4-STROKE AIR-COOLED GASOLINE ENGINE PRODUCT CODE … · 2019. 11. 21. · 14091 14091-7064...
15
4-STROKE AIR-COOLED GASOLINE ENGINE 99907-3256-01 FT730V-AS45 PRODUCT CODE P/N
Transcript of 4-STROKE AIR-COOLED GASOLINE ENGINE PRODUCT CODE … · 2019. 11. 21. · 14091 14091-7064...
4-STROKE AIR-COOLED GASOLINE ENGINE
99907-3256-01
FT730V-AS45PRODUCT CODE
P/N
FT730V- AS45 PARTS LIST INFORMATION
PARTS CATALOG INTRODUCTION
This parts catalog lists parts and sub-assemblies provided as service parts.When it becomes necessary to replace parts, always use KAWASAKI GENUINE PARTS which have passed strictinspection which guarantees quality and performance.1. HOW TO ORDER PARTS
1) When ordering the parts, be sure to use the parts catalog corresponding to the product code. Checkthe product revision codes on the product and the catalog.
2. EXPLANATION OF PARTS CATALOG FORMAT
1) Product CodeThis code describes the product code covered by this catalog. The product revision code, which is a partof the product code, is omitted.
This title is the representative name for the group of parts illustrated on the page.2) Part Group Title
The reference numbers are shown on the illustration and the list as the link between them.3) Reference Number
4) Part NumberThis is the key of your parts ordering.Three kinds of part number are used in this catalog.
6) QuantityThe figure shows quantity of the part required at the indicated position on the illustration and for thespecified product revision code.The asterisk (*) on this column means the part can be used as the substitute on the product and is supplieduntil the stock is exhausted.Note:Some small parts will be supplied by units. Example: If six (6) bolts are ordered and the minimum quantity per unit is five (5), two (2), units of the bolt will be delivered.
7) Product Revision CodeThis Code indicates an important change which affects the service parts interchangeability.
5) Description and Additional InformationThe part name, the location, the size, and the serial number as additional information, etc. are describedhere. Use them to find out and check the part required.When a part number is changed without change of the product revision code and the changed parts arenot interchangeable, the serial number of the product is noted as follows;
Center
2ND
&
AssemblyASSY
(-)
FrontGram
Number FR#G
As Required
And
3RD
Minus
Fourth
COMP
Third
Plus(+)
AR
Second
CNT
4TH
Complete
HEX
LWR
LengthLeft Hand
O/SOD =
Lower
Outside Diameter
Inside Diameter
Over Size
Hexagonal
MillimeterMM
ID =
L =Inch
LH
IN
Rear
T =U/S
Reference
Teeth
Under Size
T
REF
Revolutions Per Minute
Upper
RH
UPP
RR
VW
STD
Thickness
Standard
RPM
Watt
Right Hand
Volt
(
(FA130 − 100002(FA130 − 100002
-
--
FA130 − 100001)
)FA130 − 110001)
Affected units are from beginning of the product of theproduct code up to and including this serial number.Affected units are from this serial number and above.Affected units are in this serial number range.
2) Specify the part code (all digits) exactly as listed in this catalog on your parts order.3) The parts not shown in the illustrations of this catalog are not sold separately; only the complete unitsor next higher assemblies illustrated are supplied as the service parts.
3. ABBREVIATIONS
A Ampere
CYLINDER/CRANKCASE1.FT730V- AS45
AS45
11004 211004-0762 GASKET-HEAD11008 111008-0839 HEAD-COMP-CYLINDER,#111008A 111008-0845 HEAD-COMP-CYLINDER,#211022 111022-0046 CASE-ROCKER,#1CYL11022A 111022-0721 CASE-ROCKER,#2CYL
11061 211061-1285 GASKET,CASE-ROCKER11061A 111061-7094 GASKET,BREATHER13272 113272-1374 PLATE14091 114091-7064 COVER,BREATHER16126 116126-7020 VALVE,BREATHER
32155 132155-2214 PIPE,BREATHER49015 149015-0029 COVER-CRANKCASE49120 149120-0848 CRANKCASE-COMP59071 159071-0733 JOINT92043 392043-0858 PIN
92043A 692043-1263 PIN,6.2X8X1492049 492049-7001 SEAL-OIL,RVC2 6X11X10.292049A 192049-7010 SEAL-OIL,SD 35X48X8 R HS92049B 192049-7028 SEAL-OIL,38X62X8MTCLV92066 192066-0880 PLUG,OIL
92066A 192066-0881 PLUG92066B 192066-2223 PLUG92104 AR92104-0007 GASKET-LIQUID,TB1217H92153 1092153-7054 BOLT,8X5092154 692154-2938 BOLT,6X12
92172 192172-0870 SCREW,4X892200 1092200-1864 WASHER,10.5X19.5X1.6130 10130BA0625 BOLT-FLANGED,6X25130A 4130CA1050 BOLT-FLANGED,10X50130B 6130CA1065 BOLT-FLANGED,10X65
172 4172BA0822 BOLT-STUD,8X22670 2670B2011 O RING,11MM
QuantityDescriptionPart No.Ref.No.
2019/11/211
PISTON/CRANKSHAFT2.FT730V- AS45
AS45
13001 213001-7027 PISTON-ENGINE13002 213002-0704 PIN-PISTON13008 213008-0569 RING-SET-PISTON13025 AR13025-7009 RING-SET-PISTON L,0.513029 AR13029-7010 PISTON-ENGINE L,0.5
13031 113031-0834 CRANKSHAFT-COMP13251 213251-0719 ROD-ASSY-CONNECTING92033 492033-0790 RING-SNAP92154 492154-2842 BOLT,6X35
QuantityDescriptionPart No.Ref.No.
2019/11/212
VALVE/CAMSHAFT3.FT730V- AS45
AS45
11055 411055-7009 BRACKET12004 212004-0733 VALVE-INTAKE12005 212005-0777 VALVE-EXHAUST12009 412009-7001 RETAINER-VALVE SPRING12011 812011-2056 COLLET
12016 412016-0040 ARM-ROCKER12032 412032-7001 TAPPET13116 413116-0725 ROD-PUSH49078 449078-7002 SPRING-ENGINE VALVE,IN49118 149118-7022 CAMSHAFT-COMP
92033 192033-0778 RING-SNAP92145 192145-1653 SPRING92152 492152-1689 COLLAR92153 492153-7100 BOLT,6X29.592154 492154-1267 BOLT,8X18.2
92200 492200-2151 WASHER,8.1X18X0.592200A 192200-7048 WASHER,16.3X30X2.28312 4312AA0600 NUT-HEX,6MM
QuantityDescriptionPart No.Ref.No.
2019/11/213
LUBRICATION-EQUIPMENT4.FT730V- AS45
AS45
13272 113272-7011 PLATE,ROTOR14075 114075-0707 CAP-ASSY16154 116154-7010 ROTOR-PUMP,OUTER16154A 116154-7011 ROTOR-PUMP,INNER49065 149065-7006 FILTER-OIL
49065A 149065-7007 FILTER-OIL59071 159071-0732 JOINT,PLUG SIDE59071A 159071-0750 JOINT,ENGINE SIDE59231 159231-0746 FILLER92055 392055-0892 RING-O,15.8X2.4
92066 192066-0818 PLUG92140 192140-7003 BALL,STEEL,13/3292145 192145-1809 SPRING,OIL RELIEF92154 192154-2823 BOLT,6MM92154A 392154-2938 BOLT,6X12
92173 292173-1502 CLAMP92173A 192173-2109 CLAMP92192 192192-1430 TUBE,12.7X18.3X350555 1555A0420 PIN-SPRING,4X20
QuantityDescriptionPart No.Ref.No.
2019/11/214
COOLING-EQUIPMENT5.FT730V- AS45
AS45
13304 113304-0008 HOUSING-ASSY14037 114037-7008-9H SCREEN18020 118020-0729 BAFFLE23062 123062-7024 BRACKET-COMP49089 149089-0928 SHROUD-ENGINE,#2
49089A 149089-0932 SHROUD-ENGINE,#149089B 149089-7076 SHROUD-ENGINE55020 155020-2169 GUARD,FAN59041 159041-0027 FAN92026 292026-7007 SPACER
92039 392039-0751 RIVET,GUARD92153 892153-7007 BOLT,FLANGED,6X1692154 392154-2687 BOLT,6X1292154A 192154-2823 BOLT,6MM92154B 492154-2938 BOLT,6X12
92161 292161-0586 DAMPER92172 292172-0896 SCREW,5X19.692200 192200-1864 WASHER,10.5X19.5X1.6
QuantityDescriptionPart No.Ref.No.
2019/11/215
ELECTRIC-EQUIPMENT6.FT730V- AS45
AS45
11057 111057-1625 BRACKET,RELAY BOX11057A 111057-1626 BRACKET,RELAY BOX13272 113272-7012 PLATE21066 121066-0747 REGULATOR-VOLTAGE21130 221130-2060 CAP-SPARK PLUG
21171 221171-0725 COIL-ASSY-IGNITION21193 121193-0037 FLYWHEEL-ASSY26006 126006-0034 FUSE,10A26006A 126006-0035 FUSE,2A26006B 126006-0036 FUSE,40A
26011 126011-0931 WIRE-LEAD26011A 126011-7025 WIRE-LEAD,L=9526031 126031-2436 HARNESS26031A 126031-2437 HARNESS26031B 126031-2438 HARNESS
27010 127010-0830 SWITCH,OIL PRESSURE27034 227034-0010 RELAY59031 159031-0013 COIL-CHARGING92009 192009-2308 SCREW92070 292070-7004 PLUG-SPARK,BPR4ES(NGK),SOLID
92072 292072-0775 BAND92072A 292072-7003 BAND92153 192153-7029 BOLT92154 292154-2938 BOLT,6X1292154A 192154-7003 BOLT,12X30
92171 192171-7008 CLAMP92172 292172-0896 SCREW,5X19.692172A 192172-1091 SCREW,5X1292172B 492172-7018 SCREW,5X2092173 492173-1515 CLAMP
92200 192200-7002 WASHER130 4130BA0616 BOLT-FLANGED,6X16130A 1130BA0816 BOLT-FLANGED,8X16510 1510A5100 KEY-WOODRUFF
QuantityDescriptionPart No.Ref.No.
2019/11/216
THROTTLE-EQUIPMENT7.FT730V- AS45
AS45
11056 111056-3900 BRACKET11061 211061-7093 GASKET,MANIFOLD16163 116163-1179 THROTTLE-ASSY21176 121176-0771 SENSOR21176A 121176-0772 SENSOR
23062 123062-1163 BRACKET-COMP27012 127012-0831 HOOK,LIFT42036 142036-0800 SLEEVE49033 249033-0045 NOZZLE-INJECTION51044 151044-0883 TUBE-ASSY
59076 159076-0021 MANIFOLD-INTAKE92015 492015-1367 NUT,FLANGED,6MM92055 292055-0908 RING-O,NOZZLE-INJECTION92055A 292055-0909 RING-O,NOZZLE-INJECTION92154 392154-2938 BOLT,6X12
92161 292161-1763 DAMPER92173 292173-7003 CLAMP92173A 292173-7009 CLAMP92192 192192-1769 TUBE,BREATHER92192A 192192-1770 TUBE,TH-MANIFOLD
92200 292200-1759 WASHER130 3130BA0616 BOLT-FLANGED,6X16130A 4130BA0630 BOLT-FLANGED,6X30130B 2130BA0640 BOLT-FLANGED,6X40130C 2130BA0816 BOLT-FLANGED,8X16
QuantityDescriptionPart No.Ref.No.
2019/11/217
AIR-FILTER/MUFFLER8.FT730V- AS45
AS45
11013 111013-0763 ELEMENT-AIR FILTER,BASE11013A 111013-0764 ELEMENT-AIR FILTER,FOAM11038 111038-0050 CASE-ASSY-AIR FILTER11060 211060-7016 GASKET,MUFFLER11065 111065-0981 CAP
92055 292055-7025 RING-O92173 292173-7009 CLAMP92192 192192-1768 TUBE,AC-TH92210 292210-1730 NUT92210A 492210-7027 NUT,M8
461 4461DA0800 WASHER-SPRING,8MM
QuantityDescriptionPart No.Ref.No.
2019/11/218
FUEL-TANK/FUEL-VALVE9.FT730V- AS45
AS45
11057 111057-0750 BRACKET,PUMP-FUEL11065 111065-7037 CAP14093 114093-1064 COVER,PUMP-FUEL49019 149019-0031 FILTER-FUEL49040 149040-0736 PUMP-FUEL
49040A 149040-0769 PUMP-FUEL59071 159071-0050 JOINT59071A 159071-0723 JOINT92037 592037-1461 CLAMP,TUBE92037A 192037-2006 CLAMP
92059 192059-2011 TUBE,5X6X7592154 292154-2665 BOLT92170 692170-2009 CLAMP92172 592172-0896 SCREW,5X19.692173 192173-1495 CLAMP
92173A 192173-2326 CLAMP,TUBE-ASSY92192 192192-1209 TUBE,4.76X8.74X20092192A 192192-1372 TUBE,4.76X8.74X3592192B 192192-1547 TUBE,6.35X12.7X14092192C 192192-1771 TUBE,EVAP
92192D 192192-1772 TUBE,PULSE92192E 192192-1773 TUBE,6.35X12.7X8092200 192200-1850 WASHER,5.3X15X1.2
QuantityDescriptionPart No.Ref.No.
2019/11/219
STARTER10.FT730V- AS45
AS45
11057 111057-1624 BRACKET,FUSE13081 113081-0651 CLUTCH-ASSY,STARTER-ELECTRIC13168 113168-0847 LEVER,PINION DRIVE13280 113280-0873 HOLDER,BRUSH14093 114093-0456 COVER
16073 116073-0854 INSULATOR16146 116146-0796 COVER-ASSY,COMMUTATOR END16146A 116146-0801 COVER-ASSY,STARTER DRIVE21039 421039-0011 BRUSH,STARTER-ELECTRIC21040 421040-0005 SPRING-BRUSH
21080 121080-0011 ARMATURE,STARTER-ELECTRIC21163 121163-0754 STARTER-ELECTRIC27010 127010-0843 SWITCH,MAGNET32085 132085-0797 STOPPER,PINION92015 192015-2147 NUT
92033 192033-0777 RING-SNAP92154 292154-2116 BOLT92172 292172-0870 SCREW,4X892210 292210-1493 NUT92210A 192210-7027 NUT,M8
130 1130BA0816 BOLT-FLANGED,8X16130A 2130BA0840 BOLT-FLANGED,8X40461 1461DA0800 WASHER-SPRING,8MM
QuantityDescriptionPart No.Ref.No.
2019/11/2110
LABEL11.FT730V- AS45
AS45
56030 256030-1415 LABEL56033 156033-7001 LABEL-MANUAL56071 156071-0216 LABEL-WARNING56080 156080-0903 LABEL-BRAND,FT730V EFI
QuantityDescriptionPart No.Ref.No.
2019/11/2111
Fig No.Part No. Fig No. Part No.Fig No. Part No.Part No.Fig No.Part No.Fig No. Fig No.Part No.
FT730V- AS45 NUMERICAL PARTS INDEX
11004-0762 111008-0839 111008-0845 111013-0763 811013-0764 811022-0046 111022-0721 111038-0050 811055-7009 311056-3900 7
11057-0750 911057-1624 1011057-1625 611057-1626 611060-7016 811061-1285 111061-7093 711061-7094 111065-0981 811065-7037 9
12004-0733 312005-0777 312009-7001 312011-2056 312016-0040 312032-7001 313001-7027 213002-0704 213008-0569 213025-7009 2
13029-7010 213031-0834 213081-0651 10130BA0616 6130BA0616 7130BA0625 1130BA0630 7130BA0640 7130BA0816 10130BA0816 6
130BA0816 7130BA0840 10130CA1050 1130CA1065 113116-0725 313168-0847 1013251-0719 213272-1374 113272-7011 413272-7012 6
13280-0873 1013304-0008 514037-7008-9H 514075-0707 414091-7064 114093-0456 1014093-1064 916073-0854 1016126-7020 116146-0796 10
16146-0801 1016154-7010 416154-7011 416163-1179 7172BA0822 118020-0729 521039-0011 1021040-0005 1021066-0747 621080-0011 10
21130-2060 621163-0754 1021171-0725 621176-0771 721176-0772 721193-0037 623062-1163 723062-7024 526006-0034 626006-0035 6
26006-0036 626011-0931 626011-7025 626031-2436 626031-2437 626031-2438 627010-0830 627010-0843 1027012-0831 727034-0010 6
312AA0600 332085-0797 1032155-2214 142036-0800 7461DA0800 10461DA0800 849015-0029 149019-0031 949033-0045 749040-0736 9
49040-0769 949065-7006 449065-7007 449078-7002 349089-0928 549089-0932 549089-7076 549118-7022 349120-0848 151044-0883 7
510A5100 655020-2169 5555A0420 456030-1415 1156033-7001 1156071-0216 1156080-0903 1159031-0013 659041-0027 559071-0050 9
59071-0723 959071-0732 459071-0733 159071-0750 459076-0021 759231-0746 4670B2011 192009-2308 692015-1367 792015-2147 10
92026-7007 592033-0777 1092033-0778 392033-0790 292037-1461 992037-2006 992039-0751 592043-0858 192043-1263 192049-7001 1
92049-7010 192049-7028 192055-0892 492055-0908 792055-0909 792055-7025 892059-2011 992066-0818 492066-0880 192066-0881 1
92066-2223 192070-7004 692072-0775 692072-7003 692104-0007 192140-7003 492145-1653 392145-1809 492152-1689 392153-7007 5
92153-7029 692153-7054 192153-7100 392154-1267 392154-2116 1092154-2665 992154-2687 592154-2823 492154-2823 592154-2842 2
92154-2938 192154-2938 492154-2938 592154-2938 692154-2938 792154-7003 692161-0586 592161-1763 792170-2009 992171-7008 6
92172-0870 192172-0870 1092172-0896 592172-0896 692172-0896 992172-1091 692172-7018 692173-1495 992173-1502 492173-1515 6
92173-2109 492173-2326 992173-7003 792173-7009 792173-7009 892192-1209 992192-1372 992192-1430 492192-1547 992192-1768 8
92192-1769 792192-1770 792192-1771 992192-1772 992192-1773 992200-1759 792200-1850 992200-1864 192200-1864 592200-2151 3
92200-7002 692200-7048 392210-1493 1092210-1730 892210-7027 1092210-7027 8
99907-3256-01Part No.
