04 - slings - Bullivants
Transcript of 04 - slings - Bullivants
80 - 105
04 -
SLI
NG
SCare & UseGunnebo GrabiQ Chain SlingsGrade T(80) Chain SlingsRUD Chain SlingsSynthetic Slings
NEED HELP WITH A BIG LIFT?AMSTEEL®-BLUE BIG LIFT SLING RANGESee page 96 for details
Wire Rope SlingsSuperflex Slings
WWW.BULLIVANTS.COM 81
04 -
SLI
NG
S
Alloy Chain Slings Grade T(80) & Grade V(100)Bullivants has been assembling and supplying chain slings for over 100 years with an outstanding record for safety. Chain slings are manufactured in accordance with Australian Standard AS3775 and AS3776 using quality lifting grade components. All slings are supplied with a WLL tag fitted.Chain slings can be made to any configuration. Variations include the number of legs, the length of the legs and the fittings attached to the master links and chain legs.The useful life of alloy chain slings is considerable, but it can easily be extended by observing the following:Care • Store chain slings on A-frames or wall racks in a clean dry place. • Lightly oil chains before prolonged storage. • Never heat treat alloy chain or fittings.Use • Always visually inspect that a chain sling is free from damage or wear before use. • Ensure the weight of the load is known and is evenly distributed on the sling legs. • Ensure that the chain is free of twists and is protected from any sharp corners on the load. • Commence the lift slowly, taking up the slack gradually. Avoid shock loads. • When lowering, avoid the possibility of crushing the chain by ensuring the load does not land on it. Use packing, timber or similar.InspectionIt is important to inspect chain slings regularly and to keep a record for each sling. • Clean the chain thoroughly. • Lay the chain out on a clean surface or hang it up in a well lit area. • Every chain link should be individually inspected for any signs of wear, twisting, stretching, nicks, or gouging and any worn link measured to determine degree of wear using Vernier Calipers. • Master links and hooks should be inspected for any sign of wear at their load bearing points and for any signs of distortion, such as widening of hook throat opening. • Coupling links should be inspected for any signs of wear at their load bearing points, for excessive play of the load pin within the body halves and for impaired rotation of the body halves around the load pin. • Chain links or fittings having any defects should be clearly marked to indicate rejection and the chain sling should be withdrawn from service until properly repaired and retested prior to returning to service. • Slings that have damaged fittings may be repaired on-site by replacing the fittings (note: when reassembling coupling links it is recommended that a new pin and stud assembly be used), but must be proof tested after any modifications other than replacing safety latches that are not an integral part of a hook in accordance with AS3775.2.Remember - Every link must be examined.Chain Slings should be inspected periodically by a competent person, in accordance with AS3775.
04 -
SLI
NG
S
1300 722 99982
Working Load Limits (tonnes) - Alloy Chain Slings, Single & Multi Leg Assemblies
Loading Factors 1.00 0.75 0.75 1.30 1.73 1.41 1.00 1.30 2.25
Grade Chain size (mm)
Straight sling or adjustable sling with no
deration
Adjustable sling with deration (Note 1)
Reeved sling
Basket sling Max
60°
Straight sling (Note 2) Reeved sling (Notes 2 and 3)
Basket sling (Notes 2, 3
and 4)
60° 90° 120° Max angle 60° Max angle 60°
Grade V(100) 4 0.63 0.5 0.4 0.8 1.1 0.9 0.63 0.8 1.4
Grade V(100) 5 1 0.8 0.6 1.3 1.7 1.4 1 1.3 2.3
Grade T(80) 6 1.1 0.8 0.8 1.5 1.9 1.6 1.1 1.5 2.5
Grade V(100) 6 1.4 1.1 0.8 1.8 2.4 2.0 1.4 1.8 3.2
Grade T(80) 7 1.5 1.1 1.1 2 2.6 2.1 1.5 2 3.4
Grade V(100) 7 1.9 1.4 1.1 2.5 3.3 2.7 1.9 2.5 4.3
Grade T(80) 8 2 1.5 1.5 2.6 3.5 2.8 2 2.6 4.5
Grade V(100) 8 2.5 1.9 1.4 3.3 4.3 3.5 2.5 3.3 5.6
Grade T(80) 10 3.2 2.4 2.4 4.1 5.5 4.5 3.2 4.1 7.2
Grade V(100) 10 4 3.0 2.3 5.2 6.9 5.6 4 5.2 9.0
Grade T(80) 13 5.3 4.0 4.0 6.9 9.2 7.5 5.3 6.9 11.9
Grade V(100) 13 6.7 5.0 3.8 8.7 11.6 9.4 6.7 8.7 15.1
Grade T(80) 16 8 6.0 6.0 10.4 13.8 11.3 8 10.4 18.0
Grade V(100) 16 10 7.5 5.6 13.0 17.3 14.1 10 13.0 22.5
Grade V(100) 18 12.5 9.4 7.0 16.3 21.6 17.6 12.5 16.3 28.1
Grade T(80) 19 11.2 8.4 8.4 14.6 19.4 15.8 11.2 14.6 25.2
Grade V(100) 19 14 10.5 7.9 18.2 24.2 19.7 14 18.2 31.5
Grade T(80) 20 12.5 9.4 9.4 16.3 21.6 17.6 12.5 16.3 28.1
Grade V(100) 20 16 12.0 9.0 20.8 27.7 22.6 16 20.8 36.0
Grade T(80) 22 15 11.3 11.3 19.5 26.0 21.2 15 19.5 33.8
Grade V(100) 22 19 14.3 10.7 24.7 32.9 26.8 19 24.7 42.8
Grade V(100) 23 21 15.8 11.8 27.3 36.3 29.6 21 27.3 47.3
Grade T(80) 26 21.2 15.9 15.9 27.6 36.7 29.9 21.2 27.6 47.7
Grade V(100) 26 26.5 19.9 14.9 34.5 45.8 37.4 26.5 34.5 59.6
Grade V(100) 28 31.5 23.6 17.7 41.0 54.5 44.4 31.5 41.0 70.9
Grade T(80) 32 31.5 23.6 23.6 41 54.5 44.4 31.5 41 70.9
Grade V(100) 32 40 30.0 22.5 52.0 69.2 56.4 40 52.0 90.0
Notes:1. Some shortening devices, such as grab hooks, derate the WLL for the sling by 25%. Other shortening devices such as shortening hooks and grab hooks with cradle confi guration, may not derate the WLL for the sling. Advice regarding the appropriate deration should be sought by the manufacturer.2. The determination of the angle of the multi-leg sling is the largest included angle at the apex of the confi guration.3. Reeved slings and basket slings, in a two leg confi guration have a maximum angle for use of 60°.4. To ensure that an appropriately rated master link is used for the 2 leg basket sling, the master link to be used shall be a master link of an appropriate WLL and with intermediate links. This ensures that the factor of 2.25 can be accommodated and that there is no overcrowding with back hooking.
Temperature °C deration -40° to + 200° none + 200° to 300° 10.00% + 300° to + 400° 25.00%
WWW.BULLIVANTS.COM 83
04 -
SLI
NG
S
Gunnebo GrabiQ Chain SlingsThe Gunnebo GrabiQ sling system is designed to improve and make your lifting as quick and easy as possible.GrabiQ Means: • 25% additional strength in the new grade 10 material. • All top assemblies consist of no more than three components. • Shortening function of chain legs is integral with no extra components.One of the main merits of the GrabiQ system is that the work involved in connecting, adjusting and checking the lift takes less time and can be carried out more easily. The already included shortening function means that a four leg chain sling previously required up to thirteen different top components now needs only three using the GrabiQ system.All GrabiQ components are uniformly marked with the equivalent chain size, grade, traceability code, manufacturers name and designation, for positive identification.GrabiQ For SafetyIn lifting applications not all the legs of slings are used for lifting a load. The remaining legs are often hanging idle which can cause snagging or a potential injury to users with the GrabiQ range you can easily remove idle legs.GrabiQ Making It EasyWith the use of the GrabiQ WLL tags the correct information is provided on the sling tag no matter which sling leg combination is used. The correct WLL information is available for the user.GrabiQ For WHSThe weight of a multi-leg chain sling is considerable and in some cases can require more than one person to assist with connection. The GrabiQ sling range provides for easier handling through the reduction of components required and the option to remove idle sling legs easily.GrabiQ For VersatilityEvery GrabiQ sling has a shortening function built in to enable you to safely adjust headroom and ensure load is balanced.Working Load Limits (tonnes) - Grade V(100) GrabiQ Slings
Loading Factors 1.00 0.75 0.75 1.30 1.73 1.41 1.00 1.30 2.25
Chain size (mm)
Straight sling or adjustable sling with no
deration
Adjustable sling with deration (Note 1)
Reeved sling
Basket sling Max
60°
Straight sling (Note 2) Reeved sling (Notes 2 and 3)
Basket sling (Notes 2, 3
and 4)
60° 90° 120° Max angle 60° Max angle 60°
4 0.63 0.5 0.4 0.8 1.1 0.9 0.63 0.8 1.4
5 1 0.8 0.6 1.3 1.7 1.4 1 1.3 2.3
6 1.4 1.1 0.8 1.8 2.4 2.0 1.4 1.8 3.2
7 1.9 1.4 1.1 2.5 3.3 2.7 1.9 2.5 4.3
8 2.5 1.9 1.4 3.3 4.3 3.5 2.5 3.3 5.6
10 4 3.0 2.3 5.2 6.9 5.6 4 5.2 9.0
13 6.7 5.0 3.8 8.7 11.6 9.4 6.7 8.7 15.1
16 10 7.5 5.6 13.0 17.3 14.1 10 13.0 22.5
18 12.5 9.4 7.0 16.3 21.6 17.6 12.5 16.3 28.1
19 14 10.5 7.9 18.2 24.2 19.7 14 18.2 31.5
20 16 12.0 9.0 20.8 27.7 22.6 16 20.8 36.0
22 19 14.3 10.7 24.7 32.9 26.8 19 24.7 42.8
23 21 15.8 11.8 27.3 36.3 29.6 21 27.3 47.3
26 26.5 19.9 14.9 34.5 45.8 37.4 26.5 34.5 59.6
28 31.5 23.6 17.7 41.0 54.5 44.4 31.5 41.0 70.9
32 40 30.0 22.5 52.0 69.2 56.4 40 52.0 90.0
Notes:1. Some shortening devices, such as grab hooks, derate the WLL for the sling by 25%. Other shortening devices such as shortening hooks and grab hooks with cradle confi guration, may not derate the WLL for the sling. Advice regarding the appropriate deration should be sought by the manufacturer.2. The determination of the angle of the multi-leg sling is the largest included angle at the apex of the confi guration.3. Reeved slings and basket slings, in a two leg confi guration have a maximum angle for use of 60°.4. To ensure that an appropriately rated master link is used for the 2 leg basket sling, the master link to be used shall be a master link of an appropriate WLL and with intermediate links. This ensures that the factor of 2.25 can be accommodated and that there is no overcrowding with back hooking.
Temperature °C deration -40° to + 200° none + 200° to 300° 10.00% + 300° to + 400° 25.00%
04 -
SLI
NG
S
1300 722 99984
Single Leg Chain Slings With Safety Hook: Unit of Measure - Each
Fitted with GrabiQ chain, the all-in-one compact GrabiQ Master Grab MG and GrabiQ BKG/ GBK safety hook.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox.
W
eigh
t (kg
)
WLL
(ton
nes)
133400 6 1 1 2.4 1.5
133401 6 1 2 3.2 1.5
133402 6 1 3 4 1.5
133403 6 1 4 4.8 1.5
133404 6 1 5 5.6 1.5
133405 8 1 1 2.8 2.5
133406 8 1 2 4.2 2.5
133407 8 1 3 5.6 2.5
133408 8 1 4 7 2.5
133409 8 1 5 8.4 2.5
133410 10 1 1 4.9 4
133411 10 1 2 6.8 4
133412 10 1 3 8.7 4
133413 10 1 4 10.6 4
133414 10 1 5 12.5 4
133415 13 1 1 8.5 6.5
133416 13 1 2 11 6.5
133417 13 1 3 14.5 6.5
133418 13 1 4 18 6.5
133419 13 1 5 21.5 6.5
133420 16 1 1 14.6 10
133421 16 1 2 20.2 10
133422 16 1 3 25.8 10
133423 16 1 4 31.4 10
133424 16 1 5 36.9 10
Single Leg Chain Slings With Sling Hook: Unit of Measure - Each
Fitted with GrabiQ chain, the all-in-one compact GrabiQ Master Grab MG and GrabiQ EGKN sling hook.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox.
W
eigh
t (kg
)
WLL
(ton
nes)
133425 6 1 1 2.2 1.5
133426 6 1 2 3 1.5
133427 6 1 3 3.8 1.5
133428 6 1 4 4.6 1.5
133429 6 1 5 5.4 1.5
133430 8 1 1 2.6 2.5
133431 8 1 2 4 2.5
133432 8 1 3 5.4 2.5
133433 8 1 4 6.8 2.5
133434 8 1 5 8.2 2.5
133435 10 1 1 4.3 4
133436 10 1 2 6.4 4
133437 10 1 3 8.3 4
133438 10 1 4 10.2 4
133439 10 1 5 12.1 4
133440 13 1 1 7 6.5
133441 13 1 2 10.5 6.5
133442 13 1 3 13 6.5
133443 13 1 4 16.5 6.5
133444 13 1 5 20 6.5
133445 16 1 1 13.8 10
133446 16 1 2 19.4 10
133447 16 1 3 25 10
133448 16 1 4 30.6 10
133449 16 1 5 36.1 10
WWW.BULLIVANTS.COM 85
04 -
SLI
NG
S
Double Leg Chain Slings With Safety Hooks: Unit of Measure - Each
Fitted with GrabiQ Chain, GrabiQ MGD Master Link all-in-one compact top link which can be used as a shortener for 2 leg slings and GrabiQ BKG/GBK Safety Hooks.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox.
W
eigh
t (kg
)
WLL
(ton
nes)
133450 6 2 1 3.5 2.6
133451 6 2 2 5.1 2.6
133452 6 2 3 6.7 2.6
133453 6 2 4 8.3 2.6
133454 6 2 5 9.8 2.6
133455 8 2 1 5.4 4.3
133456 8 2 2 8.2 4.3
133457 8 2 3 11 4.3
133458 8 2 4 13.8 4.3
133459 8 2 5 16.6 4.3
133460 10 2 1 8.7 6.9
133461 10 2 2 12.7 6.9
133462 10 2 3 16.7 6.9
133463 10 2 4 20.7 6.9
133464 10 2 5 24.7 6.9
133465 13 2 1 16 11.2
133466 13 2 2 23 11.2
133467 13 2 3 30 11.2
133468 13 2 4 37 11.2
133469 13 2 5 44 11.2
133470 16 2 1 28.5 17.3
133471 16 2 2 39.7 17.3
133472 16 2 3 50.9 17.3
133473 16 2 4 62.7 17.3
133474 16 2 5 73.3 17.3
Double Leg Chain Slings With Sling Hooks: Unit of Measure - Each
Fitted with GrabiQ Chain, GrabiQ MGD Master Link all-in-one compact top link which can be used as a shortener for 2 leg slings and GrabiQ EGKN Sling Hook.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox.
W
eigh
t (kg
)
WLL
(ton
nes)
133475 6 2 1 3.1 2.6
133476 6 2 2 4.7 2.6
133477 6 2 3 6.3 2.6
133478 6 2 4 7.9 2.6
133479 6 2 5 9.4 2.6
133480 8 2 1 5 4.3
133481 8 2 2 7.6 4.3
133482 8 2 3 10.4 4.3
133483 8 2 4 13.2 4.3
133484 8 2 5 16 4.3
133485 10 2 1 8.3 6.9
133486 10 2 2 12.3 6.9
133487 10 2 3 16.3 6.9
133488 10 2 4 20.3 6.9
133489 10 2 5 24.3 6.9
133490 13 2 1 15.6 11.2
133491 13 2 2 22.6 11.2
133492 13 2 3 29.6 11.2
133493 13 2 4 36.6 11.2
133494 13 2 5 43.6 11.2
133495 16 2 1 27.3 17.3
133496 16 2 2 38.1 17.3
133497 16 2 3 49.3 17.3
133498 16 2 4 61.1 17.3
133499 16 2 5 71.7 17.3
04 -
SLI
NG
S
1300 722 99986
Single Leg Chain Slings With Safety Hook: Unit of Measure - Each
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox
Wei
ght (
kg)
WLL
(ton
nes)
133842 8 1 3 7.0 2.5133843 8 1 6 12.1 2.5133844 10 1 3 11.7 4133845 10 1 6 19.5 4133846 13 1 3 20.4 6.7133847 13 1 6 33.9 6.7133848 16 1 3 32.0 10133849 16 1 6 51.8 10133850 20 1 3 49.7 16133851 20 1 6 77.0 16132377* 22 1 3 73 19132376* 22 1 6 109 19
*22mm sling configurations use BK Self Locking Hooks & OG Grab Hook Shorteners.
Single Leg Chain Slings With Sling Hook: Unit of Measure - Each
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox
Wei
ght (
kg)
WLL
(ton
nes)
133852 8 1 3 6.6 2.5133853 8 1 6 11.7 2.5133854 10 1 3 10.6 4133855 10 1 6 18.4 4133856 13 1 3 19.4 6.7133857 13 1 6 32.9 6.7133858 16 1 3 30.1 10133859 16 1 6 49.9 10133860 20 1 3 49.0 16133861 20 1 6 76.3 16132373* 22 1 3 70 19132372* 22 1 6 106 19
*22mm sling configurations use EKN Sling Hooks & OG Grab Hook Shorteners.
Double Leg Chain Slings With Safety Hook: Unit of Measure - Each
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox
Wei
ght (
kg)
WLL
(ton
nes)
133862 8 2 3 13.9 4.3133863 8 2 6 24.1 4.3133864 10 2 3 23.5 6.9133865 10 2 6 39.1 6.9133866 13 2 3 40.0 11.2133867 13 2 6 67.0 11.2133868 16 2 3 64.7 17.3133869 16 2 6 104.3 17.3133870 20 2 3 94.5 27.6133871 20 2 6 149.1 27.6132375* 22 2 3 137 32.8132374* 22 2 6 209 32.8
*22mm sling configurations use BK Self Locking Hooks & OG Grab Hook Shorteners.
Double Leg Chain Slings With Sling Hook: Unit of Measure - Each
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
App
rox
Wei
ght (
kg)
WLL
(ton
nes)
133872 8 2 3 13.1 4.3133873 8 2 6 23.3 4.3133874 10 2 3 21.3 6.9133875 10 2 6 36.9 6.9133876 13 2 3 38.0 11.2133877 13 2 6 65.0 11.2133878 16 2 3 60.9 17.3133879 16 2 6 100.5 17.3133880 20 2 3 93.1 27.6133881 20 2 6 147.7 27.6132371* 22 2 3 131 32.8132370* 22 2 6 203 32.8
*22mm sling configurations use EKN Sling Hooks & OG Grab Hook Shorteners.
GrabiQ Grade V(100) Slings - Classic Configuration25% extra capacity compared to Grade T(80) - but with the traditional configuration using classic type master links, grab hooks and end fittings. All chain and components are tested and carry identification marks for full traceability.
WWW.BULLIVANTS.COM 87
04 -
SLI
NG
S
FlexiLeg Sling fitted With MF Masterlink, C-Grabs & Sling Hooks: Unit of Measure - Each
This FlexiLeg sling comes with GrabiQ chain, MF Master Link, C Grabs and EGKN Sling Hooks. The FlexiLeg system allows this sling to be configured in various ways.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
Leng
th o
f Le
gs (m
eter
)
WLL
(ton
nes)
Si
ngle
Leg
WLL
(ton
nes)
M
ulti
Leg
133650 6 1 1.5 2.6
133651 6 2 1.5 2.6
133652 6 3 1.5 2.6
133653 6 4 1.5 2.6
133654 6 5 1.5 2.6
133655 8 1 2.5 4.3
133656 8 2 2.5 4.3
133657 8 3 2.5 4.3
133658 8 4 2.5 4.3
133659 8 5 2.5 4.3
133660 10 1 4 6.9
133661 10 2 4 6.9
133662 10 3 4 6.9
133663 10 4 4 6.9
133664 10 5 4 6.9
133665 13 1 6.5 11.2
133666 13 2 6.5 11.2
133667 13 3 6.5 11.2
133668 13 4 6.5 11.2
133669 13 5 6.5 11.2
133670 16 1 10 17.3
133671 16 2 10 17.3
133672 16 3 10 17.3
133673 16 4 10 17.3
133674 16 5 10 17.3
FlexiLeg Sling fitted With MF Masterlink, C-Grabs & Safety Hooks: Unit of Measure - Each
This FlexiLeg sling comes with GrabiQ chain, MF Master Link, C Grabs and BKG/ GBK Sling Hooks. The FlexiLeg system allows this sling to be configured in various ways.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
Leng
th o
f Le
gs (m
eter
)
WLL
(ton
nes)
Si
ngle
Leg
WLL
(ton
nes)
M
ulti
Leg
133675 6 1 1.5 2.6
133676 6 2 1.5 2.6
133677 6 3 1.5 2.6
133678 6 4 1.5 2.6
133679 6 5 1.5 2.6
133680 8 1 2.5 4.3
133681 8 2 2.5 4.3
133682 8 3 2.5 4.3
133683 8 4 2.5 4.3
133684 8 5 2.5 4.3
133685 10 1 4 6.9
133686 10 2 4 6.9
133687 10 3 4 6.9
133688 10 4 4 6.9
133689 10 5 4 6.9
133690 13 1 6.5 11.2
133691 13 2 6.5 11.2
133692 13 3 6.5 11.2
133693 13 4 6.5 11.2
133694 13 5 6.5 11.2
133695 16 1 10 17.3
133696 16 2 10 17.3
133697 16 3 10 17.3
133698 16 4 10 17.3
133699 16 5 10 17.3
GrabiQ Flexileg SlingsGrabiQ FlexiLeg is a flexible range of chain sling solutions with instant leg interchange, where one single master link and a combination of five legs replaces four slings, which is equal to ten legs with the traditional system (a 50% reduction!). By using unique features of the GrabiQ range, we have increased the flexibility of lifting with chain slings even further.
04 -
SLI
NG
S
1300 722 99988
Grade T(80) Chain SlingsChain slings are assembled from Grade T(80) Alloy Chain providing high strength, low weight, high wear resistance and long life. Chain and components are tested and carry identification marks for full traceability.Working Load Limits (tonnes) - Grade T(80) Chain Slings
Loading Factors 1.00 0.75 0.75 1.30 1.73 1.41 1.00 1.30 2.25
Chain size (mm)
Straight sling or adjustable sling with no
deration
Adjustable sling with deration (Note 1)
Reeved sling
Basket sling Max
60°
Straight sling (Note 2) Reeved sling (Notes 2 and 3)
Basket sling (Notes 2, 3
and 4)
60° 90° 120° Max angle 60° Max angle 60°
6 1.1 0.8 0.8 1.5 1.9 1.6 1.1 1.5 2.5
7 1.5 1.1 1.1 2 2.6 2.1 1.5 2 3.4
8 2 1.5 1.5 2.6 3.5 2.8 2 2.6 4.5
10 3.2 2.4 2.4 4.1 5.5 4.5 3.2 4.1 7.2
13 5.3 4.0 4.0 6.9 9.2 7.5 5.3 6.9 11.9
16 8 6.0 6.0 10.4 13.8 11.3 8 10.4 18.0
19 11.2 8.4 8.4 14.6 19.4 15.8 11.2 14.6 25.2
20 12.5 9.4 9.4 16.3 21.6 17.6 12.5 16.3 28.1
22 15 11.3 11.3 19.5 26.0 21.2 15 19.5 33.8
26 21.2 15.9 15.9 27.6 36.7 29.9 21.2 27.6 47.7
32 31.5 23.6 23.6 41 54.5 44.4 31.5 41 70.9
Notes:1. Some shortening devices, such as grab hooks, derate the WLL for the sling by 25%. Other shortening devices such as shortening hooks and grab hooks with cradle confi guration, may not derate the WLL for the sling. Advice regarding the appropriate deration should be sought by the manufacturer.2. The determination of the angle of the multi-leg sling is the largest included angle at the apex of the confi guration.3. Reeved slings and basket slings, in a two leg confi guration have a maximum angle for use of 60°.4. To ensure that an appropriately rated master link is used for the 2 leg basket sling, the master link to be used shall be a master link of an appropriate WLL and with intermediate links. This ensures that the factor of 2.25 can be accommodated and that there is no overcrowding with back hooking.
Temperature °C deration -40° to + 200° none + 200° to 300° 10.00% + 300° to + 400° 25.00%
Chain Slings Grade T(80): Unit of Measure - EachThese chain slings come with shortening hooks, safety hooks, alloy tag and are tested in our NATA endorsed laboratory supplied in a bucket for easy and clean storage.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
WLL
(ton
nes)
WLL
@ 6
0°
(tonn
es)
132100 8 1 1.0 2
132101 8 1 2.0 2
132102 8 1 3.0 2
132357 8 1 4.0 2
132358 8 1 5.0 2
132359 8 1 6.0 2
132103 8 2 1.0 3.5
132104 8 2 1.5 3.5
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
WLL
(ton
nes)
WLL
@ 6
0°
(tonn
es)
132105 8 2 2.0 3.5
132106 8 2 2.5 3.5
132107 8 2 3.0 3.5
132360 8 2 3.5 3.5
132108 8 2 4.0 3.5
132361 8 2 4.5 3.5
132362 8 2 5.0 3.5
132363 8 2 5.5 3.5
WWW.BULLIVANTS.COM 89
04 -
SLI
NG
S
Chain Slings Grade T(80) (continued): Unit of Measure - EachThese chain slings come with shortening hooks, safety hooks, alloy tag and are tested in our NATA endorsed laboratory supplied in a bucket for easy and clean storage.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
WLL
(ton
nes)
WLL
@ 6
0°
(tonn
es)
132109 8 2 6.0 3.5
132364 8 3 1.0 3.5
132365 8 3 2.0 3.5
132366 8 3 3.0 3.5
132367 8 3 4.0 3.5
132368 8 3 5.0 3.5
132369 8 3 6.0 3.5
132670 8 4 1.0 3.5
132110 8 4 2.0 3.5
132111 8 4 3.0 3.5
132112 8 4 4.0 3.5
132971 8 4 5.0 3.5
133272 8 4 6.0 3.5
133273 10 1 1.0 3.2
132114 10 1 2.0 3.2
133274 10 1 3.0 3.2
133275 10 1 4.0 3.2
133276 10 1 5.0 3.2
133277 10 1 6.0 3.2
132116 10 2 1.0 5.5
133278 10 2 1.5 5.5
132117 10 2 2.0 5.5
133279 10 2 2.5 5.5
132118 10 2 3.0 5.5
133280 10 2 3.5 5.5
132119 10 2 4.0 5.5
133281 10 2 4.5 5.5
133282 10 2 5.0 5.5
133283 10 2 5.5 5.5
132120 10 2 6.0 5.5
133284 10 3 1.0 5.5
133285 10 3 2.0 5.5
133286 10 3 3.0 5.5
133287 10 3 4.0 5.5
Other fittings, lengths and configurations are available.
OR
DER
CO
DE
Cha
in D
ia.
(mm
)
No.
of L
egs
Leng
th (m
)
WLL
(ton
nes)
WLL
@ 6
0°
(tonn
es)
133288 10 3 5.0 5.5
133289 10 3 6.0 5.5
133290 10 4 1.0 5.5
133291 10 4 2.0 5.5
133292 10 4 3.0 5.5
133293 10 4 4.0 5.5
133294 10 4 5.0 5.5
133298 13 1 3.0 5.3
133299 13 1 4.0 5.3
133300 13 1 5.0 5.3
133301 13 1 6.0 5.3
133302 13 2 1.0 9.2
133303 13 2 1.5 9.2
133304 13 2 2.0 9.2
133305 13 2 2.5 9.2
133306 13 2 3.0 9.2
133307 13 2 3.5 9.2
133308 13 2 4.0 9.2
133309 13 2 4.5 9.2
133310 13 2 5.0 9.2
133311 13 2 5.5 9.2
133312 13 2 6.0 9.2
133313 13 3 1.0 9.2
133314 13 3 2.0 9.2
133315 13 3 3.0 9.2
133316 13 3 4.0 9.2
133317 13 3 5.0 9.2
133318 13 3 6.0 9.2
133319 13 4 1.0 9.2
133320 13 4 2.0 9.2
133321 13 4 3.0 9.2
133322 13 4 4.0 9.2
133323 13 4 5.0 9.2
133324 13 4 6.0 9.2
04 -
SLI
NG
S
1300 722 99990
RUD Chain SlingsWorking Load Limits (tonnes) - Grade 120 Chain Slings
Chain Dia. (mm)
Single Leg Slings Slings of 2, 3 or 4 Legs Single Leg 2 Leg 2, 3 or 4 Leg
Straight / Adj. Sling Reeved Sling
Straight Multileg Slings Basket Basket Reeved
60° 90° 120° 60° 60° 60°
ICE 6 1.8 1.4 3.1 2.5 1.8 2.3 4.1 2.3
ICE 8 3.0 2.3 5.2 4.2 3.0 3.9 6.8 3.9
ICE 10 5.0 3.8 8.7 7.1 5.0 6.5 11.3 6.5
ICE 13 8.0 6.0 13.8 11.3 8.0 10.4 18.0 10.4
ICE 16 12.5 9.4 21.6 17.6 12.5 16.3 28.1 16.3
Load Factor > 1 0.75 1.73 1.41 1 1.3 2.25 1.3
ICE Grade 120 Assembled Chain Slings/Clevis Sling Hook: Unit of Measure - Each • Manufactured in standard lengths, other lengths available • Fully assembled with clevis sling hook • Includes clevis grab hook, stainless steel tag and test certificate
OR
DER
CO
DE
Cha
in S
ize
(mm
)
No.
of l
egs
WLL
(ton
nes)
Leg
Leng
th (m
)
RU
D P
art N
o.
133882 8 1 3.0 1 7771081
133883 8 1 3.0 2 7771082
133884 8 1 3.0 3 7771083
133885 10 1 5.0 1 7771084
133886 10 1 5.0 2 7771085
133887 10 1 5.0 3 7771086
133888 13 1 8.0 3 7771087
133889 13 1 8.0 6 7771088
133890 8 2 5.2 @ 60° 1 7771089
133891 8 2 5.2 @ 60° 2 7771090
133892 8 2 5.2 @ 60° 3 7771091
133893 10 2 8.6 @ 60° 1 7771092
133894 10 2 8.6 @ 60° 2 7771093
133895 10 2 8.6 @ 60° 3 7771094
133896 10 2 8.6 @ 60° 4 7771095
133897 10 2 8.6 @ 60° 6 7771096
133898 13 2 13.8 @ 60° 3 7771097
133899 13 2 13.8 @ 60° 6 7771098
WWW.BULLIVANTS.COM 91
04 -
SLI
NG
S
VIP Chain Slings - Grade V(100)The most technologically advanced alloy chain sling system available - with 25% higher working load capacity and greater wear resistance than Grade T(80) (t) chain. This system comes with an extensive range of fittings, to offer the most innovative chain sling system available. Full range of components available from 4mm through to 28mm.Working Load Limits (tonnes) - Grade V(100) Chain Slings
Chain Dia. (mm)
Single Leg Slings Slings of 2, 3 or 4 Legs Single Leg 2 Leg 2, 3 or 4 Leg
Straight / Adj. Sling Reeved Sling
Straight Multileg Slings Basket Basket Reeved
60° 90° 120° 60° 60° 60°
VIP 4 0.63 0.5 1.1 0.9 0.63 0.8 1.4 0.8
VIP 6 1.5 1.1 2.6 2.1 1.5 2.0 3.4 2.0
VIP 8 2.5 1.9 4.3 3.5 2.5 3.3 5.6 3.3
VIP 10 4.0 3.0 6.9 5.6 4.0 5.2 9.0 5.2
VIP 13 6.7 5.0 11.6 9.4 6.7 8.7 15.1 8.7
VIP 16 10.0 7.5 17.3 14.1 10.0 13.0 22.5 13.0
VIP 20 16.0 12.0 27.7 22.6 16.0 20.8 36.0 20.8
VIP 22 20.0 15.0 34.6 28.2 20.0 26.0 45.0 26.0
VIP 28 31.5 23.6 54.5 44.4 31.5 41.0 70.9 41.0
Load Factor > 1 0.75 1.73 1.41 1 1.3 2.25 1.3
VIP Grade V(100) Assembled Chain Slings/Clevis Sling Hook: Unit of Measure - Each • Manufactured in standard lengths, other lengths available. • Fully assembled with VCGH clevis sling hook • Includes clevis grab hook, stainless steel tag and test certificate
OR
DER
CO
DE
Cha
in S
ize
(mm
)
No.
of L
egs
WLL
(ton
nes)
Leg
Leng
th (m
)
RU
D P
art N
o.
133900 8 1 2.5 1 7771045
133901 8 1 2.5 2 7771046
133902 8 1 2.5 3 7771047
133903 10 1 4.0 1 7771048
133904 10 1 4.0 2 7771049
133905 10 1 4.0 3 7771050
133906 13 1 6.7 3 7771051
133907 13 1 6.7 6 7771052
133908 8 2 4.3 @ 60° 1 7771053
OR
DER
CO
DE
Cha
in S
ize
(mm
)
No.
of L
egs
WLL
(ton
nes)
Leg
Leng
th (m
)
RU
D P
art N
o.
133909 8 2 4.3 @ 60° 2 7771054
133910 8 2 4.3 @ 60° 3 7771055
133911 10 2 6.9 @ 60° 1 7771056
133912 10 2 6.9 @ 60° 2 7771057
133913 10 2 6.9 @ 60° 3 7771058
133914 10 2 6.9 @ 60° 4 7771059
133915 10 2 6.9 @ 60° 6 7771060
133916 13 2 11.6 @ 60° 3 7771061
133917 13 2 11.6 @ 60° 6 7771062
04 -
SLI
NG
S
1300 722 99992
VIP Grade V(100) Assembled Chain Slings/Clevis Self Locking Hooks: Unit of Measure - Each • Manufactured in standard lengths, other lengths available. • Fully assembled with VAGH clevis self locking hook • Includes clevis grab hook, stainless steel tag and test certificate
OR
DER
CO
DE
Cha
in S
ize
(mm
)
No.
of L
egs
WLL
(ton
nes)
Leg
Leng
th (m
)
RU
D P
art N
o.
133918 8 1 2.5 1 7771063
133919 8 1 2.5 2 7771064
133920 8 1 2.5 3 7771065
133921 10 1 4.0 1 7771066
133922 10 1 4.0 2 7771067
133923 10 1 4.0 3 7771068
133924 13 1 6.7 3 7771069
133925 13 1 6.7 6 7771070
133926 8 2 4.3 @ 60° 1 7771071
133927 8 2 4.3 @ 60° 2 7771072
133928 8 2 4.3 @ 60° 3 7771073
133929 10 2 6.9 @ 60° 1 7771074
133930 10 2 6.9 @ 60° 2 7771075
133931 10 2 6.9 @ 60° 3 7771076
133932 10 2 6.9 @ 60° 4 7771077
133933 10 2 6.9 @ 60° 6 7771078
133934 13 2 11.6 @ 60° 3 7771079
133935 13 2 11.6 @ 60° 6 7771080
Synthetic SlingsCare & Use • Never overload equipment • Do not use if WLL tag is removed or illegible. • Inspect sling for damage prior to use. • Do not use if there is any sign of cut webbing, snagging, heat or chemical damage, excessive wear, damaged seams, any other defects or presence of grit, abrasive materials or other harmful matter. • Do not tie knots in sling webbing. • Protect sling webbing from sharp edges. Use protective sleeves. • Do not expose sling to temperatures above 90°C. • Do not allow abrasive or other damaging grit to penetrate fibres. • Consult with manufacturer’s recommendations before immersing a sling in a chemical solution. • Keep away from strong alkalis and phenolic compounds.InspectionSynthetic slings should be inspected for the following prior to use: • One major disadvantage of woven webbing slings is that when used to lift loads such as concrete slabs, grit can penetrate the sling causing internal fibre damage, which is not always obvious. • Internal wear, caused by repeated flexing, particularly where particles of grit have penetrated into the fibres. • Damage to a fixed protective coating or sleeve can allow abrasive grit easy access to the sling fibres.
• Melting or shrinkage of fibres due to exposure to high temperatures. Remember that high temperatures can result from friction as well as from a hot environment. • Prolonged exposure to ultra violet light, generally from sunlight, will weaken synthetic fibres. This may be indicated by powdering of the outer layer. • Chemical attack may also cause fibres to break down and soften. Surface fibres may be plucked or rubbed off and there may be local stiffening of the sling.Operators should refer to the manufacturer’s specification criteria and the appropriate standards.There are two types of Flat Slings available:1. Double and single ply are standard.2. Endless and four ply are also available. • Total sizing flexibility to suit the exact requirement. • Wide, flat load bearing surface. • Sleeving can be wider than sling. • Lifts smooth or fragile objects without risk or damage. • Wide choice of lifting modes. • High strength to weight ratio. • Colour coded for positive identification. • Light and flexible for good access in awkward locations. • Anti-abrasion protection available. • Anti-cutting protection available. • Conforms to Australian Standards AS1353.
WWW.BULLIVANTS.COM 93
04 -
SLI
NG
S
Synthetic SlingsWorking Load Limits (kgs) - Flat Webbing Sling AS1353, Roundslings AS4497
Direct Load
Material Colour
Vertical WLL (kg)
Choke WLL (kg)
Basket WLL (kg)
30° WLL (kg)
60° WLL (kg)
90° WLL (kg)
120° WLL (kg)
1000 Violet 1000 800 2000 1900 1700 1400 1000
2000 Green 2000 1600 4000 3800 3400 2800 2000
3000 Yellow 3000 2400 6000 5700 5100 4200 3000
4000 Grey 4000 3200 8000 7600 6800 5600 4000
5000 Red 5000 4000 10000 9500 8500 7000 5000
6000 Brown 6000 4800 12000 11400 10200 8400 6000
8000 Blue 8000 6400 16000 15200 13600 11200 8000
10000 Orange 10000 8000 20000 19000 17000 14000 10000
Synthetic Flat Slings - AS1353: Unit of Measure - Each
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Wid
th (m
m)
Col
our
131427 1 1.0 50 Violet
131428 1 1.5 50 Violet
131430 1 2.0 50 Violet
131443 1 2.5 50 Violet
131432 1 3.0 50 Violet
131447 1 5.0 50 Violet
131514 1 10.0 50 Violet
131448 2 1.0 75 Green
131450 2 1.5 75 Green
131433 2 2.0 75 Green
131435 2 2.5 75 Green
131436 2 3.0 75 Green
131456 2 4.0 75 Green
131459 2 5.0 75 Green
131461 2 6.0 75 Green
131463 3 2.0 90 Yellow
131465 3 3.0 90 Yellow
131466 3 4.0 100 Yellow
131557 3 5.0 100 Yellow
131559 3 6.0 100 Yellow
131467 4 3.0 140 Grey
131554 4 4.0 90 Grey
131469 5 4.0 150 Red
131470 6 3.0 180 Brown
131599 10 3.0 300 Orange
Other sizes available.
04 -
SLI
NG
S
1300 722 99994
Synthetic Round Slings - AS4497: Unit of Measure - Each • Fully colour coded. • Ideal for choke lifting cylindrical objects. • Lifts smooth objects without any damage. • Wears evenly along its length for greater working life. • Wide choice of lifting modes, can be used for towing. • High strength to weight ratio. • Anti-abrasion protection available. • Unique monofilament webbing. • Conforms to Australian Standard AS4497. • Safety factor to Australian and International Standards.
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Col
our
131284 1 0.5 Violet
131285 1 0.75 Violet
131262 1 1.0 Violet
131270 1 1.5 Violet
131263 1 2.0 Violet
131271 1 2.5 Violet
131272 1 3.0 Violet
131286 1 4.0 Violet
131327 1 5.0 Violet
131328 1 6.0 Violet
131287 2 0.5 Green
131288 2 0.7 Green
131264 2 1.0 Green
131273 2 1.5 Green
131265 2 2.0 Green
131274 2 2.5 Green
131266 2 3.0 Green
131276 2 4.0 Green
131346 2 5.0 Green
131290 2 6.0 Green
131277 3 1.0 Yellow
131291 3 1.5 Yellow
131267 3 2.0 Yellow
131292 3 2.5 Yellow
131268 3 3.0 Yellow
131278 3 4.0 Yellow
131355 3 5.0 Yellow
131293 3 6.0 Yellow
131359 4 1.0 Grey
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Col
our
131360 4 1.5 Grey
131295 4 2.0 Grey
131279 4 3.0 Grey
131280 4 4.0 Grey
131362 4 5.0 Grey
131296 4 6.0 Grey
131297 5 2.0 Red
131281 5 3.0 Red
131298 5 4.0 Red
131299 5 5.0 Red
131300 5 6.0 Red
131301 6 2.0 Brown
131302 6 2.5 Brown
131303 6 3.0 Brown
131304 6 4.0 Brown
131305 6 5.0 Brown
131306 6 6.0 Brown
131374 8 2.0 Blue
131307 8 2.5 Blue
131375 8 3.0 Blue
131376 8 4.0 Blue
131308 8 6.0 Blue
131309 10 3.0 Orange
131385 10 4.0 Orange
131310 10 6.0 Orange
131311 10 8.0 Orange
131388 10 10.0 Orange
131403 20 6.0 Orange
Other sizes available.
WWW.BULLIVANTS.COM 95
04 -
SLI
NG
S
Secutex Synthetic Clip-on Sling Protective Sleeves: Unit of Measure - Each
It is recommended that a form of protective sleeving is used in conjunction with synthetic slings when lifting objects with rough surfaces, which are likely to abrade the webbing; sharp or jagged edges, can cut the webbing. Protective sleeving will increase the working life of synthetic lifting slings.To achieve desired performance protective sleeves should: • Be fitted correctly over the sling. Ensure the width of the sleeve is compatible with the synthetic sling to which it is being applied. • Be positioned correctly around the load. • Be selected to suit the application.
OR
DER
CO
DE
Slin
g W
idth
(m
m)
132013 50
132014 75
131613 100
132015 150
132016 300
Drum Lifters: Unit of Measure - Each
Fabricated from 100% polyester webbing. Fitted with robust zinc passivated ratchet and an oblong lifting link or kooper reinforced folded eyes. A much easier and safe method of transporting drums, ideal for refuse bins.
OR
DER
CO
DE
WLL
(kg)
Type
131439 500 With Metal O Link
131474 500 With Lifting Eyes
04 -
SLI
NG
S
1300 722 99996
Need Help With A Big Lift?AmSteel®-Blue BIG LIFT SLINGS
Manufactured in accordance with AS4991 - 2004 and can be supplied with thimble ends or soft loops (with or without protective sleeves).Advantages • On average 15% the weight of an equivalent wire rope sling of same diameter • Light weight, as such greater lifting radius for the crane operator • Handling by riggers, less risk of crush or hand injury by wire penetrationNOTE: Interfacing components shall not be less than 1.5 times the rope diameter otherwise a 25% deration applies to the WLL as stated on this chart. Bending Ratios for grommets shall not be less than 4 times the rope diameter*Double Grommets used with a Ramshorn Hook only.
Working Load Limits (tonnes) - HMPE AmSteel® -Blue Slings in accordance with AS4991/FRS0412
Method Of Loading Sling
Direct Loaded Choke Hitch Basket Hitch Direct Loaded Grommets
SingleSingle Round Loaded
Single Square Loaded
Single Round Loaded MultilegSingle *Double
Included Angle 0° 60° 90° 120° 0° to 60° 90° 120°
Nom. Dia.
(mm)
MBF (kN)
Am
Stee
l® -B
lue
12 136.0 2.77 2.08 1.39 5.55 4.80 3.91 2.77 4.80 3.91 2.77 4.43 7.76
16 211.8 4.32 3.24 2.16 8.64 7.47 6.09 4.32 7.47 6.09 4.32 6.91 11.95
18 258.0 5.26 3.94 2.63 10.52 9.10 7.42 5.26 9.10 7.42 5.26 8.41 14.54
22 364.0 7.42 5.57 3.71 14.84 12.84 10.46 7.42 12.84 10.46 7.42 11.87 20.53
24 436.5 8.90 6.67 4.45 17.80 15.40 12.55 8.90 15.40 12.55 8.90 14.24 24.63
28 592.5 12.08 9.06 6.04 24.16 20.90 17.03 12.08 20.90 17.03 12.08 19.32 33.42
30 661.1 13.48 10.11 6.74 26.96 23.32 19.01 13.48 23.32 19.01 13.48 21.56 37.30
32 736.7 15.02 11.27 7.51 30.04 25.98 21.18 15.02 25.98 21.18 15.02 24.00 41.52
36 913.3 18.62 13.97 9.31 37.24 32.21 26.25 18.62 32.21 26.25 18.62 29.80 51.55
44 1343.9 27.40 20.55 13.70 54.80 47.40 38.63 27.40 47.40 38.63 27.40 43.84 75.85
56 2148.0 43.79 32.84 21.90 87.58 75.76 61.75 43.79 75.76 61.75 43.79 70.00 121.10
64 2648.7 54.00 40.50 27.00 108.00 93.42 76.14 54.00 93.42 76.14 54.00 86.40 149.47
80 4031.9 82.20 61.65 41.10 164.40 142.21 115.90 82.20 142.21 115.90 82.20 131.52 227.52
88 5846.7 119.20 89.40 59.60 238.40 206.21 168.07 119.20 206.21 168.07 119.20 190.72 329.94
All slings are tested by Bullivants and supplied NATA certified as standard issue, or alternate international standard upon consultation with Bullivants.
WWW.BULLIVANTS.COM 97
Wire Rope Slings - Single, Two, Three & Four LegWorking Load Limits (tonnes) - Wire Rope Slings With Ferrule Secured Eyes In Accordance With AS1666.1
Method of Loading Sling
Direct Loaded
Choke Hitch Basket Hitch
Round LoadDirect Loaded
Choke Hitch Round Load
Round Loaded
Rectangle Loaded
Single Wrap
Double Wrap
Included Angle - - - 0° 60° 90° 120° 0° to 60° 90° 120° 0° to 45° 0° to 60°
Nom. Dia.
(mm)
MBF (kN)
1570
Gra
de F
ibre
Cor
e
8 28.2 0.55 0.41 0.27 1.11 0.96 0.78 0.55 0.96 0.78 0.55 0.729 35.6 0.70 0.52 0.35 1.40 1.21 0.99 0.70 1.21 0.99 0.70 0.91
10 44.0 0.86 0.65 0.43 1.73 1.50 1.22 0.86 1.50 1.22 1.86 1.1311 53.2 1.05 0.78 0.52 2.10 1.81 1.48 1.05 1.81 1.48 1.05 1.3612 63.3 1.23 0.92 0.61 2.47 2.14 1.74 1.23 2.14 1.74 1.23 1.6113 74.3 1.47 1.10 0.73 2.94 2.54 2.07 1.47 2.54 2.07 1.47 1.9114 86.2 1.70 1.27 0.85 3.40 2.94 2.40 1.70 2.94 2.40 1.70 2.2116 113 2.22 1.67 1.11 4.45 3.85 3.14 2.22 3.85 3.14 2.22 2.8918 143 2.80 2.10 1.40 5.61 4.85 3.95 2.80 4.85 3.95 2.80 3.6520 176 3.48 2.61 1.74 6.97 6.03 4.91 3.48 6.03 4.91 3.48 4.5322 213 4.20 3.15 2.10 8.40 7.27 5.92 4.20 7.27 5.92 4.20 5.4624 253 5.01 3.76 2.50 10.03 8.67 7.07 5.01 8.67 7.07 5.01 6.5226 297 5.88 4.41 2.94 11.77 10.18 8.30 5.88 10.18 8.30 5.88 7.6528 345 6.81 5.11 3.40 13.63 11.79 9.61 6.81 11.79 9.61 6.81 8.8632 450 8.90 6.68 4.45 17.81 15.41 12.56 8.90 15.41 12.56 8.90 11.58
Method of Loading Sling
Direct Loaded
Choke Hitch Basket Hitch
Round LoadDirect Loaded
Choke Hitch Round Load
Round Loaded
Rectangle Loaded
Single Wrap
Double Wrap
Included Angle - - - 0° 60° 90° 120° 0° to 60° 90° 120° 0° to 45° 0° to 60°
Nom. Dia.
(mm)
MBF (kN)
1770
Gra
de W
ire R
ope
Cor
e
8 40.2 0.78 0.58 0.39 1.56 1.35 1.10 0.78 1.35 1.10 0.78 1.019 51.1 0.99 0.74 0.49 1.98 1.71 1.40 0.99 1.71 1.40 0.99 1.29
10 63.1 1.22 0.92 0.61 2.40 2.10 1.72 1.22 2.10 1.72 1.22 1.5911 76.3 1.48 1.11 0.74 3.00 2.60 2.10 1.48 2.60 2.10 1.48 1.9212 90.8 1.76 1.32 0.88 3.50 3.00 2.50 1.76 3.00 2.50 1.76 2.3013 107 2.10 1.55 1.04 4.10 3.60 2.90 2.10 3.60 2.90 2.10 2.7014 124 2.40 1.80 1.20 4.80 4.20 3.40 2.40 4.20 3.40 2.40 3.1016 161 3.10 2.30 1.56 6.20 5.40 4.40 3.10 5.40 4.40 3.10 4.1018 204 4.00 3.00 1.98 7.90 6.80 5.60 4.00 6.80 5.60 4.00 5.1020 252 4.90 3.70 2.40 9.80 8.40 6.90 4.90 8.40 6.90 4.90 6.3022 305 5.90 4.40 3.00 11.80 10.20 8.30 5.90 10.20 8.30 5.90 7.7024 363 7.00 5.30 3.50 14.10 12.20 9.90 7.00 12.20 9.90 7.00 9.1026 426 8.30 6.20 4.10 16.50 14.30 11.60 8.30 14.30 11.60 8.30 10.7028 494 9.60 7.20 4.80 19.10 16.60 13.50 9.60 16.60 13.50 9.60 12.4032 646 12.50 9.40 6.30 25.00 22.00 17.60 12.50 22.00 17.60 12.50 16.3036 817 15.80 11.90 7.90 32.00 27.00 22.00 15.80 27.00 22.00 15.80 21.0040 1010 19.60 14.70 9.80 39.00 34.00 28.00 19.60 34.00 28.00 19.60 25.0044 1220 24.00 17.70 11.80 47.00 41.00 33.00 24.00 41.00 33.00 24.00 31.0048 1450 28.00 21.00 14.00 56.00 49.00 40.00 28.00 49.00 40.00 28.00 37.0052 1710 33.00 25.00 16.60 66.00 57.00 47.00 33.00 57.00 47.00 33.00 43.0056 1980 38.00 29.00 19.20 77.00 66.00 54.00 38.00 66.00 54.00 38.00 50.0060 2270 44.00 33.00 22.00 88.00 76.00 62.00 44.00 76.00 62.00 44.00 57.00
04 -
SLI
NG
S
04 -
SLI
NG
S
1300 722 99998
Wire RopeWorking Load Limit (WLL) is the maximum load that may be applied to the sling, in tension as intended. • All slings are proof tested. • All slings are to be tagged with WLL.Note: For safe lifting practices refer to AS1666.2 - Wire Rope Slings - Care & Use.All slings must be visually inspected prior to Each lift. A thorough inspection of all slings in use must be made at regular intervals.Inspections must be conducted by a competent person who will inspect for the following: • Broken Wires (refer to Australian Standards for quantity breaks). • Corrosion (rust). • Kinks • Crushed or flattered sections. • Bird-caging and high stranding. • Damaged thimbles (where fitted). • Stretching or extended lay. • >33% wear on individual wires. • Adjacent broken wires. • Heat damage. • Other obvious damage.If in your opinion a sling has sufficient damage of any type that may result in an accident or injury don’t use it report it!Sling Features • Test certificate supplied as standard. • Individually stamped with WLL and Test Certificate number. • After swage dimension of ferrule measured and recorded. • Nominal soft eye Each end. • Galvanised or Black Wire Rope.Sling Options • Colour coded slings to suit your requirements. • Aluminium or steel tag. • Thimble eye on request.Custom Made SolutionsThe Bullivants range includes a range of custom designed and manufactured solutions in Wire Rope. Please contact your local Bullivants branch for details.All Bullivants wire rope slings are designed, manufactured, tested and tagged in accordance with AS1666, and are available in machined spliced aluminium, steel or hand spliced terminations.
WWW.BULLIVANTS.COM 99
04 -
SLI
NG
S
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132030 0.69 0.5 9 150 0.23
131001 0.69 1 9 200 0.38
132031 0.69 1.5 9 200 0.5
131012 0.69 2 9 200 0.63
132032 0.69 2.5 9 200 0.75
132033 0.69 3 9 200 0.88
132034 0.69 3.5 9 200 1.0
132035 0.69 4 9 200 1.1
132036 0.69 4.5 9 200 1.2
132037 0.69 5 9 200 1.3
132038 0.69 5.5 9 200 1.5
132039 0.69 6 9 200 1.6
132040 0.85 0.5 10 150 0.62
131004 0.85 1 10 240 0.83
132041 0.85 1.5 10 240 0.95
131005 0.85 1.75 10 240 1.01
132042 0.85 2 10 240 1.08
131006 0.85 2.5 10 240 1.2
131014 0.85 3 10 240 1.33
132043 0.85 3.5 10 250 1.45
132049 1.44 1 13 300 0.95
131007 1.44 1.25 13 300 1.08
132050 1.44 1.5 13 300 1.21
131015 1.44 1.75 13 300 1.34
131143 1.44 2 13 300 1.48
131016 1.44 2.5 13 300 1.74
131017 1.44 3 13 300 2.01
132051 1.44 3.5 13 300 2.27
132052 1.44 4 13 300 2.54
132053 1.44 4.5 13 300 2.8
131145 1.44 5 13 300 3.07
132054 1.44 5.5 13 300 3.33
131146 1.44 6 13 300 3.6
132055 2.2 1 16 250 1.41
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132056 2.2 1.5 16 300 1.9
131020 2.2 1.75 16 300 2.1
132057 2.2 2 16 300 2.31
131021 2.2 2.5 16 300 2.72
131022 2.2 3 16 300 3.12
132058 2.2 3.5 16 300 3.53
132059 2.2 4 16 300 3.94
132060 2.2 4.5 16 300 4.35
131161 2.2 5 16 300 4.75
132061 2.2 5.5 16 300 5.16
131162 2.2 6 16 300 5.57
131226 2.8 1 18 300 1.93
132063 2.8 1.5 18 300 2.44
131227 2.8 2 18 300 2.96
131167 2.8 2.5 18 300 3.47
132064 2.8 3 18 300 3.99
132065 2.8 3.5 18 300 4.5
132066 2.8 4 18 300 5.02
132067 2.8 4.5 18 300 5.53
132068 2.8 5 18 300 6.05
132069 2.8 5.5 18 300 6.56
132070 2.8 6 18 300 7.08
132071 3.4 1 20 300 2.4
132072 3.4 1.5 20 350 3.16
131179 3.4 2 20 350 3.8
131180 3.4 2.5 20 350 4.43
132073 3.4 3 20 350 5.07
132074 3.4 3.5 20 350 5.7
132075 3.4 4 20 350 6.34
132076 3.4 4.5 20 350 6.97
132077 3.4 5 20 350 7.61
132078 3.4 5.5 20 350 8.24
132079 3.4 6 20 350 8.8
Other sizes available.
6 x 24 Construction Wire Rope Sling - 6 x 24 Soft Eye: Unit of Measure - Each6x24 Construction, Fibre Core, Grade 1570, Aluminium Ferrule, Soft Eyes.
04 -
SLI
NG
S
1300 722 999100
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132178 1 0.5 9 150 0.39
131002 1 1 9 150 0.56
131013 1 1.5 9 150 0.73
131003 1 2 9 150 0.9
131130 1 2.5 9 150 1.07
131131 1 3 9 150 1.24
132179 1 3.5 9 150 1.41
132006 1 4 9 150 1.58
132180 1 4.5 9 150 1.75
131132 1 5 9 150 1.92
132182 1 5.5 9 150 2.09
132183 1 6 9 150 2.26
131147 2.1 1 13 200 1.23
131149 2.1 1.5 13 200 1.59
131018 2.1 2 13 200 1.94
131152 2.1 2.5 13 200 2.3
131019 2.1 3 13 200 2.65
132185 2.1 3.5 13 200 3
131155 2.1 4 13 200 3.36
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132186 2.1 4.5 13 200 3.71
131156 2.1 5 13 200 4.06
132188 2.1 5.5 13 200 4.42
132189 2.1 6 13 200 4.77
132007 3.1 1 16 250 2.1
132190 3.1 1.5 16 250 2.64
131163 3.1 2 16 250 3.17
132191 3.1 2.5 16 250 3.71
131164 3.1 3 16 250 4.24
132192 3.1 3.5 16 250 4.78
132008 3.1 4 16 250 5.31
132193 3.1 4.5 16 250 5.85
132194 3.1 5 16 250 6.38
132195 3.1 5.5 16 250 6.92
132196 3.1 6 16 250 7.45
132200 4 2.5 18 300 4.97
132203 4 4 18 300 6.99
132207 4 6 18 300 9.69
Other sizes available.
6x25 Construction Wire Rope - 6x25 Soft Eye AUSTRALOC: Unit of Measure - EachMade from 6 x 25 Construction, Grade 1770 Steel Core Wire Rope fitted with Australoc Ferrules with soft eyes.
WWW.BULLIVANTS.COM 101
04 -
SLI
NG
S
6 x 36 Construction Wire Rope Slings - 6x36 Soft Eye AUSTRALOC: Unit of Measure - Each
Made from 6 x 36 Construction, Grade 1770 Steel Core Wire Rope fitted with Australoc Ferrules with soft eyes.
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132208 5.9 1.5 22 300 5.41
132209 5.9 2 22 300 6.42
132210 5.9 2.5 22 300 7.43
132211 5.9 3 22 300 8.44
132212 5.9 3.5 22 300 9.45
132213 5.9 4 22 300 10.46
132214 5.9 4.5 22 300 11.47
132215 5.9 5 22 300 12.48
132216 5.9 5.5 22 300 13.49
132217 5.9 6 22 300 14.5
132218 7 1.5 24 400 7.28
132219 7 2 24 400 8.48
132220 7 2.5 24 400 9.69
132221 7 3 24 400 10.89
132222 7 3.5 24 400 12.1
132223 7 4 24 400 13.3
132224 7 4.5 24 400 14.51
132225 7 5 24 400 15.11
132226 7 5.5 24 400 16.92
132227 7 6 24 400 18.12
132228 9.6 1.5 28 400 9.86
132229 9.6 2 28 400 11.5
132230 9.6 2.5 28 400 13.14
132231 9.6 3 28 400 14.78
132232 9.6 3.5 28 400 16.42
132233 9.6 4 28 400 18.06
132234 9.6 4.5 28 400 19.7
132235 9.6 5 28 400 21.34
132236 9.6 5.5 28 400 22.98
132237 9.6 6 28 400 24.62
132238 12.5 1.5 32 500 13.86
132239 12.5 2 32 500 16
132240 12.5 2.5 32 500 18.14
132241 12.5 3 32 500 20.28
132242 12.5 3.5 32 500 22.42
132243 12.5 4 32 500 24.56
132244 12.5 4.5 32 500 26.7
132245 12.5 5 32 500 28.84
132246 12.5 5.5 32 500 30.98
132247 12.5 6 32 500 33.12
Other sizes available.
6 x 36 Construction Wire Rope Slings - 6x36 Soft Eye: Unit of Measure - Each
Made from 6 x 36 Construction, Grade 1770 Steel Core Wire Rope fitted with Aluminium Ferrules with soft eyes.
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132083 0.99 2 9 200 0.84
132092 1.22 0.5 10 200 0.42
132093 1.22 1 10 200 0.63
132094 1.22 1.5 10 200 0.84
132095 1.22 2 10 200 1.04
132096 1.22 2.5 10 200 1.25
132097 1.22 3 10 200 1.46
132098 1.22 3.5 10 200 1.67
132099 1.22 4 10 200 1.88
133325 1.22 4.5 10 200 2.09
133326 1.22 5 10 200 2.3
133327 1.22 5.5 10 200 2.51
133328 1.22 6 10 200 2.72
133329 2.1 1 13 300 1.23
133330 2.1 1.5 13 300 1.58
133331 2.1 2 13 300 1.94
133332 2.1 2.5 13 300 2.29
133333 2.1 3 13 300 2.64
133334 2.1 3.5 13 300 3
133335 2.1 4 13 300 3.35
04 -
SLI
NG
S
1300 722 999102
6 x 36 Construction Wire Rope Slings - 6x36 Soft Eye (continued): Unit of Measure - Each
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
133336 2.1 4.5 13 300 3.7
133337 2.1 5 13 300 4.06
133338 2.1 5.5 13 300 4.41
133339 2.1 6 13 300 4.77
133340 3.1 1 16 300 1.9
133341 3.1 1.5 16 300 2.44
133342 3.1 2 16 300 2.97
133343 3.1 2.5 16 300 3.51
133344 3.1 3 16 300 4.04
133345 3.1 3.5 16 300 4.58
132121 3.1 4 16 300 5.11
132122 3.1 4.5 16 300 5.65
132123 3.1 5 16 300 6.18
132124 3.1 5.5 16 300 6.72
132125 3.1 6 16 300 7.25
132126 4 1 18 300 2.44
132127 4 1.5 18 300 3.11
132128 4 2 18 300 3.79
132129 4 2.5 18 300 4.46
132130 4 3 18 300 5.14
132131 4 3.5 18 300 5.81
132132 4 4 18 300 6.49
132133 4 4.5 18 300 7.16
132134 4 5 18 300 7.84
132135 4 5.5 18 300 8.51
132136 4 6 18 300 9.19
132138 5.9 1.5 22 350 4.73
132139 5.9 2 22 300 5.74
132140 5.9 2.5 22 300 6.75
132141 5.9 3 22 300 7.76
132142 5.9 3.5 22 300 8.77
132143 5.9 4 22 300 9.78
132144 5.9 4.5 22 350 10.79
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
Soft
Eye
Size
(m
m)
App
rox.
W
eigh
t (kg
)
132145 5.9 5 22 350 11.8
132146 5.9 5.5 22 350 12.81
132147 5.9 6 22 350 13.82
132148 7 1.5 24 350 5.69
132149 7 2 24 350 6.9
132150 7 2.5 24 350 8.1
132151 7 3 24 350 9.31
132152 7 3.5 24 350 10.51
132153 7 4 24 350 11.72
132154 7 4.5 24 350 12.92
132155 7 5 24 350 14.13
132156 7 5.5 24 350 15.33
132157 7 6 24 350 16.54
132158 9.6 1.5 28 400 8.56
132159 9.6 2 28 400 10.2
132160 9.6 2.5 28 400 11.84
132161 9.6 3 28 400 13.48
132162 9.6 3.5 28 400 15.12
132163 9.6 4 28 400 16.76
132164 9.6 4.5 28 400 18.4
132165 9.6 5 28 400 20.04
132166 9.6 5.5 28 400 21.68
132167 9.6 6 28 400 23.32
132168 12.5 1.5 32 500 11.64
132169 12.5 2 32 500 13.78
132170 12.5 2.5 32 500 15.92
132171 12.5 3 32 500 18.06
132172 12.5 3.5 32 500 20.2
132173 12.5 4 32 500 22.34
132174 12.5 4.5 32 500 24.48
132175 12.5 5 32 500 26.62
132176 12.5 5.5 32 500 28.76
132177 12.5 6 32 500 30.9
Other sizes available.
WWW.BULLIVANTS.COM 103
04 -
SLI
NG
S
6x36 Construction Wire Rope Slings: Unit of Measure - EachMade with 6 x 36 Construction, Grade 1770, Steel Core Wire Rope fitted with Aluminium Ferrule and Thimble Eyes.
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
App
rox.
W
eigh
t (kg
)
132248 0.99 0.5 9 0.6
132253 0.99 3 9 2.1
132260 1.22 0.5 10 0.75
132261 1.22 1 10 1.1
132262 1.22 1.5 10 1.5
132263 1.22 2 10 1.9
132264 1.22 2.5 10 2.3
132265 1.22 3 10 2.7
132266 1.22 3.5 10 3.1
132267 1.22 4 10 3.5
132268 1.22 4.5 10 3.9
132269 1.22 5 10 4.3
132270 1.22 5.5 10 4.7
132271 1.22 6 10 5.1
132272 2.1 1 13 1.1
132273 2.1 1.5 13 1.7
132274 2.1 2 13 2.3
132275 2.1 2.5 13 2.9
132276 2.1 3 13 3.6
132277 2.1 3.5 13 4.2
132278 2.1 4 13 4.8
132279 2.1 4.5 13 5.4
132280 2.1 5 13 6
132281 2.1 5.5 13 6.6
132282 2.1 6 13 7.2
132283 3.1 1 16 1.4
132284 3.1 1.5 16 2
132285 3.1 2 16 2.6
132286 3.1 2.5 16 3.2
132287 3.1 3 16 3.8
132288 3.1 3.5 16 4
132289 3.1 4 16 5
OR
DER
CO
DE
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
App
rox.
W
eigh
t (kg
)
132290 3.1 4.5 16 5.6
132291 3.1 5 16 6.2
132292 3.1 5.5 16 6.8
132293 3.1 6 16 7.4
132294 4 1 18 2.75
132295 4 1.5 18 3.6
132296 4 2 18 4.4
132297 4 2.5 18 5.2
132298 4 3 18 6
132299 4 3.5 18 6.8
132300 4 4 18 7.6
132301 4 4.5 18 8.4
132302 4 5 18 9.2
132303 4 5.5 18 10
132304 4 6 18 10.8
132306 5.9 1.5 22 5.3
132307 5.9 2 22 6.4
132308 5.9 2.5 22 7.5
132309 5.9 3 22 8.6
132310 5.9 3.5 22 9.6
132311 5.9 4 22 10.7
132312 5.9 4.5 22 11.8
132313 5.9 5 22 12.9
132314 5.9 5.5 22 14
132315 5.9 6 22 15.1
132316 7 1.5 24 6.5
132317 7 2 24 7.2
132318 7 2.5 24 8.4
132319 7 3 24 9.6
132320 7 3.5 24 10.8
132321 7 4 24 12
132322 7 4.5 24 13.2
04 -
SLI
NG
S
1300 722 999104
6x36 Construction Wire Rope Slings (continued): Unit of Measure - Each
Ord
er C
ode
WLL
(ton
nes)
Leng
th (m
)
Rop
e D
ia.
(mm
)
App
rox.
W
eigh
t (kg
)
132323 7 5 24 14.4
132324 7 5.5 24 15.6
132325 7 6 24 16.8
132326 9.6 1.5 28 9.6
132327 9.6 2 28 11.2
132328 9.6 2.5 28 12.8
132329 9.6 3 28 14.4
132330 9.6 3.5 28 16
132331 9.6 4 28 17.6
132332 9.6 4.5 28 19.2
132333 9.6 5 28 20.8
132334 9.6 5.5 28 21.4
132335 9.6 6 28 23
132336 12.5 1.5 32 12.2
132337 12.5 2 32 14.3
132338 12.5 2.5 32 16.4
132339 12.5 3 32 18.6
132340 12.5 3.5 32 20.7
132341 12.5 4 32 22.8
132342 12.5 4.5 32 24
132343 12.5 5 32 25.2
132344 12.5 5.5 32 28.4
132345 12.5 6 32 30.7
Other sizes available.
Superflex Slings:Unit of Measure - Each
Superflex Slings are made from special plaited cable using hi-tensile 2070MPa galvanised plaited steel complete with soft eyes swaged with aluminium ferrules. Because of its plaited construction Superflex provides greater energy absorption properties than 6 stranded standard Wire Rope.
OR
DER
CO
DE
Des
crip
tion
Dia
. (m
m)
Eye
Size
(mm
)
Leng
th (m
)
SWL
(t)
131201 Three-0 12 220 1 1.4
133841 Three-0 12 220 1.5 1.4
131026 Three-0 12 220 2 1.4
131202 Three-0 12 220 3 1.4
131204 Three-0 12 220 4 1.4
131205 Three-5 14 250 1 1.8
132029 Three-5 14 250 1.5 1.8
131206 Three-5 14 250 2 1.8
131207 Three-5 14 250 3 1.8
131634 Four-0 16 290 1 2.4
132346 Four-0 16 290 1.5 2.4
131209 Four-0 16 290 2 2.4
132347 Four-0 16 290 3 2.4
132348 Four-0 16 290 4 2.4
132349 Four-5 18 290 1 3
131211 Four-5 18 290 1.5 3
131213 Four-5 18 290 2 3
131214 Four-5 18 290 3 3
132350 Four-5 18 290 4 3
132351 Five-0 20 360 1 4
131215 Five-0 20 360 1.5 4
132352 Five-0 20 360 2 4
132353 Five-0 20 360 3 4
131217 Five-0 20 360 4 4
132354 Six-5 26 470 1.5 6.5
132355 Six-5 26 470 2 6.5
131218 Six-5 26 470 3 6.5
132356 Six-5 26 470 4 6.5
Note: Superflex can be hand spliced upon requestOther sizes available.
WWW.BULLIVANTS.COM 105
04 -
SLI
NG
S
Superflex Slings with Steel FerrulesThis is our double swage technology applied to Superflex Slings - the steel ferrule system, following on from original conceptual work done by Raymond McLaren in the 1980’s.Our new system has the following advantages: • The ferrule is 18 percent smaller in diameter than equivalent aluminium ones (Talurit system) • The sling is entirely made of steel. Thus it can be used in maritime and caustic environments such as found in alumina smelters and similar • The tapered end neatly covers the wire ends, eliminating the main hazard in using slings, that is cutting hands on the sharp wire ends protruding from the ferrule • Four inspection holes provide the capability to see the wire ends from any side of the ferrule, as per the requirements of AS1666. • The ferrule is also chamfered at the throat end, thus providing a sling that is easier to use in tight places. • Stainless steel ferrules can be made to the same dimensions when required for special purposes. • The system is scalable, so providing the capability for the manufacture of larger Superflex Slings in future. • The Double Swage Process delivers EXTREME SAFETY as well as a high resultant strength - it is at least as secure as a hand splice, but the mechanical joint generates a higher UTS than a splice can. • It provides a true centreline pull, improving mechanical and aesthetic design resolution.Contact us for more information regarding the new steel ferrule system.Flat Woven Wire Slings • The basic manufacture of these types of slings involves 24 special wire ropes like the superflex strop or twice the amount of wires as that in the single part sling. • The ends (eyes) of the slings are like the superflex cable and opened during the flat section to give the 24 individual cords or wire ropes held apart by a cross weave. • The individual wire ropes would be to AS 3569 with the finished sling coming under the general requirements of “Wire Rope Slings - AS1666.1”. • These slings also are very flexible and have a wider section at the point of load like a websling has.
Flat Woven Steel Slings: Type 1 - Cradle Lift (standard) - Machine Woven Flat Cables
Nom. Size Of Sling =
Width (mm)
Woven Flat Cable SWL (tonnes)
24 Ply Warp, Fine Cords, 2 Ply Weft, Fine Cords Cradle Lift Included Angle At The Hook Proof Load
Flat Cable Thickness (mm)
Generic Cord Size (mm) Weight (kg/m) Woven Jacket
Nom. Dia.WLL In Single
Fall (kN) < 30° 60° 120° Straight Pull In Single Fall
50 5 2.0 0.4 32 10.2 1.9 1.7 1.0 20.464 7 2.5 0.6 38 16.0 3.0 2.7 1.6 32.076 8 3.0 1.0 52 23.8 4.5 4.0 2.3 47.688 10 3.5 1.3 62 31.6 6.0 5.3 3.1 63.2
100 11 4.0 1.6 70 42.5 9.1 7.1 4.1 85.0112 12 4.5 2.1 76 53.4 10 9.0 5.2 107125 14 5.0 2.7 102 71.4 13 12 7.0 143160 17 6.5 4.3 120 114 21 19 11 228200 20 8.0 6.9 150 170 32 28 17 340250 25 10.0 10.3 170 255 48 43 25 510
Flat Woven Steel Slings: Type 2 - Choker Lift
Woven Flat Cable Slings
Nom. Size Of Sling 24 Ply Warp, Fine Steel Cords and 2 Ply Weft, Fine Steel Cords SWL
(tonnes)SWL
(tonnes) Proof Load
Flat Cable Width (mm)
Flat Cable Thickness (mm)
Generic Cord Size (mm)
Weight (kg/m)
Woven Jacket Nom. Dia.
WLL In Single Fall (kN)
Choked on round load
Choked on square load
Straight Pull In Single Fall
50 5 2.0 0.4 32 10.2 0.7 0.5 20.464 7 2.5 0.6 38 16.0 1.2 0.8 32.076 8 3.0 1.0 52 23.8 1.7 1.1 47.688 10 3.5 1.3 62 31.6 2.3 1.5 63.2
100 11 4.0 1.6 70 42.5 3.1 2.0 85.0112 12 4.5 2.1 76 53.4 3.8 2.6 107125 14 5.0 2.7 102 71.4 5.1 3.4 143160 17 6.5 4.3 120 114 8.2 5.5 228200 20 8.0 6.9 150 170 12 8.2 340250 25 10.0 10.3 170 255 18 12 510