8/12/2019 044002Rustilo DWX 21

1/5

SAFETY DATA SHEET

1 . Identification of the substance/preparation and company/undertaking

Rustilo DWX 21Product name

451217SDS no.

Use of thesubstance/preparation

Rust preventive / Water displacement fluid.For specific application advice see appropriate Technical Data Sheet or consult our company

representative.

Castrol (U.K.) LimitedWakefield HousePipers WaySwindonWiltshire, SN3 1REUnited KingdomTel.: +44 (0)1793 512712Fax.: +44 (0)1793 486083

Supplier

Carechem: +44 (0) 1235 239 670 (24 hours)EMERGENCY TELEPHONENUMBER

E-mail address MSDSadvice@bp.com

Hazards identification2 .

This preparation is classified as dangerous according to Directive 1999/45/EC as amended and adapted.

Physical/chemical hazards Flammable.

Human health hazards Harmful: may cause lung damage if swallowed. Repeated exposure may cause skin dryness or cracking.Vapours may cause drowsiness and dizziness.

Environmental hazards Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.

See sections 11 and 12 for more detailed information on health effects and symptoms and environmental hazards.

Additional hazards Residual film: Not classified.

Composition/information on ingredients3 .

Hydrocarbon solvent, film forming corrosion preventives and additives

CAS no. % EINECS /ELINCS.

ClassificationChemical name

Naphtha (petroleum), hydrodesulfurized heavy 64742-82-1 50 - 100 265-185-4 R10Xn; R65R66, R67N; R51/53

[1]

2-(2-butoxyethoxy)ethanol 112-34-5 1 - 5 203-961-6 Xi; R36 [1] [2]Nonyl phenol polyglycol ether 9016-45-9 0.1 - 1 500-024-6 Xi; R36/38

N; R51/53[1]

See section 16 for the full text of the R-phrases declared above

Occupational exposure limits, if available, are listed in section 8.

[1] Substance classified with a health or environmental hazard

[2] Substance with a workplace exposure limit

[3] PBT-substance

[4] vPvB-substance

4 . First-aid measures

Skin contact

In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Get medicalattention if irritation occurs.

Immediately wash exposed skin with soap and water. Remove contaminated clothing and shoes. Washclothing before reuse. Clean shoes thoroughly before reuse. Get medical attention if irritation develops.

If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, giveoxygen. Get medical attention.

Notes to physician Treatment should in general be symptomatic and directed to relieving any effects.

Inhalation

Eye contact

Ingestion If swallowed, do not induce vomiting. Never give anything by mouth to an unconscious person. Aspirationhazard if swallowed. Can enter lungs and cause damage. Get medical attention.

Product name

Date of issue

Rustilo DWX 21

20 December 2010 Format

(United Kingdom)

United Kingdom(UK)

Product code 451217-GB04

Language

Page: 1/5

ENGLISH

( ENGLISH )

8/12/2019 044002Rustilo DWX 21

2/5

Fire-fighting measures5 .

Extinguishing media

Suitable In case of fire, use water fog, foam, dry chemical or carbon dioxide extinguisher or spray.

Do not use water jet.Not suitable

Decomposition products may include the following materials:carbon dioxidecarbon monoxide

Hazardous decompositionproducts

Flammable liquid and vapour. Vapour may cause flash fire. Vapours may accumulate in low or confinedareas or travel a considerable distance to a source of ignition and flash back. Runoff to sewer may createfire or explosion hazard.

Unusual fire/explosion hazards

None identified.Special fire-fightingprocedures

Fire-fighters should wear positive pressure self-contained breathing apparatus (SCBA) and full turnoutgear.

Protection of fire-fighters

6 . Accidental release measures

Environmental precautions

Personal precautions

Stop leak if without risk. Move containers from spill area. Approach the release from upwind. Prevententry into sewers, water courses, basements or confined areas. Wash spillages into an effluent treatmentplant or proceed as follows. Contain and collect spillage with non-combustible, absorbent material e.g.sand, earth, vermiculite or diatomaceous earth and place in container for disposal according to localregulations (see section 13). Use spark-proof tools and explosion-proof equipment. Dispose of via alicensed waste disposal contractor. Contaminated absorbent material may pose the same hazard as thespilt product. Note: see section 1 for emergency contact information and section 13 for waste disposal.

No action shall be taken involving any personal risk or without suitable training. Evacuate surroundingareas. Keep unnecessary and unprotected personnel from entering. Do not touch or walk through spiltmaterial. Shut off all ignition sources. No flares, smoking or flames in hazard area. Avoid breathingvapour or mist. Provide adequate ventilation. Wear appropriate respirator when ventilation is inadequate.Put on appropriate personal protective equipment (see section 8).

Avoid dispersal of spilt material and runoff and contact with soil, waterways, drains and sewers. Inform therelevant authorities if the product has caused environmental pollution (sewers, waterways, soil or air).Water polluting material. May be harmful to the environment if released in large quantities.

Large spill

Stop leak if without risk. Move containers from spill area. Absorb with an inert material and place in anappropriate waste disposal container. Dispose of via a licensed waste disposal contractor.

Small spill

Handling and storage7 .

Storage Store in a segregated and approved area. Keep container in a cool, well-ventilated area. Keep containertightly closed and sealed until ready for use. Avoid all possible sources of ignition (spark or flame).

Aspiration hazard if swallowed. Can enter lungs and cause damage. Do not ingest. If ingested, do notinduce vomiting. Avoid prolonged or repeated contact with skin. Use only with adequate ventilation. Keepaway from heat, sparks and flame. To avoid fire or explosion, dissipate static electricity during transfer byearthing and bonding containers and equipment before transferring material. Use explosion-proofelectrical (ventilating, lighting and material handling) equipment. Wash thoroughly after handling.Concentrations of mist, fumes and vapours in enclosed spaces may result in the formation of explosiveatmospheres. Excessive splashing, agitation or heating must be avoided.

Handling

8 . Exposure controls/personal protection

Ingredient name Occupational exposure limits

Exposure controls

Low boiling point hydrogen treated naphtha (white spirit) EH40 (United Kingdom (UK)).TWA: 350 mg/m 8 hour(s).

Base oil - unspecified EH40-OES (United Kingdom (UK)).STEL: 10 mg/m 15 minute(s). Form: Oil mist, mineral

TWA: 5 mg/m 8 hour(s). Form: Oil mist, mineral

2-(2-butoxyethoxy)ethanol EH40/2005 WELs (United Kingdom (UK)).STEL: 15 ppm 15 minute(s). Issued/Revised: 10/2007

TWA: 10 ppm 8 hour(s). Issued/Revised: 10/2007 STEL: 15 mg/m 15 minute(s). Issued/Revised: 10/2007

TWA: 10 mg/m 8 hour(s). Issued/Revised: 10/2007

Low boiling point hydrogen treated naphtha (white spirit) ACGIH (United States).TWA: 100 ppm 8 hour(s).

Base oil - unspecified ACGIH (United States).STEL: 10 mg/m 15 minute(s). Form: Mineral oil, mist

TWA: 5 mg/m 8 hour(s). Form: Mineral oil, mist

For information and guidance, the ACGIH values are included. For further information on these please consult your supplier.

Whilst specific OELs for certain components may be shown in this section, other components may be present in any mist, vapour or dustproduced. Therefore, the specific OELs may not be applicable to the product as a whole and are provided for guidance only.

ACGIH TLVs

Product name

Date of issue

Rustilo DWX 21

20 December 2010 Format

(United Kingdom)

United Kingdom(UK)

Product code 451217-GB04

Language

Page: 2/5

ENGLISH

( ENGLISH )

8/12/2019 044002Rustilo DWX 21

3/5

Occupational exposurecontrols

Provide exhaust ventilation or other engineering controls to keep the airborne concentrations of vapoursbelow their respective occupational exposure limits.

Hygiene measures Wash hands, forearms and face thoroughly after handling chemical products, before eating, smoking andusing the lavatory and at the end of the working period.

Personal protective equipment

Respiratory protection

Hand protection Wear suitable gloves. Chemical-resistant gloves. Recommended: Nitrile gloves.The correct choice of protective gloves depends upon the chemicals being handled, the conditions of workand use, and the condition of the gloves (even the best chemically resistant glove will break down afterrepeated chemical exposures). Most gloves provide only a short time of protection before they must bediscarded and replaced. Because specific work environments and material handling practices vary, safetyprocedures should be developed for each intended application. Gloves should therefore be chosen inconsultation with the supplier/manufacturer and with a full assessment of the working conditions.

Eye protection Safety glasses with side shields.

Use only with adequate ventilation.In case of insufficient ventilation, wear suitable respiratory equipment.Recommended: half-face mask - organic vapor filter (Type A).The correct choice of respiratory protection depends upon the chemicals being handled, the conditions ofwork and use, and the condition of the respiratory equipment. Safety procedures should be developed foreach intended application. Respiratory protection equipment should therefore be chosen in consultationwith the supplier/manufacturer and with a full assessment of the working conditions.

Skin and body Avoid contact with skin. Wear suitable protective clothing.

Physical and chemical properties9 .

Flash point Closed cup: 38C (100.4F)

Colour Brown.

Physical state Liquid.

Odour Solvent.

General information

Appearance

Important health, safety and environmental information

8/12/2019 044002Rustilo DWX 21

4/5

Disposal considerations13 .

The generation of waste should be avoided or minimised wherever possible. Empty containers or linersmay retain some product residues. This material and its container must be disposed of in a safe way.Dispose of surplus and non-recyclable products via a licensed waste disposal contractor. Disposal of thisproduct, solutions and any by-products should at all times comply with the requirements of environmentalprotection and waste disposal legislation and any regional local authority requirements. Avoid dispersal ofspilt material and runoff and contact with soil, waterways, drains and sewers.

Disposal considerations /Waste information

Unused product

European waste catalogue(EWC)

14 06 03* other solvents and solvent mixtures

However, deviation from the intended use and/or the presence of any potential contaminants may requirean alternative waste disposal code to be assigned by the end user.

Packaging

European waste catalogue(EWC)

15 01 10* packaging containing residues of or contaminated by dangerous substances

14 . Transport information

International transport regulations

ADR/RIDClassification

IMDGClassification

Regulatoryinformation

UN number Proper shipping name Class PG* Additional information

ADNRClassification

ICAO/IATAClassification

UN1300

UN1300

UN1300 Turpentine substitute mixture. Marinepollutant (Low boiling point hydrogentreated naphtha (white spirit))

Turpentine substitute mixture

Turpentine substitute mixture 3

3

3 III

III

III Hazard identificationnumber30

RemarksEnvironmentallyhazardous substancemark.

Tunnel restriction code:D/E

RemarksEnvironmentallyhazardous substancemark.

Emergency schedules(EmS)F-E, S-E

Marine pollutant

UN1300 Turpentine substitute mixture 3 III RemarksEnvironmentallyhazardous substancemark.

PG* : Packing group

Label

UK Emergency Action Code:

ADR/RID Classification code: F1

3Y

ADNR Classification code: F1

Regulatory information15 .

Classification and labelling have been performed according to EU directives 1999/45/EC and 67/548/EEC as amended and adapted.

Label requirements

Hazard symbol or symbols

Indication of danger

R10- Flammable.R65- Harmful: may cause lung damage if swallowed.R66- Repeated exposure may cause skin dryness or cracking.R67- Vapours may cause drowsiness and dizziness.R51/53- Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.

Risk phrases

Harmful Dangerous for the environment

Product name

Date of issue

Rustilo DWX 21

20 December 2010 Format

(United Kingdom)

United Kingdom(UK)

Product code 451217-GB04

Language

Page: 4/5

ENGLISH

( ENGLISH )

8/12/2019 044002Rustilo DWX 21

5/5

Safety phrases S23- Do not breathe vapour or spray.S24/25- Avoid contact with skin and eyes.S43- In case of fire, never use water.S51- Use only in well-ventilated areas.S61- Avoid release to the environment. Refer to special instructions/safety data sheet.S62- If swallowed, do not induce vomiting: seek medical advice immediately and show this container orlabel.

Other regulations

Europe inventory

At least one component is not listed.

At least one component is not listed.

At least one component is not listed.

All components are listed or exempted.

At least one component is not listed.

At least one component is not listed.

At least one component is not listed.

At least one component is not listed.

United States inventory(TSCA 8b)

Australia inventory (AICS)

Canada inventory

China inventory (IECSC)Japan inventory (ENCS)

Korea inventory (KECI)

Philippines inventory(PICCS)

Other information16 .

R10- Flammable.R65- Harmful: may cause lung damage if swallowed.R36- Irritating to eyes.R36/38- Irritating to eyes and skin.R66- Repeated exposure may cause skin dryness or cracking.R67- Vapours may cause drowsiness and dizziness.R51/53- Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.

Full text of R-phrases referredto in sections 2 and 3

History

Prepared by Product Stewardship

Notice to reader

All reasonably practicable steps have been taken to ensure this data sheet and the health, safety and environmental information contained in itis accurate as of the date specified below. No warranty or representation, express or implied is made as to the accuracy or completeness of thedata and information in this data sheet.

The data and advice given apply when the product is sold for the stated application or applications. You should not use the product other than forthe stated application or applications without seeking advice from us.

It is the users obligation to evaluate and use this product safely and to comply with all applicable laws and regulations. The BP Group shall notbe responsible for any damage or injury resulting from use, other than the stated product use of the material, from any failure to adhere torecommendations, or from any hazards inherent in the nature of the material. Purchasers of the product for supply to a third party for use atwork, have a duty to take all necessary steps to ensure that any person handling or using the product is provided with the information in thissheet. Employers have a duty to tell employees and others who may be affected of any hazards described in this sheet and of any precautionsthat should be taken.

Indicates information that has changed from previously issued version.

Date of issue/ Date ofrevision

Date of previous issue

20/12/2010.

22/10/2008.

Product name

Date of issue

Rustilo DWX 21

20 December 2010 Format

(United Kingdom)

United Kingdom(UK)

Product code 451217-GB04

Language

Page: 5/5

ENGLISH

( ENGLISH )