Post on 06-Feb-2018
F.u.G. Elektronik GmbH - Florianstr. 2 - D 83024 Rosenheim - GERMANY
36
High voltage power supplies
Design examples
FunctionThe rectified line voltage maintainsa square wave generator of constantfrequency, whose AC voltage istransformed, rectified and filtered,producing the output voltage. For theregulation the square wave voltageis pulse width modulated.
Features
• Light-weight
• Efficiency appr. 90%
• In units from 12,5 kV on, theHV-components are moulded in(removable) silicon resin.
• Unlimited operation with ratedcurrent in a short-circuitcondition
• Unlimited operation with nominalpower
• Voltage and current regulationwith automatic, sharp transition
• Control mode indicated by LED
• Voltage and current setting with10-turn potentiometers withprecision scale; the adjustingknob can be locked
• 4½digits DVM for voltage andcurrent
• Suitable for capacitive loads
Design• Depending on voltage and
nominal power ½19" or 19”table-top case
• 19" rackadapters are availableas accessories
Outputs• At all units are the outputs on the
rear.
• Mating HV-connectors areincluded.
Technical Data• Mains connection:
230 V ±10% 47 Hz to 63 Hz
• Ambient temperature:0°C to +40°C
• Output polarity:Positive or negative, the polarityhas to be indicated with theorder
• Output isolation:The "0V" terminal is connectedto earth, but may bedisconnected on need. The "0V"terminal than is earthy and mayfloat with respect to earth up to±300 V.
Further high-voltage powersupplies see page 38
HCL 35-2000020000 V / 1,5 mA
HCL 35-3500035000 V / 1 mA
F.u.G. Elektronik GmbH - Florianstr. 2 - D 83024 Rosenheim - GERMANY
37
High voltage power suppliesSeries HCL from 3500 V to 35000 V / 14 W to 350 W
All further data apply for voltage andcurrent regulation and refer to therated value, if not otherwise stated.
• Setting range:from appr. 0,1% to 100%
• Setting resolution:±1 x 10-4
• Reproducibility:1 x 10-3
• Residual ripple:<1 x 10-4pptyp. 5 x 10-5pp
Current control:<10 ms for load changescausing anoutput change ofless than 10% of the ratedvoltage
• Setting time at nominal load:<100 ms to 500 ms, dependingon type, for output voltagechanges from 10% to 90% or90% to 10%.
• Discharging time constant foroutput without load:appr. 1 to 10 sec.
(depending on type).
Options
• Analog programming
• Analog programming, floating
• Computer interfaceIEEE 488 and RS 232
• Polarity reversal switch, incombination with the analogprogramming or computerinterface remote controlled
• Lower ripple
• Higher stability
• Deviation:for ±10% mains voltagevariation: < ± 1 x 10-5
for no load / full load: <±2 x 10-4
over 8 hours under constantconditions: <±1 x 10-4
within the temperature range:<±1,5 x 10-4 / K
• Recovery time:
Voltage control:<1 ms for load changes from10% to 100%or from 100% to 10%.
epyT epyT epyT epyT epyT egatloV egatloV egatloV egatloV egatloV tnerruC tnerruC tnerruC tnerruC tnerruC htdiW htdiW htdiW htdiW htdiW thgieH thgieH thgieH thgieH thgieH htpeD htpeD htpeD htpeD htpeD thgieW thgieW thgieW thgieW thgieW
LCH -41 0053 -0 0053 V -0 4 Am 222/"91½ mm 98/UH2 mm 054 mm 4 gk
LCH -53 0053 -0 0053 V -0 01 Am 222/"91½ mm 98/UH2 mm 054 mm 4 gk
LCH -041 0053 -0 0053 V -0 04 Am 222/"91½ mm 98/UH2 mm 054 mm 4 gk
LCH -053 0053 -0 0053 V -0 001 Am 344/"91 mm 98/UH2 mm 054 mm 7 gk
LCH -41 0056 -0 0056 V -0 2 Am 222/"91½ mm 98/UH2 mm 054 mm 4 gk
LCH -53 0056 -0 0056 V -0 5 Am 222/"91½ mm 98/UH2 mm 054 mm 4 gk
LCH -041 0056 -0 0056 V -0 02 Am 222/"91½ mm 98/UH2 mm 054 mm 4 gk
LCH -053 0056 -0 0056 V -0 05 Am 344/"91 mm 98/UH2 mm 054 mm 7 gk
LCH -41 00521 -0 00521 V -0 1 Am 222/"91½ mm 98/UH2 mm 054 mm 3,4 gk
LCH -53 00521 -0 00521 V -0 5,2 Am 222/"91½ mm 98/UH2 mm 054 mm 3,4 gk
LCH -041 00521 -0 00521 V -0 01 Am 222/"91½ mm 98/UH2 mm 054 mm 3,4 gk
LCH -053 00521 -0 00521 V -0 52 Am 344/"91 mm 98/UH2 mm 054 mm 5,7 gk
LCH -41 00002 -0 00002 V -0 6,0 Am 222/"91½ mm 98/UH2 mm 054 mm 3,4 gk
LCH -53 00002 -0 00002 V -0 5,1 Am 222/"91½ mm 98/UH2 mm 054 mm 3,4 gk
LCH -041 00002 -0 00002 V -0 6 Am 222/"91½ mm 98/UH2 mm 054 mm 3,4 gk
LCH -053 00002 -0 00002 V -0 51 Am 344/"91 mm 98/UH2 mm 054 mm 5,7 gk
LCH -53 00053 -0 00053 V -0 1 Am 344/"91 mm 98/UH2 mm 054 mm 7,7 gk
LCH -041 00053 -0 00053 V -0 4 Am 344/"91 mm 98/UH2 mm 054 mm 7,7 gk
LCH -053 00053 -0 00053 V -0 01 Am 344/"91 mm 98/UH2 mm 054 mm 7,7 gk
dedulcnierasrotcennoc-VHgnitaM
.redroehthtiwytiraloptuptuoehtetacidniesaelp,hctiwslasreverytiraloptuohtiwsredroroF
75egapees,85GRelbacdednemmocer,VHSepytVk5,6dnaVk5,3roF
",066031elbacdednemmocer,12SHepytVk02dnaVk5,21roF
",11GRelbacdednemmocer,0343FepytVk53roF
F.u.G. Elektronik GmbH - Florianstr. 2 - D 83024 Rosenheim - GERMANY
38
High voltage power supplies
Design examples
HCN 700 - 2000020000 V / 30 mA
HCN 140 - 65006500 V / 20 mA
HCN 14 - 1250012500 V / 1 mA
F.u.G. Elektronik GmbH - Florianstr. 2 - D 83024 Rosenheim - GERMANY
39
High voltage power suppliesSeries HCN from 3500 V to 150 kV / 14 W to 4200 W
FunctionThe rectified line voltage maintainsa square wave generator of constantfrequency, whose AC voltage istransformed, rectified and filtered,producing the output voltage. For theregulation the square wave voltageis pulse width modulated.
Features
• Compact size
• Efficiency appr. 90%
• In units from 6,5 kV ; 12,5 kV or20 kV on (depending on power)the HV-components aremoulded in (removable) siliconresin.
• Unlimited operation with ratedcurrent in a short-circuitcondition
• Unlimited operation with nominalpower
• Voltage and current regulationwith automatic, sharp transition
• Control mode indicated by LED
• Voltage and current setting with10-turn potentiometers withprecision scale; the adjustingknob can be locked
• 3½ digit DVM for voltage andcurrent (at ½19" switch-selected)
• Standard starting currentlimitation for units from 700 Wnominal power on
• Suitable for capacitive loads
Design• Up to 35 W, 20 kV nominal
power - ½19" table-top case,from 140 W nominal power on,19" table-top case.
• 19" rack-adapters see page 56
Outputs• For units up to 35 kV nominal
voltage, the output is located onthe front panel, from 65 kVnominal voltage on the rear
• Mating HV-connectors areincluded.From 65 kV on, deliverycomplete with 3 m cable
Technical Data• Mains connection:
up to 1400 W nominal power230 V ±10% 47 Hz to 63 Hz;
from 2800 W nominal power on400 V ±10% 47 Hz to 63 Hzthree-phase
• Ambient temperature:0°C to +40°C
• Output polarity:positive or negative, the polarityhas to be indicated with theorder
As an option units up to 65 kVare available with polarityreversal switch
• Output isolation:The "0V" terminal is connectedto earth, but may bedisconnected on need. The "0V"terminal than is earthy and mayfloat with respect to earth up to±300 V.
All further data apply for voltage andcurrent regulation and refer to therated value, if not otherwise stated.
• Setting range:from appr. 0,1% to 100%
• Setting resolution:±1 x 10-4
• Reproducibility:±1 x 10-3
• Residual ripple:<1 x 10-4pptyp. 5 x 10-5pp
• Deviation:for ±10% mains voltagevariation:< ± 1 x 10-5
for no load / full load:<±2 x 10-4
over 8 hours under constantconditions:<±1 x 10-4
within the temperature range:<±1,5 x 10-4 / K
• Recovery time:
Voltage control:<1 ms for load changes from10% to 100%or from 100% to 10%.
Current control:<10 ms for load changescausing anoutput change ofless than 10% of the ratedvoltage
• Setting time at nominal load:<100 ms to 500 ms, dependingon type, for output voltagechanges from 10% to 90% or90% to 10%.
• Discharging time constant foroutput without load:appr. 1 to 10 sec. (depending ontype).
Options• Analog programming
• Analog programming, floating
• Computer interfaceIEEE 488 and RS 232
• DVM with higher resolution
• Polarity reversal switch, up to65 kV.
• Lower ripple
• Higher stability
For more information on our optionsplease see pages 60 and 61.Also, some options may containchanges of the description of theunit.
Types see next pages
We also supply units with higher voltages up to 200 kV with polarity reversal !
High voltage power supplies with higher power andhigher voltage ratings please see from page 42 on, series HCH.
F.u.G. Elektronik GmbH - Florianstr. 2 - D 83024 Rosenheim - GERMANY
40
High voltage power suppliesSeries HCN from 3,5 kV to 20 kV / 14 W to 4200 W
epyT epyT epyT epyT epyT egatloV egatloV egatloV egatloV egatloV tnerruC tnerruC tnerruC tnerruC tnerruC htdiW htdiW htdiW htdiW htdiW thgieH thgieH thgieH thgieH thgieH htpeD htpeD htpeD htpeD htpeD thgieW thgieW thgieW thgieW thgieW
NCH -41 0053 -0 0053 V -0 4 Am 222/"91½ mm 331/UH3 mm 053 mm 3 gk
NCH -53 0053 -0 0053 V -0 01 Am 222/"91½ mm 331/UH3 mm 053 mm 4 gk
NCH -041 0053 -0 0053 V -0 04 Am 344/"91 mm 331/UH3 mm 053 mm 6 gk
NCH -053 0053 -0 0053 V -0 001 Am 344/"91 mm 331/UH3 mm 053 mm 7 gk
NCH -007 0053 -0 0053 V -0 002 Am 344/"91 mm 331/UH3 mm 055 mm 11 gk
NCH -0041 0053 -0 0053 V -0 004 Am 344/"91 mm 771/UH4 mm 055 mm 12 gk
NCH -0082 0053 )3 -0 0053 V -0 008 Am 344/"91 mm 553/UH8 mm 055 mm 53 gk
NCH -0024 0053 )3 -0 0053 V -0 2,1 A 344/"91 mm 553/UH8 mm 056 mm 05 gk
NCH -41 0056 -0 0056 V -0 2 Am 222/"91½ mm 331/UH3 mm 053 mm 4 gk
NCH -53 0056 -0 0056 V -0 5 Am 222/"91½ mm 331/UH3 mm 053 mm 5 gk
NCH -041 0056 -0 0056 V -0 02 Am 344/"91 mm 331/UH3 mm 053 mm 6 gk
NCH -053 0056 -0 0056 V -0 05 Am 344/"91 mm 331/UH3 mm 053 mm 7 gk
NCH -007 0056 -0 0056 V -0 001 Am 344/"91 mm 331/UH3 mm 055 mm 11 gk
NCH -0041 0056 -0 0056 V -0 002 Am 344/"91 mm 771/UH4 mm 055 mm 12 gk
NCH -0082 0056 )3 -0 0056 V -0 004 Am 344/"91 mm 553/UH8 mm 055 mm 53 gk
NCH -0024 0056 )3 -0 0056 V -0 006 Am 344/"91 mm 553/UH8 mm 056 mm 05 gk
NCH -41 00521 -0 00521 V -0 1 Am 222/"91½ mm 331/UH3 mm 053 mm 4 gk
NCH -53 00521 -0 00521 V -0 5,2 Am 222/"91½ mm 331/UH3 mm 053 mm 5 gk
NCH -041 00521 -0 00521 V -0 01 Am 344/"91 mm 331/UH3 mm 053 mm 21 gk
NCH -053 00521 -0 00521 V -0 52 Am 344/"91 mm 331/UH3 mm 053 mm 41 gk
NCH -007 00521 -0 00521 V -0 05 Am 344/"91 mm 331/UH3 mm 055 mm 61 gk
NCH -0041 00521 -0 00521 V -0 001 Am 344/"91 mm 771/UH4 mm 055 mm 32 gk
NCH -0082 00521 )3 -0 00521 V -0 002 Am 344/"91 mm 553/UH8 mm 055 mm 53 gk
NCH -0024 00521 )3 -0 00521 V -0 003 Am 344/"91 mm 993/UH9 mm 056 mm 05 gk
NCH -41 00002 -0 00002 V -0 6,0 Am 222/"91½ mm 331/UH3 mm 053 mm 4 gk
NCH -53 00002 -0 00002 V -0 5,1 Am 222/"91½ mm 331/UH3 mm 053 mm 5 gk
NCH -041 00002 -0 00002 V -0 6 Am 344/"91 mm 331/UH3 mm 053 mm 31 gk
NCH -053 00002 -0 00002 V -0 51 Am 344/"91 mm 331/UH3 mm 053 mm 41 gk
NCH -007 00002 -0 00002 V -0 03 Am 344/"91 mm 331/UH3 mm 055 mm 91 gk
NCH -0041 00002 -0 00002 V -0 06 Am 344/"91 mm 771/UH4 mm 055 mm 52 gk
NCH -0082 00002 )3 -0 00002 V -0 021 Am 344/"91 mm 553/UH8 mm 055 mm 05 gk
NCH -0024 00002 )3 -0 00002 V -0 002 Am 344/"91 mm 993/UH9 mm 056 mm 06 gk
esahp-eerhtnoitcennocsniaM)3
tseuqernoelbaliavaerasgnitaregatlovrorewoprehtO
F.u.G. Elektronik GmbH - Florianstr. 2 - D 83024 Rosenheim - GERMANY
41
High voltage power suppliesSeries HCN from 35 kV to 150 kV / 35 W to 4200 W
For units with higher voltage and higher power see series HCH page 43.
epyT epyT epyT epyT epyT egatloV egatloV egatloV egatloV egatloV tnerruC tnerruC tnerruC tnerruC tnerruC htdiW htdiW htdiW htdiW htdiW thgieH thgieH thgieH thgieH thgieH htpeD htpeD htpeD htpeD htpeD thgieW thgieW thgieW thgieW thgieW
NCH -53 00053 -0 00053 V -0 1 Am 344/"91 mm 331/UH3 mm 053 mm 51 gk
NCH -041 00053 -0 00053 V -0 4 Am 344/"91 mm 331/UH3 mm 054 mm 71 gk
NCH -053 00053 -0 00053 V -0 01 Am 344/"91 mm 771/UH4 mm 054 mm 22 gk
NCH -007 00053 -0 00053 V -0 02 Am 344/"91 mm 662/UH6 mm 054 mm 03 gk
NCH -0041 00053 -0 00053 V -0 04 Am 344/"91 mm 013/UH7 mm 055 mm 54 gk
NCH -0082 00053 )3 -0 00053 V -0 08 Am 344/"91 mm 993/UH9 mm 056 mm 06 gk
NCH -0024 00053 )3 -0 00053 V -0 021 Am 344/"91 mm 784/UH11 mm 056 mm 09 gk
NCH -53 00056 -0 00056 V -0 5,0 Am 344/"91 mm 122/UH3* mm 053** mm 71 gk
NCH -041 00056 -0 00056 V -0 2 Am 344/"91 mm 122/UH5* mm 054** mm 05 gk
NCH -053 00056 -0 00056 V -0 5 Am 344/"91 mm 122/UH5* mm 054** mm 55 gk
NCH -007 00056 -0 00056 V -0 01 Am 344/"91 mm 553/UH8* mm 055 mm 56 gk
NCH -0041 00056 -0 00056 V -0 02 Am 344/"91 mm 993/UH9* mm 055 mm 07 gk
NCH -0082 00056 )3 -0 00056 V -0 04 Am 344/"91 mm 993/UH9* mm 056 mm 08 gk
NCH -041 000001 -0 000001 V -0 1 Am 344/"91 mm 122/UH5 mm 055 mm 06 gk
NCH -053 000001 -0 000001 V -0 3 Am 344/"91 mm 553/UH8 mm 055 mm 86 gk
NCH -007 000001 -0 000001 V -0 6 Am 344/"91 mm 553/UH8 mm 055 mm 37 gk
NCH -0041 000001 -0 000001 V -0 21 Am 344/"91 mm 784/UH11 mm 057 mm 09 gk
NCH -041 000051 -0 000051 V -0 5,0 Am 344/"91 mm 444/UH01 mm 057 mm 011 gk
NCH -053 000051 -0 000051 V -0 2 Am 344/"91 mm 444/UH01 mm 057 mm 031 gk
NCH -007 000051 -0 000051 V -0 4 Am 344/"91 mm 444/UH01 mm 057 mm 041 gk
esahp-eerhtnoitcennocsniaM)3
.ytiraloptuptuoehtetacidniesaelp,hctiwslasreverytiraloptuohtiwstinuroF.hctiwslasreverytiralophtiwelbaliavaeraVk56otpustinullA
.rehgihmm09/UH2erastinuesehthctiwslasreverytiralopnoitpoehthtiW)*
.peedmm055erastinuesehthctiwslasreverytiralopnoitpoehthtiW)**