Antibacterial Properties of Tannic Acid Incorporated Rice ... · Tannic acid, a gallic ester of...
Transcript of Antibacterial Properties of Tannic Acid Incorporated Rice ... · Tannic acid, a gallic ester of...
Antibacterial Properties of Tannic Acid Incorporated Rice Starch-
gelatin Film
J. Bakar , R. Ahangari, R. Abdul Rahman and R. Karim
Department of Food Technology, Faculty of Food Science and Technology, Universiti Putra Malaysia,
43400, Serdang, Selangor, Malaysia.
Abstract. Many food products either handled chill or frozen are frequently packed in plastic-based
materials, although these packaging materials are of environmental concerns due to their non-biodegradable
characteristics. However, for a short handling period at chill temperatures, for products such as beef, chicken
or fish sausages, safety of consuming the products is the utmost important issue. Hence, these products are
formulated with preservatives such as nitrates to prolong their shelf-life. This brings in the concept of
employing active packaging material as an additional measure to ensure minimal surface contamination to
the packaged foods for better shelf-life. Therefore, the objective of this paper is to determine the antibacterial
activity of tannic acid when incorporated in rice starch-gelatin biodegradable/edible film at 0 to 0.6%
concentrations. The antibacterial activities of the incorporated film were carried out against Escherichia coli
O157:H7, Listeria monocytogenes, Salmonella typhimurium, and Bacillus cereus for the duration of sixteen
days under ambient temperatures (~ 28 oC). Upon storage, the increasing concentration of tannic acid
incorporation resulted in a significant (p<0.05) increase in inhibition effect as evidence by the zone of
inhibitions obtained. The zones of inhibition were 4.5-7 mm for Escherichia coli, 0-7 mm for Salmonella
typhimurium, 0-6 mm in Listeria monocytogenes 0.5-4.5 mm for Bacillus cereus. The result also showed that
E. coli O157:H7 was most sensitive to the presence of tannic acid than L. monocytogenes, S. typhimurium,
and B. cereus. Film incorporated with 0.45 and 0.6% tannic acid were the films with the highest antibacterial
activities. Higher incorporation with tannic acid is limited by the darkening of the film and stiffer texture.
Tannic acid can be a potential antibacterial ingredient in active biodegradable/edible packaging formulation.
Keywords: biodegradable film, tannic acid, rice starch-gelatin film, antibacterial activity
1. Introduction
Biodegradable/edible films function as a barrier to moisture, gas, aroma, and lipid besides protecting a
food product after the primary package is opened [1]. The degradability of these films is so rapid as such
they will help reduce the environmental pollution issue unlike their counterpart the non-degradable plastic
films. Starch-based films have minimum barrier to moisture [2] low permeability to oxygen [2]-[4].
Therefore, they form weak brittle films and hence limit their application as a food packaging material with
good functional properties. However, physical and/or chemical modifications could improve the overall
performance of the film [3]. Proteins such as soy proteins, whey protein and gluten have been used in various
modifications of the starch-based films to influence their barrier properties. Gelatin could also be used in
modifying the barrier properties of starch-based films. Starch-based films and coatings have been reported to
be used for produce packaging such as strawberries, mushrooms and other vegetables [5].
Tannic acid, a gallic ester of D-glucose is known for its antioxidant capacity because of their multiple
phenolic groups that is able to interact with biological macromolecules [6]. It exists in a range of fruits and
plants and is listed as a ‘generally recognized as safe’ (GRAS) food additive [7] and [8]. Several researchers
have reported that tannic acid has antimicrobial activity against foodborne pathogens such as Escherichia
coli and Listeria monocytogenes [8]-[11]. The application of biodegradable film with tannic acid
incorporation for prevention of wound infection was recently reported [12]. There is no previous report for Corresponding author. Tel.: + 603- 8946 8396; fax: +603-8948 5970.
E-mail address: [email protected].
International Proceedings of Chemical, Biological and Environmental Engineering, V0l. 100 (2017)
DOI: 10.7763/IPCBEE. 2017. V100. 2
8
the usage of tannic acid in rice starch-fish gelatin edible films to impart additional functional properties to
the film for food application. Therefore, the objective of this paper is to determine the effect of tannic acid
incorporation in the rice starch-gelatin film on the microbial inhibition properties of the film against
Escherichia coli O157:H7, Listeria monocytogenes, Salmonella typhimurium, and Bacillus cereus which
could be reflective of their potential to be used as active packaging for the reduction of surface
contamination in actual food application system. The effectiveness of the tannic acid incorporation in the
film was studied at ambient temperature of approximately 28 oC.
2. Material and Methods
2.1. Film formation and Observation
Aqueous solutions of 5 % (w/w) rice starch and the addition of fish gelatin (1 %) including 40 % sorbitol
(w/w, starch and gelatin blend basis) were prepared with the addition of tannic acid at different
concentrations (0.15, 0.30, 0.45, and 0.60 %). The film mixtures were then adjusted to about pH 8 to 9 by
Na2CO3. The mixture was thoroughly mixed before casting into plastic petri dishes (15 cm×15 cm×1.5 cm)
and was allowed to dry in a ventilated oven at 65 oC around 24 h. Dried films were peeled off and kept in
desiccators (RH 56 % at 28 oC) until use.
2.2. Storage Study of Film
The prepared films were cut into 6 mm diameter discs and stored in the respective desiccators for the
total duration of sixteen days. They were removed at pre-determined intervals and placed on streaked agar of
the different tested microbes prior to standard incubation time as described in the antimicrobial test. The
initial day was designated as day one (D1).
2.3. Antimicrobial Test
The disc-diffusion assay was carried out according to [13] and [14]. Films’ inhibition against
Escherichia coli O157:H7 (ATCC 43895), Listeria monocytogenes (ATCC 19115), Salmonella typhimorium
(ATCC 14028), and Bacillus cereus (ATCC 33019) were conducted. Each microbial culture was incubated
at 37 °C in tryptic soy agar (TSA) (Becton Dickinson, Maryland, USA) for 18 h with shaking at 120 rpm.
Cell numbers were adjusted to 5 logs CFU/ml with peptone water (Becton Dickinson, Maryland, USA)
before their use. Each culture was homogenously streaked on to Mueller-Hinton agar (Becton Dickinson,
Maryland, USA) and a disc of 6 mm in diameter of rice starch-gelatin films of various tannic acid
concentrations were then placed on the agar and the plates were incubated at 37 °C for 18 h. The clear zone
around the film disc on the media was measured. Film without tannic acid incorporation was run separately
as the control. The test was carried out three times for each microbe evaluated. The inhibition zone reported
was the clear zone diameter after the deduction of the diameter of the film discs.
2.4. Statistical Analysis
Data were analyzed by one-way analysis of variance (ANOVA) using Minitab release 16. The one-way
ANOVA was used to analyze the effect of rice starch-fish gelatin edible films incorporated with tannic acid.
The Tukey’s test with 95 % confidence interval was used for mean comparison when a significant variation
was found by the ANOVA test.
3. Results and Discussion
3.1. Film Observation
The appearance of plasticized-rice starch-fish gelatin films was slightly opaque and smooth, but rice
starch-fish gelatin films incorporated with tannic acid were brownish and stiffer than the untreated film. This
is due to the cross-linking property of tannic acid itself (Fig. 1).
9
(a) (b)
Fig. 1: Rice starch-fish gelatin film without tannic acid (a) and incorporated with tannic acid (b)
3.2. Antimicrobial Activity
Control film without tannic acid exhibited no inhibitory influence on the growth of tested microbes.
Film incorporated with tannic acid at concentration from 0.15 to 0.60 % per disc demonstrated antimicrobial
activities against E. coli, L. monocytogenes, S. typhimurium, and B. cereus. Fig. 2-Fig. 5 show the inhibition
zone plates against the tested microbes.
Fig. 2: Agar diffusion inhibition zone of Escherichia coli
Fig. 3: Agar diffusion inhibition zone of Listeria monocytogenes
10
Fig. 4: Agar diffusion inhibition zone of Salmonella typhimurium
Fig. 5: Agar diffusion inhibition zone of Bacillus cereus
With increasing tannic acid concentration the zone of inhibition increased significantly (p<0.05).
Previous researches had demonstrated that tannic acid have antimicrobial activity on an extensive range of
microorganisms as well as foodborne pathogens such as E.coli 0157:H7 and L. monocytogenes based on log
reduction of their growth; however, the studies reported were not done with edible films [8], [11] and [15].
The zone of inhibition were 4.5-7 mm for Escherichia coli (Fig. 6), 0-6 mm in Listeria monocytogenes (Fig.
7), 0-7 mm for Salmonella typhimurium (Fig. 8) and 0.5-4.5 mm for Bacillus cereus (Fig. 9). The result also
showed that E. coli O157:H7 was more sensitive to the tannic acid present than L. monocytogenes, S.
typhimurium, and B. cereus. This variation might reflect differences in cell surface structures between Gram-
negative and Gram-positive bacteria. The outer cell membrane of bacteria containing lipopolysaccharide may
delay some water-soluble antimicrobial molecules’ ability to influence cytoplasmic membranes. The cause of
stabilization of lipopolysaccharide layer is divalent cations such as Mg2+ and Ca2+ ions. There is a strong
chelating property of these divalent cations with tannic acid [8]. Tannic acid penetration removed these
cations which would be the lipopolysaccharide cell surface layer of Gram-negative bacteria’s destabilization
but would not have any effect on Gram-positive bacteria. On the membrane, the antimicrobial effect’ mode
of tannic acid might be correlated to its inactivation ability of enzymes, microbial adhesions, mineral uptake,
and cell envelope transport proteins [8], [9], and [12]. In contrast, gram-positive bacteria has preventive
barrier against water-soluble tannic acid due to their thick peptidoglycan layer.
There was no significant (p> 0.05) inhibition against S. typhimurium and B. cereus in lower
concentrations of tannic acid, 0.15 and 0.30 % (Fig. 8 and Fig. 9) respectively. There was significant
inhibition against all studied microbes in higher concentration of tannic acid (0.45 and 0.6 %); however,
there was no significant difference between the inhibitory effects of the two concentrations of tannic acid
against the studied microbes.
On the overall, by day sixteen, moderate to strong inhibition could not be obtained for L. monocytogenes,
S. typhimurium and B. cereus where the tannic acid concentration were less than 0.3, 0.4 and 0.4 percent
incorporation, respectively.
11
Fig. 6: Zone of inhibition for E. coli
Fig. 7. Zone of inhibition for L.monocytogenes
0
2
4
6
8
D1 D4 D8 D12 D16
Zon
e o
f in
hib
itio
n (
mm
)
Days of storage
0 0.15 0.3 0.45 0.6
S. typhimurium
Fig. 8: Zone of inhibition for S.typhimurium
Fig. 9: Zone of inhibition of B.cereus
4. Conclusions
12
The addition of tannic acid to the base film resulted in a stiffer and darker film biodegradable/edible rice
starch-fish gelatin film with increasing concentration of tannic acid incorporation. Tannic acid incorporation
in the rice starch-gelatin film can render antibacterial property to the film for food application. Hence, the
film studied can be used as an active packaging material. The starch-gelatin film incorporated with tannic
acid at 0.45 and 0.60 % showed better inhibition against E. coli O157:H7, L. monocytogenes, S. typhimurium,
and B. cereus activities. E. coli is most sensitive among the four studied microbes.
5. Acknowledgment
The authors like to thank Universiti Putra Malaysia, Malaysia and the Ministry of Science and
Technology, Malaysia for supporting this work through the grant PRGS/1/2015/SG06/UPM/01/2.
6. References
[1] S. J. Kim and Z. Ustunol. Solubility and moisture sorption isotherms of whey-protein-based edible films as
influenced by lipid and plasticizer incorporation. Journal of Agricultural and Food Chemistry. 2001, 49 (9): 438-
4391.
[2] S. Guilbert, N. Gontard, and L.G.M Gorris. Prolongation of the shelf life of perishable food products using
biodegradable films and coatings. Food Science and Technology. 1996, 29 (1-2): 10-17.
[3] Z. Liu. Edible films and coatings from starch. In: J.H. Han (ed). Innovations in Food Packaging. London: Elsevier
Academic Press, 2005, pp. 318-337.
[4] P. Dole, C. Joly, E. Espuche, I. Alric, and N. Gontad. Gas transport properties of starch-based films. Carbohydrate
Polymers. 2004, 58 (3): 335-343.
[5] F. Versino, O.V. Lopez, M.A. Garcia, and N.E. Zaritzky. Starch-based films and food coatings: An overview.
Starch – Stärke. 2016, 68 (11-12): 1026-1037.
[6] N. Aelenei, M. I. Popa, O. Novac, G. Lisa, and L. Balaita. Tannic acid incorporation in chitosan-based
microparticles and in vitro controlled release. Journal of Materials Science: Materials in Medicine, 2009, 20
(5):1095-1102.
[7] H. Akiyama, K. Fujii, O. Yamasaki, T. Oono, and K. Iwatsuki. Antibacterial action of several tannins against
Staphylococcus aureus. Journal of Antimicrobial Chemotherapy, 2001, 48 (4): 487-491.
[8] K. T. Chung, Z. Lu, and M. W. Chou. Mechanism of inhibition of tannic acid and related compounds on the
growth of intestinal bacteria. Food and Chemical Toxicology. 1998, 36 (12 ): 1053-1060.
[9] K. T. Chung, S. E. Stevens Jr., W. F. Lin, and C. I. Wei. Growth inhibition of selected food-borne bacteria by
tannic acid, propyl gallate and related compounds. Letters in Applied Microbiology. 1993, 17(1): 29-32.
[10] A. Scalbert. Antimicrobial properties of tannin. Phytochemistry. 1991, 30 (12 ): 3875-3883.
[11] T. Taguri, T. Tanaka, and I. Kouno. Antimicrobial activity of 10 different plant polyphenols against bacteria
causing food-borne disease. Biological & Pharmaceutical Bulletin. 2004, 27 (12 P ): 1965-1969.
[12] N. Sahiner, S. Sagbas, C. Silan, N. Aktas, and M. Turk. Biocompatible and biodegradable poly (Tannic acid)
hydrogel with antimicrobial and antioxidant properties. International Journal of Biological Macromolecules. 2016,
82 (January ): 150-159.
[13] M. S. Ali-Shtayeh, M. R. Yaghmour, Y. R. Faidi, K. Salem, and M. A. Al-Nury. Antimicrobial activity of 20
plants used in folkloric medicine in the Palestinian area. Journal of Ethnopharmacology. 1998, 60 (3): 265-271.
[14] J. L. Mau, C. P. Chen, and P. C. Hsieh. Antimicrobial effect of extracts from Chinese chive, cinnamon, and corini
fructus. Journal of Agricultural and Food Chemistry. 2001, 49 (1): 183-188.
[15] R. Pyla, T. J. Kim, J. L. Silva, and Y. S. Jung. Enhanced antimicrobial activity of starch-based film impregnated
with thermally processed tannic acid, a strong antioxidant. International Journal of Food Microbiology. 2010, 137
(2-3): 154-160.
13