237 senthil
-
Upload
4th-international-conference-on-advances-in-energy-research-icaer-2013 -
Category
Technology
-
view
197 -
download
0
Transcript of 237 senthil
![Page 1: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/1.jpg)
SENTHIL KUMAR KANDASAMY
ASSISTANT PROFESSOR
DEPARTMENT OF ECE
KONGU ENGINEERING COLLEGE
ERODE, TAMILNADU
Investigations of Silver Zirconia Composite as
Electrode in Supercapacitor
![Page 2: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/2.jpg)
To fabricate supercapacitor using silver-zirconia composite as one electrode and activated carbon as another electrode and to measure the capacitance using LCR meter. Silver zirconia composite was synthesized and characterized using UV Visible spectroscopy and XRD.
Finally, the supercapacitor was fabricated and measured the capacitance using LCR meter. There were two set ups created. One is single parallel plate arrangement and another one is cascading arrangement. The capacitance value is compared.
Abstract
![Page 3: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/3.jpg)
Technology which deals with the various structures of matter having dimensions of the order of a billionth of a meter.
Nanotechnology
![Page 4: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/4.jpg)
Electrochemical Double Layer Capacitor Energy is stored in supercapacitor by polarizing the electrolytic solution. Electrolytic capacitor , capacitance value limited by flat surface area and
dielectric properties Energy Density: It is the amount of energy stored per unit volume or mass. The amount of energy stored is very large because of high surface area
created by porous electrodes and the small charge separation created by separator.
Power Density: It combines energy density with the speed that energy can be drawn out of a device.
Farad: The electron storing capacity of capacitor is measured in unit Farad. One farad is approximately the charge with 6,280,000,000,000,000,000 electrons.
Advantages of the supercapacitor include high energy density compared to capacitors, High power density compared to batteries, Shorter charging time, Longer cycle life , Longer shelf life, Stability, Light weight and so on.
Introduction
![Page 5: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/5.jpg)
Supercapacitors Higher power density Much faster charge and
discharge rate Environmentally friendly Extremely low internal
resistance or ESR High efficiency (97-98%) Over a million charge-
discharge cycles
Higher energy density Typically, 200 – 1000
charge and discharge cycles
Contains highly reactive and hazardous chemicals
Negatively effected by low temperatures
Supercapacitor Vs Batteries
Batteries
![Page 6: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/6.jpg)
![Page 7: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/7.jpg)
Extremely porous with a very large surface area.
Surface resembles a spongeMore electrons to be stored than other
materials.Low electronic conductivity
Activated Carbon
![Page 8: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/8.jpg)
The specific capacitance and kinetic reversibility of the composite electrodes were enhanced by addition of silver nanoparticles.
For Zirconia, porosity in the range of 2-21% and size in the range of 65-120 nm.
The mixture was subjected to physical/chemical activation in an attempt to increase the surface area and specific capacitance of the electrode.
Silver Zirconia Composite
![Page 9: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/9.jpg)
The silver colloids were synthesized by chemical reduction method. The CTAB was added to silver nitrate (0.1 M) solution and stirred. Then, the L-ascorbic acid (0.1 M) was added to that solution to produce silver nanoparticles. By chemical reduction silver colloids were prepared. Then, zirconium oxalate and sodium hydroxide is mixed with the silver colloid and stirred for 24 hrs to make it as a homogeneous solution. By proper sintering temperature, silver zirconia composite were obtained. This particle can dispersed in triethanolamine and water in the ratio 1:3.
Synthesis
![Page 10: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/10.jpg)
Results and Discussion
![Page 11: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/11.jpg)
FTIR
![Page 12: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/12.jpg)
Wave Number, cm-1
Assignment References
1 483 Symmetric stretching mode of Zr-O-Zr bond,Zr-O vibration,Strong absorption attributed to tetragonal zirconia.Monoclinic ZrO2,O-Zr-OZr-O stretching vibration
470, V. Eswaranand and T. Pradeep, 2002.470, Luis A. P´erez-Maqueda and Egon Matijevi et al, 1997.471, Guorong Duan et al,2008506, W.T. Tang et al, 2010.400-500, Zijun Zhang et al,2011450, Zijun Zhang et al,2011
2 660 IR active fundamental mode of ZrO2 ,Asymmetric stretching mode of Zr-O-Zr bondZr-O bondSi-O-Ag bond
653, A. Sreekumaran Nair et al, 2004.650, V. Eswaranand and T. Pradeep, 2002.650, Zijun Zhang et al,2011670, Chang Sool kim et al,2008
3 797 Zr-O bond 833, Zijun Zhang et al,20114 907 Zr-O bond
Si-O-Ag bond937, Zijun Zhang et al,2011889, Chang Sool kim et al,2008
5 1110 Bending vibration of C-H 1122,Shaoxu Wang et al,20066 1288 C-C bond 1284, Zijun Zhang et al,20117 1426 Absorption bond of NO3 1387, Chang Sool Kim et al,20088 1684 Stretching vibrations of the OH groups
H-O-H bending vibrations C-O bond
1634, S. Jayakumar et al, 2011,Zijun Zhang et al, 2011.1645, Chang Sool Kim et al,20081597, Zijun Zhang et al,2011
9 3395 Bending vibrations of the OH groupsBending vibrations of the OH band due to absorbed water molecules
3419, Guorong Duan et al,20083426,S. Jayakumar et al, 2011,Zijun Zhang et al, 2011.
![Page 13: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/13.jpg)
XRF Analysis
Element Analysis
Element Weight,%
1 Zr K 92.114
2 Si K 5.763
3 Hf L 1.306
4 Ag K 0.605
5 Ti K 0.211
Using EDX 720.
It is used to
measure the
weight
percentage of
the individual
elements.
Analysis
performed before
calcination.
![Page 14: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/14.jpg)
XRD
Broad peak at 27
degree which
confims the
amorphous
nature of the as
prepared
composite.
![Page 15: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/15.jpg)
AFM
Surface
roughness.
![Page 16: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/16.jpg)
Supercapacitor setup
Electrode -
Activated Carbon
and Silver
Zirconia
Composite
Electrolyte – KI
Separator –
Whatman Paper
![Page 17: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/17.jpg)
Asymmetric supercapacitor developed successfully using silver zirconia composite as one electrode and activated carbon as another electrode in KI electrolyte
Asymmetric supercapacitor can exhibit maximum energy density.
Two layers consisting of nanoporous electrodesSeparator is impregnated with an organic
electrolyte Thin separator can only withstand low voltages
![Page 18: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/18.jpg)
Dielectric constant of medium X area of the plate
Capacitance = ----------------------------------
Distance between the plates
![Page 19: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/19.jpg)
Capacitance measurement
S.No Capacitor Arrangement Electrolyte Capacitance
1 Single parallel plate capacitor KI 1 F to 12 F
2 Cascading arrangement KI 33 F to 180 F
Measured using
LCR meter.
Compared to
single parallel
plate capacitor ,
cascading
arrangement of
supercapacitor
gives the better
result.
![Page 20: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/20.jpg)
Silver zirconia composite was synthesized and characterized using UV Visible spectroscopy and XRD. Finally, the supercapacitor was fabricated and measured the capacitance using LCR meter. For single setup the capacitance range varies between 1 F to 12 F. But for cascading arrangement the capacitance value drastically varies in between 33 F to 180 F.
Conclusion
![Page 21: 237 senthil](https://reader035.fdocuments.in/reader035/viewer/2022081502/557d43fdd8b42a9c148b4686/html5/thumbnails/21.jpg)
Questions?