Post on 21-May-2020
www.TriCountyMetals.com
SL-LOK 1 1/2” and SS-Lok 1 3/4’ Installation Manual
.197”
.709” .394”.248”1.417” 1.496”
15.5”
®available in
14”1.620”
.120”
.715”
.344”
1.75”
Flat
Ribbed
Striated
Flat
Ribbed
Striated
Drip Edge 1Gable Trim 1 1 11 10'Sidewall 1 11 10'Endwall 1 11 10' 1Transition 1 1 11 10' 1Valley 2 20'Ridge Cap 2 22 20' 2
Z- Flash
ing
Eave Cleats
Panel Starte
rs
Rivets
Tack
y Tape
Titebond (tu
bes)
Hip
Hip Hip
Hip
Eave Eave
EaveEave
Eave
Eave Eave
Eave
Valley Valley
Valley Valley
Ridge
Ridge
Ridge
Gable End
Gable End
18’18’
13’ 4” 13’ 4”
19’ 6”19’ 6”
12’ 28’
12’ 3”
12’ 3”
49’ 9”
14’ 9” 14’ 9”
18’ 14’14’
8’ 6” 8’ 6”
24’ 7”
24’ 12’ 3”
14’ 4”
14’ 4”
18’
14’ 9”
14’ 9”
12’ 3”
26’
24’
Plumbing Stack
3” Diameter
Plumbing Stack
3” Diameter
Panel
Pancake Screws
EaveCleat
ExtendedEave Drip
Clip
Pancake Screw
Tacky Tape
Upper Panel Panel Starter
Tacky Tape
Upper Panel
Pancake Screw
Step2: To find “C” you will need to mark a string tied to“A” 4’ long and mark another string tied to “ B” that is 5’ long.
Place another mail at “C” where the two measurements come together. This will finish the 3-4-5 triangle
NOTE: If your lines is 3” from the gable at both “A” and ”C” the your house is square.
A B
C
RIDGE
EAVE
GA
BLE
GA
BLE
Step 1: Temporarily place a nail 3” from the eave and gable as shown here as “A”.
Measure 3’ parralel on the eave lineand place another nail shown here as “B”.
Panel Starter
Pancake Screw
Tacky Tape
Upper Panel
Transition FlashingRivet
Z-Flashing
Lower Panel
Tacky Tape
Pancake Screw
Set Back
Sidi
ng
Z-Flashing
Rivet
Tacky Tape
Pancake Screws
PanelRoof Deck
PancakeScrews
Rivet
Z-Flashing
Tacky Tape
Sidi
ng
Panel
Z-Flashing
Tacky Tape
Pancake Screw
Eave Cleat Panel
Pancake Screw
Z FlashingPanelPanel
Pancake Screw
Tacky TapeTacky Tape
RivetRivet
3”
6”
Color
110o
Color
6”
3”
110o
Name: _____________________________________________Phone: _________________________________Address: ________________________________________________________________________________________Email: _______________________________________________Job Name: __________________________________Pickup Location: ____________________________________Delivery Location: _________________________________________________________________________________
Panels
Ultra-LokGauge: _______________Color: _______________
PBR-LokGauge: _______________Color: _______________
TCM-Lok _____________Gauge: _______________Color: _______________
SL-Lok Gauge: _______________Color: _______________
MS-Lok ________Gauge: _______________Color: _______________
5V-LokGauge: _______________Color: _______________
Enter Panel Sizes
Quantity Feet Inches
TRIM QTYDrip EdgeRidge CapHip CapGable RakeValleySidewallEndwallTransition FlashingChimney FlashingPanel StarterZ-FlashingEave Cleat
Specialty Trim 1(attach drawing or draw in box)
FASTENERS Woodgrip Screw QTY
WoodZac QTY XG QTY
1”1 1/2”2”2 1/2"PancakesTek ScrewsLap ScrewsFASTENERS QTYStainless RivetsPainted RivetsPurlin Screws #9 x 3”Collated NailsStick NailsTrim Nails 1-1/4”Felt Nails 1 1/4”Stinger Nails
Woodgrip
INSULATION/VENTILATION QTYTCM Radiant Barrier
TCM Radiant Tape Flex-o-Vent
Profile Vent
Vent Clips
SEALANTS QTYPeel and SealTitebondExpanding FoamTacky TapeInside ClosuresOutside Closures
UNDERLAYMENTS/PURLINS QTYUltra HT Wind & Water Underlayment Synthetic HT 1 x 4 x 12 SYP
FLASHINGS QTY
StandardQTY
High TempRoof Boots#3: 1/4” - 5” Color:
#5: 4 1/4” - 7 1/2”#7: 6”-11”#9: 9” - 19”Electric Pipe BootTouch-Up Paint Spray StyleGooseneck Vents
Specialty Trim 2(attach drawing or draw in box)
Notes:
Quote Request OrderPlease select:
SS-LokGauge: _______________Color: _______________
Trenton301 SE 16th St
Trenton, FL 32693Office # (352) 463-8400
Fax # (352) 463-0785
Live Oak10142 90th Trail
Live Oak, FL 32060 Office # (386) 330-0101
Fax # (386) 330-0167
Ocala3021 Northwest Blitchton Rd.
Ocala, FL 34475Office # (352) 622-5500
Fax # (352) 622-5502
Tallahassee3708 Northwest Passage
Tallahassee, FL 32303Office # (850) 574-4001
Fax # (850) 574-4003
Brooksville 922 Ponce De Leon Blvd
Brooksville, FL 34601 Office # 352-587-8120
Fax # 352-587-8122
DeLand1721 Langley Ave., DeLand, FL 32724
Office# (386) 738-2579Fax # (386) 734-5044