5r55_new Dtr Sensor ( Digital Range Sensor)

FORD MOTOR COMPANYNEW DIGITAL TRANSMISSION RANGE

(DTR) SENSOR FOR SOME 1997 AND LATER MODEL VEHICLES

CHANGE:

REASON:

Beginning at the start of production for 1997, some vehicles will be equipped with a new Digital Transmission Range (DTR) sensor, and externally looks identical to the previous Manual Lever Position Sensor (MLPS ), with the exception of 12 pin locations in the connector of the DTR. Refer to Figure 1.Internally however, the new Digital Transmission Range (DTR) sensor operates totally different than the previous sensor. The new DTR sensor completes the start circuit in Park and Neutral, the backup lamp circuit in Reverse, and the neutral sense circuit (4WD Only) when in Neutral. The new DTR sensor also opens/closes a set of four different switches that are monitored by the Powertrain Control Module (PCM) to determine the position of the transmission manual lever.

Increased accuracy of information to the PCM, and increased durability of the sensor.

PARTS AFFECTED:

INTERCHANGEABILITY:

SPECIAL NOTES:

DTR SENSOR - Replaces the previous manual lever position sensor and is identified by the new basic part number which is -7F293-, as shown in Figure 1. The prefix and suffix will be different depending on the vehicle model and transmission type.

The new design Digital Transmission Range (DTR) sensor will not back service any previous model vehicles built before 1997, nor any1997or later model vehicles that are equipped with the manual lever position sensor.Manual Lever Position Sensor (MLPS) = basic part number -7A247- (Stamped on Part)Digital Transmission Range Sensor (DTR) = basic part number -7F293- (Stamped on Part).

In Figure 1 we have provided you with pin number identification for both the transmission range sensor and the vehicle harness connector.In Figure 2 we have provided a chart that will give you the open/closed state of each internal switch, dependent on selector position, and notice that three positions read a 270W resistor that is also internal. Also in Figure 2 we have included a chart with wire colors, which is for the 1997 Ranger.In Figure 3 we have provided you with a schematic of the Digital Transmission Range sensor in each of the six selector positions for those of you that want to follow each circuit.

Refer to following Page for Diagnostic Procedures.

Technical Service Information

AUTOMATIC TRANSMISSION SERVICE GROUP

Copyright © 2001 ATSG

02-14 of 22

BACKBACK

TESTING PROCEDURE FOR THE 1997 AND LATER DESIGN LEVELDIGITAL TRANSMISSION RANGE SENSOR (DTR)

NOTE: All testing that we have provided for you is done with a DVOM, set to the ohms position, and all tests are performed with the ignition switch in the "OFF" position.

(1) Testing the transmission range 3A switch, and the 270W internal resistor is done across pins 2 and 3 of the DTR sensor, and must be checked in each selector position to determine the switch and resistor integrity. Refer to Figure 4.

(2) Testing the transmission range 1 switch is done across pins 2 and 4 of the DTR sensor, and must be checked in each selector position to determine switch integrity. Refer to Figure 5.

(3)

(4)

(5)

(6)

Testing the transmission range 2 switch is done across pins 2 and 5 of the DTR sensor, and must be checked in each selector position to determine switch integrity. Refer to Figure 6.

Testing the transmission range 4 switch is done across pins 2 and 6 of the DTR sensor, and must be checked in each selector position to determine switch integrity. Refer to Figure 7.

Testing the reverse lamp circuit is done across pins 9 and 11 of the DTR sensor, and must be checked in each selector position to determine switch integrity. Refer to Figure 8.

Testing the neutral start circuit is done across pins 10 and 12 of the DTR sensor, and must be checked in each selector position to determine switch integrity. Refer to Figure 9.

In Figure 10 we have provided a chart that is based on data for the DTR that is seen when using the Snap-On Scanner. A brief description of voltage values has been provided as an aid in Digital Transmission Range sensor diagnosis.

Refer to Figure 11 for an Index of charts that will provide you with pin identification and wire color information for DTR equipped vehicles up through model year 2000.




02-14 of 22

BACKBACK

12 11 10 9 8

23456 1

7

View looking into DTR Sensorharness connector-terminal side

1 7

82

93

104

115

126

View looking into DTR Sensor

Figure 1

Ford

F7TP

-7F2

93-A

A

NEUTRAL LC

Ford Ford

Identification




02-14 of 22

BACKBACK

P R N 2 1TERMINALS

2 AND 3 CLOSED

CLOSED CLOSED CLOSED

CLOSED

CLOSED

CLOSED

CLOSEDCLOSED

CLOSED

CLOSED

CLOSED

OPEN

OPEN

OPEN

OPEN OPEN

OPEN OPEN

OPEN

OPEN

OPEN

OPEN

OPEN

OPEN

OPENOPEN

OPEN

OPEN

OPEN

CLOSED

CLOSED

CLOSED

2 AND 4

2 AND 5

2 AND 6

9 AND 11

10 AND 12

D

269.5W269.5W269.5W

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W

9 11 12 10 4 5 6 32

PP

L/O

RG

BL

K/P

NK

PIN

K

RE

D/L

TB

YE

L/B

LK

LT

B/B

LK

GR

Y/R

ED

WH

T/B

LK

LT

B/Y

EL

DIGITAL TRANSMISSION RANGE SENSOR

NOTE: Colors listed below are for 1997 Ranger with 5R55E.

Figure 2




02-14 of 22

BACKBACK

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W9 11 12 10 4 5 6 32

PARK POSITION

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W

9 11 12 10 4 5 6 32

REVERSE POSITION

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W

9 11 12 10 4 5 6 32

NEUTRAL POSITION

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W

9 11 12 10 4 5 6 32

OVERDRIVE POSITION

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W

9 11 12 10 4 5 6 32

"2" POSITION

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D

P 1

2R

N D 270 W

9 11 12 10 4 5 6 32

"1" POSITION

Figure 3



02-14 of 22

BACKBACK

WW

OFF

RPM

RPMCOMmAA

V

V

mVWW

WW

VmAA

mAA

0.0

CLOSED CLOSED CLOSED OPEN OPEN OPEN2 AND 4

P R N 2 1TERMINALS D


1

789101112

23456

WW

OFF

RPM

RPMCOMmAA

V

V

mVWW

WW

VmAA

mAA

0.0

CLOSEDCLOSED OPEN OPENOPENCLOSED2 AND 5



1

789101112

23456

Figure 4

Figure 5

Figure 6

WW

OFF

RPM

RPMCOMmAA

V

V

mVWW

WW

VmAA

mAA

0.0

P R N 2 1TERMINALS

2 AND 3 CLOSED CLOSED CLOSED

D


1

789101112

23456

269.5W269.5W269.5W




02-14 of 22

BACKBACK

WW

OFF

RPM

RPMCOMmAA

V

V

mVWW

WW

VmAA

mAA

0.0

CLOSEDOPEN OPEN OPENOPENCLOSED10 AND 12



1

789101112

23456

WW

OFF

RPM

RPMCOMmAA

V

V

mVWW

WW

VmAA

mAA

0.0

CLOSEDOPEN OPEN OPEN OPENOPEN9 AND 11



1

789101112

23456

WW

OFF

RPM

RPMCOMmAA

V

V

mVWW

WW

VmAA

mAA

0.0

CLOSEDCLOSEDOPEN OPENOPENCLOSED2 AND 6



1

789101112

23456

Figure 7

Figure 8

Figure 9




02-14 of 22

BACKBACK


Figure 10

White/Red

White

White/Blue

White/Green

PCM "Center"ConnectorNo. 175B

Volt

age

from

Fus

e 20

1 in

Cent

ral J

unct

ion

Box

PO

WER

TRAI

N C

ON

TRO

L M

OD

ULE

TR1

TR2

TR3A

TR4

1

2

3

4

5

7

9

10

12

13

17

18

21

22

Dig

ital

Tra

nsm

issi

on R

ange

(D

TR)

Sens

or

StarterRelay

White/Red

White

White/Blue

Brown/Yellow

White/Green

Gray

Not

Use

dN

ot U

sed

Not

Use

dN

ot U

sed

Located in AuxilliaryJunction Box (Underhood)

Gra

y/O

ran

ge

12

DN

RP

3/

4

12

DN

RP

3/

4

12

DN

RP

3/

4

12

DN

RP

3/

4

12

DN

RP

3/

4

12

DN

RP

3/

4

12

DN

RP

3/

4

45

36

89

7

12

1011

2

DIGITAL TRANSMISSION RANGE (DTR) SENSOR DIAGNOSIS

1. TR_V is the voltage at PCM connector 175B, pin 9 (TR3A Circuit) to Signal Return. 2. TR_D: 1 = Open DTR Switch 0 = Closed DTR Switch

4. Breakout Box readings are taken from PCM signal pins for TR1, TR2, TR3A, TR4 to Signal Return. Voltages for TR1, TR2, TR4: 0 = 0.0 Volts (Shorted to Ground) 1 = 9.0 to 14.0 Volts (Open Circuit) Voltages for TR3A: 0 = 0.0 Volts (Circuit Shorted to Ground) 1 = 1.3 to 5.0 Volts (Open Circuit) 1.8 to 5.0 Volts is an invalid reading and is usually an open in wires or bad resistor in DTR sensor.

SELECTOR POSITION PID:TRPID:TR_D

TR4 TR3A TR2 TR1 TR3A (175B pin 9 to sigrtn)

PID:TR_V

PARK P/N 0

0

1

1

1

1

1

1 1

1

11

1

1

0

0

00

0

0

0

0 0.0 Volts

0.0 Volts

0.0 Volts

1.3 to 1.8 Volts

1.3 to 1.8 Volts

1.3 to 1.8 Volts

0

0

REV

NTRL

OD*

MAN 2**

MAN 1

REVERSE

NEUTRAL

OVERDRIVE

MANUAL 2

MANUAL 1* Will read "Drive" if OD is canceled.

** MAN 2 = Drive for applications without OD cancel feature.

Snap-OnScanner Data

Snap-OnScanner Data

NOTE: Example shown below is for 2000 Lincoln LS



02-14 of 22

BACKBACK

1997 Aerostar 3.0-4.0 See Figure 121997 Expedition 4.6-5.4 See Figure 121997 Pickup 5.4 See Figure 121997 Explorer 4.0 SOHC See Figure 121997 Explorer 5.0 See Figure 121997 Mountaineer 5.0 See Figure 121997 Ranger 2.3-3.0-4.0 See Figure 121997 Lincoln Mark Eight See Figure 131997 F150-250 Light Duty 4.2 From 6-24-96 See Figure 131997 F150-250 Light Duty 4.6 From 6-24-96 See Figure 131997 Econoline Van 4.2-4.6 See Figure 131997 Econoline Van 5.4-6.8 See Figure 131997 Econoline Van 7.3 Diesel See Figure 13

1998 Lincoln Continental See Figure 141998 Crown Victoria See Figure 141998 Grand Marquis See Figure 141998 Expedition 5.4 See Figure 141998 Navigator 5.4 See Figure 141998 F150-250 Light Duty 5.4 See Figure 141998 Explorer/Mountaineer See Figure 141998 Ranger 2.5, 3.0, 4.0 See Figure 141998 Expedition 4.6 See Figure 151998 F150-250 Light duty 4.2-4.6 See Figure 151998 Lincoln Mark Eight See Figure 151998 Mustang 3.8-4.6 SOHC See Figure 151998 Sable/Taurus 3.0 12 Valve-3.0 Flex Fuel See Figure 151998 Lincoln Town Car See Figure 161998 Econoline Van 4.2-4.6-5.4 See Figure 161998 Econoline Van 7.3 Diesel See Figure 16

1999 Lincoln Continental See Figure 161999 Crown Victoria/Grand Marquis See Figure 171999 Econoline Van 4.2-4.6 See Figure 171999 Econoline 250-350 Super Duty 5.4-6.8 See Figure 171999 Econoline 250-350 Super Duty 7.3 Diesel See Figure 171999 Expedition 4.6 5.4 See Figure 181999 Navigator 5.4 See Figure 181999 Explorer 4.9 OHV See Figure 181999 Mountaineer 4.0 SOHC See Figure 181999 Explorer 5.0 See Figure 181999 Mountaineer 5.0 See Figure 181999 Mustang 3.8-4.6 SOHC See Figure 181999 F150-250 Light Duty 4.2-4.6-5.4 See Figure 191999 F250-350 Super Duty 5.4-6.8 See Figure 191999 F250-350 Super Duty 7.3 Diesel See Figure 191999 Ranger 2.5-3.0-4.0 See Figure 191999 Sable/Taurus 3.0 12 Valve, 3.0 flex Fuel See Figure 191999 Lincoln Town Car See Figure 201999 Windstar 3.0-3.8 See Figure 20

2000 Lincoln Continental See Figure 202000 Crown Victoria/Grand Marquis See Figure 202000 Econoline 150-250 4.2-4.6 See Figure 212000 Econoline 5.4 Super Duty See Figure 212000 Econoline 6.8 Super Duty See Figure 212000 Econoline 7.3 Diesel See Figure 212000 Excursion 5.4, 6.8 Gas See Figure 212000 Excursion 7.3 Diesel See Figure 222000 F250-350 Super Duty Gas See Figure 212000 F150-250 Light Duty See Figure 222000 F250-350 Super Duty 7.3 Diesel See Figure 222000 Expedition 4.6-5.4 See Figure 222000 Navigator 5.4 See Figure 222000 Explorer 4.0, 4.0 SOHC-5.0 See Figure 222000 Mountaineer 4.0 SOHC-5.0 See Figure 222000 Lincoln LS 3.0 See Figure 232000 Mustang 3.8-4.6 SOHC See Figure 232000 Ranger 2.5-3.0-4.0 See Figure 232000 Sable/Taurus See Figure 232000 Lincoln Town Car See Figure 242000 Windstar See Figure 24

2001 Ranger 2.5-3.0-4.0 SOHC See Figure 24

FORD MOTOR COMPANYDIGITAL RANGE SENSOR (DTR) WIRING CHART

TABLE OF CONTENTS

Figure 11




02-14 of 22

BACKBACK

TERM.NO.

TERM.NO.

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

Purple-Orange

Red-Lt.Blue

Black-Pink

Pink

91

64

3

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4

Fuse 5 15a. Hot in Run

To Starter Relay

To Reverse Lights

From Ign. Switch-Hot in Start

1997 Aerostar 3.0-4.0

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Red-White

Black

GEM 22 4WD

Lt. Blue-Pink

Dk.Blue-Orange Fuse 21 15a. Hot in Start

Black-Pink

Tan-Red

1997 Expedition 4.6-5.4 Pickup 5.4

TERMINALNUMBER

TERMINALNUMBER

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4

To Starter Relay

To Reverse Lights

GEM 22

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1

Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

Red-White

Black

Purple-Orange

Red-Lt.Blue

Black-Pink

Pink

91

64

49

50

3

4WD

Fuse 24 10a. Hot in Start

Fuse 28 10a.Hot in Run

1997 Explorer 4.0 SOHC

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4

To Starter Relay

To Reverse Lights

GEM 22

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1

Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

Red-White

Black

Purple-Orange

Red-Lt.Blue

Black-Pink

Pink

91

64

49

50

3

4WD


Fuse 26 10a.Hot in Run

1997 Explorer-Mountaineer 5.0Ranger 2.3-3.0-4.0

12 11 10 9 8

23456 1

7


1 7

82

93

104

115

126


Figure 12




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Red-Black

Red-Lt.Blue Fuse 6 10a. Hot in Start

Black-Pink

White-Pink

1997 Lincoln Mark Eight

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Red-Black


Black-Pink

Tan-Red

4WDGEM 22

GroundBlack

Red-White

TERMINALNUMBER

1997 F150-250 Light Duty4.2 From 6-24-964.6 From 6-24-96

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

Grey-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Red-Lt.Blue


Black-Pink

White-Pink

1997 Econoline Van Gas 4.2-4.6WIRE

COLORPCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Orange-Black

White-Pink

Grey-Black

91

64

17 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Red-Lt.Blue


Black-Pink

White-Pink

1997 Econoline Van Gas 5.4-6.8 and7.3 Diesel

12 11 10 9 8

23456 1

7


1 7

82

93

104

115

126


Figure 13




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Red-Black

White-Orange Fuse 23 10a. Hot in Start

Black-Pink

Tan-Red

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Red-Lt.Blue

From Ign. Swit, Hot in Start

Violet-Black

White-Pink

1998 Lincoln Continental 1998 Crown Victoria/Grand Marquis

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Pink

Dk.Blue-Pink Fuse 21 15a. Hot in Start

Black-Pink

Tan-Red

GEM 22 4WD

Black

Red-White

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Tan-Red

Fuse 24 7.5a. Hot in Start

Black-Pink

White-Pink or Pink

GEM 22 4WD

Black

Red-White

1998 Expedition-Navigator F150-250 Light Duty 5.4

1998 Explorer-MountaineerRanger 2.5-3.0-4.0

12 11 10 9 8

23456 1

7


1 7

82

93

104

115

126


Figure 14




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Pink


Black-Pink

Tan-Red

GEM 22 4WD

Black

Red-White

1998 Expedition 4.61998 F150-250 Light Duty 4.2-4.6

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Red-Black


Black-Pink

White-Pink

1998 Lincoln Mark Eight

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Red-Lt.Blue From Ign.Swit, Hot in Start

Black-Pink

White-Pink

1998 Mustang 3.8-4.6 SOHC

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Red-LtBlue Fuse 7 10a. Hot in Start

Black-Pink

White-Pink

1998 Sable/Taurus 3.0 12Valve-3.0 Flex Fuel

12 11 10 9 8

23456 1

7


1 7

82

93

104

115

126


Figure 15




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Black

White-Pink


Black-Pink

Brown-Pink

1998 Lincoln Town CarTERMINAL

NUMBER

TERMINALNUMBER

WIRECOLOR

WIRECOLOR

PCM PINNUMBER

PCM PINNUMBER

CIRCUITFUNCTION

CIRCUITFUNCTION

2

2

3

3

4

4

5

5

6

6

7

7

8

8

9

9

10

10

11

11

12

12

1

1

Grey-Red

Grey-Red

Lt.Blue-Yellow

Lt.Blue-Yellow

White-Yellow

White-Yellow

Dk.Blue-White

Dk.Blue-White

Dk.Green-Yellow

Dk.Green-Yellow

91

91

64

64

3 or 34

17

49

49

50

50

Ground

Ground

TR3A 5 volts to DTR

TR3A 5 volts to DTR

TR1

TR1

TR2

TR2

TR4

TR4



To Starter Relay

To Starter Relay

To Reverse Lights

To Reverse Lights

Purple-Orange

Purple-Orange

Red-Lt.Blue

Red-Lt.Blue



Black-Pink

Black-Pink

White-Pink

White-Pink

1998 Econoline Van Gas4.2, 4.6, 5.4, 6.8

1998 Econoline Van 7.3 DieselTERMINAL

NUMBERWIRE

COLORPCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Orange-Black

Black-White

Dk.Green-Orange

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4



To Starter Relay

To Reverse Lights

Red-Black

Tan-Red

Black-Pink

White-Orange

1999 Lincoln Continental

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 16




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Red-Lt.Blue


Black-Pink

White-Pink

1999 Crown Victoria-Grand Marquis

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

Lt.Green-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Ppl-Org orWht-Ppl

Red-Lt.Blue


Black-Pink

Tan-Red

1999 Econoline Van Gas 4.2-4.6

TERMINALNUMBER

TERMINALNUMBER

WIRECOLOR

WIRECOLOR

PCM PINNUMBER

PCM PINNUMBER

CIRCUITFUNCTION

CIRCUITFUNCTION

2 2

3 3

4 4

5 5

6 6

7 7

8 8

9 9

10 10

11 11

12 12

1 1Grey-Red Grey-Red

Lt.Blue-Yellow Lt.Blue-Yellow

Yellow-Black Yellow-Black

Lt.Blue-Black Lt.Blue-Black

DkGrn-Yel or LtGrn-Red Lt.Blue-Red

91 91

64 64

3 or 34 17

49 49

50 50

Ground Ground

TR3A 5 volts to DTR TR3A 5 volts to DTR

TR1 TR1

TR2 TR2

TR4 TR4

Fuse 12 15a. Hot in Run Fuse 12 15a. Hot in Run

To Starter Relay To Starter Relay

To Reverse Lights To Reverse Lights

Wht-Ppl or Ppl-Org Wht-Ppl or Ppl-Org

Red-Lt.Blue Red-Lt.Blue

Fuse 34 10a. Hot in Start Fuse 34 10a. Hot in Start

Black-Pink Black-Pink

Tan-Red Tan-Red

1999 Econoline Van 250-350Super Duty 5.4, 6.8

1999 Econoline Van 250-350Super Duty 7.3 Diesel

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 17




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


Fuse 21 15a.Hot in Start

To Reverse Lights

Lt.Blue-Pink

Dk.Blue-Orange

To Starter Relay

Black-Pink

Tan-Red

GEM 22 4WD

Black

Red-White

1999 Expedition 4.6-5.41999 Navigator 5.4

TERMINALNUMBER

TERMINALNUMBER

WIRECOLOR

WIRECOLOR

PCM PINNUMBER

PCM PINNUMBER

CIRCUITFUNCTION

CIRCUITFUNCTION

2

2

3

3

4

4

5

5

6

6

7

7

8

8

9

9

10

10

11

11

12

12

1

1

Grey-Red

Grey-Red

Lt.Blue-Yellow

Lt.Blue-Yellow

Yellow-Black

Yellow-Black

Lt.Blue-Black

Lt.Blue-Black

White-Black

White-Black

91

91

64

64

3 or 34

3 or 34

49

49

50

50

Ground

Ground

Ground

TR3A 5 volts to DTR

TR3A 5 volts to DTR

TR1

TR1

TR2

TR2

TR4

TR4



To Starter Relay


To Reverse Lights

To Reverse Lights

Purple-Orange

Orange

Tan-Red

Red-Lt.Blue


To Starter Relay

Black-Pink

Black-Pink

White-Pink or Pink

White-Pink

GEM 22 4WD

Black

Red-White

1999 Explorer 4.9 OHV1999 Mountaineer 4.0 SOHC

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Yellow-Black

White-Black

Lt.Blue-Yellow

Lt.Blue-Black

91

3

50

64

49

Ground

Ground

TR1

TR4

TR3A 5 volts to DTR

TR2


To Starter Relay

To Reverse Lights

Purple-Orange

Tan-Red


Black-Pink

White-Pink or Pink

GEM 22 4WD

Black

Red-White

1999 Explorer/Mountaineer 5.0 1999 Mustang 3.8-4.6 SOHC

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 18




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4



To Reverse Lights

Lt.Blue-Pink

Dk.Blue-Orange

To Starter Relay

Black-Pink

Tan-Red

GEM 22 4WD

Black

Red-White

1999 F150-250 Light Duty 4.2, 4.6, 5.4

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

White-Black

Yellow-Black

Lt.Blue-Black

Lt.Blue-Yellow

91

50

17 or 34

49

64

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Pink


Black-Pink

Tan-Red

GEM 1 4WD

Pnk-Org or Ppl-Org

Red-White

1999 F250-350 Super Duty 5.4-6.8 Gas1999 F250-350 Super Duty 7.3 Diesel

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Purple-Orange

Tan-Red


Black-Pink

White-Pink or Pink

GEM 22 4WD

Black or Bare

Red-White

1999 Ranger 2.5-3.0-4.0

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blu-Yel or Pnk-Blk

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Orange

Brown-Pink Fuse 7 10a. Hot in Start

Blk-Pnk or Pnk-Blk

Tan-Red

1999 Sable-Taurus 3.0 12 Valve, 3.0 Flex Fuel

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 19




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4

Fuse 17 10a.a. Hot in Run

To Starter Relay

To Reverse Lights

Lt.Blue-Black

White-Pink


Black-Pink

Brown-Pink

1999 Lincoln Town Car

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1

Grey-Red

Lt.Blue-Yellow

Orange-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4

Fuse 19 10a. Hot in StartRed-Lt.Blue

To Starter RelayWhite-Pink

1999 Windstar 3.0-3.8

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Orange-Black

Black-White

Dk.Green-Orange

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4



To Reverse Lights

Red-Black

White-Orange

To Starter Relay

Black-Pink

Tan-Red

2000 Lincoln Continental

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Violet-Orange

Red-Lt.Blue

From Ign.Swit, Hot in Start

Black-Pink

White-Pink

2000 Crown Victoria/Grand Marquis

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 20




02-14 of 22

BACKBACK

TERMINALNUMBER

TERMINALNUMBER

WIRECOLOR

WIRECOLOR

PCM PINNUMBER

PCM PINNUMBER

CIRCUITFUNCTION

CIRCUITFUNCTION

2 23 3

4 4

5 5

6 6

7 7

8 8

9 9

10 10

11 11

12 12

1 1Grey-Red Grey-Red

Lt.Blue-Yellow Lt.Blue-Yellow

Yellow-Black Yellow-Black

Lt.Blue-Black Lt.Blue-Black

Lt.Green-Red Dk.Green-Yellow

91 91

64 64

3 or 34 3 or 34

49 49

50 50

Ground Ground

TR3A 5 volts to DTR TR3A 5 volts to DTR

TR1 TR1

TR2 TR2

TR4 TR4

Fuse 12 15a. Hot in Run Fuse 12 15a. Hot in Run

To Starter Relay To Starter Relay

To Reverse Lights To Reverse Lights

White-Violet White-Violet

Red-Lt.Blue Red-Lt.Blue

Fuse 34 10a. Hot in Start Fuse 34 10a. Hot in Start

Black-Pink Black-Pink

Tan-Red Tan-Red

2000 Econoline Van 150-250 4.2, 4.6,2000 Econoline Van 5.4 Super Duty 2000 Econoline 6.8 Super Duty

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blu-Blk or Wht-Pnk

Lt.Blu-Red or Gry-Blk

91

64

17

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

White-Violet

Red-Lt.Blue


Black-Pink

Tan-Red

2000 Econoline 7.3 Diesel

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

and Transfer Case Pin 4

TR3A 5 volts to DTR

TR1

TR2

TR4



To Reverse Lights

Lt.Blue-Pink

Dk.Blu-Org or Wht-Pnk

To Starter Relay

Black-Pink

Tan-Red

GEM 1

GEM 4

4WD

Violet-Yellow

Red-White

2000 Excursion 5.4, 6.8 Gas2000 F250-350 Super Duty Gas

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 21




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Reverse Lights

Lt.Blue-Pink

Dk.Blue-Orange

To Starter Relay

Black-Pink

Tan-Red

GEM 22 4WD

Black

Red-White

2000 F150-250 Light Duty

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1

Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

17

49

50

Ground

and Transfer Case Pin 4

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Pink

Dk.Blu-Org or Wht-Pnk Fuse 20 15a. Hot in Start

Black-Pink

Tan-Red

GEM 1

GEM 4

4WD

Violet-Yellow

Red-White

2000 Excursion 7.3 Diesel2000 F250-350 Super Duty 7.3 Diesel

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Pink


Black-Pink

Tan-Red

GEM 22 4WD

Black

Red-White

2000 Expedition 4.6, 5.42000 Navigator 5.4

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Violet-Orange

Tan-Red


Black-Pink

Pink

GEM 22 4WD

Black

Red-White

2000 Explorer 4.0, 4.0 SOHC, 5.02000 Mountaineer 4.0 SOHC, 5.0

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 22




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Brown-Yellow

White

White-Green

White-Blue

White-Red

17

9

22

18

10

Reverse Lights

TR3A 5 volts to DTR

TR1

TR2

TR4

Fuse 201 5a. Hot in StartPurple-Orange

To Starter RelayGrey

2000 Lincoln LS 3.0

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Orange


Black-Pink

White-Pink

2000 Mustang 3.8-4.6 SOHC

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Violet-Orange

Tan-Red


Black-Pink

Wht-Pnk or Wht-Vio

GEM 22 4WD

Black

Red-White

2000 Ranger 2.5, 3.0, 4.0

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Red-Black

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Black-Yellow

Brown-Pink Fuse 237 15a. Hot in Start

Black-Pink

Tan-Red

2000 Sable/Taurus

1 7

82

93

104

115

126


12 11 10 9 8

23456 1

7


Figure 23




02-14 of 22

BACKBACK

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Lt.Blue-Black

White-Pink


Black-Pink

Brown-Pink

2000 Lincoln Town Car

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Orange-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4

To Starter Relay


White-Pink

2000 Windstar

TERMINALNUMBER

WIRECOLOR

PCM PINNUMBER

CIRCUITFUNCTION

2

3

4

5

6

7

8

9

10

11

12

1Grey-Red

Lt.Blue-Yellow

Yellow-Black

Lt.Blue-Black

White-Black

91

64

3 or 34

49

50

Ground

Ground

TR3A 5 volts to DTR

TR1

TR2

TR4


To Starter Relay

To Reverse Lights

Violet-Orange

Tan-Red


Black-Pink

Pink

To 4WD Control Module

Black

Red-White

2001 Ranger 2.5, 3.0, 4.0 SOHC

12 11 10 9 8

23456 1

7


1 7

82

93

104

115

126


Figure 24




02-14 of 22

BACKBACK

5r55_new Dtr Sensor ( Digital Range Sensor)

Documents

Transcript of 5r55_new Dtr Sensor ( Digital Range Sensor)