��������� ��������� � ��� � ����#��##�����������
�*#�'�� ��� ������ �������� � ���� �*�� � � � ����� ��� �������� � ��� ��3�� � "����� ���� �� (�� ��� ���������� � ����� � ��� ���� ����� C0 1 �� 0 1#�D
4��� '������ ��� ?�
0 1 � 42--.-�#� 42--.-�,
0 1#� 42--.-�*� 42--.-�,
�**�'3���H� �� ��� ��3��� ���$�� � ��* � �������� � ����� �� � ��� ��� �� �� � ��3�� � "������
��F+�$ 5�#?��A�����:��;� 5��+��� #������ %��� �, �!&3))�(�� �F+�"�����
�*+�! ����� ��� �� )��� ���
�*,�! ����� ��� ��3�� � "������ � � ��� ������ ��� �,� �� � ���� � ��� ��������� ��3���
�*-�! ����� ��� � ��� � ��� ��"�� ����� � � ���$� � �������
�+.�! ����� ��� � ��� � ��� ��"�� ����� ������
�"�#�$%� &'()� � *+�, �������#+-�#.� �����# ���/�������
42--.-�,
42--.-�# �42--.-�*
)��� ��
=��$� ����� ��
4� ��� � �����"�� �����
��������� ��������� � ��� � ����#��##��� �������(
�+��! ����� ��� ��������� ���� �� �� ���� �� ��� � ����� ���
?)�6��� ��������� ���� �� ��� ��� ������ �� ��� � ����������
?� ?��
� 0� �����"���� ���$�
� 0� � ������"� ������
� 0� ��� � ���$�
0� "�����"� ������
�+��! ����� ��� ����� �� � � ��� � ���$� ����� �� �� �����
�+��! ����� ��� ��� �� "��"� ��� ���� � � ��� ������ ���� �� �� � � ��� � ���� ��"��
�+ �! ����� ��� "��"� ���� ���$��� � � �� ����� ������
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
( � � )
)��(
'���� ��
'�� � ���$������ �� �� ����
'���� �����
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-32
(75)Install the fluid temperature sensor. (This step isunnecessary if the sensor is incorporated in the solenoidvalve harness).
(76)Install the 28 mounting bolts of the valve body.
(77)Attach the solenoid valve harness to the valve body byconnecting the fluid temperature sensor (only in theharness that incorporates the sensor) and all theconnectors.
No. Parts to beconnected
Cable colour Connectorhousingcolour
1 Underdrivesolenoid valve
White, red, red Black
2 Overdrivesolenoid valve
Orange, red Black
3 Low-reversesolenoid valve
Brown, yellow Milky white
4 Second solenoidvalve
Green, red, red <up to Nov. 2000>
Blue, red, red <from Dec. 2000>
Milky white
5 Damper clutchcontrol solenoidvalve
Blue,yellow, yellow
Black
6* Fluid temperaturesensor
Black, red Black
*: Not applicable to type with solenoid valve harness incorporatingfluid temperature sensor
(78)Install the manual control shaft detent spring and detent.<Model 1996>
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
TFA1387Fluid temper-ature sensor
5
4
1
3
2
6
Manual controlshaft detent
Manual control shaft detent spring
AUTOMATIC TRANSMISSION (E–W) – Transmission 23A-3-33
Install the manual control shaft detent. <from Model 1997>
(79)Apply the liquid gasket to the valve body cover.
Liquid gasket:MITSUBISHI genuine sealant Part No. MD974421or equivalent
(80)Install the valve body cover, and then tighten its mountingbolts to the specified torque.
(81)Install the speedometer gear or sealing cap.
(82)Install the inhibitor switch and manual control lever.
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
TFA1877
Manual controlshaft detent
Manual control lever
Inhibitorswitch
AUTOMATIC TRANSMISSION (E–W) – Transmission23A-3-34
(83)Install the input shaft speed sensor and output shaft speedsensor.
(83a) Press in the air breather (A) until it becomes flush withthe transmission case (B) as shown in the drawing. <Airbreather type>
(84)Apply a small amount of ATF to the oil filter gasket. Tightenthe filter to the specified torque. <Externally mountedtype>
(85)Install the eye bolt, a new gasket, and the oil cooler feedtube.
(86)Install the oil dipstick.(87)Install the brackets.
(88)Install the torque converter, and secure it so that theshown dimension (A) meets the reference value.
Reference value: approx.12.2 mm <F4A41, F4A42>approx. 9.4 mm <F4A51>
CautionApply ATF to the oil pump drive hub before installingthe torque converter. Be careful not to damage theoil seal lip when installing the torque converter.
RevisedPWEE9514-J� Jun. 2003Mitsubishi Motors Corporation
Input shaft speed sensor
Output shaft speed sensor
A AB B
A
��������� ��������� � ��� � ��� %+�/ ����)�(
), ��� %��%!����� �:�< �! ��� �:�<
( ��
)
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
!�#�##��-�9 #��/#�:� �� )��� �
�� '��� �� ���� �� )�� ����
� )�� ��� �������
��� �:�< � 0�� %���������� � �� ����������
�:����� ����������! ����� � �� )��� � � ��� ���� ��"� � ��� �� ����� � ����� 1�0 � ��� )��� ��
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,��
��������� ��������� � ��� � ��$��$��"� ��+�2. ��$ ��/+� �.��� ����'�(
', �! !�0 �����; �! �%�� �;� � ������&��(&
!����� �:�< �! ��� �:�<
(� 7
(�
()6
�((('
(�&
')
(�3
6(�
&(((�
(�()
('
�
�
('
)
7
3
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
+�-�� �� 2�+�2. $�#2# ��$ /����#
4��� 9����� ���� 9����� ����� 9����� ������ �����
0 1 � � � �
0 1 ��0 1#�
�
!�#�##��-�9 #��/#�� ' �� �� ��� ! ��� ������� '��� �� �
�!� � ' �� �� ���� #� 9����� ������ �������� *� 9����� ������� +� 9����� �����
��� �:� ,� ' �� �� �
-� '��� � ����� ����� �.� /��� �
��� %���� ���� ���� ( ������"� ������ ����
��� ��� /��� ���� � � /��� �
�#� ( ������"� ������ ����� ��
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
��������� ��������� � ��� � ��$��$��"� ��+�2. ��$ ��/+� �.�������'��
!����� �:�< � 0�� %���������% �� ��0��
��� �:�< � 0�� %�������!��� ����������1���� 1�0� ���� �������� @���� � ����� 5����� � � /��� ��� � � ����� ����������
�:���% �� ����������
��������; %��� G�����; !���G�����; ����� %��� ����������
��� 1��� ���� ����� ���� � ���� ����� 1� � ��� ������ ������������ ���� � � ������ ������ ����� � ��� ������������� �� ��� ����� 2� � ��� � ������"� ����������� ���
��+���������#� �.� 2�+�2. $�#2 �� �� -����� �##��-���5��,
��� ! ����� ��� ������ ������ ����� � ��� ��� ������� �
+�-�� �� 2�+�2. $�#2# ��$ /����#
4��� 9����� ���� 9����� ����� 9����� ������ �����
0 1 � � � �
0 1 ��0 1#�
�
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
4/--,-� 4/--,-.+
4/--,-� 4/--,-.+
� :
9����� ������ '���� ��� 9����������� �����
K%L � K>L
9����� �����
��������� ��������� � ��� � ��$��$��"� ��+�2. ��$ ��/+� �.��� ����'��
�!���% �� ����������9���$ ���� ��� ������ �� ������ ��� � �� �� � � � ��������� ������ ����� �� ����� ��� ��� ���� "����� >�� ������ � ��� ������ ��� ��� ��� ������� �� � ����� ��������� ������ ����� �"� ��� !� � ����� ��� ��� ���� "����������� � � �� �� � � ��@����
����$��$ "��+�A(,� � (,) �� 1 )�)(4(,7 � (,6 �� 1 )�)�> )�'(4
4��� '������ ��� ?�
0 1 �� 0 1 � 42--�*�,� 4/--,-�
0 1#� 42--�*�-� 4/--,-�
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,-�
42--�*�, �42--�*�-
��������� ��������� � ��� � �"��#� ��$ �"��$��"� ��+�2. ����7�(
7, 0 � �! �0 !�0 �����;!����� �:�< �! ��� �:�<
( �
�
)
' 7
3
6
(�((
(�
(�()
('
(7
(3
(6
(&
��
(
�
�
)
'
7
3
(�
('
(3
(&��
(�
(6
(7
()6
(�
((
6 C0 1 �D �& C0 1#�D
6 C0 1 �D � & C0 1#�D
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
+�-�� �� 2�+�2. $�#2# ��$ /����#
4��� =������������
9���������
9����������
9����������� �����
)"��� 0 1 � � � � ����"� 0 1 � � �������
0 1#� � � �
%�"���� ������ � � � �
!�#�##��-�9 #��/#��� �� ' �� �� �� � �� 9����� ������ ������ � �� 9����� ����� � � 9����� ������ � #� ' �� �� ��!� *� 9����� ������ ������!� +� 9����� �����!� ,� 9����� ������!� -� =������� ����� C0 1#�D
��� ��� �.� ' �� �� ���� '��� � ����� ��
��� ��� /��� ���� %���� ���� �� � )"�����"� ������ ����
��� �#� /��� ��:� �*� %�"���� ������ ���� ��� �+� /��� �
�,� %�"���� ������ ����� ����� �-� /��� ���� �.� /��� �
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � �"��#� ��$ �"��$��"� ��+�2.����7��
!����� �:�< � 0�� %��������% �� ��0��
��� �:�< � 0�� %�������!��� ����������1���� 1�0� ���� �������� @���� � ����� 5����� � � /��� ��� � � ����� ����������
�:� 0 � �����; %���� ����������1��� ��� ���� ��������� �� ���� ������ 1 � � 2� � �����"���� ������ ���� � � ��� ��"���� ������ ����� �� �������� ����
�����% �� ������������� '�� ������� ��� �� ��� � ��� ���������� ���� ������ ��� �� ��� ������� �� � ����� ��
��� ���� � ����� �� � � ��"���� ������ ����� ��� � � ��� � ����� ��� � �� �� ��
��� 9���$ ���� ��� ������ �� ������ ��� � �� �� � � ���� ����� ���� � ����� �� �� ����� ��� ��� ���� "�����!� � ����� ��� ��� ���� "����� ������ � � �� �� � ���@����
����$��$ "��+�A � ��,�& ��
�!�% ��� %��� G �����; %��� G �����;!��� G �����; ����� %��� ����������
! ����� ��� ������ ������ ����� � ��� ��� ������� �
��+���������#� �.� 2�+�2. $�#2 �� �� -����� �##��-���5 �.�2�+�2. $�#2,
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,-� 4/---#-.
�
:
4/--,-� 4/---#-.
9����� ������ '���� ���
9����� �����
9����������� �����
1 )�)(4
��������� ��������� � ��� � �"��#� ��$ �"��$��"� ��+�2. ����7��
� � ��% �� ����������9���$ ���� ��� ������ �� ������ ��� � �� �� � � � ��������� ������ ����� �� ����� ��� ��� ���� "����� >�� ������ � ��� ������ ��� ��� ��� ������� �� � ����� ��������� ������ ����� �"� ��� !� � ����� ��� ��� ���� "����������� � � �� �� � � ��@����
����$��$ "��+�A(,� � (,) �� 1 )�)(4(,7 � (,6 �� 1 )�)�> )�'(4
4��� '������ ��� ?�
0 1 �� 0 1 � 42--�*�,� 4/--,-�
0 1#� 42--�*�-� 4/--,-�
� � �����; %��� G �����; !��� G �����; ����� %��� ����������
��� 1��� ���� ����� ���� � ���� ����� 1� � ��� ������ ������������ ���� � � ������ ������ ����� � ��� ������������� �� ��� ����� 2� � ��� ��"���� ������ ����� ���
��+���������#� �.� 2�+�2. $�#2 �� �� ,
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
9����� ������ '���� ���
9����� �����
9����������� �����
1 )�)�4
9����������� '���� ���
9����� �����
9����������� �����
1 )�'(4
=������������
4/--,-�
42--�*�, �42--�*�-
�
:
��������� ��������� � ��� � �"��#� ��$ �"��$��"� ��+�2.����7�)
��� ! ����� ��� ������ ������ ����� � ��� ��� ������� �
�����% �� ������������� ! ����� ��� � �� �� � � � ��� ��"� � ��"���� ������
����� ������ '�� ������� ��� 42--�+-. C0 1 D � 42--�+,-
C0 1#D � � 4/--,-� �� ��� � ��� ���������� � � ������� ��� ������ ���� ��
��� 9���$ ���� ��� ������ �� ������ ��� � �� �� � � ���� ������ ������ ����� �� ����� ��� ��� ���� "�����!� � ����� ��� ��� ���� "����� ������ � � �� �� � ���@����
����$��$ "��+�A (,' � (,3 ��
9����� ������'���� ���
9����������� �����
K%L � K>L
9����� �����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,-� 42--�+-. C0 1 D �42--�+,- C0 1#D
9����� ��
��������� ��������� � ��� ��"��$��"� %�������9 ������� 1 )�)(> )�)� 8��.�+� ����8�9 ��+�2.4 ����3�(
3, �0 !�0 %�� ��< ��� 1 )�)(> )�)� 8��.�+� � ���< �����;4
!����� �:�< �! ��� �:�<
(
�
�
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
!�#�##��-�9 #��/#�� ' �� �� ��� )"�����"� ��� ����� ��������� )"�����"� � ���� ����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� �%�������9 ������� �##��-�9 1 )�)�8��. ����8�9 ��+�2.> )�'(4 ����3��(
3�,%�� ��< ��� ��� �:�<1 )�)� 8��. � ���< �����;> )�'(4
!����� �:�< �! ��� �:�<
(
�
�
)
'
7
3
6&
(�
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
!�#�##��-�9 #��/#�� '����� �����
�:� �� ) ����� �������� ' �� �� � � )����� ��� ����� �������
��� #� ������ ����� � F�
*� ( ������"� �� ������� +� ������ ����� � F
,� ' �� �� �-� )"�����"� ��� ����� ��������.� )"�����"� � ���� ����
��� �:�< � 0�� %������� �;��� : ��� E� G �;��� : ��� E)
����������9���$ ��� � �������� ������� � ������ ����� �� ����� � � � � � � ����� ��� �� ��� �
��+����:� 2����+� �-�+� �.� ��#��������� $���2���� �� �.� �.�+#�-�����5#,
�$$�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
������ ����� � F
������ ����� � F�
AUTOMATIC TRANSMISSION (E–W) –Planetary Carrier Assembly <F4A42with One-way Clutch, F4A51>23A-7a-2
�B�ONE-WAY CLUTCH INSTALLATIONInsert the one-way clutch into the overdrive annulus gearso that the arrow points to the output planetary carrier side.
RevisedPWEE9514-G� Feb. 2001Mitsubishi Motors Corporation
One-way clutch
Outputplanetarycarrier
Overdriveannulusgear
��������� ��������� � ��� � ��8���"��#� :��?� ����6�(
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
6, ���� 0 � :�H ������3��)3
!����� �:�< �! ��� �:�<
(
�
�
&�������� ��� � ��� ������� ���� ���������� ����� ����� ���� �����������
!�#�##��-�9 #��/#��� �� /��� ���� �� /��� �
�� &����"���� ���$� ����
��� �:�< � 0�� %������!��� ����������1���� 1�0� ���� �������� @���� � ����� 5����� � � /��� ��� � � ����� ����������
��������� ��������� � ��� � ��2��$ :��?� ����&�(
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
&, � ��! :�H �����(6��(�
!����� �:�< �! ��� �:�<
)
�
�
(
&�������� ��� � ��� ������� ���� ���������� ����� ����� ���� �����������
!�#�##��-�9 #��/#��� �� '�� � ���$� ����� ��
�� /��� ��� '�� � ���$� ����
��� � /��� �
��� �:�< � 0�� %������!��� ����������1���� 1�0� ���� �������� @���� � ����� 5����� � � /��� ��� � � ����� ����������
AUTOMATIC TRANSMISSION (E–W) – Output Shaft 23A-10-1
PWEE9514-G� Feb. 2001Mitsubishi Motors Corporation Revised
10. OUTPUT SHAFT 23302210019
DISASSEMBLY AND REASSEMBLY
4
2
5
1
Lubricate all internalparts with automatictransmission fluid duringreassembly.
3
Disassembly steps�A� �C� 1. Transfer driven gear
2. Bearing retainer�B� 3. Outer race
�B� �A� 4. Taper roller bearing5. Output shaft
DISASSEMBLY SERVICE POINTS�A� TRANSFER DRIVEN GEAR REMOVALMD998917
(except F4A51)
��������� ��������� � ��� � �+�/+� �.�������(���
�:� ��% ��� : ��� ��0��
��� �:�< � 0�� %������� ��% ��� : ��� ����������
4��� '������ ��� ?�
0 1 �� 0 1 � 4/--,,��� 4/--,,� � 4/--,,��
0 1#� 4/--,,��� 4/--,,� � 4/--,,�+
�:���� �� ����������
4��� '������ ��� ?�
0 1 �� 0 1 � 42--.-�*� 42--.-�,
0 1#� 42--.-�+� 42--.-�,
��� ��� !�0 � � ����������
4��� '������ ��� ?�
0 1 �� 0 1 � 4/--,,��� 4/--,,��� 42--,,��
0 1#� 4/--,,��� 4/--,,��� 42--,,�
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
4/--,,.�
4/--,,��
4/--,,�� �4/--,,�+
4/--,,�
42--.-�,
42--.-�* �42--.-�+
4/--,,��
4/--,,��
4/--,,�� �4/--,,�
��������� ��������� � ��� �����#��� !��"� ���� 1 )�)( +/ ��!�2, (&&3> )�)� +/ �� !�2, (&&34 ����((�(
((, ��� !�0 � �1 )�)( +/ �� !�2, (&&3> )�)� +/ �� !�2, (&&34!����� �:�< �! ��� �:�<
�
�
(
(&' �
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
!�#�##��-�9 #��/#��� �:� �� &�$ ���:� ��� �� ��� ���� ���"� ���� ����� �
�� ��� ���� ���"� ����
!����� �:�< � 0�� %������� ���H �� ��0����� =��� �� ��� ��� � � ������ � ��� ��$ ���
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� �����#��� !��"� ���� 1 )�)( +/ ��!�2, (&&3> )�)� +/ �� !�2, (&&34����((��
��� (�� ��� ������� �� � ��"� ��� ��$ ���
�:� ��� !�0 � � : ��� ��0��
��� �:�< � 0�� %������� ��� !�0 � � : ��� ����������
�:� ���H �� ������������� 1���� 1�0 � � �� ��$ ��� � � ������ �� � ��� ���������
��3��� ��� ��� ���$ � ��� � � � ������ � ������������ ��3�� ���� �
��� (�� � �� �� � ���� � ���"� � ��� �� �� ��� � ���� �� ����
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
42--�*�*
4/--,� ,
42--.-�,
4/--,,��4/--,,�-
42--�*�*
��������� ��������� � ��� � !����������� ����(��(
(�, !� ����!����� �:�< �! ��� �:�<
(�' �
�
�(
&7
3)
'�
�(�
& 3
7
6
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
!�#�##��-�9 #��/#� � �� /������ ���� ���"� ����
��� �!� �� 2��� ����� �� C0 1 �D�:� ��� �� ����� ����� ����� ��
C0 1 �� 0 1#�D�:� � &�$ �� ��� #� =� � �����
��� *� =� � ���� +� >��������� ,� '��� �������� -� '������
�.� /������ ���� ����
!����� �:�< � 0�� %�������:��� : ��� ��0��
�"�#�$%� &'()�:� �-, (&&3���#+-�#.� �����# ���/�������
4/--,,.�
��������� ��������� � ��� � !���������������(���
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
�:� ��% ��� : ��� ��0��
��� �:�< � 0�� %��������%�� > ��! � �> ���; > %���> %���
�;� � ������������� ! ����� ��� ������� � ��� ���$ ���� � ��� ���� ������
� � ��� ������� ��� ���� ����� � � ��� ������� ���������
?)�6'����� ��� ���� ��H� ������ �.�-� � ��.. � ��� ������� � � �� ���� �����
��� 1����� ��� ������� � ��� ���$ ���� � ��� �� � �� � ������� �� � � ������ ����� � ��� ���� ������ � � ��������� ����� �� ��� � ��
��� ! ���� ��� �� � ������
� � 4������ ������$���� ������ ��� ���� ����� � ��� � ��
����$��$ "��+�A �,��' � �,('� ��
�#� !� � ����� ��� ��� ���� "����� ��� �� � ������ � ������� ��� ���$���� ���� �
?)�61�@��� � ���� ��� ���$������ ��� �3����
�:� ���H %� ����������! ����� ��� ��$ �� � ��� ��� ������� �
4/--,,.�
/������ �������� &�$ ��
=� � �����
��������� ��������� � ��� � !����������� ����(���
��� ��% ��� : ��� ����������
4��� '������ ��� ?�
0 1 � 4/--,,��� 4/--,,�.
0 1#� 4/--,,��� 4/--,,�
�!�:��� : ��� ����������
� � !� ���� !�0 � � ����������1���� 1�0 � ��� ���� ������ ��� ���� � ��� ��������� ��3��� ��� ��� ��3�� ���
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
4/--,,��
4/--,,�. �4/--,,�
����� ���������� �
4/--,,��
4/--,,�-2���� �
3
'
�
�
(6
7
)
1 )�)(4
�01��#-
3
'
�
�
(6
7
)
1 )�)�4
3
'
�
�(
6
7
)
1 )�'(4&
(�
��������� ��������� � ��� � 0��"� :�$9 ����(��(
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
(�, 0��0 :�!< �����''��)'
!����� �:�< �! ��� �:�<
7 �
7 �
(( �
(( �
7 �
(�
(6
(&
��
(7(3
()('
3 (((�
((
'
6
(
(�&
(
�
�
)
&�������� ��� � ��� ������� ���� ���������� ����� ����� ���� �����������
7
!�#�##��-�9 #��/#�� '�� �� "��"� ������
��� ��� �� ( ������"� ��� �� "��"���� ��� �� '�� � ��� �� "��"���� ��� � /���� ������ � ��� ��� ��
"��"���� ��� #� )"�����"� ��� �� "��"���� ��� *� &����"���� ��� �� "��"�
+� 4� ��� "��"�,� 9"��-� =�����.� )������ "��"� ��� �������
�:� ��� '���� ���� ������� ����$ ������:� ��� '��� �
��� =������� � � /��� � "��"���� �#� /��� � "��"� ���� ���� �*� '���� ���� ��� � ���������� �+� '��� ���� �,� '���� ���� ������� ����$ �������� �-� '��� �
�.� ! ���� "��"� ��� �������
��������� ��������� � ��� � 0��"� :�$9����(���
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
&�������� ��� � ��� ������� ���� ���������� ����� ����� ���� �����������
��
�(
�)
�'�7
�3
�6
�&��
�(
��
��
)(�3
�7 �)
�'
�6
�&
)�
��
��� %������� /���� ������ � ��� "��"� ����"���� /���� ������ � ��� "��"�� � /���� ������ � ��� "��"� ���� ��#� =�����*� '�����+� %������� "��"� ���� ��,� %������� "��"��-� =�����.� 0�������� "��"� 1 ����"���� 0�������� "��"� 1�
��� 0�������� "��"� 1 ���� ���� 0�������� "��"� 1�� � =�����#� =����*� ��3�� � "����� "��"��+� ��3�� � "����� "��"� ���� ��,� =�����-� 0�������� "��"� 2 ����"� .� 0�������� "��"� 2 �� ! ���� "��"� ���
��������� ��������� � ��� � 0��"� :�$9 ����(���
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
&�������� ��� � ��� ������� ���� ���������� ����� ����� ���� �����������
)�
)�
))
)'
)3
)7
)6
'(
'�'�
7(
7�
'7''
')'�
'3'6
'&
)&
�� %���� �� )"�����"� �������� � ��� "��"�
����"� � )"�����"� �������� � ��� "��"� #� )"�����"� �������� � ��� "��"�
���� � *� %���� +� &����"���� �������� � ��� "��"�
����"� ,� &����"���� �������� � ��� "��"� -� &����"���� �������� � ��� "��"�
���� �#.� =����#�� =���
#�� '������ � "��"�#�� %����# � ( ������"� �������� � ��� "��"�
����"�##� ( ������"� �������� � ��� "��"�#*� ( ������"� �������� � ��� "��"�
���� �#+� %����#,� '�� � �������� � ��� "��"�
����"�#-� '�� � �������� � ��� "��"�*.� '�� � �������� � ��� "��"�
���� �*�� )������ "��"� ���
��������� ��������� � ��� � 0��"� :�$9����(��)
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
!����� �:�< � 0�� %��������� ��! 0��0 � ��0��
4��$ ��� �� "��"�� �� ����� ��� � � �$� ����������������
��� �:�< � 0�� %��������%��G�� � :���G!��%�� 0��0 G!��%��
0��0 �%�� ����������
�:��%��G�� � :��� ����������
������ ��! 0��0 � ������������� 1���� 1�0� ���� �������� @���� � �����5����� � �)��� ��
� � � ����� ������������� ! ����� ��� ��� �� "��"�� �� ������� � � ��� ��$� ���� �
�����������
?� ?��
� ( ������"� ��� �� "��"�
� '�� � ��� �� "��"�
� /���� ������ � ��� ��� �� "��"�
)"�����"� ��� �� "��"�
# &����"���� ��� �� "��"�
'���� ����� � ���� �
/��� � "��"�'���� ���� � � ���� �
'���� ����� � ���� �
'��������
(
�
�
)
'
��������� ��������� � ��� � �/��$������ ���� ����()�(
(), �% !�� � � �!����� �:�< �! ��� �:�<
(
�
�
)
1���� ���������� ����� ����� ���� "� � ���������� � �������� �
!�#�##��-�9 #��/#�� �������� '�������� ���"� ������ )��� � � '���"�
�"�#�$%� &'()� � �+5, (&&&���#+-�#.� �����# ���/�������
��������� ��������� � ��� � !��"� �.��� ��� ���� ����('�(
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
(', !�0 �;� � ��� � �� �����)����'
!����� �:�< �! ��� �:�<
�
)
�
(
&�������� ��� � ��� ������� ���� ���������� ����� ����� ���� �����������
!�#�##��-�9 #��/#��� �� )�� ����
�� ��3�� � "����� ���� ��:� �� )�� ����
� ��� ����� ����
��� �:�< � 0�� %��������� � �� ����������
4/--,,..
��������� ��������� � ��� � !��"� �.��� ��� ��������('��
%� &'()� ��9 (&&'���#+-�#.� �����# ���/�������
�:���� � �� ����������
4/--,,..