77GHz Phased-Array Transceiver in Silicon
description
Transcript of 77GHz Phased-Array Transceiver in Silicon
1
77GHz Phased-Array Transceiver77GHz Phased-Array Transceiverin Siliconin Silicon
A. Natarajan, A. Babakhani, A. Komijani,
X. Guan, and, A. Hajimiri
California Institute of Technology
2
OutlineOutline
Motivation On-chip Antennas Local LO-Path Phase-Shifting Architecture A 77GHz Phased-Array Transceiver in SiGe Measurement Results Conclusion
3
BLINDSPOTDETECTION
ADAPTIVE CRUISE CONTROL
PARKINGASSISTANCE
MotivationMotivation
24GHz 60GHz 77GHz
Vehicular RadarWireless Communications
Fully-integrated silicon-based multiple-antenna systems enable widespread commercial applications at high frequencies. Complex, novel architectures can be realized on silicon with greater reliability and lower cost.
4
Challenges of mm-Waves in SiChallenges of mm-Waves in Si
Substrate high dielectric constant (absorbs the fields). Conductive substrate (substrate losses). Low breakdown voltages (power challenges). Poor metal conductivity. High-frequency interface.
5
OutlineOutline
Motivation On-chip Antennas Local LO-Path Phase-Shifting Architecture A 77GHz Phased-Array Tranceiver in SiGe Measurement Results Conclusion
6
Antenna on SiliconAntenna on Silicon
Silicon’s high dielectric constant (r~11.7) and conductivity
of silicon substrate are the major design challenges Most of the power gets absorbed into silicon It may appear that ground shields might solve this problem
0
20
40
60
80
100
1 4 7 10 13 16Dielectric Constant
No
rmal
ized
po
wer
(%) Pdielectric
Pair
Air, ε=1
Silicon, εr=11.7
<5 %
>95%
Top-Side
7
On-Chip Ground ShieldOn-Chip Ground Shield
Typical distance between the top and bottom metal layers
is very small (less than 15μm) Even for 15μm ground distance, the radiation resistance
is around 0.02Ω (efficiency of 1-2%)
hAir, ε=1
Silicon, ε=11.7
SiO2, ε=4Ground
Distance from Ground(µm), h
Half-Wavelength Dipole Antenna with Ground Layer
Eff
icie
ncy
(%)
Res
ista
nce
(Ω)
10-2
10-1
100
101
102
10-2
10-1
100
101
102
0 60 120 180 240 300
Radiation Resistance
TotalResistance
Efficiency
8
A dielectric lens on the backside combines most of the surface wave power and couples it into air
Reflection from silicon-air boundary can be eliminated by a matching layer
Is a good thermal heat sink (Si thermal conductivity = 149 W/(m.k) better than Brass (120W/(m.k))
Dielectric LensDielectric Lens
Silicon, ε=11.7
SiO2, ε=4Air, ε=1
Air, ε=1Silicon Lens
Back-Side
Top-Side
["Integrated-Circuit Antennas," by D.B. Rutledge, et al., Infrared and Millimeter Waves, 1983.]
9
OutlineOutline
Motivation On-chip Antennas Local LO-Path Phase-Shifting Architecture A 77GHz Phased-Array Transceiver in SiGe Measurement Results Conclusion
10
Earlier ImplementationsEarlier Implementations24GHz Phased-Array Transmitter 24GHz Phased-Array Receiver
Multiple-phase VCO
Distribution Network
Multiple phases of VCO were generated and distributed to each element, where one phase was selected. Well-suited for low-resolution beam steering with few elements.• H. Hashemi, X. Guan, and A. Hajimiri, “A Fully-Integrated 24GHz 8-Path Phased-Array Receiver in Silicon,” ISSCC 2004.
• A. Natarajan, A. Komijani, and A. Hajimiri, “A 24GHz Phased-Array Transmitter in 0.18m CMOS,” ISSCC 2005.
11
Local LO Phase-Shifting ArchitectureLocal LO Phase-Shifting Architecture
The desired phases are generated locally by interpolating between I and Q phases using phase rotator. Phase shift resolution is limited by the interpolator rather than by number of phases generated by the VCO. Scales with larger number of elements as it reduces area and complexity of LO signal distribution network..
12
90˚
cos(θ)
sin(θ)
LO signalcos(ωt - θ)
Phase-shiftedLO signal
cos(ωt)
Local LO Phase-Shifting ArchitectureLocal LO Phase-Shifting Architecture
Element 1
Element 1
Element 1
Element 1
The desired phases are generated locally by interpolating between I and Q phases using phase rotator. Phase shift resolution is limited by the interpolator rather than by number of phases generated by the VCO. Scales with larger number of elements as it reduces area and complexity of LO signal distribution network..
13
OutlineOutline
Motivation On-chip Antennas Local LO-Path Phase-Shifting Architecture A 77GHz Phased-Array Transceiver in SiGe Measurement Results Conclusion
14
Transceiver ArchitectureTransceiver Architecture
A. Babakhani et al., “A 77GHz 4-Element Phased Array Receiver with On-Chip Dipole Antennas,” ISSCC 2006.
Fully-integrated 4-element 77GHz phased-array transceiver. Two-stage frequency translation. (LO1: 52GHz, IF=LO2:26GHz) Local phase shifting in each element enables beam steering.
15
52GHz Phase Rotator52GHz Phase Rotator
Quadrature signal generated locally using a delay. Phase-shifter resolution limited by DAC resolution.
16
Die MicrographDie Micrograph
0.12m SiGe transistors in BiCMOS process, ft : 200GHz. 7 metal layers: Top two layers are 4m and 1.25m thick.
17
OutlineOutline
Motivation On-chip Antennas Local LO-Path Phase-Shifting Architecture A 77GHz Phased-Array Transmitter in SiGe Measurement Results Conclusion
18
LNA Gain and NFLNA Gain and NFLNA Gain and NF
0
5
10
15
20
25
30
74 75 76 77 78 79 80 81 82
Frequency(GHz)
Gai
n &
NF
(dB
)
LNA Gain
LNA NF
Measured LNA peak gain @ 77GHz = 23dB BW = 6GHz, NF = 6dB
19
Receiver Conversion Gain and NFReceiver Conversion Gain and NF
More than 35dB gain between 78.5GHz and 80GHz 3-dB bandwidth is more than 2GHz Minimum NF of 8.0dB measured at 79.2GHz
0
5
10
15
20
25
30
35
40
76 77 78 79 80 81 82 83Frequency(GHz)
Ga
in &
NF
(dB
) Gain
NF
20
System Packaging and SetupSystem Packaging and Setup
Silicon chip is thinned down to 100μm Floorplan issues lead to edge antennas A 500μm silicon wafer for mechanical stability Low frequency signals using wire-bond and board traces
21
Antenna GainAntenna Gain
Peak Gain of +2dBi has been achieved in the E-plane Lens improves the gain by more than 10dB
E-Plane Pattern
-35
-25
-15
-5
5
-30 -15 0 15 30Angle(degree)
An
ten
na
Gai
n(d
B)
With Lens
Without Lens10dB
22
Transmitter Test SetupTransmitter Test Setup
Combination of waveguide probe testing and internal self- test mechanisms. Stand-alone PA testing and mixer output tested through internal test pads.
23
PA MeasurementsPA MeasurementsSmall-signal Gain Large-signal @ 77GHz
3dB bandwidth larger than 15GHz (20% fractional BW). Output-referred 1dB compression point: 14.5dBm. Simulated peak power and PAE: 16dBm, 14%.
24
Transmitter PerformanceTransmitter Performance
Output-referred 1dB compression point is +10.6dBm. 40dB conversion gain from baseband to RF.
25
Loopback Loopback TestingTesting
In loopback mode, output of upconversion mixer connected to input of downconversion mixer. Pattern measurement possible with baseband input and baseband output.
LO2_I LO2_Q
DivBy 2
52GHz
77GHz PA
Φ
Φ
Φ
Φ
IBB
QBB
LO2_I
LO2_Q
IF Amplifiers@ 26GHz
RF Mixer
PhaseRotator
Φ
Φ
Φ
Φ
IBB
QBB
LO2_I
LO2_Q
CombiningAmplifier@ 26GHz
RF Mixer
77GHz LNA
A. Babakhani et al., “A 77GHz 4-Element Phased Array Receiver with On-Chip Dipole Antennas,” ISSCC 2006.
26
00.20.40.60.8
190 -80-70
-60
-50
-40
-30
-20-10
010
20
30
40
50
60
7080
00.20.40.60.8
190
-80-70
-60
-50
-40
-30
-20-10
010
20
30
40
50
60
7080
00.20.40.60.8
190
-80-70
-60
-50
-40
-30
-20-10
010
20
30
40
50
60
7080
00.20.40.60.8
190
-80-70
-60
-50
-40
-30
-20-10
010
20
30
40
50
60
7080
2-element 2-element LoopbackLoopback Array Pattern Array Pattern
Array pattern measured with two elements active in the receiver and the transmitter.
27
What the Future HoldsWhat the Future Holds Silicon systems at yet higher frequencies (mm-wave and
beyond).
Systems that leverage the benefits of integration to realize complex architectures that include mm-wave, analog, and digital circuits,
Elimination of all high frequency interfaces to the outside world
The last paragraph of Gordon Moore’s seminal paper published in 1965: “Even in the microwave area, structures included in the definition of integrated
electronics will become increasingly important. … The successful realization of such items as phased-array antennas, for example, using a multiplicity of integrated microwave power sources, could completely revolutionize radar.”
His visionary prophecy is fulfilled in silicon 40 years later.
G. E. Moore, “Cramming more components onto integrated circuits,” Electronics, vol. 38, no. 8, pp. 114–117, Apr. 1965.
28
AcknowledgementsAcknowledgements Lee Center for Advanced Networking, Caltech,
Prof. Rutledge (Caltech), Dr. Analui (Caltech/Luxtera) and Theodore Yu (Caltech/UCSD), Dr. Weinreb of JPL, Prof. Hashemi of USC,
The DARPA Trusted Foundry program and IBM T. J.
Watson for chip fabrication
Software Assistance: Cadence, Agilent Technologies, and Zeland Software, Inc.