6500D NA Parts Manual...Y 59685 (000000--005639 ) Seal, Door, Dump 1 Y 59686 (000000--005639 )...

6500D

330290Rev. 06

*330290*

Parts Manual

This manual is furnished with each new TENNANT Model 6500D.

This manual consists of the How To Use This Manual; Standard Parts; Options; Breakdowns; EngineBreakdown; and Cross Reference sections.

MACHINE DATAPlease fill out at time of installation for future reference.

Machine Model Number -- 6500D

Machine Serial Number --

Machine Options --

TENNANT Representative/phone no. --

Customer ID Number --

Date of Installation --

Manual Number -- 330290

Revision: 06

Published: 9--02

Copyright E 1998, 1999, 2000, 2001, 2002 TENNANT, Printed in U.S.A.

HOW TO USE THIS MANUAL

1-16500D 330290 (5--98)


This section on HOW TO USE THIS MANUAL willtell you how to:

-- Find important machine information forordering correct repair parts.

-- Find TENNANT part numbers.-- Order TENNANT parts and supplies.

IMPORTANT INFORMATION

When placing an order for parts, the machinemodel and machine serial number are important.Refer to the MACHINE DATA box which is filledout during the installation of your machine. TheMACHINE DATA box is located on the inside ofthe front cover of this manual.

The model number of your machine is on the sideof the machine.

The serial number of your machine is printed onthe machine data plate located as shown.


6500D 330290 (5--98)1-2

FINDING A TENNANT PART NUMBER

This manual contains the following sections:

-- HOW TO USE THIS MANUAL-- STANDARD PARTS-- OPTIONS-- BREAKDOWNS-- CROSS REFERENCE

The STANDARD PARTS section lists repair partsfor standard machines. They are grouped in thisgeneral order:

-- General wear parts.-- Machine frame and related parts.-- Machine propelling system.-- Scrubbing components.-- Electrical parts.

The OPTION section lists repair parts of options.

The BREAKDOWN section lists available repairparts of major components.

All sections in this manual consist of partsillustrations and corresponding parts lists.

The parts illustrations are numbered with Refnumbers which refer to corresponding parts lists.

The parts lists include a number of columns ofinformation:

-- Ref -- column refers to the reference numberon the parts illustration.∇ -- indicates the part is an assembly.Y -- indicates the part is included in theassembly listed just before it.

-- TENNANT Part No. -- column lists theTENNANT part number for the part.

-- Serial Number -- column indicates the set ofmachines the part number is applicable to.Serial numbers change when the machinedesign has been modified. The most currentdesign of the machine is shown in the mainillustration, older designs are boxed in acorner of the illustration.

-- Description -- column is a brief descriptionof the part.

-- Qty. -- column lists the quantity of that partused in that area of the machine.


1-36500D 330290 (5--98)

NOTE: If a service kit is installed on yourmachine, be sure to keep the INSTRUCTIONBULLETIN which came with the kit. It containsrepair parts numbers needed for ordering futureparts.

NOTE: Fasteners used in this machine may bemetric or non-metric. Take care when replacinghardware to replace with same thread size.

PLACING AN ORDER

Orders may be placed by phone, fax, or by mail.Phone orders may need written confirmation.Follow the steps below to insure prompt delivery:

1. Identify the model number of your machine.

2. Identify the serial number of your machine.

3. Find the part number of the part you need.Do not order by page number or referencenumber. If you are not able to find the partnumber, call your TENNANT representativefor help or send the old part as a sample.

4. Determine the quantity of the part you need.

5. Provide the following company information:

-- Company name

-- Customer ID Number

-- Shipping address

-- Billing address

-- First and last name of person orderingparts

-- Telephone number

-- Purchase order number

6. Provide definitive shipping instructions.


6500D 330290 (5--98)1-4

Any claim for loss or damage to a shipment intransit should be filed promptly with thetransportation company making the delivery.Shipments will be complete unless the packing listor order acknowledgement indicates items backordered.

If parts received are suspected to be incorrect ordefective, please contact the TENNANTrepresentative from whom you ordered the part.They will give authorization for return and/orhandle replacement shipments when required.

STANDARD PARTS

2-16500D 330290 (9--02)

SECTION 2Contents Page

Fig. 1 -- General RecommendedMaintenance Items 2-2. . . . . . . . . . . . .

Fig. 2 -- Replacement Brushes 2-5. . . . . . . . . . .Fig. 3 -- Main Frame Group 2-6. . . . . . . . . . . . . .Fig. 4 -- Right Brush Door Group 2-8. . . . . . . . .Fig. 5 -- Left Brush Door Group 2-9. . . . . . . . . . .Fig. 6 -- Seat and Shroud Group 2-10. . . . . . . . .Fig. 7 -- Right Grille Group 2-12. . . . . . . . . . . . . .Fig. 8 -- Left Grille and Hydraulic

Cooler Group 2-14. . . . . . . . . . . . . . . . .Fig. 9 -- Engine Cover Group 2-16. . . . . . . . . . . .Fig. 10 -- Engine Side Door Group 2-18. . . . . . . .Fig. 11 -- Steering and Firewall Group 2-20. . . . .Fig. 12 -- Instrument Panel Assembly 2-22. . . . .Fig. 13 -- Side Instrument Panel Group 2-24. . . .Fig. 14 -- Circuit Breaker and Relay Group 2-26.Fig. 15 -- Engine and Governor Group 2-28. . . . .Fig. 16 -- Engine Mount Group 2-30. . . . . . . . . . .Fig. 17 -- Air Cleaner Group 2-32. . . . . . . . . . . . . .Fig. 18 -- Alternator and Engine Fan Group 2-34Fig. 19 -- Muffler Group (000000-- 007237) 2-35.Fig. 20 -- Muffler Group (007238-- ) 2-36. .Fig. 21 -- Fuel Tank Group 2-38. . . . . . . . . . . . . . .Fig. 22 -- Radiator Group 2-40. . . . . . . . . . . . . . . .Fig. 23 -- Battery Group 2-42. . . . . . . . . . . . . . . . .Fig. 24 -- Rear Drive Wheel Group 2-44. . . . . . . .Fig. 25 -- Rear Wheel Assembly 2-46. . . . . . . . . .Fig. 26 -- Front Wheel and Brakes Group 2-48. .Fig. 27 -- Brake Lever and Pedal Group 2-50. . .Fig. 28 -- Directional Pedal Group 2-52. . . . . . . . .Fig. 29 -- Hydraulic Pump Linkage Group 2-54. .Fig. 30 -- Hopper Group (Metal Hopper) 2-56. . .Fig. 31 -- Hopper Group (Plastic Hopper) 2-58. .Fig. 32 -- Hopper Dump Door Group

(Metal Hopper) 2-60. . . . . . . . . . . . . . . .Fig. 33 -- Hopper Cylinder and Dust

Door Group (Metal Hopper) 2-62. . . . .Fig. 34 -- Hopper Cylinder and Dump

Door Group (Plastic Hopper) 2-64. . . .Fig. 35 -- Hopper Hood and Bumper

Group (Metal Hopper) 2-66. . . . . . . . . .Fig. 36 -- Hopper Hood Group

(Plastic Hopper) 2-68. . . . . . . . . . . . . . .Fig. 37 -- Hopper Bumper Group

(Plastic Hopper) 2-70. . . . . . . . . . . . . . .Fig. 38 -- Filter Box Group (Metal Hopper) 2-72.Fig. 39 -- Filter Box Group (Plastic Hopper) 2-74Fig. 40 -- Hopper Lift Arms Group 2-76. . . . . . . . .Fig. 41 -- Side Brush Motor and Pivot Group 2-78Fig. 42 -- Side Brush Lift Group 2-80. . . . . . . . . . .Fig. 43 -- Main Brush Lift Group

(000000--019999) 2-82. . . . . . . . . . . . .Fig. 44 -- Main Brush Lift Group

(020000-- ) 2-84. . . . . . . . . . . . . .

Contents Page

Fig. 45 -- Main Brush Drive Group(000000--019999) 2-86. . . . . . . . . . . . .

Fig. 46 -- Main Brush Drive Group(020000-- ) 2-88. . . . . . . . . . . . . .

Fig. 47 -- Vacuum Fan Group 2-90. . . . . . . . . . . .Fig. 48 -- Vacuum Fan Motor and

Fittings Group 2-92. . . . . . . . . . . . . . . . .Fig. 49 -- Hydraulic Schematic

(Metal Hopper) 2-94. . . . . . . . . . . . . . . .Fig. 50 -- Hydraulic Schematic

(Plastic Hopper) 2-96. . . . . . . . . . . . . . .Fig. 51 -- Hydraulic Hose Group

(Metal Hopper) 2-98. . . . . . . . . . . . . . . .Fig. 52 -- Hydraulic Hose Group

(Plastic Hopper) 2-100. . . . . . . . . . . . . .Fig. 53 -- Hydraulic Reservoir Group 2-102. . . . .Fig. 54 -- Hydraulic Valve Group 2-104. . . . . . . . .Fig. 55 -- Hydraulic Pumps Group 2-106. . . . . . . .Fig. 56 -- Electrical Schematic

(000000--019999) 2-108. . . . . . . . . . . .Fig. 57 -- Electrical Schematic

(0020000-- ) 2-112. . . . . . . . . . . .Fig. 58 -- Wire Harnesses Group

(000000--019999) 2-114. . . . . . . . . . . .Fig. 59 -- Wire Harnesses Group

(020000-- ) 2-122. . . . . . . . . . . . .Fig. 60 -- Label Group 2-126. . . . . . . . . . . . . . . . . .

STANDARD PARTS

6500D 330290 (9--01)2-2

6500, D, NAFig. 1 -- General Recommended Maintenance Items

Ref.TennantPart No.

Machine SerialNumber Description Qty.

o 69943 (000000-- ) Performance Pkg 400Hr Die 355L 1Y 58120 (000000-- ) Element, Air Filter 1Y 55849 (000000-- ) Filter, Oil 4Y 36050 (000000-- ) Filter, Fuel 1Y 55844 (000000-- ) Filter, Fuel, Element 1Y 65869--1 (000000-- ) Fluid, Hyd Oil, Shp 15/40 1Gal 6Y 55740 (000000-- ) Filter Element Ph 1o 398335 (000000--019999 ) Kit, Maintenance, 800Hr 1Y 57803 (000000--019999 ) Circuitbreaker, 15.0a, Resetable 2Y 79399 (000000--019999 ) Switch 1Y 59687 (000000--019999 ) Seal 2Y 59685 (000000--019999 ) Seal 1Y 379751 (000000--019999 ) Skirt 1Y 379750 (000000--019999 ) Skirt 1Y 54190 (000000--019999 ) Skirt, Deflector 1Y 59680 (000000--019999 ) Skirt, Lip 1Y 59681 (000000--019999 ) Skirt, Lip 1Y 379705 (000000--019999 ) Skirt, Lip 1Y 379706 (000000--019999 ) Skirt, Lip 1Y 54089 (000000--019999 ) Skirt 2Y 58103 (000000--019999 ) Seal, Door, Dump, Hppr, Rear 1Y 59105 (000000--019999 ) Seal, Door, Dump, Hppr, Rear 1Y 55884 (000000--019999 ) Retainer, Seal, Hppr, .12 X 1.8 X 40.3l 1Y 379629 (000000--019999 ) Kit, Fltr, Fine Particle 1Y 32126 (000000--019999 ) Stud, Wheel, .50--20 X 1.50 1Y 24339 (000000--019999 ) Nut, Wheel, .50--20 X 60 Angle 1Y 87866 (000000--019999 ) Key, Switch, Set Of Two 1Y 61490 (000000--019999 ) Kit, Replmt, Seal 1Y 59335 (000000--019999 ) Kit, Seal, Hyd 1Y 04483 (000000--019999 ) Kit, Seal, Hyd 1Y 79812 (000000--019999 ) Kit, Seal, Hyd, Valve 1o 383228 (020000-- ) Kit, Maintenance, 800Hr 1Y 383722 (020000-- ) Circuitbreaker, 15.0a 2Y 79399 (020000-- ) Switch 1Y 59687 (020000-- ) Seal 2Y 59685 (020000-- ) Seal 1Y 379751 (020000-- ) Skirt 1Y 379750 (020000-- ) Skirt 1Y 54190 (020000-- ) Skirt, Deflector 1Y 59680 (020000-- ) Skirt, Lip 1Y 59681 (020000-- ) Skirt, Lip 1Y 379705 (020000-- ) Skirt, Lip 1Y 379706 (020000-- ) Skirt, Lip 1Y 54089 (020000-- ) Skirt 2Y 58103 (020000-- ) Seal, Door, Dump, Hppr, Rear 1Y 59105 (020000-- ) Seal, Door, Dump, Hppr, Rear 1Y 55884 (020000-- ) Retainer, Seal, Hppr, .12 X 1.8 X 40.3l 1Y 379629 (020000-- ) Kit, Fltr, Fine Particle 1Y 32126 (020000-- ) Stud, Wheel, .50--20 X 1.50 1Y 24339 (020000-- ) Nut, Wheel, .50--20 X 60 Angle 1

STANDARD PARTS

2-36500D 330290 (9--01)

Fig. 1 -- General Recommended Maintenance Items

Ref.TennantPart No.


Y 87866 (020000-- ) Key, Switch, Set Of Two 1Y 61490 (020000-- ) Kit, Replmt, Seal 1Y 59335 (020000-- ) Kit, Seal, Hyd 1Y 04483 (020000-- ) Kit, Seal, Hyd 1Y 79812 (020000-- ) Kit, Seal, Hyd, Valve 1o 72067 (000000--005639 ) Maint Kit, Skirts 355L 1Y 59687 (000000--005639 ) Seal, Door, Dump, Side 2Y 59688 (000000--005639 ) Strap, Door, Dump, Side 2Y 09007 (000000--005639 ) Scr Hexssm 6X1.0 25 8Y 01684 (000000--005639 ) Washer Flt .25 Ss 16Y 08712 (000000--005639 ) Nut--Hxlocnyln M 6X1.0 Reg Ss 8Y 55864 (000000--005639 ) Cord, Sponge 1Y 59685 (000000--005639 ) Seal, Door, Dump 1Y 59686 (000000--005639 ) Strap, Door, Dump 1Y 09007 (000000--005639 ) Scr Hexssm 6X1.0 25 6Y 01684 (000000--005639 ) Washer Flt .25 Ss 12Y 08712 (000000--005639 ) Nut--Hxlocnyln M 6X1.0 Reg Ss 6o 72068 (000000--005639 ) Maint Kit, Seals 355L 1Y 59680 (000000--005639 ) Skirt, Lip 1Y 59681 (000000--005639 ) Skirt, Lip 1Y 55890 (000000--005639 ) Strap, Main Lip 1Y 09010 (000000--005639 ) Scr Hexssm 8X1.25 25 5Y 01685 (000000--005639 ) Washer Flt .31 Ss 5Y 08713 (000000--005639 ) Nut--Hxlocnyln M 8X1.25 Reg Ss 5Y 54089 (000000--005639 ) Skirt, Side, Sbdc, Lh 1Y 54013 (000000--005639 ) Plate, Retainer, Lh 1Y 54014 (000000--005639 ) Plate, Retainer, Front, Lh 1Y 12459 (000000--005639 ) Scr--Hxfmgm 6X1.0 20 Pltd 6Y 01684 (000000--005639 ) Washer Flt .25 Ss 6o 379841 (005640-- ) Kit, Maint Seal, Hopper Door 6500 1Y 379699 (005640-- ) Seal, Door, Dump 1Y 379698 (005640-- ) Plate, Retainer, Dump Door 1Y 379791 (005640-- ) Bolt, Carriage, M06x1.0 6Y 01684 (005640-- ) Washer Flt .25 Ss 6Y 08712 (005640-- ) Nut--Hxlocnyln M 6X1.0 Reg Ss 6Y 379702 (005640-- ) Seal, Door, Dump, Side 2Y 379703 (005640-- ) Strap, Door, Dump, Side 2Y 08716 (005640-- ) Screw--Hexssm 6x1.0 8Y 01684 (005640-- ) Washer Flt .25 Ss 16Y 08712 (005640-- ) Nut--Hxlocnyln M 6X1.0 Reg Ss 8o 379842 (005640-- ) Kit, Maint Skirt, Hopper 6500 1Y 379706 (005640-- ) Skirt, Lip 1Y 379705 (005640-- ) Skirt, Lip 1Y 379704 (005640-- ) Strap, Main Lip 1Y 379792 (005640-- ) Bolt, Carriage, M08x1.25 5Y 01685 (005640-- ) Washer, Flt .31Ss 5Y 08713 (005640-- ) Nut--Hxlocnyln M 8X1.25 Reg Ss 5Y 54089 (005640-- ) Skirt, Side, Sbdc, Lh 1Y 379831 (005640-- ) Plate, Retainer 1Y 379814 (005640-- ) Plate, Retainer 1

STANDARD PARTS

6500D 330290 (9--01)2-4

Fig. 1 -- General Recommended Maintenance Items

Ref.TennantPart No.


Y 11329 (005640-- ) Screw--Hexssm 6x1.0 6Y 01684 (005640-- ) Washer Flt .25 Ss 6

STANDARD PARTS

2-56500D 330290 (6--99)

Fig. 2 -- Replacement Brushes

2

3

1

351707 -- 6500, 6550EFig. 2 -- Replacement Brushes

Ref.TennantPart No.


1 54927 (000000-- ) Brush--Sweep Spl--45Lg--24 Single Row--Fiber and Wire 11 54922 (000000-- ) Brush--Sweep Spl--45Lg--24 Single Row--Nylon 12 54923 (000000-- ) Brush--Sweep Spl--45Lg--8 Double Row--Nylon 12 54925 (000000-- ) Brush--Sweep Spl--45Lg--8 Double Row--Poly and Wire 12 59440 (000000-- ) Brush--Sweep Spl--45Lg--8 Double Row--Wire 12 66019 (000000-- ) Brush--Sweep Spl--45Lg--8 Double Row--Poly 12 66018 (000000-- ) Brush--Sweep Spl--45Lg--5 Double Row--Nylon 12 370008 (000000-- ) Brush--Sweep Spl--45Lg--Wedg Poly 12 370009 (000000-- ) Brush--Sweep Spl--45Lg--Wndo Poly 13 51021N (000000-- ) Brush--Side Swp --26 Dia--Nylon 13 51542 (000000-- ) Brush--Side Swp --26 Dia--Flatwire 13 70538 (000000-- ) Brush--Side Swp --26 Dia--Poly 1

STANDARD PARTS

6500D 330290 (9--01)2-6

Fig. 3 -- Main Frame Group

1

2

5

26

8

6

2615

11

12

13

16

2

17

18

19

2122

14

14

23

10

9

24

7

25

4 320

23

15 26

STANDARD PARTS

2-76500D 330290 (9--01)

353637 -- 6500, NAFig. 3 -- Main Frame Group

Ref.TennantPart No.


1 379574 (000000--019999 ) Frame Wldt, Main 11 383186 (020000-- ) Frame Wldt, Main 12 69904 (000000-- ) Spring Assy, Recirculation 13 379752 (000000-- ) Skirt, Hopper, Top 14 56890 (000000-- ) Strap, Backing, Hopper 15 09342 (000000-- ) Chain, Link#2/0, 5Links Plain 16 54190 (000000-- ) Blade, Deflector 16 374517 (000000-- ) Skirt, Recirculation, Turf (Option) 17 54184 (000000-- ) Strip, Retainer, Seal 18 54182 (000000-- ) Bracket, Flap, Recirculation 19 54192 (000000--019999 ) Channel, Retainer, Seal, Rear 19 383161 (020000-- ) Channel, Retainer, Seal, Rear 110 54197 (000000--019999 ) Skirt, Seal, M Br 110 383160 (020000-- ) Skirt, Seal, M Br 111 53491 (000000-- ) Insulation, Acoustic, Firewall 112 62595--21 (000000-- ) Molding, Trim 11--14Ga 25.62 113 69915 (000000-- ) Bolt--Carrm 8X1.25 40 4.6 Pltd 414 01314 (000000-- ) Plugbtn .38H .03--.12 Blacknyl 315 01685 (000000-- ) Washer, Flat, .31 Ss 416 72152 (000000-- ) Panel, Engine 117 21642 (000000-- ) Horn, 12V 118 67767 (000000-- ) Clamp -- Cable, .69 Dia .62 Wth 319 53468 (000000-- ) Clamp, Hose 320 21246 (000000-- ) Rivet, Plastic .325x.787 521 70284 (000000-- ) Wire Assy, Horn Ground, 16 Ga x 6 122 222809 (000000-- ) Cable, 9” Bundle Dia 323 57167 (000000-- ) Plugbtn .62H .03--.12 Blacknyl 224 09011 (000000-- ) Screw, Hex, M08--1.25 X 30, Ss 425 01684 (000000-- ) Washer, Flat, .25 Ss 426 08713 (000000-- ) Nut, Hex, Lock, M08--1.25,Nl,Ss 8

STANDARD PARTS

6500D 330290 (6--99)2-8

Fig. 4 -- Right Brush Door Group

1

2

3

4

5

6

7

8

9

10

11

1213

14

15

351713 -- ALL

Ref.TennantPart No.


1 59761 (000000-- ) Door Wldt, Brush, Rh 12 72120 (000000-- ) Hinge, Door, Brush 13 59195 (000000-- ) Latch, Hook, Rh 14 59192 (000000-- ) Latch, Bolt 15 379751 (000000-- ) Skirt Assy, Brush Door, Rh 16 379756 (000000-- ) Strip, Retainer, Skirt 17 59537 (000000-- ) Seal, Door, Brush, Rh 18 72118 (000000-- ) Bracket, Mtg, Hinge, Rh 19 379755 (000000-- ) Skirt, Deflector 110 59692 (000000-- ) Strap, Deflector 111 69931 (000000-- ) Seal, Foam Rbr 112 58770 (000000-- ) Strip, Retainer 113 56914 (000000-- ) Strap 114 72968 (000000-- ) Rivet, Plastic .250x.898 515 13301 (000000-- ) Seal, Rbr, .31 x .75 x 7.0 1

STANDARD PARTS

2-96500D 330290 (6--99)

Fig. 5 -- Left Brush Door Group

1

2

3

4

5

6

7

8

910

12

11

14

13

15

351715 -- ALL

Ref.TennantPart No.


1 59760 (000000-- ) Door Wldt, Brush, Lh 12 72120 (000000-- ) Hinge, Door, Brush 13 59194 (000000-- ) Latch, Hook, Lh 14 59192 (000000-- ) Latch, Bolt 15 379750 (000000-- ) Skirt Assy, Brush Door, Lh 16 379756 (000000-- ) Strip, Retainer, Skirt 17 379755 (000000-- ) Skirt, Deflector 18 59692 (000000-- ) Strap, Deflector 19 72119 (000000-- ) Bracket, Mtg, Hinge, Lh 110 69931 (000000-- ) Seal, Foam Rbr 111 58770 (000000-- ) Strip, Retainer 112 56914 (000000-- ) Strap 113 72968 (000000-- ) Rivet, Plastic .250x.898 514 59538 (000000-- ) Seal, Door, Brush, Lh 115 13301 (000000-- ) Seal, Rbr, .31 x .75 x 7.0 1

STANDARD PARTS

6500D 330290 (9--02)2-10

Fig. 6 -- Seat and Shroud Group

1

2

3

4

56

7

89

10

11

12

13

14

15

16

17

18

19

20

STANDARD PARTS

2-116500D 330290 (9--02)

07049 -- 6500, IC, NAFig. 6 -- Seat and Shroud Group

Ref.TennantPart No.


1 58297 (000000-- ) Panel Wldt, Sppt, Seat 12 54030 (000000-- ) Panel, Inside 13 59771 (000000-- ) Bracket 14 53494 (000000-- ) Insulation, Acoustic, Panel 15 383227 (000000-- ) Panel, Filler, Upper 16 59766 (000000-- ) Bracket, Inside 1

o 7 72138 (000000-- ) Plate, Floor w/tread 1Y 8 16369 (000000-- ) Pad, Tread 1

9 62595--22 (000000-- ) Molding, Trim 11--14Ga 14.20 110 62595--23 (000000-- ) Molding, Trim 11--14Ga 22.80 111 53839 (000000-- ) Cover Wldt, Sppt, Seat 112 59822 (000000-- ) Insulation, Acoustic, Seat 113 44906 (000000-- ) Pin,Hair Cotter #Lhcot--2,Leitk 114 54615 (000000-- ) Rod Wldt, Seat 115 53492 (000000-- ) Insulation, Acoustic, Plate 116 57702 (000000-- ) Cable 117 54055 (000000-- ) Rail, Seat, Rh 218 375411 (000000-- ) Seat 119 58595 (000000-- ) Nut, U M 8X1.25 Pltd 120 33807 (000000-- ) Plugbtn .44H 2

STANDARD PARTS

6500D 330290 (9--01)2-12

Fig. 7 -- Right Grille Group

14

13

6

7

5

3

2

2

1

2

4

8

9

1212

10

11

9

16

18

17

18

18

17

26

23

19

2021

21

22

2829

30

2815

29 31

2931

2524

STANDARD PARTS

2-136500D 330290 (9--02)

353652 -- 6500 -- DFig. 7 -- Right Grille Group

Ref.TennantPart No.


1 59870 (000000--019999 ) Sprng, Tens, 0.50 Odx.05 Wire 2.5L 12 69972 (000000--019999 ) Src--Hex M12x1.75 40 10.9Pltd 63 01318 (000000--019999 ) Tip, Rubber 14 45214 (000000--019999 ) Scr--Hex .38--16x2.50 Full Thd 15 70249 (000000--019999 ) Bracket, Stop Bolt, Rear Grill 16 59192 (000000--019999 ) Latch, Bolt 17 72473 (000000--019999 ) Latch, Hook, RH 18 74456 (000000--019999 ) Bracket, Mtg. Latch 19 36328 (000000--019999 ) Washer--Belleville .50 Pltd 410 72179 (000000--019999 ) Bracket, Grille 111 15648 (000000--019999 ) Bearing, Flange 212 72176 (000000--019999 ) Pin, Pivot, Upper 213 70256 (000000--019999 ) Channel Wldt, Corner Post 114 379564 (000000-- ) Grille, Right 115 06945 (020000-- ) Screw, Hex, M06 X 1.0 X 30, 8.8 116 383183 (020000-- ) Channel, Post, Corner 117 16931 (020000-- ) Screw, Hex, M08 X 1.25 X 20, 8.8 618 32491 (020000-- ) Washer, Flt, .31 Std 819 383129 (020000-- ) Bracket, Hinge 120 06967 (020000-- ) Screw, Hex, M12 X 1.75 X 20, 8.8 221 36328 (020000-- ) Washer, Belleville, .50 422 08711 (020000-- ) Nut, Hex, Lock, M12 X 1.75,Nl 223 383149 (020000-- ) Hinge 124 32493 (020000-- ) Washer, Flt, .50 Std 225 41345 (020000-- ) Screw, Hex, M12 X 1.75 X 25, 8.8 226 08709 (020000-- ) Nut, Hex, Lock, M08 X 1.25, Nl 227 383184 (020000-- ) Plate, Mtg, Latch 128 06942 (020000-- ) Screw, Hex, M06 X 1.0 X 16, 8.8 329 32490 (020000-- ) Washer, Flt, .25 Std 430 383185 (020000-- ) Latch Assy, Door Holder, Rbr 131 08708 (020000-- ) Nut, Hex, Lock, M06 X 1.0, Nl 2

STANDARD PARTS

6500D 330290 (9--01)2-14

Fig. 8 -- Left Grille and Hydraulic Cooler Group

1

2

3

9

10

11

13

14

15

17

17

12

15

16

21

87

4

19

20

18

6

6

5

5

5

28 29

23

30

27

2231

26

25

24

26

STANDARD PARTS

2-156500D 330290 (9--01)

07076 -- 6500, IC, NA, CEFig. 8 -- Left Grille and Hydraulic Cooler Group

Ref.TennantPart No.


o 1 55619 (000000-- ) Filter Assy, Spin--On 10Micron 1Y 2 55740 (000000-- ) Filter Element Ph 1

3 379565 (000000-- ) Grille, Left 14 59870 (000000-- ) Sprng, Tens, 0.50 Odx.05 Wire 2.5L 15 69972 (000000--019999 ) Scr--Hex M12x1.75 40 10.9Pltd 66 36328 (000000--019999 ) Washer--Belleville .50 Pltd 47 55347 (000000-- ) Scr--Hex .38--16x2.00 Full Thd 18 70248 (000000-- ) Bracket, Rear Grill Stop Bolt 19 70252 (000000-- ) Bracket, Mtg, Latch 110 59695 (000000-- ) Latch, Hook, Lh 111 59192 (000000-- ) Latch, Bolt 112 53466 (000000-- ) Clamp, Hose 213 82798 (000000-- ) Cooler--Hyd 12 0500 114 46481 (000000-- ) Ftg--Hyd E90 Jm12/Om12 215 16081 (000000-- ) Ftg--Hyd E45 Jm12/Om12 216 41016 (000000-- ) Clamp--Cable, 2.25Dia 1.00Wth 117 87676 (000000-- ) Sleeve--Nyln #24 30.0L 218 72179 (000000--019999 ) Bracket, Grille 119 15648 (000000--019999 ) Bearing, Flange 220 72176 (000000--019999 ) Pin, Pivot, Upper 221 01318 (000000-- ) Tip, Rubber 122 39311 (020000-- ) Nut, Hex, Std, M08 X 1.25 223 383129 (020000-- ) Bracket, Hinge 124 08711 (020000-- ) Nut, Hex, Lock, M12 X 1.75,Nl 225 69972 (020000-- ) Screw, Hex, M12 X 1.75 X 40, 10.9 226 36328 (020000-- ) Washer, Belleville, .50 427 383149 (020000-- ) Hinge 128 41345 (020000-- ) Screw, Hex, M12 X 1.75 X 25, 8.8 229 32493 (020000-- ) Washer, Flt, .50 Std 230 16931 (020000-- ) Screw, Hex, M08 X 1.25 X 20, 8.8 231 32491 (020000-- ) Washer, Flt, .31 Std 2

STANDARD PARTS

6500D 330290 (5--98)2-16

Fig. 9 -- Engine Cover Group

1

2

3

4

5

6

7

8

910

12

13

14

15 16

13

14

1718

19

1516

1516

1516

20

21

11

STANDARD PARTS

2-176500D 330290 (6--99)

07075 -- ICFig. 9 -- Engine Cover Group

Ref.TennantPart No.


1 58977 (000000-- ) Cover Wldt, Engine 12 59019 (000000-- ) Foam, Engine Cover 13 58999 (000000-- ) Foam, Engine Cover, Bottom 14 12271 (000000-- ) Nut, U M 6X1.0 Pltd 205 374523 (000000-- ) Plate Wldt, Cover, Bottom 16 69952 (000000-- ) Plate, Deflector, Engine Cover 17 58849 (000000-- ) Bracket, Deflector, Eng Cover 18 69951 (000000-- ) Plate, Deflector, Eng Cover 19 59514 (000000-- ) Latch 110 59192 (000000-- ) Latch, Bolt 111 70142 (000000-- ) Bracket, Latch, Bolt, Eng Cover 112 69907 (000000-- ) Handle Assy, Latch, Eng Cover 113 55048 (000000-- ) Rod, Latch, Engine Cover 1

o 14 69906 (000000-- ) Spring--Gas Assy, Eng Cover 2Y 15 64595 (000000-- ) Clip, Spring 2Y 16 58494 (000000-- ) Stud, Ball 2

17 69986 (000000-- ) Insulation, Acoustic, Engine Cover 118 69987 (000000-- ) Insulation, Acoustic, Engine Cover 119 70136 (000000-- ) Bracket, Latch 120 53091 (000000-- ) Sprng,Tens,0.50Odx.05Wire 1.0L 121 14601 (000000-- ) Balljoint .250--28 1

STANDARD PARTS

6500D 330290 (5--98)2-18

Fig. 10 -- Engine Side Door Group

1

2

3

4

5

67

8 9

STANDARD PARTS

2-196500D 330290 (6--99)

07091 -- JP, NAFig. 10 -- Engine Side Door Group

Ref.TennantPart No.


1 59377 (000000-- ) Hinge Wldt, Door, Engine 22 59830 (000000-- ) Door Wldt 13 59018 (000000-- ) Foam, Door, Engine, Side 14 59829 (000000-- ) Bracket, Door 15 59661 (000000-- ) Latch 16 75128 (000000-- ) Spindle, Adjustment 27 72154 (000000-- ) Bolt, Latch 18 59828 (000000-- ) Bracket, Latch, Door 19 59647 (000000-- ) Seal, Rubber 1

STANDARD PARTS

6500D 330290 (9--01)2-20

Fig. 11 -- Steering and Firewall Group

12

17

13

20

14

15

16

24

22

21

29

29

25

22

28

27

23

26

19

18

30

31

32

35

3433

1

2

3

4

6

78

9

10

11

5

STANDARD PARTS

2-216500D 330290 (9--02)

353653 -- 6500, D, NAFig. 11 -- Steering and Firewall Group

Ref.TennantPart No.


1 56373 (000000--019999 ) Bracket Wldt, Valve 12 56379 (000000--019999 ) Lever Wldt, Tilt 13 56198 (000000--019999 ) Spring, Torsion 14 23191 (000000--019999 ) Pin,Clevis,0.37 Dia.X 3.00 Lg 15 04733--10 (000000--019999 ) Pin,Clevis,0.25 Dia.X 2.44 Lg 16 59940 (000000--019999 ) Knob, Tapered M8 17 58665 (000000--019999 ) Bracket Wldt, Mtg, Steering,Lh 18 58667 (000000--019999 ) Bracket Wldt, Mtg, Steering,Rh 19 56392 (000000--019999 ) Rod, Spring 110 63852 (000000--019999 ) Sprng,Comp,0.74Idx.11Wire 5.5L 111 56385 (000000--019999 ) Bracket Wldt, Notched 112 57935 (000000-- ) Column, Steering 1

Y 74142 (000000-- ) Cap, Tube 213 74172 (000000-- ) Steer Control, Hyd (See Breakdowns) 114 47522 (000000-- ) Ftg--Hyd E45 Jm06/Om06 415 34330 (000000-- ) Sleeve--Nyln #38 30.0L 116 49263 (000000-- ) Tie, Cable 3.00D Max 11.41Lg 317 58748 (000000-- ) U -- Bolt 118 56362 (000000-- ) Cover, Steering 119 54345 (000000-- ) Grommet,Rbr,1.62Id,For .13Matl 120 56398 (000000-- ) Wheel, Steering, 14 Dia X 36T 121 41016 (000000-- ) Clamp--Cable, 2.25Dia 1.00Wth 122 53466 (000000-- ) Clamp, Hose 323 62595--3 (000000-- ) Molding, Trim 11--14Ga 5.75 124 62595--4 (000000-- ) Molding, Trim 11--14Ga 10.00 1

o 25 56237 (000000--019999 ) Control Box, Governor, Die (Repl by 374127) 1Y 374625 (000000--019999 ) Plug, Control Box 2

25 374127 (020000-- ) Kit, Replmt, Control, Govnr, [All Purps] 126 86381 (000000-- ) Block, Fuse 127 87319 (000000-- ) Fuse, 40 Amp 128 55035 (000000-- ) Plug, Plastic 1.00 D 129 59935 (000000-- ) Plate Wldt, Governor 230 56185 (000000-- ) Nut--Hx Jam M20x1.5 4 Pltd 131 02994 (000000-- ) Scr Hex Ss .38--16 x0.75 232 02995 (000000-- ) Scr Hex Ss .38--16 x1.25 233 383127 (020000-- ) Bracket Wldt, Valve 134 16735 (020000-- ) Screw, Hex, M08 X 1.25 X 16, 8.8 435 32491 (020000-- ) Washer, Flt, .31 Std 2

r1lLine

STANDARD PARTS

6500D 330290 (9--02)2-22

Fig. 12 -- Instrument Panel Assembly

28

19

31

10

11

12

13

14

15

16

25

2324

33

3234

17

27

26

29

30

30

22

21

20

1

3

45

6 7

2

1

8

9

18

STANDARD PARTS

2-236500D 330290 (9--02)

353656 -- 6500,D, NAFig. 12 -- Instrument Panel Assembly

Ref.TennantPart No.


o 379659 (000000--019999 ) Replm Kit, Instr Panel 1Y 1 59976 (000000--019999 ) Replm Kit, Case 1Y 2 59977 (000000--019999 ) Replm Kit, Seal 1Yo 3 379658 (000000--019999 ) Replm Kit, Cir Board 1YY 4 59978 (000000--019999 ) Replm Kit, Hourmeter 1Y 5 59979 (000000--019999 ) Replm Kit, Touch Panel 1Y 6 59971 (000000--019999 ) Replm Kit, Lamp, Backlighting (8) 2Y 7 56346 (000000--019999 ( Replm Kit, Lamp, Fault (8) 1

8 10632--5 (000000--019999 ) Grommet,Rbr,0.25Id,For .09Matl 49 54342 (000000--019999 ) Panel Assy, Instr 110 12271 (000000-- ) Nut, U M 6X1.0 Pltd 2

o 11 87536 (000000-- ) Switch Ignition 1Y 12 87866 (000000-- ) Key Set,Switch Ku 1

13 19768 (000000-- ) Plate, Reinforcement--Ignition 114 382516 (000000-- ) Boot, Switch 115 353165 (000000-- ) Boot, Switch, Ignition 116 49263 (000000-- ) Tie, Cable, Nyl, 11.4l .19w 3.0 Max D 1

o 17 383212 (020000-- ) Panel, Instmt, W/ Label, [6500] 1Y 18 383220 (020000-- ) Gasket 1

19 383130 (020000-- ) Seal, Foam 120 383131 (020000-- ) Panel, Indicator Light 121 32490 (020000-- ) Washer, Flt, .25 Std 222 08708 (020000-- ) Nut, Hex, Lock, M06 X 1.0, Nl 223 31988 (020000-- ) Gauge, Hourmeter, Electronic 124 222683 (020000-- ) Gasket, Hourmeter 125 09146 (020000-- ) Screw, Pan, M03 X 0.5 X 12, 4.8 226 39658 (020000-- ) Washer, Lock, Int, #04 227 01754 (020000-- ) Nut, Hex, Std, M03 X 0.5 228 34813 (020000-- ) Gauge, Fuel, 0--90ohm 8--18vdc 129 72971 (020000-- ) Rivet, Plstc, .325d X 0.787 430 361075 (020000-- ) Light, Panl, 14vdc, , 1.1 X 1.0 631 383211 (020000-- ) Panel, Instmt, W/ Label, [6500] 132 398528 (020000-- ) Switch, Rocker, Dpdt, On--Off--Mom 133 398508 (020000-- ) Switch, Rocker, Dpdt, Mom--Off--Mom 134 392171 (020000-- ) Switch, Rocker, Dpdt On -- Off -- On 1

STANDARD PARTS

6500D 330290 (9--01)2-24

Fig. 13 -- Side Instrument Panel Group

1

2

45

6

7

8

15

10

13 121414

12

18

16

17

11

9

3

STANDARD PARTS

2-256500D 330290 (9--01)

353641 -- 6500, NAFig. 13 -- Side Instrument Panel Group

Ref.TennantPart No.


1 59824 (000000--019999 ) Panel Assy, Instrument w/label 11 383213 (020000-- ) Panel, Side, W/ Label, [6500] 12 69909 (000000--019999 ) Bellows Assy, Valve 13 59636 (000000--019999 ) Insulation, Acoustic 14 59622 (000000-- ) Insulation, Acoustic 15 59621 (000000-- ) Insulation, Acoustic 16 59628 (000000-- ) Insulation, Acoustic 17 59623 (000000-- ) Insulation, Acoustic 18 59629 (000000-- ) Insulation, Acoustic 19 383179 (020000-- ) Insulation, Acoustic 110 69234 (000000-- ) Clamp--Cable, 1.00Dia. .62Wth 211 59647 (000000-- ) Seal, Rubber 112 01314 (000000-- ) Plugbtn .38H .03--.12 Blacknyl (LPG only) 213 55035 (000000-- ) Plug, Plastic, 1.00 D 114 77399 (000000-- ) Clip, Pine--tree .236h Plastic 215 44078 (000000-- ) Switch, Pushmom, Spst100A 12V 1

o 16 383214 (020000-- ) Panel, Valve Handle, W/ Label, [6500] 1Y 17 383180 (020000-- ) Seal, Handle, Valve 1

18 16944 (020000-- ) Screw, Hex, M04 X 0.7 X 10, Fmg 8

STANDARD PARTS

6500D 330290 (9--02)2-26

Fig. 14 -- Circuit Breaker and Relay Group

7

8

9

11

12

11

13

14

15

20

10

16 17

1

23

4

5

6

3

5

19

18

STANDARD PARTS

2-276500D 330290 (9--02)

353659 -- 6500, DFig. 14 -- Circuit Breaker and Relay Group

Ref.TennantPart No.


1 56186 (000000--019000 ) Relay, Shrouded, 12 Vdc 62 87583 (000000--019000 ) Breaker--Circuit, 2.5 Resetbl 13 57803 (000000--019000 ) Breaker--Circuit, 15 Resetbl 54 57167 (000000--019000 ) Plugbtn .62H .03--.12 Blacknyl 35 57751 (000000--019000 ) Boot--Circuit Breaker 66 56188 (000000--019000 ) Plate, Circuit Breaker 17 57772 (000000-- ) Plate--Cover 28 56992 (006518-- ) Button, Plug, 0.50H .03--.12 [Black Nyl] 29 77399 (006518-- ) Clip, [Pine--Tree], .236h, Plstc 210 57804 (020000-- ) Relay, 12vdc, 40a, Spdt, [Potter] 311 383722 (020000-- ) Circuitbreaker, 15.0a 512 33807 (020000-- ) Button, Plug, 0.44h .03--.12 [Black Nyl] 313 383189 (020000-- ) Plate, Access 114 379656 (020000-- ) Timer 115 06942 (020000-- ) Screw, Hex, M06 X 1.0 X 16, 8.8 216 08708 (020000-- ) Nut, Hex, Lock, M06 X 1.0, Nl 217 32490 (020000-- ) Washer, Flt, .25 Std 218 379665 (020000-- Module 119 383727 (020000-- Circuitbreaker, 40.0a 120 55845 (020000-- ) Screw, Hex, M05 X 0.8 X 16, Fmg 3

STANDARD PARTS

6500D 330290 (9--02)2-28

Fig. 15 -- Engine and Governor Group

1

65 7

11

1216

13

14

2

4

3

8

9

10

1718

21

19

2022

15

16

r1lLine

STANDARD PARTS

2-296500D 330290 (9--02)

353826 -- 6500, DFig. 15 -- Engine and Governor Group

Ref.TennantPart No.


1 84625 (000000-- ) Engine, Diesel Kubota E Series (See Engine Breakdown) 12 59884 (000000-- ) Ftg--Metric E90 Omm22/Jm12 13 59891 (000000-- ) Hose--Hyd Low12 Jf/Jf 14 59885 (000000-- ) Ftg--Hyd Plg Jm12 15 24976 (000000-- ) Ftg--Brs E45 Pm02/Pf02 16 79399 (000000-- ) Switch, Pressure, Oil 17 36165 (000000--019999 ) Send Unit, Temperature 17 60711 (020000-- ) Switch, Temperature, Water 18 59640 (000000-- ) Bracket Wldt, Mtg, Actuator 1

o 9 58391 (000000--008219 ) Throttle Assy, Block, Die 1Y 10 64939 (000000--008219 ) Bearing, Bronze 2

11 391815 (000000--008219 ) Boot, Rubber 112 58362 (000000--008219 ) Rod, Throttle Control, Diesel 113 07539 (000000--008219 ) Actuator, Governor 114 30481 (000000--008219 ) Lever, Governor Actuator 115 53424 (000000--008219 ) Stud, .25--28 4.6L .25--28 116 14601 (000000--008219 ) Balljoint .250--28 217 374511 (000000-- ) Bracket, Drain Hose Clamp 118 30407 (000000-- ) Clip, Keeper, Open 119 71385 (008220-- ) Actuator, Govnr, Dsl 120 393401 (008220-- ) Adaptor, Actuator, Govnr, Eng, Dsl 121 71388 (008220-- ) Screw, Soc, M06 X 1.0 X 16, 12.9 422 70165 (008220-- ) Gasket, Throttle 1

STANDARD PARTS

6500D 330290 (9--01)2-30

Fig. 16 -- Engine Mount Group

7

63

12

910

11

511

10

11

8

4

1 2

11

11

10

13

14

15

r1lLine

r1lNoteEngine mount hardware (qty 3);

06972 SCREW, HEX, M12 X 1.75 X 60, 8.808711 NUT, HEX, LOCK, M12 X 1.75,NL

STANDARD PARTS

2-316500D 330290 (3--00)

351793 -- DFig. 16 -- Engine Mount Group

Ref.TennantPart No.


1 55837 (000000-- ) Adaptor, Flywheel Hsg, Kubota 12 19252 (000000-- ) Coupling Assy, Flywheel 13 54911--16 (000000-- ) Dowel,Cyl.Block To Flywhl.Hsg. 24 58566 (000000-- ) Housing, Flywheel, Rework 15 57773 (000000-- ) Wire Assy--Elect.,Ground 16 74405 (000000-- ) Starter, Die (See Engine Breakdown) 17 55831 (000000-- ) Bracket Wldt, Mtg, Engine 18 57755 (000000-- ) Bracket Wldt,Mtg,Eng, Rear, Rh 19 57754 (000000-- ) Bracket Wldt,Mtg,Eng,Rear, Lh 110 51176 (000000-- ) Dampner, Engine 311 04414 (000000-- ) Washer, Flat 612 59946 (000000-- ) Magnet Assy, Pick--Up 113 30407 (000000-- ) Clip, Keeper, Open 114 375117 (000000-- ) Solenoid Starter, 12V 115 361339 (000000-- ) Scr--Hxfmgm 6x1.0 16 Pltd 2

STANDARD PARTS

6500D 330290 (9--02)2-32

Fig. 17 -- Air Cleaner Group

9

7

8

8

8

12

3

13

8

11

10 25

4

6

1

14

STANDARD PARTS

2-336500D 330290 (9--02)

07084 -- DFig. 17 -- Air Cleaner Group

Ref.TennantPart No.


o 1 58538 (000000-- ) Air Cleaner 1Y 2 58120 (000000-- ) Element, Air Filter 1Y 3 02740 (000000-- ) Clamp Assembly Dn 1Y 4 02741 (000000-- ) Cup Assembly Dn 1Y 5 07562 (000000-- ) Nut, Wing .44--20 Special 1

6 51560--3 (000000-- ) Clamp,Mounting,Cyclopac Aircl. 27 58090 (000000-- ) Hose, Molded, Air Intake 18 14432 (000000-- ) Clamp--Wormdrive, 1.81-- 2.75D 49 03026 (000000-- ) Indicator,Service,Air Filter 110 53783 (000000-- ) Bracket, Mtg, Air Cleaner 111 58346 (000000-- ) Tube -- Carb. Air Intake 112 59811 (000000-- ) Tube, Inlet, A Clnr 113 30407 (000000-- ) Clip, Keeper, Open 114 58121 (000000-- ) Element, Fltr, Air 1

STANDARD PARTS

6500D 330290 (6--99)2-34

Fig. 18 -- Alternator and Engine Fan Group

7

10

1

6

5

8

9

2 3

4

07083 -- D

Ref.TennantPart No.


1 82731 (000000-- ) Wire--Ground, Alternator 12 30569 (000000-- ) Spacer, Fan 13 30559 (000000-- ) Fan, Pusher 14 57824 (000000-- ) Scr--Soc M 6X1.0 20 Nylonloc 45 55855 (000000-- ) Bracket, Alternator 16 55863 (000000-- ) Sleeve, .438B 1.00D .49 Sml 1

o 7 60559 (000000-- ) Alternator, 50A/12V Mando 1Y 61931 (000000-- ) Regulator Assy Md 1Y 86041 (000000-- ) Bearing--Ball, .669B 1.575D 0.472W 1Y 61529 (000000-- ) Cplt Brush Kit Md 1Y 61531 (000000-- ) Rectifier Assy Md 1Y 70160 (000000-- ) Altrntr Pulley Md 1

8 07274 (000000-- ) Spacer,Idler Mount 19 55856 (000000-- ) Arm, Alternator 110 58327 (000000-- ) Belt, V Hc41 X 41 1

STANDARD PARTS

2-356500D 330290 (9--02)

Fig. 19 -- Muffler Group (000000-- 007237)

1

2

2

2

6

7

8

10

11

3 4

9

5

12

10

5

07086 -- D, NA

Ref.TennantPart No.


1 55851 (000000--007237 ) Muffler, Exhaust 12 24012 (000000--007237 ) Clamp--Muffler,For 1.62 Od Tube 33 374677 (000000--006133 ) Repl. Kit, Bracket 14 54274 (000000--006133 ) Isolator--Vibration, 125lb. Rating 15 30013 (000000--007237 ) Washer--Flt .31 Fender Pltd 16 74451 (000000--007237 ) Pipe, Exhaust, Die 17 74452 (000000--007237 ) Pipe, Exhaust, Die 18 374676 (006134--007237 ) Angle, Muffler Hanger 19 16931 (006134--007237 ) Screw, Hex, M8 110 08709 (006134--007237 ) Nut, Hex, M8 211 374691 (006134--007237 ) Strap, Muffler Hanger 112 39277 (006134--007237 ) Screw, Hex, M8 1

STANDARD PARTS

6500D 330290 (9--02)2-36

Fig. 20 -- Muffler Group (007238-- )

1

2

6

3

10

5

2

4

2

7

8

9

13

13

11

1412

STANDARD PARTS

2-376500D 330290 (9--02)

07086 -- D, NAFig. 20 -- Muffler Group (007238-- )

Ref.TennantPart No.


1 55851 (007238-- ) Muffler, Exhaust 12 24012 (007238-- ) Clamp--Muffler,For 1.62 Od Tube 33 369780 (007238-- ) Tube Wldt, Exhaust, 1.6d W/ Flex 14 74452 (007238-- ) Pipe, Exhaust, Die 15 374735 (007238-- ) Channel, Mtg, Isolator, Muffler 16 374736 (007238-- ) Channel, Mtg, Muffler, [6500 Dsl] 17 54274 (007238-- ) Isolator--Vibration, 125lb. Rating 28 06955 (007238-- ) Screw, Hex, M08 X 1.25 X 35, 8.8 29 76570 (007238-- ) Screw, Hex, M08 X 1.25 X 30, 8.8 210 08709 (007238-- ) Nut, Hex, M8 211 374691 (007238-- ) Strap, Muffler Hanger 112 39277 (007238-- ) Screw, Hex, M8 113 39349 (007238-- ) Washer, Flt, .31 Sae 414 30013 (007238-- ) Washer, Flat, .31 Fender 1

STANDARD PARTS

6500D 330290 (5--01)2-38

Fig. 21 -- Fuel Tank Group

1

2

3

4

6

7 26

8

9

10

11

12

14

15

16

1718

19

2021

22

23

24

2512

13

13

12

12

5

STANDARD PARTS

2-396500D 330290 (3--00)

07087 -- D, NAFig. 21 -- Fuel Tank Group

Ref.TennantPart No.


1 55222 (000000-- ) Tray, Gas 1o 2 72191 (000000-- ) Tank, Fuel, 9.4 Gal 1Y 3 48267 (000000-- ) Cap, Fuel 1Yo 4 74406 (000000-- ) Sending Unit 1YY 5 14131 (000000-- ) Gasket 1Y 6 48126 (000000-- ) Ftg--Plug Npt 02Pm Sq Hd 1

7 53029 (000000-- ) Ftg--Brs E90 Bm05/Pm02 18 82509 (000000-- ) Hose, Fuel Line .31 Idx11.0 19 70173 (000000-- ) Hose, Fuelline, 10.0L 110 72192 (000000-- ) Fuelline 111 87738 (000000-- ) Hose, Rbr .188 I.D. X 29.0 Lg 112 43844 (000000-- ) Clamp--Wormdrive, 0.25-- 0.62D 413 87396 (000000-- ) Strap Weldmt, Gas Tank 214 15555--1 (000000-- ) Ftg--Brs E90 If05/Pm02 115 72193 (000000-- ) Fuelline 116 53078 (000000-- ) Ftg--Brs E90 If03/Pm02 1

o 17 58301 (000000-- ) Fitting Assy, Fuel 1Y 18 77002 (000000-- ) Seal, O--Ring .064X.30 1

19 58091 (000000-- ) Tube Assy, .250 D 04JF/04JF 120 06764 (000000-- ) Ftg--Hyd E90 Pm04/Jm04 1

o 21 55850 (000000-- ) Filter, Fueldiesel 1Y 55844 (000000-- ) Filter, Fuel, Element 1

22 72491 (000000-- ) Bracket, Mounting, Filter 123 46236 (000000-- ) Clamp--Cable, 0.25Dia 0.56Wth 124 15555--2 (000000-- ) Fitting, Brass E90 125 67767 (000000-- ) Clamp--Cable,.69Dia. 62Wth 126 59015 (000000-- ) Pump, Fuel 1

STANDARD PARTS

6500D 330290 (5--98)2-40

Fig. 22 -- Radiator Group

2

3

4

5

6

7

8

9

1

12

13

14

15

10 11

7

STANDARD PARTS

2-416500D 330290 (6--99)

07085 -- D, NAFig. 22 -- Radiator Group

Ref.TennantPart No.


1 55225 (000000-- ) Radiator 12 54911--32 (000000-- ) Draincock,End.Block 13 31755 (000000-- ) Cap, Radiator 14 55857 (000000-- ) Hose, Radiator, Upper, Die 15 55858 (000000-- ) Hose, Radiator, Lower, Die 16 11399 (000000-- ) Clamp--Wormdrive, 0.81-- 1.50D 27 11531 (000000-- ) Clamp--Wormdrive, 1.06-- 2.00D 28 54274 (000000-- ) Isolator--Vibration,60 Lb.Ratng 29 59551 (000000-- ) Plate, Filler 110 59881 (000000-- ) Spacer 111 10632--13 (000000-- ) Grommet,Rbr,1.50Id,For .19Matl 112 74395 (000000-- ) Guard, Fan, W/Label, Die 113 72147 (000000-- ) Bracket, Radiator Mount 114 59550 (000000-- ) Channel, Mtg, Radiator 115 74401 (000000-- ) Plate, Filler, Diesel 1

STANDARD PARTS

6500D 330290 (5--01)2-42

Fig. 23 -- Battery Group

1

2

4

5

6

3

To Bell To

78

Housing Starter

4

STANDARD PARTS

2-436500D 330290 (6--99)

07080 -- DFig. 23 -- Battery Group

Ref.TennantPart No.


1 10143 (000000-- ) Battery, 12V, Cc Amps:600 Wet 1o 2 60292 (000000-- ) Wire Assy, 66.0 Lg, 2 Ga, Pos 1Y 3 68873 (000000-- ) Boot, Batt. Term. 1--2 Ga Red 1

4 67767 (000000-- ) Clamp--Cable, .69Dia. .62Wth 25 49266 (000000-- ) Tie, Cable 1.75D Max 7.50Lg 26 33671 (000000-- ) Strap,Rubber Tie--Down 1

o 7 60293 (000000-- ) Wire Assy, 42.0 Lg, 2 Ga, Neg 1Y 8 68872 (000000-- ) Boot, Batt. Term. 1--2 Ga Black 1

STANDARD PARTS

6500D 330290 (5--98)2-44

Fig. 24 -- Rear Drive Wheel Group

1

2

4

6

7

8

10

11

12

13

22

15

16

1718

9

4

3

25

2

19

21

20

5

2423

14

23

22

r1lLine

r1lText Box39350 Washer32987 Nut, 0.75-10

r1lLine

STANDARD PARTS

2-456500D 330290 (3--00)

07058 -- 6500, NAFig. 24 -- Rear Drive Wheel Group

Ref.TennantPart No.


1 374561 (000000-- ) Housing, Sppt, Wheel 12 51339 (000000-- ) Bearing--Cone, 1.38Bore 0.71Wth 23 47801 (000000-- ) Ftg, Grease.25--28Th Strt .63L 24 51338 (000000-- ) Bearing--Cup , 2.56Dia 0.55Wth 25 54051 (000000-- ) Washer, Thrust 16 73281 (000000-- ) Pin, Wheel Support, Rear 17 54052 (000000-- ) Nut--Hxslot 1.12--18 Pltd 18 72926 (000000-- ) Scr Soc M16--2.0x50 29 70157 (000000-- ) Clamp--Cable, 2.50Dia 1.00Wth Ss 110 24339 (000000-- ) Nut--Wheel .50--20 60 Angle 511 58842 (000000-- ) Plate -- Hose Support 112 53601 (000000-- ) Cylinder--Hyd (See Breakdowns) 113 56820 (000000-- ) Ftg--Hyd E90 Jm06/Om06 214 64886 (000000-- ) Balljoint, Rod End 115 64887 (000000-- ) Balljoint, Rod End 116 361025 (000000--005544 ) Motor--Hyd Gear (See Breakdowns) 116 374559 (005545-- ) Motor--Hyd Gear (See Breakdowns) 117 46480 (000000-- ) Ftg--Hyd Str Jm10/Om10 218 77097 (000000-- ) Ftg--Hyd E90 Jm04/Om04 1

o 19 82239 (000000-- ) Hub & Stud Assy 1Y 20 32126 (000000-- ) Stud, Wheel .50--20 x 1.50 5

21 72155 (000000-- ) Bracket, Drive Motor 122 374553 (000000-- ) Scr--Hex .75--10x3.50 Pltd 223 374552 (000000-- ) Tube, 1.25D 0.75B 0.8L Stl 224 374563 (000000-- ) Washer, 2.156B 3.5D .16 Felt 125 374560 (000000-- ) Seal, Rear Drive Grease Cavity 1

STANDARD PARTS

6500D 330290 (3--99)2-46

Fig. 25 -- Rear Wheel Assembly

1

2

3

4

5

6

7

1

STANDARD PARTS

2-476500D 330290 (6--99)

10932 -- IC, NAFig. 25 -- Rear Wheel Assembly

Ref.TennantPart No.


o 70287 (000000-- ) Tire & Rim Assy, 5.70/5.00R--8 1Y 1 53818 (000000-- ) Rim Assembly 1Yo 2 53819 (000000-- ) Tire, Tube and Flap Assembly 1YY 3 70280 (000000-- ) Tube, Inner --5.00R--8, Js2 Valve 1YY 4 53819--2 (000000-- ) Flap, Tube 1Y 5 45786 (000000-- ) Cap, Valve Stem 1Y 6 41430 (000000-- ) Nut, Hxlocnyln M10x1.5 5Y 7 370181 (000000-- ) Screw--Hx M10x1.5 Pltd 5

STANDARD PARTS

6500D 330290 (9--01)2-48

Fig. 26 -- Front Wheel and Brakes Group

1

2

3

4

5

6 7

1810

12

13

14

15

16

1615

1216

1216

1216

15

15

12

16

15

12

14

5

12

17

11

20

23

19

22 21

8

9

24

STANDARD PARTS

2-496500D 330290 (9--02)

07048 -- IC, NA, CEFig. 26 -- Front Wheel and Brakes Group

Ref.TennantPart No.


o 1 54577 (000000-- ) Brake Assy 2Y 66211 (000000-- ) Brake Shoes 2Yo 66213 (000000-- ) Brake Repair Kit 1YY 70161 (000000-- ) Chrome Pltd Cam Shft 1Y 70158 (000000-- ) Return Spring--Brakes 2o 2 54437 (000000-- ) Wheel Assy 2Y 3 54567 (000000-- ) Tire,18X5X12.12 Solid 1Y 4 51338 (000000-- ) Bearing--Cup , 2.56Dia 0.55Wth 2

5 51339 (000000-- ) Bearing--Cone, 1.38Bore 0.71Wth 46 14242 (000000-- ) Nut--Hxslot 1.00--20 Pltd 27 54390 (000000-- ) Cap, Hub 28 54467 (000000--020052 ) Clevis, Adjustable 19 58288 (000000--020052 ) Clip, Cable 110 86240 (000000-- ) Pin Clevis .375 Dia X 1.13 Lg 111 39005 (000000-- ) Pin, Cotter, .094 X 0.75 112 369781 (000000-- ) Pulley, Cable, 1.5D, Nyl 713 54617 (000000-- ) Cable, Brake, Service 114 09088 (000000-- ) Pin,Clevis,0.37 Dia.X 1.00 Lg 215 54400 (000000-- ) Angle, Cable Keeper 616 222460 (000000-- ) Spacer, Pulley 617 32969 (000000-- ) Washer--flt 1.00 Pltd 218 374710 (020053-- ) Clevis, Adj, 0.38pin, 0.50 -- 20 119 71373 (020053-- ) Clevis Wldt, Adj, .50pin 0.50--20, Pl 120 39313 (020053-- ) Nut, Hex, Std, M12 X 1.75 121 08182 (020053-- ) Pin, Cotter, .125 X 1.00 122 58078 (020053-- ) Pin, Clevis, 0.50 D X 1.25l 123 48985 (020053-- ) Nut, Hex, Jam, .50--20 124 374711 (000000--020052 ) Kit, Replmt, Connector, Cable, Brake 1

STANDARD PARTS

6500D 330290 (5--98)2-50

Fig. 27 -- Brake Lever and Pedal Group

2

14

6

7

8

9

10

1

11

1213

10

5

4

3

3

15

STANDARD PARTS

2-516500D 330290 (9--02)

07093 -- NA, JPFig. 27 -- Brake Lever and Pedal Group

Ref.TennantPart No.


o 1 72132 (000000-- ) Shaft Wldt, Brake w/pad 1Y 2 51109 (000000-- ) Pad 1

3 86751 (000000-- ) Brg, Brake 24 23788 (000000-- ) Ring--Retain, Ex, 0.98OD, E--Ring 25 54607 (000000-- ) Spring, Torsion 16 69933 (000000-- ) Pad, Rubber 17 51545 (000000-- ) Lever, Brake 18 51562 (000000-- ) Sleeve, .344B .50D .81 Cr.Anc 29 54616 (000000-- ) Cable, Parking Brake 110 86240 (000000-- ) Pin Clevis .375 Dia X 1.13 Lg 211 369781 (000000-- ) Pulley, Cable, 1.5D, Nyl 112 54400 (000000-- ) Angle, Cable Keeper 113 222460 (000000-- ) Spacer, Pulley 114 58979 (000000-- ) Scr--Hexss M6 x 1.0 415 08712 (000000-- ) Nut--Hxlocnyln M6 x 1.0 Regss 4

STANDARD PARTS

6500D 330290 (5--98)2-52

Fig. 28 -- Directional Pedal Group

7

5

9

10

11

12

13

14

11

4

15

6

2

1

8

3

45

16

17

STANDARD PARTS

2-536500D 330290 (6--99)

351740 -- 6500Fig. 28 -- Directional Pedal Group

Ref.TennantPart No.


1 05686 (000000-- ) Rod--End M10X1.5 W/Stud 22 54996 (000000-- ) Rod, Adjusting 13 16213 (000000-- ) Scr--Shld .312Dx1.00L .25--20 14 53927 (000000-- ) Bracket Sppt, Control Rod 25 04843 (000000-- ) Bearing, Flange .625 Bore 26 67290 (000000-- ) Pin,Clevis,0.50 Dia.X 3.75 Lg 17 74475 (000000-- ) Rod Weldt, Drive Linkage 18 73411 (000000-- ) Shock Absorber 19 379732 (000000-- ) Bracket, Speed Limiter 110 51813 (000000-- ) Pin,Clevis,0.37 Dia.X 2.12 Lg 111 05686 (000000-- ) Rod--End M10X1.5 W/Stud 212 374520 (000000-- ) Rod, Speed Limiter, Adjusting, Rh 1

o 13 72129 (000000-- ) Pedal, Propel w/pad 1Y 14 75430 (000000-- ) Pad, Tread 1

15 75430 (000000-- ) Pad, Tread 116 84170 (000000-- ) Bracket, Retainer 117 75934 (000000-- ) Nut--Hxlocnyln .25--20 Thin Pltd 1

STANDARD PARTS

6500D 330290 (5--98)2-54

Fig. 29 -- Hydraulic Pump Linkage Group

23

4

5

6

7

8

9

10

1

11

12

13

14

4

10

11

9

7

8

16

15

17

STANDARD PARTS

2-556500D 330290 (6--99)

07090 -- ICFig. 29 -- Hydraulic Pump Linkage Group

Ref.TennantPart No.


1 05686 (000000-- ) Rod--End M10X1.5 W/Stud 12 54015 (000000-- ) Rod, Adjusting 13 86791 (000000-- ) Scr--Shld .500Dx1.25L .38--16 14 52508 (000000-- ) Washer--Wavy Spring,#Ww--381--&--8 25 54997 (000000-- ) Bracket Assy, Isolator 16 54999 (000000-- ) Arm, Control, Pintle 17 53953 (000000-- ) Arm 28 54205 (000000-- ) Bumper, Threaded 29 63234 (000000-- ) Sleeve, Bearing 210 11842 (000000-- ) Sprng,Tens,0.75Odx.12Wire 3.4L 211 48079 (000000-- ) Bolt--Eye, .25--20Th .25B 1.4L 212 53947 (000000-- ) Cam 113 54655 (000000-- ) Cam 114 53950 (000000-- ) Bracket, Propel 115 09775 (000000-- ) Nut--Hx Stdss M10x1.5 Left 116 36643 (000000-- ) Nut--Hxlocnyln .38--16 Thin Pltd 117 50045 (000000-- ) Scr--Hex .31--24x0.62 Pltd 1

STANDARD PARTS

6500D 330290 (6--99)2-56

Fig. 30 -- Hopper Group (Metal Hopper)

6

7

2

1

8

28

18

29

3

54

9

101016

11

13

14 15

1612

17

6

619

10

2120

2223

23

24

2625

27

23

STANDARD PARTS

2-576500D 330290 (9--02)

351742 -- Not 6500 CE, JPFig. 30 -- Hopper Group (Metal Hopper)

Ref.TennantPart No.


1 379535 (000000--005639 ) Hopper Wldt 12 59680 (000000--005639 ) Skirt, Lip 13 59681 (000000--005639 ) Skirt, Lip 14 55890 (000000--005639 ) Strap, Main Lip 15 09010 (000000--005639 ) Screw, Hex, M08--1.25 X 25, Ss 56 01685 (000000--005639 ) Washer, Flat, .31 Ss 87 08713 (000000--005639 ) Nut, Hex, Lock, M08--1.25,Nl,Ss 58 55021 (000000--005639 ) Filter, Dust, Panel, Perma Filter 19 82483 (000000--005639 ) Tube 210 08712 (000000--005639 ) Nut, Hex, Lock, M06--1.0, Nl,Ss 1211 33930 (000000--005639 ) Screw, Hex, M06--1.0 X 40, Ss 212 58103 (000000--005639 ) Seal 113 59105 (000000--005639 ) Seal 114 55884 (000000--005639 ) Strap 115 09007 (000000--005639 ) Screw, Hex, M06--1.0 X 25, Ss 616 01684 (000000--005639 ) Washer, Flat, .25 Ss 1217 55879 (000000--005639 ) Angle 118 09740 (000000--005639 ) Screw, Hex, M08--1.25 X 20, Ss 319 07791 (000000--005639 ) Nut, Hex, Flange, M08--1.25 320 59189 (000000--005639 ) Plate 121 55965 (000000--005639 ) Seal 122 15678 (000000--005639 ) Screw, Hex, M06--1.0 X 16, Ss 423 40678 (000000--005639 ) Clamp, Cable 324 72159 (000000--005639 ) Washer, .562b 3.03 D .25hr 625 69972 (000000--005639 ) Screw, Hex, M12--1.75 X 40,10.9 626 36328 (000000--005639 ) Washer, Belleville, .50 627 59814 (000000--005639 ) Insulation, Acoustic, Hopper 128 59821 (000000--005639 ) Insulation, Acoustic, Hopper 129 379785 (000000--005639 ) Seal, Foam Rubber 1

STANDARD PARTS

6500D 330290 (5--01)2-58

Fig. 31 -- Hopper Group (Plastic Hopper)

2

24

16

1517

1

27

15

3

5

35

15

14

12

13

1415

5

2615

25

22 23

6

21

10

97

8

14

20

18

19 4

6

4 11

STANDARD PARTS

2-596500D 330290 (9--01)

352716 -- 6500Fig. 31 -- Hopper Group (Plastic Hopper)

Ref.TennantPart No.


1 379590 (005640-- ) Hopper, Molded 12 379707 (005640-- ) Plate, Support, Hopper 13 49826 (005640-- ) Screw, Hex, M08--1.25 X 16, Ss 54 08713 (005640-- ) Nut, Hex, Lock, M08--1.25,Nl,Ss 75 01685 (005640-- ) Washer, Flat, .31 Ss 106 379829 (005640-- ) Washer, .34B 1.50D 97 379706 (005640-- ) Skirt, Lip 18 379705 (005640-- ) Skirt, Lip 19 379704 (005640-- ) Strap, Main Lip 110 379792 (005640-- ) Bolt, Carriage M8x1.25Pltd 511 54089 (005640-- ) Skirt, Side, SBDC, Lh 112 379831 (005640-- ) Plate, Retainer 113 379814 (005640-- ) Plate, Retainer 114 11329 (005640-- ) Screw, Hex, M06--1.0 X 16, Ss 1015 01684 (005640-- ) Washer, Flat, .25 Ss 1616 379812 (005640-- ) Panel Wldt, Perma Filter 117 33930 (005640-- ) Screw, Hex, M06--1.0 X 40, Ss 218 59189 (005640-- ) Plate 119 55965 (005640-- ) Seal, Vac Wand 120 46236 (005640-- ) Clamp, Cable 0.25D 0.56W Stl 121 379727 (005640-- ) Wiper Door 122 379726 (005640-- ) Strap, Wiper, Door 123 59658 (005640-- ) Screw, Hex, M08--1.25 X 25, Ss 724 379834 (005640-- ) Seal, Pocket, Hopper 125 379835 (005640-- ) Plate, Retainer 126 08716 (005640-- ) Screw, Hex, M06--1.0 X 20, Ss 527 08712 (005640-- ) Nut, Hex, Lock, M06--1.0, Nl,Ss 5

STANDARD PARTS

6500D 330290 (6--99)2-60

Fig. 32 -- Hopper Dump Door Group (Metal Hopper)

1

3

2

4

5

6

98

6

76

7

10

11

11

11

12

8

9

6 16

6

15

14

13

tech pubNote33612 - screw66185 - jam nut

STANDARD PARTS

2-616500D 330290 (6--99)

351744 -- Not 6500 CE, JPFig. 32 -- Hopper Dump Door Group (Metal Hopper)

Ref.TennantPart No.


1 374507 (000000--005639 ) Door Wldt, Dump 12 55864 (000000--005639 ) Cord, Sponge 13 59685 (000000--005639 ) Seal 14 59686 (000000--005639 ) Strap 15 09007 (000000--005639 ) Screw, Hex, M06--1.0 X 25, Ss 146 01684 (000000--005639 ) Washer, Flat, .25 Ss 347 08712 (000000--005639 ) Nut, Hex, Lock, M06--1.0, Nl,Ss 148 59687 (000000--005639 ) Seal 29 59688 (000000--005639 ) Strap 210 55889 (000000--005639 ) Rod 111 55892 (000000--005639 ) Spring, Tension 312 11893 (000000--005639 ) Bolt, Eye, .25--20x1.5x .56 Eye 313 54089 (000000--005639 ) Skirt 114 54013 (000000--005639 ) Plate, Retainer 115 54014 (000000--005639 ) Plate, Retainer 116 12459 (000000--005639 ) Screw, Hex, Fmg, M06--1.0 X 20 6

STANDARD PARTS

6500D 330290 (6--99)2-62

Fig. 33 -- Hopper Cylinder and Dust Door Group (Metal Hopper)

2

3

4

5

6 7

8

9

101

11

12

13

14

15

17

18

19

20

21

22

16

15

2323

16

24

4

26

25

272829

30

STANDARD PARTS

2-636500D 330290 (3--00)

07064 -- NAFig. 33 -- Hopper Cylinder and Dust Door Group (Metal Hopper)

Ref.TennantPart No.


1 51317 (000000--005639 ) Pin,Roll,.38Odx2.00L,.375/.382 22 53910 (000000--005639 ) Door, Dust 13 53915 (000000--005639 ) Rod Wldt 14 34725 (000000--005639 ) Collar, Locking 45 34096 (000000--005639 ) Bearing--Flange,2 Hole .625Bore 26 26103 (000000--005639 ) Pin,Roll,.18Odx1.25L,.187/.192 27 59966 (000000--005639 ) Bar, Link 28 59965 (000000--005639 ) Switch Assy, Roller 19 42120--1 (000000--005639 ) Bearing--Self Align 1.250 Bore 210 78787 (000000--005639 ) Yoke, Pivot, Machining 211 55893 (000000--005639 ) Bar, Link 212 54096 (000000--005639 ) Cylinder--Hyd,2.0X 4.0Da2500Psi 213 55586 (000000--005639 ) Ftg--Hyd Str Jm04/Om04 214 77097 (000000--005639 ) Ftg--Hyd E90 Jm04/Om04 215 87677 (000000--005639 ) Sleeve--Nyln #20 20.0L 316 34392 (000000--005639 ) Ftg--Hyd Tee Jm04Jmbjm 217 68441 (000000--005639 ) Ftg--Hyd E45 Jm04/Jf04 118 23524 (000000--005639 ) Ring,Retain,Ex,0.50Od,Selflock 219 11211 (000000--005639 ) Pin,Clevis,0.50 Dia.X 2.25 Lg 220 58078 (000000--005639 ) Pin,Clevis,0.50 Dia.X 1.25 Lg 221 51534 (000000--005639 ) Pin,Clevis,0.50 Dia.X 2.00 Lg 222 55914 (000000--005639 ) Hub, Pivot 223 08182 (000000--005639 ) Pin, Cotter 424 47801 (000000--005639 ) Ftg, Grease .25--28Th Strt .63L 225 09744 (000000--005639 ) Screw, Hex, M06--1.0 X 12, Ss 426 08712 (000000--005639 ) Nut, Hex, Lock, M06--1.0, Nl,Ss 427 24199 (000000--005639 ) Screw, Hex, M05--0.8 X 16, Ss 228 01683 (000000--005639 ) Washer, Flat, #10 Ss 229 09739 (000000--005639 ) Nut, Hex, Lock, M05--0.8, Nl,Ss 230 09026 (000000--005639 ) Screw, Hex, M08--1.25 X 40, Ss 4

STANDARD PARTS

6500D 330290 (6--99)2-64

Fig. 34 -- Hopper Cylinder and Dump Door Group (Plastic Hopper)

30

2516

15

5

28 2726

7

85

9

24

15

6

1

29

1213

11 162

3

4

65 10

9

58

7

56

5

6

3117

14

13

20181321

22

13

2319

13

14

3233

STANDARD PARTS

2-656500D 330290 (6--99)

352718 -- 6500Fig. 34 -- Hopper Cylinder and Dump Door Group (Plastic Hopper)

Ref.TennantPart No.


1 379701 (005640-- ) Door Wldt, Dump 12 379699 (005640-- ) Seal, Door, Dump 13 379698 (005640-- ) Plate, Retainer, Dump Dooor 14 379791 (005640-- ) Bolt, Carriage M6x1.0 Pltd 65 01684 (005640-- ) Washer, Flat, .25 Ss 266 08712 (005640-- ) Nut, Hex, Lock, M06--1.0, Nl,Ss 167 379702 (005640-- ) Seal, Door, Dump, Side 28 379703 (005640-- ) Srap, Door, Dump, Side 29 08716 (005640-- ) Screw, Hex, M06--1.0 X 25, Ss 810 379809 (005640-- ) Bracket, Switch, Door 111 379728 (005640-- ) Bracket, Cylinder 112 09010 (005640-- ) Screw, Hex, M08--1.25 X 25, Ss 213 01685 (005640-- ) Washer, Flat, .31 Ss 1414 08713 (005640-- ) Nut, Hex, Lock, M08--1.25,Nl,Ss 615 06474A (005640-- ) Pin, Clevis 216 32486 (005640-- ) Washer, Flat, .50 Sae 217 379821 (005640-- ) Seal, Shaft 218 55914 (005640-- ) Hub, Pivot 219 42120--1 (005640-- ) Bearing, Align. Self 1.25B 220 47801 (005640-- ) Fitting, Grease, Str 221 222504 (005640-- ) Screw--Hexssm 8x1.25 55 422 49826 (005640-- ) Screw, Hex, M08--1.25 X 16, Ss 223 379829 (005640-- ) Washer, .344B 1.5D .12Cr 224 54096 (005640-- ) Cylinder, Hyd 2.0B 4.0S 2500 125 364697 (005640-- ) Tube, 0.75D 0.51B 0.8L Stl 226 59965 (005640-- ) Switch Assembly, Roller--No 127 09739 (005640-- ) Nut, Hex, Lock, M05--0.8, Nl,Ss 228 55586 (005640-- ) Fitting, Hyd, Str 129 77097 (005640-- ) Fitting, Hyd, Elbow 130 84029 (005640-- ) Sleeve, 45” Lg 131 379832 (005640-- ) Washer, 1.25Ob 2.0D .19L 232 01683 (005640-- ) Washer, Flat 10 Ss 433 24199 (005640-- ) Screw, Hex, M05--0.8 X 16, Ss 2

STANDARD PARTS

6500D 330290 (6--99)2-66

Fig. 35 -- Hopper Hood and Bumper Group (Metal Hopper)

1 2

4

5

6

7

8

91011

12

13

14

15

16

17

18

19

20

21

22

1

3

8 1011

1415

23

24

23

24

25

26

27

28

29

3

29

STANDARD PARTS

2-676500D 330290 (3--00)

351746 -- IC, NAFig. 35 -- Hopper Hood and Bumper Group (Metal Hopper)

Ref.TennantPart No.


o 1 74310 (000000--005639 ) Cover, Hopper 1Y 2 59442 (000000--005639 ) Strip, Mtg, Hinge 1Y 3 59738 (000000--005639 ) Strip, Mtg, Gusset 2Y 4 59737 (000000--005639 ) Bracket, Gusset, Corner, Lh 1Y 5 59739 (000000--005639 ) Bracket, Gusset, Corner, Rh 1

6 17200 (000000--005639 ) Label, Tennant Logo-- 10.0 Blue 17 70185 (000000--005639 ) Bracket Wldt, Hpr Cvr Sprng 28 70178 (000000--005639 ) Plate Wldt, Sprngbrkt Backing 49 64535 (000000--005639 ) Spring--Gas 120Lb 7.1 Stroke 210 64595 (000000--005639 ) Clip Safety 411 58494 (000000--005639 ) Stud, Ball, Gas Spring 412 10632--1 (000000--005639 ) Grommet,Rbr,1.06Id,For .19Matl 113 58500 (000000--005639 ) Hinge, Coverhopper 314 59004 (000000--005639 ) Housing, Headlight 215 58524 (000000--005639 ) Headlight, 12V.Rect. 216 379551 (000000--005639 ) Bumper Wldt, Front 117 59448 (000000--005639 ) Skirt,Bumperstop 218 379883 (000000--005639 ) Seal, Bulb 119 62595--6 (000000--005639 ) Molding, Trim 11--14Ga 7.50 120 369817 (000000--005639 ) Duct, Vinyl (Cut in 2) 121 74352 (000000--005639 ) Cable, Cover, Safety 122 74353 (000000--005639 ) Spring, Tension 123 72971 (000000--005639 ) Rivet, Plastic .325D x .787 824 72969 (000000--005639 ) Rivet, Plastic .181D x .720 825 70193 (000000--005639 ) Bracket, Cable Spring 126 08716 (000000--005639 ) Screw, Hex, M06--1.0 X 20, Ss 427 01684 (000000--005639 ) Washer, Flat, .25 Ss 428 08712 (000000--005639 ) Nut, Hex, Lock, M06--1.0, Nl,Ss 429 01760 (000000--005639 ) Nut, Hex, Lock, .31--18, Nl 4

STANDARD PARTS

6500D 330290 (5--01)2-68

Fig. 36 -- Hopper Hood Group (Plastic Hopper)

12

6

1

14

2

3

78

78

14

4

6

5

5 6

78

911

15

1011

13

5

16

16

16

17

STANDARD PARTS

2-696500D 330290 (5--01)

352722 -- 6500, NA, CEFig. 36 -- Hopper Hood Group (Plastic Hopper)

Ref.TennantPart No.


1 379764 (005640--006745 ) Hopper Cover Assembly 12 379591 (005640--006745 ) Cover, Inner Molded 13 379786 (005640-- ) Bracket, Hood, Rh 14 379787 (005640-- ) Bracket, Hood, Lh 15 49826 (005640--006745 ) Screw, Hex, M08--1.25 X 16, Ss 136 32491 (005640--006745 ) Washer, Flat, .31 Hard 157 58494 (005640-- ) Stud, Ball, Gas Spring 48 64595 (005640-- ) Clip, Safety Gas Spring 49 379784 (005640-- ) Hinge, Hopper Cover 310 11329 (005640-- ) Screw, Hex, M06--1.0 X 16, Ss 611 32490 (005640-- ) Washer, Flat, .25 Hard 1212 17200 (005640--006745 ) Label, Tennant Logo, Oval 10.5 113 62595--6 (005640--006745 ) Molding, Trim 11--14Ga 7.5 114 64535 (005640-- ) Spring--Gas 120Lb 7.1 Stroke 215 08708 (005640-- ) Nut, Hex, Lock, M06--1.0, Nl 616 01685 (005640-- ) Washer, Flat, .31 Ss 417 379881 (006746-- ) Cover, Hopper, 6500 1

STANDARD PARTS

6500D 330290 (6--99)2-70

Fig. 37 -- Hopper Bumper Group (Plastic Hopper)

3

12

54

109

15

16

24

1

18

1419

17 20

2322

14

13

6

5

3

410

9

25

21

22

23

11

1214

16 15

8

7

2723

2

22

26

STANDARD PARTS

2-716500D 330290 (3--00)

352720 -- 6500, NA, JPFig. 37 -- Hopper Bumper Group (Plastic Hopper)

Ref.TennantPart No.


1 11636 (005640-- ) Latch, Draw, Flexible 12 01335 (005640-- ) Rivet, Pop-- .125Dx.44x.25 43 364498 (005640-- ) Pin, Hopper, Lift 24 69972 (005640-- ) Screw, Hex, M12--1.75 X 40,10.9 25 36328 (005640-- ) Washer, Belleville, .50 26 379820 (005640-- ) Plate, Retainer, Bumper 27 379788 (005640-- ) Plate, Retainer, Rh 18 379789 (005640-- ) Plate, Retainer, Lh 19 36328 (005640-- ) Washer, Belleville, .50 410 08711 (005640-- ) Nut, Hex, Lock, M12--1.75,Nl 411 379827 (005640-- ) Plate, Retainer, Bumper 212 09774 (005640-- ) Screw, Hex, M12--1.75 X 50, Ss 413 09741 (005640-- ) Nut, Hex, Lock, M12--1.75,Nl,Ss 414 36328 (005640-- ) Washer, Belleville, .50 1015 58524 (005640-- ) Headlight, 12V. Rect. 216 360943 (005640-- ) Screw, Pan, #10--14 X 0.75 817 379883 (005640-- ) Seal, Bulb 118 09029 (005640-- ) Screw, Hex, M12--1.75 X 40, Ss 219 32494 (005640-- ) Washer, Flat, .62 Hard 220 379833 (005640-- ) Bracket, Stiffener 121 08716 (005640-- ) Screw, Hex, M06--1.0 X 20, Ss 422 01684 (005640-- ) Washer, Flat, .25 Ss 1623 08712 (005640-- ) Nut, Hex, Lock, M06--1.0, Nl,Ss 1024 379551 (005640-- ) Bumper Wldt, Front 125 59448 (005640-- ) Skirt, Bumper Stop 226 08716 (005640-- ) Screw, Hex, M6--1.0, Ss 427 41178 (005640-- ) Washer, Flat, .25 Fender Pltd 2

STANDARD PARTS

6500D 330290 (9--02)2-72

Fig. 38 -- Filter Box Group (Metal Hopper)

18

11

11

12

14

21

15

1

513

3

2

316

7

9 4

6

8

17 10 1017

19

19

20

20

22

23

23

r1lPencil

r1lPencil

r1lPencil

r1lLine

r1lLine

r1lLine

STANDARD PARTS

2-736500D 330290 (9--02)

351748 -- IC (Not 6500CE, JP)Fig. 38 -- Filter Box Group (Metal Hopper)

Ref.TennantPart No.


1 379558 (000000--005639 ) Tray, Filter Carrier 12 379555 (000000--005639 ) Plate, Panel, Shaker 13 49697 (000000--005639 ) Screw, Pan, M04--0.7 X 10, Ss 54 02712 (000000--005639 ) Thermostat 15 79425 (000000--005639 ) Seal, Bulb, [Sd--0106], 140.00l 16 379560 (000000--005639 ) Foam, Acoustic, Hopper 17 81812 (000000--005639 ) Spring 18 379556 (000000--005639 ) Cover, Filter Panel 19 40607 (000000--005639 ) Ftg--Brs Str 110 379530 (000000--005639 ) Bracket, Filter, Hold Down 211 379531 (000000--005639 ) Bar Wldt, Shaker 212 379781 (000000--005639 ) Insulation, Foam 113 375209 (000000--005639 ) Filter Pkg, Dust, Panel, 94 Plts 113 379882 (000000--005639 ) Kit, Filter, Synthetic (Option) 113 375249 (000000--005639 ) Kit, Filter, Surface Load, 98 Plts (Option) 114 77320 (000000--005639 ) Hose, Vacuum 115 23498 (000000--005639 ) Clamp, Wormdrive 116 379890 (000000--005639 ) Solenoid Assy, Filter Shaker, 12V 117 04706 (000000--005639 ) Handle, Lift, Brush 418 379665 (000000--005639 ) Module, Shaker, 12V 119 26395--2 (000000--005639 ) Clamp, Cable 220 379822 (000000--005639 ) Seal 421 379823 (000000--005639 ) Clamp, Bridge, 4.0 122 379849 (000000--005639 ) Restrictor Ring Kit 123 49266 (000000--005639 ) Tie, Cable, Nyl, 07.3L .19W 1.8 Max D 4

STANDARD PARTS

6500D 330290 (9--02)2-74

Fig. 39 -- Filter Box Group (Plastic Hopper)

19

20

2

1

3

4

56

6

7

12

1511

9

8

1716

18

23

2322

21

24

24

2424

25

26

27

27

2928

30

22

31 14

10

13

25

r1lLine

r1lLine

r1lLine

r1lText Box13

r1lText Box32

r1lText Box33

STANDARD PARTS

2-756500D 330290 (9--02)

352724 -- 6500, NA, CEFig. 39 -- Filter Box Group (Plastic Hopper)

Ref.TennantPart No.


1 379817 (005640-- ) Seal, Foam Rubber, Filter 12 375209 (005640-- ) Filter Pkg, Dust, Panel, 94 Plts 12 379882 (005640-- ) Kit, Filter, Synthetic (Option) 12 375249 (005640-- ) Kit, Filter, Surface Load, 98 Plts (Option) 13 379555 (005640-- ) Plate, panel, Shaker 14 379890 (005640-- ) Solenoid Assy, Filter Shaker 15 26395--2 (005640-- ) Clamp, Cable 16 49697 (005640-- ) Screw, Pan, M04--0.7 X 10, Ss 57 81812 (005640-- ) Spring, Tension, Shaker 18 379708 (005640-- ) Bracket Wldt, Hopper 19 46236 (005640-- ) Clamp, Cable 110 02712 (005640--019999 ) Thermostat 111 82733 (005640-- ) Gasket 112 360943 (005640-- ) Screw, Pan, #10--14 X 0.75 213 379665 (005640--019999 ) Shaker Module, 12V 114 40607 (005640--019999 ) Fitting, Brass, Str 115 367679 (020000-- ) Switch, Thermostat 116 77320 (005640-- ) Hose, Vacuum 117 23498 (005640-- ) Clamp, Wormdrive 118 379823 (005640-- ) Clamp, Bridge, 4.0 119 379816 (005640-- ) Seal, Foam Rubber, Front 120 379830 (005640-- ) Sheet, Plastic, Backup 121 43560 (005640-- ) Clamp, Cable 122 361339 (005640-- ) Screw, Hex, Fmg, M06--1.0 X 16 Pltd 223 69234 (005640-- ) Clamp, Cable 224 379822 (005640-- ) Seal 425 49266 (005640-- ) Cable Tie 426 86330 (005640-- ) Duct, Vinyl 227 379829 (005640-- ) Washer, .344B 228 41178 (005640-- ) Washer, Fender, .25 229 07805 (005640-- ) Screw, Hex, M6 230 379849 (005640-- ) Restrictor Ring Kit 131 375202 (005640-- ) Seal, Ure, 0.38th, 0.75w 40.0l Adh 1

r1lLine

r1lText Box32 06945 Screw ...........................................................................133 32490 Washer .........................................................................1

STANDARD PARTS

6500D 330290 (9--01)2-76

Fig. 40 -- Hopper Lift Arms Group

2

3

5

6

7

8

9

10

1

1112

13

14

15

1617

18

19

20

21

23

23

10

13

14

12

8

4

22

10

10

5

STANDARD PARTS

2-776500D 330290 (9--01)

351750 -- IC, NA, JPFig. 40 -- Hopper Lift Arms Group

Ref.TennantPart No.


1 59825 (000000-- ) Arm Assy, Hopper w/label 1o 69908 (000000-- ) Pin Assy, Clevis, Hopper Lift 1Y 2 59866 (000000-- ) Bearing, Journal 1.25 Idx1.0Lg 1Y 3 59867 (000000-- ) Pin, Grooved 1Y 4 59861 (000000-- ) Ring, Retaining, Ext, 1.25 Dia 2

5 54079 (000000-- ) Washer,1.281B 1.75D .O8Cr Znc 46 55462 (000000-- ) Pin, Rh 17 55463 (000000-- ) Pin, Lh 18 39308 (000000-- ) Scr Soc M 8X1.25 25 29 74419 (000000-- ) Cylinder--Hyd (See Breakdowns) 110 59542 (000000-- ) Ring, Retaining, Intl, 2.00Dia 411 59380 (000000-- ) Pin--Grvd,1.00D 3.0L2/ 2.71Btwn 112 23788 (000000-- ) Ring,Retain,Ex,0.98Od,E--Ring 213 42120--1 (000000-- ) Bearing--Self Align 1.250 Bore 214 77097 (000000-- ) Ftg--Hyd E90 Jm04/Om04 215 16455 (000000-- ) Ftg--Hyd Rst Jm04/.047 116 59827 (000000-- ) Arm Assy, Safety w/label 117 58645 (000000-- ) Handle, Safety Arm 118 59842 (000000-- ) Pin, Arm, Safety 119 23788--1 (000000-- ) Ring, Retaining, Ext, .75 Dia 220 59849 (000000-- ) Nut, Retainer R/.312 Dia 121 58359 (000000-- ) Retaining Ring--External, 1.25D 122 16786 (000000-- ) Bumper, Safety Arm 123 70272 (000000-- ) Washer, 1.281B 1.75Od .31Hrznc 223 70271 (000000-- ) Washer, 1.281B 1.75Od .25Hrznc 2

STANDARD PARTS

6500D 330290 (9--01)2-78

Fig. 41 -- Side Brush Motor and Pivot Group

2 3

4

5

6

7

8

9

10

1

11

12

13

14

15

16

17

4

3

16

(000000--005639)

18

19

20

(Metal Hopper)

13

21

222324

STANDARD PARTS

2-796500D 330290 (9--01)

352728 -- 6500, NA, JPFig. 41 -- Side Brush Motor and Pivot Group

Ref.TennantPart No.


1 54050 (000000-- ) Pivot Assy, S Br 12 54660 (000000-- ) Pin, Clevis .75 Dia X 5.5 Lg 13 53965 (000000-- ) Arm Assy, Lift 24 51225 (000000-- ) Pin,Clevis,0.50 Dia.X 5.50 Lg 25 379557 (000000-- ) Bracket, Motor 16 379607 (000000-- ) Motor--Hyd Gear (See Breakdowns) 17 47508 (000000-- ) Ftg--Hyd Str Jm06/Om10 28 47504 (000000-- ) Ftg--Hyd E90 Jm06/Jf06 19 16082 (000000-- ) Guard, String, Brush Motor 110 379532 (000000-- ) Guard, Brush 111 379534 (000000-- ) Hub, Brush Adaptor 112 84581 (000000-- ) Pin Assy, Side Brush W/Clip 113 47745 (000000-- ) Sprng,Tens,1.12Odx.14Wire 6.3L 114 53466 (000000-- ) Clamp, Hose 215 34359 (000000-- ) Ftg--Hyd E45 Jm04/Om04 116 51538 (000000-- ) Pin,Clevis,0.50 Dia.X 5.00 Lg 217 75028 (000000-- ) Sleeve--Nyln #20 65.0L 118 379815 (005640-- ) Bracket, Spring, Sidebrush 119 49826 (005640-- ) Screw--Hexss M8x1.25 120 01685 (005640-- ) Washer Flt .31 Ss 121 02942 (000000-- ) Pin, Hair Cotter 122 39396 (000000-- ) Screw, Hex, .31--12 X 1.50, Fmg, [Ab] 523 46559 (000000-- ) Screw, Hex, .38--16x1.25, Nl 424 32492 (000000-- ) Washer, Flt, .38 Std 4

STANDARD PARTS

6500D 330290 (5--01)2-80

Fig. 42 -- Side Brush Lift Group

2

3

16

6

7

89

10

1

12

13

14

11

5

4

5

15

18

18

19

17

20

2121

22

STANDARD PARTS

2-816500D 330290 (5--01)

352726 -- 6500Fig. 42 -- Side Brush Lift Group

Ref.TennantPart No.


1 54934 (000000-- ) Cable, Lift, S Br 12 12267 (000000-- ) Yoke,End--Adjustable 13 59899 (000000-- ) Bracket, Side Brush 14 74391 (000000-- ) Pulley Assy -- Cable, 1.5 Dia 25 222460 (000000-- ) Spacer, Pulley 36 54400 (000000-- ) Angle, Cable Keeper 17 374573 (000000-- ) Bracket, S Br Lift 18 54848 (000000-- ) Knob, Adjusting 19 52296 (000000-- ) Washer, .405B .81D .06Nylon 110 56662 (000000-- ) Bracket 111 58872 (000000-- ) Panel, Support 112 56641 (000000-- ) Lever Wldt, S Br 113 54995 (000000-- ) Knob, Tapered 114 29584 (000000-- ) Pin,Clevis,0.37 Dia.X 2.00 Lg 115 29558 (000000-- ) Pin,Clevis,0.37 Dia.X 1.50 Lg 116 379684 (000000-- ) Pully Assembly 2.75 117 379686 (000000-- ) Angle, Cable Keeper 118 32716 (000000-- ) Nut--Hx Jam M10x1.5 Ss 319 09026 (000000-- ) Screw, Hex, M08 X 1.25 X 40, Ss 120 32491 (000000-- ) Washer, Flt, .31 Std 121 64153 (000000-- ) Washer, 0.34d 1.12d .11, Stl, Pl 222 08713 (000000-- ) Nut, Hex, Lock, M08 X 1.25,Nl, Ss 1

STANDARD PARTS

6500D 330290 (9--01)2-82

Fig. 43 -- Main Brush Lift Group (000000--019999)

2

3

4

5

6

7

8

9

10

1

11

12

13

4

4

5

99

15

16

14

14

STANDARD PARTS

2-836500D 330290 (9--01)

07055 -- 6500Fig. 43 -- Main Brush Lift Group (000000--019999)

Ref.TennantPart No.


1 12267 (000000--019999 ) Yoke,End--Adjustable 12 86240 (000000--019999 ) Pin Clevis .375 Dia X 1.13 Lg 13 54840 (000000--019999 ) Cable, Lift, M Br 14 74391 (000000--019999 ) Pulley Assy -- Cable, 1.5 Dia 35 54400 (000000--019999 ) Angle, Cable Keeper 36 54663 (000000--019999 ) Bearing, Self Aligning 17 54118 (000000--019999 ) Lever Wldt, M Br 18 69903 (000000--019999 ) Bellows Assy, Brush Lift 19 222460 (000000--019999 ) Spacer, Pulley 310 56662 (000000--019999 ) Bracket 111 54995 (000000--019999 ) Knob, Tapered 112 54848 (000000--019999 ) Knob, Adjusting 113 52296 (000000--019999 ) Washer, .405B .81D .06Nylon 114 32716 (000000--019999 ) Nut--Hx Jam M10x1.5 Ss 215 16944 (000000--019999 ) Scr Hxfmgm 4x0.7 Pltd 816 09740 (000000--019999 ) Scr Hexss M8x1.25 1

STANDARD PARTS

6500D 330290 (9--02)2-84

Fig. 44 -- Main Brush Lift Group (020000-- )

1

3

14

10

12

11

13

42

5

15

18

17

19

16

9

8

20

6

7

STANDARD PARTS

2-856500D 330290 (9--02)

353644 -- 6500Fig. 44 -- Main Brush Lift Group (020000-- )

Ref.TennantPart No.


1 12267 (020000-- ) Clevis, Adj, 0.38pin, M10x1.5 12 32716 (020000-- ) Nut, Hex, Jam, M10 X 1.5, Ss 13 86240 (020000-- ) Pin, Clevis, 0.38 D X 1.13l 14 08179 (020000-- ) Pin, Cotter, .094 X 1.00 15 383194 (020000-- ) Cable, Lift, Main Brush 16 383265 (020000--020250 ) Kit, Ci, Rnd Brush Lift Handle, [6500] 17 360467 (020000--020250 ) Grip, Vinyl 18 383258 (020251-- Lever Wldt, Brush Lift 19 54995 (020251-- Knob, Tpr, 1.12D 3.86L M10X1.5 Plstc 110 383200 (020000-- ) Plate Wldt, Stop, [6500] 111 383201 (020000-- ) Plate Wldt, Brush, Adj, [6500] 112 383205 (020000-- ) Knob, Star, 2.2od 8ear 1.1l M10x1.5 Pls 113 09740 (020000-- ) Screw, Hex, M08 X 1.25 X 20, Ss 114 08709 (020000-- ) Nut, Hex, Lock, M08 X 1.25,Nl 115 32491 (020000-- ) Washer, Flt, .31 Std 116 09028 (020000-- ) Screw, Hex, M10x1.5x25, Ss 117 07450 (020000-- ) Bearing, Thrust, 0.66B 1.25D 0.06W 118 363087 (020000-- ) Bushing, Flng, 0.44b 1.25d 0.25l 119 16944 (020000-- ) Screw, Hex, M04 X 0.7 X 10, Fmg 420 383263 (020251-- ) Panel Assy, Main Brush W/Label 1

STANDARD PARTS

6500D 330290 (9--01)2-86

Fig. 45 -- Main Brush Drive Group (000000--019999)

2

3

4

5

6

7

8

9

10

1

11

12

13

14

15

16

1718

19

20

21

22

2324

25

4

5

4

43

6

26

2728

29

r1lLine

r1lLine

r1lLine

r1lText Box06975

r1lText Box36328

r1lText Box08711

STANDARD PARTS

2-876500D 330290 (9--01)

07054 -- 6500, NAFig. 45 -- Main Brush Drive Group (000000--019999)

Ref.TennantPart No.


1 54693 (000000--019999 ) Shaft Wldt, Brush 12 54199 (000000--019999 ) Plate, Mtg, Main Brush Shaft 13 51448 (000000--019999 ) Bearing&Clr ,1.25B 2.44D 1.41W 24 51449 (000000--019999 ) Flange,Brg,3 Hole 45 51317 (000000--019999 ) Pin,Roll,.38Odx2.00L,.375/.382 26 54680 (000000--019999 ) Hub Assy, Brush Arm 27 13156 (000000--019999 ) Arm Wldt, Brush, Lh 18 74468 (000000--005544 ) Motor--Hyd Gear (See Breakdowns) 18 379608 (005545--019999 ) Motor--Hyd Gear (See Breakdowns) 19 44869 (000000--019999 ) Ftg--Hyd Str Jm08/Om08 110 52402 (000000--019999 ) Ftg--Hyd Str Jm06/Om08 111 87631 (000000--019999 ) Plug Weld, Brush Drive, Sweep 112 51715 (000000--019999 ) Clamp, Hose 113 55586 (000000--019999 ) Ftg--Hyd Str Jm04/Om04 114 53985 (000000--019999 ) Plug, Thread 1/2--13 115 54659 (000000--019999 ) Arm Wldt, Idler, W/Brush 116 55779 (000000--019999 ) Plug Wldt, Idler 117 24899 (000000--019999 ) Bearing--Ball,1.38B 2.83D 0.67W 118 30252 (000000--019999 ) Strip, Retainer, Bearing 119 30253 (000000--019999 ) Plate, Seal 120 30251 (000000--019999 ) Shaft, Idler 121 30255 (000000--019999 ) Plug, Tube 122 51564 (000000--019999 ) Washer, .531B 1.75D .12Cr.Znc 123 54204 (000000--019999 ) Plate, Mtg, Latch 124 54878 (000000--019999 ) Latch 125 82831 (000000--019999 ) Sleeve--Nyln #24 35.0L 126 56228 (000000--019999 ) Sleeve, .254B .31D .52 Plastc 127 01684 (000000--019999 ) Washer Flt .25 Ss 128 07805 (000000--019999 ) Scr Hexss M12x1.75 129 15678 (000000--019999 ) Scr Hexss M6x1.0 2

r1lLine

r1lText Box09120 Scr, Flt M5 .................................................................6

STANDARD PARTS

6500D 330290 (9--02)2-88

Fig. 46 -- Main Brush Drive Group (020000-- )

2

5

8

1

13

14

15

16

17

18

11

19

2021

22

23

24

25

12

26

4

33

27

2829

5

1012

9

7

4

6

30

30

31

3232

3

3334

r1lLine

r1lLine

r1lLine

r1lText Box08711

r1lText Box36328

r1lText Box06975

STANDARD PARTS

2-896500D 330290 (9--01)

07054 -- 6500, NA, JPFig. 46 -- Main Brush Drive Group (020000-- )

Ref.TennantPart No.


1 383137 (020000-- ) Tube Wldt 12 383142 (020000-- ) Bracket, Mtg, Rh 13 383143 (020000-- ) Bracket, Mtg, Lh 14 25887 (020000-- ) Bearing, W/ Collar, 0.75b 1.85d 1.06w 25 35973 (020000-- ) Flange, Brg, 1.9id 2h 46 383139 (020000-- ) Arm Wldt, Brush, Lh 17 383210 (020000-- ) Arm, Brush, W/ Label, [6500] 18 360110 (020000-- ) Stud, Special 19 52508 (020000-- ) Washer 210 360109 (020000-- ) Bar, Hex, Stl, 0.75 1.6l .50h Thru 111 11631 (020000-- ) Pin, Roll, .250 D X 3.50l, .250/.256 112 360492 (020000-- ) Cap 213 379608 (020000-- ) Motor, Hyd, Gear (See Breakdown) 114 44869 (020000-- ) Fitting, Hyd, Str, Jm08/Om08 115 52402 (020000-- ) Fitting, Hyd, Str, Jm06/Om08 116 87631 (020000-- ) Plug Wldt, Drive, Brush, Sweep 117 51715 (020000-- ) Bracket, U, .18 2.8 0.9 1.0l 1/0.3h 118 55586 (020000-- ) Fitting, Hyd, Str, Jm04/Om04 119 55779 (020000-- ) Plug Wldt, Idler, Brush 120 24899 (020000-- ) Ring, Ball, 1.38b 2.83d 0.67w 121 30252 (020000-- ) Strip, Retainer 122 30253 (020000-- ) Plate, Seal 123 30251 (020000-- ) Shaft 124 30255 (020000-- ) Plug 125 51564 (020000-- ) Washer, 0.53b 1.75d .12, Stl, Pl 126 82831 (020000-- ) Sleeve, Nyl, #27 35.0l 127 56228 (020000-- ) Tube, Plstc, 0.31od 0.25id 00.5l, Blk 128 01684 (020000-- ) Washer, Flt, .25 Ss 129 07805 (020000-- ) Screw, Hex, M06 X 1.0 X 35, Ss 130 39395 (020000-- ) Screw, Hex, M10x1.5x25, Ss 231 32987 (020000-- ) Nut, Hex, Lock, .75--10Nl 232 09740 (020000-- ) Screw, Hex, M08x1.25x20, Ss 1033 08709 (020000-- ) Nut, Hex, lock, M08x1.25, Nl 1034 32491 (020000-- ) Washer, Flt, .31 Std 3

STANDARD PARTS

6500D 330290 (5--98)2-90

Fig. 47 -- Vacuum Fan Group

2

34

5

6

78

9

10

1

11

12

13

14

15

15

1716

Technical PublicationsNoteVacuum Fan Impeller Mounting Hardware31241 Nut (1)32485 Washer (1) - Not illustrated

Technical PublicationsNoteHydraulic Motor Mounting Hardware39534 Flat Screw (4)32981 Nut (4)

STANDARD PARTS

2-916500D 330290 (5--01)

07053 -- ICFig. 47 -- Vacuum Fan Group

Ref.TennantPart No.


o 1 72133 (000000-- ) Fan Wldt, Vac w/gaskets 1Y 2 59734 (000000-- ) Seal, Fan, Vac, Outlet 1Y 3 59967 (000000-- ) Seal, Fan, Vac, Motor 1

4 54275A (000000-- ) Bracket, Mounting Motor 15 74454 (000000-- ) Impeller 9.00 Dia. 1

o 6 59656 (000000-- ) Fan Wldt, Vac, Inlet w/gasket 1Y 7 59735 (000000-- ) Seal, Fan, Vac, Inlet 1

8 54274 (000000-- ) Isolator--Vibration,60 Lb.Ratng 49 58540 (000000-- ) Fan Wldt, Vac, Transition 110 378972 (000000-- ) Seal, Fan, Vac, Transition 111 59649 (000000-- ) Isolator, Vibration .37 Dia 112 374504 (000000-- ) Hinge Wldt, Engine Cover, Rh 113 374505 (000000-- ) Hinge Wldt, Engine Cover, Lh 114 69990 (000000-- ) Insulation, Acoustic, Engine Cover 115 66184 (000000-- ) Seal, Acoustic, Engine Cover 216 34323 (000000-- ) Scr--Hex .25--20x0.75 Nylonloc 417 41178 (000000-- ) Washer Flt .25 Fender Pltd 4

STANDARD PARTS

6500D 330290 (6--99)2-92

Fig. 48 -- Vacuum Fan Motor and Fittings Group

1

2

3

4

5

8

9

7

6

STANDARD PARTS

2-936500D 330290 (6--99)

351756 -- 6500Fig. 48 -- Vacuum Fan Motor and Fittings Group

Ref.TennantPart No.


1 45482 (000000-- ) Ftg--Hyd Tee Jm08Jmjf 12 44868 (000000-- ) Ftg--Hyd E90 Jm08/Om08 13 31599 (000000-- ) Ftg--Hyd Tee Jm04Omjm 14 57979 (000000-- ) Ftg--Hyd Str Jm04/Jf08 15 53485 (000000-- ) Motor--Hyd Gear (See Breakdowns) 16 35033 (000000-- ) Ftg--Hyd E90 Jm12/Jf12 17 40514 (000000-- ) Ftg--Hyd Tee Jm12Jmjf 18 59975 (000000-- ) Ftg--Hyd Str Jm10/Jf12 19 62390 (000000-- ) Ftg--Hyd Str Jm12/Om08 1

STANDARD PARTS

6500D 330290 (5--01)2-94

Fig. 49 -- Hydraulic Schematic (Metal Hopper)

1 2 3 4 5

STANDARD PARTS

2-956500D 330290 (5--01)

Fig. 49 -- Hydraulic Schematic (Metal Hopper)

1 2 3 4 5

351757 -- 6500, NA

STANDARD PARTS

6500D 330290 (5--01)2-96

Fig. 50 -- Hydraulic Schematic (Plastic Hopper)

1 2 3 4 5

STANDARD PARTS

2-976500D 330290 (5--01)

Fig. 50 -- Hydraulic Schematic (Plastic Hopper)

1 2 3 4 5

351757 -- 6500

STANDARD PARTS

6500D 330290 (5--01)2-98

Fig. 51 -- Hydraulic Hose Group (Metal Hopper)

E C ABDF

IN

OUT

BYD

R P

L T

IN

OUT

25

13

1

2

34

56

7

8

9

10

1112

14

15

16

17

18

19

2021

22

23

2426

15

10

14

STANDARD PARTS

2-996500D 330290 (3--00)

351760 -- 6500, NAFig. 51 -- Hydraulic Hose Group (Metal Hopper)

Ref.TennantPart No.


1 59568 (000000--005639 ) Hose--Hyd Low08 Jf/J4 12 59560 (000000--005639 ) Hose--Hyd Med06 Jf/J9 13 02469 (000000--005639 ) Hose--Hyd Med06 Jf/J9 24 55691 (000000--005639 ) Hose--Hyd Med04 Jf/Jf 15 59565 (000000--005639 ) Hose--Hyd Low04 Jf/J4 16 59564 (000000--005639 ) Hose--Hyd Low04 Jf/J4 17 31719 (000000--005639 ) Hose--Hyd Med12 Jf/J9 18 59563 (000000--005639 ) Hose--Hyd Med10 Jf/J9 19 35488 (000000--005639 ) Hose--Hyd Low12 Jf/Jf 110 62100 (000000--005639 ) Hose--Hyd Med06 Jf/Jf 211 59561 (000000--005639 ) Hose--Hyd Med06 Jf/J9 112 62337 (000000--005639 ) Hose--Hyd Med06 Jf/Jf 113 19637 (000000--005639 ) Hose--Hyd Med08 Jf/J9 114 57173 (000000--005639 ) Hose--Hyd Med04 Jf/J4 215 19644 (000000--005639 ) Hose--Hyd Med04 Jf/J4 216 59581 (000000--005639 ) Hose--Hyd Med04 Jf/J4 117 59582 (000000--005639 ) Hose--Hyd Med04 Jf/J9 118 59574 (000000--005639 ) Hose--Hyd Med10 Jf/J4 119 59575 (000000--005639 ) Hose--Hyd Med10 Jf/Jl9 120 59573 (000000--005639 ) Hose--Hyd Low06 Jf/J4 121 59572 (000000--005639 ) Hose--Hyd Suc20 Jf/J4 122 59576 (000000--005639 ) Hose--Hyd Med08 Jf/Jl9 123 59579 (000000--005639 ) Hose--Hyd Med04 Jf/J9 124 59106 (000000--005639 ) Hose--Hyd Med12 Jf/Jl9 125 57962 (000000--005639 ) Hose--Hyd Med04 Jf/J9 126 59585 (000000--005639 ) Hose--Hyd Med04 Jf/J4 1

STANDARD PARTS

6500D 330290 (5--01)2-100

Fig. 52 -- Hydraulic Hose Group (Plastic Hopper)

E C ABDF

IN

OUT

BYD

R P

L T

IN

OUT

1

2

34

56

7

8

9

10

11

12

13

15

16

17

18

19

2021

22

23

24

10

14

STANDARD PARTS

2-1016500D 330290 (3--00)

351760 -- 6500Fig. 52 -- Hydraulic Hose Group (Plastic Hopper)

Ref.TennantPart No.


1 59568 (005640-- ) Hose--Hyd Low08 Jf/J4 12 59560 (005640-- ) Hose--Hyd Med06 Jf/

6500D NA Parts Manual...Y 59685 (000000--005639 ) Seal, Door, Dump 1 Y 59686 (000000--005639 )...

Documents

Transcript of 6500D NA Parts Manual...Y 59685 (000000--005639 ) Seal, Door, Dump 1 Y 59686 (000000--005639 )...